POWER DISTRIBUTION – Chevrolet Cutaway G3500 1999 – SYSTEM WIRING DIAGRAMS

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 4) for Chevrolet Cutaway G3500 1999

List of elements for Power Distribution Wiring Diagram (1 of 4) for Chevrolet Cutaway G3500 1999:

• (crossbody harness, approx 4 cm from convenience center conn breakout)
• (engine harn, near bulkhead connector)
• (i/p harness, approx 4 cm into tcc/stoplamp switch breakout)
• (rear a/c harness, approx 23 cm from blower motor resistor/ relay breakout)
• (rear a/c harness, approx 7 cm from blower motor resistor breakout)
• (rear aux htr and a/c harness, approx 33 cm from rear aux hvac module breakout)
• A13
• Abs fuse 60a
• Acc
• Ambulance
• Aux-a fuse 50a
• Aux-b fuse 50a
• Auxiliary battery
• Auxiliary blower motor high speed relay
• Auxiliary blower motor low speed relay
• Auxiliary blower motor medium speed relay
• Battery
• Battery junction block
• Blower fuse 60a
• Blower motor resistor relay
• Brake fuse 18 10a
• C202
• C206
• C210
• C302
• Convenience center
• Crank fuse 8 10a
• Cruise control module (gasoline)
• Cruise control switch
• Cruise fuse 6 10a
• Diesel
• Electronic brake control module (ebcm)
• From aux-a fuse (diagram 1 of 4)
• Front auxiliary hvac control module
• Fusible link (10 ga- rust)
• Fusible link (10 ga-rust)
• G200 (left kick panel)
• Gasoline
• Generator
• Glowplug relay
• Heater and a/c control logic module
• Heater and a/c controller
• Htr a/c fuse 12 20a
• I/p fuse block
• Ign-a fuse 40a
• Ign-b fuse 50a
• Ignition switch
• Inline fuse 30a
• Left front power side window switch
• Lock
• Nca
• Off
• P/b booster fluid low alarm
• Park/ neutral position switch
• Passenger
• Pnk
• Pwr wdo fuse b 25a
• Radio
• Radio 1 fuse 17 10a
• Rear auxiliary hvac control module
• Rear auxiliary mode valve and seal assembly
• Rear auxiliary temperature valve assembly
• Red
• Resistor
• Right front power side window switch
• Rr blower fuse 30a
• Rr hvac fuse 24 10a
• Run
• S122
• S201
• S210
• S213
• S220
• S229
• S252
• S307
• S311
• S312
• S404
• S405
• S412
• Start
• Starter relay
• Starter solenoid
• Tcc/ stoplamp switch
• Temperature valve actuator motor
• To s214 (diagram 3 of 4)
• To trans fuse (diagram 4 of 4)
• To underhood fuse-relay center (diagram 2 of 4)
• To upfitter provision relay (diagram 1 of 4)
• Trailer wiring provision
• Underhood fuse/relay center
• Upfitter provision connector
• Upfitter provision relay (behind left b pillar)
• Vehicle control module (vcm) (gasoline)
• W/ rear a/c
• Windshield washer/ wiper switch
• Windshield wiper motor
• Wiper fuse 11 25a

Power Distribution Wiring Diagram (2 of 4) for Chevrolet Cutaway G3500 1999

List of elements for Power Distribution Wiring Diagram (2 of 4) for Chevrolet Cutaway G3500 1999:

• (6.5l, 5.0l, 5.7l-engine harness, approx 11-19 cm from bulkhead connector, 4.3l, 7.4l-engine harness, approx 65cm from underhood fuse relay center) s127
• (crossbody harness, approx 14 cm from power door lock relay breakout) s232
• (crossbody harness, left side of dash)
• (engine harness, approx 4 cm into main harness breakout)
• (i/p harness, 4 cm from radio breakout)
• (i/p harness, 7 cm from instrument cluster breakout)
• (i/p harness, approx 4 cm into power seat harness breakout)
• (i/p harness, approx 8 cm into i/p relay center breakout)
• (i/p harness, approx 9 cm from radio breakout) s227
• (right body harness, approx 13 cm from side door jamb switch breakout)
• (right body harness, approx 7 cm from power seat switch breakout)
• (sun shade illum mirror harness, approx 7 cm from right sun shade lamp breakout)
• (underhood lamp harness, approx 11 cm from reel lamp connector breakout) s148
• (upfitter provision-left body harness, 150 cm from convenience center connector others-left body harness, behind left "b" pillar)
• A/c compressor enable relay
• A/c fuse 20a
• Auxiliary power outlet
• Batt fuse 50a
• C13
• C202
• C210
• Center dome lamp
• Cig ltr fuse 13 20a
• Cigarette lighter
• Convenience center
• Ctsy fuse 3 20a
• D13
• Data link connector (dlc)
• Daytime running lamp (drl) diode module
• Drl fuse 15 15a
• Ecm-b fuse 20a
• From underhood b fuse-relay center (diagram 1 of 4)
• From underhood fuse-relay center (diagram 1 of 4)
• Front dome lamp
• Fuel pump relay
• G200 (left kick panel)
• Hazard fuse 5 20a
• Hazard warning switch
• Headlamp switch
• Heater and a/c controller
• Horn fuse 20a
• Horn relay
• Htd mir fuse 2 20a
• I/p compartment lamp
• I/p fuse block
• Illuminated entry module
• Left front power door lock switch
• Left power seat switch
• Left stepwell lamp
• Left sun shade mirror lamp
• Lighting fuse 40a
• Multi- function alarm module
• Nca
• Others
• Park lps fuse 9 20a
• Passlock module
• Power antenna assembly
• Power door lock control module
• Power door lock relay
• Power outside rear view mirror remote control switch
• Powertrain control module (pcm) (diesel)
• Pwr accy fuse a 25a
• Pwr aux fuse 7 25a
• Radio
• Radio-b fuse 19 10a
• Rear dome lamp
• Red
• Remote control door lock receiver
• Right front power door lock switch
• Right power seat switch
• Right rear power door lock switch
• Right stepwell lamp
• Right sun shade mirror lamp
• S120
• S205
• S211 (i/p harness, approx 4 cm from park brake warning switch breakout)
• S212
• S218
• S219
• S221
• S222
• S300
• S308
• S309
• S406
• Security strg fuse 21 10a
• Side stepwell lamp
• Stop fuse 1 20a
• Tcc/stop- lamp switch
• Underhood fuse/relay center
• Underhood lamp
• Underhood reel lamp
• Vehicle control module (vcm) (gasoline)
• W/ lamp group option
• W/ power pass seat
• W/ upfitter provisions
• W/o keyless entry
• W/o upfitter provissions

