All Wiring Diagrams for Chevrolet RV Cutaway G2000 3500 model

AIR CONDITIONING

5.7L

5.7L VIN R, Compressor Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Compressor Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (in eng harness) s101 (7.4l) (in eng harness)
• A/c
• A/c compress0r high pressure cutoff switch (rear of a/c compressor)
• A/c compress0r low pressure cutoff switch (in refrigerant line)
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c fuse 10a
• Bi-lev
• Blnd
• Def
• G119 (right side of engine)
• Heat
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• Hvac control module
• I/p fuse block
• Ign e fuse 10a
• Max
• Off
• Pnk
• S215 (i/p harn, 4 cm from radio breakout)
• Underhood fuse/relay center
• Vehicle control module (left side of engine compartment)
• Vent

5.7L VIN R, Heater Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Heater Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (i/p harness, 4 cm from radio breakout)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harness, 30 cm from blower motor resistor breakout)
• (rear a/c harness, 37 cm from blower motor resistor breakout)
• (rear a/c harness, 67 cm from blower motor resistor breakout)
• (school bus)
• Auxiliary blower motor (left rear of cabin, behind rear wheelwell)
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Auxiliary blower motor switch
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C1 f
• C2 c
• C202
• Convenience center
• Def
• G119 (right side of engine)
• G200 (behind left kick panel)
• G416 (left rear frame rail) g402 (left rear of vehicle)
• Heat
• Heater controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Interior lights system
• Med
• Off
• Red
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• S202 (dash harn, 7 cm from vssb breakout)
• S215
• S327
• S400 (left body harness, near chmsl)
• S405
• S412
• S413
• Tan
• Temperature valve actuator motor (on hvac plenum)
• Underhood fuse/relay center
• Vent

5.7L VIN R, Manual A/C Wiring Diagram, Cargo Van for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Manual A/C Wiring Diagram, Cargo Van for Chevrolet RV Cutaway G2000 3500:

• (aux hvac harn, 14 cm from aux hvac module breakout)
• (below dash, right side of hvac plenum) temperature valve actuator motor
• (i/p harn, 4 cm from radio breakout)
• (i/p harn, 7 cm from vssb breakout)
• (in engine harness)
• (in underhood fuse/relay center)
• (left body harn, left side of cabin)
• (left rear interior)
• (left rear of cabin, behind rear wheelwell)
• (left rear of vehicle)
• (rear a/c harn, 67 cm from blower motor resistor breakout)
• (rear a/c harn, 7 cm from o/s air vlv actuator breakout)
• (rear a/c harness, 30 cm from blower motor resistor/relay breakout)
• (rear aux hvac harn, 29 cm from rear aux hvac module breakout)
• A/c
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c compressor high pressure cutoff switch (rear of a/c compressor)
• A/c compressor low pressure cutoff switch (in refrigerant line)
• A/c fuse 10a
• Auxiliary blower motor
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Bi-lev
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C2 c
• C202
• C3 d3
• Convenience center
• D3 c3
• Def
• Diode
• Front auxiliary hvac control module
• G119 (right side of engine)
• G200 (left kick panel)
• G402
• Heat
• Heater & a/c controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Interior lights system
• Max
• Med
• Off
• Pnk
• Rear auxiliary mode valve and seal assy (left rear interior)
• Rear auxiliary temperature
• Red
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• S202
• S215
• S307
• S318
• S404
• S405 (rear a/c harn, 37 cm from blower resistor breakout)
• S411
• S412
• S413
• Tan
• Temp
• Under- hood fuse/ relay center
• Valve assy
• Vehicle control module (left side of engine compartment)
• Vent
• Vent mode

5.7L VIN R, Manual A/C Wiring Diagram, Passenger Van for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Manual A/C Wiring Diagram, Passenger Van for Chevrolet RV Cutaway G2000 3500:

• (aux hvac harn, 14 cm from aux hvac module breakout)
• (aux hvac harn, 26 cm from frt aux hvac mod breakout)
• (aux hvac harn, 57 cm from frt aux hvac module breakout)
• (below dash, right side of hvac plenum) temperature valve actuator motor
• (front interior roof panel)
• (i/p harn, 7 cm from vssb breakout)
• (i/p harn, 4 cm from radio breakout) s215
• (in engine harness)
• (in underhood fuse/relay center)
• (left body harn, left side of cabin)
• (left rear interior)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harn, 67 cm from o/s air vlv actuator breakout)
• (rear a/c harn, 7 cm from blower motor resistor breakout)
• (rear a/c harness, 30 cm from blower motor resistor/relay breakout)
• (rear aux hvac harn, 29 cm from rear aux hvac module breakout)
• (rear hvac harn, 13 cm from frt aux hvac module breakout)
• A/c
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c compressor high pressure cutoff switch (rear of a/c compressor)
• A/c compressor low pressure cutoff switch (in refrigerant line)
• A/c fuse 10a
• Auxiliary blower motor
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Bi-lev
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C2 c
• C202
• Convenience center
• Def
• Diode
• Front auxiliary hvac control module
• G119 (right side of engine)
• G200 (left kick panel)
• G402 (left rear of vehicle)
• Heat
• Heater & a/c control logic module
• Heater & a/c controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Interior lights system
• Max
• Med
• Off
• Pnk
• Rear auxiliary hvac control module
• Rear auxiliary mode valve and seal assy (left rear interior)
• Rear auxiliary temperature
• Red
• Rr blower fuse 30a
• Rr ctrl
• Rr hvac fuse 24 10a
• S202
• S307
• S318
• S319
• S320
• S321
• S404
• S405 (rear a/c harn, 37 cm from blower resistor breakout)
• S411
• S412
• S413
• Tan
• Temp
• Under- hood fuse/ relay center
• Valve assy
• Vehicle control module (on left side of engine compartment)
• Vent
• Vent mode

6.5L

6.5L VIN F, Compressor Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Compressor Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• A/c
• A/c compress0r high pressure cutout switch (rear of a/c compressor)
• A/c compress0r low pressure cutout switch (in refrigerant line)
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c fuse 10a
• Bi-lev
• Blnd
• Def
• G110 (left front of engine)
• Harness)
• Heat
• Heater & a/c controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Max
• Off
• Pnk
• Powertrain control module (behind center of dash)
• S215 (i/p harn, 4 cm from radio breakout)
• Underhood fuse/relay center
• Vent

6.5L VIN F, Heater Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Heater Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (i/p harness, 4 cm from radio breakout)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harness, 30 cm from blower motor resistor breakout)
• (rear a/c harness, 37 cm from blower motor resistor breakout)
• (rear a/c harness, 67 cm from blower motor resistor breakout)
• (school bus)
• Auxiliary blower motor (left rear of cabin, behind rear wheelwell)
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Auxiliary blower motor switch
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C1 f
• C2 c
• C202
• Convenience center
• Def
• G119 (right side of engine)
• G200 (behind left kick panel)
• G416 (left rear frame rail) g402 (left rear of vehicle)
• Heat
• Heater controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Interior lights system
• Med
• Off
• Red
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• S202 (dash harn, 7 cm from vssb breakout)
• S215
• S327
• S400 (left body harness, near chmsl)
• S405
• S412
• S413
• Tan
• Temperature valve actuator motor (on hvac plenum)
• Underhood fuse/relay center
• Vent

6.5L VIN F, Manual A/C Wiring Diagram, Cargo Van for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Manual A/C Wiring Diagram, Cargo Van for Chevrolet RV Cutaway G2000 3500:

• (aux hvac harn, 14 cm from aux hvac module breakout)
• (below dash, right side of hvac plenum) temperature valve actuator motor
• (i/p harn, 4 cm from radio breakout)
• (i/p harn, 7 cm from vssb breakout)
• (in engine harness)
• (in underhood fuse/relay center)
• (left body harn, left side of cabin)
• (left front of eng) g110
• (left rear interior)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harn, 67 cm from blower motor resistor breakout)
• (rear a/c harn, 7 cm from o/s air vlv actuator breakout)
• (rear a/c harness, 30 cm from blower motor resistor/relay breakout)
• (rear aux hvac harn, 29 cm from rear aux hvac module breakout)
• A/c
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c compressor high pressure cutoff switch (rear of a/c compressor)
• A/c compressor low pressure cutoff switch (in refrigerant line)
• A/c fuse 10a
• Auxiliary blower motor
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Bi-lev
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C2 c
• C202
• C3 d3
• Convenience center
• D3 c3
• Def
• Diode
• Front auxiliary hvac control module
• G110 (left front of engine)
• G200 (left kick panel)
• Heat
• Heater & a/c controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Interior lights system
• Max
• Med
• Off
• Pnk
• Powertrain control module (behind center of dash)
• Rear auxiliary mode valve and seal assy (left rear interior)
• Rear auxiliary temperature
• Red
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• S202
• S215
• S307
• S400
• S404
• S405 (rear a/c harn, 37 cm from blower resistor breakout)
• S411
• S412
• S413
• Tan
• Temp
• Under- hood fuse/ relay center
• Valve assy
• Vent
• Vent mode

6.5L VIN F, Manual A/C Wiring Diagram, Passenger Van for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Manual A/C Wiring Diagram, Passenger Van for Chevrolet RV Cutaway G2000 3500:

• (aux hvac harn, 14 cm from aux hvac module breakout)
• (aux hvac harn, 26 cm from frt aux hvac mod breakout)
• (aux hvac harn, 57 cm from frt aux hvac module breakout)
• (below dash, right side of hvac plenum) temperature valve actuator motor
• (front interior roof panel)
• (i/p harn, 7 cm from vssb breakout)
• (i/p harn, 4 cm from radio breakout) s215
• (in engine harness)
• (in underhood fuse/relay center)
• (left body harn, left side of cabin)
• (left front of eng) g110
• (left rear interior)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harn, 67 cm from blower motor resistor breakout)
• (rear a/c harn, 7 cm from o/s air vlv actuator breakout)
• (rear a/c harness, 30 cm from blower motor resistor/relay breakout)
• (rear aux hvac harn, 29 cm from rear aux hvac module breakout)
• (rear hvac harn, 13 cm from frt aux hvac module breakout)
• A/c
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c compressor high pressure cutoff switch (rear of a/c compressor)
• A/c compressor low pressure cutoff switch (in refrigerant line)
• A/c fuse 10a
• Auxiliary blower motor
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Bi-lev
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C2 c
• C202
• Convenience center
• Def
• Diode
• Front auxiliary hvac control module
• G110 (left front of engine)
• G200 (left kick panel)
• G402 (left rear of vehicle)
• Heat
• Heater & a/c controller
• Heater and a/c control logic module
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Interior lights system
• Max
• Med
• Off
• Pnk
• Powertrain control module (behind center of dash)
• Rear auxiliary hvac control module
• Rear auxiliary mode valve and seal assy (left rear interior)
• Rear auxiliary temperature
• Red
• Rr blower fuse 30a
• Rr ctrl
• Rr hvac fuse 24 10a
• S202
• S307
• S318
• S319
• S320
• S321
• S404
• S405 (rear a/c harn, 37 cm from blower resistor breakout)
• S411
• S412
• S413
• Tan
• Temp
• Under- hood fuse/ relay center
• Valve assy
• Vent
• Vent mode

7.4L

7.4L VIN J, Compressor Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Compressor Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (in eng harness) s101 (7.4l) (in eng harness)
• A/c
• A/c compress0r high pressure cutoff switch (rear of a/c compressor)
• A/c compress0r low pressure cutoff switch (in refrigerant line)
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c fuse 10a
• Bi-lev
• Blnd
• Def
• G119 (right side of engine)
• Heat
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• Hvac control module
• I/p fuse block
• Ign e fuse 10a
• Max
• Off
• Pnk
• S215 (i/p harn, 4 cm from radio breakout)
• Underhood fuse/relay center
• Vehicle control module (left side of engine compartment)
• Vent

7.4L VIN J, Heater Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Heater Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (i/p harness, 4 cm from radio breakout)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harness, 30 cm from blower motor resistor breakout)
• (rear a/c harness, 37 cm from blower motor resistor breakout)
• (rear a/c harness, 67 cm from blower motor resistor breakout)
• (school bus)
• Auxiliary blower motor (left rear of cabin, behind rear wheelwell)
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Auxiliary blower motor switch
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C1 f
• C2 c
• C202
• Convenience center
• Def
• G119 (right side of engine)
• G200 (behind left kick panel)
• G416 (left rear frame rail) g402 (left rear of vehicle)
• Heat
• Heater controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Interior lights system
• Med
• Off
• Red
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• S202 (dash harn, 7 cm from vssb breakout)
• S215
• S327
• S400 (left body harness, near chmsl)
• S405
• S412
• S413
• Tan
• Temperature valve actuator motor (on hvac plenum)
• Underhood fuse/relay center
• Vent

7.4L VIN J, Manual A/C Wiring Diagram, Cargo Van for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Manual A/C Wiring Diagram, Cargo Van for Chevrolet RV Cutaway G2000 3500:

• (aux hvac harn, 14 cm from aux hvac module breakout)
• (below dash, right side of hvac plenum) temperature valve actuator motor
• (i/p harn, 4 cm from radio breakout)
• (i/p harn, 7 cm from vssb breakout)
• (in engine harness)
• (in underhood fuse/relay center)
• (left body harn, left side of cabin)
• (left rear interior)
• (left rear of cabin, behind rear wheelwell)
• (left rear of vehicle)
• (rear a/c harn, 67 cm from blower motor resistor breakout)
• (rear a/c harn, 7 cm from o/s air vlv actuator breakout)
• (rear a/c harness, 30 cm from blower motor resistor/relay breakout)
• (rear aux hvac harn, 29 cm from rear aux hvac module breakout)
• A/c
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c compressor high pressure cutoff switch (rear of a/c compressor)
• A/c compressor low pressure cutoff switch (in refrigerant line)
• A/c fuse 10a
• Auxiliary blower motor
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Bi-lev
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C2 c
• C202
• C3 d3
• Convenience center
• D3 c3
• Def
• Diode
• Front auxiliary hvac control module
• G119 (right side of engine)
• G200 (left kick panel)
• G402
• Heat
• Heater & a/c controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Interior lights system
• Max
• Med
• Off
• Pnk
• Rear auxiliary mode valve and seal assy (left rear interior)
• Rear auxiliary temperature
• Red
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• S202
• S215
• S307
• S318
• S404
• S405 (rear a/c harn, 37 cm from blower resistor breakout)
• S411
• S412
• S413
• Tan
• Temp
• Under- hood fuse/ relay center
• Valve assy
• Vehicle control module (left side of engine compartment)
• Vent
• Vent mode

