ENGINE PERFORMANCE – Mercury Milan Hybrid 2010 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.5L

2.5L, Engine Performance Wiring Diagram, Except Hybrid (1 of 5) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Except Hybrid (1 of 5) for Mercury Milan Hybrid 2010:

• 10a
• 15a
• 40a
• A/c cycling pressure transducer
• Accelerator pedal position (app) sensor (left side of dash)
• Accr
• Acpt
• Air conditioning system
• App1
• App1rtn
• App1vref
• App2
• App2rtn
• App2vref
• Battery junction box (bjb) (left side of engine compt)
• Bpp
• Bps
• C175b
• Canv
• Case gnd
• Cbb46
• Cbk01
• Cbk02
• Cbp44
• Ccb08
• Cdb08
• Cdc10
• Cdc12
• Cdc15
• Cdc35
• Ce114
• Ce302
• Ce336
• Ces09
• Cet42
• Cet43
• Ch302
• Computer data lines system
• Cooling fans system
• Cruise control system
• Exterior lights system
• Fcv
• Feps
• Floor shifter
• Fpc
• Fpm
• Ftpt
• Ftptref
• Fuel tank pressure (ftp) sensor (top of fuel tank)
• Fuse
• G102 (left rear of engine compt)
• Gd120
• Gencom
• Genmon
• Hot at all times
• Hs can+
• Hs can-
• Iat
• Ign
• Kapwr
• Le136
• Le137
• Le230
• Le424
• Maf
• Mafrtn
• Pcm power relay
• Pcmrc
• Power gnd
• Powertrain control module (pcm) (left rear of engine compt)
• Re136
• Re137
• Re325
• Re407
• Res08
• S119
• S125
• S143
• Sbb23
• Sccs
• Sccsrtn
• Shift interlock system
• Sigrtnc
• Smc
• Smcs
• Smr
• Starting/charging system
• Tip +
• Tip -
• Vce03
• Vdb04
• Vdb05
• Ve225
• Ve518
• Ve701
• Ve702
• Ve740
• Ve808
• Ve922
• Ves10
• Vh433
• Vmc05
• Vpwr
• Vpwrtr-pn
• Vref
• Vsout
• Wiper/washer system

2.5L, Engine Performance Wiring Diagram, Except Hybrid (2 of 5) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Except Hybrid (2 of 5) for Mercury Milan Hybrid 2010:

• (rear of vehicle chassis) evap canister vent control solenoid
• 15a
• 30a
• 6f transmission
• Battery junction box (bjb) (left side of engine compt)
• Brake pedal position switch (left side of dash)
• C168a
• C168b
• C2280e
• Cblr/c456 vfs
• Cet05
• Cet06
• Cet07
• Cet08
• Cet09
• Cet10
• Cet18
• Cet25
• Fuel pump diode
• Fuel pump relay
• Fuse
• G102 (left rear of engine compt)
• G103
• Hot at all times
• Hot in run or start
• Le111
• Lpc vfs
• M/t
• Mass air flow/intake air temperature (maf/iat) sensor (left front of engine compt)
• Oss
• Re406
• Ret24
• S121
• S137 (dash panel to headlamp junction harness, near breakout to battery junction box)
• S140 (starter motor relay and battery ground harness, near breakout to battery junction box (bjb))
• S146
• S147 (battery cable wire harness, near breakout to automatic transmission)
• Smart junction box (sjb) (left side of dash)
• Sol pwr
• Ssa cb1234 vfs
• Ssb c35r vfs
• Ssc cb26 vfs
• Sse on/off sol
• Tcc vfs
• Tft
• Tft sig rtn
• Trs
• Trs/oss gnd
• Trs/oss pwr
• Tss
• Tss gnd
• Tss pwr
• Vet26
• Vet27
• Vet32
• Vet33

2.5L, Engine Performance Wiring Diagram, Except Hybrid (3 of 5) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Except Hybrid (3 of 5) for Mercury Milan Hybrid 2010:

