Wiring Diagram VW NEW BEETLE CABRIOLET 2010 - Fuses - TCS/ESP button
A | Battery |
D | Ignition/starter switch |
E20 | Switches and instruments light regulator |
E256 | TCS/ESP button |
J104 | ABS with EDL/ TCS/ ESP control unit, left in engine compartment |
L71 | Traction control switch illumination |
S9 | Fuse in fuse box |
S178 | Fuse -6- (30), in fuse box/battery |
S179 | Fuse -7- (30), in fuse box/battery |
T3 | 3-pin connector, on fuse box/battery |
T6c | 6-pin connector, on lighting control/adjuster headlight range |
T6j | 6-pin connector, on TCS/ESP button |
T47 | 47-pin connector, on ABS with EDL/TCS/ESP control unit |
10 | Earth point, in plenum chamber |
A2 | Positive (+) connection (15), in dash panel wiring harness |
A4 | Positive (+) connection (58b), in dash panel wiring harness |
B149 | Positive (+) connection -2- (15a), in interior wiring harness |
* | Only models with ESP |
Wiring Diagram VW NEW BEETLE CABRIOLET 2010 - Steering angle sender - ABS valves
F | Brake light switch |
G85 | Steering angle sender, on steering column |
J104 | ABS with EDL control unit |
J217 | Automatic gearbox control unit |
J256 | Convertible top operation control unit |
M... | Brake light bulb |
N133 | ABS inlet valve, rear right |
N134 | ABS inlet valve, rear left |
N135 | ABS outlet valve, rear right |
N136 | ABS outlet valve, rear left |
S15 | Fuse in fuse box/relay plate |
T6k | 6-pin connector, on steering angle sender |
T10a | 10-pin connector, grey, coupling station, electronics box, on left in plenum chamber |
T26 | 26-pin connector |
T47 | 47-pin connector |
501 | Screw connection -2- (30), on relay plate |
A18 | Connection (54), in dash panel wiring harness |
A108 | Connection (speed signal), in dash panel wiring harness |
A121 | Connection (high bus), in dash panel wiring harness |
A122 | Connection (low bus), in dash panel wiring harness |
A167 | Positive (+) connection -3- (30a), in dash panel wiring harness |
* | Only models with ESP |
** | Only models with automatic gearbox |
Wiring Diagram VW NEW BEETLE CABRIOLET 2010 - Speed sensor - ABS valves
G44 | Rear right speed sensor |
G45 | Front right speed sensor |
G46 | Rear left speed sensor |
G47 | Front left speed sensor |
G201 | Brake pressure sender -1-, on brake master cylinder |
J104 | ABS with EDL/ TCS/ ESP control unit, left in engine compartment |
N99 | ABS inlet valve, front right |
N100 | ABS outlet valve, front right |
N101 | ABS inlet valve, front left |
N102 | ABS outlet valve, front left |
N125 | Differential lock valve 1 |
N126 | Differential lock valve 2 |
T2c | 2-pin connector, near rear right speed sensor |
T2d | 2-pin connector, near rear left speed sensor |
T47 | 47-pin connector, on ABS with EDL/TCS/ESP control unit |
D146 | Connection (rear left speed sensor +), in engine compartment wiring harness |
D147 | Connection (rear left speed sensor -), in engine compartment wiring harness |
D148 | Connection (rear right speed sensor +), in engine compartment wiring harness |
D149 | Connection (rear right speed sensor -), in engine compartment wiring harness |
* | Only models with ESP |
** | Only models with EDL |
*** | Applicable from model year 2004 |
Wiring Diagram VW NEW BEETLE CABRIOLET 2010 - Lateral acceleration sender - yaw rate sender - brake pressure sender -1- - ABS valves
G200 | Lateral acceleration sender, next to steering column |
