ENGINE PERFORMANCE – Hyundai Tucson Limited 2006 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.0L

2.0L, Engine Performance Wiring Diagram (1 of 4) for Hyundai Tucson Limited 2006

List of elements for 2.0L, Engine Performance Wiring Diagram (1 of 4) for Hyundai Tucson Limited 2006:

• (a/t)
• (top of fuel tank) fuel sender & fuel pump motor
• (under left side of dash) g29
• (w/ 4wd)
• (w/ esc)
• (w/o 4wd)
• (w/o esc)
• Abs/esc control module (in right front corner of engine compt)
• Batt volt
• C130-1
• Canister purge control valve (top center of engine)
• Comm area net hi
• Comm area net lo
• Computer data lines system
• Cpv ctrl
• Crankshaft position sensor (left rear of engine)
• Ec11
• Ec12
• Ect in
• Engine control relay
• Engine coolant temperature (ect) sensor & sender (left front of engine)
• Engine room (e/r) relay & fuse box (in left front corner of engine compt)
• Fuel pump motor
• Fuel pump relay
• Fuel tank pressure sensor (behind fuel tank)
• Fusible link (ecu) 30a
• G14 (below center of rear seat)
• Gnd
• Hot at all times
• Ign coil 1 (cyl 1,4)
• Ign coil 2 (cyl 2,3)
• Inj 1 ctrl
• Inj 4 ctrl
• Inj fuse 15a
• Instrument cluster system
• Joint connector e18
• Nca
• O2s heating
• O2s sig
• Oil ctrl valve
• On/start in
• Pnk
• Powertrain control module (pcm) (under left side of dash)
• Red
• Sensor gnd
• Sensor pwr
• Sensor sig
• Snsr fuse 10a
• Throttle position sensor (on throttle body assembly)
• Vehicle speed in
• Wheel sensor (w/o abs/tcs/esc)
• Wheel speed sens

2.0L, Engine Performance Wiring Diagram (2 of 4) for Hyundai Tucson Limited 2006

List of elements for 2.0L, Engine Performance Wiring Diagram (2 of 4) for Hyundai Tucson Limited 2006:

• (on top of engine) ignition coil
• Camshaft position sensor (on right front of engine)
• Canister close valve (behind fuel tank)
• Fuel injector 1 (top of intake manifold runners)
• Fuel injector 2 (top of intake manifold runners)
• Fuel injector 3 (top of intake manifold runners)
• Fuel injector 4 (top of intake manifold runners)
• Heated oxygen sensor (down) (top rear of engine)
• Heated oxygen sensor (up) (top rear of engine)
• Ignition coil 1
• Ignition coil 2
• Joint connector c123 (right of blower motor)
• Joint connector c135 (lower right side of dash)
• Knock sensor (on right side of engine block)
• Nca
• Oil control valve (left front of engine)
• Pnk
• Red
• To spark plugs

2.0L, Engine Performance Wiring Diagram (3 of 4) for Hyundai Tucson Limited 2006

List of elements for 2.0L, Engine Performance Wiring Diagram (3 of 4) for Hyundai Tucson Limited 2006:

• (below center console)
• (under left side of dash) g29
• 4wd ecm
• A/c mid switch
• A/c relay
• A/c sig in
• A/c sw on in
• A/t
• Air conditioning system
• C130-1
• Ccv ctrl
• Closing
• Cooling fans system
• Corner of engine compt)
• Data link connector (below left side of dash)
• Diagnosis k-line
• Ect sensor
• Engine ctrl rly
• Engine rpm sig
• Fan relay (high)
• Fan relay (low)
• Fuel consumption
• Fuel pump relay
• Fuse 10a
• Gnd
• Hot in on or start
• I/p junction box (under left side of dash, near kick panel)
• I/p-a
• I/p-c
• Iat sig
• Idle speed control actuator (top center of engine)
• Immobilizer ind
• Inj 2 ctrl
• Inj 3 ctrl
• Instrument cluster
• Joint connector c123 (right of blower motor)
• M/t
• M15-1
• M15-2
• M15-3
• Maf sensor (in intake duct)
• Maf sig
• Micro controller
• Mil ind
• Mil ind ctrl
• Multi- purpose check connector (right front
• Nca
• Oil lamp sensor
• Oil temperature sensor (left front of engine)
• Opening
• Pnk
• Powertrain control module (pcm) (under left side of dash)
• Red
• Sensor gnd
• Sensor sig
• Shield
• Sig
• Smatra (smart transponder antenna) (if equipped) (under left side of dash)

2.0L, Engine Performance Wiring Diagram (4 of 4) for Hyundai Tucson Limited 2006

List of elements for 2.0L, Engine Performance Wiring Diagram (4 of 4) for Hyundai Tucson Limited 2006:

• (under left side of dash)
• 2nd solenoid valve ctrl
• A/t control relay (under left side of dash)
• A/t pulse generator ``a" (on top of transaxle)
• A/t pulse generator ``b" (under air cleaner)
• A/t rly ctrl
• Atm mode switch
• Atm solenoid valve (top of transaxle)
• Auto cruise
• Battery volt
• C130-2
• Cruise control module (on right fender, behind strut tower)
• D input
• Dcc solenoid valve ctrl
• Down shift
• Fuse 10a
• Fuse 15a
• G28
• G28 (under left side of dash)
• Ground
• Hot at all times
• Hot in run or start
• I/p junction box (under left side of dash, near kick panel)
• I/p-a
• I/p-e
• Instrument cluster system (prnd ind)
• Joint connector c135 (lower right side of dash)
• Joint connector m08 (under left side of dash)
• Lr solenoid valve ctrl
• Manual
• N input
• Normal
• O/t
• Od solenoid valve ctrl
• Oil
• P input
• Pnk
• Powertrain control module (pcm) (under left side of dash)
• Pulse generator ``a"
• Pulse generator ``b"
• Pwm sig
• R input
• Red
• Select
• Select switch
• Sensor
• Sensor gnd
• Stop lamp switch (on brake pedal bracket)
• Stop sw input
• Temp
• Transaxle range switch (on top left side of transaxle)
• Ud solenoid valve ctrl
• Up shift

2.7L

2.7L, Engine Performance Wiring Diagram (1 of 3) for Hyundai Tucson Limited 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (1 of 3) for Hyundai Tucson Limited 2006:

• (below center console) 4wd ecm
• (below left side of dash) data link connector
• (in right front corner of engine compt)
• (right front corner of engine compt) multipurpose check connector
• (under left side of dash) immobilizer control module
• (under left side of dash) transmission control module (tcm)
• (w/ 4wd)
• (w/ esc)
• (w/o 4wd)
• (w/o esc)
• A/c mid sw
• A/c on signal
• A/c relay
• A/c signal in
• Abs/esc control module
• Air conditioning system
• Battery voltage
• C23-1
• C24-3
• C30-1
• C30-4
• C30-5
• Camshaft position sensor (top of engine)
• Ccv
• Cmp signal
• Comm high
• Comm low
• Computer data lines system
• Con- denser
• Cooling fans system
• Engine control module (ecm) (under left side of dash)
• Engine speed sig
• Fan high
• Fan low
• Ftp signal
• Fuel lvl gnd
• Fuel lvl signal
• Fuel pump relay
• Fuel tank pressure sensor (behind fuel tank)
• Fuse 10a
• Fuse 20a
• G24 (under left side of dash)
• G26 (front of right cylinder head)
• Ground
• Hot in on or start
• I/p junction box (under left side of dash, near kick panel)
• I/p-a
• I/p-c
• Ign coil
• Ignition coil (on top of engine)
• Immobilizer
• Instrument cluster
• Instrument cluster system
• Joint connector c23 (right of blower motor)
• K-line
• M15-1
• M15-3
• Memory pwr
• Micro controller
• Mil control
• Mil ind
• Nca
• On start input
• Pnk
• Red
• Sensor gnd
• Sensor pwr
• Speed sig
• To spark plugs
• W/ immobilizer
• W/o
• Wheel sensor (w/o abs/tcs/esc)
• Whl spd

2.7L, Engine Performance Wiring Diagram (2 of 3) for Hyundai Tucson Limited 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (2 of 3) for Hyundai Tucson Limited 2006:

• (top of fuel tank) fuel sender & fuel pump motor
• (top of left cylinder head)
• (top of right cylinder head)
• Canister close valve (behind fuel tank)
• Ec01
• Ec02
• Engine control relay
• Engine room (e/r) relay & fuse box (in left front corner of engine compt)
• Fuel injector
• Fuel pump motor
• Fuel pump relay
• Fusible link (ecu) 30a
• G14 (below center of rear seat)
• Hot at all times
• Inj fuse 15a
• Joint connector c35 (lower right side of dash)
• Joint connector e18
• Nca
• Red
• Snsr fuse 10a

2.7L, Engine Performance Wiring Diagram (3 of 3) for Hyundai Tucson Limited 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (3 of 3) for Hyundai Tucson Limited 2006:

• (front of engine) crankshaft position sensor
• (front of engine) power steering pressure switch
• (in intake duct) mass air flow sensor
• (left front of engine) engine coolant temperature (ect) sensor & sender
• (on throttle body assembly) throttle position sensor
• (pins 11 thru 16: not used)
• (pins 2 thru 6: not used)
• (pins 2 thru 7: not used)
• (pins 8 thru 12: not used)
• (top front of engine) air temperature sensor
• (top of engine) knock sensor 1
• (top of engine) knock sensor 2
• Ats signal
• C30-2
• C30-3
• Canister purge control valve (top center of engine)
• Ckp signal
• Closing
• Ect signal
• Engine control module (ecm) (under left side of dash)
• Engine ctrl relay
• Fuel consumption
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Heated oxygen sensor (b1/s1) (top of engine)
• Heated oxygen sensor (b1/s2) (right front of engine)
• Heated oxygen sensor (b2/s1) (in exhaust manifold)
• Heated oxygen sensor (b2/s2) (top front of engine)
• Ho2s b1/s1
• Ho2s b1/s1 htr
• Ho2s b1/s2
• Ho2s b1/s2 htr
• Ho2s b2/s1
• Ho2s b2/s1 htr
• Ho2s b2/s2
• Ho2s b2/s2 htr
• Idle speed control actuator (top center of engine)
• Instrument cluster system
• Joint connector c23 (right of blower motor)
• Knock sensor 1
• Knock sensor 2
• Maf signal
• Nca
• Opening
• Pcsv ctrl
• Pnk
• Pwr steer sw in
• Red
• Sensor gnd
• Sensor pwr
• Shield gnd
• Tps signal
• Variable intake manifold control motor 1 (top rear of engine)
• Variable intake manifold control motor 2 (top front of engine)
• Vis sol 1
• Vis sol 2