7.4L VIN J, Manual A/C Wiring Diagram, Passenger Van for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Manual A/C Wiring Diagram, Passenger Van for Chevrolet RV Cutaway G2000 3500:

• (aux hvac harn, 14 cm from aux hvac module breakout)
• (aux hvac harn, 26 cm from frt aux hvac mod breakout)
• (aux hvac harn, 57 cm from frt aux hvac module breakout)
• (below dash, right side of hvac plenum) temperature valve actuator motor
• (front interior roof panel)
• (i/p harn, 7 cm from vssb breakout)
• (i/p harn, 4 cm from radio breakout) s215
• (in engine harness)
• (in underhood fuse/relay center)
• (left body harn, left side of cabin)
• (left rear interior)
• (left rear of cabin, behind rear wheelwell)
• (rear a/c harn, 67 cm from o/s air vlv actuator breakout)
• (rear a/c harn, 7 cm from blower motor resistor breakout)
• (rear a/c harness, 30 cm from blower motor resistor/relay breakout)
• (rear aux hvac harn, 29 cm from rear aux hvac module breakout)
• (rear hvac harn, 13 cm from frt aux hvac module breakout)
• A/c
• A/c compressor clutch coil
• A/c compressor enable relay (in underhood fuse/relay center)
• A/c compressor high pressure cutoff switch (rear of a/c compressor)
• A/c compressor low pressure cutoff switch (in refrigerant line)
• A/c fuse 10a
• Auxiliary blower motor
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Auxiliary blower motor resistor (left rear of cabin, behind rear wheelwell)
• Bi-lev
• Blend
• Blower fuse 60a
• Blower motor
• Blower motor resistor/relay (right side of front blower motor)
• C2 c
• C202
• Convenience center
• Def
• Diode
• Front auxiliary hvac control module
• G119 (right side of engine)
• G200 (left kick panel)
• G402 (left rear of vehicle)
• Heat
• Heater & a/c control logic module
• Heater & a/c controller
• Hot at all times
• Hot in run
• Hot in run or start
• Htr-a/c fuse 12 20a
• I/p fuse block
• Ign e fuse 10a
• Interior lights system
• Max
• Med
• Off
• Pnk
• Rear auxiliary hvac control module
• Rear auxiliary mode valve and seal assy (left rear interior)
• Rear auxiliary temperature
• Red
• Rr blower fuse 30a
• Rr ctrl
• Rr hvac fuse 24 10a
• S202
• S307
• S318
• S319
• S320
• S321
• S404
• S405 (rear a/c harn, 37 cm from blower resistor breakout)
• S411
• S412
• S413
• Tan
• Temp
• Under- hood fuse/ relay center
• Valve assy
• Vehicle control module (on left side of engine compartment)
• Vent
• Vent mode

ANTI-LOCK BRAKES

5.7L

5.7L VIN R, Anti-lock Brake Wiring Diagrams for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Anti-lock Brake Wiring Diagrams for Chevrolet RV Cutaway G2000 3500:

• (engine harness, 4.3l, 5.0l, 5.7l: near fuel injector harness breakout, 7.4l: near a/t input shaft speed sensor breakout)
• Abs fuse 60a
• Abs ind
• Abs ind ground
• B17
• Battery
• Brake fuse 18 10a
• Brake ind
• Brake ind input
• Brake pressure differential switch (on left frame rail, near center of vehicle)
• Brake sw input
• Data link connector (under left side of dash)
• Daytime running lamp control module (under left side of dash)
• Diagnostic sig
• Ebcm ground
• Electronic brake control module (on left frame rail near center of vehicle)
• G125 (4.3l) g117 (5.0l, 5.7l, 7.4l) (4.3l: at generator bracket, 5.0l, 5.7l, 7.4l: rear of right cylinder head)
• G125 (at generator bracket)
• Gauges fuse 4 10a
• Hot at all times
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition
• Instrument cluster
• Left front wheel speed sensor
• Passlock module (below center of dash)
• Pnk
• Red
• Right front wheel speed sensor
• S101
• S102
• S122
• S153 (engine harness, 4.3l; 8 cm from a/c compressor breakout, 5.0l, 5.7l, 7.4l; 8 cm from bulkhead connector at left rear of engine compartment)
• S154 (engine harness, 98 cm from underhood fuse/relay center, toward a/c compressor breakout)
• S156
• S207 (i/p harn, 4 cm from park brake warning switch breakout)
• S210
• S216
• Sensor high
• Sensor low
• Serail data
• Serial data
• Signal ground
• Tan
• Tcc/ stoplamp switch (on brake pedal support)
• Underhood fuse/relay center
• Underhood fuse/relay center (left side of engine compt)
• Vehicle control module (left side of engine compt)
• Vehicle speed sensor (left side of transmission)
• Vss (+)
• Vss (-)
• Vss sig
• Warning systems

6.5L

6.5L VIN F, Anti-lock Brake Wiring Diagrams for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Anti-lock Brake Wiring Diagrams for Chevrolet RV Cutaway G2000 3500:

• (engine harness, 4 cm from brake pressure differential switch breakout)
• (left front of engine, at a/c compressor)
• Abs fuse 60a
• Abs ind
• Abs ind ground
• B17
• Battery
• Brake fuse 18 10a
• Brake ind
• Brake ind input
• Brake pressure differential switch (on left frame rail, near center of vehicle)
• Brake sw input
• Data link connector (under left side of dash)
• Daytime running lamp control module (under left side of dash)
• Diagnostic sig
• Ebcm ground
• Electronic brake control module (on left frame rail, near center of vehicle)
• G110
• G125 (at generator bracket)
• Gauges fuse 4 10a
• Hot at all times
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition
• Instrument cluster
• Left front wheel speed sensor
• Passlock module (below center of dash)
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• Red
• Right front wheel speed sensor
• S101
• S102
• S153 (engine harness, 27 cm from a/c compressor breakout)
• S154 (engine harness, 4 cm from main harness breakout)
• S156
• S207 (i/p harn, 4 cm from park brake warning switch breakout)
• S210
• S216
• Sensor high
• Sensor low
• Serial data
• Signal ground
• Tan
• Tcc/ stoplamp switch (on brake pedal support)
• Underhood fuse/relay center
• Underhood fuse/relay center (left side of engine compt)
• Vehicle speed sensor (left side of transmission)
• Vehicle speed sensor buffer module (under glove box)
• Vss (+)
• Vss (-)
• Vss sig
• Warning systems

7.4L

7.4L VIN J, Anti-lock Brake Wiring Diagrams for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Anti-lock Brake Wiring Diagrams for Chevrolet RV Cutaway G2000 3500:

• (engine harness, 4.3l, 5.0l, 5.7l: near fuel injector harness breakout, 7.4l: near a/t input shaft speed sensor breakout)
• Abs fuse 60a
• Abs ind
• Abs ind ground
• B17
• Battery
• Brake fuse 18 10a
• Brake ind
• Brake ind input
• Brake pressure differential switch (on left frame rail, near center of vehicle)
• Brake sw input
• Data link connector (under left side of dash)
• Daytime running lamp control module (under left side of dash)
• Diagnostic sig
• Ebcm ground
• Electronic brake control module (on left frame rail near center of vehicle)
• G125 (4.3l) g117 (5.0l, 5.7l, 7.4l) (4.3l: at generator bracket, 5.0l, 5.7l, 7.4l: rear of right cylinder head)
• G125 (at generator bracket)
• Gauges fuse 4 10a
• Hot at all times
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition
• Instrument cluster
• Left front wheel speed sensor
• Passlock module (below center of dash)
• Pnk
• Red
• Right front wheel speed sensor
• S101
• S102
• S122
• S153 (engine harness, 4.3l; 8 cm from a/c compressor breakout, 5.0l, 5.7l, 7.4l; 8 cm from bulkhead connector at left rear of engine compartment)
• S154 (engine harness, 98 cm from underhood fuse/relay center, toward a/c compressor breakout)
• S156
• S207 (i/p harn, 4 cm from park brake warning switch breakout)
• S210
• S216
• Sensor high
• Sensor low
• Serail data
• Serial data
• Signal ground
• Tan
• Tcc/ stoplamp switch (on brake pedal support)
• Underhood fuse/relay center
• Underhood fuse/relay center (left side of engine compt)
• Vehicle control module (left side of engine compt)
• Vehicle speed sensor (left side of transmission)
• Vss (+)
• Vss (-)
• Vss sig
• Warning systems

ANTI-THEFT

Anti-theft Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Anti-theft Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (diesel only) s247 (i/p harn, 21 cm left of hvac switch breakout)
• (engine harn) s153
• (i/p harn, 6 cm from park brake switch breakout) s207
• (not used)
• 12v
• 5 volt ref
• B17
• Capacitor 0.47 mf
• Data link connector (left side of dash)
• Diesel
• Diesel only
• Electronic brake control module (left center of vehicle)
• Filter (molded in steering column harness)
• Fuel sender buffer module (behind center of dash)
• G125 (front of engine, near thermostat housing)
• Gasoline
• Gauges fuse 4 10a
• Grd
• Hot at all times
• Hot in run or start
• I/p fuse block
• Ign
• Instrument cluster
• Nca
• Passlck sig
• Passlock module (below center of dash)
• Passlock sensor (internal to steering column)
• Passlock signal
• Pnk
• Powertrain control module (behind center of dash)
• Ref voltage
• Resistor 10 ohms
• S102
• S216
• S254
• Sec ind out
• Security fuse 21 10a
• Security indicator
• Sens ret
• Sensor grd
• Serial data
• Vehicle control module (left side of engine compt)

COMPUTER DATA LINES

Computer Data Lines for Chevrolet RV Cutaway G2000 3500

List of elements for Computer Data Lines for Chevrolet RV Cutaway G2000 3500:

• (4.3l: engine harn, 5 cm from a/c compressor breakout, toward transmission) (5.0/5.7l: engine harn, 8 cm from ignition coil breakout toward transmission) (7.4l: engine harn, 5 cm from 36 pin in-line conn toward egr sensor breakout) (6.5l diesel: engine harn, 27 cm from breakout to underhood fuse relay center)
• C210
• Convenience center (under left side of dash)
• Data clss
• Data link connector (dlc) (under left side of dash)
• Diag sig
• Diesel
• Electronic brake control module (ebcm) (on left frame rail near center of vehicle)
• G125 (at generator bracket)
• G200 (behind left kick panel)
• Gas
• Hot at all times
• I/p fuse block
• Inflatable restraint sensing & diagnostic module (under left front seat)
• Passlock module (below center of dash)
• Powertrain control module (pcm) (behind center of dash)
• Prog signal
• Pwr aux fuse 7 25a
• Remote control door lock receiver (behind center of dash)
• S153
• S201
• S207 (dash harness, approx 5 cm into vss buffer breakout)
• S218
• S254
• Serial data
• Tan
• Vehicle control module (vcm) (on left side of eng compt)

CRUISE CONTROL

5.7L

5.7L VIN R, Cruise Control Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Cruise Control Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (4.3l)
• (5.0l, 5.7l, 7.4l)
• A12
• A13
• A14
• A15
• Auto cruise
• Brake fuse 18 10a
• Cruise control module (front of engine compt, near left fender)
• Cruise control switch
• Cruise fuse 6 10a
• Cruise on input
• Cruise signal
• Electronic brake control module (on left frame rail near center of vehicle)
• Exterior light system
• G117 (rear of right cly head) g125 (at generator bracket)
• Ground
• Hot at all times
• Hot in run
• I/p fuse block (left lower kick panel)
• Ignition
• Off
• Pnk
• R/a
• Radio assembly
• Resume/accel sig
• S/c
• S122
• S154 (engine harness, 4 cm from ignition coil breakout)
• S239 (i/p harn, 10 cm from radio breakout)
• S253 (i/p harness, near park brake breakout)
• S254
• Set/coast sig
• Speed input
• Speed sensor input
• Speed signal
• Stop fuse 1 20a
• Stoplamp sw input
• Tcc/stoplamp switch (on brake pedal support)
• Vcm signal
• Vehicle control module (vcm) (left side of engine compt)
• Vehicle speed sensor (vss) (left side of transmission)
• Vss high
• Vss low

6.5L

6.5L VIN F, Cruise Control Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Cruise Control Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (1999)
• (2000-01)
• (i/p harness, behind i/p fuse block) s114
• (i/p harness, near park brake breakout)
• A11
• A12
• A13
• A14
• A15
• B10
• B11
• Brake fuse 18 10a
• Cruise control on/off switch
• Cruise fuse 6 10a
• Cruise on input
• D10
• Electronic brake control module (on left frame rail near center of vehicle)
• Exterior light system
• Hot at all times
• Hot in run
• I/p fuse block (left lower kick panel)
• Off
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• R/a
• Resume/accel sig
• S/c
• S111 (engine harn, 4 cm from main harness breakout that leads to underhood relay center breakout)
• S210
• S253
• Set/coast sig
• Speed sig output
• Speed signal input
• Stop fuse 1 20a
• Stoplamp switch input
• Tcc/brake switch (top of brake pedal)
• Vehicle speed sensor (vss) (left side of transmission)
• Vehicle speed sensor buffer (below dash, near steering column)
• Vss high
• Vss low
• Vss output

7.4L

7.4L VIN J, Cruise Control Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Cruise Control Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (4.3l)
• (5.0l, 5.7l, 7.4l)
• A12
• A13
• A14
• A15
• Auto cruise
• Brake fuse 18 10a
• Cruise control module (front of engine compt, near left fender)
• Cruise control switch
• Cruise fuse 6 10a
• Cruise on input
• Cruise signal
• Electronic brake control module (on left frame rail near center of vehicle)
• Exterior light system
• G117 (rear of right cly head) g125 (at generator bracket)
• Ground
• Hot at all times
• Hot in run
• I/p fuse block (left lower kick panel)
• Ignition
• Off
• Pnk
• R/a
• Radio assembly
• Resume/accel sig
• S/c
• S122
• S154 (engine harness, 4 cm from ignition coil breakout)
• S239 (i/p harn, 10 cm from radio breakout)
• S253 (i/p harness, near park brake breakout)
• S254
• Set/coast sig
• Speed input
• Speed sensor input
• Speed signal
• Stop fuse 1 20a
• Stoplamp sw input
• Tcc/stoplamp switch (on brake pedal support)
• Vcm signal
• Vehicle control module (vcm) (left side of engine compt)
• Vehicle speed sensor (vss) (left side of transmission)
• Vss high
• Vss low

