ENGINE PERFORMANCE – Ford Pickup F350 Super Duty 2002 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

4.2L

4.2L, Engine Performance Wiring Diagrams (1 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.2L, Engine Performance Wiring Diagrams (1 of 4) for Ford Pickup F350 Super Duty 2002:

• (rear of right fender apron)
• (right rear of engine compt)
• 4x4 low sw
• 820 ohms
• A/c system
• Accs
• Battery junction box (left side of engine compt)
• C243
• C270b
• Case gnd
• Central junction box (under left side of dash)
• Ckp(+)
• Ckp(-)
• Cooling fans system
• Data link (+)
• Data link (-)
• Data link connector (partial) (under center of dash)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Evr ctrl
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G101
• G102 (right rear of engine compt)
• G104
• Ho2s (12)
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 2
• Ignition coil
• Ignition transformer capacitor 1 (on top of engine)
• Imrc
• Instrument cluster system
• Intake manifold runner control (imrc) (on right side of engine)
• Ks sensor
• Maf
• Nca
• O/d off
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R n
• S100
• S106
• S116
• S117 (fuel charge harn, near breakout to iac valve)
• S153
• S225
• Scp bus +
• Scp bus -
• Shift sol a
• Shift sol b
• Tcs
• Tft
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp
• Transmission control switch (a/t)
• Transmission system

4.2L, Engine Performance Wiring Diagrams (2 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.2L, Engine Performance Wiring Diagrams (2 of 4) for Ford Pickup F350 Super Duty 2002:

• (eng control sens harn, near breakout to starter mtr relay) s137
• (engine control sensor harn, near breakout to 4-pin conn in right rear corner of engine compt)
• (engine control sensor harn, near breakout to 40-pin conn in left rear of engine compt)
• (engine control sensor harn, near breakout to windshield wiper motor)
• (under left side of dash) central junction box
• Battery junction box (left side of engine compt)
• C201d
• C220a
• Check fuel cap indicator
• Cooling fan system
• Crankshaft position (ckp) sensor (lower front of engine)
• Crankshaft position sensor shield
• Differential pressure feedback egr (dpfe) sensor (right side of engine)
• Fuel pump relay
• Fuel tank pressure transducer sensor (at fuel tank)
• Fuse 15a
• Fuse 20a
• G123 (right rear of engine compt)
• Generic electronic module/ central timer module
• Hot at all times
• Instrument cluster
• Intake air temperature (iat) sensor (on intake manifold)
• Nca
• Pnk
• Red
• Red/pnk
• S100
• S127
• S135 (fuel charge harn, near breakout to fuel inj 4)
• S136 (fuel charge harn, near breakout to fuel inj 2)
• S138
• S139
• Throttle position (tp) sensor (on throttle body)
• Transfer case speed sensor (at left rear of transmission)
• Vss input

4.2L, Engine Performance Wiring Diagrams (3 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.2L, Engine Performance Wiring Diagrams (3 of 4) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp sw to rear lamp feed harn, at breakout to 38-pin conn in right rear of engine compt)
• (engine control sensor harn, near breakout to 40-pin conn, left rear corner of engine compt)
• (fuel charge harn, near breakout to 16-pin conn, right rear of eng compt)
• (fuel charge harn, near top of cylinder 2)
• (inside fuel pump assembly) fuel pump module
• (left front of engine compt)
• (under right side of dash) inertia fuel shut-off switch
• 4r70w transmission
• Egr vacuum regulator solenoid (right side of engine)
• Electronic pressure control solenoid
• Evap canister purge
• Fuel injectors
• G104
• Idle air control valve (on left side of intake manifold)
• Instrument cluster system
• Nca
• Output shaft speed (oss) sensor (left side of transmission)
• Pnk
• Red
• Red/pnk
• S129
• S131 (fuel charge harn, near breakout to imrc)
• S140
• S141 (back-up lamp sw to rear lamp feed harn, in breakout to 38-pin conn conn in right rear of engine compt)
• S154
• S155
• S400
• Shift solenoids
• Ssa
• Ssb
• Tan
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Valve (left rear corner of engine compt)

4.2L, Engine Performance Wiring Diagrams (4 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.2L, Engine Performance Wiring Diagrams (4 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to windsheild wiper motor)
• (in left side of engine compt) speed control servo
• (left kick panel)
• (near fuel tank) evap canister vent solenoid
• (on left side of engine compartment)
• (on left side of engine) cylinder head temperature sensor
• (right side of engine) knock sensor (ks)
• (under left side of dash) brake pedal position (bpp) switch
• 5v ref volt
• A/c clutch relay
• A/t
• Battery junction box
• Bpp sw
• C270a
• C270b
• Cam pos in
• Camshaft position (cmp) sensor (on front of engine)
• Canister vent
• Central junction box (under left side of dash)
• Cyl head temp
• Digital transmission range sensor (left side of transmission)
• Dpfe sens
• Epc sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pump ctrl
• Fuel tank press
• Fuse 5a
• G101 (right rear of engine compt)
• G101 (right rear of engine compt)
• G201
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 12 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 22 (on engine exhaust pipe)
• Heater ctrl
• Hot at all times
• Hot in start
• Iac sol
• Ign coil 3
• Ind lp ctrl
• Kap b(+)
• Knock sensor
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• M/t
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Oss (+)
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Ref voltage
• Rf ho2s
• Rf ho2s sig (11)
• Rr ho2s
• S100
• S143
• S160
• S208
• Speed sensor
• Tan
• Tcc sol
• Tp sens in
• Tr3a (a/t) cpp (m/t)
• Trans ctrl ind
• Vapor valve
• Vpwr
• Vss (+)
• Vss input
• Wot relay