• (dash panel to headlamp junction harness, near breakout to battery box) s182
• (front of engine) knock sensor
• (left rear of engine) manifold absolute pressure (map) sensor
• (left rear side of vehicle) fuel pump control module
• (top of fuel tank) fuel tank unit
• C175t
• Ce226
• Ce233
• Ce515
• Ce608
• Ce903
• Ce904
• Cet05
• Cet06
• Cet07
• Cet08
• Cet09
• Cet10
• Cet18
• Cet25
• Cet34
• Cls28
• Computer data lines system
• Cpp-bt
• Cpp-tt
• Cr167
• Cruise control system
• Ens
• Exterior lights system
• Fpc
• Fpm
• Fppwr
• Fprtn
• Fuel sender return
• Fuel sender signal
• G403 (above left rear wheel well)
• Gd151
• Gnd
• Heated oxygen sensor (ho2s) 12 (exhaust manifold)
• Ho2s-12
• Hs can+
• Hs can-
• Htr-12
• Ifs input
• Instrument cluster (ic)
• Lcp vfs
• Le111
• Oss
• Powertrain control module (pcm) (left rear of engine compt)
• Re226
• Re406
• Ret24
• Rlc
• Rmc32
• Shift interlock system
• Sigrtn
• Sol pwr
• Ssa cb1234 vfs
• Ssb c35r vfs
• Ssc cb26 vfs
• Ssd cblr/c456 vfs
• Sse on/off sol
• Tcc vfs
• Tcs
• Tft
• Tr gnd
• Trs
• Trs/oss/tss vpwr
• Tss
• Ve225
• Ve518
• Ve731
• Ve806
• Vet26
• Vet27
• Vet32
• Vet33
• Vmc11

2.5L, Engine Performance Wiring Diagram, Except Hybrid (4 of 5) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Except Hybrid (4 of 5) for Mercury Milan Hybrid 2010:

• (engine control sensor and fuel charge harness, near breakout to fuel injector 2) s135
• (rear of intake manifold) evaporative emission (evap) canister purge valve
• (top center of cylinder head) cylinder head temperature (cht) sensor
• (top rear of engine) egr stepper motor
• Coil
• Coil on plug (cop) 1 (top front of valve cover)
• Coil on plug (cop) 2 (top center of valve cover)
• Coil on plug (cop) 3 (top center of valve cover)
• Coil on plug (cop) 4 (top rear of valve cover)
• Electronic throttle control (etc) motor (on throttle body)
• Ignition transformer capacitor (top rear of valve cover)
• Output shaft speed (oss) sensor (m/t) (top of transmission)
• S181 (engine control sensor and fuel charge wire harness, near breakout to c133)

2.5L, Engine Performance Wiring Diagram, Except Hybrid (5 of 5) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Except Hybrid (5 of 5) for Mercury Milan Hybrid 2010:

• (engine control sensor and fuel charge harness, near breakout to fuel injector 1)
• (top of intake manifold) fuel injectors
• (top rear of engine) camshaft position sensor
• C175e
• Ce101
• Ce102
• Ce103
• Ce104
• Ce113
• Ce205
• Ce206
• Ce207
• Ce208
• Ce235
• Ce303
• Ce304
• Ce305
• Ce306
• Ce412
• Ce422
• Ce426
• Cht
• Cid1
• Ckp shld
• Ckp+
• Ckp-
• Cop-a
• Cop-b
• Cop-c
• Cop-d
• Crankshaft position sensor (lower right front of engine)
• De135
• Early production
• Eegr1
• Eegr2
• Eegr3
• Eegr4
• Etcref
• Etcrtn
• Heated oxygen sensor (ho2s) 11 (exhaust manifold)
• Heated oxygen sensor (ho2s) 11 (late production) (exhaust manifold)
• Ho2s-11
• Htr-11
• Inj1
• Inj2
• Inj3
• Inj4
• Ks1+
• Ks1-
• Late production
• Le111
• Le134
• Le423
• Le448
• Le451
• Le452
• Map
• Powertrain control module (pcm) (left rear of engine compt)
• Re134
• Re135
• Re323
• Re405
• S138 (engine control sensor and fuel charge harness, near breakout to fuel injector 1)
• Sigrtne
• Tacm+
• Tacm-
• Tp1 ns
• Tp2 ps
• Uo2s
• Uo2sgref
• Uo2spc
• Uo2spct
• Variable camshaft timing (vct) valve
• Vct
• Ve706
• Ve711
• Ve712
• Ve735
• Ve801
• Ve803
• Ve818
• Ve819
• Ve826
• Vmv-cc/evmv
• Vref

