AIR CONDITIONING
A/C Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for A/C Wiring Diagram for Ford Aerostar 1997:
- (3.0l)
- (4.0l)
- (generator rectifier sys harn, on a/c clutch field coil breakout) s129
- (rear lamp harn, left rear of cargo area)
- (rear lamp harn, near aux blower motor relay breakout)
- (rear lamp harn, near auxiliary blower motor breakout)
- (top left center of safety wall)
- (top rear corner of right fender apron)
- A/c clutch diode
- A/c clutch field coil
- A/c wot cutout relay (in engine compartment relay box )
- A/c-heater control assembly
- Auxiliary a/c system refrigerant valve solenoid (behind left b pillar)
- Auxiliary blower motor
- Auxiliary blower motor relay (behind left b pillar)
- Auxiliary blower motor resistor assembly (behind left b pillar)
- Blower motor
- Blower motor resistor assembly (top right side of safety wall)
- Blower motor switch
- Clutch cycling pressure switch (right rear of engine compartment on a/c accumulator)
- Def
- Defrost
- Floor
- Front auxiliary blower motor switch
- Fuse 6 20a
- Fuse 9 30a
- Fuse panel
- G105
- G121
- G206 (behind center of i/p, left of radio)
- Heat
- High pressure cutoff switch (3.0l-right front of engine) (4.0l-left front of engine)
- Hot at all times
- Hot in accy or run
- Hot in run
- Max
- Med
- Mix
- Norm
- Off
- Pcm power relay
- Power- train control module (pcm) (top left side of safety wall)
- Rear
- Rear auxiliary blower motor switch
- Red
- S102 (eng control sens harn, top rear corner of right fender apron)
- S104 (generator rectifier sys harn, right front of eng compt)
- S106 (engine control sensor harness)
- S137 (eng control sens harn, near blower motor breakout)
- S215 (main harn, behind center of i/p)
- S243 (main harn, behind center of i/p)
- S283 (main harn, behind left side of i/p)
- S303 (rear lamp harn, left side of cargo area)
- S309 (rear lamp harn, near auxiliary blower motor breakout)
- S310
- S311
- S312 (rear lamp harn, near auxiliary blower motor resistor assembly breakout)
- S318
- Vent
Heater Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Heater Wiring Diagram for Ford Aerostar 1997:
- (not used)
- (rear lamp harn, left rear of cargo area)
- (rear lamp harn, near aux blower motor relay breakout)
- (rear lamp harn, near auxiliary blower motor breakout)
- Auxiliary blower motor
- Auxiliary blower motor relay (behind left b pillar)
- Auxiliary blower motor resistor assembly (behind left b pillar)
- Blower motor
- Blower motor resistor assembly (top right side of safety wall)
- Blower motor switch
- Defrost
- Front auxiliary blower motor switch
- Fuse 9 30a
- Fuse panel
- G105 (top rear corner of right fender apron)
- G206 (behind center of i/p, left of radio)
- Heat
- Heater control assembly
- Hot at all times
- Hot in run
- Med
- Mix
- Off
- Rear
- Rear auxiliary blower motor switch
- S102 (eng control sens harn, top rear corner of right fender apron)
- S137 (eng control sens harn, near blower motor breakout)
- S243 (main harn, behind center of i/p)
- S283 (main harn, behind left side of i/p)
- S303 (rear lamp harn, left side of cargo area)
- S309 (rear lamp harn, near auxiliary blower motor breakout)
- S310
- S311
- S312 (rear lamp harn, near auxiliary blower motor resistor assembly breakout)
- S318
- Vent
ANTI-LOCK BRAKES
Anti-lock Brake Wiring Diagrams for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Anti-lock Brake Wiring Diagrams for Ford Aerostar 1997:
- "anti-lock" brakes indicator
- "brake" indicator
- (main harn, in breakout to rabs module) s212
- (main harn, near breakout to instrument cluster) s231
- (top of rear axle)
- Acc
- Brake fluid level switch (left rear of engine compartment, on brake master cylinder)
- Brake on/off (boo) switch (on brake pedal support)
- Brake on/off input
- Brake warning resistor/diode assembly (taped to main harness, near g206)
- C250
- C251
- Diff sensor ground
- Diff speed input
- Differential speed sensor (dds)
- Dss input
- Dss return
- Dss test connector (left rear of engine compart- ment)
- Dump sol output
- Dump solenoid
- Dump valve solenoid
- Fuse 15a
- Fuse 20a
- Fuse panel (behind left side of i/p, left of steering column)
- G100 (front of left fender apron, left of battery)
- G206 (behind center of instrument panel, below left side of radio)
- Gnd
- Hot at all times
- Hot in run
- Hot in start or run
- Ignition switch
- Instrument cluster
- Isolation sol output
- Isolation valve solenoid
- Lock
- Low fluid lvl input
- Module ground
- Nca
- Off
- Power (hot in run)
- Pressure differential warning switch (left rear of engine compartment, below brake fluid reservoir)
- Psom module (instrument cluster)
- Pwr (hot all times)
- Rabs proportioning valve switch assembly (left rear of engine compartment, below master cylinder)
- Rabs test connector (behind left side of instrument panel, taped to main harness)
- Rear anti-lock brake module (rabs) (behind center of i/p, below ashtray)
- Red
- Red/pnk
- S105
- S213
- S216
- S228
- S232 (main harn, near breakout to instrument cluster)
- S233 (main harn, in breakout to rabs module)
- S262 (main harn, near breakout to wiper control module)
- S265 (main harn, near breakout to ground g206)
- S274
- Start run
- Valve reset
- Warning lamp
COMPUTER DATA LINES
Computer Data Lines for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Computer Data Lines for Ford Aerostar 1997:
- Bus (+)
- Bus (-)
- Data link connector (dlc) (center of i/p)
- G114 (left rear of engine compartment, on safety wall)
- G206 (behind center of i/p, below left side of radio)
- Hot at all times
- Powertrain control module (pcm) (top left side of safety wall, left side of brake master cylinder)
- Red
- S222
- S243
- To trailer/ camper adapter
CRUISE CONTROL
Cruise Control Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Cruise Control Wiring Diagram for Ford Aerostar 1997:
- (main harn, near break- out to speed control switch assembly) s200
- Brake input
- Brake on/off (boo) switch (on brake pedal support)
- C228
- C249
- Clock- spring assembly (top of steering column)
- Coast
- Exterior lights system
- Fuse 15a
- Fuse 20a
- Fuse 30a
- Fuse panel
- G206 (behind center of i/p, below right side of radio)
- Horn relay (behind lower left side of i/p)
- Horn switch
- Hot at all times
- Hot in acc or run
- Instrument cluster
- Nca
- Off
- Ohms
- Power
- Psom module
- Resume
- S200
- S201 (main harn, near breakout to speed control switch assembly)
- S209
- S214
- S215
- S218
- S228 (main harn, near breakout to shift lock actuator)
- Set/ accel
- Speed control disable switch (behind left side of i/p)
- Speed control servo/amplifier assembly (left rear corner of engine compt)
- Speed control switch assembly (in steering wheel)
- Vss input
- Vss output
DEFOGGERS
Defogger Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Defogger Wiring Diagram for Ford Aerostar 1997:
- (behind center of i/p,
- (center of left fender apron, at starter relay)
- (top left side of rear door/liftgate header)
- Below left side of radio)
- Fuse 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G206
- G406
- Hot at all times
- Hot in run
- Illumination
- Interior lights system
- Momentary switch
- On indicator
