ENGINE PERFORMANCE – Ford Escape Hybrid 2007 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.3L

2.3L, Engine Performance Wiring Diagram, Except Hybrid (1 of 5) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Except Hybrid (1 of 5) for Ford Escape Hybrid 2007:

• (beneath left rear of vehicle) evap canister vent control solenoid
• (lower left side of dash) data link connector (dlc)
• (rear of engine compt, on firewall) g109
• Accr
• Accs
• Acpsw
• Air conditioning system
• Anti-theft system
• Boo
• Bvrefc
• C175b
• C2280c
• Can+
• Can-
• Canvnt
• Case grd
• Cfc
• Compt)
• Cooling fans system
• Feps
• Fpm
• Fppwr
• Fprtn
• Ftpt
• Fuel gauge sensor
• Fuel pump
• Fuel pump driver module (under center of vehicle)
• Fuel sndr rtn
• Fuel sndr signal
• Fuel tank unit (beneath left rear of vehicle, in fuel tank)
• Fuse 5a
• G101 (rear of engine compt, on firewall)
• G405 (under rear center of vehicle)
• Gnd
• Hfc
• Hot at all times
• Iat
• Ifs input
• Inertia fuel shutoff (ifs) switch (base of right door pillar, near kick panel)
• Instrument cluster
• Kapwr
• Lfc
• Mafrtn
• Mafs
• Nca
• Powertrain control module (pcm) (rear center of firewall)
• Psps
• Pwr grd
• Red
• Red/pnk
• Rx data
• S104
• S410
• Shift interlock system
• Sigrtnc
• Smart junction box (sjb) (below center of dash)
• Starting/charging system
• Strt-out
• Tcs
• Tx out
• Vmv-cc/evmv
• Vpwr
• Vrsrtn

2.3L, Engine Performance Wiring Diagram, Except Hybrid (2 of 5) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Except Hybrid (2 of 5) for Ford Escape Hybrid 2007:

• (left side of transmission) (a/t) output shaft speed (oss) sensor
• (on bracket, above brake pedal) brake pedal position switch
• (rear of engine compt) evaporative emission (evap) canister purge valve
• (top of engine) s105
• (top of engine) s155
• C2280c
• Camshaft position sensor (right front of cylinder head)
• Cruise control system
• Cylinder head temperature sensor (top of engine, on cylinder head)
• Fuel rail pressure/ temperature sensor (top of engine)
• Fuel tank pressure transducer sensor (beneath left rear of vehicle)
• Fuse 15a
• G101 (rear of engine compt, on firewall)
• Hot at all times
• Manifold absolute pressure (map) sensor (left rear of engine, near intake manifold)
• Mass air flow (maf) sensor (near rear of cylinder head, in air intake duct)
• Of engine compt)
• Power steering pressure switch (left front of of engine)
• Red/pnk
• S104
• S109 (top of engine)
• Smart junction box (sjb) (below center of dash)
• Throttle position sensor (tps) (on throttle body)

2.3L, Engine Performance Wiring Diagram, Except Hybrid (3 of 5) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Except Hybrid (3 of 5) for Ford Escape Hybrid 2007:

• (on top of engine) s154
• (on top of transmission) transmission range (tr) sensor
• (rear of engine) s150
• (top of transmission) transmission hardware unit
• 1868 (or 199)
• 3-2t/ccs solenoid
• A/t
• C175t
• Cruise control system
• Electronic pressure control solenoid
• Epc
• Ho2s-12
• Htr-12
• M/t
• Oss
• Powertrain control module (pcm) (rear center of firewall)
• Red/pnk
• Shift solenoid a
• Shift solenoid b
• Sigrtnt
• Ss3l
• Ssa
• Ssb
• Tcch
• Tft
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Tss
• Vehicle speed sensor (vss) (m/t) (right side of transmission)
• Vss

2.3L, Engine Performance Wiring Diagram, Except Hybrid (4 of 5) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Except Hybrid (4 of 5) for Ford Escape Hybrid 2007:

• (top of engine) s103
• (top of engine) s107
• (under battery junction box)
• A/c clutch relay
• Battery junction box (bjb) (left front corner of engine compt)
• C2280b
• Egr stepper motor (rear of engine)
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 2a
• Fuse 30a
• Fuse 5a
• G300 (under driver's seat)
• Heated oxygen sensor (ho2s) 11 (rear center of engine compt)
• Heated oxygen sensor (ho2s) 12 (near right front of engine, in exhaust)
• Hot at all times
• Hot in run or start
• Idle air control (iac) valve (top of engine, near throttle body)
• Intake manifold tuning (imt) valve (near top front of engine)
• Pcm power diode
• Pcm power relay
• Red
• Red/pnk
• S111 (rear of engine)
• S128
• S129
• S332
• Smart junction box (sjb) (below center of dash)
• Tan/red
• Turbine shaft speed (tss) sensor (a/t) (left side of transmission)

2.3L, Engine Performance Wiring Diagram, Except Hybrid (5 of 5) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Except Hybrid (5 of 5) for Ford Escape Hybrid 2007:

• (lower right front of engine) crankshaft position sensor
• (on top of engine) s151
• (on top of engine) s152
• (top of engine)
• Altcom
• Altmon
• Bvrefe
• C175e
• Cda
• Cdb
• Cdc
• Cdd
• Cht
• Cid1
• Ckp+
• Ckp-
• Coil on plug 1
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Eerg1
• Eerg2
• Eerg3
• Eerg4
• Frt
• Fuel injector
• G101 (rear of engine compt, on firewall)
• Ho2s-11
• Htr-11
• Iac
• Ignition trans- former capacitor 1 (rear of cylinder head)
• Inj1
• Inj2
• Inj3
• Inj4
• Ips
• Knock sensor (front of engine, below cylinder head)
• Ks1+
• Ks1-
• Map
• Nca
• Powertrain control module (pcm) (rear center of firewall)
• Red
• Red/pnk
• S104
• Sigrtne
• Starting/ charging system
• Tan
• Tan/red
• Tps
• Vis

2.3L, Engine Performance Wiring Diagram, Hybrid (1 of 6) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Hybrid (1 of 6) for Ford Escape Hybrid 2007:

• (beneath left rear of vehicle) evap canister vent control solenoid
• (center of left rocker panel) s316
• (left rear of engine compt, on bulkhead) g107
• (top of fuel tank) fuel tank isolation valve
• Acc
• Accr
• Accs
• Acet
• Acfds
• Acpsw
• Acrsw
• Air conditioning system
• Anti-theft system
• App1
• App1bvref
• App1rtn
• App2
• App2bvref
• App2rtn
• App3
• Battery junction box (bjb) (left rear of engine compt)
• Boo
• Bpo
• Bps
• Bvref
• C175b
• Canvnt
• Cgnd
• Computer data lines system
• Cooling fans system
• Cruise control system
• Evaporative emission (evap) canister purge valve (rear of engine compt)
• Evmv
• Fc1
• Fc2
• Fc3
• Feps
• Fpm
• Fppwr
• Fprtn
• Ftpt
• Ftv
• Fuel gauge sensor
• Fuel pump
• Fuel pump driver module (under left center of vehicle)
• Fuel sndr
• Fuel tank unit (beneath left rear of vehicle, in fuel tank)
• Fuse 30a
• Fuse 5a
• Fuse 7.5a
• G106 (left rear of engine compt, on bulkhead)
• G405
• Gnd
• Hot at all times
• Hs can +
• Hs can -
• Iat
• Ifs input
• Ignition switch
• Inertia fuel shutoff (ifs) switch (right kick panel)
• Instrument cluster
• Maf
• Mafrtn
• Mfp
• Nca
• Off
• Pat r
• Pat t
• Powertrain control module (pcm) (rear center of firewall)
• Psr
• Rdi
• Red
• Red/pnk
• Rtn
• Run
• S123 (left side of engine compartment, near rear air box)
• S130
• S136 (center rear of engine compt, near powertrain control module (pcm))
• S137
• S406 (left "d" pillar)
• S410
• Sccs
• Sccsrtn
• Sigrtn
• Start
• To high voltage cutoff switch (diagram 6 of 6)
• To traction battery control module (diagram 6 of 6)
• Vbatt
• Vpwr

2.3L, Engine Performance Wiring Diagram, Hybrid (2 of 6) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Hybrid (2 of 6) for Ford Escape Hybrid 2007:

• (front of engine compt) s102
• (in breakout to battery junction box (bjb)) s116
• (left side of engine compt, above wheelwell) s144
• (near heated oxygen sensor (ho2s) 11)
• (under left side of dash) accelerator pedal position sensor
• A/c evaporative temperature sensor (behind right side of dash)
• C1458a
• C1458b
• C1458c
• C1458d
• C1458e
• Camshaft position sensor (on rear of cylinder head)
• Computer data lines system
• Cooling fans system
• Cto
• Cylinder head temperature sensor (top of engine)
• Dc/dc interlock +
• Dc/dc interlock -
• Dc/dc +
• Dc/dc -
• Ect
• Fuel rail pressure/ temperature sensor (top of engine)
• Fuel tank pressure transducer sensor (beneath left rear of vehicle)
• G106 (left rear of engine compt, on bulkhead)
• G108 (left rear of engine compt, near transaxle control module)
• Gnd
• Gsdn
• Hs can +
• Hs can -
• Hv +
• Hv -
• Interlock +
• Interlock -
• Isdn1
• Isdn2
• Manifold absolute pressure (map) sensor (left rear of engine, near intake manifold)
• Mass air flow/intake air temperature (maf/iat) sensor) (left side of engine compt, in air intake duct)
• Msdn
• Red
• Red/pnk
• S103
• S137
• S142
• Sig rtn
• Tgac
• Tmac
• To traction battery control module (diagram 6 of 6)
• Transaxle control module (above transaxle)
• Vbatt
• Vpwr

2.3L, Engine Performance Wiring Diagram, Hybrid (3 of 6) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Hybrid (3 of 6) for Ford Escape Hybrid 2007:

• (behind left headlight assembly)
• (on top of transmission) transmission range (tr) sensor
• (right side of engine compt) dc/dc converter module
• Aclpcs
• Acrdv
• Air conditioning system
• Battery
• C1457a
• C1457b
• C1457c
• C1457d
• C175t
• C2280b
• C2280d
• Cto
• Dc/int+
• Dc/int-
• Dce
• Dcf
• Dc_enable
• Dc_fault
• Fuse 2a
• Fuse 5a
• G100 (near battery)
• G101 (near battery)
• G105 (right front of engine compt)
• Gnd
• Gsdn
• High voltage wires
• Hot in run or start
• Hvdc+
• Hvdc-
• Mecp
• Mect
• Msdn
• Pcm power diode
• Power distri- bution system
• Powertrain control module (pcm) (rear center of firewall)
• Red
• Red/pnk
• S115
• S127
• S128
• S129
• S251
• Smart junction box (sjb) (below center of dash)
• Tgac
• Tmac
• Tr a1
• Tr a1bvref
• Tr a1rtn
• Tr a2
• Tr a2bvref
• Tr a2rtn
• Tr a3
• Vbatt

2.3L, Engine Performance Wiring Diagram, Hybrid (4 of 6) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Hybrid (4 of 6) for Ford Escape Hybrid 2007:

• (left side of engine compt, near strut tower)
• Air conditioning system
• Battery junction box (bjb) (left rear of engine compt)
• Egr stepper motor (rear of engine)
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse 40a
• Fuse 5a
• G103 (right front of engine compt)
• Heated oxygen sensor (ho2s) 11 (right front of engine)
• Heated oxygen sensor (ho2s) 13 (right front of engine)
• Hot at all times
• Injector relay
• Pcm power relay
• Power sustain relay
• Red
• Red/pnk
• S105 (right front side of engine)
• S106 (left front corner of engine compt)
• S110
• S111
• S112
• S151
• Tan/red

2.3L, Engine Performance Wiring Diagram, Hybrid (5 of 6) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Hybrid (5 of 6) for Ford Escape Hybrid 2007:

• (top left side of engine) s107
• (top of engine)
• Bvrefe
• C175e
• Cd1a
• Cd2d
• Cd3b
• Cd4c
• Cht
• Ckpn
• Ckpp
• Cmp1
• Coil on plug 1
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Crankshaft position sensor (lower right front of engine)
• Egrmc1
• Egrmc2
• Egrmc3
• Egrmc4
• Electronic throttle control (etc) motor (left rear of engine)
• Frp
• Frt
• Fuel injector
• G106 (left rear of engine compt, on bulkhead)
• Ho2s11
• Ho2s13
• Htr11
• Htr13
• Ignition trans- former capacitor 1 (rear of cylinder head)
• Inj1a
• Inj2d
• Inj3b
• Inj4c
• Knock sensor
• Ks1n
• Ks1p
• Map
• Nca
• Powertrain control module (pcm) (rear center of firewall)
• Red/pnk
• S100
• S104 (near powertrain control module)
• Sigrtne
• Tacm +
• Tacm -
• Tan
• Tan/red
• Tp1 ns
• Tp2 ps
• Tpbvref
• Tprtn