2.5L, Engine Performance Wiring Diagram, Hybrid (1 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (1 of 8) for Mercury Milan Hybrid 2010:

• (dash panel to headlamp junction harness, near breakout to battery junction box) s157
• (under rear seat) evap canister vent control solenoid
• (under rear seat) fuel vapor vent valve
• A/c pressure transducer (right rear of engine compt)
• Accelerator pedal position (app) sensor (on accelerator pedal bracket)
• Accr
• Aclpcs
• Acpsw
• Acpt
• Air conditioning system
• App1
• App2
• Boo
• Bps
• C175b
• C2280b
• C2280d
• C2280e
• Canv
• Cbb40
• Cbk01
• Cbp28
• Cbp44
• Ccb08
• Cdb08
• Ce114
• Ce302
• Ce420
• Cec01
• Cec02
• Cec03
• Ces09
• Cgnd
• Ch302
• Ch421
• Ch425
• Computer data lines system
• Cooling fans system
• Cruise control system
• Cto
• Ectref2
• Ectrtn2
• Etcref1
• Etcrtn1
• Exterior lights system
• Fc v
• Fc1
• Fc2
• Feps
• Fpc
• Fpm
• Ftp
• Ftpref
• Fuel tank pressure sensor (top of fuel tank)
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fvvv
• G102 (left rear of engine compt)
• Gd120
• Gnd
• Hot at all times
• Hot in start or run
• Hs can+
• Hs can-
• Iat
• Ignition switch
• Injpwrm
• Isp-r
• Isp-r/s
• Kapwr
• Le136
• Le137
• Le230
• Le424
• Lock
• Maf
• Mafrtn
• Off
• Pcmrc
• Powertrain control module (pcm) (left rear of engine compt)
• Re136
• Re137
• Re325
• Re407
• Res08
• Run/ run/ acc
• S121
• S195 (dash panel to headlamp junction harness, near breakout to bjb)
• S230
• Sbb23
• Sccs
• Sccsrtn
• Sigrtn
• Smart junction box (sjb) (left side of dash)
• Start
• Tgac
• Tmac
• Vdb04
• Vdb05
• Ve225
• Ve518
• Ve701
• Ve702
• Ve740
• Ve808
• Ve922
• Ves10
• Vh433
• Vmc02
• Vmc05
• Vpwr
• Vref
• Vsout
• Vyt05
• Vyt06
• Wiper/washer system

2.5L, Engine Performance Wiring Diagram, Hybrid (2 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (2 of 8) for Mercury Milan Hybrid 2010:

• (body main harness, near breakout to g401)
• (body main harness, near breakout to left rear wheel speed sensor) s461
• (dash panel to headlamp junction harness, near breakout to battery junction box)
• (not used) c133
• 10a
• 15a
• 20a
• 30a
• 40a
• Battery junction box (bjb) (left side of engine compt)
• Brake pedal position switch (left side of dash)
• C310a
• Cbb48
• Ce226
• Computer data lines system
• Cr167
• Ens
• Fpc
• Fpm
• Fppwr
• Fprtn
• Fuel pump control module (left rear side of vehicle)
• Fuel pump diode
• Fuel sender return
• Fuel sender signal
• Fuel tank unit (top of fuel tank)
• Fuse
• G102 (left rear of engine compt)
• G104 (right front of engine compt)
• G403 (above left rear wheel well)
• Gd151
• Gnd
• Heater pump relay
• Hot at all times
• Ifs vpwr
• Injector relay
• Instrument cluster (ic)
• M/e coolant pump relay
• Mass air flow/intake air temperature (maf/iat) sensor (on air cleaner inlet duct)
• Ms can+
• Ms can-
• Nca
• Re226
• Restraints control module (rcm) (under center console)
• Reverse lamp relay
• S119
• S137
• S140
• S144 (dash panel to headlamp junction harness, near breakout to battery junction box)
• S462
• S463
• S464 (body main harness, near breakout to left rear wheel speed sensor)
• Ve225
• Ve518

