GROUND DISTRIBUTION – Chevrolet RV Cutaway G3500 2006 – SYSTEM WIRING DIAGRAMS

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Chevrolet RV Cutaway G3500 2006

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Chevrolet RV Cutaway G3500 2006:

• (4.3l)
• (4.3l) ignition control module (icm)
• (4.8l/5.3l/6.0l)
• (forward lamp harness, approx 12 cm from left headlamp connector breakout)
• (in engine harness, approx 4 cm from knock sensor breakout)
• (not used) d2
• 4.8l, 5.3l, 6.0l
• A/c compressor clutch
• A/c low pressure switch
• Battery
• Blower motor resistor assembly
• Brake fluid level switch
• C101
• Camshaft position (cmp) sensor shield
• Coolant level switch
• Crankshaft position (ckp) sensor shield
• Diesel
• Electronic brake control module (ebcm)
• Engine control module (ecm)
• Engine oil level switch
• Fuel pressure regulator shield
• Fuel pump relay
• Fuel rail pressure (frp) sensor shield
• G100 (left front of engine compt)
• G101 (right front of engine compt)
• G102 (gasoline: on left rear of engine) (diesel: left front lower side of eng block)
• G103 (diesel) (left front lower side of eng block)
• G103 (gasoline) (on right rear of engine)
• G104 (on lower right front of engine)
• G105 (on right front frame rail, in engine compt)
• G106 (on right front of engine compt)
• G107 (diesel) (left front lower side of eng block)
• G108 (diesel) (right front lower side of eng block)
• G300 (on left frame rail, near ebcm) (w/ active brake control)
• G300 (on left frame rail, near ebcm) (w/o active brake control)
• G301 (behind left kick panel)
• G305 (diesel) (left center outer frame rail)
• Gas
• Glow plug control module (gpcm)
• Horn assembly
• Ignition coil 1
• Ignition coil 2
• Ignition coil 3
• Ignition coil 4
• Ignition coil 5
• Ignition coil 6
• Ignition coil 7
• Ignition coil 8
• Inflatable restraint i/p module disable switch
• Inflatable restraint sensing & diagnostic module (sdm)
• Intake air temperature (iat)/ mass air flow (maf) sensor
• Left front marker lamp
• Left front park/turn signal lamp
• Left headlamp (w/ sealed beam headlamps)
• Left high beam headlamp (w/ composite headlamps)
• Left low beam headlamp (w/ composite headlamps)
• Nca
• On top right side of engine)
• Park/ neutral position (pnp) switch
• Powertrain control module (pcm)
• Red
• Right front marker lamp
• Right front park/turn signal lamp
• Right headlamp (w/ sealed beam headlamps)
• Right high beam headlamp (w/ composite headlamps)
• Right low beam headlamp (w/ composite headlamps)
• S101 s101 (in engine harness, approx 43 cm from underhood lamp breakout)
• S107
• S108
• S118 (forward lamp harness, approx 13 cm from right headlamp connector breakout)
• Secondary battery
• Throttle actuator control (tac) module
• Transmission control module (tcm)
• Underhood fuse block
• Underhood lamp
• Vacuum pump
• W/ active brake control

Ground Distribution Wiring Diagram (2 of 4) for Chevrolet RV Cutaway G3500 2006

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Chevrolet RV Cutaway G3500 2006:

• (if equipped) power brake booster fluid flow alarm switch
• (if equipped) rear seat audio control
• (if equipped) remote control door lock receiver
• (in dash harness, approx 5 cm from inflatable restraint i/p module connector breakout)
• (in dash harness, approx 8 cm from c200 breakout)
• (rv/upfitter) provisional
• A/t shift lock control solenoid
• A12
• Air temperature actuator
• Auxiliary power outlet 1
• Auxiliary power outlet 2
• Auxiliary relay 24
• Body control module (bcm)
• Body fuse block
• C200 breakout)
• C222
• Cargo unlk relay 27
• Chime module
• Cigar lighter
• Cruise control module
• Ctsy lp relay 26
• Data link connector (dlc)
• Door lks relay 30
• Drv unlk relay 28
• Exc radio delete
• G302 (behind left kick panel)
• G303 (behind left kick panel)
• G304 (behind right kick panel)
• Gasoline w/o active brake control
• Hazard switch
• Headlamp & panel dimmer switch
• Headlamp dimmer switch
• High idle switch
• Hvac control assembly
• Ignition key alarm switch
• Inflatable restraint passenger air bag on/off indicator
• Inflatable restraint passenger presence system module
• Inside rearview mirror
• Instrument panel cluster
• Light duty w/o r/v upfitter
• Pass unlk relay 31
• Radio
• Radio delete
• Rr defog relay 25
• S264 (in steering column harness, approx 29 cm from c200)
• Steering wheel speed/ position sensor
• Tan
• Tow/haul switch
• Traction control switch
• Turn signal/ hazard flasher module
• Turn signal/ multifunction switch
• W/ active brake control
• W/ cigar lighter
• W/ electronic display
• W/ heated outside mirrors & rear defogger
• W/o cigar lighter
• Windshield washer fluid pump
• Windshield wiper motor
• Windshield wiper/washer switch
• Wnd rap relay 23

