All Wiring Diagrams for Dodge Cab & Chassis R1996 3500 model

AIR CONDITIONING

A/C Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for A/C Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• l
• (diesel)
• (right side of dash panel)
• (top of cylinder head)
• 20a
• 30a
• A/c
• A/c comp clutch rly
• A/c compressor clutch
• A/c compressor clutch relay
• A/c high pressure switch (near a/c compressor)
• A/c low pressure switch (on a/c accumulator)
• A/c request signal
• A/c select input
• Blower motor
• Blower motor resistors (right side of i/p)
• C13
• C20
• C22
• C23
• C241
• C90
• Def
• Fuse 10a
• Fuse b
• Fuse block
• Fuse f2
• G125 (below compressor) (gasoline)
• G206 (i/p right center support)
• Heat
• Heater-a/c control assembly
• Hi/lo
• Hot at all times
• Hot in run
• Hot in run or start
• Interior lights system
• Max a/c
• Off
• Power distribution center
• Powertrain control module
• Tan

Heater Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Heater Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• lo
• 30a
• Blower motor
• Blower motor resistors (right side of i/p)
• Def
• Fuse block
• Fuse f2
• G206 (i/p left center support)
• Heat
• Heater switch
• Hi/lo
• Hot in run
• Interior lights system
• Off
• Tan

ANTI-LOCK BRAKES

All-Wheel ABS Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for All-Wheel ABS Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (right fender side shield)
• 4wd switch input
• 4x4 ind
• 4x4 switch (on transfer case)
• 87a
• A20
• Abs lamp relay ctrl
• Abs pump relay (in power distribution center)
• Abs pump relay ctrl
• Abs warning ind ctrl
• Abs warning lamp relay (in power distribution center)
• Acc
• Anti- lock ind
• Anti-lock brake system control module (left fender side shield)
• B113
• B114
• B116
• B120
• B18
• B19
• B243
• B245
• B248
• B249
• B252
• B254
• B47
• B60
• Brake warn indic.
• Brake warning ind
• Brake warning switch (on left frame panel)
• C215
• D11
• D12
• Data link connector (left bottom of i/p)
• Data link input
• Data link output
• Dump sol
• Engine controls system (pcm)
• Fuse 20a
• Fuse 40a
• Fuse block
• G100 (left fender side shield)
• G100 (left front side shield)
• G101
• G107
• G19
• G206 (i/p right center support)
• Ground
• Hot at all times
• Hot in run
• Hydraulic control unit (left fender side shield)
• Ignition
• Ignition switch
• Instrument cluster
• Isolate sol
• Joint connector c (left side cowl)
• Left front reset
• Left front wheel sensor
• Left isolation and dump solenoids
• Lt frnt isolate sol ctrl
• Lt front dump ctrl
• Lt front wheel sensor
• Off
• Power distribution center
• Pump motor ctrl
• Pump motor feed
• Rear dump sol ctrl
• Rear isolate sol ctrl
• Rear reset
• Rear wheel anti-lock brake sensor (top of rear differential)
• Rear wheels sensor high
• Rear wheels sensor low
• Red
• Reset sw
• Right front reset
• Right front wheel sensor
• Right isolation and dump solenoids
• Rt frnt isolate sol ctrl
• Rt front dump sol ctrl
• Rt front wheel sensor
• Run
• Rwal valve (left fender side shield)
• Start
• Stop lamp switch
• Stop lamp switch (on brake pedal bracket)
• V40
• Vacuum sensor (left fender side shield) (diesel only)

Rear Wheel ABS Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Rear Wheel ABS Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (diesel only)
• 4wd indicator
• 4wd switch input
• 4x4 switch (on front axle)
• A20
• Abs warning ind ctrl
• Abs warning lamp
• Acc
• B101
• B108
• B111
• B112
• B113
• B114
• Brake sw input
• Brake warning
• Brake warning lamp
• Brake warning switch (left side frame rail)
• C215
• C223
• Data link connector (left bottom of i/p)
• Diagnostic signal
• Diesel only
• Dump sol
• F32
• Fuse 15a
• Fuse 20a
• Fuse block
• Fused b(+)
• G100 (left fender side shield)
• G102 (left fender side shield)
• G107
• G11
• G19
• G206 (i/p right center support)
• Gasoline only
• Ground
• Hot at all times
• Hot in run
• Ignition
• Ignition switch
• Instrument cluster
• Isolate sol
• Isolate valve sol
• Joint connector b (left side of i/p)
• Joint connector c (left side of i/p)
• Off
• Park brake indic.
• Park brake input
• Park brake switch (on brake bracket)
• Pnk
• Rear wheel anti-lock control module (center of i/p)
• Rear wheel anti-lock sensor (in rear differential)
• Rear wheel sensor (+)
• Rear wheel sensor (-)
• Reset
• Reset sw
• Run
• Rwal dump solenoid
• Rwal valve (near master cylinder)
• Start
• Stop lamp switch (brake pedal bracket)
• V40
• Vacuum sensor (left fender side shield) (diesel only)

COMPUTER DATA LINES

Computer Data Lines for Dodge Cab & Chassis R1996 3500

List of elements for Computer Data Lines for Dodge Cab & Chassis R1996 3500:

• Airbag control module (center of i/p)
• Anti-lock brake controller (center of i/p)
• Anti-lock brake controller (left fender side shield)
• B112
• B113
• C121
• C137
• C223
• C228
• C232
• Ccd bus (+)
• Ccd bus (-)
• D11
• D20
• D21
• Data link connector (lower left i/p)
• Fuse 15a
• Fuse block
• G125 (front of engine)
• Hot at all times
• Joint connector b
• Pnk
• Powertrain control module (right side cowl)
• Rear wheel speed sensor
• Rwal diag
• Sci receive
• Sci transmit
• Speed sensor
• W/ all wheel abs
• W/ rear wheel abs

CRUISE CONTROL

Cruise Control Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Cruise Control Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• Anti-lock brake controller (if equipped)
• C11
• C135
• C137
• C24
• C32
• G100 (left fender side sheild)
• G206 (i/p left center support)
• Ground
• Joint connector c
• On/ off
• Powertrain control module (right side of safety wall)
• Resume/ accel
• Rwal module (if equipped)
• Sensor ground
• Set/ coast
• Speed ctrl res
• Stop lamp switch (top of brake pedal support)
• Stop sw
• Stop sw sense
• Tan/red
• V32
• V35
• V36
• V37
• V40
• Vac solenoid
• Vacuum ctrl
• Vehicle speed control servo (side of battery tray)
• Vehicle speed control switches
• Vent ctrl
• Vent solenoid
• Vsc sw signal

ENGINE PERFORMANCE

5.2L

5.2L CNG, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L CNG, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500:

• (brake master cylinder)
• (front of engine)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• Automatic shutdown relay
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• C135
• C136
• Cam pos sns
• Crnk pos sns
• Dnstr ho2s in
• Ect sens in
• Egr sol ctrl
• Egr solenoid (right side of intake manifold)
• F18
• Fuel injectors
• Fuel pres sens
• Fuel temp sens
• Fuse 4 30a
• Fuse 8 20a
• Fused b (+)
• Fused ign
• G116
• G125
• G72
• G79
• Gen field drv
• Gov press sig
• Ground
• High pressure fuel shut-off solenoid
• High pressure fuel shut-off solenoid relay
• Hot at all times
• Iat sens in
• Idle air ctrl 1
• Idle air ctrl 2
• Idle air ctrl 3
• Idle air ctrl 4
• Ign coil drvr
• Ignition coil (right front of engine)
• Inj 1 driver
• Inj 2 driver
• Inj 3 driver
• Inj 4 driver
• Inj 5 driver
• Inj 6 driver
• Inj 7 driver
• Inj 8 driver
• K11
• K12
• K13
• K14
• K19
• K20
• K21
• K22
• K24
• K26
• K28
• K30
• K341
• K35
• K38
• K39
• K40
• K41
• K44
• K54 (a/t) g54 (m/t)
• K58
• K59
• K60
• K88
• Low pressure fuel shut-off solenoid
• Map sens in
• Output vss grd
• Output vss sig
• Overdrv sol
• P/n pstn sw
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Sensor grd
• Starting/ charging
• Starting/ charging system
• System
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tan/pnk
• Tps sens in
• Trans relay
• Trans temp in
• Transmission output shaft speed sensor (left rear of transmission)
• Upshft/tcc ctrl
• Upstr ho2s in
• Var force sol
• Vss in
• Z12

5.2L CNG, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L CNG, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500:

• (front of
• Battery temperature sensor (below battery)
• Block
• Downstream heated oxygen sensor (behind converter)
• Engine coolant temperature sensor (near thermostat)
• Engine)
• Fuel gauge pressure sensor
• Fuel pressure sensor
• Fuel temperature sensor
• Fuse
• Fuse 9 10a
• G125
• Hot in run or start
• Idle air control motor (on side of throttle body)
• Instrument cluster system (speedometer)
• Intake air temperature sensor (right side of intake manifold)
• Manifold absolute pressure sensor (on throttle body)
• Nca
• Pnk
• Tan/pnk
• Upstream heated oxygen sensor (front of converter shell)
• Vehicle speed control switches

5.2L CNG, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L CNG, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500:

• (i/p right center support, near radio)
• (not used)
• (w/ a/t)
• A/c comp cl rly
• A/c high pressure cutout switch (a/c high pressure line)
• A/c low pressure cutout switch (a/c low pressure line)
• A/c request
• A/c select
• A/c system
• A/t
• A142
• Asd relay sens
• Asd rly ctrl
• Batt temp sens
• C10
• C11
• C12
• C13
• C137
• C14
• C15
• C16
• C17
• C18
• C19
• C20
• C21
• C215
• C216
• C22
• C23
• C24
• C25
• C26
• C27
• C28
• C29
• C30
• C31
• C32
• C90
• Camshaft position sensor (in dis- tributor)
• Control
• Crankshaft position sensor (rear of engine block)
• Cruise
• Cruise control system
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Data link connector (left i/p)
• Fuel press. gauge
• Fuse 15a
• Fuse block
• G12
• G14
• G206
• G21
• G24
• Gen ind drvr
• Gov press sig
• Hi press fuel shutoff rly ctrl
• Hot in run or start
• Instrument cluster
• J/c c (behind left knee bolster)
• K118
• K31
• K51
• K54
• K88
• M/t
• Maint req ind.
• Message center
• Mil ind drvr
• Mil ind.
• Od lamp drvr
• Od off switch
• Overdrive switch
• Overdrv sol
• Pnk
• Power distri- bution center
• Powertrain control module (right side safety wall)
• Red
• Sci receive
• Sci transmit
• Sensor grd
• Spd ctrl resume
• Sri lamp drvr
• Stop lamp switch
• Stop lp switch
• System
• T16
• T18
• T25
• T54
• T60
• Tach signal
• Tacho- meter
• Tan/red
• Tcc sol ctrl
• Throttle position sensor (side of throttle body)
• Trans rly out
• Trans temp lamp drvr
• Trans temp sns
• Trans- mission relay
• Transmission solenoid assembly (on transmission)
• Upshift ind.
• V32
• V35
• V36
• V37
• V40
• Var force sol
• Vehicle speed sensor (on trans- mission)

5.2L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500:

• fused b(+) tps sens in up ho2s in
• gen field drv
• inj 1 driver inj 3 driver inj 5 driver
• output sens
• overdrv sol
• trans temp in inj 7 driver
• var frce sol
• (front of
• (not used)
• 5.2l &
• 5.2l & 5.9l only
• 5.9l only
• A/t
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• Automatic shutdown relay
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• C135
• C136
• C215
• C216
• Coil driver
• Crnk pos sns
• Down ho2s in down ho2s in
• Egr sol ctrl
• Engine)
• F18
• Fuel injectors
• Fuel pump relay
• Fuse 15a
• Fuse block
• G125
• Gov press sig
• Ground ground
• Hot in run or start
• Iat sens in
• Idle air 1 idle air 4
• Idle air 2
• Idle air 3
• Ign power
• Ignition coil (right front of engine)
• Inj 2 driver
• Inj 4 driver
• Inj 6 driver
• Inj 8 driver
• Instrument cluster
• K11
• K12
• K13
• K14
• K19
• K20
• K21
• K22
• K24
• K26
• K28
• K30
• K341
• K35
• K38
• K39
• K40
• K41
• K44
• K54
• K58
• K59
• K60
• K88
• M/t
• Map sens in
• Output sens
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Prk/neutral
• Sensor grd
• Starting/ charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tcc drvr
• Trans relay
• Transmission ouput shaft speed sensor (left rear of transmission)
• Up- shift ind.
• Vehicle speed sensor
• Vss in
• Z12

5.2L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500:

• Block
• Crankshaft position sensor (rear of engine block)
• Downstream heated oxygen sensor (3.9/5.2/ 5.9l l/d trans only) (behind converter)
• Downstream heated oxygen sensor (5.9l h/d trans only) (behind converter)
• Egr solenoid (5.2/5.9l only) (right side of intake manifold)
• Engine coolant temperature sensor (near thermostat)
• Fuel pump
• Fuel pump module (top of fuel tank)
• Fuel signal
• Fuse
• Fuse 9 10a
• G116 (brake master cylinder)
• G125 (front of engine)
• G206 (i/p right center support)
• Hot in run or start
• Idle air control motor (on side of throttle body)
• Low fuel out
• Manifold absolute pressure sensor (on throttle body)
• Nca
• Pnk
• Sensor grd
• Sensor return
• Upstream heated oxygen sensor (front of converter shell)

5.2L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500:

• A/c comp rly
• A/c high pressure cutout switch (a/c high pressure line)
• A/c low pressure cutout switch (a/c low pressure line)
• A/c request
• A/c select in
• A142
• Air conditioning system
• Air conditioning system (a/c-heater control switch)
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery)
• Brake sw in
• C10
• C11
• C12
• C13
• C137
• C14
• C15
• C16
• C17
• C18
• C19
• C20
• C209
• C21
• C22
• C23
• C24
• C25
• C26
• C27
• C28
• C29
• C30
• C31
• C32
• C90
• Camshaft position sensor (in distributor)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Data link connector (left i/p)
• Duty cycle/ evap purge solnd (rear of intake manifold)
• Evap sol drvr
• Fuel level in
• Fuel pmp rly
• Fuse 4 30a
• Fuse 8 20a
• G12
• G14
• G206 (i/p right center support, near radio)
• G21
• G24
• Gen ind drvr
• Gen ind lamp
• Gov press sig
• Hot at all times
• Instrument cluster
• Intake air temper- ature sensor (right side of intake manifold)
• Joint connector c (behind left knee bolster)
• K118
• K226
• K31
• K51
• K52
• K54
• K88
• Low fuel sens
• Message center
• Mil ind drvr
• Mil ind lamp
• Overdrive switch
• Overdrv ind
• Overdrv sol
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Red
• Sci receive
• Sci transmit
• Sensor grd
• Sri driver
• Stop lamp switch (under left side of i/p)
• T16
• T18
• T25
• T54
• T60
• Tach signal
• Tan/red
• Tcc sol ctrl
• Throttle position sensor (side of throttle body)
• Trans overdrv
• Trans rly out
• Trans temp ind
• Trans temp sns
• Trans- mission relay
• Transmission solenoid assembly (transmission)
• V32
• V35
• V36
• V37
• V40
• Var force sol
• Vehicle speed sensor

5.9L

5.9L Turbo Diesel, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500:

• egr fault mon
• iat sens in
• prk/neutral air sys rly 1 speed sens sig
• wait to start
• water in fuel
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• Air sys rly 2
• Automatic shutdown relay
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• Battery
• C135
• C136
• D28
• F18
• Fuel pump relay
• Fused b(+)
• G125 (front of engine)
• G85
• Gen field drv
• Ground ground
• Heated intake air system
• Heated intake air system relay no. 1 (below left battery)
• Heated intake air system relay no. 2 (below left battery)
• Ign power
• Instrument cluster system
• K20
• K21
• K22
• K24
• K30
• K54
• K88
• Not functional
• Output sens
• Output sens gov press sig
• Overdrv sol
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• S21
• S22
• Sensor grd
• Starting/ charging system
• Starting/charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tcc drvr
• Tps sens in
• Trans relay
• Trans temp in
• Transmission ouput shaft speed sensor (left rear of transmission)
• Var frce sol
• Vss in
• Z12

5.9L Turbo Diesel, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500:

• Battery
• Block
• Coolant temp
• Diag req
• Egr control module
• Egr fault
• Egr iat +
• Egr iat -
• Egr intake air temperature sensor
• Egr intake engine coolant temperature sensor
• Egr sol
• Egr solenoid (right side of engine)
• Engine speed sensor (front of engine)
• Engine starter motor relay (hot in start)
• Fuel heater (above starter motor)
• Fuel heater relay (near master cylinder)
• Fuel pump module (top of fuel tank)
• Fuel shut down relay (near master cylinder)
• Fuel shut down solenoid (near rear of injection pump)
• Fuel signal
• Fuse
• Fuse 9 10a
• G116 (brake master cylinder)
• G125 (front of cylinder head)
• Gnd
• Hot in run and start
• Not functional
• Pnk
• Red/ tan
• Sensor grd
• Shut dwn rel
• Temp sen grd
• Tp sens sig

5.9L Turbo Diesel, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500:

• (a/c-heater control switch)
• A/c comp rly
• A/c high pressure cutout switch (a/c high pressure line)
• A/c low pressure cutout switch (a/c low pressure line)
• A/c request
• A/c select in
• A142
• Air conditioning system
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery)
• Brake sw in
• C10
• C11
• C12
• C13
• C137
• C14
• C15
• C16
• C17
• C18
• C19
• C20
• C209
• C21
• C22
• C23
• C24
• C25
• C26
• C27
• C28
• C29
• C30
• C31
• C32
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• D29
• Data link connector
• Egr diag
• Fuel level in
• Fuse 4 30a
• Fuse 8 20a
• G12
• G14
• G206 (i/p right center support, near radio)
• G21
• G24
• Gen ind drvr
• Gen ind lamp
• Gov press sig
• Hot at all times
• Instrument cluster
• Instrument cluster system
• Instrument cluster system (vss power)
• Intake air temper- ature sensor (right side of intake manifold)
• Joint connector c (behind left knee bolster)
• K118
• K226
• K31
• K51
• K54
• K88
• Mil ind drvr
• Mil ind lamp
• Not functional
• Overdrv ind
• Overdrv sol
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Red
• Sci receive
• Sci transmit
• Sensor grd
• Stop lamp switch (under left side of i/p)
• T16
• T18
• T25
• T54
• T60
• Tach signal
• Tan/red
• Tcc sol ctrl
• Throttle position sensor (side of throtlle body)
• Trans overdrv
• Trans rly out
• Trans temp ind
• Trans temp sns
• Trans- mission relay
• Transmission solenoid assembly (transmission)
• V32
• V35
• V36
• V37
• V40
• Var force sol
• Water in fuel
• Water in fuel sensor (bottom of fuel filter)