- Rear window defrost control
- Rear window defrost grid
- Relay
- S221
- S249
- S274
- Timing circuit
ENGINE PERFORMANCE
3.0L
3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Aerostar 1997:
- (ckp) sensor (+)
- (ckp) sensor (-)
- (engine harness, in breakout to pcm) s107
- (engine harness, near breakout to pcm inline fuse)
- (ho2s) rear
- (left rear of engine compartment, on safety wall)
- (pf) sensor
- 10a
- A/c cutoff sw
- Air conditioning system
- Ccs sol
- Ckp shield
- Data link (+)
- Data link (-)
- Data link connector (dlc) (center of i/p)
- Dlc
- Ect sens in
- Egr vac reg
- Engine compartment relay box (left rear of engine comartment)
- Engine compartment relay box (left rear of engine compartment)
- Fuel pump mon
- Fuel pump relay
- Fuse 15a
- Fuse panel (behind left of i/p, left of steering column)
- G103 (left center of safety wall, near windshield wiper motor)
- G107
- Ground
- Hot at all times
- Hot in start or run
- Iat sens
- Ign coil #1
- Ign coil #2
- Ignition coil (top left rear of engine)
- Maf sig rtn
- Mil
- Nca
- Octane adj plug
- Off
- Pcm inline fuse (left rear of engine compartment)
- Pcm power relay
- Pcm pwr relay diode
- Powertrain control module (left side of safety wall, left side of brake master cylinder)
- Primary
- Purge flow sensor (top center front of engine)
- Pwr gnd
- Radio noise capacitor (top left rear of engine)
- Red
- S101
- S109 (fuel harness, near breakout to ignition coil)
- S113
- S122
- S124 (engine harness, near breakout to pcm inline fuse)
- S213
- Secondary
- Shield gnd
- Shift sol 1
- Shift sol 2
- Tach
- To spark plugs
- Tr1
- Tr2
- Tr4
- Trans ctrl sw
- Trans fl temp
- Transmission control indicator lamp (tcil)
- Transmission control switch (tcs)
3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Aerostar 1997:
- (ckp) shield
- (cmp) shield
- (engine harness, near breakout to octane adjust shorting bar)
- (fuel harness, near breakout to fuel injector #4)
- Brake warning resistor/ diode assembly (behind left side of i/p, taped to main harness)
- C251
- Camshaft position (cmp) sensor (top rear of engine)
- Crankshaft position (ckp) sensor (lower right front of engine)
- Differential pressure feedback egr (dpfe) sensor (top left front of engine)
- Engine coolant temperature (ect) sensor (top center front of engine)
- Fuse 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G103 (left center of safety wall, near windshield wiper motor)
- G203 (behind center of i/p, below right side of radio)
- Hot in start
- Instrument cluster
- Intake air temperature (iat) sensor (left side of engine compartment)
- Malfunction indicator lamp (mil) (check engine)
- Nca
- Octane adjust plug (left rear of engine compartment)
- Or run
- Red
- S110 (fuel harness, near breakout to 8-pin gray conn, near middle of safety wall)
- S113
- S123
- S125
- S200
- S209
- S213
- Throttle position (tp) sensor (top center front of engine)
3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Aerostar 1997:
- (behind center of right cowl panel) inertia fuel shut-off (ifs) switch
- (top of fuel tank) fuel pump/ fuel gauge sender
- (under center of vehicle, behind engine) 4r44e/4r55e automatic transmission
- Air conditioning system
- Coast clutch sole- noid (css)
- Egr vacuum regulator (evr) solenoid valve (near fuel injector #3)
- Electronic pressure control (epc) solenoid
- Evaporative (evap) emission canister purge valve (left side of engine, near throttle body)
- Fuel injectors (top of engine)
- G200 (behind center of i/p, below left side of radio)
- Idle air control (iac) valve (top left front of engine)
- Red
- S115 (fuel harness, near breakout to fuel injector #4)
- S116 (engine harness, near breakout to pcm)
- S119 (fuel harness, near breakout to fuel injector #2)
- S127
- S204
- Shift solenoid
- Tan
- Torque converter clutch (tcc) solenoid
- Transmission fluid temperature (tft) sensor
- Turbine shaft speed (tss) sensor
3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Aerostar 1997:
- (cmp) shield
- (h2os) front
- (ho2s) front
- (ho2s) front heated oxygen sensor (right rear of engine, on exhaust manifold)
- (ho2s) rear
- (ho2s) rear heated oxygen sensor (right rear of engine, on exhaust manifold)
- (on top of brake pedal)
- (pcm pwr relay)
- (right side of i/p, above cowl panel)
- 270 ohms
- A/c wot cutout
- Air conditioning system
- B+ (kapwr)
- Brake on/off
- Brake on/off (boo) switch
- C249
- Cam pos sens
- Digital transmission range (dtr) sensor (left side of automatic transmission)
- Dpfe sens
- Epc sol ctrl
- Evap can purge
- Fuel inj #2
- Fuel inj #4
- Fuel inj #6
- Fuel inj 1 ctrl
- Fuel inj 3 ctrl
- Fuel inj 5 ctrl
- Fuel pump ctrl
- Fuse 15a
- Fuse panel (behind left side of i/p/ left of steering column)
- G103 (left center of safety wall, near windshield wiper motor)
- Hot at all times
- Iac valve ctrl
- Ignition coil #3
- Instrument cluster
- Maf sens
- Mass air flow (maf) sensor (on air intake assembly)
- Nca
- Near breakout to shift lock actuator)
- Power gnd
- Powertrain control module (pcm) (left side of safety wall, left side of brake master cylinder)
- Psom module
- Pwr gnd
- Red
- Ref volt
- S113
- S122
- S128 (fuel harness, near breakout to fuel injector #4)
- S201 (main harness, near breakout to speed control switch assembly)
- S214
- Shift sol 3
- Sig rtn
- Speed control amplifier
- Speed output
- Tan
- Tcc sol ctrl
- Tp sens
- Tr sens
- Trans ctrl ind
- Tss
- Vss out- put
4.0L
4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Aerostar 1997:
- (ckp) sensor (+)
- (ckp) sensor (-)
- (engine harness, in breakout to pcm) s107
- (engine harness, near breakout to c112 pcm inline fuse)
- (ho2s) rear
- (left rear of engine compartment, on safety wall)
- (pf) sensor
- 10a
- A/c cutoff sw
- Air conditioning system
- Ccs sol
- Ckp shield
- Data link (+)
- Data link (-)
- Data link connector (dlc) (center of i/p)
- Dlc
- Ect sens in
- Egr vac reg
- Engine compartment relay box (left rear of engine comartment)
- Engine compartment relay box (left rear of engine compartment)
- Fuel pump mon
- Fuel pump relay
- Fuse 15a
- Fuse panel (behind left of i/p, left of steering column)
- G103 (left center of safety wall, near windshield wiper motor)
- G107
- Ground
- Hot at all times
- Hot in start or run
- Iat sens
- Ign coil #1
- Ign coil #2
- Ignition coil (right side of engine)
- Maf sig rtn
- Mil
- Nca
- Octane adj plug
- Off
- Output shaft spd
- Pcm inline fuse (left rear of engine compartment)
- Pcm power relay
- Pcm pwr relay diode
- Powertrain control module (left side of safety wall, left side of brake master cylinder)
- Primary
- Purge flow sensor (top center front of engine)
- Pwr gnd
- Radio noise capacitor (right side of engine)
- Red
- S101
- S109 (fuel harness, near breakout to ignition coil)
- S113
- S122
- S213
- Secondary
- Shield gnd
- Shift sol 1
- Shift sol 2
- Tach
- To spark plugs
- Tr1
- Tr2
- Tr4
- Trans ctrl sw
- Trans fl temp
- Transmission control indicator lamp (tcil)
- Transmission control switch (tcs)
4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Aerostar 1997:
- (ckp) shield
- (cmp) shield
- (fuel harness, near breakout to fuel injector #6)
- Brake warning resistor/ diode assembly (behind left side of i/p, taped to main harness)