4.6L

4.6L, Engine Performance Wiring Diagrams (1 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.6L, Engine Performance Wiring Diagrams (1 of 4) for Ford Pickup F350 Super Duty 2002:

• (4.6l)
• (engine control sensor harn, near breakout to 40-pin connector, left rear left rear corner of eng compt)
• (fuel charge harn, near breakout to 42-pin conn in right rear of engine compt)
• (fuel charge harn, near breakout to fuel injector 3)
• (left front of engine compt) g104
• (right rear of engine compt)
• 4x4 low ind sw
• Accs
• Air conditioning system
• Battery junction box (left side of engine compt)
• Capacitor (left front of engine)
• Case gnd
• Central junction box (under left side of dash)
• Ckp(+)
• Ckp(-)
• Coil on plug
• Data link (+)
• Data link (-)
• Data link connector (partial) (under center of dash)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Evr ctrl
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G101
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Ignition trans- former
• Ignition trans- former capacitor (right front of engine)
• Imcc
• Ind
• Instrument cluster system
• Ks sensor
• Maf
• Nca
• Not used
• O/d off
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R n
• Rr ho2s sig (12)
• S100
• S106 (or s105)
• S116
• S161
• S162 (fuel charge harn, near breakout to fuel injector 7)
• Shift sol a
• Shift sol b
• Tcil
• Tcs
• Tcss
• Tft
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2
• Tr4
• Transmission control switch (a/t)
• Transmission system

4.6L, Engine Performance Wiring Diagrams (2 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.6L, Engine Performance Wiring Diagrams (2 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin conn in left rear of engine compt)
• (engine control sensor harn, near breakout to windshield wiper motor)
• (engine control sensor harn, right rear of engine compt)
• (not used)
• Battery junction box (left side of engine compt)
• Crankshaft position (ckp) sensor (lower front of engine)
• Crankshaft position sensor shield
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Fuel pump relay
• Fuel tank pressure sensor (in fuel tank)
• Fuse 15a
• Fuse 20a
• G101 (right rear of engine compt)
• Hot at all times
• Intake air temperature (iat) sensor (on intake manifold)
• Intake manifold runner control module (4.6l) (right side of engine)
• Nca
• Pnk
• Power distribution box (left side of engine compt)
• Red
• Red/pnk
• S100
• S127
• S135 (fuel charge harn, near breakout to fuel inj 8)
• S136 (fuel charge harn, near breakout to fuel inj 7)
• S137 (engine control sensor harn, near breakout to starter relay)
• S138
• S139
• S199
• Throttle position (tp) sensor (on throttle body)
• Transfer case speed sensor (left rear of trans)

4.6L, Engine Performance Wiring Diagrams (3 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.6L, Engine Performance Wiring Diagrams (3 of 4) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp sw to rear lamp feed harn, in breakout to 38-pin conn in right rear engine compt)
• (engine control sensor harn, near breakout to 40-pin conn, left rear corner
• (engine ctrl sensor harn, near breakout to windsheild wiper motor)
• (fuel charge harn, near breakout to 16-pin conn, right rear of engine compt)
• (fuel charge harn, near breakout to ignition coil 3)
• (fuel tank) fuel pump module
• (left side of engine compt) speed control servo
• (under left side of dash) central junction box
• 4r70w transmission
• C201d
• Egr vacuum regulator solenoid (left side of engine)
• Electronic pressure control solenoid
• Evap canister purge
• Fuel injectors
• G104 (left front of engine compt)
• Generic electronic module
• Idle air control (iac) valve (on left side of intake manifold)
• Inertia fuel shut-off switch (under right side of dash)
• Instrument cluster system
• Nca
• Of engine compt)
• Output shaft speed (oss) sensor (left side of transmission)
• Pressure controllers
• Red
• Red/pnk
• S129
• S131 (fuel charge harn, near breakout to ign coil 7)
• S140
• S141
• S143
• S154
• S155
• S400
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Valve (left rear corner of engine compt)
• Vss input

4.6L, Engine Performance Wiring Diagrams (4 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 4.6L, Engine Performance Wiring Diagrams (4 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sens harn, near breakout to 40-pin conn, left rear of eng compt)
• (near fuel tank) canister vent solenoid
• (on left side of engine compartment)
• (right side of engine) knock sensor (ks)
• (top front of engine) cylinder head temperature (cht) sensor
• (under left side of dash) brake pedal position (bpp)switch
• 5v ref volt
• A/c clutch relay
• A/t
• Battery junction box
• Bpp sw
• Cam pos in
• Camshaft position (cmp) sensor (on front of engine)
• Canister vent
• Central junction box (under left side of dash)
• Check fuel cap ind
• Cooling fan system
• Cyl head temp
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Epc sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 5a
• G101 (right rear of engine compt)
• G201 (left kick panel)
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 12 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 22 (on engine exhaust pipe)
• Heater ctrl
• Hot at all times
• Hot in start
• Iac sol
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Ind ctrl
• Instrument cluster
• Kap b(+)
• Knock sensor
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• M/t
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Not used
• Oss (+)
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Rr ho2s
• S100
• S160
• S208
• S236
• S274
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr3a/cpp
• Vapor valve
• Vpwr
• Vss (+)
• Wot relay

