All Wiring Diagrams for Suzuki Samurai JA 1992 model

AIR CONDITIONING

A/C Wiring Diagram for Suzuki Samurai JA 1992

List of elements for A/C Wiring Diagram for Suzuki Samurai JA 1992:

• 20a
• A/c amplifier (right side of i/p)
• A/c compressor clutch
• A/c switch
• Blower fan switch
• Blower motor (behind center of i/p)
• Blower switch
• Condenser fan motor
• Condenser motor relay (right front fender)
• Coolant temperature switch
• Engine control module (right side of i/p)
• Evaporative temperature
• Fresh off switch
• Fuse
• Fuse panel
• Fusible
• Hot at all times
• Hot in on
• Idle up solenoid (right side of engine)
• In-line
• Link
• Magnet clutch relay (right side of i/p)
• Off
• Red
• Sensor
• Starting/charging system
• Temperature control volume

Heater Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Heater Wiring Diagram for Suzuki Samurai JA 1992:

• 20a
• Blower fan switch
• Blower motor (behind center of i/p)
• Blower switch
• Fuse
• Fuse panel
• Hot in on
• Off

COMPUTER DATA LINES

Data Link Connector Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Data Link Connector Wiring Diagram for Suzuki Samurai JA 1992:

• Diagnostic socket
• Engine control module (behind right i/p)
• Fuse box (behind left i/p)
• Monitor coupler (right side of engine compt)

DEFOGGERS

Defogger Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Defogger Wiring Diagram for Suzuki Samurai JA 1992:

• 1986-89
• 1990-94
• Combination switch
• Diode
• Engine controls system
• Fuse 11 15a (1990-94)
• Fuse 15a (1986-89)
• Fuse box (left dash)
• Hot in ign or start
• Illum.
• Illumination controller
• Ind.
• Interior lights system
• Nca
• Nca not used
• Off
• Rear defogger
• Rear defogger switch
• Red

ENGINE PERFORMANCE

1.3L

1.3L TBI, Engine Performance Wiring Diagrams (1 of 2) for Suzuki Samurai JA 1992

List of elements for 1.3L TBI, Engine Performance Wiring Diagrams (1 of 2) for Suzuki Samurai JA 1992:

• (front
• (front right
• (top of engine above throttle body)
• 5th sw (not calif)
• A/c on signal
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• Air conditioning system
• Ats
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• Camshaft angle (cas) sensor
• Cas
• Clutch switch
• Combination meter
• Condenser (left rear of engine compartment near ignition coil)
• Crank signal
• Diag request signal
• Distributor
• Duty check output
• Ecm gnd (calif)
• Ecm ground
• Egr vsv
• Engine control module (ecm) (right side of i/p)
• Engine)
• Fuel injector
• Fuel injector output
• Fuel pump relay gnd
• Fuse #14 15a
• Fuse #3 15a
• Fuse #8 15a
• Fuse box
• G116 (left rear of engine compartment on bulkhead)
• G119
• Hot at all times
• Hot in start or on
• Idle switch signal
• Ign driver output
• Ign signal
• Igniter (left rear of engine compartment)
• Ignition coil (left rear of engine compartment)
• Ignition power input
• Injector ground
• Isc solenoid valve
• Main relay (right side of i/p)
• Main relay ground
• Malfunction indicator lamp
• Memory power input
• Mil indic control
• Nca
• Noise suppressor filter (left rear of engine compartment)
• O2 sensor
• Of engine)
• Oxygen sensor (left side of engine in exhaust manifold)
• Pnk
• Power source
• Pressure sensor
• Red
• Regts
• Resistor coupler
• Right of
• Sensor ground
• Test switch signal
• Throttle opener
• Tps
• Vehicle speed input
• Vss
• Wts

1.3L TBI, Engine Performance Wiring Diagrams (2 of 2) for Suzuki Samurai JA 1992

List of elements for 1.3L TBI, Engine Performance Wiring Diagrams (2 of 2) for Suzuki Samurai JA 1992:

• (behind left rear wheelhouse)
• 5th switch (on transmission)
• Acc
• Air temperature sensor (right front of engine below throttle body)
• Clutch switch (behind left side of i/p, above clutch pedal)
• Diagnosis switch terminal (under left side of i/p, near fuse panel)
• Exhaust gas recirculation temperature (egrt) sensor (calif only) (right rear of engine compartment)
• Exhaust gas recirculation vacuum solenoid valve (front right of engine)
• Fuel pump (in fuel tank)
• Fuel pump relay (right side of i/p)
• G123 (right side of safety wall)
• G201 (behind right side of i/p, near blower motor)
• G402
• Hot at all times
• Idle speed control sol valve (left side of throttle body)
• Ignition switch
• Lock
• Manifold absolute pressure (map) sensor (right rear of engine compartment)
• Monitor coupler (engine) (right side of engine compartment near fusible link box)
• Nca
• Pnk
• Start
• Throttle opener vacuum solenoid valve (right front of engine)
• Throttle position (tp) sensor (on throttle body)
• Water temperature sensor (right side of engine, on intake manifold)