- C251
- Camshaft position (cmp) sensor (top rear of engine)
- Crankshaft position (ckp) sensor (lower right front of engine)
- Differential pressure feedback egr (dpfe) sensor (top left front of engine)
- Engine coolant temperature (ect) sensor (top center front of engine)
- Fuse 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G103 (left center of safety wall, near windshield wiper motor)
- G203 (behind center of i/p, below right side of radio)
- Hot in start
- Instrument cluster
- Intake air temperature (iat) sensor (left side of engine compartment)
- Malfunction indicator lamp (mil) (check engine)
- Nca
- Octane adjust plug (left rear of engine compartment)
- Or run
- Output shaft speed sensor (mounted on transmission)
- Red
- S110 (fuel harness, near breakout to 8-pin conn, near middle of safety wall)
- S113
- S123
- S125 (engine harness, near breakout to octane adjust shorting bar)
- S200
- S209
- S213
- Throttle position (tp) sensor (top center front of engine)
4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Aerostar 1997:
- (behind center of right cowl panel) inertia fuel shut-off (ifs) switch
- (top of fuel tank) fuel pump/ fuel gauge sender
- (under center of vehicle, behind engine) 4r44e/4r55e automatic transmission
- Air conditioning system
- Coast clutch sole- noid (css)
- Egr vacuum regulator (evr) solenoid valve (near fuel injector #3)
- Electronic pressure control (epc) solenoid
- Evaporative (evap) emission canister purge valve (left side of engine, near throttle body)
- Fuel injectors (top of engine)
- G200 (behind center of i/p, below left side of radio)
- Idle air control (iac) valve (top left front of engine)
- Red
- S115 (fuel harness, near breakout to fuel injector #6)
- S116 (engine harness, near breakout to pcm)
- S119 (fuel harness, near breakout to fuel injector #3)
- S127
- S204
- Shift solenoid
- Tan
- Torque converter clutch (tcc) solenoid
- Transmission fluid temperature (tft) sensor
- Turbine shaft speed (tss) sensor
4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Aerostar 1997:
- (cmp) shield
- (engine harness, near breakout to 8-pin gray conn, above front of trans)
- (h2os) front
- (ho2s) front
- (ho2s) front heated oxygen sensor (right rear of engine, on exhaust manifold)
- (ho2s) rear
- (ho2s) rear heated oxygen sensor (right rear of engine, on exhaust manifold)
- (on top of brake pedal)
- (pcm pwr relay)
- (right side of i/p, above cowl panel)
- 270 ohms
- A/c wot cutout
- Air conditioning system
- B+ (kapwr)
- Brake on/off
- Brake on/off (boo) switch
- C249
- Cam pos sens
- Digital transmission range (dtr) sensor (left side of automatic transmission)
- Dpfe sens
- Epc sol ctrl
- Evap can purge
- Fuel inj #2
- Fuel inj #4
- Fuel inj #6
- Fuel inj 1 ctrl
- Fuel inj 3 ctrl
- Fuel inj 5 ctrl
- Fuel pump ctrl
- Fuse 15a
- Fuse panel (behind left side of i/p/ left of steering column)
- G103 (left center of safety wall, near windshield wiper motor)
- Hot at all times
- Iac valve ctrl
- Ignition coil #3
- Instrument cluster
- Maf sens
- Mass air flow (maf) sensor (on air intake assembly)
- Nca
- Near breakout to shift lock actuator)
- Ods
- Overdrive drum speed sensor (mounted on transmission)
- Power gnd
- Powertrain control module (pcm) (left side of safety wall, left side of brake master cylinder)
- Psom module
- Pwr gnd
- Red
- Ref volt
- S113
- S122
- S126
- S128 (fuel harness, near breakout to evap canister purge valve)
- S201 (main harness, near breakout to speed control switch assembly)
- S214
- Shift sol 3
- Sig rtn
- Speed control amplifier
- Speed output
- Tan
- Tcc sol ctrl
- Tp sens
- Tr sens
- Trans ctrl ind
- Tss
- Vss out- put
EXTERIOR LIGHTS
Back-up Lamps Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Back-up Lamps Wiring Diagram for Ford Aerostar 1997:
- Backup lamps relay (left rear cargo area, part of trailer tow module)
- Digital transmission range (dtr) sensor (left side of automatic transmission)
- Fuse 15a
- Fuse panel
- G206 (behind center of i/p, below left side of radio)
- G402 (center of left 'd' pillar)
- Hot at all times
- Hot in run
- Inline fuse
- Left backup lamp
- Red
- Right backup lamp
- S249
- S301
- S410
- S411
- Trailer backup lights
Exterior Lamps Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Exterior Lamps Wiring Diagram for Ford Aerostar 1997:
- (main harn, behind left side of i/p) s276
- (main harn, near inst cluster breakout) s275
- (main harn, near shift lock actuator breakout)
- (main harness, behind left side of i/p)
- (rear lamp harn, near courtesy lamp relay breakout)
- (rear lamp harn, near left rear stop/side marker/ turn lamp breakout)
- (rear lamp harn, near right rear stop/side marker/ turn lamp breakout)
- 10a
- 12v (in run)
- Backup lamps relay
- Brake on/off (boo) switch (behind left side i/p, on brake pedal support)
- C250
- C251
- C268
- Electronic flasher (behind left side of i/p, on front of fuse panel)
- Fuse 15a
- Fuse panel (behind left side of i/p, left side of steering column)
- G100 (front left fender apron, left of battery)
- G105 (top rear corner of right fender apron, below hood hinge)
- G206 (behind center of i/p, below left side of radio)
- G206 (behind center of i/p, left side of radio)
- G402 (center of left "d" pillar)
- Ground
- Hazard
- Head
- High mount stop lamp
- Hot at all times
- Hot in run
- Instrument cluster
- Left
- Left turn lp
- Left front park/ turn lamp
- Left rear stop/ side marker lamp
- Left turn indicator
- Licence lamp (w/dual rear doors)
- Licence lamps (w/ lift gate)
- Main light switch off
- Multi-function switch (top left side of steering column)
- Nca
- Normal
- Park
- Pulsed 12v
- Red
- Right
- Right turn lp
- Right front park/ turn lamp
- Right rear stop/ side marker lamp
- Right turn indicator
- Running lamps relay (left rear cargo area, part of trailer tow module)
- S102
- S103
- S120 (eng cntrl sens harn, near left headlamp breakout)
- S214
- S216
- S219
- S228
- S249
- S261
- S274
- S301
- S306
- S400
- S402
- S406
- S407
- S410
- S412
- Trailer backup lamps
- Trailer ground
- Trailer left turn/ stop lamps
- Trailer right turn/ stop lamps
- Trailer running lamps
GROUND DISTRIBUTION
Ground Distribution Wiring Diagram (1 of 2) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Ground Distribution Wiring Diagram (1 of 2) for Ford Aerostar 1997:
- (3.0l)
- (4.0l)
- (behind center of i/p, below left side of radio)
- (center of i/p) data link connector (dlc)
- (eng cntrl sens harness)
- (front left fender apron, left of battery)
- (fuel tank gauge sender jumper harn, near elect 4 wheel driver module breakout)
- (left rear of engine compartment, on safety wall)
- (lower left front of engine)
- (lower left rear of engine, near
- (main harn, below powertrain control module)
- (main harn, near speed control amplifier breakout) s250
- (top left center of safety wall, near
- (top rear corner of right fender apron, below hood hinge)
- 3.0l
- 4.0l
- A/c clutch diode
- A/c clutch field coil
- A/c heater control illum-
- Air bag diagnostic monitor
- Battery
- Blower motor resistor assembly
- Brake fluid level switch
- Breakout)
- Button connectors
- C232
- C233
- C250
- C251
- C257