5.4L

5.4L Bi-Fuel, Engine Performance Wiring Diagrams (1 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Bi-Fuel, Engine Performance Wiring Diagrams (1 of 5) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin connector, left rear corner of engine compt)
• (engine control sensor harn, near breakout to starter motor relay)
• (fuel charge harn, near breakout to 42-pin conn in right rear of engine compt)
• (fuel charge harn, near breakout to fuel injector 3)
• (left front of eng compt) g104
• (right side of firewall)
• (under left side of dash) generic electronic module
• (vcl/sensor harn, left rear of engine compt)
• 4x4 low & high indicator switch (left side of transmission)
• 4x4 low ind sw
• 4x2
• Accs
• Air conditioning system
• Battery junction box (left side of engine compt)
• C201a
• C270b
• Case gnd
• Center of dash)
• Central junction box (under left side of dash)
• Ckp(+)
• Ckp(-)
• Css
• Data link (+)
• Data link (-)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Electronic shift on the fly (esof)
• Evr ctrl
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G101
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Ignition trans- former capacitor (top left side of engine)
• Ignition trans- former capacitor (top right side of engine)
• Imcc
• Ind
• Instrument cluster system
• Ks sensor
• Maf
• Mechanical shift on the fly (msof)
• Nca
• Not used
• O/d off
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R n
• Rr ho2s sig (12)
• S100
• S106 (or s105)
• S116
• S142
• S161
• S162 (fuel charge harn, near breakout to fuel injector 7)
• S225
• S4003
• S4004
• Shift sol 1
• Shift sol 2
• Tcil
• Tcs
• Tcss
• Tft
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2
• Tr4
• Transmission control switch (a/t)

5.4L Bi-Fuel, Engine Performance Wiring Diagrams (2 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Bi-Fuel, Engine Performance Wiring Diagrams (2 of 5) for Ford Pickup F350 Super Duty 2002:

• (cng)
• (engine control sensor harn, near breakout to 40-pin conn in left rear of engine compt)
• (engine control sensor harn, near breakout to windshield wiper motor)
• (engine control sensor harn, right rear of engine compt)
• (fuel charge harn, near breakout to fuel inj 8)
• (lpg)
• (near battery)
• (near fuel tank) tank valve 1 (cng)
• (near fuel tank) tank valve diode (cng)
• (right rear of body compt) lock off diode
• (right rear of body compt) lock off solenoid
• (right rear of engine compt) cold start heater diode (lpg)
• (under right side of dash) inertia fuel shut-off switch
• Battery junction box (left side of engine compt)
• C220a
• Cold start heater (lpg)
• Cold start heater relay (lpg) (right side of engine compt)
• Crankshaft position (ckp) sensor (lower front of engine)
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Fuel pump relay
• Fuel reset
• Fuel tank pressure sensor (in fuel tank)
• Fuse 15a
• Fuse 20a
• G101 (right side of firewall)
• Hot at all times
• Instrument cluster
• Intake air temperature (iat) sensor (on intake manifold)
• Nca
• Pnk
• Red
• Red/pnk
• S1003 (engine harn, near breakout to bjb)
• S101
• S127
• S135
• S136 (fuel charge harn, near breakout to fuel inj 7)
• S137 (engine control sensor harn, near breakout to starter relay)
• S138
• S139
• S199
• S4005
• S4006
• S4010
• S4011
• S4012
• S4014 s4031
• S4015
• S4016
• S4020 (vcl/sensor harn, right rear of engine compt)
• S4032
• S4033
• S4034
• S4035
• S4036
• Throttle position (tp) sensor (on throttle body)
• Transfer case speed sensor (left rear of trans)
• Turbine shaft speed (tss) sensor (left rear of trans)

5.4L Bi-Fuel, Engine Performance Wiring Diagrams (3 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Bi-Fuel, Engine Performance Wiring Diagrams (3 of 5) for Ford Pickup F350 Super Duty 2002:

• (b+)
• (compuvalve harn, near fuel tank)
• (compuvalve harn, right rear of engine compt)
• (fuel tank) fuel tank pressure sensor
• (fuel tank) fuel tank temperature sensor
• (right front of engine compt)
• (right front of engine compt) g119
• (vcl/sens harn, right rear of engine compt)
• (vcl/sensor harn, right rear of engine compt)
• 1ooo
• 87a
• A red
• Bi-fuel power relay
• Bi-fuel relay module
• Bus (-)
• C4001
• C410
• C495
• Ckp (+)
• Ckp (-)
• Cng
• Cold st
• Compuvalve module
• Cool s
• Coolant solenoid
• F cut
• F send
• F temp
• Fuel pump assembly (fuel tank)
• Fuel pump cutoff relay
• Fuse 10a
• Fuse 3a
• G001
• G002
• G003
• G004
• G005
• G006
• G007
• G008
• G009
• G010
• G011
• G013
• G015
• G016
• G017
• G018
• G019
• G021
• G022
• G024
• G026
• G027
• G030
• G032
• G038
• G042
• G043
• G045
• G046
• G047
• G049
• G050
• G051
• G052
• G053
• G054
• G055
• G056
• G057
• G058
• G059
• G060
• G061
• G062
• G063
• G064
• G086
• G096
• G104 (left front of engine compt)
• G4001
• G830
• Ground
• High flow injector assembly
• Ho2s 11
• Ho2s 21
• Hot at all times
• Ign
• Ind sw
• Indicator light switch
• Inj 1
• Inj 2
• Inj 3
• Inj 4
• Inj 5
• Inj 6
• Inj 7
• Inj 8
• Lk off
• Low flow injector assembly
• Nca
• Not used
• Not used c4000
• Pnk
• Red
• Red/pnk
• Resistor
• S400
• S4001
• S4007
• S4008
• S4017
• S4021
• S4040
• Sig rtn
• Tps rtn

