ENGINE PERFORMANCE – Dodge Caravan C/V 1995 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.5L

2.5L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995

List of elements for 2.5L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995:

• (left fender side shield)
• (right side forward of engine)
• A/c clutch relay sig
• A/c cycling sw input
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown bat
• Automatic shut down relay (in power distri- bution center)
• B/h conn
• Brake sense
• C13
• C137
• C20
• C24
• Control module
• Cooling fans system
• Cruise control system
• D20
• D21
• Data link connector (data bus) (left side lower instrument panel)
• Data link connector (engine) (front left shock tower)
• Data link receive
• Data link transmit
• Direct battery
• Distributor ign sig (+)
• Ect sensor
• Eng fuse 15a
• Evap/purge solenoid
• F15
• F20
• Fuel pump & gauge sending unit
• Fuel pump fuse 15a
• Fuel pump relay (in power distri- bution center)
• Fuse 10a
• Fuse block: i/p
• G100 (left fender shield, rear of battery)
• G200 (left kick panel)
• Gen field driver
• Generator
• High speed fan relay
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition start sig
• Ignition switch
• Inj driver
• Injector
• Instrument cluster system (fuel gauge)
• K11
• K19
• K20
• K22
• K24
• K29
• K39
• K40
• K41
• K51
• K52
• K54
• K59
• K60
• Low speed fan relay
• Map sensor
• Off
• Park/neutral sw
• Pnk
• Power distribution center
• Power ground
• Powertrain
• Red
• Run
• Sensor return
• Serial buss b+
• Serial buss b-
• Signal ground
• Start
• Starting/ charging system (engine starter relay)
• Stop lamp switch with vehicle speed control
• T41
• Tan/red
• Throttle position
• Transmission emcc sol
• V35
• V36
• V37
• Vehicle spd ctrl-vent
• Vehicle speed ctrl
• Vhcl spd ctrl-vacuum
• Volt sense
• Vss
• Z11
• Z12

2.5L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995

List of elements for 2.5L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995:

• Automatic transmission only
• B/h conn
• Body computer
• Check engine
• Data link connector (data buss) (left side lower instrument panel)
• Distributor
• Engine coolant sensor (top right of engine)
• Evap/purge solenoid (right side fender shield)
• Fuse 20a
• Fuse block: i/p
• G115 (throttle body ground, top rear of engine)
• Heated oxygen sensor (top rear of engine)
• Hot at all times
• Ignition coil
• Instrument cluster
• Map sensor (right side of dash panel)
• Nca
• Red
• Throttle position sensor (on throttle body)
• Transmission tcc lu solenoid (left front of transmission)
• Vehicle speed sensor (rear of trans- mission)

3.0L

3.0L, Engine Performance Wiring Diagrams, with Transmission Control Module (1 of 2) for Dodge Caravan C/V 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams, with Transmission Control Module (1 of 2) for Dodge Caravan C/V 1995:

• (left fender side shield)
• (right side rear of engine)
• A/c cycling sw input
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown relay
• Automatic shut down relay (in power distri- bution center)
• B/h conn
• Brake sense
• C13
• C137
• C20
• C24
• Control module
• Cooling fans system
• Cruise control system
• D20
• D21
• Data link connector (data bus) (left side lower instrument panel)
• Data link connector (engine) (front left shock tower)
• Data link receive
• Data link transmit
• Direct battery
• Distributor ign sig
• Distributor ign sig (+)
• Ect sensor
• Egr solenoid
• Eng fuse 15a
• Evap/purge solenoid
• F15
• Fuel
• Fuel pump & gauge sending unit
• Fuel pump fuse 15a
• Fuel pump relay (in power distri- bution center)
• Fuse 10a
• Fuse block: i/p
• G100 (left fender shield, rear of battery)
• G200 (left kick panel)
• Gen field driver
• Generator
• Hight speed fan relay
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Injectors
• Instrument cluster system (fuel gauge)
• K11
• K12
• K13
• K14
• K19
• K20
• K22
• K24
• K29
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K58
• K59
• K60
• Low speed fan relay
• Map sensor
• Off
• Park/neutral sw
• Pnk
• Power distribution center
• Power ground
• Powertrain
• Red
• Run
• Sensor return
• Serial buss b+
• Serial buss b-
• Signal ground
• Start
• Starting/ charging system (engine starter relay)
• Stop lamp switch with vehicle speed control
• T41
• Tan
• Tan/red
• Throttle position
• Transmission system (transmission control module)
• V35
• V36
• V37
• Vehicle spd ctrl-vent
• Vehicle speed ctrl
• Vhcl spd ctrl-vacuum
• Volt sense
• Vss
• Wot cutout relay
• Z11
• Z12