- Camshaft position (cmp) sensor
- Ckp shield
- Cmp shield
- Door lock/ unlock control relay
- Electronic 4 wheel drive module
- Electronic flasher
- Engine compartment relay box
- From ignition switch (diagram 2 of 2)
- G100
- G105
- G110
- G114
- G116
- G206
- Ination
- Instrument cluster
- Left front park/ turn lamp
- Left headlamp
- Mass air flow sensor
- Pcm power relay
- Powertrain control module (pcm)
- Purge flow sensor
- Rabs proportioning valve switch assembly
- Radio
- Rear anti-lock brake system (rabs) module
- Red
- Right front park/ turn lamp
- Right headlamp
- S103 (eng cntrl sensor harn, front of left fender apron)
- S105 (eng control sensor harness)
- S113
- S122
- S245 (main harn, behind center of i/p)
- S261 (main harn, near air bag diagnostic module breakout)
- S264 (main harn, near wiper control module breakout)
- S277
- S300 (door lock feed harn, near sliding door courtesy lamp switch breakout)
- S308
- Sliding door ajar relay
- Starter motor/ solenoid)
- Stepwell lamp
- Warning chime module
- Windshield washer pump motor
- Windshield wiper motor
- Windshield wiper motor)
- Wiper control module
Ground Distribution Wiring Diagram (2 of 2) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Ground Distribution Wiring Diagram (2 of 2) for Ford Aerostar 1997:
- (behind center of i/p, below left side of radio)
- (behind center of i/p, below right
- (fuel tank gauge sender jumper harn, near floor pan grommet breakout) s204
- (rear lamp harn, near courtesy lamp relay breakout) s301
- (rear license lamp feed harn, in center of tailgate)
- (rear license lamp feed harn, rear center of vehicle)
- (tailgate warning switch harn, near license lamps breakout)
- Ashtray lamp
- Auxiliary blower motor relay
- Blower motor switch
- Breakout)
- C249
- C250
- C257
- Cargo lamp
- Data link connector (center of i/p)
- Front auxiliary blower motor switch
- Fuel pump/ fuel gauge sender
- G206
- G206 (behind center of i/p, below right side of radio)
- G406 (top left side of rear door/ liftgate header)
- Glove box lamp and switch
- Gnd
- High mount stop lamp
- High mount stop lamp
- Ignition switch
- Illumi- nated entry timer
- Instrument cluster
- Instrument panel cigar lighter
- Instrument panel cigar lighter lamp
- Left backup lamp
- Left license lamp
- Left rear stop/side marker lamp
- License lamp
- Liftgate ajar switch
- Liftgate washer pump motor
- Liftgate wiper motor
- Liftgate wiper/ washer switch
- Master window/ door lock switch
- Midline radio only
- Nca
- Power door lock module
- Power mirror switch
- Power- train control module
- Premium radio only
- Radio
- Radio amplifier
- Rear auxiliary blower motor switch illumi- nation
- Rear cigar lighter
- Rear cigar lighter illumi- nation
- Rear door latch switch
- Rear window defrost control
- Rear window defrost grid
- Remote head- phone module
- Remote headphone module
- Right backup lamp
- Right license lamp
- Right rear door ajar switch
- Right rear stop/side marker lamp
- S202 (cigar lighter harn, near inst panel cigar lighter breakout)
- S209 (main harn, near instrument cluster breakout)
- S257 (main harn, behind center of i/p)
- S258 (main harn, behind center of i/p)
- S302 (rear lamp harn, near power door lock module breakout)
- S303 (rear lamp harn, left side of cargo area)
- S401 (rear lamp conn harn, near left turn lamp breakout)
- S402
- S403
- S412
- Seat belt buckle switch
- Shift lock actuator
- Side of radio)
- Speed control servo/ amplifier assembly
- To g206 (diagram 1 of 2)
- W/ rear wiper/washer
- W/dual rear doors
- W/o rear wiper/washer
- With auxiliary blower
- With dual rear doors
- With dual rear doors
- With lift gate
- With liftgate
HEADLIGHTS
Headlight Wiring Diagram, with DRL for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Headlight Wiring Diagram, with DRL for Ford Aerostar 1997:
- (center of left fender apron, at starter relay)
- (main harn, behind center of i/p) s265
- (on park brake support) park brake switch
- Battery input
- Brake ind output
- Brake indicator
- Brake warning resistor/diode assembly (behind left side of i/p, taped to main harness near g206)
- C231
- C250
- C251
- Daytime running lamps (drl) module (front of left fender apron, forward of starter relay)
- Dimmer
- Exterior lights system
- Flash-to- pass
- Fuse 12 30a
- Fuse 18 15a
- Fuse 4 15a
- Fuse 5 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G100 (front left fender apron, left of battery)
- G105 (top rear corner of right fender apron, below hood hinge)
- G206 (behind center of i/p, below left side of radio)
- Head
- Hi beam indicator
- High beam ind output
- Hot at all times
- Hot in run
- Hot in start or run
- Ignition input
- Instrument cluster
- Left headlamp
- Low beam input
- Main light switch
- Multi-function switch (top left side of steering column)
- Off
- Park
- Park brake on input
- Pass
- Pulsed hi beam output
- Right headlamp
- S102
- S103
- S134 (eng control sensor harn, front of left fender apron)
- S135 (eng control sensor harn, front of left fender apron)
- S136
- S213
- S216
- S218
- S274
Headlight Wiring Diagram, without DRL for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Headlight Wiring Diagram, without DRL for Ford Aerostar 1997:
- (eng control sensor harn, front of left fender apron) s135
- 22a
- C231
- C250
- Dimmer
- Flash- to- pass
- Fuse 12 30a
- Fuse panel (behind left side of i/p, left of steering column)
- G100 (front left fender apron, left of battery)
- G105 (top rear corner of right fender apron, below hood hinge)
- G206 (behind center of i/p, below left side of radio)
- Head
- Hi beam indicator
- Hot at all times
- Instru- ment cluster
- Left headlamp
- Main light switch
- Multi-function switch (top left side of steering column)
- Off
- Park
- Pass
- Right headlamp
- S102
- S103
- S134 (eng control sensor harn, front of left fender apron)
- S218
- S274
HORN
Horn Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Horn Wiring Diagram for Ford Aerostar 1997:
- (main harness, near breakout to speed control switch assembly) s200
- 30a
- Clockspring assembly (below steering wheel)
- Fuse 12
- Fuse panel (behind left side of i/p)
- High pitch horn (lower right front of engine compt, behind lower radiator support)
- Horn relay (behind lower left side of i/p, right of steering column)
- Horn switch
- Hot at all times
- Low pitch horn (lower right front of engine compt, behind lower radiator support)
- Nca
- S218
- Speed control servo/amplifier assembly (left rear corner of engine compt)
- Speed control switch assembly (in steering wheel)
INSTRUMENT CLUSTER
Instrument Cluster Wiring Diagram (1 of 2) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Ford Aerostar 1997:
- (behind center of i/p, below right side of radio)
- (main harn, below left side of i/p)
- (top left center of safety wall, near wiper motor)
- Above cowl panel)
- Acc
- Air bag diagnostic module (behind left side of i/p, near top of cowl panel)
- Air bag ind.
- Amp ind.
- Anti- slosh module
- Bat
- Brake ind.
- C249
- C250
- C251
- Column)
- Coolant temp. gauge
- Daytime running lamps module (front of left fender apron, forward of starter relay)
- Door ajar ind.
- Electronic 4 wheel drive ind.