5.4L Bi-Fuel, Engine Performance Wiring Diagrams (4 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Bi-Fuel, Engine Performance Wiring Diagrams (4 of 5) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp sw to rear lamp feed harn, in breakout to 38 pin conn, right rear eng compt)
• (back-up lamp sw to rear lamp feed harn, in breakout to 38-pin conn in right rear engine compt)
• (engine control sensor harn, near breakout to 40 pin conn, left rear corner of engine compt)
• (engine ctrl sensor harn, near breakout to windshield wiper motor)
• (fuel charge harn, near breakout to 16-pin conn, right rear of engine compt)
• (fuel charge harn, near breakout to ignition coil 3)
• (fuel tank) liquid propane gas sender
• (left side of engine compt) speed control servo
• (under left side of dash) central junction box
• C201d
• Coast clutch solenoid
• Egr vacuum regulator solenoid (left side of engine)
• Electronic pressure control solenoid
• Evap canister purge valve (left rear corner of eng compt)
• Fuel injectors
• Generic electronic module
• Idle air control (iac) valve (on left side of intake manifold)
• Intake manifold runner control module (left side of engine)
• Lpg
• Nca
• Output shaft speed (oss) sensor (left side of transmission)
• Red
• Red/pnk
• S129
• S131 (fuel charge harn, near breakout to ign coil 7)
• S140
• S141
• S143
• S154
• S155
• Shift solenoid 1
• Shift solenoid 2
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission
• Transmission fluid temperature sensor
• Vss input

5.4L Bi-Fuel, Engine Performance Wiring Diagrams (5 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Bi-Fuel, Engine Performance Wiring Diagrams (5 of 5) for Ford Pickup F350 Super Duty 2002:

• (engine control sens harn, near breakout to 40-pin conn, left rear of eng compt)
• (near fuel tank) evap canister vent valve
• (on left side of engine compartment)
• (right side of engine) knock sensor (ks)
• (top front of engine) cylinder head temperature (cht) sensor
• (under left side of dash) brake pedal position (bpp) switch
• (vcl/sens harn, right rear of engine compt)
• 5v ref volt
• A/c clutch relay
• Battery junction box
• Bpp sw
• Cam pos in
• Camshaft position (cmp) sensor (on front of engine)
• Canister vent
• Central junction box (under left side of dash)
• Cyl head temp
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Epc sol
• From dtr sensor (diagram 1 of 5)
• Fuel cap off ind
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 5a
• G101 (right side of firewall)
• G201 (left kick panel)
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 12 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 22 (on engine exhaust pipe)
• Heater ctrl
• Hot at all times
• Iac sol
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Ind ctrl
• Instrument cluster
• Kap b(+)
• Knock sensor
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Oss (+)
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Rr ho2s
• S100
• S101
• S160
• S199
• S208
• S236
• S274
• S4018
• S4019
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr3a/cpp
• Tss
• Vapor valve
• Vpwr
• Vss (+)
• Wot relay

5.4L CNG, Engine Performance Wiring Diagrams (1 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L CNG, Engine Performance Wiring Diagrams (1 of 5) for Ford Pickup F350 Super Duty 2002:

• (eng ctrl sensor harn, near breakout to 12-pin conn, center front of eng compt)
• (left front of engine compt) g104
• (under center of dash) (partial) datalink connector
• A/c on sig
• Air conditioning system
• Battery junction box (left side of engine compt)
• Case gnd
• Ccs
• Central junction box (under left side of dash)
• Ckp (+)
• Ckp (-)
• Data link (+)
• Data link (-)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Dtr-tr1
• Dtr-tr2
• Dtr-tr4
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G101 (right rear of engine compt)
• G201 (lower left kick panel)
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Instrument cluster
• Maf
• Nca
• Ngv timer (left rear of engine compt)
• O/d off
• Ohms
• Pcm power diode
• Pcm power relay
• Powertrain control module (right side of engine compt)
• Pwr gnd
• R n
• S116
• S156
• S157
• S207
• S225
• Ss1
• Ss2
• Starting/ charging system
• Tan/red
• Tcil ind
• Tcs
• Tft
• To dtr sensor (diagram 5 of 5)
• Transmission control indicator lamp
• Transmission control switch

