Dodge Neon High Line 1999 - ELECTRICAL COMPONENT LOCATOR 1999 ELECTRICAL COMPONENT LOCATION Chrysler Motors Electrical Component Location
Dodge Neon High Line 1999 - INTRODUCTION
NOTE: Some component locations are illustrated by graphics. - the following tables for proper figure references.
Dodge Neon High Line 1999 - SAFETY PRECAUTION
WARNING: When working on vehicles equipped with Supplemental Restraint System (SRS), never apply electrical voltage to the system. This could cause the SRS (air bag) to be deployed.
Dodge Neon High Line 1999 - BUZZERS, RELAYS & TIMERS
Dodge Neon High Line 1999 BUZZERS, RELAYS & TIMERS
Component Component Location ABS Warning Indicator Relay In power distribution center. A/C Compressor Clutch Relay In power distribution center. Automatic Shut Down Relay In power distribution center. Combination Flasher On fuse block. Engine Starter Motor Relay In power distribution center. Fan Relay (Solid State) On left front inner frame, behind radiator. Fuel Pump Relay In power distribution center. Horn Relay In power distribution center. Ignition Key Lamp Relay On fuse block. Interior Lamp Relay On fuse block.
Dodge Neon High Line 1999 - CIRCUIT PROTECTION DEVICES
Dodge Neon High Line 1999 CIRCUIT PROTECTION DEVICES
Component Component Location Fuse Block Under left side of dash. Power Distribution Center At rear of battery. See Fig. 1 .
Dodge Neon High Line 1999 - CONTROL UNITS
Dodge Neon High Line 1999 CONTROL UNITS
Component Component Location Air Bag Control Module Under rear of center console. Controller Anti-Lock Brake On left front frame rail, below master cylinder. Daytime Running Lamp (DRL) Module On underside of dash, attached to support brace. Fuel Tank Module On fuel tank. Powertrain Control Module On left front inner fender. See Fig. 2 . Remote Keyless Entry Module Under center of dash, above HVAC controls.
Dodge Neon High Line 1999 - MOTORS
Dodge Neon High Line 1999 MOTORS
Component Component Location A/C-Heater Blower Motor On right side of HVAC housing. Idle Air Control Motor On throttle body. Leak Detection Pump On right front inner fender panel. Power Sun Roof Motor Above headliner, front of sun roof opening. Radiator Fan Motor On rear of radiator. Windshield Washer Pump In bottom of washer fluid reservoir. Wiper Motor On left side of firewall.
Dodge Neon High Line 1999 - SENDING UNITS & SENSORS
Dodge Neon High Line 1999 SENDING UNITS & SENSORS
Component Component Location Battery Temperature Sensor On front lower portion of battery tray. See Fig. 1 . Camshaft Position (CMP) Sensor At rear of cylinder head. See Fig. 3 . Crankshaft Position (CKP) Sensor On engine block, above oil filter. See Fig. 4 . Downstream Heated Oxygen Sensor Rear of catalytic converter. Engine Coolant Temperature Sensor (DOHC) On intake manifold, next to thermostat housing. Engine Coolant Temperature Sensor (SOHC) On rear of cylinder head, next to camshaft position sensor. See Fig. 3 . IAT/MAP Sensor On intake manifold. Knock Sensor On side of engine block, in front of starter. Throttle Position Sensor On throttle body. Upstream Heated Oxygen Sensor At right side of engine, on exhaust manifold. See Fig. 4 . Vehicle Speed Sensor In transmission extension housing. See Fig. 4 . Wheel Speed Sensor (Front) (2) On respective steering knuckle. Wheel Speed Sensor (Rear) (2) On respective disc brake adapter.
Dodge Neon High Line 1999 - SOLENOIDS & SOLENOID VALVES
Dodge Neon High Line 1999 SOLENOIDS & SOLENOID VALVES
Component Component Location Duty Cycle EVAP/Purge Solenoid On right strut tower. EGR Transducer Solenoid Mounted to clean air hose. See Fig. 3 . Torque Converter Clutch Solenoid In transmission, on valve body. Vehicle Speed Control Servo On side of battery tray.
Dodge Neon High Line 1999 - SWITCHES
Dodge Neon High Line 1999 SWITCHES
Component Component Location A/C Cycling Switch Center of HVAC housing. A/C High Pressure Switch On top of A/C compressor. A/C Low Pressure Switch On expansion valve. Back-Up Light Switch On top of transmission. See Fig. 2 . Clutch Interlock Switch (M/T) On clutch pedal bracket. See Fig. 5 . Engine Oil Pressure Switch On right side of engine block. See Fig. 4 . Park/Neutral Position Switch (A/T) On left side of transmission. Power Steering Pressure Switch On power steering gear. Seat Belt Switch At left "B" pillar. Stoplight Switch Top of brake pedal support. See Fig. 5 .
Dodge Neon High Line 1999 - MISCELLANEOUS
Dodge Neon High Line 1999 MISCELLANEOUS
Component Component Location Blower Motor Resistor Block On right side of firewall. Data Link Connector (DLC) At left side of steering column. Ignition Coil Pack On top of valve cover. See Fig. 3 .