G202 | Yaw rate sender, next to steering column |
G419 | ESP sensor unit |
J104 | ABS with EDL/ TCS/ ESP control unit, left in engine compartment |
N225 | Electronic stability program switch valve -1- |
N226 | Electronic stability program switch valve -2- |
N227 | Electronic stability program high pressure valve -1- |
N228 | Electronic stability program high pressure valve -2- |
T4w | 4-pin connector, near ESP sensor unit |
T16 | 16-pin connector, diagnostic connector |
T47 | 47-pin connector, on ABS with EDL/TCS/ESP control unit |
V64 | ABS hydraulic pump |
A76 | Connection (diagnosis wire K), in dash panel wiring harness |
* | Only models with ESP |
** | Only models without ESP |
*** | Right-hand drive models only |
**** | Applicable from model year 2004 |
Wiring Diagram VW NEW BEETLE CABRIOLET 2010 - Control unit with display in dash panel insert - handbrake warning switch - brake fluid level warning contact
F9 | Handbrake warning switch |
F34 | Brake fluid level warning contact |
J285 | Control unit with display in dash panel insert |
K14 | Handbrake warning lamp |
K118 | Brake system warning lamp |
T10 | 10-pin connector, orange, coupling station, electronics box, on left in plenum chamber |
T10d | 10-pin connector, white, coupling station, electronics box, on left in plenum chamber |
T32 | 32-pin connector, blue, on dash panel insert |
T32a | 32-pin connector, green, on dash panel insert |
12 | Earth point, left in engine compartment |
42 | Earth point, next to steering column |
81 | Earth connection -1-, in dash panel wiring harness |
85 | Earth connection -1-, in engine compartment wiring harness |
131 | Earth connection -2-, in engine compartment wiring harness |
135 | Earth connection -2-, in dash panel wiring harness |
D55 | Connection (brake wear indicator, left), in engine compartment wiring harness |
* | Left-hand drive models only |
** | Only models without daytime driving lights |
Right-hand drive models only |
Wiring Diagram VW NEW BEETLE CABRIOLET 2010 - Control unit with display in dash panel insert - brake lining/pad wear sender - data bus diagnostic interface
G34 | Brake lining/pad wear sender, front left |
J285 | Control unit with display in dash panel insert |
J533 | Data bus diagnostic interface |
K47 | ABS warning lamp |
K155 | Stability program warning lamp, TCS/ESP |
T32a | 32-pin connector, green, on dash panel insert |
D55 | Connection (brake wear indicator, left), in engine compartment wiring harness |
D56 | Connection (brake wear indicator, left), in engine compartment wiring harness |
VW NEW BEETLE CABRIOLET 2010 Overview of fuses
1 - | Fuses -S162-, -S163-, -S164-, -S176-, -S177-, -S178-, -S179-, -S180- on fuse holder/battery |
q | Location |
q | Position of fuses |
2 - | Fuses -S43-, -S67- -S68-, -S111-, -S130-, -S144-, -S283-, -S329-, |
3 - | Fuses (S) in fuse holder, left dash panel |
q | Location |
q | Position of fuses from August 2002 |
q | Position of fuses from July 2005 |
Torque settings |
⇒ Electrical system, Repair Group 97, removing and installing fuse holders |
Fuse colours |
30 A - green |
25 A - white |
20 A - yellow |
15 A - blue |
10 A - red |
7.5 A - brown |
5 A - beige |
3 A - purple |
VW NEW BEETLE CABRIOLET 2010 Position of fuses on fuse holder/battery
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