5.4L CNG, Engine Performance Wiring Diagrams (2 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L CNG, Engine Performance Wiring Diagrams (2 of 5) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin conn in left rear of engine compt)
• (engine control sensor harn, near breakout to windshield wiper motor)
• (fuel charge harn, near breakout to fuel inj 8)
• (fuel tank harn, near breakout to tank valve 2) s302
• (left side of engine compt) speed control servo
• (under left side of dash) central junction box
• Battery junction box (left side of engine compt)
• C201d
• C220b
• C270b
• Crankshaft position (ckp) sensor (lower front of engine)
• Crankshaft position sensor shield
• Front in-bed fuel tank valve (at fuel tank)
• Fuel gauge
• Fuse 15a
• G101 (right rear of engine compt)
• G104 (left front of engine coompt)
• Generic electronic module/ central timer module
• Inertia fuel shut-off switch (under right side of dash)
• Injection control pressure (icp) sensor (on top of engine)
• Instrument cluster
• Intake air temperature (iat) sensor (on intake manifold)
• Midship fuel tank valve (at fuel tank)
• Nca
• Rear in-bed fuel tank valve (at fuel tank)
• Red
• Red/pnk
• S101
• S135
• S136 (fuel charge harn, near breakout to ing coil 4)
• S139
• S143
• S159 (engine ctrl sensor harn, near breakout to wiper motor)
• S199
• S301
• Throttle position (tp) sensor (on throttle body)
• Vss input

5.4L CNG, Engine Performance Wiring Diagrams (3 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L CNG, Engine Performance Wiring Diagrams (3 of 5) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp harn, at breakout to 38-pin conn in right rear of engine compt)
• Battery junction box (left side of engine compt)
• Coast clutch solenoid
• Electronic pressure control solenoid
• Fuel pump relay
• Fuel rail cutoff valve (on fuel rail)
• Fuse 20a
• G102 (lower right rear of engine)
• Hot at all times
• Ignition coils
• Ignition transformer capacitor (on top left side of engine)
• Ignition transformer capacitor (on top right side of engine)
• Nca
• R4100 transmission
• Red
• Red red
• Red/pnk
• S117 (fuel charge harn, near breakout to 42-pin inline conn in right rear of engine compt)
• S140
• S153
• S161 (fuel charge harn, in breakout to injector 3)
• S162 (fuel charge harn, in breakout to injector 7)
• Shift solenoid
• Torque converter clutch solenoid
• Transmission fluid temperature sensor

5.4L CNG, Engine Performance Wiring Diagrams (4 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L CNG, Engine Performance Wiring Diagrams (4 of 5) for Ford Pickup F350 Super Duty 2002:

• (eng control sens harn, near breakout to wiper motor)
• Cooling fans system
• Data (+)
• Data (-)
• Fuel gauge
• Fuel injectors
• Fuel press
• Fuel temp
• Ground
• Ignition
• Inj 1 input
• Inj 1 out
• Inj 2 input
• Inj 2 out
• Inj 3 input
• Inj 3 out
• Inj 4 input
• Inj 4 out
• Inj 5 input
• Inj 5 out
• Inj 6 input
• Inj 6 out
• Inj 7 input
• Inj 7 out
• Inj 8 input
• Inj 8 out
• Ngv fuel tank pressure sensor (at fuel tank)
• Ngv fuel tank temperature sensor (at fuel tank)
• Ngv module (on front of engine)
• Output shaft speed (oss) sensor (on left side of transmission)
• Power
• Red
• Red/pnk
• S127
• S129 (fuel charge harn, near breakout to ign coil 3)
• S131 (fuel charge harn, near breakout ign coil 7)
• S303 (fuel tank harn, near fuel tank)
• Sig return
• Tan
• Tan/ red
• Tan/red
• Timer

5.4L CNG, Engine Performance Wiring Diagrams (5 of 5) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L CNG, Engine Performance Wiring Diagrams (5 of 5) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp harn, in breakout to 38-pin conn in right rear eng compt)
• (eng cntrl sens harn)
• (engine control sensor harn, right rear of engine compt)
• (fuel charge harness)
• (left rear of engine compt)
• (left rear of trans) turbine shaft speed sensor
• (left side of dash) brake pedal position (bpp) switch
• (top front of left head) cylinder head temperature sensor
• 270 ohms
• 5v ref
• A/c clutch relay
• Battery junctioin box (in left side of engine compt)
• Bpp switch
• C220a
• C270a
• C270b
• Camshaft position (cmp) sensor (on front of engine)
• Central junction box (under left side of dash)
• Cmp sensor
• Cooling fan system
• Cyl head temp
• Digital transmission range sensor (dtr sensor-a/t) (left side of transmission)
• Dtr-tr3a
• Eft sensor
• Epc sol
• From dtr sensor (diagram 1 of 5)
• Fuel cap off ind
• Fuel ctrl
• Fuel rail temperature sensor (on top of engine)
• Fuse 5a
• G101 (right rear of engine compt)
• G201 (lower left kick panel)
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Ho2s (11)
• Ho2s (21)
• Ho2s sig (#11)
• Ho2s sig (21)
• Hot at all times
• Idle air control valve (on left side of intake manifold)
• Idle air ctrl
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Ind ctrl
• Inj pressure
• Instrument cluster
• Kap b(+)
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Ngv module
• Not used
• Oss sensor
• Powertrain control module (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Relay output
• S100
• S138
• S141
• S154
• S155
• S158
• Sig rtn
• Tcc sol
• Tp sens in
• Tss sensor
• Vpwr
• Vss (+)
• Wire terminates in harness
• Wot relay