5.9L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500:

• fused b(+) tps sens in up ho2s in
• gen field drv
• inj 1 driver inj 3 driver inj 5 driver
• output sens
• overdrv sol
• trans temp in inj 7 driver
• var frce sol
• (front of
• (not used)
• 5.2l &
• 5.2l & 5.9l only
• 5.9l only
• A/t
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• Automatic shutdown relay
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• C135
• C136
• C215
• C216
• Coil driver
• Crnk pos sns
• Down ho2s in down ho2s in
• Egr sol ctrl
• Engine)
• F18
• Fuel injectors
• Fuel pump relay
• Fuse 15a
• Fuse block
• G125
• Gov press sig
• Ground ground
• Hot in run or start
• Iat sens in
• Idle air 1 idle air 4
• Idle air 2
• Idle air 3
• Ign power
• Ignition coil (right front of engine)
• Inj 2 driver
• Inj 4 driver
• Inj 6 driver
• Inj 8 driver
• Instrument cluster
• K11
• K12
• K13
• K14
• K19
• K20
• K21
• K22
• K24
• K26
• K28
• K30
• K341
• K35
• K38
• K39
• K40
• K41
• K44
• K54
• K58
• K59
• K60
• K88
• M/t
• Map sens in
• Output sens
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Prk/neutral
• Sensor grd
• Starting/ charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tcc drvr
• Trans relay
• Transmission ouput shaft speed sensor (left rear of transmission)
• Up- shift ind.
• Vehicle speed sensor
• Vss in
• Z12

5.9L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500:

• Block
• Crankshaft position sensor (rear of engine block)
• Downstream heated oxygen sensor (3.9/5.2/ 5.9l l/d trans only) (behind converter)
• Downstream heated oxygen sensor (5.9l h/d trans only) (behind converter)
• Egr solenoid (5.2/5.9l only) (right side of intake manifold)
• Engine coolant temperature sensor (near thermostat)
• Fuel pump
• Fuel pump module (top of fuel tank)
• Fuel signal
• Fuse
• Fuse 9 10a
• G116 (brake master cylinder)
• G125 (front of engine)
• G206 (i/p right center support)
• Hot in run or start
• Idle air control motor (on side of throttle body)
• Low fuel out
• Manifold absolute pressure sensor (on throttle body)
• Nca
• Pnk
• Sensor grd
• Sensor return
• Upstream heated oxygen sensor (front of converter shell)

5.9L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500:

• A/c comp rly
• A/c high pressure cutout switch (a/c high pressure line)
• A/c low pressure cutout switch (a/c low pressure line)
• A/c request
• A/c select in
• A142
• Air conditioning system
• Air conditioning system (a/c-heater control switch)
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery)
• Brake sw in
• C10
• C11
• C12
• C13
• C137
• C14
• C15
• C16
• C17
• C18
• C19
• C20
• C209
• C21
• C22
• C23
• C24
• C25
• C26
• C27
• C28
• C29
• C30
• C31
• C32
• C90
• Camshaft position sensor (in distributor)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Data link connector (left i/p)
• Duty cycle/ evap purge solnd (rear of intake manifold)
• Evap sol drvr
• Fuel level in
• Fuel pmp rly
• Fuse 4 30a
• Fuse 8 20a
• G12
• G14
• G206 (i/p right center support, near radio)
• G21
• G24
• Gen ind drvr
• Gen ind lamp
• Gov press sig
• Hot at all times
• Instrument cluster
• Intake air temper- ature sensor (right side of intake manifold)
• Joint connector c (behind left knee bolster)
• K118
• K226
• K31
• K51
• K52
• K54
• K88
• Low fuel sens
• Message center
• Mil ind drvr
• Mil ind lamp
• Overdrive switch
• Overdrv ind
• Overdrv sol
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Red
• Sci receive
• Sci transmit
• Sensor grd
• Sri driver
• Stop lamp switch (under left side of i/p)
• T16
• T18
• T25
• T54
• T60
• Tach signal
• Tan/red
• Tcc sol ctrl
• Throttle position sensor (side of throttle body)
• Trans overdrv
• Trans rly out
• Trans temp ind
• Trans temp sns
• Trans- mission relay
• Transmission solenoid assembly (transmission)
• V32
• V35
• V36
• V37
• V40
• Var force sol
• Vehicle speed sensor

8.0L

8.0L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R1996 3500:

• fused b(+) tps sens in lft up ho2s
• gen field drv
• output sens
• overdrv sol
• trans temp in inj 7 driver
• var frce sol
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• Automatic shutdown relay
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• C135
• C136
• Camshaft position sensor (left front of engine, on timing chain cover)
• Coil 1
• Coil 1 driver
• Coil 2
• Coil 2 driver
• Coil 3
• Coil 3 driver
• Coil 4
• Coil 4 driver
• Coil 5
• Coil 5 driver
• Crnk pos sns
• F18
• Fuel injectors
• Fuel pump relay
• G125 (front of engine)
• Gov press sig
• Ground ground
• Iat sens in
• Idle air 1 idle air 4
• Idle air 2
• Idle air 3
• Ign power
• Ignition coil 4-pack (right side of engine)
• Ignition coil 6-pack (right side of engine)
• Inj 10 driver
• Inj 2 driver
• Inj 4 driver
• Inj 6 driver
• Inj 8 driver
• Inj 9 driver inj 1 driver inj 3 driver inj 5 driver
• Instrument cluster system
• K11
• K115
• K116
• K12
• K13
• K14
• K141
• K17
• K18
• K19
• K20
• K21
• K22
• K24
• K26
• K28
• K30
• K32
• K341
• K38
• K39
• K40
• K41
• K43
• K44
• K441
• K54
• K58
• K59
• K60
• K88
• Map sens in
• Output sens
• Pnk
• Post cat ho2s rt up ho2s
• Power distribution center
• Powertrain control module (right side safety wall)
• Pre cat ho2s
• Prk/neutral
• Pwr in
• Sensor grd
• Starting/ charging system
• Starting/charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tan/red
• Tcc drvr
• Trans relay
• Transmission output shaft speed sensor (left rear of transmission)
• Vss in
• Z12

8.0L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R1996 3500:

• Block
• Crankshaft position sensor (right side of engine block)
• Engine coolant temperature sensor (near thermostat)
• Fuel pump
• Fuel pump module (top of fuel tank)
• Fuel signal
• Fuse
• Fuse 9 10a
• G116 (brake master cylinder)
• G125 (front of engine)
• G206 (i/p right center support)
• Hot in run and start
• Idle air control motor (on side of throttle body)
• Left upstream heated oxygen sensor (left exhaust down tube)
• Low fuel out
• Manifold absolute pressure sensor (side of upper intake manifold)
• Nca
• Pnk
• Post-cat heated oxygen sensor (california only) (behind catalytic converter)
• Pre-cat heated oxygen sensor (california only) (front of converter shell)
• Right upstream heated oxygen sensor (right exhaust down tube)
• Sensor grd
• Sensor return
• Tan/red

8.0L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R1996 3500:

• (a/c-heater control switch)
• A/c comp rly
• A/c high pressure cutout switch (a/c high pressure line)
• A/c low pressure cutout switch (a/c low pressure line)
• A/c request
• A/c select in
• A142
• Air conditioning system
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery)
• Brake sw in
• C10
• C11
• C12
• C13
• C137
• C14
• C15
• C16
• C17
• C18
• C19
• C20
• C209
• C21
• C22
• C23
• C24
• C25
• C26
• C27
• C28
• C29
• C30
• C31
• C32
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Data link connector
• Duty cycle/ evap purge solnd (rear of intake manifold)
• Evap sol drvr
• Fuel level in
• Fuel pmp rly
• Fuse 4 30a
• Fuse 8 20a
• G12
• G14
• G206 (i/p right center support, near radio)
• G21
• G24
• Gen ind drvr
• Gen ind lamp
• Gov press sig
• Hot at all times
• Instrument cluster
• Instrument cluster system
• Instrument cluster system (vss power)
• Intake air temper- ature sensor (below left side of intake)
• Joint connector c (behind left knee bolster)
• K118
• K226
• K31
• K51
• K52
• K54
• K88
• Low fuel sens
• Mil ind drvr
• Mil ind lamp
• Overdrv ind
• Overdrv sol
• Pnk
• Power distribution center
• Powertrain control module (right side safety wall)
• Red
• Sci receive
• Sci transmit
• Sensor grd
• Sri driver
• Stop lamp switch (under left side of i/p)
• T16
• T18
• T25
• T54
• T60
• Tach signal
• Tan/red
• Tcc sol ctrl
• Throttle position sensor (side of throtlle body)
• Trans overdrv
• Trans rly out
• Trans temp ind
• Trans temp sns
• Trans- mission relay
• Transmission solenoid assembly (transmission)
• V32
• V35
• V36
• V37
• V40
• Var force sol

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Back-up Lamps Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (below horns)
• (on transmission)
• (right side, transmission)
• A/t
• Back-up lamp switch
• Back-up lamps
• Fuse 15 10a
• Fuse block
• G100
• Hot in run
• Joint connector c (left side of instrument panel)
• M/t
• Park/neutral position switch
• Trailer tow connector