Power Distribution Wiring Diagram (3 of 4) for Chevrolet Cutaway G3500 1999

List of elements for Power Distribution Wiring Diagram (3 of 4) for Chevrolet Cutaway G3500 1999:

• (engine harness, 117 cm from underhood fuse-relay center)
• (engine harness, appprox 12 cm from right ho2s sensor (bnk 2 sens 1) breakout)
• (engine harness, approx 15 cm into fuel injector harness breakout)
• (engine harness, approx 4 cm from egr valve breakout) 5.0l, 5.7l
• (engine harness, approx 4 cm from fuel injector harness breakout)
• (engine harness, approx 7 cm into main harness breakout)
• (engine harness, approx 8 cm from fuel injector harness breakout)
• (engine harness, approx 8 cm into fuel injector harness breakout)
• (engine harness, near front of engine)
• (engine harness, top left of engine)
• (engine jumper harness, approx 2 cm from optical fuel temperature sensor breakout)
• (engine jumper harness, near left side of engine)
• (fed) (cal)
• (o2s jumper harness, 35 cm from 6-pin connector on right frame rail)
• (o2s jumper harness, approx 66 cm from 6-pin conn on right frame rail)
• 4.3l
• 5.0l, 5.7l
• 6.5l
• 7.4l
• A/c compressor enable relay
• C nca
• C11
• C12
• Camshaft position (cmp) sensor
• Crankshaft position (ckp) sensor
• Diesel
• Ecm-1 fuse 20a
• Eng-1 fuse 20a
• Epr solenoid
• Evaporative emission (evap) canister purge solenoid valve
• Evaporative emission (evap) canister purge valve
• Evaporative emission (evap) canister purge valve solenoid
• Evaporative emission (evap) canister vent valve
• From ignition switch (diagram 1 of 4)
• Fuel heater
• Fuel injectors 1, 3 & 5
• Fuel injectors 1, 3, 5 & 7
• Fuel injectors 1, 3, 5, & 7
• Fuel injectors 2, 4 & 6
• Fuel injectors 2, 4, 6 & 8
• Fuel injectors 2, 4, 6, & 8
• Fuel shutoff solenoid
• Fuel solenoid driver
• Glow plug relay
• Heated oxygen sensor (ho2s) bank 1
• Heated oxygen sensor (ho2s) bank 1 sensor 1
• Heated oxygen sensor (ho2s) bank 1 sensor 2
• Heated oxygen sensor (ho2s) bank 1 sensor 3
• Heated oxygen sensor (ho2s) bank 2 sensor 1
• Heated oxygen sensor (ho2s) bank 2 sensor 2
• Ign-1 fuse 20a
• Ign-e fuse 10a
• Ignition coil
• Ignition control module (icm)
• Mass airflow (maf) sensor
• Pnk
• Pnk (engine harness, approx 5 cm from ho2s sens (bnk 2 sens 1) breakout) s130
• Pnk s304
• Powertrain control module (pcm)
• S107
• S108
• S117 pnk
• S126
• S130
• S131 pnk
• S132
• S132 pnk
• S133 pnk
• S214
• S304
• S304 (na1)
• Secondary air injection (air) reaction pump relay
• Sensor 2 (na1)
• To i/p fuse block (diagram 4 of 4)
• Underhood fuse/relay center
• Underhood fuse/relay center (calif only)
• Vehicle control module (vcm)
• Waste gate solenoid
• Water in fuel sensor

Power Distribution Wiring Diagram (4 of 4) for Chevrolet Cutaway G3500 1999

List of elements for Power Distribution Wiring Diagram (4 of 4) for Chevrolet Cutaway G3500 1999:

• (i/p harness, approx 30 cm from bulkhead connector) s217
• (i/p harness, approx 4 cm from breakout to connector at base of steering column) s216
• Air bags fuse 10 10a
• Automatic transmission
• B10
• B17
• C210
• Convenience center
• Daytime running lamp (drl) control module
• Daytime running lamp (drl) relay
• From ignition switch (diagram 1 of 4)
• From s214 (diagram 3 of 4)
• Fuel sender buffer module (diesel)
• Gauges fuse 4 10a
• Hazard warning switch
• Headlamp switch
• I/p fuse block
• I/p relay center
• Illum fuse 14 10a
• Illuminated entry module
• Inflatable restraint sensing and diagnositc module
• Instrument cluster
• Interior lights system
• Interior lights system (i/p dimmer switch)
• Low engine coolant level indicator module (diesel)
• Multi- function alarm module
• Park/neutral position switch
• Passlock module
• Pnk
• Remote control door lock receiver
• Trans fuse 20 10a
• Turn b/u fuse 16 20a
• Vehicle speed sensor buffer (diesel)
• W/ keyless entry
• W/o keyless entry