- Electronic 4 wheel drive module (under right side of left front seat)
- Enable
- Enable psom programming connector (behind right cowl panel)
- Engine coolant temperature sender (3.0l-top center front of engine) (4.0l-top right front of engine)
- Engine oil pressure switch (3.0l-top of engine near valve cover) (4.0l-lower left front of engine, above engine oil pan)
- Fasten belts ind.
- Fuel gauge
- Fuel pump/fuel gauge sender (below rear of vehicle, top of fuel tank)
- Fuse 10a
- Fuse 15a
- Fuse 5a
- Fuse panel (behind left side side of i/p, left of steering
- G116
- G206
- Generator voltage regulator (top right front of engine)
- Gnd
- High beam ind.
- Hot at all times
- Hot in run
- Hot w/ lamp sw in park or head
- Ign
- Ign (run)
- Ignition switch
- Illumination lamps
- Instrument cluster
- Left turn ind.
- Lock
- Malfunction ind.
- Multi- function switch (top left side of steering column)
- Odometer select
- Off
- Ohms
- Oil press. gauge
- Programming
- Psom module
- Rear abs ind.
- Red/pnk
- Right turn ind.
- Run
- S201 (main harn, near speed control switch assembly)
- S209
- S211
- S220
- S254
- S275 (main harn, near breakout to cluster)
- S276
- S277
- Speed control amplifier (behind right side of i/p,
- Start
- Trip reset
- Volt- meter
- Vss input
- Vss output
- Vss return
- Warning chime module (behind left side of i/p, near top of cowl panel)
Instrument Cluster Wiring Diagram (2 of 2) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Ford Aerostar 1997:
- "b" pillar)
- (front of sliding door)
- (left rear corner of cargo area)
- (main harn, near breakout to cluster)
- (main harn, near breakout to ground g206)
- (rear harn, near breakout to license lmp)
- (rear of right
- (top left side of safety wall,
- Acc
- Brake fluid level switch (on brake master cylinder)
- Brake warning resistor/diode (taped to main harness, near g206)
- Button connectors
- Courtesy lamp relay
- Daytime running lamps module (front of left fender apron, forward of starter relay)
- Differential speed sensor (top of rear axle)
- Dss test connector (left rear of engine compt, on safety wall)
- Fuse
- Fuse 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G100 (left front fender apron, left of battery)
- G206 (behind center of i/p, below left side of radio)
- G406 (top left side of rear door/ lift gate header)
- Gnd
- Hot in acc or run
- Hot in run or start
- Ignition switch
- Interior lights
- Left front door ajar switch
- Left of brake master cylinder)
- Liftgate ajar switch
- Lock
- Off
- Park brake
- Powertrain control module
- Pressure differential warning switch (below brake fluid reservoir)
- Rear anti-lock brake module (behind center of i/p, below ash tray)
- Rear door latch switch
- Red
- Red/pnk
- Right front door ajar switch
- Right rear door ajar switch
- Run
- S105
- S213
- S215
- S231
- S232
- S250
- S262
- S265
- S266
- S274
- S402
- S403
- S405
- Sliding door ajar relay (right of steering column)
- Start
- Switch (on park brake support)
- W/ drl
- W/ dual rear doors
- W/ liftgate
- W/o drl
INTERIOR LIGHTS
Courtesy Lamps Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Courtesy Lamps Wiring Diagram for Ford Aerostar 1997:
- (below center of i/p, below left side of radio) g206
- (main harn, behind center of i/p)
- (main harn, near inst cluster breakout)
- (rear lamp harn, near left side of cargo area)
- (tailgate warn sw harn, near license lp breakout)
- (top left side of rear door/ liftgate header)
- Battery
- Brake warning resistor/diode assembly (behind left side of i/p)
- C250
- C251
- Cargo lamp
- Courtesy lamp relay (front of left "d" pillar, above rear lamps grommet)
- Dome
- Dome and reading lamps
- Dome lamp
- Door ajar indicator
- Door handle in
- Fuse 15a
- Fuse 20a
- Fuse panel (behind left side of i/p, left side of steering column)
- G206 (below center of i/p, below left side of radio)
- G406
- Glove box lamp and switch
- Ground
- Hot at all times
- Hot in acc or run
- Hot in start or run
- Ignition
- Illumin entry out
- Illuminated entry timer (center rear of left "b" pillar)
- Instrument cluster
- Left courtesy lamp switch
- Left door handle switch (on top of latch assembly)
- Left door open input
- Left instru- ment panel courtesy lamp
- Left vanity mirror lamp and switch
- Lift gate
- Lift gate ajar switch (in lower center of lift gate, on latch assembly)
- Main light switch
- Nca
- Off
- Power mirror switch
- Read- ing lamps
- Rear door latch switch (in top of right rear door)
- Red/pnk
- Right courtesy lamp switch
- Right door handle switch (on top of latch assembly)
- Right instru- ment panel courtesy lamp
- Right rear door ajar switch (in lower left corner of door)
- Right vanity mirror lamp and switch
- S213
- S215
- S217
- S224
- S243
- S245
- S252
- S254
- S266
- S300
- S301
- S303
- S305
- S307 (rear lamp harn, near left rear "b" pillar)
- S402
- S403
- S405
- Sliding door courtesy lamp switch
- Stepwell lamp
- W/ illuminated entry
- W/ rear wiper/washer
- W/ w/ dual rear doors
- W/ w/o reading lamps
- W/o rear wiper/washer
- Warning chime module (behind left side of i/p, near top of cowl panel)
Instrument Illumination Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Instrument Illumination Wiring Diagram for Ford Aerostar 1997:
- (main harn, behind center of i/p) s211
- (not used)
- 15a 15a
- 5a 5a
- A/c- a/c- heater heater control control illumination illumination
- Ashtray ashtray lamp lamp
- B2 b2
- C250 c250
- C257 c257
- Dimmer dimmer
- Dn dn
- Fuse 11 fuse 11
- Fuse 13 fuse 13
- Fuse 4 fuse 4
- Fuse fuse panel panel (behind left (behind left side of i/p, side of i/p, left of steering left of steering column) column)
- G206 g206 (behind center of i/p, (behind center of i/p, below right side of radio) below right side of radio)
- G206 g206 (below (below center center of i/p, of i/p, below below left left side of side of radio) radio)
- G206 g206 (below center of i/p, (below center of i/p, below left side of radio) below left side of radio)
- Head head
- Hot at all hot at all times times
- Hot in acc hot in acc or run or run
- I i
- Ign ign
- Illumin- illumin- ation ation lamps lamps 5 bulbs 5 bulbs
- Instrument cluster
- Instrument instrument panel panel cigar cigar lighter lighter lamp lamp
- Liftgate liftgate wiper/ wiper/ washer washer switch switch
- Main light main light switch switch
- Off off
- Park park
- Power power distribution distribution system system
- R r
- Radio radio
- Rear auxiliary rear auxiliary blower motor blower motor switch switch illumination illumination
- Rear cigar rear cigar lighter lighter
- Rear cigar rear cigar lighter lighter illumination illumination
- Rear rear window window defrost defrost control control
- Remote remote headphone headphone module module
- S202
- S216
- S245
- S250
- S251
- S258
- S274
- S302
- S313 (rear lamp harn, near remote headphone module breakout)
- W/ auxiliary w/ auxiliary blower motor blower motor
POWER DISTRIBUTION
Power Distribution Wiring Diagram (1 of 3) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Power Distribution Wiring Diagram (1 of 3) for Ford Aerostar 1997:
- (12 ga-
- (16 ga-
- (18 ga-
- (20 ga-
- (diagram 2 of 3)
- (eng cntrl sens harn, left rear of eng compt) s124
- (eng cntrl sensor harn, right front of eng compartment)