1 | - | S162 - Fuse 1 (30) in fuse holder on battery | 50A | - | V101 - Secondary air pump motor, for secondary air pump only J359 - Low heat output relay, models with diesel engines, manual gearbox only J360 - High heat output relay, models with diesel engines, manual gearbox only | 30 |
2 | - | S163 - Fuse 2 (30) in fuse holder on battery | 50A | - | J17 - Fuel pump relay (17/30) J370 - Glow plug activation control unit, models with diesel engines only | 30 |
3 | - | S164 - Fuse 3 (30) in fuse holder on battery | 40A | - | J293 - Radiator fan control unit (T4e/1) V7 - Radiator fan | 30 |
4 | - | S176 - Fuse 4 (30) in fuse holder on battery | 110A | - | J59 - X - contact relief relay (7/30) | 30a |
5 | - | S177 - Fuse 5 (30) in fuse holder on battery | 110 A 150 A | - | C - Alternator (90A) C - Alternator (120A) | 30 30 |
6 | - | S178 - Fuse 6 (30) in fuse holder on battery | 30A | - | J104 - ABS control unit (T47a/1) | 30 |
7 | - | S179 - Fuse 7 (30) in fuse holder on battery | 30A | - | J104 - ABS control unit (T47a/32) | 30 |
8 | - | S180 - Fuse 8 (30) in fuse holder on battery | 30A | - | F18 - Radiator fan thermal switch J293 - Radiator fan control unit (T4e/3) | 30 |
VW NEW BEETLE CABRIOLET 2010 Fuses on the 13 position additional relay carrier above the relay plate, from August 2002
Torque settings |
⇒ Electrical system, Repair Group 97, removing and installing fuse holders |
Fuse colours |
30 A - green |
25 A - white |
20 A - yellow |
15 A - blue |
10 A - red |
7.5 A - brown |
5 A - beige |
3 A - purple |
Notes:
t | Fuses from S 23 up to S44 are designated with an additional 2 in the Current Flow Diagram. |
t | For example S 28 is designated as S 228. |
VW NEW BEETLE CABRIOLET 2010 Position of fuses on fuse holder, left dash panel, from August 2002
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
1 | - | S1 - Fuse 1 in fuse holder | 10A | - | J131 - Heated driver seat control unit (T6/5) J132 - Heated front passenger seat control unit (T6b/5) W6 - Glove compartment light Z20/ Z21 - Left/right washer jet heater element | X |
2 | - | S2 - Fuse 2 in fuse holder | 10A | - | E3 - Hazard warning light switch (T7/6) | X |
3 | - | S3 - Fuse 3 in fuse holder | 5A | - | E20 - Switches and instruments illumination regulator J5 - Fog light relay (4/86) | 58 |
New Beetle Cabriolet | Fitting Locations | No. 801 / 10 |
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
6 | - | S6 - Fuse 6 in fuse holder | 5A | - | J393 - Convenience system central control unit (T23/5) | 15 |
7 | - | S7 - Fuse 7 in fuse holder | 10A | - | F4 - Reversing light switch F125 - Multifunction switch (T10k/10), 6-speed automatic gearbox 09G only, with Tiptronic (engine codes BDC, BGD) F189 - Tiptronic switch (T8/7) G22 - Speedometer sender, manual gearbox with engine codes BDC, BGD J220 - Motronic control unit (T121/9), engine code BKF only M16 / M17 - Left/right reversing light bulb | 15 |
8 | - | S8 - Fuse 8 in fuse holder | - | - | Vacant | 15 |
9 | - | S9 - Fuse 9 in fuse holder | 5A | - | E256 - TCS and ESP button (T6/6), for ABS with EDL, TCS and ESP only J104 - ABS control unit (T47a/4) G85 - Steering angle sender (T6k/5), for ABS with EDL, TCS and ESP only | 15 |
10 | - | S10 - Fuse 10 in fuse holder | 10A | - | J285 - Control unit in dash panel insert (T32/30) J393 - Convenience system central control unit (T23/17) R - Radio (T8a/4) | 86s |