2.5L, Engine Performance Wiring Diagram, Hybrid (3 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (3 of 8) for Mercury Milan Hybrid 2010:

• (dash panel to headlamp junction harness, near breakout to battery junction box)
• (dash panel to headlamp junction harness, near breakout to bjb)
• Air conditioning system
• Auxiliary relay box (left front of engine compt)
• C1458a
• C1458b
• C1458c
• C175t
• Cbb39
• Ce233
• Ce318
• Ch307
• Cls28
• Computer data lines system
• Cto
• Cyb03
• Cyb04
• Cyb16
• Cyb17
• Cyt08
• Dual battery fuse assembly (front of battery)
• Exterior lights system
• G103 (left front of engine compt)
• Gd121
• Gmsdn
• Gnd
• Ho2s12
• Hot at all times
• Hpcr
• Hs can +
• Hs can -
• Htr12
• Hv+
• Hv-
• Hvi+
• Hyi-
• Hyt03
• Hyt04
• Isdn1
• Let56
• Let57
• Mecp
• Mect
• Midi fuse (pink) 200a c1620b
• Msdn
• Pcm power relay
• Powertrain control module (pcm) (left rear of engine compt)
• Re406
• Red
• Ret56
• Ret57
• Rlc
• S143
• S193
• S194
• Sbb23
• Sigrtn
• Tgac
• Tmac
• Tr-a1 ref
• Tr-a1 rtn
• Tr-a1 sig
• Tr-a2 ref
• Tr-a2 rtn
• Tr-a2 sig
• Transaxle control module (on transaxle)
• Transmission range (tr) sensor (on transaxle)
• Vbatt
• Vdb04
• Vdb05
• Ve731
• Ve810
• Vet56
• Vet57
• Vmc02
• Vpwr
• Vyt05
• Vyt06

2.5L, Engine Performance Wiring Diagram, Hybrid (4 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (4 of 8) for Mercury Milan Hybrid 2010:

• (exhaust manifold) heated oxygen sensor (ho2s) 12
• (left front of engine) air conditioning compressor module (accm)
• (on transaxle assembly)
• (right rear of engine compt) anti-lock brake system (abs) module
• (right rear of engine compt) high voltage junction box
• Battery energy control module (becm) (behind left side of rear seat)
• Becm in+
• Becm in-
• C1457a
• C1457b
• C1457c
• C1457d
• C1469a
• C1469b
• C4237b
• Cbk03
• Ch401
• Computer data lines system
• Cont crl posh
• Cont crl posl
• Cyb03
• Cyd01
• Cyd02
• Dc/dc converter module
• Fvi+
• Fvi-
• G105
• Gd108
• Gnd
• Hs can+
• Hs can-
• Hv+
• Hv-
• Hvdc+
• Hvdc-
• Hvi+
• Hvi-
• Hyt03
• Hyt04
• Instr can h
• Instr can l
• J1-a39
• J1-a41
• J1-a44
• J1-a47
• J1-a55
• J1-a56
• J1-a58
• J1-a59
• J1-a61
• J1-a62
• J1a02
• J1a07
• J1a11
• J1a16
• J1a17
• J1a18
• J1a51
• J1a65
• J1a66
• J1a69
• J1a70
• Nca
• Pack hs can l
• Pack hs canl
• Prech ctlh
• Prech ctll
• Pwr gnd
• Red
• Sdc02
• Sig rtn
• Temp inlet
• Temp inlet rtn
• Vbatt
• Vdb04
• Vdb05
• Vpwr