- (gen rectifier system harn, right front of eng compt)
- (main harn, behind center of i/p) s215
- (main harn, behind left kick panel)
- (main harn, behind left kick panel) s222
- (main harn, behind left side of i/p)
- (main harn, near data link connector breakout)
- (main harn, near inst cluster breakout) s272
- (main harn, near wiper control module breakout) s263
- (not used)
- (rabs) module breakout) s212
- (trailor lamp harn, near backup lamps relay breakout)
- 3.0l
- 4.0l
- A/c- heater control assembly
- Acc
- Air bag diagnostic monitor
- Auxiliary blower motor relay
- Backup lamps relay
- Battery
- Brake on/off (boo) switch
- C172
- C233
- C249
- C268
- Circuit breaker 14 20a
- Circuit breaker 2 6a
- Data link connector
- Digital trans- mission range (dtr) sensor
- Door lock/ unlock control relay
- Engine compartment relay box
- Fuel pump relay
- Fuse 10a
- Fuse 15a
- Fuse 20a
- Fuse link a
- Fuse link b
- Fuse link c
- Fuse link d
- Fuse link e
- Fuse link f
- Fuse link k
- Fuse panel
- Generator voltage regulator
- Ignition switch
- Illumi- nated entry timer
- In-line fuse 30a
- Instrument cluster
- Lock
- Master window/ door lock switch
- Multi- function switch
- Of i/p) s251
- Off
- Only
- Pcm inline fuse
- Pcm power relay
- Pnk
- Power door lock module
- Power- train control module (pcm)
- Radio
- Radio amplifier
- Rear anti- lock brake system (rabs) module
- Rear window defrost control
- Red
- Remote headphone module
- Right window/ door lock switch
- Run
- Running lamp relay
- S108
- S111 (engine control sensor harness, center of left fender)
- S133 (eng cntrl sensor harn, near starter relay breakout)
- S138 (eng cntrl sens harn, near starter relay breakout)
- S139
- S214 (main harn, behind left side of i/p)
- S221
- S269
- S280
- S410
- Sliding door ajar relay
- Speed control disable switch
- Speed control server/ amplifier assembly
- Sta
- Start
- Starter motor/ solenoid
- Starter relay
- To fuse panel
- To fuse panel (diagram 3 of 3)
- To fuse panel, and fuse link g, and instrument cluster (diagram 3 of 3)
- To main light switch (diagram 2 of 3)
- Wind- shield wiper motor
- Wiper control module
Power Distribution Wiring Diagram (2 of 3) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Power Distribution Wiring Diagram (2 of 3) for Ford Aerostar 1997:
- (main harn, behind center of i/p)
- (main harn, behind left side of i/p) s216
- (main harn, behind left side of i/p) s219
- (main harn, behind right kick panel) s217
- (not used)
- (vanity mirror lamp feed harn, near right vanity mirror lamp and switch breakout)
- 22a
- C231
- C249
- Cargo lamp
- Courtesy lamp relay
- Daytime running lamps (drl) module
- Dimmer
- Dome
- Dome and reading lamps
- Exterior lights system
- From a fuse link a (diagram 1 of 3)
- From fuse panel (diagram 1 of 3)
- Fuse 15a
- Fuse 20a
- Fuse 30a
- Fuse 5a
- Fuse panel
- G206 (behind center of i/p, below left side of radio)
- Glove box lamp and switch
- Head
- Horn relay
- Ign
- Illumi- nated entry timer
- Instrument cluster
- Instrument panel cigar lighter
- Interior lights system
- Interior lights system (instrument illumination)
- Left courtesy lamp switch
- Left vanity mirror lamp and switch
- Main light switch
- Multi- function switch
- Nca
- Off
- Park
- Power mirror switch
- Radio
- Rear anti-lock brake system (rabs) module
- Rear cigar lighter
- Rear cigar lighter illumination
- Red
- Right courtesy lamp switch
- Right vanity mirror lamp and switch
- S202
- S218 (main harn, near horn relay breakout)
- S252
- S254
- S255 (main harn, near elect flasher breakout)
- S302
- S305
- Sliding door courtesy lamp switch
- Test conn- ector
- W/ auxiliary blower motor
- W/ dual rear door
- W/ illumi- nated entry only
- Warning chime module
Power Distribution Wiring Diagram (3 of 3) for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Power Distribution Wiring Diagram (3 of 3) for Ford Aerostar 1997:
- (main harn, behind left side of i/p) s249
- A/c-heater control assembly
- Air bag diagnostic monitor
- Brake warning resistor/ diode assembly
- C250
- C251
- C268
- Daytime running lamps (drl) module
- Digital transmission range (dtr) sensor
- Electronic 4 wheel drive module
- Engine compartment relay box
- From ignition switch (diagram 1 of 3)
- Fuse 15a
- Fuse 30a
- Fuse panel
- Heater control assembly
- Ignition coil
- Inline circuit breaker 4.5a
- Instrument cluster
- Lift gate wiper motor
- Lift gate wiper/ washer switch
- Multi- function switch
- Nca
- Pcm power relay
- Pcm power relay diode
- Radio noise capacitor
- Rear window defrost control
- Red
- S109 (fuel charge harn, near ignition coil breakout)
- S136 (engine control sensor harn, front of left fender apron)
- S213 (main harn, behind left side of i/p)
- S220 (main harn, near instrument cluster breakout)
- Shift lock actuator
- Transmission control switch (tcs)
- W/ air conditioning
- W/ liftgate wiper/ washer only
- W/o air conditioning
- Warning chime module
POWER DOOR LOCKS
Power Door Lock Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Power Door Lock Wiring Diagram for Ford Aerostar 1997:
- (center of left fender
- (door lock harn, in breakout to sliding door court lamp switch) s321
- (in bottom of
- 30a
- Apron, at starter relay)
- Bat
- Behind left "b" pillar)
- Button
- Connectors
- Door lock/unlock control relay
- Fuse link c
- G206 (behind center of i/p, below left side of radio)
- Ground
- Hot at all times
- In-line fuse (behind left side of i/p, taped to main harness near fuse panel)
- Left front door lock motor
- Liftgate door lock motor (w/ liftgate)
- Lk sldg dr ctrl
- Lock
- Lock ctrl
- Master window/door lock switch
- Power door lock module (left front of cargo area,
- Right "b" pillar)
- Right front door lock motor
- Right rear door lock motor (w/ dual rear doors)
- Right window/door lock switch
- S221
- S245
- S280
- S300
- S302
- S319 (rear lamp harn, near breakout to auxiliary blower motor) (w/ auxiliary blower motor) or breakout to left rear seat speaker) (w/o auxiliary blower motor)
- S320 (rear lamp harn, near breakout to auxiliary blower motor) (w/ auxiliary blower motor) or breakout to left rear seat speaker) (w/o auxiliary blower motor)
- Sliding door lock motor
- Un- lock
- Unlock
- Unlock ctrl
POWER MIRRORS
Power Mirror Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Power Mirror Wiring Diagram for Ford Aerostar 1997:
- Direct- tional switch
- Fuse 15a
- Fuse panel (behind left side of i/p, left side of steering column)
- G206 (behind center of i/p, below left side of radio)
- Hot at all times
- L/r motor
- Left power mirror nca
- Left/ right switch
- Nca
- Power mirror switch
- Red
- Right power mirror nca
- S254
- S274
- Up/dn motor
POWER WINDOWS
Power Window Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Power Window Wiring Diagram for Ford Aerostar 1997:
- Circuit breaker 14 20a
- Fuse panel (behind left side of i/p, left side of steering column)
- G500 (left front door, at door ajar switch)
- Hot in acc or run
- Left power window motor
- Master window/ door lock switch
- Nca
- Right power window motor
- Right window/ door lock switch
- S272
- S303
- Up down
RADIO