DEFOGGERS

Defogger Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Defogger Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• C210
• Convenience center (under left side of dash)
• Fixed glass
• G200 (behind left kick panel)
• G998 (right interior "d" pillar)
• G999 (left interior "d" pillar)
• Heated mirror switch
• Heater & a/c controller
• Hot at all times
• Hot in run
• Htd mir fuse 2 20a
• Htr-a/c fuse 12 20a
• I/p fuse block (on left lower kick panel)
• Left power rear view mirror
• Left rear window defogger grid
• Moving glass
• Rear window defogger relay (bottom of left "b" pillar)
• Right power rear view mirror
• Right rear window defogger grid
• Rr defog fuse 22 25a
• S202
• S206
• S215
• S245
• S400
• S429
• S500
• S601
• S903
• Solid state timer

ENGINE PERFORMANCE

5.7L

5.7L VIN R, Engine Performance Wiring Diagrams (1 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Engine Performance Wiring Diagrams (1 of 4) for Chevrolet RV Cutaway G2000 3500:

• (lower front of engine, near crankshaft) crankshaft position sensor
• (right side of engine) evaporative emissions canister purge solenoid valve
• (top left side of engine) idle air control valve
• 1-2 shift sol
• 2-3 shift sol
• 4l60-e 4l80-e trans
• Air pump relay cntrl
• Camshaft position sensor (part of distributor, rear top of engine)
• Canister vet sig
• Ckp low
• Ckp sig
• Cmp return
• Cmp signal
• Coil a hi
• Coil b hi
• Css sig
• Ect sig
• Egr position signal
• Evaporative emission canister vent valve (on left frame rail, near fuel tank)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel lvl sig out
• Fuel tank press sig
• G110 (left front of engine)
• Heated oxygen sensor bank 1 sensor 1 (in exhaust pipe in front of catalytic converter)
• Heated oxygen sensor bank 1 sensor 3 (in exhaust pipe in front of catalytic converter)
• Heated oxygen sensor bank 2 sensor 2 (5.7l 0nly) (in exhaust pipe in back of catalytic converter)
• Ho2s low
• Ho2s signal
• Iac high
• Iac low
• Iat sig
• Knock sens signal
• Knock sensor (top rear of engine)
• Maf signal
• Map sens signal
• Nca
• Pnk
• Pnk c
• Pwm tcc sol output
• S101
• S152
• Shift solenoid output
• Solid state
• Tan
• Tcc sol output
• Temp sens signal
• Tp sig
• Trans
• Vehicle control module (vcm) (left side of engine compartment)
• Vehicle speed sensor (left side of transmission)
• Vss low
• Vss signal

5.7L VIN R, Engine Performance Wiring Diagrams (2 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Engine Performance Wiring Diagrams (2 of 4) for Chevrolet RV Cutaway G2000 3500:

• (w/4l60-e trans)
• (w/4l80-e trans)
• 1-2 shift solenoid
• 2-3 shift solenoid
• 3-2 shift solenoid
• A/t fluid pressure manual valve position switch
• Automatic transmission
• Ecm-1 fuse 20a
• Eng-1 k7
• Exhaust gas recirculation valve (top front of engine)
• Fluid temp sensor ground
• Fluid temp sensor signal
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuse 20a l8
• Heated oxygen sensor bank 2 sensor 1 (in exhaust pipe in front of catalytic converter)
• Hot in run or start
• Ignition
• Nca
• Pnk
• Pnk s130
• Pressure control solenoid valve
• Red
• S132
• S133
• Tan
• Tcc pcm solenoid valve
• Tcc solenoid vlave
• Underhood fuse/relay center
• W/4l60-e 4-speed trans only

5.7L VIN R, Engine Performance Wiring Diagrams (3 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Engine Performance Wiring Diagrams (3 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harn, approx 8 cm from ho2s sensor, bank 2 sensor 1) s136
• (engine harness, approx 85 cm from underhood fuse/relay center toward a/c compressor clutch breakout)
• (engine harness, approx 91 cm from underhood fuse/relay center toward a/c comp clutch breakout)
• (left front of engine) g110
• 87a
• Air fuse 30a
• B14
• B17
• Ecm-b fuse 20a
• Engine coolant temperature gauge sensor (on left cylinder head, between two front spark plugs)
• F11
• Fuel lvl input
• Fuel pump & sender (in fuel tank under rear of vehicle)
• Fuel pump relay
• Fuel tank pressure sensor (in fuel tank)
• G110 (left front of engine)
• G12
• Gauges fuse 4 10a
• Hot at all times
• Hot in off, run or start
• Hot in run or start
• I/p fuse block
• Input
• Instrument cluster
• Intake air temperature sensor (front of engine compartment, part of air intake duct)
• Malfunction indicator lamp (mil) "service engine soon"
• Manifold absolute pressure sensor (top right side of engine)
• Mass airflow sensor (part of air intake duct, top front of engine)
• Odometer speedometer/
• Pnk
• Red
• S101
• S102
• S103
• S119
• S137
• S139
• S152
• S216
• Secondary air injection reaction pump clutch
• Secondary air injection reaction pump relay
• Secondary air injection reaction solenoid
• Sig in
• Sig out
• Tan
• Tan a
• Throttle position sensor (on side of throttle body)
• Trans fuse 20 10a
• Underhood fuse/relay center

5.7L VIN R, Engine Performance Wiring Diagrams (4 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, Engine Performance Wiring Diagrams (4 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harness, 111 cm from underhood fuse/ relay center toward a/c comp clutch breakout)
• (engine harness, 98 cm from underhood fuse/ relay center toward a/c comp clutch breakout)
• (i/p harness, approx 10 cm into radio breakout)
• (i/p harness, approx 18 cm from engine sensors inline conn toward bulkhead)
• (left front of engine) g110
• 5 volt reference
• 5 volts reference
• A/c com rel ctrl
• A/c comp cycling sw
• A/c compressor enable relay
• A/c request sig
• Air conditioning system
• Automatic transmission input shaft speed sensor (w/4l80-e) (left side of transmission)
• Battery
• Brake switch input
• Coil
• Cruise control module (front of engine compartment near left fender)
• Cruise ctrl sig eng
• Cruise engaged output
• Data link connector (under left side of dash)
• Distributor
• Egr valve ctrl
• Electronic brake control module (ebcm) (left frame rail near center of vehicle)
• Evap driver
• Fuel lvl module
• Fuel pump rly feed
• Ground
• High voltage coil wire
• Hot in run
• I/p fuse block
• Ic cntrl
• Ignition
• Ignition coil (top rear of engine)
• Ignition control module (top right side of engine, at ignition coil)
• Inline conn toward breakout) s153
• Inpuit speed sens low
• Input speed sens high
• M4 brake fuse 18 10a n3
• Mal func lp output
• Pcs high
• Pcs low
• Pnk
• Pnk a
• Radio
• Range sig a
• Range sig b
• Range sig c
• Red
• S101
• S122
• S154
• S210
• S231
• S239
• Sensor ground
• Serial data
• Solid state
• Speed sensor input
• Stoplamp switch input
• Tcc signal
• Tcc/stoplamp switch (behind dash, on brake pedal support)
• Underhood fuse/relay center
• Vehicle control module (vcm) (left side of engine compartment)
• Vss signal
• Vss signal output

6.5L

6.5L VIN F, Engine Performance Wiring Diagrams, California (1 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, California (1 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harness, near left top of engine)
• (engine jumper harness, approx 21 cm from inline conn, near top left of engine)
• (engine jumper harness, approx 4 cm into crankshaft position sensor breakout)
• (i/p harness, approx 4 cm from steering column harness)
• (lower left front of engine, near crankshaft) crankshaft position sensor
• (near themostat housing) g125
• (top front of engine) engine coolant temperature sensor
• (top of engine)
• (top right
• 1-2 a
• 12v
• 5v ref
• A 2-3 shift sol
• A tcc pwm sol
• A/c request
• A/t fluid pressure (tfp) manual valve position switch
• A10
• A11
• A12
• A14
• A15
• Air conditioning system
• Anti-lock brake system
• App 1 gnd
• App 1 ref volt
• App 1 sig
• App 2 gnd
• App 2 sig
• App 3 gnd
• App 3 ref volt
• App 3 sig
• Automatic transmission
• Automatic transmission input shaft speed sensor (left side of transmission)
• B10
• B11
• B12
• Boost sens input
• Brake switch input
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• Camshaft posit sens
• Ckp ground
• Closure gnd
• Closure sig
• Coil 1 high
• Coil 1 low
• Coil 2 high
• Coil 2 low
• Cruise control
• Cruise on/off sw
• Cruise res/acc sw
• Cruise set/coast sig
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• Ect sig
• Engine crank sens input
• Fuel pump rly ctrl
• Fuel pump sig
• Fuel temp sens
• Glow plug "wait" lp out
• Glow plug relay
• Ground
• High res sig
• Iat sig
• On/off
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• Pressure control solenoid valve
• Pressure ctrl sol
• Radio
• Range mode sel a
• Range mode sel b
• Range mode sel c
• Red
• Resume
• S115
• S124
• S238
• S254
• Second vss sig
• Sense ground
• Sensor gnd
• Set
• Shift sol
• Side of engine) intake air temperature sensor
• Solid state
• Switch
• Tan
• Tan b
• Tcc/abs sw in
• Tft sens
• Trans input sp sig
• Transmission fluid temperature sensor
• Transmission speed input
• Turbocharger boost sensor
• Vehicle speed input
• Vehicle speed sensor (left side of transmission)
• Vehicle speed sensor buffer module (under glove box)
• Vss hi
• Vss lo
• Vss rtn
• Vss sig

6.5L VIN F, Engine Performance Wiring Diagrams, California (2 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, California (2 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine jumper harness, approx 4 cm into optical fuel temper- ature sensor breakout)
• 5 volt ref
• Accelerator pedal position (app) sensor (below dash, attached to accelerator pedal)
• Cmp sig
• D2 trans fuse 20 10a e1
• D8 stop fuse 1 20a c7
• Electronic brake control module (left frame rail, near center of vehicle)
• High res sig
• Hot at all times
• Hot in off, run or start
• Hot in run
• I/p fuse block
• Ignition timing stepper motor (top front of engine)
• M4 brake fuse 18 10a n3
• Optical fuel/ temperature sensor (top center of engine, on fuel injection pump)
• Pnk
• Red
• S105
• S111
• S210
• S253
• Sens grd
• Tan d
• Tcc/stoplamp switch (behind dash, on brake pedal support)

6.5L VIN F, Engine Performance Wiring Diagrams, California (3 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, California (3 of 4) for Chevrolet RV Cutaway G2000 3500:

• (at generator bracket) g119
• (engine harness, approx 10 cm from ebcm breakout) s138
• (left frame rail, near center of vehicle)
• (near thermostat housing)
• A15
• B13
• B14
• B15
• B17
• Ecm-b fuse 20a
• Engine shutoff solenoid (top front of engine)
• F11
• Fuel lift pump
• Fuel pump relay (left side of engine compt, in underhood fuse/relay center)
• Fuel solenoid (on rear of fuel injection pump)
• Fuel solenoid driver (left side of fuel injection pump)
• G12
• G125
• Gauges fuse 4 10a
• Hot at all times
• Hot in run or start
• I/p fuse block
• Instrument cluster
• Pnk
• Red
• S101
• S102
• S107 (engine jumper harness, approx 4 cm into fuel shut-off solenoid breakout)
• S112
• S120
• S216
• Service engine soon indicator
• Service throttle soon indicator
• Speedometer solid state logic
• Tan
• Underhood fuse block
• Wait to start "glow plugs" indicator
• Water in fuel indicator
• Water in-fuel sensor (left frame rail, near center of vehicle, part of fuel filter/management)

6.5L VIN F, Engine Performance Wiring Diagrams, California (4 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, California (4 of 4) for Chevrolet RV Cutaway G2000 3500:

• "serv eng soon" ind
• "serv throttle soon" ind
• (engine harness, 14 cm from starter solenoid breakout)
• (left frame rail, near center of vehicle, part of fuel filter/management) fuel heater
• 12v battery fused
• A/c enable
• A/c system
• App 2 ref voltage
• Battery
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• Data link connector (dlc) (under left side of dash)
• Ecm-1 h7
• Electronic brake control module (left frame rail, near center of vehicle)
• Eng-1 k7
• Eso ctrl
• Eso sol ctrl
• Fuel inj ctrl
• Fuse 20a
• G119 (at generator bracket)
• Glow plug 1
• Glow plug 2
• Glow plug 3
• Glow plug 4
• Glow plug 5
• Glow plug 6
• Glow plug 7
• Glow plug 8
• Glow plug relay (top right side of engine)
• Glow plug relay control
• Glow plug signal
• Ground
• Hot at all times
• Hot in run or start
• Ignition
• Left bank glow plug output
• Pcm gnd
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• Red
• Right bank glow plug output
• S101
• S102
• S108
• S117
• S121
• S130
• S253 (eng harn, 27 cm from inline conn, near top left of engine)
• Serial data sig
• Shift sol 1/2 input
• Shift sol 2/3 input
• Tan
• Tcc pwm sol
• Underhood fuse block
• Wait to start sig
• Wastegate sol ctrl
• Wastegate solenoid (top right side of engine)

6.5L VIN F, Engine Performance Wiring Diagrams, Federal (1 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, Federal (1 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harness, near left top of engine)
• (engine jumper harness, approx 21 cm from inline conn, near top left of engine)
• (engine jumper harness, approx 4 cm into crankshaft position sensor breakout)
• (i/p harness, approx 4 cm from steering column harness)
• (lower left front of engine, near crankshaft) crankshaft position sensor
• (near themostat housing) g125
• (top front of engine) engine coolant temperature sensor
• (top of engine)
• (top right
• 1-2 a
• 12v
• 5v ref
• A 2-3 shift sol
• A tcc pwm sol
• A/c request
• A/t fluid pressure (tfp) manual valve position switch
• A10
• A11
• A12
• A14
• A15
• Air conditioning system
• Anti-lock brake system
• App 1 gnd
• App 1 ref volt
• App 1 sig
• App 2 gnd
• App 2 sig
• App 3 gnd
• App 3 ref volt
• App 3 sig
• Automatic transmission
• Automatic transmission input shaft speed sensor (left side of transmission)
• B10
• B11
• B12
• Boost sens input
• Brake switch input
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• Camshaft posit sens
• Ckp ground
• Closure gnd
• Closure sig
• Coil 1 high
• Coil 1 low
• Coil 2 high
• Coil 2 low
• Cruise control
• Cruise on/off sw
• Cruise res/acc sw
• Cruise set/coast sig
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• Ect sig
• Engine crank sens input
• Fuel pump rly ctrl
• Fuel pump sig
• Fuel temp sens
• Glow plug "wait" lp out
• Glow plug relay
• Ground
• High res sig
• Iat sig
• On/off
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• Pressure control solenoid valve
• Pressure ctrl sol
• Radio
• Range mode sel a
• Range mode sel b
• Range mode sel c
• Red
• Resume
• S115
• S124
• S238
• S254
• Second vss sig
• Sense ground
• Sensor gnd
• Set
• Shift sol
• Side of engine) intake air temperature sensor
• Solid state
• Switch
• Tan
• Tan b
• Tcc/abs sw in
• Tft sens
• Trans input sp sig
• Transmission fluid temperature sensor
• Transmission speed input
• Turbocharger boost sensor
• Vehicle speed input
• Vehicle speed sensor (left side of transmission)
• Vehicle speed sensor buffer module (under glove box)
• Vss hi
• Vss lo
• Vss rtn
• Vss sig

