GROUND DISTRIBUTION – Chevrolet Cutaway G3500 1999 – SYSTEM WIRING DIAGRAMS

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 3) for Chevrolet Cutaway G3500 1999

List of elements for Ground Distribution Wiring Diagram (1 of 3) for Chevrolet Cutaway G3500 1999:

• (forward lamp harness, approx 19 cm into left forward lamp breakout)
• (forward lamp harness, approx 22 cm into right forward lamp breakout)
• (i/p harness, approx 7 cm into vss buffer breakout)
• (lower i/p harness, approx 7 cm into i/p compartment lamp breakout)
• (not used) e13
• (upfitter provision)
• (w/ upfitter provisions)
• A/t shift lock solenoid
• Ashtray lamp
• Auxiliary battery (diesel)
• Auxiliary power outlet
• Battery
• C210
• Cigarette lighter
• Convenience center
• Convenience center (left side of dash)
• Data link connector
• Daytime running lamp (drl) control module
• G100 (left front of engine compt)
• G100 (left side
• G100 (left side of engine compartment)
• G101 (right front
• G101 (right front of engine compt)
• G113 (middle of left frame rail)
• G116 (near brake master cylinder)
• G118 (right lower front of engine)
• G119 (right frame rail, near front of engine)
• G200 (behind left kick panel)
• G200 (left kick panel)
• Headlamp switch
• Heater and a/c controller
• I/p compartment lamp
• I/p relay center
• Ignition switch
• Illuminated entry module
• Instrument cluster
• Left front park and turn signal lamp (inner) (w/ composite headlamps)
• Left front park and turn signal lamp (outer) (w/ composite headlamps)
• Left front park and turn signal lamp (w/ sealed beam headlamps)
• Left front side marker lamp
• Left headlamp (w/ sealed beam headlamps)
• Left high beam headlamp (w/ composite headlamps)
• Left low beam headlamp (w/ composite headlamps)
• Left power seat switch
• Left sun shade mirror lamp
• Low engine coolant level indicator module (diesel)
• Low engine coolant level indicator sensor (diesel)
• Multi- function alarm module
• Nca
• Of engine compt)
• P/b booster fluid flow switch
• Power antenna assembly
• Power door lock control module
• Power door lock relay
• Radio
• Remote control door lock receiver
• Right front park and turn signal lamp (inner) (w/ composite headlamps)
• Right front park and turn signal lamp (outer) (w/ composite headlamps)
• Right front park and turn signal lamp (w/ sealed beam headlamps)
• Right front side marker lamp
• Right headlamp (w/ sealed beam headlamps)
• Right high beam headlamp (w/ composite headlamps)
• Right low beam headlamp (w/ composite headlamps)
• Right sun shade mirror lamp
• S201 (i/p harness, approx 4 cm from park brake warning switch breakout)
• S202
• S204 (sun shade harness, approx 7 cm from right sun shade breakout)
• S205
• S206 (upfitter provision-crossbody harness, approx 24 cm from power door lock relay breakout, others-crossbody harness, approx 4 cm from breakout to connector near left side of dash)
• Seat belt switch
• Side door jamb switch (w/ upfitter provisions)
• Steering column ground
• Temperature valve actuator motor
• To s500 or left front door jamb switch (diagram 2 of 3)
• To s601 or right front door jamb switch (diagram 2 of 3)
• Turn/ hazard lamp flasher
• Upfitter provisions relay
• W/ upfitter provisions
• W/o keyless entry
• Windshield washer pump motor
• Windshield wiper motor

Ground Distribution Wiring Diagram (2 of 3) for Chevrolet Cutaway G3500 1999

List of elements for Ground Distribution Wiring Diagram (2 of 3) for Chevrolet Cutaway G3500 1999:

• (4.3l-engine harness, approx 20 cm from knock sensor breakout, 5.0l or 5.7l-engine harness, approx 10 cm from g117 breakout, 7.4l-engine harness, approx 14 cm from fuel injector breakout)
• (4.3l-engine harness, approx 4 cm from fuel injector breakout, 5.0l or 5.7l-approx 4 cm from a/c comp clutch breakout, 7.4l-engine harness, approx 8 cm from ect sensor breakout)
• (5.0l, 5.7l) g110 (4.3l) g119 (7.4l) g117
• (front of engine)
• (front of engine, near thermostat housing)
• (i/p harness, approx 40 cm from bulkhead connector)
• (left front door harness, approx 7 cm from power window switch breakout)
• (left front of engine) (right front of engine) (right rear of engine)
• (o2s jumper harness, 15-77 cm from 6-pin connector on right frame rail)
• (right front door harness, approx 7 cm from power window switch breakout)
• (underhood lamp harness, approx 4 cm from breakout to connector near blower motor)
• 4.3l
• 4.3l, gvw over 8500 lbs., federal emissions
• 5.0/ 5.7l
• 5.0l, 5.7l, 7.4l
• 7.4l
• 7.4l only
• 7.4l/ 4.3l
• A/c compressor clutch
• A/c low pressure cutout switch
• B13
• Base
• Blower motor resistor/ relay
• Brake pressure differential switch
• Cruise control module
• Data link connector (dlc)
• Diode
• Electronic brake control module (ebcm)
• Except 7.4l
• From s206 (diagram 1 of 3)
• Fuel pump and sender
• Fuel pump relay
• G125
• G200 (left kick panel)
• Gasoline engines
• Heated oxygen sensor (ho2s) bank 1 sensor 1
• Heated oxygen sensor (ho2s) bank 1 sensor 2
• Heated oxygen sensor (ho2s) bank 1 sensor 3
• Heated oxygen sensor (ho2s) bank 1 sensor 3 (ex 7.4l)
• Heated oxygen sensor (ho2s) bank 2 sensor 1
• Heated oxygen sensor (ho2s) bank 2 sensor 2 (7.4l)
• Horns
• Ignition control module (icm)
• Inflatable restraint front end discriminating sensor
• Inflatable restraint sensing and diagnostic module
• Instrument cluster
• Left front door jamb switch
• Left front power door lock switch
• Left front power side window switch
• Left power outside rear view mirror
• Mass airflow (maf) sensor
• Nca
• Non base
• Others
• Others except 7.4l
• Park/ neutral position switch
• Passlock module
• Power outside rear view mirror remote control switch
• Right front door jamb switch
• Right front power door lock switch
• Right front power side window switch
• Right power outside rear view mirror
• S101
• S102 (ex 7.4l-engine harness, approx 104 cm from underhood fuse/relay panel breakout, 7.4l-engine harness, approx 5 cm from a/c comp clutch breakout)
• S103
• S104
• S112
• S208 (i/p harness, approx 7 cm into inflatable restraint sensing and diagnostic module breakout)
• S301
• Secondary air injection reaction (air) pump clutch (7.4l only)
• Starter relay
• Underhood fuse/relay center
• Underhood lamp
• Underhood reel lamp
• Vehicle control module (vcm)
• W/ tr9 lamp group

Ground Distribution Wiring Diagram (3 of 3) for Chevrolet Cutaway G3500 1999

List of elements for Ground Distribution Wiring Diagram (3 of 3) for Chevrolet Cutaway G3500 1999:

• (aux heater and a/c harness, approx 14 cm from front aux hvac module breakout)
• (engine harness, approx 11 cm from 38-pin conn left front of engine)
• (engine harness, approx 4 cm from 38-pin conn left front of engine)
• (i/p harness, approx 40 cm from bulkhead connector)
• (left front of engine)
• (underhood lamp harness, approx 4 cm from breakout to connector near blower motor)
• (upfitter provision-left body harness, approx 7 cm from breakout to connector behind left rear wheelhouse, others-left body harness, approx 7 cm from breakout to connector behind left rear lens assembly)
• A/c compressor clutch
• Ambulance package
• Auxiliary blower motor
• Auxiliary blower motor switch
• B13
• Blower motor resistor/ relay
• Brake pressure differential switch
• Center high mounted stoplamp
• Data link connector (dlc)
• Diesel engines
• Diode
• Electronic brake control module (ebcm)
• Front auxiliary hvac control module
• Fuel heater
• Fuel lift pump
• Fuel pump relay
• Fuel sender buffer module
• G110
• G125 (front of engine, near thermostat housing)
• G402 (left rear interior, behind rear wheelhouse)
• G403 (right rear interior, behind rear wheelhouse)
• Glow plug relay
• Heater and a/c control logic module
• Horns
• Instrument cluster
• Left backup lamp
• Left rear park/ stop lamp
• Left rear park/ turn lamp
• License lamp
• Nca
• Park/ neutral position switch
• Passenger vans only
• Passlock module
• Powertrain control module (pcm)
• Rear auxiliary hvac control module
• Rear auxiliary mode valve and seal assembly
• Rear auxiliary temperature valve assembly
• Right backup lamp
• Right power seat switch
• Right rear door jamb switch
• Right rear park/ stop lamp
• Right rear park/ turn lamp
• S101
• S102
• S104
• S112
• S303 (right body harness, approx 7 cm from side door jamb switch)
• S318
• S400
• S401 (left body harness, approx 7 cm from connector breakout to left rear of vehicle)
• S411 (rear a/c harness, approx 13 cm from blower motor breakout)
• S421 (center high mount stoplamp harness, approx 60 cm from breakout to connector under rear center of headliner)
• S904 (right rear door harness, approx 29 cm from door jamb switch breakout)
• S909 (right taillamp harness, approx 7 cm from pass-through grommet)
• S910 (right taillamp harness, approx 7 cm from pass-through grommet)
• Side door jamb switch
• Starter relay
• Underhood fuse/relay center
• Underhood lamp
• Underhood reel lamp
• Vehicle speed sensor buffer
• W/ auxiliary heat & a/c
• W/ auxiliary heat only
• W/ power passenger seat
• W/ tr9 lamp group
• W/o power passenger seat
• Water-in- fuel indicator