3.0L, Engine Performance Wiring Diagrams, with Transmission Control Module (2 of 2) for Dodge Caravan C/V 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams, with Transmission Control Module (2 of 2) for Dodge Caravan C/V 1995:

• B/h conn
• Body computer
• Check engine
• Data link connector (data buss) (left side lower instrument panel)
• Distributor firing order 1-2-3-4-5-6
• Egr solenoid (rear of intake)
• Engine coolant sensor (top right of engine)
• Evap/purge solenoid (right side fender shield)
• Fuse 20a
• Fuse block: i/p
• Heated oxygen sensor (on exhaust manifold)
• Hot at all times
• Ignition coil
• Instrument cluster
• Map sensor (right side of dash panel)
• Nca
• Red
• Throttle position sensor (on throttle body)
• Transmission control module (right side dash panel)
• Transmission system

3.0L, Engine Performance Wiring Diagrams, without Transmission Control Module (1 of 2) for Dodge Caravan C/V 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams, without Transmission Control Module (1 of 2) for Dodge Caravan C/V 1995:

• (left fender side shield)
• (right side rear of engine)
• A/c cycling sw input
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown relay
• Automatic shut down relay (in power distri- bution center)
• B/h conn
• Brake sense
• C13
• C137
• C20
• C24
• Control module
• Cooling fans system
• Cruise control system
• D20
• D21
• Data link connector (data bus) (left side lower instrument panel)
• Data link connector (engine) (front left shock tower)
• Data link receive
• Data link transmit
• Direct battery
• Distributor ign sig
• Distributor ign sig (+)
• Ect sensor
• Egr solenoid
• Eng fuse 15a
• Evap/purge solenoid
• F15
• Fuel
• Fuel pump & gauge sending unit
• Fuel pump fuse 15a
• Fuel pump relay (in power distri- bution center)
• Fuse 10a
• Fuse block: i/p
• G100 (left fender shield, rear of battery)
• G200 (left kick panel)
• Gen field driver
• Generator
• High speed fan relay
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Injectors
• Instrument cluster system (fuel gauge)
• K11
• K12
• K13
• K14
• K19
• K20
• K22
• K24
• K29
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Low speed fan relay
• Map sensor
• Off
• Park/neutral sw
• Pnk
• Power distribution center
• Power ground
• Powertrain
• Red
• Run
• Sensor return
• Serial buss b+
• Serial buss b-
• Signal ground
• Start
• Starting/ charging system (engine starter relay)
• Stop lamp switch with vehicle speed control
• T41
• Tan
• Tan/red
• Throttle position
• Transmission emcc sol
• V35
• V36
• V37
• Vehicle spd ctrl-vent
• Vehicle speed ctrl
• Vhcl spd ctrl-vacuum
• Volt sense
• Vss
• Wot cutout relay
• Z11
• Z12

3.0L, Engine Performance Wiring Diagrams, without Transmission Control Module (2 of 2) for Dodge Caravan C/V 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams, without Transmission Control Module (2 of 2) for Dodge Caravan C/V 1995:

• B/h conn
• Body computer
• Check engine
• Data link connector (data buss) (left side lower instrument panel)
• Distributor firing order 1-2-3-4-5-6
• Egr solenoid (rear of intake)
• Engine coolant sensor (top right of engine)
• Evap/purge solenoid (right side fender shield)
• Fuse 20a
• Fuse block: i/p
• Heated oxygen sensor (on exhaust manifold)
• Hot at all times
• Ignition coil
• Instrument cluster
• Map sensor (right side of dash panel)
• Nca
• Red
• Throttle position sensor (on throttle body)
• Transmission tcc lu solenoid (left front of transmission)
• Vehicle speed sensor (rear of trans- mission)