Exterior Lamps Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500:

• (below horns)
• (i/p right center support)
• C216
• Center high- mount stop lamps
• Fuse 18 15a
• Fuse 20 15a
• Fuse 6 15a
• Fuse block
• Fuse c 15a
• G100
• G100 (left fender side shield)
• G206
• G308 (below left rear speaker)
• Ground joint
• Hazard
• Hazard flasher (mounted in fuse block)
• Hazard switch
• Head
• Headlamp switch
• Hot at all times
• Hot in accy or run
• Instrument cluster
• Joint connector a (rear of fuse block)
• Joint connector b (near rear of fuse block)
• Left park/turn signal lamp
• Left tail/ stop/turn signal lamp
• Left turn indicator
• License lamps (w/single rear wheels)
• Normal
• Off
• Park
• Pnk/red
• Power distribution center
• Right park/turn signal lamp
• Right tail/ stop/turn signal lamp
• Right turn indicator
• Stop lamp switch (on bracket)
• Turn signal and hazard flasher switch (part of multi- function switch, located on steering column)
• Turn signal flasher (mounted in fuse block)
• Turn signal switch
• W/ trailer tow

Exterior Lamps Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500:

• (below horns)
• (if equipped)
• (left fender
• (power
• Back-up
• Backup lamps circuit
• Battery
• Brakes trailer
• Center identification lamp
• Center)
• Distribution
• Electric trailer brakes provision
• Fuse 7 40a
• G100
• G908 (front center of headliner)
• Ground
• Hot at all times
• Left forward fender lamp
• Left license lamp
• Left outboard clearance lamp
• Left outboard identification lamp
• Left rear fender lamp
• Left tailgate lamp
• Left turn
• Power distribution center
• Red/tan
• Right forward fender lamp
• Right license lamp
• Right outboard clearance lamp
• Right outboard identification lamp
• Right rear fender lamp
• Right tailgate lamp
• Right turn
• Side shield)
• Tail
• Tow relay
• Trailer
• Trailer tow connector (if equipped)
• W/ optional dual rear wheels only

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for Ground Distribution Wiring Diagram (1 of 3) for Dodge Cab & Chassis R1996 3500:

• (diesel) (gas)
• (left side of engine block)
• (near left battery)
• (not used)
• 4x4 switch
• 5.2l cng
• 87a
• Abs 2-way power feed (w/ all wheel abs)
• Abs warning lamp relay
• Airbag control module
• All wheel abs
• Anti-lock brake controller
• Battery
• C232
• Daytime running lamp module
• Diesel
• Diesel only
• Diesel w/ rear wheel abs
• Ex. 5.2l cng
• Fog lamp relay n0. 1
• Fuel pump module
• Fuel shutdown solenoid
• G100
• G100 (front of tight frame rail)
• G100 (left fender side shield)
• G100 (left front fender side shield)
• G100 (left side shield)
• G100 (near horns)
• G101 (near right battery)
• G101 (right fender side shield)
• G104 (left fender shield)
• G104 (rear of left fender side shield)
• G112
• G116 (at brake master cylinder)
• G125 (front of cylinder head)
• G125 (front of engine)
• Gasoline
• Generator
• Ground joint (near power distribution center)
• High note horn
• High pressure fuel shut-off solenoid
• Left backup lamp
• Left battery
• Left door speaker
• Left fog lamp
• Left forward fender lamp
• Left headlamp
• Left license lamp
• Left park & turn signal lamp
• Left rear fender lamp
• Left rear speaker
• Left tail/stop turn signal lamp
• Left tailgate lamp
• Low note horn
• Low washer fluid switch
• Power distribution center
• Radio
• Radio choke relay
• Rear wheel abs
• Right backup lamp
• Right battery
• Right door speaker
• Right fog lamp
• Right forward fender lamp
• Right headlamp
• Right license lamp
• Right park & turn signal lamp
• Right rear fender lamp
• Right rear speaker
• Right tail/stop turn signal lamp
• Right tailgate lamp
• Rwal valve
• Trailer tow connector
• Trailer tow relay
• Underhood lamp
• Vacuum sensor
• Vehicle speed control servo
• W/ abs
• W/ dual rear wheels
• W/ low-line cluster
• W/ medium & high-line clusters
• W/ medium or high-line clusters
• W/ premium speakers
• W/ rwal
• W/ standard speakers
• Windshield washer pump motor
• Windshield wiper motor

Ground Distribution Wiring Diagram (2 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for Ground Distribution Wiring Diagram (2 of 3) for Dodge Cab & Chassis R1996 3500:

• 3.9l, 5.2l & 5.9l
• 5.2l cng
• 8.0l
• A/c compressor clutch
• A31
• A32
• C135
• California
• Data link connector
• Downstream heated oxygen sensor
• Egr control module
• Engine coolant sending unit
• Engine starter motor relay
• Ex. 5.2l cng
• Fuel gauge pressure sensor
• Fuel heater
• Fuel heater relay
• Fuel pump module
• Fuel shut down relay
• G125 (front of engine)
• Left upstream heated oxygen sensor
• Low pressure fuel shut-off solenoid
• Nca
• Post catalyst heated oxygen sensor
• Power distribution center
• Powertrain control module
• Pre- catalyst heated oxygen sensor
• Right upstream heated oxygen sensor
• To g206
• Upstream heated oxygen sensor
• W/ 5.2l cng only
• W/ diesel engine
• W/ gasoline or cng engine
• W/ m/t only

Ground Distribution Wiring Diagram (3 of 3) for Dodge Cab & Chassis R1996 3500

List of elements for Ground Distribution Wiring Diagram (3 of 3) for Dodge Cab & Chassis R1996 3500:

• (below left rear speaker)
• (front center of headliner)
• (right kick panel)
• (w/ power windows & door locks)
• (w/o power windows & door locks)
• Anti-lock brake controller
• Buzzer
• C215
• C216
• Center high mounted stop lamps
• Center identification lamp
• Center support, near radio)
• Cigar lighter
• Day/ night mirror
• Fog lamp switch
• From g125
• G200 (left kick panel)
• G203
• G206 (i/p right
• G206 (i/p right center support)
• G308
• G908
• Glove box lamp/ switch
• Headlamp switch
• Heater control switch or a/c-heater control switch
• Instrument cluster
• Intermittent wiper control module
• Key-in- switch halo lamp
• Left door jamb switch
• Left door lock switch
• Left outboard clearance lamp
• Left outboard identification lamp
• Left power window switch
• Left visor/ vanity lamp
• Module
• Overdrive switch
• Overhead console
• Overhead map/ courtesy lamp
• Power mirror switch
• Power outlet
• Power seat switch
• Right door jamb switch
• Right outboard clearance lamp
• Right outboard identification lamp
• Right visor/ vanity lamp
• Seatbelt switch
• Stop lamp switch

HEADLIGHTS

Headlamps/Fog Lamps Wiring Diagram, with DRL for Dodge Cab & Chassis R1996 3500

List of elements for Headlamps/Fog Lamps Wiring Diagram, with DRL for Dodge Cab & Chassis R1996 3500:

• (i/p right center support)
• (left fender shield)
• (left fender side shield)
• (left front fender side shield)
• 87a
• Battery
• C216
• C217
• Daytime running lamp module (left fender side shield)
• Exterior lights system
• Flash
• Fog lamp relay 1 (power distribution center)
• Fog lamp relay 2 (power distribution center)
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 40a
• Fuse a 15a
• Fuse block (left kick panel)
• G100
• G104
• G11
• G206
• G34
• Ground
• Head
• Head- lamp switch
• Headlamp dimmer switch
• Hi beam indicator
• Hi beam out
• Hot at all times
• Hot in run
• Ignition
• Indicator ctrl
• Instrument cluster
• Interior lights system
• Joint connector (behind knee bolster)
• Joint connector (near rear of fuse block)
• L10
• Left fog lamp
• Left headlamp
• Low beam out
• Off
• Park
• Park brake sw
• Park brake switch
• Pnk/red
• Power distribution center (left rear of engine compartment
• Power distribution center (left rear of engine compartment)
• Power distribution system
• Right fog lamp
• Right headlamp

Headlamps/Fog Lamps Wiring Diagram, without DRL for Dodge Cab & Chassis R1996 3500

List of elements for Headlamps/Fog Lamps Wiring Diagram, without DRL for Dodge Cab & Chassis R1996 3500:

• (i/p right center support)
• (left fender shield)
• (left front fender side shield)
• 87a
• C216
• C217
• Exterior lights system
• Flash
• Fog lamp relay 1 (power distribution center)
• Fog lamp relay 2 (power distribution center)
• Fog lamp switch
• Fuse 15a
• Fuse 40a
• Fuse a 15a
• Fuse block (left kick panel)
• G100
• G104
• G206
• Head
• Head- lamp switch
• Headlamp dimmer switch
• Hi beam indicator
• Hot at all times
• Instrument cluster
• Interior lights system
• Joint connector (near rear of fuse block)
• Left fog lamp
• Left headlamp
• Off
• Park
• Pnk/red
• Power distribution center (left rear of engine compartment
• Power distribution center (left rear of engine compartment)
• Right fog lamp
• Right headlamp

HORN

Horn Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Horn Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (left fender side shield)
• Clockspring
• Fuse b 20a
• G104
• Ground joint (near power distribution center)
• High note horn
• Horn relay
• Hot at all times
• Low note horn
• Nca
• Power distribution center (left side of engine compartment)
• Vehicle speed control/ horn switch