EXTERIOR LIGHTS

Exterior Light Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Exterior Light Wiring Diagram for Suzuki Samurai JA 1992:

• (brake pedal bracket)
• 1995 vftc c
• Back up light switch (top of transmission)
• Combination switch
• Fuse 3 15a
• Fuse 4 15a
• Fuse 5 15a
• Fuse 9 10a
• Fuse box (left i/p)
• Head
• Hot at all times
• Hot in ign or start
• Instrument cluster
• Left
• Left back up light
• Left front combination light
• Left front side marker light
• Left front turn signal light
• Left rear combination light
• Left rear side marker light
• Left rear tail & stop light
• Left rear turn signal light
• Left turn
• License lights
• Lighting switch
• Mounted stop light
• Nca
• Not used
• Off
• Park
• Position light
• Red
• Red/
• Right
• Right back up light
• Right front combination light
• Right front side marker light
• Right front turn signal light
• Right position light
• Right rear combination light
• Right rear side marker light
• Right rear tail & stop light
• Right rear turn signal light
• Right turn
• Stop light switch
• Turn signal & 4 way switch
• Turn signal relay (left i/p)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 2) for Suzuki Samurai JA 1992

List of elements for Ground Distribution Wiring Diagram (1 of 2) for Suzuki Samurai JA 1992:

• 4wd switch
• 5th switch (except california)
• Battery
• Brake fluid level switch
• Check relay (starting)
• Cigarette lighter
• Clock
• Combination switch
• Condenser
• Daytime running light controller (canada)
• Daytime running light resistor (canada)
• Fuel pump
• Fuse box
• Heater fan motor
• High mounted stop light (usa)
• Horn
• I/p
• Illumination controller
• Left front combination light
• Left front side marker light
• Left rear side marker light
• Lights
• Nca
• Oxygen sensor shield
• Passing
• Position
• Radio noise suppressor
• Rear defogger switch
• Right front combination light
• Right front side marker light
• Right rear side marker light
• Seat belt switch
• Turn signal relay
• Turning
• Windshield washer
• Wiper motor
• Wipers

Ground Distribution Wiring Diagram (2 of 2) for Suzuki Samurai JA 1992

List of elements for Ground Distribution Wiring Diagram (2 of 2) for Suzuki Samurai JA 1992:

• Back-up
• California only
• Distributor
• Engine control module
• Fuel level gauge
• Horn switch
• Interior light
• Left license light
• Left rear combination light
• Nca
• Rear defogger
• Right license light
• Right rear combination light
• Stop tail/ nca
• Tail/ stop
• Turn

HEADLIGHTS

Headlight Wiring Diagram, without DRL (1 of 2) for Suzuki Samurai JA 1992

List of elements for Headlight Wiring Diagram, without DRL (1 of 2) for Suzuki Samurai JA 1992:

• 1995 vftc c
• Brake
• Brake fluid level switch (brake fluid reservoir cap)
• Combination switch
• Daytime running light controller (right side of i/p)
• Dimmer switch
• Drl
• Fuse 1 10a
• Fuse 2 10a
• Fuse 3 10a
• Fuse 8 15a
• Fuse box (left i/p)
• Generator
• Head
• High beam
• Hot at all times
• Hot in ign or start
• Instrument cluster
• Left headlight
• Lighting switch
• Nca
• Off
• Park
• Parking brake switch (base of parking brake lever)
• Passing switch
• Red
• Red/
• Resistor (front left fender)
• Right headlight

HORN

Horn Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Horn Wiring Diagram for Suzuki Samurai JA 1992:

• Combination switch
• Fuse 10a (1988-89)
• Fuse 4 15a (1990-94)
• Fuse box (left dash)
• Horn
• Horn relay (left dash)
• Horn switch
• Hot at all times
• Nca
• Slip ring

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Instrument Cluster Wiring Diagram for Suzuki Samurai JA 1992:

• (base of driver's seat belt buckle)
• * exc. calif. & canada
• 4wd
• 4wd switch (transfer case)
• A15
• B13
• Brake
• Brake fluid level switch (brake fluid reservoir cap)
• Buzzer
• Canada models
• Cancel switch
• Charge
• Check engine
• Check relay (right i/p)
• Clock
• Daytime running light controller (right side of i/p)
• Drl
• Electronic control module (right i/p)
• Exterior lights system
• Fuel
• Fuel level gauge sender
• Fuse 3 15a
• Fuse 5 15a
• Fuse 6 20a
• Fuse 8 15a
• Fuse box (left side of dash)
• Generator
• Headlights system
• Headlights system (canada)
• High beam
• Hot at all times
• Hot in acc or ign
• Hot in ign or start
• Illumination
• Instrument cluster
• Interior lights system
• Left turn
• Mileage sensor
• Nca
• Noise suppressor filter
• Oil pressure
• Oil pressure switch (above oil filter)
• Parking brake switch (base of parking brake lever)
• Red
• Right turn
• Seat belt
• Seat belt switch
• Starting/ charging system (clutch switch)
• Tachometer
• Temp
• Timer
• Usa models
• Vss
• Water temperature sensor (on thermostat housing)

INTERIOR LIGHTS

Interior Light Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Interior Light Wiring Diagram for Suzuki Samurai JA 1992:

• 1995 vftc c
• Clock
• Combination switch
• Door
• Door switch
• Fuse 3 15a
• Fuse box (left i/p)
• Head
• Hot at all times
• Illum.
• Illumination controller
• Illumination light
• Instrument cluster
• Lighting switch
• Nca
• Not used
• Off
• Park
• Radio
• Rear defogger switch
• Red/
• Room light
• Warning system

POWER DISTRIBUTION

Power Distribution Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Power Distribution Wiring Diagram for Suzuki Samurai JA 1992:

• 1995 vftc c
• Acc
• B12
• Back light switch
• Battery
• Canada models
• Cigarette lighter
• Clock
• Clutch switch
• Combination switch
• Condenser
• Daytime running light controller
• Door warning buzzer
• Electronic control module
• Fuel pump relay
• Fuse 1 10a
• Fuse 10 15a
• Fuse 11 15a
• Fuse 12 20a
• Fuse 2 10a
• Fuse 3 15a
• Fuse 4 15a
• Fuse 5 15a
• Fuse 6 20a
• Fuse 7 15a
• Fuse 8 15a
• Fuse 9 10a
• Fuse box
• Fusible link
• Generator
• Heater fan switch
• Horn relay
• Ign
• Igniter
• Ignition coil
• Ignition switch
• Instrument cluster
• Left headlight
• Lighting switch
• Main relay
• Nca
• Nca b
• Off
• Radio
• Radio coupler
• Rear defogger switch
• Right headlight
• Room light
• Start
• Starter motor
• Stop light switch
• Turn signal & 4 way switch
• Washer switch
• Wiper motor

RADIO

Radio Wiring Diagrams for Suzuki Samurai JA 1992

List of elements for Radio Wiring Diagrams for Suzuki Samurai JA 1992:

• (1986-89) (1990-95)
• Antenna
• Fuse 10a (1986-89)
• Fuse 15a (1990-95)
• Fuse 15a 20a
• Fuse block
• Hot at all times
• Hot in acc or on
• Interior lights system
• Nca
• Radio
• Radio coupler (1988-95)
• Speaker

STARTING/CHARGING

Charging Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Charging Wiring Diagram for Suzuki Samurai JA 1992:

• Acc
• Battery
• Charge indicator
• Daytime running light controller (1990-94 canada)
• Fuse 15a
• Fuse box (below left dash)
• Fusible link
• Generator
• Ign
• Ignition switch
• Instrument cluster
• Nca
• Off
• Start
• Starter motor

Starting Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Starting Wiring Diagram for Suzuki Samurai JA 1992:

• Acc
• Air conditioning system (1990-94)
• Battery
• Check relay (1988-94)
• Clutch switch
• Electronic control module (1990-94)
• Fusible link
• Ignition switch
• Lock
• Nca
• Start
• Starter motor

WARNING SYSTEMS

Warning System Wiring Diagrams for Suzuki Samurai JA 1992

List of elements for Warning System Wiring Diagrams for Suzuki Samurai JA 1992:

• 1995 vftc c
• Buzzer
• Door switch
• Door warning buzzer (right i/p)
• Door warning switch
• Fuse 3 15a
• Fuse 8 15a
• Fuse box (left i/p)
• Hot at all times
• Hot in ign or start
• Instrument cluster
• Interior lighting system
• Nca
• Seat belt
• Seat belt switch (base of driver's seat belt buckle)
• Timer

WIPER/WASHER

Wiper/Washer Wiring Diagram for Suzuki Samurai JA 1992

List of elements for Wiper/Washer Wiring Diagram for Suzuki Samurai JA 1992:

• Combination switch
• Fuse 15a
• Fuse box (left dash)
• Hot in on or start
• Int
• Interval unit
• Lo int
• Nca
• Off
• W/ interval * wipers w/o interval **
• Washer motor
• Washer switch
• Wiper motor
• Wiper switch
• Wipers