Mid-Line Radio Wiring Diagram, with Remote Headphones for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Mid-Line Radio Wiring Diagram, with Remote Headphones for Ford Aerostar 1997:
- C255
- C257
- C258
- Fuse 11 15a
- Fuse 8 15a
- Fuse panel (behind left side of dash)
- G206 (behind center of dash, near radio)
- Ground
- Headphone (+)
- Headphone (-)
- Hot at all times
- Hot in acc or run
- Illumination
- Interior lights system
- Left front speaker
- Left rear seat speaker
- Lf spkr (+)
- Lf spkr common
- Lr spkr (+)
- Lr spkr common
- Power
- Radio
- Remote (+)
- Remote (-)
- Remote headphone module (behind left side of cargo area, behind trim panel)
- Rf spkr (+)
- Rf spkr common
- Right front speaker
- Right rear seat speaker
- Rr spkr (+)
- Rr spkr common
- S251
- S254
- S257
Mid-Line Radio Wiring Diagram, without Remote Headphones for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Mid-Line Radio Wiring Diagram, without Remote Headphones for Ford Aerostar 1997:
- (not used)
- C255
- C257
- C258
- Fuse 11 15a
- Fuse 8 15a
- Fuse panel (behind left side of dash)
- G206 (behind center of dash, near radio)
- Ground
- Hot at all times
- Hot in acc or run
- Illumination
- Interior lights system
- Lcd display
- Left front speaker
- Left rear seat speaker
- Lf common
- Lf spkr (+)
- Lr common
- Lr spkr (+)
- Power
- Radio
- Remote (+)
- Remote (-)
- Rf common
- Rf spkr (+)
- Right front speaker
- Right rear seat speaker
- Rr common
- Rr spkr (+)
- S254
Premium Sound Radio Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Premium Sound Radio Wiring Diagram for Ford Aerostar 1997:
- (center of dash)
- Audio amplifier (behind center of dash)
- C253
- C254
- C255
- C256
- C257
- Fuse 11 15a
- Fuse 8 15a
- Fuse panel (behind left side of dash)
- G206
- G206 (behind center of dash, near radio)
- G206 (center of dash)
- Ground
- Hot at all times
- Hot in acc or run
- Illumination
- Interior lights system
- Left front (+)
- Left front (-)
- Left front speaker
- Left rear (+)
- Left rear (-)
- Left rear seat speaker
- Lf door sig (+)
- Lf door sig (-)
- Lf spkr (+)
- Lf spkr (-)
- Lr amp (-)
- Lr signal (+)
- Lr signal (-)
- Lr spkr (+)
- Lr spkr (-)
- Memory
- Mute
- Nca
- Near center of dash)
- Not used
- Power
- Radio
- Remote (+)
- Remote (-)
- Remote headphone module
- Rf door sig (+)
- Rf door sig (-)
- Rf spkr (+)
- Rf spkr (-)
- Right front speaker
- Right rear seat speaker
- Rr amp (-)
- Rr signal (+)
- Rr signal (-)
- Rr spkr (+)
- Rr spkr (-)
- Rt front (+)
- Rt front (-)
- Rt rear (+)
- Rt rear (-)
- S203 (audio harn, nca
- S251
- S254
- S257
- Seek up
- Tan
SHIFT INTERLOCKS
Shift Interlock Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Shift Interlock Wiring Diagram for Ford Aerostar 1997:
- (behind center of i/p,
- Below left side of radio)
- Brake on/off switch (behind left side of i/p, on brake pedal support)
- Exterior lights system
- Fuse 1 15a
- Fuse 5 15a
- Fuse panel
- G206
- Hot at all times
- Hot in run
- S214
- S228 (main harn, near breakout to shift lock actuator)
- S243
- S249
- Shift lock actuator (on lower part of steering column)
- Solid state
STARTING/CHARGING
Charging Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Charging Wiring Diagram for Ford Aerostar 1997:
- "amp" indicator
- (3.0l only)
- (4.0l only)
- (4.0l) g110 (lower left front of engine)
- (eng ctrl sensor harn, right front of eng compt) s139
- 500 ohms
- Acc
- Battery
- C125
- C153
- C154
- G114 (3.0l) (lower left rear of engine, near starter motor/ solenoid)
- G116 (top left center of saftey wall, near windshield wiper motor)
- Generator/ voltage regulator
- Ground distribution
- Ignition switch
- Instrument cluster
- Lock
- Off
- Power distribution
- Red
- Run
- S108 (gen rectifier system harn, right front of engine compt)
- S111
- S133
- S138
- S220
- S269
- Start
- Starter motor/ solenoid
- Starter relay
Starting Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Starting Wiring Diagram for Ford Aerostar 1997:
- 3.0l
- 4.0l
- Acc
- Battery
- Digital transmission range (dtr) sensor (left side of automatic transmission)
- G110 (4.0l) (lower left front of engine)
- G114 (3.0l) (lower left rear of engine, near starter motor/ solenoid)
- G116 (top left center of saftey wall, near windshield wiper motor)
- Ground distribution
- Ignition switch
- Lock
- Nca
- Off
- Pnk
- Red
- Run
- S138
- S268
- Sta
- Start
- Starter motor/ solenoid
- Starter relay (center of left fender apron)
SUPPLEMENTAL RESTRAINTS
Supplemental Restraint Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Supplemental Restraint Wiring Diagram for Ford Aerostar 1997:
- (main harn, behind left side of i/p)
- (main harn, near air bag diagnostic monitor breakout)
- Air bag diagnostic monitor (behind left side of i/p, near top of cowl panel)
- Air bag ind
- Air bag indicator
- Air bag safing sensor (behind left cowl panel)
- Brake warning resistor/diode assembly (left side of (i/p, taped to main harness)
- C crash sens
- C232
- C233
- C250
- C251
- Center radiator primary crash sensor (on upper radiator support)
- Clock spring assembly (below steering wheel)
- Driver's air bag (center of steering wheel)
- Drvr air bag
- Fuse 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G206 (behind center of i/p, below left side of radio)
- Gnd
- Hot at all times
- Hot in acc or run
- Hot in run
- Instrument cluster
- Nca
- Pass bag off
- Pwr (bat)
- Pwr (run)
- R crash sens
- Right kick panel crash sensor (behind right cowl panel)
- S213 (main harn, behind left side of i/p)
- S249
- S261
- S278
- S279
- Safing sens
TRANSMISSION
3.0L
3.0L, Transfer Case Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 3.0L, Transfer Case Wiring Diagram for Ford Aerostar 1997:
- (-)
- (behind center of dash, below left side of radio) g206
- Battery
- Brake input
- Brake on/off switch (on brake pedal support)
- C250
- Digital transmission range sensor (left side of transmission)
- Electronic 4 wheel drive indicator
- Electronic 4 wheel drive module (under right side of left front seat)
- Front axle speed sensor (mounted on top left side of transfer case)
- Fuse 15a
- Fuse panel
- G114 (left rear of engine compartment)
- Gnd
- Hot at all times
- Hot in start or run
- Ign
- Ind ctrl
- Instrument cluster
- Mult-function switch
- Nca
- Neutral safety in
- Power
- Rear axle speed sensor (mounted on top right side of transfer case)
- S122
- S214
- S228 (main harness, near break out to shift lock actuator)
- S308
- Signal
- Signal low
- Solid state
- Speed control disable switch
- Transfer case clutch solenoid (top right side of transfer case)
- Vref
3.0L, Transmission Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 3.0L, Transmission Wiring Diagram for Ford Aerostar 1997:
- (5r55e)
- (engine control sensor extension harness, near breakout to 8-pin conn above front of transmission)
- (engine control sensor harness)
- (engine control sensor harness, near breakout to powertrain control module) s116
- (fuel charge harness, near break out to evap canister purge valve) s128
- (fuel charge harness, near breakout to fuel injector 6)
- (left rear of engine compartment on firewall) g114
- (main harness, near breakout to instrument cluster) s231
- (near windshield wiper motor)
- (top left center of firewall, near windshield wiper motor) g116
- 10a