3.3L

3.3L CNG, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995

List of elements for 3.3L CNG, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995:

• (left fender side shield)
• (right side forward of engine)
• 5v output
• A/c comp cl relay
• A/c damped press sw
• A14
• A142
• Air conditioning system
• B/h conn
• Body computer (right of steering column)
• Brake sense
• C13
• C137
• C20
• C24
• Camshaft pos sens
• Camshaft position sensor (right side front of engine)
• Control module
• Cooling fans system
• Crankshaft pos sens
• Cruise control system
• D20
• D21
• Data link connector (engine) (front of left shock tower)
• Data link receive
• Data link transmit
• Direct battery
• Ect sensor
• Egr transducer sig
• Engine coolant sensor (top left of engine)
• F15
• Fuel gauge pressure transducer (near rear fuel tank, left side)
• Fuel level input
• Fuel temp sensor
• Fuel temper- ature sensor
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse block: i/p
• G101 (right side shield)
• G200 (left front kick panel)
• Generator
• High pressure shutoff relay (in power distri- bution center)
• High pressure solenoid valve (left frame rail)
• High speed fan relay
• Hot at all times
• Hot in run or start
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver #1
• Ign coil driver #2
• Ign coil driver #3
• Ign start/run
• Ignition coil (right side front of engine)
• Inj 1
• Inj 2
• Inj 3
• Inj 4
• Inj 5
• Inj 6
• K11
• K12
• K13
• K14
• K17
• K18
• K19
• K20
• K22
• K221
• K24
• K242
• K29
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K58
• K59
• K60
• Lo press shutoff rly
• Low press sensor
• Low pressure sensor (right front of engine)
• Low pressure shutoff relay (in power distri- bution center)
• Low pressure shutoff solenoid (near right engine mount)
• Low speed fan relay
• Map sensor
• Map sensor (rear of intake)
• Park/neutral sw
• Pnk
• Power distribution center
• Power distribution system
• Power ground
• Powertrain
• Red
• Sensor return
• Serial buss b+
• Serial buss b-
• Signal ground
• Starting system (engine starter relay)
• System (stop lamp switch)
• T41
• Tan
• Tan/pnk
• Tan/red
• Throttle position
• Throttle position sensor (on throttle body)
• Transmission system (transmission control module)
• V35
• V36
• V37
• Volt sense
• Voltage reg
• Vs ctrl
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss sig
• Z11
• Z12

3.3L CNG, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995

List of elements for 3.3L CNG, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995:

• (on exhaust
• B/h conn
• Body computer (right of steering column)
• Check engine
• Crankshaft position sensor (rear of engine, on transmission)
• Data link connector (data buss) (lower left side of i/p)
• Egr solenoid (rear of intake)
• Fuel injectors
• Fuse 20a
• Fuse block: i/p
• G206 (center rear of i/p)
• Heated
• Hot at all times
• Instrument cluster
• Manifold)
• No.1
• No.2
• No.3
• No.4
• No.5
• No.6
• Oxygen sensor
• Red
• Tan
• Transmission system

3.3L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995

List of elements for 3.3L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995:

• (left fender side shield)
• (right side forward of engine)
• A/c cycling sw input
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown relay
• Automatic shut down relay (in power distri- bution center)
• B/h conn
• Brake sense
• C13
• C137
• C20
• C24
• Camshaft pos sens
• Control module
• Cooling fans system
• Crankshaft pos sens
• Cruise control system
• D20
• D21
• Data link connector (data bus) (left side lower instrument panel)
• Data link connector (engine) (front left shock tower)
• Data link receive
• Data link transmit
• Direct battery
• Ect sensor
• Egr solenoid
• Eng fuse 15a
• Evap/purge solenoid
• F15
• Fuel
• Fuel pump & gauge sending unit
• Fuel pump fuse 15a
• Fuel pump relay (in power distri- bution center)
• Fuse 10a
• Fuse block: i/p
• G100 (left fender shield, rear of battery)
• G200 (left kick panel)
• Gen field driver
• Generator
• Hight speed fan relay
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver #1
• Ign coil driver #2
• Ign coil driver #3
• Ign feed
• Ignition coil (right front of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Injectors
• Instrument cluster system (fuel gauge)
• K11
• K12
• K13
• K14
• K17
• K18
• K19
• K20
• K22
• K24
• K29
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K58
• K59
• K60
• Low speed fan relay
• Map sensor
• Off
• Park/neutral sw
• Pnk
• Power distribution center
• Power ground
• Powertrain
• Red
• Run
• Sensor return
• Serial buss b+
• Serial buss b-
• Signal ground
• Start
• Starting/ charging system (engine starter relay)
• Stop lamp switch with vehicle speed control
• T41
• Tan
• Tan/red
• Throttle position
• Transmission system (transmission control module)
• V35
• V36
• V37
• Vehicle spd ctrl-vent
• Vehicle speed ctrl
• Vhcl spd ctrl-vacuum
• Volt sense
• Vss
• Wot cutout relay
• Z11
• Z12