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Instrument Cluster Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (center
• (conn b)
• (diesel-left side of engine)
• (gas-front of engine, on thermostat housing)
• (i/p left
• (i/p right
• (in fuse
• (left
• (left fender
• (left fender side shield)
• (left frame
• (left side of transmission)
• (right
• (right side of dash panel)
• (spare)
• (top of fuel tank)
• (v10-right front of timing cover)
• (v6 & v8-center rear of engine)
• 3.9l, 5.2l & 5.9l only
• 4wd ind.
• A10
• A11
• A13
• A14
• Acc
• Airbag ind.
• Airbag system
• Anti-lock
• Anti-lock brakes system
• B10
• B11
• B12
• B13
• B14
• B27
• B31
• Block)
• Brake
• Brake ind.
• Brake system
• Buzzer module
• C16
• C17
• C215 (conn a)
• C216
• C31
• Center support)
• Check anti- lock ind.
• Check engine ind.
• Control
• Control module
• Control module (center of i/p)
• Coolant temp.
• Daytime
• Diesel only
• Engine coolant temperature sensor
• Engine oil pressure sending unit
• Engine speed
• Except 2.5l
• Except 2.5l & diesel
• Exterior lights system
• Fender
• Four wheel abs
• Fuel gauge
• Fuel gauge sensor
• Fuel level
• Fuel tank level gauge sending unit
• Fuse 12 15a
• Fuse block: i/p
• G100
• G11
• G13
• G206
• G21
• G24
• G54
• Gnd
• Headlights system
• High beam ind.
• Hot in run or start
• Ign
• Ignition switch
• Illum.
• Illum. lamps
• Instrument cluster
• Interior lights system (rheostat)
• Joint conn c
• Lamp check
• Lamps
• Left turn ind.
• Lock
• Low fuel ind.
• Low fuel warning module
• Low washer fluid level sensor (in washer reservoir)
• Low washer ind.
• Main- tenance required ind.
• Module
• Module (left fender side shield) (w/ drl only)
• Of dash
• Of i/p)
• Oil press.
• Oil press. gauge
• Oil press. ind.
• Panel)
• Park brake switch (on brake bracket)
• Power-
• Powertrain control module
• R41
• Rail)
• Rear wheel
• Rear wheel abs
• Right turn ind.
• Run
• Running
• Seat belt ind.
• Shield)
• Side
• Side shield)
• Speedo- meter
• Start
• Switch
• T18
• Tacho- meter
• Temp. gauge
• Train
• Trans- missions system
• Transmission overdrive switch
• Upshift ind.
• Vacuum sensor
• Vehicle speed
• Vehicle speed sensor
• Volt- meter
• W/ rear wheel abs
• Warning

Message Center Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Message Center Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• All w/ a/t except 8.0l
• B20
• C18
• Diesel only
• Fuse 12 15a
• Fuse block
• G14
• G24
• G85
• G86
• Gasoline only
• Hot in run or start
• Ign
• Message center
• Powertrain control module (right side of dash panel)
• Sri ind.
• Trans. temp. ind.
• Wait to start ind.
• Water in-fuel ind.

Overhead Console Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Overhead Console Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• Air temperature sensor (front of radiator)
• All times
• Courtesy lmps
• Exterior lights system
• F12
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fuse block
• Fused b+
• Fused ignition
• G206 (i/p right center support)
• G31
• G32
• G908 (front center of headliner)
• Ground
• Hot at
• Hot in park
• Hot in run
• Interior lights system
• J/c c (behind knee bolster)
• Or head
• Or start
• Overhead console
• Panel lamps in
• Park lamps in
• Pnk
• Sensor ground
• Temp sensor
• Z11

INTERIOR LIGHTS

Courtesy Lamp Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Courtesy Lamp Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (i/p right center support)
• (not used)
• B/h conn pin #34
• Cargo
• Cargo lamps
• Dome
• Dome lamp
• Fuse 15a
• Fuse block
• G100 (near horns)
• G200 (left kick panel)
• G203 (right kick panel)
• G206
• G206 (i/p left center support)
• G206 (i/p right center support)
• G908 (front center of headliner)
• Glove box lamp & switch
• Headlamp switch
• Hot at all times
• Joint connector a (left side of i/p)
• Joint connector b (rear of fuse block)
• Joint connector c (pin #20)
• Key-in halo lamp
• Left
• Left door jamb switch
• Map lamps
• Mercury switch
• Overhead console
• Overhead map/ courtesy lamp
• Pnk
• Reading lamps
• Right
• Right door jamb switch
• Time delay relay
• Underhood lamp
• Visor/ vanity lamps
• W/ overhead console
• W/o overhead console

Instrument Illumination Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Instrument Illumination Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (i/p right center support)
• C215
• C216
• C217
• C227
• C238
• C241
• Dimmer
• Dimmer rheostat
• Fog lamp switch
• Fuse 15a
• Fuse 5a
• Fuse block
• G206
• Head
• Headlamp switch
• Heater switch or hvac switch
• Hot at all times
• Illum
• Illumi-
• Illumination lamps (7 bulbs)
• Instrument cluster
• Joint connector a (rear of fuse block)
• Joint connector c (behind knee bolster)
• Lights on input
• Nation lamps
• Off
• Overhead console
• Park
• Pnk/red
• Radio
• Trans- mission over- drive switch

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 4) for Dodge Cab & Chassis R1996 3500

List of elements for Power Distribution Wiring Diagram (1 of 4) for Dodge Cab & Chassis R1996 3500:

• (jumper)
• * gasoline engine
• ** diesel engine
• **3
• 40a
• 50a
• A/c compressor clutch relay
• A22
• Abs pump relay (all wheel abs)
• Acc
• Automatic shutdown relay
• C135
• Clutch pedal position switch
• Daytime running lamps module
• Distribution center
• Electric brake provision
• Engine starter motor
• Engine starter motor relay
• Fog lamp relay no. 2
• From power a
• Fuel pump relay (ex. 5.2l cng) high pressure fuel shut-off solenoid relay (5.2l cng)
• Fuse 1
• Fuse 2
• Fuse 3 40a
• Fuse 4 30a
• Fuse 5 40a
• Fuse 6 40a
• Fuse 7 30a
• Fuse 8 20a
• Fuse a 15a
• Fuse b 20a
• Fuse block
• Fuse c 15a
• Gen fuse 120a
• Generator
• Hazard flasher
• Horn relay
• Ignition switch
• Left battery
• Nca
• Off
• Pnk
• Power distri- bution center
• Power distribution center
• Powertrain control module
• Red
• Red/
• Red/tan
• Right battery (diesel only)
• Run
• Start
• To circuit breaker 1
• To circuit breaker 2
• To fuse
• To fuse 1 (fuse block)
• To fuse 17
• To fuse 20 (fuse block)
• To headlight switch
• To power distribution center
• Trailer tow connector
• Trailer tow relay
• Transmission relay
• W/ a/t
• W/ daytime running lights
• W/ m/t

Power Distribution Wiring Diagram (2 of 4) for Dodge Cab & Chassis R1996 3500

List of elements for Power Distribution Wiring Diagram (2 of 4) for Dodge Cab & Chassis R1996 3500:

• (fuse block)
• A/c com- pressor clutch relay
• Airbag system control module
• Automatic shut down relay
• Buzzer module
• C135 '
• C215
• C229
• C232
• Cigar lighter
• Duty cycle evap/purge solenoid
• Exhaust gas recirculation solenoid
• From fuse 3 (power distribution center)
• From fuse 9 j
• From ignition switch
• Fuel gauge pressure sensor
• Fuel heater relay
• Fuel pump relay (ex. 5.2l cng) high pressure fuel shut-off solenoid relay (5.2l cng)
• Fuel shut down solenoid
• Fuse 1 20a
• Fuse 11 10a
• Fuse 12 15a
• Fuse 5 20a
• Fuse 6 15a
• Fuse 7 15a
• Fuse 8 20a
• Fuse 9 10a
• Fuse block
• G206 (i/p left center support)
• Heated intake air system relay no. 1
• Heated intake air system relay no. 2
• Instrument cluster
• Intermittent wiper control module
• Intermittent wiper switch
• Joint connector c
• Message center
• Multi-function switch
• Overdrive switch
• Overhead console
• Power distribution center
• Power outlet
• Powertrain control module
• Radio
• Red
• To fuse 11 (fuse block)
• Transmission relay
• Turn signal flasher
• W/ 5.2l & 5.9l
• W/ 5.2l cng
• W/ diesel engine
• W/ gasoline engine
• Windshield wiper motor

Power Distribution Wiring Diagram (3 of 4) for Dodge Cab & Chassis R1996 3500

List of elements for Power Distribution Wiring Diagram (3 of 4) for Dodge Cab & Chassis R1996 3500:

• (above)
• (courtesy lamps)
• (not used)
• Anti-lock brake controller
• Buzzer module
• C228
• C229
• Circuit breaker 2 30a
• Data link connector
• Exterior lights
• From fuse 6 (power distribution center)
• From fuse block k
• From fusible link 1 (power distribution center)
• Fuse 13 5a
• Fuse 17 15a
• Fuse 18 15a
• Fuse 19 20a
• Fuse 20 15a
• Fuse block
• Glove box lamp and switch
• Head
• Headlight switch
• Headlights
• Interior lights system
• Interior lights system (instrument illumination)
• Joint connector a
• Joint connector b
• Joint connector c
• Left power door lock switch
• Multifunction switch (headlamp dimmer switch)
• Off
• Overhead console
• Park
• Pass
• Pnk
• Pnk/red
• Power mirror switch
• Power seat switch
• Radio
• Radio choke relay
• Red
• Rheostat
• Right power door lock switch
• Stop lamp switch
• System
• Time delay relay
• To fuse block (below)
• Underhood lamp
• W/ clearance & identification lamps