2.3L, Engine Performance Wiring Diagram, Hybrid (6 of 6) for Ford Escape Hybrid 2007

List of elements for 2.3L, Engine Performance Wiring Diagram, Hybrid (6 of 6) for Ford Escape Hybrid 2007:

• Ac/dc converter (right front corner of engine compt)
• Ac/dc in+
• Ac/dc in-
• Battery compartment thermistor (left rear corner of vehicle)
• Battery junction box (bjb) (left rear of engine compt)
• Battery mode door actuator (left rear corner of vehicle)
• Battery zone valve (base of left "d" pillar)
• Bpo
• C2280d
• C4227a
• C4227b
• C4227c
• Computer data lines system
• Eli
• From powertrain control module (pcm) (diagram 1 of 6)
• From s406 (diagram 1 of 6)
• From transaxle control module (diagram 2 of 6)
• Fuse 50a
• Fuse 5a
• Fuse 7.5a
• G300 (under driver's seat)
• G301 (under driver's seat)
• G403 (left rear corner of vehicle)
• Gnd
• High voltage cutoff switch (right rear corner of vehicle)
• High voltage wires
• Hot at all times
• Hot in run or start
• Hs can+
• Hs can-
• Hvtmu+
• Hvtmu-
• Int+
• Int-
• Isdn1
• Isdn2
• J/s lamp
• J/s swa
• Jump start switch
• Mode mtr+
• Mode mtr-
• Mode pot
• Mode pot wiper
• Mode pot+
• Red
• S130
• S240 (behind right side of dash, near c212)
• S251
• S311
• S313
• S416
• S417
• S419
• Sig gnd
• Smart junction box (sjb) (below center of dash)
• Switch input
• Traction battery control module (left) (on floor, behind left wheelwell)
• Traction battery control module (right) (on floor, behind right wheelwell)
• Txv sol
• Txv temp
• Txv temp rtn
• Vpwr

3.0L

3.0L, Engine Performance Wiring Diagram (1 of 5) for Ford Escape Hybrid 2007

List of elements for 3.0L, Engine Performance Wiring Diagram (1 of 5) for Ford Escape Hybrid 2007:

• (beneath left rear of vehicle) evap canister vent control solenoid
• (lower left side of dash) data link connector (dlc)
• (rear of engine compt, on firewall) g109
• Accr
• Accs
• Acpsw
• Air conditioning system
• Anti-theft system
• Boo
• C175b
• C2280c
• Can +
• Can -
• Canvnt
• Case gnd
• Compt)
• Cooling fans system
• Feps
• Fpm
• Fppwr
• Fprtn
• Ftpt
• Fuel gauge sensor
• Fuel pump
• Fuel pump driver module (under center of vehicle)
• Fuel sndr
• Fuel tank unit (beneath left rear of vehicle, in fuel tank)
• Fuse 5a
• G101 (rear of engine compt, on firewall)
• G405 (under rear center of vehicle)
• Gnd
• Hfc
• Hot at all times
• Iat
• Ifs input
• Inertia fuel shutoff (ifs) switch (base of right door pillar, near kick panel)
• Instrument cluster
• Kapwr
• Lfc
• Mafrtn
• Mafs
• Nca
• Powertrain control module (pcm) (in recess on upper center of firewall)
• Psps
• Pwr grd
• Red
• Red/pnk
• Rtn
• Rx-data
• S104
• S410
• Shift interlock system
• Smart junction box (sjb) (below center of dash)
• Smr
• Starting/charging system
• Strt-out
• Tan/red
• Tcs
• Tx-out
• Vmv-cc/evmv
• Vpwr
• Vrsrtn

3.0L, Engine Performance Wiring Diagram (2 of 5) for Ford Escape Hybrid 2007

List of elements for 3.0L, Engine Performance Wiring Diagram (2 of 5) for Ford Escape Hybrid 2007:

• (left front of rocker panel) s313
• (left side of transmission, near left axle flange) output shaft speed sensor (oss)
• (not used)
• (on bracket, above brake pedal) brake pedal position switch
• (on top of engine) s151
• (rear of engine compt) evaporative emission (evap) canister purge valve
• (right side of engine) s100
• (top of engine) s154
• C2280c
• C248
• Differential pressure feedback egr (dpfe) sensor (right rear of engine)
• Engine coolant temperature (ect) sensor (rear of engine in water outlet)
• Fuel rail pressure/ temperature sensor (top of engine)
• Fuel tank pressure transducer sensor (beneath left rear of vehicle)
• Fuse 15a
• G101 (rear of engine compt, on firewall)
• Hot at all times
• Manifold absolute pressure (map) sensor (rear of engine compt, on firewall)
• Mass air flow (maf) sensor (left side of engine compt, in air intake duct)
• Near heated oxygen sensor (ho2s) no 11) s105
• Of engine compt, near c134)
• Power steering pressure switch (left front of engine)
• Red/pnk
• S104
• Smart junction box (sjb) (below center of dash)
• Throttle position sensor (tps) (on throttle body)

3.0L, Engine Performance Wiring Diagram (3 of 5) for Ford Escape Hybrid 2007

List of elements for 3.0L, Engine Performance Wiring Diagram (3 of 5) for Ford Escape Hybrid 2007:

• (left side of engine compt) s108
• (left side of engine compt) s109
• (on top of transmission) transmission hardware unit
• (top of transmission) transmission range (tr) sensor
• 3-2t/ccs solenoid
• C175t
• Electronic pressure control solenoid
• Epc
• Ho2s-12
• Ho2s-22
• Htr-12
• Htr-22
• Oss
• Powertrain control module (pcm) (in recess on upper center of firewall)
• Red/pnk
• Shift solenoid a
• Shift solenoid b
• Ss3l
• Ssa
• Ssb
• Tcch
• Tft
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Trs
• Tss

3.0L, Engine Performance Wiring Diagram (4 of 5) for Ford Escape Hybrid 2007

List of elements for 3.0L, Engine Performance Wiring Diagram (4 of 5) for Ford Escape Hybrid 2007:

• (rear of engine compartment)
• (right side of engine, near heated oxygen sensor (ho2s) no 11) s107
• (right side of engine, near heated oxygen)
• A/c clutch relay
• Battery junction box (bjb) (left front corner of engine compt)
• C2280b
• Camshaft position sensor (front of left cylinder head)
• Differential pressure egr vacuum regulator (rear of right valve cover)
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 2a
• Fuse 30a
• Fuse 5a
• G300 (under driver's seat)
• Heated oxygen sensor (ho2s) 11 (near right rear of engine, in exhaust)
• Heated oxygen sensor (ho2s) 12 (w/ low emission vehicles) (near right front of engine)
• Heated oxygen sensor (ho2s) 21 (rear left side of engine)
• Heated oxygen sensor (ho2s) 22 (w/ low emission vehicles) (rear left side of engine)
• Hot at all times
• Hot in run or start
• Idle air control (iac) valve (below throttle body, on center rear of engine)
• Pcm power diode
• Pcm power relay
• Red
• Red/pnk
• S103
• S111 (left side of engine compt, near breakout to mass air flow (maf) sensor)
• S128
• S129
• S332
• Smart junction box (sjb) (below center of dash)
• Turbine shaft speed (tss) sensor (left side of transmission)

3.0L, Engine Performance Wiring Diagram (5 of 5) for Ford Escape Hybrid 2007

List of elements for 3.0L, Engine Performance Wiring Diagram (5 of 5) for Ford Escape Hybrid 2007:

• (front of engine block) crankshaft position sensor
• (near breakout to coil on plug 4)
• (near breakout to throttle position sensor)
• (top left side of engine)
• (top of engine) s152
• (top of engine) s157
• (top right side of engine)
• Altcom
• Altmon
• Bvrefe
• C175e
• Cda
• Cdb
• Cdc
• Cdd
• Cde
• Cdf
• Cid1
• Ckp+
• Ckp-
• Coil on plug 1
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Coil on plug 5
• Coil on plug 6
• Dpfe
• Ect
• Evr
• Frt
• Fuel injector
• G101 (rear of engine compt, on firewall)
• Ho2s-11
• Ho2s-21
• Htr-11
• Htr-21
• Iac
• Ignition trans- former capacitor 1 (right front of engine)
• Inj1
• Inj2
• Inj3
• Inj4
• Inj5
• Inj6
• Ips
• Nca
• Powertrain control module (pcm) (in recess on upper center of firewall)
• Red
• Red/pnk
• S104
• S153
• S156
• S157
• Sigrtne
• Starting/ charging system
• Tan
• Tmap
• Tps