2.5L, Engine Performance Wiring Diagram, Hybrid (5 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (5 of 8) for Mercury Milan Hybrid 2010:

• 100a
• Battery energy control module (becm) (behind left side of rear seat)
• Battery junction box (bjb) (left side of engine compt)
• Bussed electrical center (behind rear seat)
• C4236a
• C4236b
• C4236c
• C4236d
• C4236e
• C4237a
• Cbb48
• Computer data lines system
• Cr167
• Crs
• Cyb16
• Cyb17
• Ens
• Fan1 fbb
• Fan1 pwmb
• Fuse 10a
• Fuse 40a
• G300 (under driver's seat)
• Gd126
• Gnd
• High voltage low amperage fuse
• High voltage traction battery
• High voltage traction battery temperature sensor (behind rear seat)
• Hot at all times
• Hs can+
• Hs can-
• Hvi+
• Hvi-
• Isdn1
• Isdn2
• Nca
• Pnk
• Positive pack relay 60a
• Psr
• Red
• S460
• Sbb17
• Service disconnect
• Vdb04
• Vdb05
• Vyb18
• Vyb19

2.5L, Engine Performance Wiring Diagram, Hybrid (6 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (6 of 8) for Mercury Milan Hybrid 2010:

• (behind left side of rear seat) battery pack sensor module (bpsm)
• Battery pack sensor module (bpsm) (behind left side of rear seat)
• C4238a
• C4238b
• Cs aout 1
• Cs aout 2
• Cs gnd
• Cs vref
• Instr can h
• Instr can l
• J1a02
• J1a07
• J1a16
• J1a17
• J1a18
• J1a51
• J1a65
• J1a66
• J1a69
• J1a70
• J2a
• J2a16
• J2a36
• J2a67
• J2a70
• J2b1
• J2b12
• J2b13
• J2b14
• J2b2
• J2b24
• J2b25
• J2b26
• J2b27
• J2b3
• J2b35
• J2b36
• J2b37
• J2b38
• Jqa11
• Ldl
• Nca
• Pack hs can h
• Pnk
• Pwr gnd
• Red
• Sig rtn
• Tsl 1
• Tsl 2
• Tsl 3
• Tsl 9
• Tsl rtn 1
• Tsl rtn 10
• Tsl rtn 2
• Tsl rtn 3
• Tsl rtn 9
• Tsl10
• V cont pos
• V sd

2.5L, Engine Performance Wiring Diagram, Hybrid (7 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (7 of 8) for Mercury Milan Hybrid 2010:

• (center of rear floor pan) g401
• (dash panel to headlamp junction harness, near breakout to c145)
• (dash panel to headlamp junction harness, near breakout to pcm)
• (engine control sensor and fuel charge harness, near breakout to c145) s180
• (exhaust manifold) heated oxygen sensor (ho2s) 11
• (rear of intake manifold) evaporative emission (evap) canister purge valve
• (top center of cylinder head) cylinder head temperature sensor
• (top rear of engine) egr stepper motor
• Coil
• Crankshaft position sensor (lower right front of engine block)
• Fbb
• Gnd
• High voltage traction battery
• Knock sensor (front of engine)
• Motor electronics coolant temperature (mect) sensor (on transaxle)
• Nca
• Pwmb
• S117
• S118
• S138 (engine control sensor and fuel charge harness, near breakout to fuel injector 1)
• S185 (engine control sensor and fuel charge harness, near breakout to c145)
• Traction battery control cooling fan (behind left side of rear seat)
• Tsl 1
• Tsl 2
• Tsl 3
• Tsl 9
• Tsl rtn 1
• Tsl rtn 10
• Tsl rtn 2
• Tsl rtn 3
• Tsl rtn 9
• Tsl10

2.5L, Engine Performance Wiring Diagram, Hybrid (8 of 8) for Mercury Milan Hybrid 2010