Power Distribution Wiring Diagram (4 of 4) for Dodge Cab & Chassis R1996 3500

List of elements for Power Distribution Wiring Diagram (4 of 4) for Dodge Cab & Chassis R1996 3500:

• Abs pump relay
• Abs warning lamp relay
• Air bag control module
• Anti-lock brake controller
• Back-up lamp switch
• Blower motor
• C232
• Circuit breaker 1 30a
• Day/ night mirror
• Daytime running lamp module
• From ignition e
• Fuse 14 20a
• Fuse 15 10a
• Fuse 16 15a
• Fuse block
• Fuse f2 30a
• Joint connector c
• Left power window switch
• Park/neutral position switch
• Power distribution center
• Rear wheel anti-lock control module
• Right power window switch
• Switch
• Tan
• Vacuum sensor
• W/ a/t
• W/ all wheel abs
• W/ daytime running lights
• W/ diesel engine
• W/ m/t
• W/ rear wheel abs

POWER DOOR LOCKS

Power Door Lock Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Power Door Lock Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (left kick panel)
• 20a
• Fuse 19
• Fuse block: i/p
• G200
• Hot at all times
• Left power door lock motor
• Left power door lock switch
• Lock
• Red
• Right power door lock motor
• Right power door lock switch
• Unlock

POWER MIRRORS

Automatic Day/Night Mirror Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Automatic Day/Night Mirror Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• 10a
• A/t
• Back-up lamp switch (right side of transmission)
• Day/night mirror
• Fuse 15
• Fuse block
• G908 (forward center of header)
• Headlights system (drl module)
• Hot in run
• J/c c (behind knee bolster)
• M/t
• Nca
• Park/neutral position switch (on transmission)

Power Mirror Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Power Mirror Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• Fuse 17 15a
• Fuse block
• G200 (left kick panel)
• Horiz m
• Hot at all times
• Left mirror
• M vert
• Nca
• Pnk
• Power mirror switch
• Right up mirror
• Vert

POWER SEATS

Power Seat Wiring Diagrams for Dodge Cab & Chassis R1996 3500

List of elements for Power Seat Wiring Diagrams for Dodge Cab & Chassis R1996 3500:

• Aft
• Circuit breaker 2 30a
• Forward/backward seat motor
• Front up/down seat motor
• Frt dn
• Frt up
• Fuse block
• Fwd
• G308 (below left rear speaker)
• Hot at all times
• Power seat switch
• Rear/vertical seat motor
• Rr dn
• Rr up
• Vert dn
• Vert up

POWER WINDOWS

Power Window Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Power Window Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (left kick panel)
• Circuit breaker 1 30a
• Fuse block (left side of i/p)
• G200
• Hot in run
• Left power window motor
• Left power window switch
• Nca
• Right power window motor
• Right power window switch
• Tan

RADIO

Radio Wiring Diagrams, Base Radio for Dodge Cab & Chassis R1996 3500

List of elements for Radio Wiring Diagrams, Base Radio for Dodge Cab & Chassis R1996 3500:

• Antenna
• C229
• C230
• C241
• Dimmer
• Dimmer sig
• Fender side shield)
• Fuse 13 5a
• Fuse 17 15a
• Fuse 18 15a
• Fuse 7 15a
• Fuse block (left end of dash)
• Fused b(+)
• Fused ign
• G101 (right front
• Ground
• Head
• Headlamp switch
• Hot at all times
• Hot in run or acc
• Joint connector a (near rear of fuse block)
• Joint connector b (near rear of fuse block)
• Joint connector c (behind knee bolster)
• Left front door speaker
• Left rear speaker
• Lf spkr (+)
• Lf spkr (-)
• Lr spkr (+)
• Lr spkr (-)
• Nca
• Off
• Park lamp
• Pnk
• Pnk/ red
• Radio
• Rf spkr (+)
• Rf spkr (-)
• Right front door speaker
• Right rear speaker
• Rr spkr (+)
• Rr spkr (-)
• S205
• X12
• X51
• X52
• X53
• X54
• X55
• X56
• X57
• X58

Radio Wiring Diagrams, Premium Radio for Dodge Cab & Chassis R1996 3500

List of elements for Radio Wiring Diagrams, Premium Radio for Dodge Cab & Chassis R1996 3500:

• (body harn, in left power mirror motor) s305
• (body harn, left door speaker) s304
• (body harn, right door speaker) s307
• Antenna
• C229
• C230
• C241
• Dimmer
• Dimmer sig
• Fender side shield)
• Fuse 13 5a
• Fuse 17 15a
• Fuse 18 15a
• Fuse 7 15a
• Fuse block (left end of dash)
• Fused b(+)
• Fused ign
• G101 (right front
• G101 (right front fender side shield)
• Head
• Headlamp switch
• Hot at all times
• Hot in run or acc
• Joint connector a (near rear of fuse block)
• Joint connector b (near rear of fuse block)
• Joint connector c (behind knee bolster)
• Left front door speaker
• Left rear speaker
• Left tweeter speaker
• Lf spkr (+)
• Lf spkr (-)
• Lr spkr (+)
• Lr spkr (-)
• Nca
• Off
• Park lamp
• Pnk
• Pnk/ red
• Radio
• Radio 12v
• Radio choke relay (behind center of dash)
• Rf spkr (+)
• Rf spkr (-)
• Right front door speaker
• Right rear speaker
• Right tweeter speaker
• Rr spkr (+)
• Rr spkr (-)
• S205
• S212
• S213 (dash harn, center of dash)
• S301
• S302 (body harn, near left rear speaker)
• S308 (body harn, right door power window motor)
• X12
• X51
• X52
• X53
• X54
• X55
• X56
• X57
• X58
• X60

STARTING/CHARGING

5.2L

5.2L, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (front of right frame rail)
• (left side shield)
• A142
• Automatic shutdown relay (in power distribution center)
• B10
• Battery
• C12
• C137
• Feed
• Fuse 4 30a
• G100
• G101
• G125
• Gen fuse 120a
• Generator
• Power distribution
• Power distribution center
• Powertrain control module (right side of dash panel)
• Red
• Reg
• Starting system
• Voltage

5.2L, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (front of right frame rail)
• (left side shield)
• A/t
• A/t only
• Acc
• Battery
• C135
• Clutch pedal position switch (on clutch rod)
• Engine starter motor
• Engine starter motor relay (in power distribution center)
• Engine starter relay
• Engine)
• Fuse 2 40a
• Fuse 3 40a
• G100
• G101
• G125
• G125 (front of
• Ignition switch
• Lock
• M/t
• Park/neutral position switch (on transmission)
• Power distribution
• Power distribution center
• Power- train control module (right side cowl)
• Red
• Run
• Start

5.9L

5.9L Turbo Diesel, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (left side of engine block)
• (near left battery)
• (right side shield)
• A14
• A142
• A22
• Automatic shut down relay (in power distribution center)
• B10
• C12
• C135
• C137
• Field
• Fuse 4 30a
• Fuse 8 20a
• G100
• G101
• G112
• G125
• Gen fuse 120a
• Generator
• K20 c136
• Left battery
• Of dash panel)
• Pnk
• Power distribution
• Power distribution center
• Powertrain control module (right side
• Red
• Relay b+
• Right battery
• Starting system

5.9L Turbo Diesel, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• A/t
• A/t only
• Acc
• C135
• Clutch pedal position switch (on clutch rod)
• Engine starter
• Engine starter motor
• Fuse 2 40a
• Fuse 3 40a
• G100 (near left battery)
• G101 (near right battery)
• G112 (left side of engine block)
• G125 (front of engine)
• Ignition switch
• Left battery
• Lock
• M/t
• M/t only
• Motor relay (in power distribution center)
• Of dash panel)
• Park/neutral position switch
• Power distribution center
• Powertrain control module (right side
• Red
• Right battery
• Run
• Start
• Starter
• To fuel shutdown relay

5.9L, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (front of right frame rail)
• (left side shield)
• A142
• Automatic shutdown relay (in power distribution center)
• B10
• Battery
• C12
• C137
• Feed
• Fuse 4 30a
• G100
• G101
• G125
• Gen fuse 120a
• Generator
• Power distribution
• Power distribution center
• Powertrain control module (right side of dash panel)
• Red
• Reg
• Starting system
• Voltage

5.9L, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (front of right frame rail)
• (left side shield)
• A/t
• A/t only
• Acc
• Battery
• C135
• Clutch pedal position switch (on clutch rod)
• Engine starter motor
• Engine starter motor relay (in power distribution center)
• Engine starter relay
• Engine)
• Fuse 2 40a
• Fuse 3 40a
• G100
• G101
• G125
• G125 (front of
• Ignition switch
• Lock
• M/t
• Park/neutral position switch (on transmission)
• Power distribution
• Power distribution center
• Power- train control module (right side cowl)
• Red
• Run
• Start