6.5L VIN F, Engine Performance Wiring Diagrams, Federal (2 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, Federal (2 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine jumper harness, approx 4 cm into optical fuel temper- ature sensor breakout)
• 5 volt ref
• Accelerator pedal position (app) sensor (below dash, attached to accelerator pedal)
• Cmp sig
• D2 trans fuse 20 10a e1
• D8 stop fuse 1 20a c7
• Electronic brake control module (left frame rail, near center of vehicle)
• High res sig
• Hot at all times
• Hot in off, run or start
• Hot in run
• I/p fuse block
• Ignition timing stepper motor (top front of engine)
• M4 brake fuse 18 10a n3
• Optical fuel/ temperature sensor (top center of engine, on fuel injection pump)
• Pnk
• Red
• S105
• S111
• S210
• S253
• Sens grd
• Tan d
• Tcc/stoplamp switch (behind dash, on brake pedal support)

6.5L VIN F, Engine Performance Wiring Diagrams, Federal (3 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, Federal (3 of 4) for Chevrolet RV Cutaway G2000 3500:

• (at generator bracket) g119
• (engine harness, approx 10 cm from ebcm breakout) s138
• (left frame rail, near center of vehicle)
• (near thermostat housing)
• A15
• B13
• B14
• B15
• B17
• Ecm-b fuse 20a
• Engine shutoff solenoid (top front of engine)
• F11
• Fuel lift pump
• Fuel pump relay (left side of engine compt, in underhood fuse/relay center)
• Fuel solenoid (on rear of fuel injection pump)
• Fuel solenoid driver (left side of fuel injection pump)
• G12
• G125
• Gauges fuse 4 10a
• Hot at all times
• Hot in run or start
• I/p fuse block
• Instrument cluster
• Pnk
• Red
• S101
• S102
• S107 (engine jumper harness, approx 4 cm into fuel shut-off solenoid breakout)
• S112
• S120
• S216
• Service engine soon indicator
• Service throttle soon indicator
• Speedometer solid state logic
• Tan
• Underhood fuse block
• Wait to start "glow plugs" indicator
• Water in fuel indicator
• Water in-fuel sensor (left frame rail, near center of vehicle, part of fuel filter/management)

6.5L VIN F, Engine Performance Wiring Diagrams, Federal (4 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, Engine Performance Wiring Diagrams, Federal (4 of 4) for Chevrolet RV Cutaway G2000 3500:

• "serv eng soon" ind
• "serv throttle soon" ind
• (engine harness, 14 cm from starter solenoid breakout)
• (left frame rail, near center of vehicle, part of fuel filter/management) fuel heater
• 12v battery fused
• A/c enable
• A/c system
• App 2 ref voltage
• Battery
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• Data link connector (dlc) (under left side of dash)
• Ecm-1 h7
• Electronic brake control module (left frame rail, near center of vehicle)
• Eng-1 k7
• Eso ctrl
• Eso sol ctrl
• Fuel inj ctrl
• Fuse 20a
• Fusible link
• G119 (at generator bracket)
• Glow plug 1
• Glow plug 2
• Glow plug 3
• Glow plug 4
• Glow plug 5
• Glow plug 6
• Glow plug 7
• Glow plug 8
• Glow plug output
• Glow plug relay (top right side of engine)
• Glow plug relay control
• Ground
• Hot at all times
• Hot in run or start
• Ignition
• Pcm gnd
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• Red
• S101
• S102
• S108
• S117
• S121
• S130
• S253 (eng harn, 27 cm from inline conn, near top left of engine)
• Serial data sig
• Shift sol 1/2 input
• Shift sol 2/3 input
• Tan
• Tcc pwm sol
• Underhood fuse block
• Wait to start sig
• Wastegate sol ctrl
• Wastegate solenoid (top right side of engine)

7.4L

7.4L VIN J, Engine Performance Wiring Diagrams (1 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Engine Performance Wiring Diagrams (1 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harn, approx 5 cm from map sensor breakout) s147
• 1-2 shift sol ctrl
• 2-3 shift sol ctrl
• Air injection rly ctrl
• Anti-lock brakes system
• Cam pos sens signal
• Camshaft position sensor (part of distributor, rear top of engine)
• Ckp pos sens rtn
• Ckp pos signal in
• Crankshaft position sensor (lower front of engine, near crankshaft)
• Ect sens signal
• Egr pos input
• Evap vent vlv
• Evaporative emission canister vent valve (on left frame rail, near fuel tank)
• Evaporative emissions canister purge solenoid valve (top left side of engine)
• Feed ign
• Fuel gauge
• Fuel inj 1 ctrl
• Fuel inj 2 ctrl
• Fuel inj 3 ctrl
• Fuel inj 4 ctrl
• Fuel inj 5 ctrl
• Fuel inj 6 ctrl
• Fuel inj 7 ctrl
• Fuel inj 8 ctrl
• Fuel tank press sens sig
• G117 (rear of right cylinder head)
• Heated oxygen sensor bank 2 sensor 1 (in exhaust pipe in front of catalytic converter)
• Ho2s sens high
• Ho2s sens low
• Iac coil a high
• Iac coil a low
• Iac coil b high
• Iac coil b low
• Idle air control valve (top right side of engine)
• Ign feed
• Intake air temp sens
• Knock sens signal
• Knock sensor (on lower left side of engine)
• Knock sensor (on lower right side of engine)
• Map signal
• Mass air flow sens sig
• Nca
• Pnk
• Red
• S131
• S152
• Secondary air injection reaction pump clutch (lower right front of engine)
• Secondary air injection reaction pump relay (on left side of engine compartment, in underhood fuse/relay center)
• Sens rtn
• Sens sig
• Sensor rtn
• Sensor signal
• Tan
• Tcc pwm sol ctrl
• Throttle pos sens
• Trans temp sens in
• Vehicle control module (vcm) (left side of engine compartment)
• Vehicle speed sensor (left side of trans- mission)
• Vss rtn
• Vss signal
• Vss signal out

7.4L VIN J, Engine Performance Wiring Diagrams (2 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Engine Performance Wiring Diagrams (2 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harness, approx 7 cm from engine coolant temperature sensor)
• (fuel injector harness, near fuel injector connector) s140
• (fuel injector harness, near fuel injector connector) s141
• Automatic transmission
• Eng-1 fuse 20a
• Exhaust gas recirculation valve (top left side of engine)
• Fuel inj
• G117 (rear of right cylinder head)
• Heated oxygen sensor bank 1 sensor 1 (in exhaust pipe in front of catalytic converter)
• Heated oxygen sensor bank 1 sensor 3 (in exhaust pipe in front of catalytic converter)
• Heated oxygen sensor bank 2 sensor 2 (in exhaust pipe in back of catalytic converter)
• Hot in off, run or start
• Hot in run or start
• I/p fuse block
• Ignition
• Intake air temp sensor (on front of engine, part of air intake duct)
• N pressure switch
• Nca
• P pressure
• Pnk
• Pressure control solenoid valve
• R pressure switch
• Red
• S tcc pwm
• S101
• S103
• S130
• S136
• S152
• Solenoid
• Solenoid 1-2
• Solenoid 2-3
• Switch
• Tan
• Trans fluid temperature sensor
• Trans fuse 20 10a
• Underhood fuse/relay center

7.4L VIN J, Engine Performance Wiring Diagrams (3 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Engine Performance Wiring Diagrams (3 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harness, approx 14 cm from a/c compressor clutch breakout)
• (engine harness, approx 21 cm from a/c
• B13
• B14
• B17
• Brake fuse 18 10a
• Compressor clutch breakout) s139
• Engine coolant temperature sensor (top front of engine)
• Fuel gauge
• Fuel pump & sender (in fuel tank)
• Fuel tank pressure sensor (in fuel tank)
• G117 (rear of right cylinder head)
• G125 (top front of engine)
• Gauges fuse 4 10a
• Hot in run
• Hot in run or start
• I/p fuse block
• Instrument cluster
• Manifold absolute pressure (map) sensor (top front side of engine)
• Mass airflow sensor (part of air intake duct, front top of engine)
• Pnk
• Red
• S101
• S102
• S122
• S137
• S210
• S216
• S254
• Service engine soon indicator
• Signal input
• Signal output
• Speed meter
• Tcc/stop- lamp switch (behind dash, on brake pedal support)
• Throttle position sensor (on side of throttle body)

7.4L VIN J, Engine Performance Wiring Diagrams (4 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, Engine Performance Wiring Diagrams (4 of 4) for Chevrolet RV Cutaway G2000 3500:

• (engine harness, 4 cm from ect sensor breakout toward maf sensor breakout)
• (engine harness, approx 42 cm from underhood fuse block toward a/c compressor clutch breakout)
• (i/p harness, approx 10 cm into radio breakout)
• (rear of right cylinder head) g117
• 5v ref
• 5v return
• 87a
• A/c comp rel ctrl
• A/c compressor enable relay (on left side of engine compt, in underhood fuse/relay center)
• A/c low pressure sig
• A/c request signal
• Air conditioning system
• Anti-lock brakes system
• Automatic transmission input shaft speed sensor (left side of transmission)
• B +
• Brake sw input
• Check engine lp ctrl
• Cruise control module (front of engine compt, near left fender)
• Cruise ctrl engaged
• Cruise ctrl sig-engaged
• Ctrl est
• Data link connector (under left side of dash)
• Distributor
• Ecm-b fuse 20a
• Ecm-i fuse 20a
• Egr valve ctrl
• Elec spk timing ctrl sig
• Evap purge vlv driver
• Fuel pmp rly ctrl
• Fuel pump relay (on left side of engine compt, in underhood fuse/relay center)
• G117 (rear of right cylinder head)
• Ground
• High voltage coil wire
• Hot at all times
• Hot in run or start
• Ign feed
• Ignition coil (top rear of engine)
• Ignition control module (top rear of engine, on ignition coil)
• Nca
• Pc sol vlv high
• Pc sol vlv low
• Pnk
• Radio
• Red
• S101
• S102
• S132
• S153
• S154
• S231
• S239
• Sens ground
• Sens high
• Sens low
• Serial data
• Signal return
• Signal timing ctrl elec spk
• Speed sensor input
• Tcc/stoplamp input
• Trans range a input
• Trans range b input
• Trans range c input
• Underhood fuse/relay center
• Vehicle control module (vcm) (left side of engine compartment)
• Vss output
• Vss signal

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Back-up Lamps Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (dash harness, near breakout to convenience center) s260
• Back-up lamp switch (park/neutral position switch) (left side of transmission)
• D c406
• G402 (left rear of interior, behind rear wheelhouse)
• G403 (right rear of interior, behind rear wheelhouse)
• Hot in run or start
• I/p fuse block
• Left back-up lamp
• Pnk
• Power mirror system
• Right back-up lamp
• S217
• S409
• S909
• S910
• Turn b/u fuse 16 20a
• W/ optional trailer wiring package (right rear of interior)

Exterior Lamps Wiring Diagram, with Composite Headlamps for Chevrolet RV Cutaway G2000 3500

List of elements for Exterior Lamps Wiring Diagram, with Composite Headlamps for Chevrolet RV Cutaway G2000 3500:

• (2000)
• (2001)
• (dash harness, 4 cm from head- lamp switch breakout) s225
• (forward lamp harn, 26 cm into left forward lamp harness) s142
• (forward lamp harness, 26 cm from left forward lamp breakout) s135
• (left tail- lamp harn, behind left taillamp assembly) s901
• (not used)
• (right rear of interior) w/ optional trailer wiring package)
• A10
• B c406
• B9 turn pwr b8 haz pwr b7 flshr out c8 gnd
• Center high mounted stop lamp (chmsl)
• Cruise control system
• F c406
• G100 (left front of engine compartment)
• G101 (right front of engine compartment)
• G200 (behind left kick panel)
• G402 (left rear interior, behind rear wheelhouse)
• G403 (right rear interior, behind rear wheelhouse)
• Haz sw
• Hazard
• Hazard fuse 20a
• Head
• Headlamp switch
• Hot at all times
• Hot in run or start
• I/p fuse block
• I/p relay center (under left side of dash)
• Instru- ment cluster
• Interior lights system
• Left
• Left front inner park/ turn signal lamp
• Left front outer park/ turn signal lamp
• Left front side marker lamp
• Left rear park/ stop lamp
• Left rear park/ turn lamp
• Left turn ind
• License lamp
• Normal
• Off
• Park
• Park lps fuse 9 20a
• Pnk
• Right
• Right front inner park/ turn signal lamp
• Right front outer park/ turn signal lamp
• Right front side marker lamp
• Right rear park/ stop lamp
• Right rear park/ turn lamp
• Right turn ind
• S110
• S118
• S119 (engine harness, 117 cm from underhood f/r center, towards a/c compressor breakout)
• S125 (dash harness, near windshield washer pump breakout)
• S145 (forward lamp harness, 15 cm into right forward lamps breakout)
• S202
• S217
• S222
• S236 (dash harness, 4 cm from dlc breakout)
• S237 (dash harness, near base of steering column, near cluster breakout)
• S253
• S400
• S402 (left body harn, behind left taillamp assembly)
• S903
• S909
• S910
• Stop fuse 20a
• Taillamp assembly)
• Tcc/ stop lamp switch (behind dash, on brake pedal support)
• Tn sw
• Turn- b/u fuse 16 20a
• Turn/ hazard switch
• Turn/hazard lamp flasher
• W/ optional trailer wiring package (right rear of interior)

Exterior Lamps Wiring Diagram, with Sealed Beam Headlamps for Chevrolet RV Cutaway G2000 3500

List of elements for Exterior Lamps Wiring Diagram, with Sealed Beam Headlamps for Chevrolet RV Cutaway G2000 3500:

• (2000)
• (2001)
• (dash harness, 4 cm from head- lamp switch breakout) s225
• (forward lamp harness, 26 cm from left forward lamp breakout) s135
• (left tail- lamp harn, behind left taillamp assembly) s901
• (not used)
• (right rear of interior) w/ optional trailer wiring package)
• A10
• B c406
• B9 turn pwr b8 haz pwr b7 flshr out c8 gnd
• Center high mounted stop lamp (chmsl)
• Cruise control system
• F c406
• G100 (left front of engine compartment)
• G101 (right front of engine compartment)
• G200 (behind left kick panel)
• G402 (left rear interior, behind rear wheelhouse)
• G403 (right rear interior, behind rear wheelhouse)
• Haz sw
• Hazard
• Hazard fuse 20a
• Head
• Headlamp switch
• Hot at all times
• Hot in run or start
• I/p fuse block
• I/p relay center (under left side of dash)
• Instru- ment cluster
• Interior lights system
• Left
• Left front park/turn signal lamp
• Left front side marker lamp
• Left rear park/ stop lamp
• Left rear park/ turn lamp
• Left turn ind
• License lamp
• Normal
• Off
• Park
• Park lps fuse 9 20a
• Pnk
• R100 (resistor) (6 ohms, 30 watts) (forward lamp harness, left front of vehicle near headlamp)
• Right
• Right front park/turn signal lamp
• Right front side marker lamp
• Right rear park/ stop lamp
• Right rear park/ turn lamp
• Right turn ind
• S110
• S118
• S119 (engine harness, 117 cm from underhood f/r center, towards a/c compressor breakout)
• S125 (dash harness, near windshield washer pump breakout)
• S142 (forward lamp harn, 26 cm into left forward lamp harness)
• S202
• S217
• S222
• S236 (dash harness, 4 cm from dlc breakout)
• S237 (dash harness, near base of steering column, near cluster breakout)
• S253
• S400
• S402 (left body harn, behind left taillamp assembly)
• S410 (left body harn, near chmsl connector breakout)
• S903
• S909
• S910
• Stop fuse 20a
• Taillamp assembly)
• Tcc/ stop lamp switch (behind dash, on brake pedal support)
• Tn sw
• Turn- b/u fuse 16 20a
• Turn/ hazard switch
• Turn/hazard lamp flasher
• W/ optional trailer wiring package (right rear of interior)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Chevrolet RV Cutaway G2000 3500:

• (forward lamp harness, approx 19 cm into left forward lamp breakout)
• (forward lamp harness, approx 22 cm into right forward lamp breakout)
• (i/p harness, approx 7 cm into vss buffer breakout)
• (lower i/p harness, approx 7 cm into i/p compartment lamp breakout)
• (sun shade harness, approx 7 cm from right sun shade breakout)
• (upfitter provision) c206
• (w/ upfitter provisions)
• A/t shift lock solenoid
• Ashtray lamp
• Auxiliary battery (diesel)
• Auxiliary blower motor
• Auxiliary heater switch
• Auxiliary power outlet
• Battery
• C210
• C302
• Cigarette lighter
• Convenience center
• Convenience center (left side of dash)
• Cruise test resistor connector
• Data link connector
• Daytime running lamp (drl) control module
• E13
• G100 (left side of engine compt, near fender well)
• G101 (right side of engine compt, near fender well)
• G113 (left frame rail, near auxiliary battery)
• G116 (left side of engine compt, under brake master cylinder)
• G118 (right lower front of engine)
• G119 (right frame rail, near front of engine)
• G200 (behind left kick panel)
• Headlamp switch
• Heater & a/c controller
• I/p compartment lamp
• I/p relay center
• Ignition switch
• Illuminated entry module
• Instrument cluster
• Left front park & turn signal lamp
• Left front side marker lamp
• Left headlamp (w/ sealed beam headlamps)
• Left high beam headlamp (w/ composite headlamps)
• Left low beam headlamp (w/ composite headlamps)
• Left power seat switch
• Left sun shade mirror lamp
• Low engine coolant level indicator module (diesel)
• Low engine coolant level indicator sensor (diesel)
• Multi- function alarm module
• Nca
• P/b booster fluid flow switch
• Power antenna assembly
• Power door lock control module
• Power door lock relay
• Radio
• Rear fog lamp
• Remote control door lock receiver
• Right front park & turn signal lamp
• Right front side marker lamp
• Right headlamp (w/ sealed beam headlamps)
• Right high beam headlamp (w/ composite headlamps)
• Right low beam headlamp (w/ composite headlamps)
• Right sun shade mirror lamp
• S201 (i/p harness, approx 4 cm from park brake warning switch breakout)
• S202
• S204
• S205
• S206 (crossbody harness, approx 4 cm from power door lock relay breakout)
• S257 (power seat harn, under left side of dash)
• S328
• School bus equipment
• Seat belt switch
• Side door jamb switch (w/ upfitter provisions)
• Steering column ground
• Temperature valve actuator motor
• To s500 or left front door jamb switch (diagram 2 of 4)
• To s601 or right front door jamb switch (diagram 2 of 4)
• Turn/ hazard lamp flasher
• Upfitter provisions relay
• W/ upfitter provisions
• W/o keyless entry
• Windshield washer pump motor
• Windshield wiper motor

Ground Distribution Wiring Diagram (2 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Chevrolet RV Cutaway G2000 3500:

• (at generator bracket) g125
• (engine harness, approx 4 cm from a/c compressor breakout)
• (i/p harness, approx 10 cm from park brake warning switch breakout)
• (left front door harness, approx 7 cm from power window switch breakout)
• (right front door harness, approx 7 cm from power window switch breakout)
• (underhood lamp harness, approx 4 cm from breakout to connector near blower motor)
• A/c compressor clutch
• Ambulance package
• B13
• Base
• Blower motor resistor/ relay
• Brake pressure differential switch
• Data link connector (dlc)
• Diesel engines
• Diode
• Electronic brake control module (ebcm)
• From s206 (diagram 1 of 4)
• Fuel heater
• Fuel lift pump
• Fuel pump relay
• Fuel sender buffer module
• G110 (left front of engine at a/c compressor)
• G125 (front of engine, near thermostat housing)
• G200 (behind left kick panel)
• Glow plug relay
• Horns
• Inflatable restraint front end discriminating sensor
• Inflatable restraint sensing & diagnostic module
• Instrument cluster
• Left front door jamb switch
• Left front power door lock switch
• Left front power side window switch
• Left power outside rear view mirror
• Non base
• Park/ neutral position switch
• Passlock module
• Power outside rear view mirror remote control switch
• Powertrain control module (pcm)
• Right front door jamb switch
• Right front power door lock switch
• Right front power side window switch
• Right power outside rear view mirror
• S101 (engine harness, approx 22 cm from optical fuel breakout)
• S102
• S104
• S208 (i/p harness, approx 7 cm into inflatable restraint sensing & diagnostic module breakout)
• S254
• Starter relay
• Underhood fuse/relay center
• Underhood lamp
• Underhood reel lamp
• Vehicle speed sensor buffer
• W/ nb6
• W/ tr9 lamp group
• W/o nb6
• Water-in- fuel indicator

Ground Distribution Wiring Diagram (3 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Chevrolet RV Cutaway G2000 3500:

• (4.3l)
• (5.0l, 5.7l, 7.4l)
• 4.3l 5.0l 5.7l
• 4.3l 5.7l
• 4.3l, 5.0l, 5.7l a
• 7.4l
• A/c compressor clutch
• A/c low pressure cutout switch
• Air injection reaction solenoid
• B13
• Blower motor resistor/ relay
• Brake pressure differential switch
• Cruise control module
• Data link connector (dlc)
• Diode
• Electronic brake control module (ebcm)
• Except 7.4l
• Fuel pump & sender
• Fuel pump relay
• G117 (rear of right cylinder head)
• G125 (at generator bracket)
• G125 (front of engine, near thermostat housing)
• Gasoline engines
• Heated oxygen sensor (ho2s) bank 1 sensor 1
• Heated oxygen sensor (ho2s) bank 1 sensor 3
• Heated oxygen sensor (ho2s) bank 2 sensor 1
• Heated oxygen sensor (ho2s) bank 2 sensor 2
• Horns
• Ignition control module (icm)
• Instrument cluster
• Mass airflow (maf) sensor
• Nca
• Park/ neutral position switch
• Passlock module
• S101 (4.3l: engine harn, approx 20 cm from knock sensor breakout, 5.0l, 5.7l: engine harn, approx 10 cm from ignition coil breakout, 7.4l: engine harn, approx 5 cm from generator breakout)
• S102 (4.3l-engine harness, approx 104 cm from underhood fuse/relay panel breakout, ex 4.3l-engine harness, approx 4 cm from a/c compressor breakout)
• S103 (4.3l: engine harn, approx 4 cm from fuel injector breakout, 5.0l, 5.7l: engine harn, approx 4 cm from oxygen sensor breakout, 7.4l: engine harn approx 4 cm from ect sensor breakout)
• S104 (underhood lamp harness, approx 4 cm from breakout to connector near blower motor)
• S152 (4.3l: engine harn, approx 16 cm from fuel injector breakout, 5.0l, 5.7l: engine harn, approx 4 cm from fuel injector breakout, 7.4l: engine harn approx 15 cm from oxygen sensor breakout)
• S254 (i/p harn, approx 10 cm from park brake warning switch breakout)
• Secondary air injection reaction pump
• Secondary air injection reaction pump clutch
• Starter relay
• Underhood fuse/relay center
• Underhood lamp
• Underhood reel lamp
• Vehicle control module (vcm)
• W/ hydra-matic 4l60-e or 4.3l w/ hydra-matic 4l80-e c
• W/ hydra-matic 4l80-e b
• W/ tr9 lamp group

Ground Distribution Wiring Diagram (4 of 4) for Chevrolet RV Cutaway G2000 3500

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Chevrolet RV Cutaway G2000 3500:

• (auxiliary heater & a/c harn, approx 14 cm from the front auxiliary hvac module breakout) s318
• (rear a/c harn, approx 7 cm from the o/s air valve actuator breakout) s411
• Auxiliary blower motor
• Auxiliary blower motor switch
• Back-up lamp
• Cargo
• Center high mounted stoplamp
• Front auxiliary hvac control module
• Front auxiliary hvac controller
• G998 (right rear corner of the interior of the cabin, "d" pillar)
• G999 (left rear corner of interior of cabin, "d" pillar)
• Heater & a/c control logic module
• Left back-up lamp
• Left rear park & turn signal lamp
• Left rear taillamp (park/stop)
• Left rear window defogger grid
• License lamp
• Passenger
• Rear auxiliary hvac controller
• Rear auxiliary mode vavle & seal assembly
• Rear auxiliary temperature valve assembly
• Rear fog lamp
• Rear window defogger relay
• Right back-up lamp
• Right rear door jamb switch
• Right rear park & turn signal lamp
• Right rear tail lamp (park & stop)
• Right rear window defogger grid
• S318
• S400 (left body harn, left rear of vechicle)
• S401 (left body harn, left rear of vehicle)
• S902 (rear license lamp jumper near right license lamp)
• S903 (right rear door harn, approx 29 cm from the door jamb switch breakout)
• S909 (right taillight harn, near back-up lamp breakout)
• W/ auxiliary heater
• W/ auxiliary heater or wiring provisions
• W/ rear a/c
• Wiring provisions

HEADLIGHTS

Headlight Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Headlight Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (4.3l, 6.5l)
• (5.0l, 5.7l, 7.4l)
• (at generator bracket)
• (engine harn, in eng compt) s156
• (forward lamp harn, approx 13 cm from left forward lamp breakout toward right forward lamp breakout) s143
• (rear of right cylinder head)
• 17a
• 31a
• 56b
• A17
• Acc
• B17
• Brake ind ctrl
• Brake pressure differential switch (on left frame rail near center of vehicle, part of electronic brake module)
• Brake psi in
• C200
• Composite headlamps
• Daytime running lamp diode module (under left side of dash)
• Daytime running lamp relay (under left side of dash, on lower center portion of convenience center)
• Daytime running lamps control module (under left side of dash, taped to dash harness)
• Drl fuse 15 15a
• Drl indicator
• Drl relay ctrl
• E11 c200
• E12
• E13
• Electronic brake control module
• F f
• G100 (left side of engine compt)
• G101 (right side of engine compt)
• G117
• G125
• G200 (behind left kick panel)
• Gauges fuse 4 10a
• Ground
• Head
• Headlamp dimmer switch
• Headlamp leveling switch
• Headlamp switch
• High beam indicator
• Hot at all times
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ign (run/st)
• Ign key status
• Ignition switch
• Instrument cluster
• Instrument cluster system
• Interior lights system
• Lamp feed
• Left headlamp
• Left headlamp leveling actuator
• Left high beam headlamp lamp
• Left low beam headlamp lamp
• Lighting fuse 40a
• Lock
• Logic
• Nca
• Off
• Park
• Park brake in
• Park brake warning switch (near left kick panel, on park brake lever)
• Pnk
• Red
• Right headlamp
• Right headlamp leveling actuator
• Right high beam headlamp lamp
• Right low beam headlamp lamp
• Run
• S101
• S110
• S118
• S143 (forward lamp harn, approx 13 cm from left forward lamp breakout toward right forward lamp breakout)
• S144 (forward lamp harn, approx 19 cm from left forward lamp breakout)
• S149
• S150
• S151
• S201
• S202
• S205
• S211
• S216
• Sealed beam headlamps
• Start
• Tan
• Underhood fuse/relay center (on left side of engine compt)

HORN

Horn Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Horn Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (4.3l,5.0l,5.7l,7.4l) (6.5l)
• (not used)
• A11
• C100
• C200
• G117 (5.0l, 5.7l, 7.4l) (rear of right cylinder head) g125 (4.3l, 6.5l) (at generator bracket)
• Horn brush
• Horn fuse 20a
• Horn relay
• Horn switch
• Horns (left front of engine compt)
• Hot at all times
• Nca
• S103 s101
• S127
• Turn signal switch
• Underhood fuse/relay center
• Underhood fuse/relay center (left side of engine compt)

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram (1 of 2) for Chevrolet RV Cutaway G2000 3500

List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Chevrolet RV Cutaway G2000 3500:

• (4.3l/6.5l/7.4l: left side of eng, on cylinder head, 5.0l/5.7l: left cylinder head, between two front spark plugs)
• (7 bulbs)
• (diesel only)
• (engine harn, 14 cm from knock sensor) (4.3l) (engine harn, 8 cm from injector harn breakout) (5.0/5.7l) (engine harn, 10 cm from input shaft sensor) (7.4l) (engine harn, 4 cm from brake pressure differential switch) (6.5l diesel)
• (not used)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• Acc
• Air bag ind
• Anti-lock brakes system
• Anti-lock brakes warning ind
• Anti-theft system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• Bat ind
• Brake ind ctl
• Brake lamp ctl
• Brake pressure differential switch (part of electronic brake control module, left frame rail)
• Brake psi in
• Brake warning ind
• Check gauges ind
• Check gauges lamp driver
• Daytime running lamps control module (under left side of dash, taped to harness)
• Diesel only
• Diode-i d101
• Drl lamp ind
• Electronic brake control module (ebcm) (left framerail, near center of vehicle)
• Eng-i mini fuse 20a
• Engine controls system
• Engine coolant temperature gauge sensor
• Exterior lights system
• Fuel gauge
• G101 (right side of engine compt, near fender well)
• G117 (5.0, 5.7, 7.4l) (rear of right cylinder head)
• G125 (4.3, 6.5l) (at generator bracket)
• G125 (front of engine, near thermostat housing)
• G200 (behind left kick panel)
• Gauges fuse 4 10a
• Gnd
• Headlights system
• High beam ind
• Hot in run or start
• I/p fuse block (lower left kick panel)
• Ign
• Ign feed
• Ignition switch
• Illumin- ation lamps
• Ind ctrl
• Instrument cluster
• Interior lights system
• Left turn ind
• Lock
• Low coolant ind (diesel)
• Low engine coolant level indicator module (diesel only) (under left side of dash)
• Low engine coolant level indicator sensor (diesel only) (under coolant recovery/surge tank)
• Off
• Oil pressure gauge
• Park/neutral position switch (left side of transmission)
• Pk brake
• Pnk
• Prndl circuit board
• Right turn ind
• Run
• S101
• S118
• S130
• S156
• S201
• S202
• S216
• S254
• Safety belt ind
• Security ind
• Service engine soon ind
• Service throttle soon ind (diesel)
• Solid state
• Speedometer/ odometer
• Start
• Starting/charging system
• Tan
• Temp gauge
• Underhood fuse/relay center (left side of eng compt)
• Underhood fuse/relay center (on left side of eng compt)
• Volt- meter
• Wait to start ind (diesel)
• Warning system
• Water in fuel ind (diesel)
• Water-in-fuel sensor (diesel only) (left frame rail, near center of vehicle)

Instrument Cluster Wiring Diagram (2 of 2) for Chevrolet RV Cutaway G2000 3500

List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Chevrolet RV Cutaway G2000 3500:

• (behind center of dash)
• (diesel only)
• (i/p harn, approx 21 cm from hvac switch breakout) s247
• +5v ref
• 1.5k
• Anti-lock brakes system
• Batt
• Brake fuse 18 10a
• Diesel
• Engine oil pressure gauge sender (top rear of engine)
• Engine oil pressure gauge sensor (top rear of engine)
• Fuel level
• Fuel pump & sender (in fuel tank)
• Fuel sender buffer module
• Fuel sig
• Fuel tank level sender (in fuel tank)
• G116 (left side of engine compt, under brake master cylinder)
• G125 (front of engine, near thermostat housing)
• Gasoline
• Gnd
• Hot in acc or run
• Hot in run
• I/p fuse block (lower left kick panel)
• Ign
• Ignition
• Inline diode d202 (near park brake switch)
• Low flow
• Low pres.
• P/b booster fluid flow & pressure alarm delay module
• P/b booster fluid flow alarm
• P/b booster fluid flow alarm switch
• P/b booster fluid pressure alarm switch
• Park brake warning switch
• Passlock module (behind center of dash)
• Pnk
• Powertrain control module (behind center of dash)
• Radio
• Resistor r208 (w/ uj1) (near i/p fuse block)
• S210
• S238 (i/p harn, 4 cm from cluster breakout)
• S246 (i/p harn, approx 25 cm from hvac switch breakout)
• S254
• Sens gnd
• Sense sw
• Sig in
• Tan
• Tank signal
• Trans fuse 20 10a
• Twisted pair
• Vehicle control module (on left side of eng compt)
• Vehicle speed sensor (left side of transmission)
• Vehicle speed sensor buffer (diesel only) (below dash, near steering column)
• Vss high
• Vss low
• Vss out
• Vss sen
• W/ p/b booster warning option, rpo code-uj1

INTERIOR LIGHTS

Interior Light Wiring Diagram (1 of 2) for Chevrolet RV Cutaway G2000 3500

List of elements for Interior Light Wiring Diagram (1 of 2) for Chevrolet RV Cutaway G2000 3500:

• (base: body harn, approx 36 cm to rear of front dome lamp breakout)
• (body harn, approx 6 cm to rear of front dome lamp breakout)
• (crossbody harn, 9 cm to right of in-line conn breakout, toward convenience center breakout)
• (front crossbody harn, approx 23 cm from right kick panel)
• (i/p harn, 11 cm from breakout to headlamp switch) s226
• (i/p harn, 4 cm
• (left front door harn) s501
• (left kick panel)
• (right front door harn) s603
• (rke=remote keyless entry)
• (upfitter: body harn, approx 150 cm from convenience center breakout)
• A nca
• Ash- tray lamp
• Battery
• Bright adjust
• Center dome & reading lamp
• Ctsy fuse 3 20a
• Dome lamp
• Dome lamp override switch
• Dome switch
• Dr jamb sw
• From breakout to hvac controls)
• Front dome & reading lamp
• G200
• G200 (behind left kick panel)
• G200 (left kick panel)
• G403 (right rear interior, behind rear wheelhouse)
• Gauges fuse 4 10a
• Ground
• Headlamp switch
• Hot at all times
• Hot in run & start
• I/p compart- ment lamp
• I/p fuse block
• Ignition
• Illuminated entry module (on right lower kick panel)
• Lamp
• Left front door jamb switch
• Left front power door lock switch
• Left front power window switch
• Left stepwell lamp
• Left sunshade mirror lamp
• Nca
• Non- base only
• Parade mode switch
• Park lps fuse 9 20a
• Park switch
• Pnk
• Power door lock control module (on left kick panel)
• Pwr accy fuse a 25a
• Reading lamps
• Rear dome & reading lamp
• Rear door jamb switch
• Remote control door lock receiver (behind center of dash)
• Right front door jamb switch
• Right front power door lock switch
• Right front power window switch
• Right stepwell lamp
• Right sunshade mirror lamp
• S201
• S204
• S205
• S206
• S216
• S225
• S227
• S228
• S230
• S232
• S240
• S306
• S308 (sunshade illuminated mirror harn, 7 cm from right sunshade breakout)
• S406
• S903
• Side door jamb switch
• Side stepwell lamp
• To i/p fuse block (diagram 2 of 2)
• To s224 (diagram 2 of 2)
• W/ power door locks
• W/ rke
• W/o power door locks
• W/o rke

Interior Light Wiring Diagram (2 of 2) for Chevrolet RV Cutaway G2000 3500

List of elements for Interior Light Wiring Diagram (2 of 2) for Chevrolet RV Cutaway G2000 3500:

• (4.3l & diesel only)
• (all others)
• (auxiliary heat w/ a/c)
• (auxiliary heat)
• (base)
• (gasoline)
• (gasoline) (diesel)
• (i/p harn, 4 cm from breakout to headlamp switch)
• (i/p harn, approx 17 cm from radio breakout) s223
• (non- base)
• (non-base)
• (passenger)
• (rear aux htr & a/c harn, approx 7 cm from rear aux hvac module breakout) s310
• Auxiliary blower motor switch
• B10
• B12
• B13
• From headlamp switch (diagram 1 0f 2)
• Front auxiliary hvac control module
• G117 (right rear of engine)
• G119 (right front of engine)
• G125 (front of engine, near thermostat housing)
• G200 (behind left
• G402 (left rear interior, behind rear wheelhouse)
• Heater & a/c controller
• Horn fuse 20a
• Hot at all times
• Hot in accy & run
• Hot in run
• I/p fuse block
• Illum fuse 14 10a
• Instrument cluster
• Kick panel)
• Multi function alarm module
• Nca
• Odometer
• Pnk
• Prndl
• Radio
• Radio-i fuse 17 10a
• Rear auxiliary hvac control module
• Remote cd player
• S102 (gasoline)
• S103
• S104
• S127
• S148
• S152 s101
• S201
• S202
• S220
• S224
• S254 (diesel)
• S318
• S400
• Trans fuse 20 10a
• Under- hood lamp
• Under- hood reel lamp
• Underhood fuse/relay center

POWER ANTENNA

Power Antenna Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Power Antenna Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• G200 (behind left kick panel)
• Hot at all times
• I/p fuse block (on left lower
• Pnk
• Power antenna assembly (right front fender)
• Radio
• Radio-b fuse 19 10a
• S202
• S219
• Side of dash)
• Solid state

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 5) for Chevrolet RV Cutaway G2000 3500

List of elements for Power Distribution Wiring Diagram (1 of 5) for Chevrolet RV Cutaway G2000 3500:

• (crossbody harness, approx 4 cm from convenience center conn breakout)
• (engine harn, top of engine)
• (i/p harness, approx 4 cm into tcc/stoplamp switch breakout)
• (rear a/c harn, approx 23 cm from blower motor resistor/ relay breakout) s412
• (rear a/c harness, approx 7 cm from blower motor resistor breakout)
• (rear aux htr and a/c harness, approx 29 cm from rear aux hvac module breakout)
• A13
• Abs fuse 60a
• Acc
• Ambulance
• Aux-a fuse 50a
• Aux-b fuse 50a
• Auxiliary battery
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Battery
• Battery junction block
• Blower fuse 60a
• Blower motor resistor relay
• Brake fuse 18 10a
• C202
• C206
• C210
• C302
• Convenience center
• Crank fuse 8 10a
• Cruise control module (gasoline)
• Cruise control switch
• Cruise fuse 6 10a
• Diesel
• Electronic brake control module (ebcm)
• From aux-a fuse (diagram 1 of 5)
• Front auxiliary hvac control module
• Fusible link (10 ga- rust)
• Fusible link (10 ga-rust)
• G200 (behind left kick panel)
• Gasoline
• Generator
• Glowplug relay
• Heater & a/c controller
• Heater & a/c control logic module
• Htr a/c fuse 12 20a
• I/p fuse block
• Ign-a fuse 40a
• Ign-b fuse 50a
• Ignition switch
• Left front power side window switch
• Lock
• Nca
• Off
• P/b booster fluid low alarm
• Park/ neutral position switch
• Passenger
• Pnk
• Pwr wdo fuse b 25a
• Radio
• Radio 1 fuse 17 10a
• Rear auxiliary hvac control module
• Rear auxiliary mode valve and seal assembly
• Rear auxiliary temperature valve assembly
• Red
• Resistor
• Right front power side window switch
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• Run
• S122
• S201
• S210
• S213
• S220
• S229
• S252
• S307
• S311
• S312
• S404
• S405
• Start
• Starter relay
• Starter solenoid
• Tcc/ stoplamp switch
• Temperature valve actuator motor
• To s214 (diagram 3 of 5)
• To trans fuse (diagram 4 of 5)
• To underhood fuse-relay center (diagram 2 of 5)
• To upfitter provision relay (diagram 1 of 5)
• Underhood fuse/relay center
• Upfitter provision connector
• Upfitter provision relay (behind left b pillar)
• Vehicle control module (vcm) (gasoline)
• W/ rear a/c
• Windshield washer/ wiper switch
• Windshield wiper motor
• Wiper fuse 11 25a

Power Distribution Wiring Diagram (2 of 5) for Chevrolet RV Cutaway G2000 3500

List of elements for Power Distribution Wiring Diagram (2 of 5) for Chevrolet RV Cutaway G2000 3500:

• (4.3l, 5.0l, 5.7l)
• (6.5l, 5.0l, 5.7l: engine harness, approx 11-19 cm from bulkhead connector, 4.3l, 7.4l: engine harness, approx 65cm from underhood fuse relay center) s127
• (6.5l: engine harn, approx 4 cm into into main harness breakout, 4.3l: engine harn, approx 19 cm from bulkhaed connector) s120 (4.3l & 6.5l)
• (crossbody harn, approx 14 cm from power door lock relay breakout) s232
• (crossbody harness, left side of dash) s228
• (i/p harn, 4 cm from radio breakout) s219
• (i/p harn, 7 cm from instrument cluster breakout) s218
• (i/p harn, approx 37 cm from bulkhead connector) s212
• (i/p harn, approx 8 cm into i/p relay center breakout) s222
• (i/p harness, approx 4 cm into power seat breakout)
• (i/p harness, approx 9 cm from radio breakout) s227
• (left body harn, 150 cm from convenience center connector s406
• (left body harn, left interior roof panel) s406
• (sun shade illum mirror harness, approx 7 cm from right sun shade lamp breakout) s308
• (underhood lamp harn, approx 11 cm from reel lamp connector breakout) s148
• (w/ lamp option)
• 4.3l & 6.5l
• 5.0l, 5.7l, & 7.4l
• A.i.r. fuse 30a
• A.i.r. relay
• A/c compressor enable relay
• A/c compressor fuse 10a
• Auxiliary power outlet
• Batt fuse 50a
• C13
• C202
• C210
• Center dome lamp
• Cig ltr fuse 13 20a
• Cigarette lighter
• Convenience center
• Ctsy fuse 3 20a
• D13
• Data link connector (dlc)
• Daytime running lamp (drl) diode module
• Drl fuse 15 15a
• Ecm-b fuse 20a
• From underhood b fuse-relay center (diagram 1 of 5)
• From underhood fuse-relay center (diagram 1 of 5)
• Front dome lamp
• Fuel pump relay
• G200 (behind left kick panel)
• Hazard fuse 5 20a
• Hazard warning switch
• Headlamp switch
• Heater & a/c controller
• Horn fuse 20a
• Horn relay
• Htd mir fuse 2 20a
• I/p compartment lamp
• I/p fuse block
• Illuminated entry module
• Left front power door lock switch
• Left power seat switch
• Left stepwell lamp
• Left sun shade mirror lamp
• Lighting fuse 40a
• Multi- function alarm module
• Park lps fuse 9 20a
• Passlock module
• Power antenna assembly
• Power door lock control module
• Power door lock relay
• Power outside rear view mirror remote control switch
• Powertrain control module (pcm) (diesel)
• Pwr accy fuse a 25a
• Pwr aux fuse 7 25a
• Radio
• Radio-b fuse 19 10a
• Rear dome lamp
• Rear window defogger relay
• Red
• Remote control door lock receiver
• Right front power door lock switch
• Right power seat switch
• Right rear power door lock switch
• Right stepwell lamp
• Right sun shade mirror lamp
• Rr defog fuse 22 25a
• S205
• S211 (i/p harness, approx 4 cm from park brake warning switch breakout)
• S221
• Security fuse 21 10a
• Side door lock control
• Side stepwell lamp
• Stop fuse 1 20a
• Tcc/ stop- lamp switch
• Underhood fuse/relay center
• Underhood lamp
• Underhood reel lamp (w/ lamp option)
• Vehicle control module (vcm) (gasoline)
• W/ electric a
• W/ upfitter
• W/o upfitter