Ground Distribution Wiring Diagram (3 of 4) for Chevrolet RV Cutaway G3500 2006

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Chevrolet RV Cutaway G3500 2006:

• (auxiliary hvac)
• (cutaway upfitter)
• (if equipped) auxiliary blower motor switch
• (if equipped) driver window switch
• (if equipped) left rear side door jamb switch
• (if equipped) left vanity mirror lamp
• (if equipped) passenger door lock switch
• (if equipped) passenger seat adjuster switch
• (if equipped) rear auxiliary hvac control assembly
• (if equipped) right vanity mirror lamp
• (rv/ upfitter)
• (rv/upfitter) provisional p
• Auxiliary hvac control processor
• C320
• C321
• C409
• Cargo/ cutaway
• Courtesy/ reading lamp (mid)
• Courtesy/ reading lamp (rear)
• Driver door latch assembly
• Driver door lock switch
• Driver outside rearview mirror
• Driver seat adjuster switch
• Except rv/upfitter
• From splice pack sp347 a (diagram 3 of 4)
• From splice pack sp347 b (diagram 3 of 4)
• Front auxiliary hvac control assembly
• Front courtesy/ reading lamp
• G347 (on bottom of left "b" pillar)
• If equipped
• Left front seat belt switch
• Left vanity mirror lamp
• Nca
• Outside rearview mirror switch
• Passenger
• Passenger door latch assembly
• Passenger outside rearview mirror
• Passenger window switch
• Provisional b
• Provisional c
• Right front seat belt switch
• Right rear side door jamb switch
• Right vanity mirror lamp
• Rv/upfitter
• S204 (in vanity mirror lamp harness, approx 13 cm from c203)
• S304 (in driver seat harness, approx 11 cm from driver seat adjuster switch connector breakout)
• S317 (in passenger seat harness, approx 10 cm from c306)
• S500 (in left front door harness, approx 6 cm from left front door door speaker breakout)
• S600 (in right front door harness, approx 7 cm from right front door speaker breakout)
• Splice pack sp347
• To splice pack sp347 (diagram 3 of 4)
• W/ driver power seat adjuster
• W/ electronic side door lock control
• W/ outside heated mirrors
• W/ rear auxiliary controls
• W/o driver power seat adjuster
• W/o electronic side door lock control
• W/o rear auxiliary controls

Ground Distribution Wiring Diagram (4 of 4) for Chevrolet RV Cutaway G3500 2006

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Chevrolet RV Cutaway G3500 2006:

• (if equipped) cruise control module
• (if equipped) left trailer stop/turn relay
• (if equipped) rear cargo door lock switch
• (if equipped) right trailer stop/turn relay
• (in body harness, approx 16 cm from chmsl connector breakout)
• Auxiliary air temperature actuator
• Auxiliary blower motor
• Auxiliary heater
• Auxiliary mode actuator
• B11
• Brake pressure differential switch
• C405
• Cargo door latch assembly
• Center high mounted stop lamp (chmsl)
• Coolant heater
• Cutaway
• Diesel
• Dome fluorescent work lamp 1
• Dome fluorescent work lamp 2
• Except rv/ upfitter
• Fluorescent work lamp connector)
• Fuel heater
• Fuel pump
• Fuel pump & sender assembly
• Fuel pump coolant heater
• G400 (on inner left rear frame rail)
• G401 (on top of right "d" pillar)
• G402 (on top of left "d" pillar)
• G403 (on center of left "d" pillar)
• Gas passenger/ cargo heavy duty (w/o hd truck trailer wiring)
• If equipped
• Left backup lamp
• Left front dome fluorescent work lamp
• Left front side front access panel actuator
• Left front side rear access panel actuator
• Left rear dome fluorescent work lamp
• Left rear fog lamp
• Left rear side front access panel actuator
• Left rear side rear access panel actuator
• Left rear window defogger grid
• Left tail/stop & turn signal lamp
• License lamp
• Light duty
• Nca
• Others
• Park/ neutral position switch
• Passenger/ cargo van
• Rear dome lamp
• Rear hvac system
• Resistor
• Right backup lamp
• Right dome fluorescent work lamp
• Right rear fog lamp
• Right rear window defogger grid
• Right side front access panel actuator
• Right side rear access panel actuator
• Right tail/stop & turn signal lamp
• S231 (in dash harness, 23 cm from c200)
• S300 (in prp/uf2 harness, approx 42 cm from left front side front access panel actuator)
• S316 (front of fuel pump)
• S403 (in body harness, approx 6 cm from g401 breakout)
• S411 (in rear hvac harness, approx 6 cm from auxiliary blower motor connector breakout)
• S902 (in right rear door harness, approx 19 cm from license lamp connector breakout)
• S904 (rear fog lamp harness, approx 12 cm from c406 breakout)
• Stop lamp switch
• Trailer wiring harness
• Turn/ hazard flasher module
• Underhood fuse block
• W/ stationary back window
• W/ swing out back window