11 | - | S11 - Fuse 11 in fuse holder | 5A | - | J285 - Control unit in dash panel insert (T32/1) | 15 |
12 | - | S12 - Fuse 12 in fuse holder | 7.5A | - | T16 - 16-pin connector, self-diagnosis (T16/16) | 30 |
13 | - | S13 - Fuse 13 in fuse holder | 10A | - | F - Brake light switch | 30 |
14 | - | S14 - Fuse 14 in fuse holder | 10A | - | J393 - Convenience system central control unit (T23/22) | 30 |
New Beetle Cabriolet | Fitting Locations | No. 801 / 12 |
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
24 | - | S224 - Fuse 24 in fuse holder | 20A | - | E22 - Intermittent wiper switch (T8c/8) J31 - Automatic intermittent wash and wipe relay (T18a/13) | X |
25 | - | S225 - Fuse 25 in fuse holder | 25A | - | E9 - Fresh air blower switch (T6d/2) | X |
26 | - | S226 - Fuse 26 in fuse holder | 25A | - | E15 - Heated rear window switch (T6b/5) Z1 - Heated rear window | X |
27 | - | S227 - Fuse 27 in fuse holder | 15A | - | Vacant | X |
28 | - | S228 - Fuse 28 in fuse holder | 15A | - | G6 - Fuel system pressurisation pump | 87 |
29 | - | S229 - Fuse 29 in fuse holder | 15A | - | J220 - Motronic control unit (T121/3), engine code BDC only J220 - Motronic control unit (T121/21) | 30 |
30 | - | S230 - Fuse 30 in fuse holder | 20A | - | Vacant J256 - Convertible roof actuation control unit (T18/8), for manuall operated convertible roof only | 30 |
31 | - | S231 - Fuse 31 in fuse holder | 20A | - | J217 - Automatic gearbox control unit (T52/27), (T52/28) J539 - Engine speed governor control unit (T6j/3), February 2003 only | 15 |
32 | - | S232 - Fuse 32 in fuse holder | 30A | - | N30/ N31/ N32/ N33 - Injector, cylinder | 87 |
New Beetle Cabriolet | Fitting Locations | No. 801 / 14 |
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
39 | - | S239 - Fuse 39 in fuse holder | 15A | - | E3 - Hazard warning light switch (T7/7) | 30 |
40 | - | S240 - Fuse 40 in fuse holder | 20A | - | J4 - Dual tone horn relay (3/30) | 30 |
41 | - | S241 - Fuse 41 in fuse holder | 15A | - | U1 - Cigarette lighter U5 - 12 V socket | 30 |
42 | - | S242 - Fuse 42 in fuse holder | 25A | - | R - Radio (T8/5), (T8/7) R12 - Amplifier (T23/18), (T23/21), (T23/23), for radio system Monsoon only R146 - Satellite radio (T8/2) | 30 |
43 | - | S243 - Fuse 43 in fuse holder | 10A | - | G39 - Lambda probe (T6s/3) G130 - Lambda probe after catalytic converter (T4s/1) G465 - Centre Lambda probe for bank 1 catalytic converter, for engine codes AWV, BKF only G70 - Air mass meter J299 - Secondary air pump relay N80 - Activated charcoal filter system solenoid valve 1 V144 - Fuel system diagnostic pump (T3d/3) | 87 |
44 | - | S244 - Fuse 44 on fuse holder | 15A | - | J131 - Heated driver seat control unit (T6/4) J132 - Heated front passenger seat control unit (T6b/4) | 30 |
VW NEW BEETLE CABRIOLET 2010 Position of fuses on fuse holder, left dash panel, from July 2005
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
1 | - | S1 - Fuse 1 in fuse holder | 10A | - | J131 - Heated driver seat control unit (T6/5) J132 - Heated front passenger seat control unit (T6b/5) W6 - Glove compartment light Z20/ Z21 - Left/right washer jet heater element | X |
2 | - | S2 - Fuse 2 in fuse holder | 10A | - | J1 - Turn signal relay (T8d/7) | X |
3 | - | S3 - Fuse 3 in fuse holder | 5A | - | E20 - Switches and instruments illumination regulator (T3k/2) J5 - Fog light relay (4/86) | 58 |