Dodge Neon High Line 1999 - CONNECTORS
Dodge Neon High Line 1999 CONNECTORS LOCATION
Component Location C101 (Brown, 16 Pin) Behind top center of dash. C102 (Black, 4 Pin) Behind top center of dash. C103 (Blue, 16 Pin) Behind top center of dash. C105 (Black, 6 Pin) Behind left kick panel. C106 (Black, 4 Pin) At left rear of engine compartment. C108 (Light Gray, 4 Pin) At rear of ABS hydraulic unit. C160 (Light Gray, 14 Pin) Near power distribution center. C161 (Black, 10 Pin) Near power distribution center. C205 (Blue, 16 Pin) Behind left kick panel. C202 (Light Green, 10 Pin) Behind upper right side of dash. C203 (Light Gray, 6 Pin) Behind upper right side of dash. C204 (Red, 6 Pin) Behind upper left side of dash. C205 (Gray, 20 Pin) Behind lower left side of dash. C206 (Blue, 6 Pin) Behind upper right side of dash. C225 (Red, 6 Pin) Below top center of dash. C230 (Gray, 20 Pin) Behind left side of dash. C231 (Blue, 16 Pin) Behind left side of dash. C301 (Black/Gray, 2 Pin) At right "B" pillar. C303 (Black/Gray, 2 Pin) At left "B" pillar. C304 (Blue/Black, 7 Pin) At right "B" pillar. C309 (Black, 3 Pin) At left rear wheelwell.
Dodge Neon High Line 1999 - GROUNDS
Dodge Neon High Line 1999 GROUNDS LOCATION
Component Location G101 At top left side of radiator closure panel. See Fig. 2 . G102 At top left side of radiator closure panel. See Fig. 2 . G103 At right side of radiator closure panel. G104 Near starter motor. G105 Near front of battery. G106 On left frame rail. See Fig. 2 . G201 Behind left center of dash. G202 Behind left center of dash. G203 Behind right center of dash. G204 Behind right center of dash. G301 Behind right rear quarter panel. G302 Behind left rear quarter panel. G303 Behind left rear quarter panel.
Dodge Neon High Line 1999 - SPLICES
Dodge Neon High Line 1999 SPLICES LOCATION
Component Location S101 Near breakout for data link connector. S102 Near breakout for controller anti-lock brake. S103 Near breakout for controller anti-lock brake. S104 At left strut tower. S105 At left strut tower. S106 Near breakout for powertrain control module. See Fig. 2 . S107 Before breakout for left headlight. See Fig. 2 . S108 Before breakout for left headlight. See Fig. 2 . S109 Before breakout for left headlight. See Fig. 2 . S110 At breakout for powertrain control module. See Fig. 2 . S111 Near breakout for radiator fan motor. S112 Near breakout for left headlight. See Fig. 2 . S113 Near breakout for left headlight. See Fig. 2 . S114 Near breakout for left headlight. S115 Near breakout for radiator fan motor. S116 Near breakout for left foglight. S117 Near breakout for EVAP/purge solenoid. S118 On right side of engine. See Fig. 4 . S119 On right side of engine. See Fig. 4 . S120 On top left side of engine. S121 On top left side of engine. S122 On rear of engine. S123 On rear of engine. S125 On top left side of engine. S126 Near breakout for powertrain control module. See Fig. 2 . S127 On right rear of engine. S142 Near breakout for horn. S201 Near breakout for center console. S202 Near breakout for passenger air bag. S203 Near breakout for HVAC. S204 Near breakout for HVAC. S205 Behind center of dash. S206 Behind center of dash. S207 Behind top center of dash. S208 Behind top center of dash. S209 Behind top center of dash. S210 Behind top center of dash. S211 Behind center of dash. S212 Behind center of dash. S213 Behind left side of dash, near breakout for fuse block. S214 Behind left side of dash, near breakout for fuse block. S215 At breakout for door/body. S216 Near breakout for steering column. S217 Behind left side of dash, near fuse block. S218 Behind center of dash. S219 Behind center of dash. S220 Behind left side of dash, near breakout for fuse block. S301 Near breakout for left "B" pillar. S302 Near breakout for left "B" pillar. S303 Near breakout for left "B" pillar. S304 Near breakout for fuel tank. S305 Near breakout for right taillight. S306 Near breakout for fuel tank. S307 Near breakout for left taillight. S308 Near breakout for left taillight. S309 Near top of left "A" pillar. S310 Near breakout for driver's side power mirror. S311 At left rear wheelwell. S312 At right rear wheelwell. S313 Near breakout for sun roof slide switch. S314 Near breakout for sun roof slide switch.
Dodge Neon High Line 1999 - COMPONENT LOCATION GRAPHICS
NOTE:
Fig.res may show multiple component locations. - appropriate table for proper figure references.
Fig. 1: Dodge Neon High Line 1999 - Component Locations - Left Front Side Of Engine Compartment
Fig. 2: Dodge Neon High Line 1999 - Component Locations - Left Front Frame
Fig. 3: Dodge Neon High Line 1999 - Component Locations - Rear Of Engine
Fig. 4: Dodge Neon High Line 1999 - Component Locations - Right Side Of Engine
Fig. 5: Dodge Neon High Line 1999 - Component Locations - Below Left Side Of Dash