Power Distribution Wiring Diagram (3 of 5) for Chevrolet RV Cutaway G2000 3500

List of elements for Power Distribution Wiring Diagram (3 of 5) for Chevrolet RV Cutaway G2000 3500:

• (engine harn, approx 15 cm into fuel injector harness breakout) s133
• (engine harn, approx 4 cm from fuel injector harness breakout) s132
• (engine harn, approx 8 cm from fuel injector harness breakout) s132
• (engine harn, approx 8 cm from fuel injector harness breakout) s133
• (engine harness, approx 11 cm into main harness breakout) s117
• (engine harness, approx 4 cm from egr valve breakout) s132
• (engine jumper harn, approx 2 cm from the optical fuel temperature sensor breakout) s108
• (fed) (cal)
• 4.3l
• 4.3l, 5.0l, 5.7l
• 5.0l, 5.7l
• 6.5l
• 6.5l & 7.4l
• 7.4l
• A/c compressor enable relay
• C11
• C12
• Crankshaft position (ckp) sensor
• Ecm-1 fuse 20a
• Epr solenoid
• From ignition switch (diagram 1 of 5)
• Fuel injectors 1, 3 & 5
• Fuel injectors 1, 3, 5 & 7
• Fuel injectors 1, 3, 5, & 7
• Fuel injectors 2, 4 & 6
• Fuel injectors 2, 4, 6 & 8
• Fuel injectors 2, 4, 6, & 8
• Glow plug relay
• Ign-e fuse 10a
• Ignition coil
• Ignition control module (icm)
• Pnk
• Powertrain control module (pcm)
• S214 (i/p harn, approx 17 cm from bulkhead connector)
• To eng-1 fuse (diagram 5 of 5)
• To i/p fuse block (diagram 4 of 5)
• Underhood fuse/relay center
• Vehicle control module (vcm)
• Waste gate solenoid

Power Distribution Wiring Diagram (4 of 5) for Chevrolet RV Cutaway G2000 3500

List of elements for Power Distribution Wiring Diagram (4 of 5) for Chevrolet RV Cutaway G2000 3500:

• (i/p harness, approx 30 cm from bulkhead connector) s217
• (i/p harness, approx 8 cm from bulkhead connector breakout) s216
• Air bags fuse 10 10a
• Automatic transmission
• B10
• B17
• Base
• C210
• Convenience center
• Daytime running lamp (drl) control module
• Daytime running lamp (drl) relay
• Except base
• From ignition switch (diagram 1 of 5)
• From s214 (diagram 3 of 5)
• Fuel sender buffer module (diesel)
• Gauges fuse 4 10a
• Hazard warning switch
• Headlamp switch
• I/p fuse block
• I/p relay center
• Illum fuse 14 10a
• Illuminated entry module
• Inflatable restraint sensing & diagnositc control module
• Instrument cluster
• Interior lights system
• Interior lights system (i/p dimmer switch)
• Low engine coolant level indicator module (diesel)
• Multi- function alarm module
• Park/neutral position switch
• Passlock module
• Pnk
• Remote control door lock receiver or vehicle immobilizer module
• Trans fuse 20 10a
• Turn b/u fuse 16 20a
• Vehicle speed sensor buffer (diesel)

Power Distribution Wiring Diagram (5 of 5) for Chevrolet RV Cutaway G2000 3500

List of elements for Power Distribution Wiring Diagram (5 of 5) for Chevrolet RV Cutaway G2000 3500:

• (4.3l: engine harn, approx 117 cm from the underhood fuse/relay center, 5.0l & 5.7l: engine harn, approx 12 cm from the heated right oxygen sensor breakout) s130
• (engine harn jumper, approx 4 cm into the engine shutoff solenoid breakout) s107
• (engine harn, approx 5 cm from the ckp sensor breakout) s130
• 4.3l & 5.0l or 5.7l w/o a.i.r. injection reaction system
• 5.7l w/ a.i.r. injection reaction system
• 6.5l
• 7.4l
• A.i.r. relay
• Calif
• Camshaft position (cmp) sensor
• Crankshaft position (ckp) sensor
• Eng-1 fuse 20a
• Evaporative emission (evap) canister purge valve
• Evaporative emission (evap) canister vent valve
• Evaporative emission (evap) canister vent valve (calif)
• Federal
• From ecm-1 fuse (diagram 3 of 5)
• Fuel heater
• Fuel shutoff solenoid
• Fuel solenoid driver
• Heated oxygen sensor (ho2s) bank 1 sensor 1
• Heated oxygen sensor (ho2s) bank 1 sensor 3 (4.3l)
• Heated oxygen sensor (ho2s) bank 1 sensor 3 (5.0l & 5.7l)
• Heated oxygen sensor (ho2s) bank 1 sensor 3 (calif)
• Heated oxygen sensor (ho2s) bank 2 sensor 1
• Heated oxygen sensor (ho2s) bank 2 sensor 1 (calif)
• Heated oxygen sensor (ho2s) bank 2 sensor 2
• Mass airflow (maf) sensor
• Pnk
• S130 (engine harn, left top of engine)
• S131 (engine harn, approx 6cm from the map sensor breakout)
• Underhood fuse/relay center
• W/ a.i.r. injection reaction system
• Water- in-fuel sensor

POWER DOOR LOCKS

Power Door Lock Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Power Door Lock Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (crossbody harn, near power lock relay breakout) s243
• Batt (b+)
• Battery (b+)
• C210
• Convenience center (under left side of dash)
• Data link connector (under left side of dash)
• Dome lamps
• Dome lmp off
• Door lock control module (on left kick panel)
• Driver door lock actuator
• Driver dr unlk
• Driver power door lock switch
• Front passenger door lock actuator
• Front passenger power door lock switch
• G200 (left kick panel)
• Gauges fuse 4 10a
• Ground
• Hot at all times
• Hot in run, bulb test or start
• I/p fuse block (on left lower kick panel)
• Ignition
• Int lts in
• Interior lights system
• Lock
• Lock out
• Lock sig
• Pass drs unlk
• Pnk
• Power door lock relay (behind center of dash)
• Program sig
• Pwr accy fuse a 25a
• Rear cargo door lock switch
• Rear door lock actuator
• Remote control door lock receiver (behind center of dash)
• Rr door unlk
• S206
• S216
• S221
• S228
• S241 (crossbody harness, near power lock relay breakout)
• S242 (crossbody harn, near power lock relay breakout)
• S244 (crossbody harness, near power lock relay breakout)
• Side door contactor (right "b" pillar)
• Side door jamb switch
• Side door lock actuator
• Side door sw
• Tan
• Unlock
• Unlock in
• Unlock sig

POWER MIRRORS

Power Mirror Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Power Mirror Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (behind left kick panel) g200
• (left front door harness, approx 15 cm from power mirror motor connector)
• (right front door harness, approx 15 cm from power mirror switch connector)
• Ctsy fuse 3 20a
• Driver outside rearview mirror
• Hot at all times
• I/p fuse block
• Left mirror
• Outside rearview mirror switch
• Passenger outside rearview mirror
• Right mirror
• Right/ left motor
• S232
• S500
• S502
• S604
• Up/ down motor

POWER SEATS

Power Seat Wiring Diagrams for Chevrolet RV Cutaway G2000 3500

List of elements for Power Seat Wiring Diagrams for Chevrolet RV Cutaway G2000 3500:

• All- down
• All-up
• Back
• C306
• C307
• Down
• Driver seat adjuster switch
• Driver seat forward/ rearward, front vertical, rear vertical motor
• Entire seat
• For- ward
• Front down
• Front passenger seat adjuster switch
• Front passenger seat forward/ rearward, front vertical, rear vertical motor
• Front up
• G200 (behind left kick panel)
• Hot at all times
• I/p fuse block
• Left power seat forward/ rearward motor
• Left power seat front tilt motor
• Left power seat rear tilt motor
• Nca
• Pwr accy fuse a 25a
• Rear down
• Rear up
• Red
• Right power seat forward/ rearward motor
• Right power seat front tilt motor
• Right power seat rear tilt motor
• S256
• S257
• Tan

POWER WINDOWS

Power Window Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Power Window Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (left kick panel) g200
• C210
• Convenience center (left side of dash)
• Driver window motor
• Driver window switch
• Front passenger window motor
• Front passenger window switch
• Hot in accy & run
• I/p fuse block (on lower left kick panel)
• Interior lights system
• Left
• Power wdo fuse b 25a
• Right
• S229
• S500
• Tan

RADIO

Radio Wiring Diagrams for Chevrolet RV Cutaway G2000 3500

List of elements for Radio Wiring Diagrams for Chevrolet RV Cutaway G2000 3500:

• (left front door harn, approx 13cm from radio speaker breakout) s504
• (left front door harn, approx 7cm from radio speaker breakout) s503
• (right body harn, near center high mounted stoplamp breakout) s423
• (right body harn, near center high mounted stoplamp breakout) s424
• Antenna
• Anti-theft system
• Audio rtn
• Base
• Battery
• Convenience center (left side of dash)
• Diesel
• Dim ctrl
• Dim sig in
• Dim sig out
• Drain
• E&c line
• Except
• G200 (behind left kick panel)
• Gasoline
• Ground
• Hot at all times
• Hot in acc or run
• I/p fuse block
• Ignition
• Illuminaton
• Interior lights system
• Left front door speaker
• Left front door tweeter speaker
• Left overhead speaker
• Left rear door speaker
• Lf +
• Lf -
• Line
• Lr +
• Lr -
• Lt input
• Lt output
• Nca
• Pnk
• Power antenna assembly
• Premium
• Pwr antenna
• R14 in
• R14 out
• Radio
• Radio i fuse 17 10a
• Radio-b fuse 19 10a
• Red
• Remote compact disk player (below radio)
• Rf +
• Rf -
• Right front door speaker
• Right front door tweeter speaker
• Right overhead speaker
• Right rear door speaker
• Rr +
• Rr -
• Rt input
• Rt output
• S202
• S219
• S220
• S239 (i/p harn, approx 10cm into radio breakout)
• S407 (left body harn near left "b" pillar)
• S419 (left body harn, near left "b" pillar)
• S605 (right front door harn, approx 7cm from power window motor breakout)
• S606 (right front door harn, approx 4cm from power window motor breakout)
• Tan
• Vehicle control module (left side of engine compt)
• Vehicle speed sensor buffer (below dash, near steering column)
• Vss signal
• W/ upfitter
• W/o upfitter

SHIFT INTERLOCKS

Shift Interlock Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Shift Interlock Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• A/t shift lock solenoid (right side of steering column)
• G200 (behind left kick panel)
• Hot in run or start
• I/p fuse block
• Park/ neutral position switch (left side of transmission) c1
• Pnk
• S201
• S217 pnk
• Turn/ hazard switch
• Turn/bu fuse 16 20a

STARTING/CHARGING

Charging Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Charging Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (100a) (124a)
• (not used)
• (right side of engine compartment, near fender well) g101
• B l
• B16
• B17
• Battery
• Battery junction block (next to radiator)
• Charge indicator
• Fusible link (10 ga- rust)
• Gas engines
• Gauges fuse 4 10a
• Generator
• Generator (w/ ambulance package)
• Hot in run & start
• I/p fuse block (on left lower kick panel)
• Instrument cluster
• Pnk
• Power distribution system
• Red
• S158 (w/ambulance package) (engine harness, approximately 4 cm (1.6 in) from ground breakout, front of right cylinder head, toward a/c compressor)
• S216
• Starting/charging system (starting circuit)
• Stud

Starting Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Starting Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (6.5l, 4.3l) g125 (5.0l, 5.7l, 7.4l) g117 (6.5l, 4.3l: at generator bracket) (5.0l, 5.7l, 7.4l: rear of right cylinder head)
• (right side of engine compartment, near fender well) g101
• Accy
• Auxiliary battery
• Batt
• Battery
• Battery junction block
• Crank fuse 8 10a
• Diesel
• Fusible link (10 ga- rust)
• G113 (left frame rail, near auxiliary battery)
• Gas
• Generator
• Hold- in winding
• I/p fuse block (on left lower kick panel)
• Ign-a fuse 40a
• Ignition switch
• Label stud
• Lock
• Off
• Orange
• Park/neutral position switch (on left side of transmission)
• Power distribution system
• Pull- in winding
• Red
• Run
• Start
• Starter motor
• Starter relay (in underhood fuse/relay center)
• Underhood fuse/relay center (on left side of engine compartment)
• White

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Supplemental Restraint Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (i/p harness, approx 39 cm into inflatable restraint sensing & diagnostic module) s209
• A16
• Air bag indicator
• Air bags fuse 10 10a
• B nca
• B17
• Bar
• Data link connector (dlc) (under left side of dash)
• Driver side high
• Driver side low
• G200 (behind left kick panel)
• G200 (left kick panel)
• Gauges fuse 4 10a
• Ground
• Hot in run & start
• I/p fuse block (on lower left kick panel)
• Ignition
• Indicator ctrl
• Inflatable restraint diagnostic resistor
• Inflatable restraint front end discriminating sensor (on front of vehicle)
• Inflatable restraint i/p module
• Inflatable restraint sensing & diagnostic module (under left front seat)
• Inflatable restraint steering wheel module
• Inflatable restraint steering wheel module coil
• Instrument cluster
• Multi-function alarm module (under left side of dash)
• Nca
• Ohms
• Pass side high
• Pass side low
• Pnk
• S201 (i/p harness, near breakout to park brake warning switch)
• S208 (approximately 7 cm into inflatable restraint sensing & diagnostic module)
• S216 (i/p harn, 8 cm from breakout to conn at base of steering column)
• Seat belt sw
• Seat belt switch (open when buckled) (at driver's stationary belt connector)
• Sensor input
• Serial data
• Shorting
• Shorting bar
• Tan
• W/ pass sir
• W/o pass sir

TRANSMISSION

5.7L

5.7L VIN R, A/T Wiring Diagram, 4L60-E for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, A/T Wiring Diagram, 4L60-E for Chevrolet RV Cutaway G2000 3500:

• (dash harn, near
• (eng harn, 98 cm
• 1-2 shift sol
• 1-2 ss
• 2-3 shift sol
• 2-3 ss
• 3-2 downshift sol
• 3-2 ss
• 5v reference
• A/t fluid pressure manual valve position switch
• Anti-lock brakes system
• Anti-lock brakes system (electronic brake control module)
• Automatic transmission (4l60-e)
• B17
• Battery in
• Brake fuse 18 10a
• Brake switch input
• Cruise control system
• Data class ii
• Data link connector (dlc) (partial) (under left side of dash)
• Ecm-b fuse 20a
• Ecm-i fuse 20a
• Ect sens input
• Engine controls system
• Engine controls system (fuel injectors)
• Engine controls system (fuel pump relay)
• Engine coolant temperature (ect) sensor (on top front of engine)
• From underhood fuse block, toward a/c compressor clutch breakout)
• G125 (front of engine, near thermostat housing)
• Gauges fuse 4 10a
• Hot at all times
• Hot in off, run, or start
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition in
• Instrument cluster
• Malfunction indicator lamp
• Mil control
• Park brake warning switch breakout)
• Passlock module, fuel sender buffer module, headlamp leveling switch, multifunction alarm module, vehicle speed sensor buffer, low engine coolant level indicator module, convenience center, drl control module, headlamp switch, ip relay center, left/right headlamp leveling actuators
• Pcm ground
• Pcs sol hi out
• Pcs sol lo out
• Pnk
• Pressure control solenoid valve
• Range signal "a"
• Range signal "b"
• Range signal "c"
• Red
• S102
• S120
• S122
• S132
• S133 (5.0l & 5.7l only) pnk
• S136 (engine harn)
• S139 (eng harn)
• S153 (eng harn)
• S154
• S210
• S216
• S231
• Sensor ground
• Sensor return
• Tan
• Tcc pwm sol
• Tcc sol
• Tcc/abs/ cruise switch
• Tcc/stoplamp switch (behind dash, on brake pedal support)
• Throttle position (tp) sensor (on side of throttle body)
• Tp sens input
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans temp sig in
• Underhood fuse/relay center (on left side of engine compt)
• Vehicle control module (vcm) (on left side of engine compt)
• Vehicle speed sensor (vss) (on left side of transmission)
• Vss hi (signal)
• Vss lo (ground)

5.7L VIN R, A/T Wiring Diagram, 4L80-E for Chevrolet RV Cutaway G2000 3500

List of elements for 5.7L VIN R, A/T Wiring Diagram, 4L80-E for Chevrolet RV Cutaway G2000 3500:

• (dash harn, near
• (eng harn, 98 cm
• 2-3 shift sol
• 2-3 ss
• 3-2 shift sol
• 3-2 ss
• 5v reference
• A/t fluid pressure manual valve position switch
• A/t iss hi
• A/t iss lo
• Anti-lock brakes system
• Anti-lock brakes system (electronic brake control module)
• Automatic transmission (4l80-e)
• Automatic transmission input shaft speed sensor (on left side of transmission)
• B17
• Battery in
• Brake fuse 18 10a
• Brake switch input
• Cruise control system
• Data class ii
• Data link connector (dlc) (partial) (under left side of dash)
• Ecm-b fuse 20a
• Ecm-i fuse 20a
• Ect sens input
• Engine controls system
• Engine controls system (fuel injectors)
• Engine controls system (fuel pump relay)
• Engine coolant temperature (ect) sensor (on top front of engine)
• From underhood fuse block, toward a/c compressor clutch breakout)
• G125 (front of engine, near thermostat housing)
• Gauges fuse 4 10a
• Hot at all times
• Hot in off, run, or start
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition in
• Instrument cluster
• Malfunction indicator lamp
• Mil control
• Park brake warning switch breakout)
• Passlock module, fuel sender buffer module, headlamp leveling switch, multifunction alarm module, vehicle speed sensor buffer, low engine coolant level indicator module, convenience center, drl control module, headlamp switch, ip relay center, left/right headlamp leveling actuators
• Pcm ground
• Pcs sol hi out
• Pcs sol lo out
• Pnk
• Pressure control solenoid valve
• Range signal "a"
• Range signal "b"
• Range signal "c"
• Red
• S102
• S120
• S122
• S132
• S133 (5.0l & 5.7l only) pnk
• S136 (engine harn)
• S139 (eng harn)
• S153 (eng harn)
• S154
• S210
• S216
• S231
• Sensor ground
• Sensor return
• Tcc pwm sol
• Tcc/abs/ cruise switch
• Tcc/stoplamp switch (behind dash, on brake pedal support)
• Throttle position (tp) sensor (on side of throttle body)
• Tp sens input
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans temp sig in
• Underhood fuse/relay center (on left side of engine compt)
• Vehicle control module (vcm) (on left side of engine compt)
• Vehicle speed sensor (vss) (on left side of transmission)
• Vss hi (signal)
• Vss lo (ground)

6.5L

6.5L VIN F, A/T Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for 6.5L VIN F, A/T Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (engine harn, left top of engine) s124
• (ip harn, 23 cm from vss buffer module breakout)
• 1-2 shift sol
• 1-2 ss
• 2-3 shift sol
• 2-3 ss
• A/t fluid pressure manual valve position switch
• A/t iss sens hi
• A/t iss sens lo
• A12
• Accelerator pedal position (app) module (below dash, attached to accelerator pedal)
• Anti-lock brakes system (electronic brake control module)
• App 1 5v ref
• App 1 sig
• App 2 5v ref
• App 2 sig
• App 3 5v ref
• App 3 sig
• Automatic transmission (4l80-e)
• Automatic transmission input shaft speed sensor (on left side of transmission)
• B10
• B12
• B17
• Battery in
• C11
• C12
• C13
• C14
• C15
• D11
• D12
• D13
• Data link connector (dlc) (partial) (under left side of dash)
• Ecm-b fuse 20a
• Ecm-i fuse 20a
• Ect sens sig
• Engine controls system
• Engine controls system (fuel pump relay)
• Engine coolant temperature (ect) sensor (on top front of engine)
• Exterior lights system
• G125 (at generator bracket)
• G125 (front of engine, near thermostat housing)
• Gauges fuse 4 10a
• Ground
• Hot at all times
• Hot in off, run, or start
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ign
• Ign in
• Instrument cluster
• Malfunction indicator lamp
• Mil control
• Passlock module, fuel sender buffer module, headlamp leveling switch, multifunction alarm module, low engine coolant level indicator module, convenience center, drl control module, headlamp switch, ip relay center, left/right headlamp leveling actuators
• Pc sol valve hi
• Pc sol valve lo
• Pcm ground
• Pnk
• Powertrain control module (pcm) (behind center of dash)
• Pressure control solenoid valve
• Red
• S102
• S115 (engine jumper harn, near optical fuel temp sensor breakout)
• S117
• S120
• S153 (eng harn)
• S216
• S238
• S254
• Sens ground
• Serial data class ii
• Sound systems (radio)
• Stop fuse 1 20a
• Stoplamp sw in
• Stoplamp switch
• Tan
• Tcc pwm sol
• Tcc/stoplamp switch (behind dash, on brake pedal support)
• Tft sens sig
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans range "a"
• Trans range "b"
• Trans range "c"
• Underhood fuse/relay center (on left side of engine compt)
• Vehicle speed sensor (vss) (on left side of transmission)
• Vehicle speed sensor buffer module (under glove box)
• Vss hi (signal)
• Vss in
• Vss lo (ground)
• Vss out

7.4L

7.4L VIN J, A/T Wiring Diagram, 4L60-E for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, A/T Wiring Diagram, 4L60-E for Chevrolet RV Cutaway G2000 3500:

• (dash harn, near
• (eng harn, 98 cm
• 1-2 shift sol
• 1-2 ss
• 2-3 shift sol
• 2-3 ss
• 3-2 downshift sol
• 3-2 ss
• 5v reference
• A/t fluid pressure manual valve position switch
• Anti-lock brakes system
• Anti-lock brakes system (electronic brake control module)
• Automatic transmission (4l60-e)
• B17
• Battery in
• Brake fuse 18 10a
• Brake switch input
• Cruise control system
• Data class ii
• Data link connector (dlc) (partial) (under left side of dash)
• Ecm-b fuse 20a
• Ecm-i fuse 20a
• Ect sens input
• Engine controls system
• Engine controls system (fuel injectors)
• Engine controls system (fuel pump relay)
• Engine coolant temperature (ect) sensor (on top front of engine)
• From underhood fuse block, toward a/c compressor clutch breakout)
• G125 (front of engine, near thermostat housing)
• Gauges fuse 4 10a
• Hot at all times
• Hot in off, run, or start
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition in
• Instrument cluster
• Malfunction indicator lamp
• Mil control
• Park brake warning switch breakout)
• Passlock module, fuel sender buffer module, headlamp leveling switch, multifunction alarm module, vehicle speed sensor buffer, low engine coolant level indicator module, convenience center, drl control module, headlamp switch, ip relay center, left/right headlamp leveling actuators
• Pcm ground
• Pcs sol hi out
• Pcs sol lo out
• Pnk
• Pressure control solenoid valve
• Range signal "a"
• Range signal "b"
• Range signal "c"
• Red
• S102
• S120
• S122
• S132
• S133 (5.0l & 5.7l only) pnk
• S136 (engine harn)
• S139 (eng harn)
• S153 (eng harn)
• S154
• S210
• S216
• S231
• Sensor ground
• Sensor return
• Tan
• Tcc pwm sol
• Tcc sol
• Tcc/abs/ cruise switch
• Tcc/stoplamp switch (behind dash, on brake pedal support)
• Throttle position (tp) sensor (on side of throttle body)
• Tp sens input
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans temp sig in
• Underhood fuse/relay center (on left side of engine compt)
• Vehicle control module (vcm) (on left side of engine compt)
• Vehicle speed sensor (vss) (on left side of transmission)
• Vss hi (signal)
• Vss lo (ground)

7.4L VIN J, A/T Wiring Diagram, 4L80-E for Chevrolet RV Cutaway G2000 3500

List of elements for 7.4L VIN J, A/T Wiring Diagram, 4L80-E for Chevrolet RV Cutaway G2000 3500:

• (dash harn, near
• (eng harn, 98 cm
• 2-3 shift sol
• 2-3 ss
• 3-2 shift sol
• 3-2 ss
• 5v reference
• A/t fluid pressure manual valve position switch
• A/t iss hi
• A/t iss lo
• Anti-lock brakes system
• Anti-lock brakes system (electronic brake control module)
• Automatic transmission (4l80-e)
• Automatic transmission input shaft speed sensor (on left side of transmission)
• B17
• Battery in
• Brake fuse 18 10a
• Brake switch input
• Cruise control system
• Data class ii
• Data link connector (dlc) (partial) (under left side of dash)
• Ecm-b fuse 20a
• Ecm-i fuse 20a
• Ect sens input
• Engine controls system
• Engine controls system (fuel injectors)
• Engine controls system (fuel pump relay)
• Engine coolant temperature (ect) sensor (on top front of engine)
• From underhood fuse block, toward a/c compressor clutch breakout)
• G125 (front of engine, near thermostat housing)
• Gauges fuse 4 10a
• Hot at all times
• Hot in off, run, or start
• Hot in run
• Hot in run or start
• I/p fuse block (on left lower kick panel)
• Ignition in
• Instrument cluster
• Malfunction indicator lamp
• Mil control
• Park brake warning switch breakout)
• Passlock module, fuel sender buffer module, headlamp leveling switch, multifunction alarm module, vehicle speed sensor buffer, low engine coolant level indicator module, convenience center, drl control module, headlamp switch, ip relay center, left/right headlamp leveling actuators
• Pcm ground
• Pcs sol hi out
• Pcs sol lo out
• Pnk
• Pressure control solenoid valve
• Range signal "a"
• Range signal "b"
• Range signal "c"
• Red
• S102
• S120
• S122
• S132
• S133 (5.0l & 5.7l only) pnk
• S136 (engine harn)
• S139 (eng harn)
• S153 (eng harn)
• S154
• S210
• S216
• S231
• Sensor ground
• Sensor return
• Tcc pwm sol
• Tcc/abs/ cruise switch
• Tcc/stoplamp switch (behind dash, on brake pedal support)
• Throttle position (tp) sensor (on side of throttle body)
• Tp sens input
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans temp sig in
• Underhood fuse/relay center (on left side of engine compt)
• Vehicle control module (vcm) (on left side of engine compt)
• Vehicle speed sensor (vss) (on left side of transmission)
• Vss hi (signal)
• Vss lo (ground)

WARNING SYSTEMS

Warning System Wiring Diagrams for Chevrolet RV Cutaway G2000 3500

List of elements for Warning System Wiring Diagrams for Chevrolet RV Cutaway G2000 3500:

• (i/p harn, 39 cm into inflatable restraint sensing & diagnostic module breakout)
• (left kick panel)
• A12
• Battery input
• C200
• C210
• Convenience center (under left side of dash)
• Fasten belts out
• G200
• G200 (left kick panel)
• Gauges fuse 4 10a
• Ground
• Hazard fuse 5 20a
• Hot at all times
• Hot in park or head
• Hot in run or start
• I/p fuse block (on lower left kick panel)
• Ignition on input
• Illum mir fuse 14 10a
• Instrument cluster
• Instrument cluster system
• Key-in sw input
• Key-in warning switch (inside steering column assembly)
• Left front door jamb switch
• Lights on input
• Multi-function alarm module (under left side of dash)
• Nca
• Pnk
• S201
• S202
• S206
• S209
• S216
• S222
• S223
• S500
• Safety belt input
• Safety belt lamp
• Seat belt switch (opens with belt buckled) (in driver's stationary belt connector)
• Speed input
• Tan
• Upfitter package only

WIPER/WASHER

Wiper/Washer Wiring Diagram for Chevrolet RV Cutaway G2000 3500

List of elements for Wiper/Washer Wiring Diagram for Chevrolet RV Cutaway G2000 3500:

• (in dash harness, approximately 4 cm (2 in) from park brake warning switch breakout, toward dlc connector breakout) s201
• Delay
• G200 (behind left kick panel)
• Hot in accy & run
• I/p fuse block (on lower left kick panel)
• Inst wipe
• Inst wipe k
• Low
• Mist
• Mist off
• Off
• Red
• S252
• Solid state
• Wash
• Washer switch
• Windshield washer pump motor (on left front of engine compartment, at washer reservoir)
• Windshield washer/ wiper switch
• Windshield wiper motor (on left side of firewall)
• Wiper fuse 11 25a
• Wiper switch