3.3L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995

List of elements for 3.3L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995:

• B/h conn
• Body computer
• Camshaft position sensor (right front of engine)
• Check engine
• Crankshaft position sensor (right front of engine)
• Data link connector (data buss) (left side lower instrument panel)
• Egr solenoid (rear of intake)
• Engine coolant sensor (top left of engine)
• Evap/purge solenoid (right side fender shield)
• Fuse 20a
• Fuse block: i/p
• Heated oxygen sensor (top rear of engine)
• Hot at all times
• Instrument
• Map sensor (right side of dash panel)
• Red
• Throttle position sensor (on throttle body)
• Transmission control module (right side dash panel)
• Transmission system

3.8L

3.8L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995

List of elements for 3.8L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Caravan C/V 1995:

• (left fender side shield)
• (right side forward of engine)
• A/c cycling sw input
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown relay
• Automatic shut down relay (in power distri- bution center)
• B/h conn
• Brake sense
• C13
• C137
• C20
• C24
• Camshaft pos sens
• Control module
• Cooling fans system
• Crankshaft pos sens
• Cruise control system
• D20
• D21
• Data link connector (data bus) (left side lower instrument panel)
• Data link connector (engine) (front left shock tower)
• Data link receive
• Data link transmit
• Direct battery
• Ect sensor
• Egr solenoid
• Eng fuse 15a
• Evap/purge solenoid
• F15
• Fuel
• Fuel pump & gauge sending unit
• Fuel pump fuse 15a
• Fuel pump relay (in power distri- bution center)
• Fuse 10a
• Fuse block: i/p
• G100 (left fender shield, rear of battery)
• G200 (left kick panel)
• Gen field driver
• Generator
• Hight speed fan relay
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver #1
• Ign coil driver #2
• Ign coil driver #3
• Ign feed
• Ignition coil (right front of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Injectors
• Instrument cluster system (fuel gauge)
• K11
• K12
• K13
• K14
• K17
• K18
• K19
• K20
• K22
• K24
• K29
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K58
• K59
• K60
• Low speed fan relay
• Map sensor
• Off
• Park/neutral sw
• Pnk
• Power distribution center
• Power ground
• Powertrain
• Red
• Run
• Sensor return
• Serial buss b+
• Serial buss b-
• Signal ground
• Start
• Starting/ charging system (engine starter relay)
• Stop lamp switch with vehicle speed control
• T41
• Tan
• Tan/red
• Throttle position
• Transmission system (transmission control module)
• V35
• V36
• V37
• Vehicle spd ctrl-vent
• Vehicle speed ctrl
• Vhcl spd ctrl-vacuum
• Volt sense
• Vss
• Wot cutout relay
• Z11
• Z12

3.8L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995

List of elements for 3.8L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Caravan C/V 1995:

• B/h conn
• Body computer
• Camshaft position sensor (right front of engine)
• Check engine
• Crankshaft position sensor (right front of engine)
• Data link connector (data buss) (left side lower instrument panel)
• Egr solenoid (rear of intake)
• Engine coolant sensor (top left of engine)
• Evap/purge solenoid (right side fender shield)
• Fuse 20a
• Fuse block: i/p
• Heated oxygen sensor (top rear of engine)
• Hot at all times
• Instrument
• Map sensor (right side of dash panel)
• Red
• Throttle position sensor (on throttle body)
• Transmission control module (right side dash panel)
• Transmission system