List of elements for 2.5L, Engine Performance Wiring Diagram, Hybrid (8 of 8) for Mercury Milan Hybrid 2010:

• (engine control sensor and fuel charge harness, near breakout to fuel injector 4)
• (engine control sensor and fuel charge harness, near breakout to fuel injector)
• (top of intake manifold) fuel injectors
• (top rear of engine) camshaft position sensor
• (top rear of valve cover)
• C175e
• Cd1a
• Cd2d
• Cd3b
• Cd4c
• Ce101
• Ce102
• Ce103
• Ce104
• Ce113
• Ce205
• Ce206
• Ce207
• Ce208
• Ce235
• Ce303
• Ce304
• Ce305
• Ce306
• Ce412
• Ce422
• Ce426
• Cht
• Ckp+
• Ckp-
• Cmp
• Coil on plug (cop) 1
• Coil on plug (cop) 2
• Coil on plug (cop) 3
• Coil on plug (cop) 4
• De135
• Ecref
• Egrmc1
• Egrmc2
• Egrmc3
• Egrmc4
• Electronic throttle control (etc) motor (on throttle body)
• Etctrn
• Evapcp
• Ignition transformer capacitor 1 (top rear of valve cover)
• Inj1a
• Inj2d
• Inj3b
• Inj4c
• Ks1+
• Ks1-
• Le111
• Le134
• Le423
• Le448
• Le451
• Le452
• Manifold absolute pressure (map) sensor (left rear of engine)
• Map
• Powertrain control module (pcm) (left rear of engine compt)
• Re134
• Re135
• Re323
• Re405
• S135
• S139
• Shldrtn
• Sigrtne
• Tacm+
• Tacm-
• Tp1 ns
• Tp2 ps
• Uo2s
• Uo2sgref
• Uo2shtr
• Uo2spc
• Uo2spct
• Variable camshaft timing (vct) solenoid (top front of valve cover)
• Vbpwr
• Vct
• Ve706
• Ve711
• Ve712
• Ve801
• Ve803
• Ve818
• Ve819
• Ve826
• Vref

3.0L

3.0L, Engine Performance Wiring Diagram (1 of 5) for Mercury Milan Hybrid 2010

List of elements for 3.0L, Engine Performance Wiring Diagram (1 of 5) for Mercury Milan Hybrid 2010:

• (dash panel to headlamp junction harness, near breakout to battery junction box) s144
• 10a
• 15a
• 40a
• A/c clutch relay
• A/c pressure transducer (right rear of engine compt)
• Accelerator pedal position (app) sensor (left side of dash)
• Accr
• Acpt
• Air conditioning system
• App1
• App1vref
• App2
• App2vref
• Appsrtn1
• Appsrtn2
• Battery junction box (bjb) (left side of engine compt)
• Bpp
• Bps
• C175b
• Can+
• Can-
• Canvnt
• Cbb46
• Cbk01
• Cbp44
• Ccb08
• Cdb08
• Cdc10
• Cdc12
• Cdc15
• Cdc35
• Ce114
• Ce302
• Ce336
• Ces09
• Cet42
• Cet43
• Ch302
• Computer data lines system
• Cooling fans system
• Cruise control system
• Exterior lights system
• Fcv
• Feps
• Fpc
• Fpm
• Ftpt
• Ftptref
• Fuel tank pressure (ftp) sensor (top of fuel tank)
• Fuse
• G102 (left rear of engine compt)
• Gd120
• Gencom
• Genmon
• Gnd
• Hot at all times
• Iat
• Ign
• Kapwr
• Le136
• Le137
• Le230
• Le424
• Maf
• Mafrtn
• Pcm power relay
• Pcmrc
• Powertrain control module (pcm) (left rear of engine compt)
• Re136
• Re137
• Re325
• Re407
• Res08
• Reverse lamp relay
• S119
• S125
• S143
• S157
• Sbb23
• Sccs
• Sccsrtn
• Shift interlock system
• Sigrtnc
• Smc
• Smcs
• Smr
• Starting/charging system
• Tip +
• Tip -
• Vdb04
• Vdb05
• Ve225
• Ve518
• Ve701
• Ve702
• Ve740
• Ve808
• Ve922
• Vec03
• Ves10
• Vh433
• Vmc05
• Vpwr
• Vref
• Vsout
• Wiper/washer system