8.0L

8.0L, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Charging Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (front of right frame rail)
• (left side shield)
• A142
• Automatic shutdown relay (in power distribution center)
• B10
• Battery
• C12
• C137
• Feed
• Fuse 4 30a
• G100
• G101
• G125
• Gen fuse 120a
• Generator
• Power distribution
• Power distribution center
• Powertrain control module (right side of dash panel)
• Red
• Reg
• Starting system
• Voltage

8.0L, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Starting Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (front of engine)
• (front of right frame rail)
• (left side shield)
• A/t
• A/t only
• Acc
• Battery
• C135
• Clutch pedal position switch (on clutch rod)
• Engine starter motor
• Engine starter motor relay (in power distribution center)
• Engine starter relay
• Engine)
• Fuse 2 40a
• Fuse 3 40a
• G100
• G101
• G125
• G125 (front of
• Ignition switch
• Lock
• M/t
• Park/neutral position switch (on transmission)
• Power distribution
• Power distribution center
• Power- train control module (right side cowl)
• Red
• Run
• Start

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Supplemental Restraint Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• Airbag control module (below center of i/p)
• Airbag indicator
• C216
• C232
• C233
• Clock spring assembly (top of steering column)
• Cluster
• Data link connector (left i/p)
• Driver side airbag (top of steering column)
• F14
• F23
• Fuse 15a
• Fuse block
• G104 (rear of left fender side shield)
• Hot in run
• Hot in run or start
• Instrument
• Left airbag sensor (forward of left fender shield)
• R41
• R43
• R45
• R46
• R47
• R48
• R49
• Right airbag sensor (forward of right fender shield)
• Squib (airbag igniter)
• Tan

TRANSMISSION

5.2L

5.2L CNG, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L CNG, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500:

• (front of engine) g125
• (i/p right center support, near radio) g206
• (left fender side shield) g100
• 4wd ind
• 4wd sense
• 4wd switch (on front of frame)
• A14
• A16
• A17
• A22
• A23
• A31
• A32
• B11
• B21
• B25
• B27
• B28
• B29
• B30
• B31
• Brake sw sense
• C11
• C13
• C135
• C136
• C137
• C209
• C215
• C228
• C24
• C241
• C27
• C29
• C32
• Connector (partial) (under left
• Controller anti-lock brake (center of i/p)
• Cruise control system
• D20
• D21
• Data link
• Ect sens sig
• F18
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fuse block
• Fused b(+)
• Fused ign (st/run)
• G107
• G206 (i/p right center support, near radio)
• Gnd
• Gov press sig
• Hot in run or start
• Hot w/headlamp switch in park or head position (rehostat controlled)
• If equipped
• Illum
• Ind
• Instrument cluster
• Joint connector c (behind knee bolster)
• Joint connector c (pin 5)
• K22
• K30
• K54
• K88
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Output shaft spd sens gnd
• Output shaft spd sens sig
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (right side of safety wall)
• S103
• S105 (in branch for horn break out)
• S111 (in branch to controller anti-lock brakes)
• S132
• S139
• S208
• S209
• S215
• Sc1 receive
• Sci transmit
• Sensor gnd
• Side of i/p)
• Spd cntl feed
• Spd ctrl sw sig
• Spd vac sol ctrl
• Spd vent sol ctrl
• Stop lamp switch (top of brake pedal arm)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tan/red
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var sol ctrl
• Vss signal
• W/anti-lock brakes system
• W/o anti- lock brakes system
• W/o anti-lock brakes system
• Z12

5.2L CNG, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L CNG, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500:

• (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
• (before branch to fuel injectors 1,3,5,7 & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s154
• (before branch to fuel injectors 1,3,5,7, & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s136
• (before branch to fuel injectors 2, 4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s129
• (near branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s130
• (not used)
• Acc
• Automatic shut down relay
• C169
• C180
• C212
• C241
• Engine coolant temperature sensor (near thermostat)
• Engine starter motor relay
• Fuel pump relay
• Fuse 20a
• Fuse 40a
• Fuse 10a
• Fuse block
• Governor pressure signal
• Hot at all times
• Ignition switch
• Instrument cluster (speedometer)
• Off
• Overdrive solenoid control
• Park/ neutral position switch (left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• Run
• S114
• S124
• S137 (near distributor break out) (3.9l, 5.2l, 5.2l cng & 5.9l engines) (near break out to idle air control motor) (8.0l engine)
• S141 (in branch to transmission wiring) (3.9l, 5.2l, 5.2l cng, 5.9l engines) (before branch to oxygen sensors & vehicle speed sensor) (8.0l engine)
• S156 (in branch to engine harness connectors)
• Sensor ground
• Start
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission relay
• Transmission solenoid assembly (on side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid control
• Vehicle speed control/horn switch
• Vehicle speed sensor (rear of transmission) (2wd models) (rear of transfer case) (4wd models)

5.2L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500:

• (front of engine) g125
• (i/p right center support, near radio) g206
• (left fender side shield) g100
• 4wd ind
• 4wd sense
• 4wd switch (on front of frame)
• A14
• A16
• A17
• A22
• A23
• A31
• A32
• B11
• B21
• B25
• B27
• B28
• B29
• B30
• B31
• Brake sw sense
• C11
• C13
• C135
• C136
• C137
• C209
• C215
• C228
• C24
• C241
• C27
• C29
• C32
• Connector (partial) (under left
• Controller anti-lock brake (center of i/p)
• Cruise control system
• D20
• D21
• Data link
• Ect sens sig
• F18
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fuse block
• Fused b(+)
• Fused ign (st/run)
• G107
• G206 (i/p right center support, near radio)
• Gnd
• Gov press sig
• Hot in run or start
• Hot w/headlamp switch in park or head position (rehostat controlled)
• If equipped
• Illum
• Ind
• Instrument cluster
• Joint connector c (behind knee bolster)
• Joint connector c (pin 5)
• K22
• K30
• K54
• K88
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Output shaft spd sens gnd
• Output shaft spd sens sig
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (right side of safety wall)
• S103
• S105 (in branch for horn break out)
• S111 (in branch to controller anti-lock brakes)
• S132
• S139
• S208
• S209
• S215
• Sc1 receive
• Sci transmit
• Sensor gnd
• Side of i/p)
• Spd cntl feed
• Spd ctrl sw sig
• Spd vac sol ctrl
• Spd vent sol ctrl
• Stop lamp switch (top of brake pedal arm)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tan/red
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var sol ctrl
• Vss signal
• W/anti-lock brakes system
• W/o anti- lock brakes system
• W/o anti-lock brakes system
• Z12

5.2L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.2L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500:

• (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
• (before branch to fuel injectors 1,3,5,7 & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s154
• (before branch to fuel injectors 1,3,5,7, & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s136
• (before branch to fuel injectors 2, 4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s129
• (near branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s130
• (not used)
• Acc
• Automatic shut down relay
• C169
• C180
• C212
• C241
• Engine coolant temperature sensor (near thermostat)
• Engine starter motor relay
• Fuel pump relay
• Fuse 20a
• Fuse 40a
• Fuse 10a
• Fuse block
• Governor pressure signal
• Hot at all times
• Ignition switch
• Instrument cluster (speedometer)
• Off
• Overdrive solenoid control
• Park/ neutral position switch (left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• Run
• S114
• S124
• S137 (near distributor break out) (3.9l, 5.2l, 5.2l cng & 5.9l engines) (near break out to idle air control motor) (8.0l engine)
• S141 (in branch to transmission wiring) (3.9l, 5.2l, 5.2l cng, 5.9l engines) (before branch to oxygen sensors & vehicle speed sensor) (8.0l engine)
• S156 (in branch to engine harness connectors)
• Sensor ground
• Start
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission relay
• Transmission solenoid assembly (on side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid control
• Vehicle speed control/horn switch
• Vehicle speed sensor (rear of transmission) (2wd models) (rear of transfer case) (4wd models)

5.9L

5.9L Turbo Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500:

• (front of engine) g125
• (i/p right center support, near radio) g206
• (left fender side shield) g100
• 4wd ind
• 4wd sense
• 4wd switch (on front of frame)
• A14
• A17
• A22
• A23
• A31
• A32
• B11
• B21
• B25
• B27
• B28
• B29
• B30
• B31
• Brake sw sense
• C11
• C13
• C135
• C136
• C137
• C209
• C215
• C228
• C24
• C241
• C27
• C29
• C32
• Connector (partial) (under left
• Controller anti-lock brake (center of i/p)
• Cruise control system
• D20
• D21
• Data link
• Eng spd sens
• F18
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fuse block
• Fused b(+)
• Fused ign (st/run)
• G107
• G206 (i/p right center support, near radio)
• Gnd
• Gov press sig
• Hot in run or start
• Hot w/headlamp switch in park or head position (rehostat controlled)
• If equipped
• Illum
• Ind
• Instrument cluster
• Joint connector c (behind knee bolster)
• Joint connector c (pin 5)
• K22
• K24
• K30
• K54
• K88
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Output shaft spd sens gnd
• Output shaft spd sens sig
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (right side of safety wall)
• S103
• S105 (in branch for horn break out)
• S111 (in branch to controller anti-lock brakes)
• S132
• S139
• S208
• S209
• S215
• Sc1 receive
• Sci transmit
• Sensor gnd
• Side of i/p)
• Spd cntl feed
• Spd ctrl sw sig
• Spd vac sol ctrl
• Spd vent sol ctrl
• Stop lamp switch (top of brake pedal arm)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tan/red
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var sol ctrl
• Vss signal
• W/anti-lock brakes system
• W/o anti- lock brakes system
• W/o anti-lock brakes system
• Z12