5.4L Supercharged, Engine Performance Wiring Diagrams (1 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Supercharged, Engine Performance Wiring Diagrams (1 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin connector, left rear left rear corner of eng compt)
• (fuel charge harn, near breakout to 42-pin conn in right rear of engine compt)
• (fuel charge harn, near breakout to fuel injector 3)
• (right rear of engine compt)
• A/c system
• Accs
• Battery junction box (left side of engine compt)
• C270b
• Case gnd
• Central junction box (under left side of dash)
• Ckp(+)
• Ckp(-)
• Coil on plug
• Css
• Data link (+)
• Data link (-)
• Data link connector (partial) (under center of dash)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Evr ctrl
• Fuel h/l rly
• Fuel pump mon
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G101
• G104 (left front of engine compartment)
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Ignition trans- former capacitor (top left side of engine)
• Ignition trans- former capacitor (top right side of engine)
• Ind
• Instrument cluster system
• Intake air temperature sensor 2 (top of engine)
• Ks sensor
• Maf
• Nca
• O/d off
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R n
• Red
• Rr ho2s sig (12)
• S100
• S1003 (engine control sensor harn, near breakout to battery junction box)
• S105
• S116
• S161
• S162 (fuel charge harn, near breakout to fuel injector 7)
• Shift sol a
• Shift sol b
• Sol ctrl
• Supercharger bypass solenoid (rear of engine)
• Tcil
• Tcs
• Tft
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2
• Tr4
• Transmission control switch (a/t)

5.4L Supercharged, Engine Performance Wiring Diagrams (2 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Supercharged, Engine Performance Wiring Diagrams (2 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control harn, left front corner of vehicle)
• (engine control harn, left front corner of vehicle) s151
• (engine control sensor harn, near breakout to windshield wiper motor)
• (engine control sensor harn, right rear of engine compt)
• (left front of engine compt)
• (left front of engine compt) g104
• (rear of right fender apron) g102
• 87a
• Auxiliary relay box 1 (behind left side of dash)
• Barometric absolute pressure sensor (rear of engine)
• Battery junction box (left side of engine compt)
• Charge air cooler pump motor (left front of engine compt)
• Charge air cooler pump relay
• Crankshaft position (ckp) sensor (lower front of engine)
• Crankshaft position sensor shield
• Crash fuel shutoff relay
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Dropping resistor (left front of engine compt)
• Fuel pump assembly (at fuel tank)
• Fuel pump high/low relay
• Fuel pump relay
• Fuel tank pressure sensor (in fuel tank)
• Fuse 20a
• G104
• G123 (right rear of engine compt)
• Hot at all times
• Inertia fuel shut-off switch (under right side of dash)
• Instrument cluster system
• Intake air temperature (iat) sensor 1 (on intake manifold)
• Nca
• Red
• Red/pnk
• S100
• S102
• S106
• S127
• S135 (fuel charge harn, near breakout to fuel inj 8)
• S136 (fuel charge harn, near breakout to fuel inj 7)
• S137 (engine control sensor harn, near breakout to starter relay)
• S138
• S144
• S197 (engine control sensor harn, near breakout to cyl 5)
• S199
• Throttle position (tp) sensor (on throttle body)
• Turbine shaft speed (tss) sensor (left rear of trans)

5.4L Supercharged, Engine Performance Wiring Diagrams (3 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Supercharged, Engine Performance Wiring Diagrams (3 of 4) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp sw to rear lamp feed harn, in breakout to 38-pin conn in right rear engine compt)
• (engine control sensor harn, near breakout to 40-pin conn, left rear corner of engine compt)
• (engine ctrl sensor harn, near breakout to windshield wiper motor)
• (fuel charge harn, near breakout to 16-pin conn, right rear of engine compt)
• (fuel charge harn, near breakout to ignition coil 3)
• (left side of engine compt) speed control servo
• (under left side of dash) central junction box
• 4r100 transmission
• C201d
• Coast clutch solenoid
• Egr vacuum regulator solenoid (left side of engine)
• Electronic pressure control solenoid
• Evap canister purge
• Fuel injectors
• Generic electronic module
• Idle air control (iac) valve (on left side of intake manifold)
• Output shaft speed (oss) sensor (left side of transmission)
• Red
• Red/pnk
• S129
• S131 (fuel charge harn, near breakout to ign coil 7)
• S140
• S141
• S143
• S154
• S155
• Shift solenoid
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Valve (left rear corner of engine compt)
• Vss input

5.4L Supercharged, Engine Performance Wiring Diagrams (4 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L Supercharged, Engine Performance Wiring Diagrams (4 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sens harn, near breakout to 40-pin conn, left rear of eng compt)
• (near fuel tank) canister vent solenoid
• (on left side of engine compartment)
• (right side of engine) knock sensor (ks)
• (top front of engine) cylinder head temperature (cht) sensor
• (under left side of dash) brake pedal position (bpp) switch
• 5v ref volt
• A/c clutch relay
• Air cool rly
• Bap sensor
• Battery junction box
• Bpp sw
• Cam pos in
• Camshaft position (cmp) sensor (on front of engine)
• Canister vent
• Central junction box (under left side of dash)
• Cyl head temp
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Epc sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 5a
• G101 (right rear of engine compt)
• G201 (left kick panel)
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 12 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 22 (on engine exhaust pipe)
• Heater ctrl
• Hot at all times
• Iac sol
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Kap b(+)
• Knock sensor
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Oss (+)
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Rr ho2s
• S100
• S160
• S208
• S236
• S274
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr3a/cpp
• Tss
• Vapor valve
• Vpwr
• Vss (+)
• Wot relay