3.0L, Engine Performance Wiring Diagram (2 of 5) for Mercury Milan Hybrid 2010

List of elements for 3.0L, Engine Performance Wiring Diagram (2 of 5) for Mercury Milan Hybrid 2010:

• (battery cable wire harness, near breakout to automatic transmission)
• 10a
• 15a
• 30a
• 6f transmission
• Battery junction box (bjb) (left side of engine compt)
• Brake pedal position switch (left side of dash)
• C168a
• C168b
• C2280e
• Cblr/c456 vfs
• Cet05
• Cet06
• Cet07
• Cet08
• Cet09
• Cet10
• Cet18
• Cet25
• Evap canister vent control solenoid
• Fuel pump diode
• Fuel pump relay
• Fuse
• G102 (left rear of engine compt)
• G103 (left rear of engine compt)
• Hot at all times
• Hot in run or start
• Le111
• Lpc vfs
• Mass air flow/intake air temperature (maf/iat) sensor (left front of engine compt)
• Oss
• Re406
• Ret24
• S121
• S130 (dash panel to headlamp junction harness, near breakout to battery junction box (bjb))
• S137 (dash panel to headlamp junction harness, near breakout to battery junction box)
• S140
• S146
• S147
• Smart junction box (sjb) (left side of dash)
• Sol pwr
• Ssa cb1234 vfs
• Ssb c35r vfs
• Ssc cb26 vfs
• Sse on/off sol
• Tcc vfs
• Tft
• Tft sig rtn
• Trs
• Trs/oss gnd
• Trs/oss pwr
• Tss
• Tss gnd
• Tss pwr
• Vet26
• Vet27
• Vet32
• Vet33

3.0L, Engine Performance Wiring Diagram (3 of 5) for Mercury Milan Hybrid 2010

List of elements for 3.0L, Engine Performance Wiring Diagram (3 of 5) for Mercury Milan Hybrid 2010:

• (left rear side of vehicle) fuel pump control module
• (top of fuel tank) fuel tank unit
• (top right rear of engine) knock sensor 1
• (under center console) restraints control module (rcm)
• C175t
• C310a
• Ce226
• Ce233
• Ce234
• Ce608
• Cet05
• Cet06
• Cet07
• Cet08
• Cet09
• Cet10
• Cet18
• Cet25
• Cet34
• Cet42
• Cet43
• Cls28
• Computer data lines system
• Cr167
• Ens
• Exterior lights system
• Floor shifter
• Fpc
• Fpm
• Fppwr
• Fprtn
• Fuel sender return
• Fuel sender signal
• G403 (above left rear wheel well)
• Gd151
• Gnd
• Heated oxygen sensor (ho2s) 13 (w/ low emission vehicles) (exhaust system)
• Ho2s-12
• Ho2s-13
• Hs can+
• Hs can-
• Htr-12
• Htr-13
• Ifs input
• Instrument cluster (ic)
• Lcp vfs
• Le111
• Nca
• Oss
• Powertrain control module (pcm) (left rear of engine compt)
• Re226
• Re406
• Ret24
• Rlc
• S148 (battery cable wire harness, near breakout to automatic transmission)
• S251
• Sigrtn
• Sol pwr
• Ssa cb1234 vfs
• Ssb c35r vfs
• Ssc cb26 vfs
• Ssd cblr/c456 vfs
• Sse on/off sol
• Tcc vfs
• Tcs
• Tft
• Tip+
• Tip-
• Tr gnd
• Transmission control switch
• Trs
• Trs/oss/ vpwr
• Tss
• Ve225
• Ve518
• Ve731
• Ve733
• Vet26
• Vet27
• Vet32
• Vet33