5.9L Turbo Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L Turbo Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500:

• (after break out to engine coolant temperature sending unit) s130
• (between break outs for intake air heaters & fuel heater) s157
• (no location given) s137
• (not used)
• Acc
• Automatic shut down relay
• C169
• C180
• C212
• C241
• Engine speed sensor (front of engine)
• Engine starter motor relay
• Fuel pump relay (not used on diesel)
• Fuse 20a
• Fuse 40a
• Fuse 10a
• Fuse block
• Governor pressure signal
• Hot at all times
• Ignition switch
• Instrument cluster (speedometer)
• Off
• Overdrive solenoid control
• Park/ neutral position switch (left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• Run
• S114
• S124
• S131 (before pcm)
• S141 (before pcm)
• S156 (in branch to engine harness connectors)
• S159 (before pcm)
• Sensor ground
• Start
• Throttle position sensor (on injection pump)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Trans- mission relay
• Transmission solenoid assembly (on side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid control
• Vehicle speed control/horn switch
• Vehicle speed sensor (rear of transmission) (2wd models) (rear of transfer case) (4wd models)

5.9L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500:

• (front of engine) g125
• (i/p right center support, near radio) g206
• (left fender side shield) g100
• 4wd ind
• 4wd sense
• 4wd switch (on front of frame)
• A14
• A16
• A17
• A22
• A23
• A31
• A32
• B11
• B21
• B25
• B27
• B28
• B29
• B30
• B31
• Brake sw sense
• C11
• C13
• C135
• C136
• C137
• C209
• C215
• C228
• C24
• C241
• C27
• C29
• C32
• Connector (partial) (under left
• Controller anti-lock brake (center of i/p)
• Cruise control system
• D20
• D21
• Data link
• Ect sens sig
• F18
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fuse block
• Fused b(+)
• Fused ign (st/run)
• G107
• G206 (i/p right center support, near radio)
• Gnd
• Gov press sig
• Hot in run or start
• Hot w/headlamp switch in park or head position (rehostat controlled)
• If equipped
• Illum
• Ind
• Instrument cluster
• Joint connector c (behind knee bolster)
• Joint connector c (pin 5)
• K22
• K30
• K54
• K88
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Output shaft spd sens gnd
• Output shaft spd sens sig
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (right side of safety wall)
• S103
• S105 (in branch for horn break out)
• S111 (in branch to controller anti-lock brakes)
• S132
• S139
• S208
• S209
• S215
• Sc1 receive
• Sci transmit
• Sensor gnd
• Side of i/p)
• Spd cntl feed
• Spd ctrl sw sig
• Spd vac sol ctrl
• Spd vent sol ctrl
• Stop lamp switch (top of brake pedal arm)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tan/red
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var sol ctrl
• Vss signal
• W/anti-lock brakes system
• W/o anti- lock brakes system
• W/o anti-lock brakes system
• Z12

5.9L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 5.9L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500:

• (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
• (before branch to fuel injectors 1,3,5,7 & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s154
• (before branch to fuel injectors 1,3,5,7, & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s136
• (before branch to fuel injectors 2, 4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s129
• (near branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s130
• (not used)
• Acc
• Automatic shut down relay
• C169
• C180
• C212
• C241
• Engine coolant temperature sensor (near thermostat)
• Engine starter motor relay
• Fuel pump relay
• Fuse 20a
• Fuse 40a
• Fuse 10a
• Fuse block
• Governor pressure signal
• Hot at all times
• Ignition switch
• Instrument cluster (speedometer)
• Off
• Overdrive solenoid control
• Park/ neutral position switch (left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• Run
• S114
• S124
• S137 (near distributor break out) (3.9l, 5.2l, 5.2l cng & 5.9l engines) (near break out to idle air control motor) (8.0l engine)
• S141 (in branch to transmission wiring) (3.9l, 5.2l, 5.2l cng, 5.9l engines) (before branch to oxygen sensors & vehicle speed sensor) (8.0l engine)
• S156 (in branch to engine harness connectors)
• Sensor ground
• Start
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission relay
• Transmission solenoid assembly (on side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid control
• Vehicle speed control/horn switch
• Vehicle speed sensor (rear of transmission) (2wd models) (rear of transfer case) (4wd models)

8.0L

8.0L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R1996 3500:

• (front of engine) g125
• (i/p right center support, near radio) g206
• (left fender side shield) g100
• 4wd ind
• 4wd sense
• 4wd switch (on front of frame)
• A14
• A16
• A17
• A22
• A23
• A31
• A32
• B11
• B21
• B25
• B27
• B28
• B29
• B30
• B31
• Brake sw sense
• C11
• C13
• C135
• C136
• C137
• C209
• C215
• C228
• C24
• C241
• C27
• C29
• C32
• Connector (partial) (under left
• Controller anti-lock brake (center of i/p)
• Cruise control system
• D20
• D21
• Data link
• Ect sens sig
• F18
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 5a
• Fuse block
• Fused b(+)
• Fused ign (st/run)
• G107
• G206 (i/p right center support, near radio)
• Gnd
• Gov press sig
• Hot in run or start
• Hot w/headlamp switch in park or head position (rehostat controlled)
• If equipped
• Illum
• Ind
• Instrument cluster
• Joint connector c (behind knee bolster)
• Joint connector c (pin 5)
• K22
• K30
• K54
• K88
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Output shaft spd sens gnd
• Output shaft spd sens sig
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (right side of safety wall)
• S103
• S105 (in branch for horn break out)
• S111 (in branch to controller anti-lock brakes)
• S132
• S139
• S208
• S209
• S215
• Sc1 receive
• Sci transmit
• Sensor gnd
• Side of i/p)
• Spd cntl feed
• Spd ctrl sw sig
• Spd vac sol ctrl
• Spd vent sol ctrl
• Stop lamp switch (top of brake pedal arm)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tan/red
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var sol ctrl
• Vss signal
• W/anti-lock brakes system
• W/o anti- lock brakes system
• W/o anti-lock brakes system
• Z12

8.0L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500

List of elements for 8.0L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R1996 3500:

• (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
• (before branch to fuel injectors 1,3,5,7 & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s154
• (before branch to fuel injectors 1,3,5,7, & (9)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s136
• (before branch to fuel injectors 2, 4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s129
• (near branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s130
• (not used)
• Acc
• Automatic shut down relay
• C169
• C180
• C212
• C241
• Engine coolant temperature sensor (near thermostat)
• Engine starter motor relay
• Fuel pump relay
• Fuse 20a
• Fuse 40a
• Fuse 10a
• Fuse block
• Governor pressure signal
• Hot at all times
• Ignition switch
• Instrument cluster (speedometer)
• Off
• Overdrive solenoid control
• Park/ neutral position switch (left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• Run
• S114
• S124
• S137 (near distributor break out) (3.9l, 5.2l, 5.2l cng & 5.9l engines) (near break out to idle air control motor) (8.0l engine)
• S141 (in branch to transmission wiring) (3.9l, 5.2l, 5.2l cng, 5.9l engines) (before branch to oxygen sensors & vehicle speed sensor) (8.0l engine)
• S156 (in branch to engine harness connectors)
• Sensor ground
• Start
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission relay
• Transmission solenoid assembly (on side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid control
• Vehicle speed control/horn switch
• Vehicle speed sensor (rear of transmission) (2wd models) (rear of transfer case) (4wd models)

WARNING SYSTEMS

Warning System Wiring Diagrams for Dodge Cab & Chassis R1996 3500

List of elements for Warning System Wiring Diagrams for Dodge Cab & Chassis R1996 3500:

• (behind knee bolster)
• (below left rear speaker)
• (i/p right center support)
• (left kick panel)
• Buzzer module (on i/p support, right of steering column)
• C216
• Exterior lights system
• F12
• Fuse 10a
• Fuse 15a
• Fuse block (left side of i/p)
• Fused b (+)
• G10
• G13
• G200
• G206
• G26
• G308
• Ground
• Head
• Headlamp switch
• Hot at all times
• Hot in run or start
• Ignition
• Instrument cluster
• Joint connector c (behind knee bolster)
• Joint connector c
• Key-in- switch/ halo lamp (part of ignition switch)
• Key-in/ lts-on/door open sense
• Left door jamb switch
• Lp driver
• Off
• Park
• Pnk
• Seat belt
• Seat belt lamp
• Seat belt switch (in left "b" pillar)
• Switch sense

WIPER/WASHER

Wiper/Washer Wiring Diagram for Dodge Cab & Chassis R1996 3500

List of elements for Wiper/Washer Wiring Diagram for Dodge Cab & Chassis R1996 3500:

• (in washer reservoir)
• (in windshield washer reservoir)
• (multi- function switch)
• Acc/run
• C215
• Delay out
• Dly
• Fuse 15a
• Fuse 20a
• Fuse block (left side of i/p)
• G100 (left fender side shield)
• G104 (left fender shield)
• G206 (i/p right center support)
• Gnd
• Ground joint (near power distribution center)
• Hot in acc or run
• Hot in run or start
• Instrument cluster
• Intermittent wiper control module (top center of i/p)
• Intermittent wiper switch
• Low washer fluid switch
• Low washer indicator
• Mode sens
• Off
• Park
• Park switch
• Red/
• Sw mode
• V10
• Vi7
• Wash
• Washer
• Windshield washer pump motor
• Windshield wiper motor