5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (1 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (1 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin connector, left rear left rear corner of eng compt)
• (fuel charge harn, near breakout to 42-pin conn in right rear of engine compt)
• (fuel charge harn, near breakout to fuel injector 3)
• (left front of engine compt) g104
• (right rear of engine compt)
• 4x4 low ind sw
• Accs
• Air conditioning system
• Battery junction box (left side of engine compt)
• C270b
• Capacitor (top left side of engine)
• Case gnd
• Central junction box (under left side of dash)
• Ckp(+)
• Ckp(-)
• Coil on plug
• Css
• Data link (+)
• Data link (-)
• Data link connector (partial) (under center of dash)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Evr ctrl
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G101
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Ignition trans- former
• Ignition trans- former capacitor (top right side of engine)
• Ind
• Instrument cluster system
• Ks sensor
• Maf
• Nca
• Not used
• O/d off
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R n
• Rr ho2s sig (12)
• S100
• S106 (or s105)
• S116
• S161
• S162 (fuel charge harn, near breakout to fuel injector 7)
• S225
• Shift sol a
• Shift sol b
• Tcil
• Tcs
• Tcss
• Tft
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2
• Tr4
• Transmission control switch (a/t)
• Transmission system

5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (2 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (2 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin conn in left rear of engine compt)
• (engine control sensor harn, near breakout to windshield wiper motor) s127
• (engine control sensor harn, right rear of engine compt)
• (fuel tank) fuel pump assembly
• (under right side of dash) inertia fuel shut-off switch
• Battery junction box (left side of engine compt)
• Crankshaft position (ckp) sensor (lower front of engine)
• Crankshaft position sensor shield
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Fuel pump relay
• Fuel tank pressure sensor transducer (in fuel tank)
• Fuse 15a
• Fuse 20a
• G101 (right rear of engine compt)
• G104 (left front of eng compt)
• Hot at all times
• Instrument cluster system
• Intake air temperature (iat) sensor (on intake manifold)
• Nca
• Pnk
• Power distribution box (left side of engine compt)
• Red
• Red/pnk
• S100
• S135 (fuel charge harn, near breakout to fuel inj 8)
• S136 (fuel charge harn, near breakout to fuel inj 7)
• S137 (engine control sensor harn, near breakout to starter relay)
• S138
• S139
• S199
• S400
• Throttle position (tp) sensor (on throttle body)
• Transfer case speed sensor (left rear of trans)
• Turbine shaft speed (tss) sensor (left rear of trans)

5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (3 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (3 of 4) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp sw to rear lamp feed harn, in breakout to 38-pin conn in right rear engine compt)
• (engine control sensor harn, near breakout to 40-pin conn, left rear corner of engine compt)
• (engine ctrl sensor harn, near breakout to windsheild wiper motor)
• (fuel charge harn, near breakout to 16-pin conn, right rear of engine compt)
• (fuel charge harn, near breakout to ignition coil 3)
• (left side of engine compt) speed control servo
• (under left side of dash) central junction box
• 4r100 transmission
• C201d
• Coast clutch solenoid
• Egr vacuum regulator solenoid (left side of engine)
• Electronic pressure control solenoid
• Evap canister purge
• Fuel injectors
• Generic electronic module
• Idle air control (iac) valve (on left side of intake manifold)
• Output shaft speed (oss) sensor (left side of transmission)
• Red
• Red/pnk
• S129
• S131 (fuel charge harn, near breakout to ign coil 7)
• S140
• S141
• S143
• S154
• S155
• Shift solenoid a
• Shift solenoid b
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Valve (left rear corner of engine compt)
• Vss input

5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (4 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R100 Transmission (4 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sens harn, near breakout to 40-pin conn, left rear of eng compt)
• (near fuel tank) evap canister vent valve
• (on left side of engine compartment)
• (right side of engine) knock sensor (ks)
• (top front of engine) cylinder head temperature (cht) sensor
• (under left side of dash) brake pedal position (bpp) switch
• 5v ref volt
• A/c clutch relay
• Battery junction box
• Bpp sw
• Cam pos in
• Camshaft position (cmp) sensor (on front of engine)
• Canister vent
• Central junction box (under left side of dash)
• Cyl head temp
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Epc sol
• From dtr sensor (diagram 1 of 4)
• Fuel cap off ind
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 5a
• G101 (right rear of engine compt)
• G201 (left kick panel)
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 12 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 22 (on engine exhaust pipe)
• Heater ctrl
• Hot at all times
• Iac sol
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Ind ctrl
• Instrument cluster
• Kap b(+)
• Knock sensor
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Oss (+)
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Rr ho2s
• S100
• S160
• S208
• S236
• S274
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr3a/cpp
• Tss
• Vapor valve
• Vpwr
• Vss (+)
• Wot relay

5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (1 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (1 of 4) for Ford Pickup F350 Super Duty 2002:

• (4.6l)
• (engine control sensor harn, near breakout to 40-pin connector, left rear left rear corner of eng compt)
• (fuel charge harn, near breakout to 42-pin conn in right rear of engine compt)
• (fuel charge harn, near breakout to fuel injector 3)
• (left front of engine compt) g104
• (right rear of engine compt)
• 4x4 low ind sw
• Accs
• Air conditioning system
• Battery junction box (left side of engine compt)
• Capacitor (left front of engine)
• Case gnd
• Central junction box (under left side of dash)
• Ckp(+)
• Ckp(-)
• Coil on plug
• Data link (+)
• Data link (-)
• Data link connector (partial) (under center of dash)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dlc
• Evr ctrl
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G101
• Hot at all times
• Hot in run or start
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Ignition trans- former
• Ignition trans- former capacitor (right front of engine)
• Imcc
• Ind
• Instrument cluster system
• Ks sensor
• Maf
• Nca
• Not used
• O/d off
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R n
• Rr ho2s sig (12)
• S100
• S106 (or s105)
• S116
• S161
• S162 (fuel charge harn, near breakout to fuel injector 7)
• Shift sol a
• Shift sol b
• Tcil
• Tcs
• Tcss
• Tft
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2
• Tr4
• Transmission control switch (a/t)
• Transmission system

5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (2 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (2 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sensor harn, near breakout to 40-pin conn in left rear of engine compt)
• (engine control sensor harn, near breakout to windshield wiper motor)
• (engine control sensor harn, right rear of engine compt)
• (not used)
• Battery junction box (left side of engine compt)
• Crankshaft position (ckp) sensor (lower front of engine)
• Crankshaft position sensor shield
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Fuel pump relay
• Fuel tank pressure sensor (in fuel tank)
• Fuse 15a
• Fuse 20a
• G101 (right rear of engine compt)
• Hot at all times
• Intake air temperature (iat) sensor (on intake manifold)
• Intake manifold runner control module (4.6l) (right side of engine)
• Nca
• Pnk
• Power distribution box (left side of engine compt)
• Red
• Red/pnk
• S100
• S127
• S135 (fuel charge harn, near breakout to fuel inj 8)
• S136 (fuel charge harn, near breakout to fuel inj 7)
• S137 (engine control sensor harn, near breakout to starter relay)
• S138
• S139
• S199
• Throttle position (tp) sensor (on throttle body)
• Transfer case speed sensor (left rear of trans)

5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (3 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (3 of 4) for Ford Pickup F350 Super Duty 2002:

• (back-up lamp sw to rear lamp feed harn, in breakout to 38-pin conn in right rear engine compt)
• (engine control sensor harn, near breakout to 40-pin conn, left rear corner
• (engine ctrl sensor harn, near breakout to windsheild wiper motor)
• (fuel charge harn, near breakout to 16-pin conn, right rear of engine compt)
• (fuel charge harn, near breakout to ignition coil 3)
• (fuel tank) fuel pump module
• (left side of engine compt) speed control servo
• (under left side of dash) central junction box
• 4r70w transmission
• C201d
• Egr vacuum regulator solenoid (left side of engine)
• Electronic pressure control solenoid
• Evap canister purge
• Fuel injectors
• G104 (left front of engine compt)
• Generic electronic module
• Idle air control (iac) valve (on left side of intake manifold)
• Inertia fuel shut-off switch (under right side of dash)
• Instrument cluster system
• Nca
• Of engine compt)
• Output shaft speed (oss) sensor (left side of transmission)
• Pressure controllers
• Red
• Red/pnk
• S129
• S131 (fuel charge harn, near breakout to ign coil 7)
• S140
• S141
• S143
• S154
• S155
• S400
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Valve (left rear corner of engine compt)
• Vss input

5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (4 of 4) for Ford Pickup F350 Super Duty 2002

List of elements for 5.4L, Engine Performance Wiring Diagrams, with 4R70W Transmission (4 of 4) for Ford Pickup F350 Super Duty 2002:

• (engine control sens harn, near breakout to 40-pin conn, left rear of eng compt)
• (near fuel tank) canister vent solenoid
• (on left side of engine compartment)
• (right side of engine) knock sensor (ks)
• (top front of engine) cylinder head temperature (cht) sensor
• (under left side of dash) brake pedal position (bpp)switch
• 5v ref volt
• A/c clutch relay
• A/t
• Battery junction box
• Bpp sw
• Cam pos in
• Camshaft position (cmp) sensor (on front of engine)
• Canister vent
• Central junction box (under left side of dash)
• Check fuel cap ind
• Cooling fan system
• Cyl head temp
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Epc sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 5a
• G101 (right rear of engine compt)
• G201 (left kick panel)
• Heated oxygen sensor (ho2s) 11 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 12 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 21 (on engine exhaust pipe)
• Heated oxygen sensor (ho2s) 22 (on engine exhaust pipe)
• Heater ctrl
• Hot at all times
• Hot in start
• Iac sol
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Ind ctrl
• Instrument cluster
• Kap b(+)
• Knock sensor
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• M/t
• Maf sens in
• Mass airflow (maf) sensor (in air cleaner assembly)
• Nca
• Not used
• Oss (+)
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Rr ho2s
• S100
• S160
• S208
• S236
• S274
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr3a/cpp
• Vapor valve
• Vpwr
• Vss (+)
• Wot relay