3.0L, Engine Performance Wiring Diagram (4 of 5) for Mercury Milan Hybrid 2010

List of elements for 3.0L, Engine Performance Wiring Diagram (4 of 5) for Mercury Milan Hybrid 2010:

• (engine control sensor and fuel charge harness, near breakout to coil on plug 3) s135
• (engine control sensor and fuel charge harness, near breakout to fuel injector 4) s136
• (in front of throttle body) evaporative emission (evap) canister purge valve
• (right exhaust manifold) heated oxygen sensor (ho2s) 12
• (right rear of intake manifold) egr stepper motor
• (top rear of engine) manifold absolute pressure (map) sensor
• (top rear of right cylinder head) heated positive crankcase ventilation (pcv) valve
• Coil
• Coil on plug (cop) 1 (top front of valve cover)
• Coil on plug (cop) 2 (top of right valve cover)
• Coil on plug (cop) 3 (top rear of right valve cover)
• Coil on plug (cop) 4 (top of left valve cover)
• Coil on plug (cop) 5 (top of left valve cover)
• Coil on plug (cop) 6 (top rear of valve cover)
• Cylinder head temperature (cht) sensor
• Electronic throttle control (etc) motor (on throttle body)
• Ignition transformer capacitor (top front of left valve cover)
• S181

3.0L, Engine Performance Wiring Diagram (5 of 5) for Mercury Milan Hybrid 2010

List of elements for 3.0L, Engine Performance Wiring Diagram (5 of 5) for Mercury Milan Hybrid 2010:

• (engine control sensor & fuel charge harness, near breakout to coil on plug 1) s153
• (left front of engine) camshaft position sensor 2
• (left side of intake manifold) fuel injectors
• (right front of engine) camshaft position sensor 1
• (top left of intake manifold) fuel injector
• (top right of intake manifold) fuel injectors
• C175e
• Ce101
• Ce102
• Ce103
• Ce104
• Ce113
• Ce205
• Ce206
• Ce207
• Ce208
• Ce209
• Ce210
• Ce235
• Ce236
• Ce303
• Ce304
• Ce305
• Ce306
• Ce307
• Ce308
• Ce321
• Ce412
• Ce421
• Ce422
• Ce426
• Cht
• Cid 2
• Cid1
• Ckp shld
• Ckp+
• Ckp-
• Cop-a
• Cop-b
• Cop-c
• Cop-d
• Cop-e
• Cop-f
• Crankshaft position sensor (lower right front of engine block)
• De135
• Eegr1
• Eegr2
• Eegr3
• Eegr4
• Etcref
• Etcrtn
• Heated oxygen sensor (ho2s) 11 (right exhaust manifold)
• Heated oxygen sensor (ho2s) 21 (left exhaust manifold)
• Inj1
• Inj2
• Inj3
• Inj4
• Inj5
• Inj6
• Knock sensor 2 (rear of engine near water outlet)
• Ks1+
• Ks1-
• Ks2+
• Ks2-
• Le111
• Le134
• Le423
• Le448
• Le449
• Le450
• Le451
• Le452
• Le453
• Map
• Pcv
• Powertrain control module (pcm) (left rear of engine compt)
• Re134
• Re135
• Re323
• Re324
• Re405
• S138 (engine control sensor & fuel charge harness, near breakout to coil on plug 1)
• Sigrtne
• Tacm+
• Tacm-
• Tp1 ns
• Tp2 ps
• Uo2s
• Uo2sgref
• Uo2shtr
• Uo2spc
• Uo2spct
• Variable camshaft timing (vct) solenoid 1 (top front of right valve cover)
• Variable camshaft timing (vct) solenoid 2 (top front of left valve cover)
• Vct1
• Vct2
• Ve706
• Ve707
• Ve711
• Ve712
• Ve801
• Ve802
• Ve803
• Ve818
• Ve819
• Ve826
• Ve827
• Vmv-cc/evmv
• Vref