- Air conditioning system
- Automatic transmission
- Brake on/off switch (on brake pedal support)
- Brake warning resistor/ diode assembly (left side of dash)
- C172
- C250
- C251
- Coast clutch solenoid (4r44e)
- Data link connector (center of (dash)
- Differential speed sensor (top of rear axle)
- Digital transmission range sensor (left side of transmission)
- Dss input
- Dss return
- Electronic pressure control solenoid
- Engine compartment relay box
- Engine controls system
- Engine coolant temperature sensor (top left front of engine)
- Fuel pump relay
- Fuse 15a
- G116
- Harness, near break- out to shift lock actuator)
- Hot at all times
- Hot in start or run
- I/p fuse panel
- Instrument cluster
- Liftgate wiper/ washer circuit breaker
- Malfunction indicator lamp (check engine)
- Multi- function switch
- Nca
- O/d off
- Output shaft speed sensor (5r55e only)
- Overdrive drum speed sensor (5r55e only)
- Pcm inline fuse (left rear of engine compartment)
- Pcm power relay
- Pcm power relay diode
- Powertrain control module (left of brake master cylinder)
- Psom module
- R p
- Red
- Red/ pnk
- S107
- S113
- S119 (fuel charge harness, near break- out to fuel injector 3)
- S122
- S123
- S124
- S125
- S126
- S127
- S201 (main harness, near breakout to speed control sw assembly)
- S213
- S232 (main harness, near breakout to inst cluster)
- Shift solenoid
- Shift solenoid (5r55e)
- Speed control disable switch
- Speed output
- Throttle postion sensor
- Torque converter clutch solenoid
- Transmission control indicator lamp
- Transmission control switch
- Transmission fluid temperature sensor
- Turbine shaft speed sensor
4.0L
4.0L, Transfer Case Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Transfer Case Wiring Diagram for Ford Aerostar 1997:
- (-)
- (behind center of dash, below left side of radio) g206
- Battery
- Brake input
- Brake on/off switch (on brake pedal support)
- C250
- Digital transmission range sensor (left side of transmission)
- Electronic 4 wheel drive indicator
- Electronic 4 wheel drive module (under right side of left front seat)
- Front axle speed sensor (mounted on top left side of transfer case)
- Fuse 15a
- Fuse panel
- G114 (left rear of engine compartment)
- Gnd
- Hot at all times
- Hot in start or run
- Ign
- Ind ctrl
- Instrument cluster
- Mult-function switch
- Nca
- Neutral safety in
- Power
- Rear axle speed sensor (mounted on top right side of transfer case)
- S122
- S214
- S228 (main harness, near break out to shift lock actuator)
- S308
- Signal
- Signal low
- Solid state
- Speed control disable switch
- Transfer case clutch solenoid (top right side of transfer case)
- Vref
4.0L, Transmission Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Transmission Wiring Diagram for Ford Aerostar 1997:
- (5r55e)
- (engine control sensor extension harness, near breakout to 8-pin conn above front of transmission)
- (engine control sensor harness)
- (engine control sensor harness, near breakout to powertrain control module) s116
- (fuel charge harness, near break out to evap canister purge valve) s128
- (fuel charge harness, near breakout to fuel injector 6)
- (left rear of engine compartment on firewall) g114
- (main harness, near breakout to instrument cluster) s231
- (near windshield wiper motor)
- (top left center of firewall, near windshield wiper motor) g116
- 10a
- Air conditioning system
- Automatic transmission
- Brake on/off switch (on brake pedal support)
- Brake warning resistor/ diode assembly (left side of dash)
- C172
- C250
- C251
- Coast clutch solenoid (4r44e)
- Data link connector (center of (dash)
- Differential speed sensor (top of rear axle)
- Digital transmission range sensor (left side of transmission)
- Dss input
- Dss return
- Electronic pressure control solenoid
- Engine compartment relay box
- Engine controls system
- Engine coolant temperature sensor (top left front of engine)
- Fuel pump relay
- Fuse 15a
- G116
- Harness, near break- out to shift lock actuator)
- Hot at all times
- Hot in start or run
- I/p fuse panel
- Instrument cluster
- Liftgate wiper/ washer circuit breaker
- Malfunction indicator lamp (check engine)
- Multi- function switch
- Nca
- O/d off
- Output shaft speed sensor (5r55e only)
- Overdrive drum speed sensor (5r55e only)
- Pcm inline fuse (left rear of engine compartment)
- Pcm power relay
- Pcm power relay diode
- Powertrain control module (left of brake master cylinder)
- Psom module
- R p
- Red
- Red/ pnk
- S107
- S113
- S119 (fuel charge harness, near break- out to fuel injector 3)
- S122
- S123
- S124
- S125
- S126
- S127
- S201 (main harness, near breakout to speed control sw assembly)
- S213
- S232 (main harness, near breakout to inst cluster)
- Shift solenoid
- Shift solenoid (5r55e)
- Speed control disable switch
- Speed output
- Throttle postion sensor
- Torque converter clutch solenoid
- Transmission control indicator lamp
- Transmission control switch
- Transmission fluid temperature sensor
- Turbine shaft speed sensor
WARNING SYSTEMS
Warning System Wiring Diagrams for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Warning System Wiring Diagrams for Ford Aerostar 1997:
- (main harn, behind left side of i/p) s219
- C250
- Fasten belts indicator
- Fasten belts input
- Fuse 15a
- Fuse panel (behind left side of i/p, left of steering column)
- G206 (behind center of i/p, below left side of radio)
- Ground
- Head
- Hot at all times
- Hot in start or run
- Ignition
- Indicator output
- Instrument cluster
- Interior lights system
- Key in ignition input
- Key warning switch (part of ignition assembly)
- Left courtesy lamp switch
- Left door open input
- Lights on input
- Main light switch
- Nca
- Off
- Park
- Red/pnk
- S204
- S213
- S216
- S245
- S261
- S274
- S305
- Seat belt buckle switch (driver's seat belt buckle assembly)
- Warning chime module (behind left side of i/p, near top of cowl panel)
WIPER/WASHER
Front Wiper/Washer Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Front Wiper/Washer Wiring Diagram for Ford Aerostar 1997:
- (main harn, near breakout to wiper ctrl module)
- 100k ohms
- 3.3k ohms
- 7.25k
- C231
- Circuit breaker 2 6a
- Com
- Fuse panel
- G105 (right side of engine compt, on upper fender apron)
- Gnd
- Hot in acc or run
- Int max
- Int min
- M-f sw gnd
- Multi- function switch (top left side of steering column)
- Off
- Off 36.27k ohms
- Ohms
- Park
- Park switch
- Pwr (ign)
- Run
- S105
- S263
- S264
- Signal input
- Washer pwr
- Washer switch
- Wind- shield washer pump motor
- Windshield wiper motor
- Wiper control module (right of steering column)
- Wiper mtr hi
- Wiper mtr lo
- Wiper switch
Rear Wiper/Washer Wiring Diagram for Ford Aerostar 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for Rear Wiper/Washer Wiring Diagram for Ford Aerostar 1997:
- (top left side of rear door/ liftgate header) g406
- 4.5a
- Fuse 15a
- Fuse panel
- G206 (below left side of radio)
- Ground distribution system
- Hot in start or run
- Illumination lamp
- In-line circuit breaker (near left side of fuse panel)
- Interior lights system
- Liftgate washer pump motor
- Liftgate wiper motor
- Liftgate wiper/washer switch
- Nca
- Park
- Power distribution system
- Red
- Run
- S274
- S301
- S403
- Washer switch
- Wiper switch