ENGINE PERFORMANCE
2.0L TWIN TURBO
2.0L Twin Turbo, Engine Performance Wiring Diagram (1 of 5) for BMW 528i 2012
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for 2.0L Twin Turbo, Engine Performance Wiring Diagram (1 of 5) for BMW 528i 2012:
- (front left side of engine) knock sensor cylinder 1 & 2
- (rear left side of engine) knock sensor cylinder 3 & 4
- (right side of engine) intake-manifold pressure sensor
- Activation elec throttle vlv act
- Activation oil press ctrl valv
- Activation throttle vlv act
- Activation vol ctrl vlv
- Crankshaft sens gnd
- Crankshaft sens sig
- Crankshaft sens sply
- Crankshaft sensor (lower left rear of crankcase)
- Digital motor electronics (dme) control module (top rear of engine)
- Elec throttle vlv act gnd
- Elec throttle vlv act sig
- Int air temp pres gnd
- Int air temp pres sens
- Int pipe pres sens gnd
- Int pipe pres sens sply
- Knock sens sig
- Lin bus sig
- Nca
- Oil lvl sens gnd
- Oil lvl sens sig
- Oil lvl sens sply
- Oil press ctrl vlv sply
- Oxy sens aft cat conv sply
- Oxygen sens aft cat conv gnd
- Oxygen sens bef cat conv gnd
- Oxygen sens bef cat conv sply
- Oxygen sens sig
- Oxygen sensor after catalytic converter
- Press sens gnd
- Press sens sig
- Press sens sply
- Quantity control valve
- Rail press sens gnd
- Rail press sens sply
- Rail pressure sensor (on right cylinder head fuel rail)
- Red
- Starting/charging system
- Suction jet pump pressure sensor
- Temp sens sig
- Vol ctrl vlv sply
- Wastegate valve pressure converter
- Wastegate vlv activation press conv
- Wastegate vlv press conv sply
2.0L Twin Turbo, Engine Performance Wiring Diagram (2 of 5) for BMW 528i 2012
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO 모든 배선 다이어그램에 액세스하십시오.List of elements for 2.0L Twin Turbo, Engine Performance Wiring Diagram (2 of 5) for BMW 528i 2012:
- (bottom of oil pan) oil level sensor
- (right side of engine) intake air temperature pressure sensor
- Blow-off valve
- Electric coolant pump (left side of engine)
- Electromotive throttle actuator
- Engine ventilation heating
- Exhaust vanos solenoid actuator
- Fuse 50a
- Hot at all times
- Intake camshaft sensor (left front of cylinder head)
- Intake vanos solenoid actuator
- Nca
- Oil pressure control valve
- Oxygen sensor before catalytic converter
- Power distribution box (in engine compt)
- Red
- Tank vent valve
- X664 2b
- Z6000 3b
2.0L Twin Turbo, Engine Performance Wiring Diagram (3 of 5) for BMW 528i 2012
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO 모든 배선 다이어그램에 액세스하십시오.List of elements for 2.0L Twin Turbo, Engine Performance Wiring Diagram (3 of 5) for BMW 528i 2012:
- (top rear of engine) digital motor electronics (dme) control module
- Activation
- Activation blow-off vlv
- Activation characteristic map hermostat
- Activation charcoal filter vlv
- Activation elect coolant pump
- Activation vlvelct rly
- Blow-off valve sply
- Characteristic map
- Charcoal filter vlv sply
- Digital motor electronics (dme) control module (top rear of engine)
- Dme main relay
- Engine coolant temp sens gnd
- Engine oil press/temp sens gnd
- Engine oil press/temp sens sig
- Engine oil press/temp sens sply
- Engine vent heating gnd
- Engine vent heating sply
- Exhaust activation vanos solenoid vlv
- Exhaust camshaft sens gnd
- Exhaust camshaft sens sig
- Exhaust camshaft sens sply