4 | - | S4 - Fuse 4 in fuse holder | 5A | - | X - number plate light | 58 |
5 | - | S5 - Fuse 5 in fuse holder | 7.5 A | - | E45-Cruise control system switch E159 - Fresh air/air recirculation flap switch (T8n/5) E184 - Fresh air and air recirculation switch (T8n/5) F36 - Clutch pedal switch (T4m/3), for manual gearbox only F47 - Brake pedal switch (T4y/2) G65 - High-pressure sender (T3c/3) J89 - Daytime running lights change-over relay (8/86) J293 - Radiator fan control unit (T14/9) J502 - Tyre pressure monitor control unit (T20b/18) T16 - 16-pin connector, self-diagnosis (T16/1) V35 - Right radiator fan Y2 - Digital clock Y7 - Automatic anti-dazzle interior mirror, rain sensor | 15 |
New Beetle Cabriolet | Fitting Locations | No. 801 / 17 |
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
14 | - | S14 - Fuse 14 in fuse holder | 10A | - | J393 - Convenience system central control unit (T23/22) | 30 |
15 | - | S15 - Fuse 15 in fuse holder | 5A | - | G85 - Steering angle sender (T6p/4) for TCS/ESP J217 - Automatic gearbox control unit (T68/45) J285 - Control unit in dash panel insert (T32/23) Y2 - Digital clock | 30 |
16 | - | S16 - Fuse 16 in fuse holder | 10A | - | J293 - Radiator fan control unit (T14/4) | 30 |
17 | - | S17 - Fuse 17 in fuse holder | - | - | Vacant | 30 |
18 | - | S18 - Fuse 18 in fuse holder | 10A | - | J285 - Control unit in dash panel insert (T32/a17) M32 - Right main beam bulb | 56a |
19 | - | S19 - Fuse 19 in fuse holder | 10A | - | M30 - Left main beam bulb | 56a |
20 | - | S20 - Fuse 20 in fuse holder | 15A | - | M31 - Right headlight dipped beam bulb | 56b |
21 | - | S21 - Fuse 21 in fuse holder | 15A | - | M29 - Left headlight dipped beam bulb | 56b |
22 | - | S22 - Fuse 22 in fuse holder | 5A | - | J285 - Control unit in dash panel insert (T32/26) M3 - Right side light bulb M22 - Right brake and tail light bulb M34 - Front right side marker bulb M38 - Rear right side marker bulb | 58r |
New Beetle Cabriolet | Fitting Locations | No. 801 / 19 |
No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
33 | - | S233 - Fuse 33 on fuse holder | 20A | - | Vacant | 30 |
34 | - | S234 - Fuse 34 on fuse holder | 10A | - | Vacant | 87 |
35 | - | S235 - Fuse 35 on fuse holder | 30A | - | Vacant | 30 |
36 | - | S236 - Fuse 36 on fuse holder | 15A | - | E23 - Front and rear fog light switch (T17/2) | X |
37 | - | S237 - Fuse 37 in fuse holder | 20A | - | J220 - Motronic control unit (T121/62) J271 - Motronic current supply relay (2/30) | 30 |
38 | - | S238 - Fuse 38 in fuse holder | 15A | - | J386 - Driver door control unit (T29/19), models with window regulator, from 2003 up to 2007 J387 - Front passenger door control unit (T29a/19), models with window regulator, from 2003 up to 2007 J667 - Power output module for left headlight (T9n/2), (T9n/6) | 30 |
39 | - | S239 - Fuse 39 in fuse holder | 15A | - | E3 - Hazard warning light switch (T8d/8) | 30 |
40 | - | S240 - Fuse 40 in fuse holder | 20A | - | H1 - Horn or dual tone horn J4 - Dual tone horn relay (3/30) | 30 |
41 | - | S241 - Fuse 41 in fuse holder | 15A | - | U1 - Cigarette lighter U5 - 12 V socket U18 - 12 V socket -2-, from 07.03 U19 - 12 V socket 3, in luggage compartment, from 07.03 | 30 |
42 | - | S242 - Fuse 42 in fuse holder | 25A | - | R - Radio (T8/5, T8/7) | 30 |