- Exhaust vanos sol valv sply
- Fuel injectors sply
- Fuse 100a
- Fuse 15a
- Fuse 20a
- Fuse 40a
- Fuse box (under spare tire)
- Gnd
- Hot at all times
- Hot-film air mass meter gnd
- Hot-film air mass meter sig
- Hot-film air mass meter sply
- Ignition & fuel injection relay
- Inlet activation vanos sol vlv
- Intake camshaft sens gnd
- Intake camshaft sens sig
- Intake camshaft sens sply
- Intake vanos sol vlv sply
- Lin bus sig
- Motor position sensor
- Mtr activation
- Mtr position snse gnd
- Mtr position snse sig
- Mtr position snse sply
- Power distribution box
- Red
- Sply ign
- Sply valvetronic
- Temp sens sig
- Terminal 15 sply
- Thermostat supy
- Valvetronic actuator motor
- Valvetronic relay
- X168 1b
- Z10 3b (lower right front of engine compt)
- Z6000 4b
2.0L Twin Turbo, Engine Performance Wiring Diagram (4 of 5) for BMW 528i 2012
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO 모든 배선 다이어그램에 액세스하십시오.List of elements for 2.0L Twin Turbo, Engine Performance Wiring Diagram (4 of 5) for BMW 528i 2012:
- (above 1 cylinders) ignition coil cylinder 1
- (above 2 cylinders) ignition coil cylinder 2
- (above 3 cylinders) ignition coil cylinder 3
- (above 4 cylinders) ignition coil cylinder 4
- (forward of rear power distribution box) dc/dc converter
- Car access system
- Characteristic map thermostat
- Electrical wastegate valve
- Engine coolant temperature sensor (top front of engine)
- Engine oil pressure/ temperature sensor (left side of engine)
- Exhaust camshaft sensor (rear of engine)
- Exhaust flap electric changeover valve (left side of rear compt)
- Fuse 10a
- Fuse 5a
- Hot film air mass meter (right front of engine compt)
- Hot w/ terminal 15n relay energized
- Hot w/ terminal 30b relay energized
- Junction box (right side of dash)
- Nca
- Plug spark
- Rear fuse holder (right side of rear compt)
- Red
- Rotor position sensor
- Spark plug
- Z6000 1b
- Z6000 2b
2.0L Twin Turbo, Engine Performance Wiring Diagram (5 of 5) for BMW 528i 2012
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO 모든 배선 다이어그램에 액세스하십시오.List of elements for 2.0L Twin Turbo, Engine Performance Wiring Diagram (5 of 5) for BMW 528i 2012:
- (top of engine) fuel injectors
- 11b
- Accelerator pedal module (part of acceleration pedal assembly)
- Anti-theft system
- Cas sub-bus
- Computer data lines system
- Cooling fans system
- Digital motor electronics (dme) control module (top rear of engine)
- Early production
- Electric fan activation
- Engine start sig
- Engine start sig electric fan activation cut-out rly
- Flexray bus sig
- Fuel inj 1 activation
- Fuel inj 1 sply
- Fuel inj 2 activation
- Fuel inj 2 sply
- Fuel inj 3 activation
- Fuel inj 3 sply
- Fuel inj 4 activation
- Fuel inj 4 sply
- Fuse 5a
- Hall sens gnd
- Hall sens sig
- Hall sens sply
- Hall sensor sig
- Hot at all times
- Hot w/ bi-stable relay energized
- Ign coil 1 activation
- Ign coil 1 sply
- Ign coil 2 activation
- Ign coil 2 sply
- Ign coil 3 activation
- Ign coil 3 sply
- Ign coil 4 activation
- Ign coil 4 sply
- Late production
- Lin bus sig
- Natural vacuum leak detection
- Natural vacuum leak detection electric changeover vlv
- Pnk
- Pressure switch
- Pt-can bus sig
- Rear fuse holder (right side of rear compt)
- Red
- Speed sig
- Term 30b pwr sply
- Terminal 15 sply
- Terminal 15 wake-up sig
- Z10 13b (right "c" pillar)