All Wiring Diagrams for Ford Explorer 1997

AIR CONDITIONING

A/C Wiring Diagram, Auto A/C for Ford Explorer 1997

List of elements for A/C Wiring Diagram, Auto A/C for Ford Explorer 1997:

• (eng harn, between a/c clutch diode & a/c comp clutch solenoid breakout)
• (eng harn, left front of engine compartment)
• (eng harn, left side of eng compt)
• (eng harn, near a/c comp clutch solenoid)
• (engine harn, left side of eng compt)
• (engine harn, rear of engine compartment) s144
• (i/p harn, behind center of i/p)
• (i/p harn, near instrument panel breakout)
• (i/p harn, near right door jamb) s240
• (i/p harn, right side of i/p)
• (right side of engine compt)
• A/c compressor clutch solenoid
• A/c clutch cycling pressure switch (right side of engine compartment)
• A/c clutch diode
• A/c clutch out
• A/c plenum)
• A/c pressure cutoff switch (left side of engine compartment)
• Ambient temp input
• Ambient temperature sensor (left front of engine compartment)
• Battery
• Blend door act
• Blend door actuator (behind right side of i/p, top of
• Blend door pot
• Blend door ref
• Blower motor
• Blower motor relay (in auxiliary relay box 2)
• Blower motor speed
• Blower motor speed controller (near blower motor)
• Blower speed fback
• C297
• C298
• Data line
• Data link connector (dlc) (behind left side of i/p)
• Electronic automatic temperature control (eatc) module (center of i/p)
• Eng/met conv
• Fuse 10a
• Fuse 15a
• Fuse 50a
• Fuse 7.5a
• G103
• G103 (right side of eng compartment)
• G104 (left rear corner of engine compartment)
• G104 (left rear corner of engine compt)
• G201 (under right side of i/p)
• Ground
• Hot at all times
• Hot in run
• Ignition
• Illumination
• In car temp sens
• In-car temperature sensor
• Interior fuse panel
• Interior lights system
• Med
• Message center
• Off
• Pcm power relay
• Power distribution box
• Powertrain control module (pcm) (on right side of safety wall)
• Rear blower motor
• Rear air door actuator (in i/p console)
• Rear blower motor relay (behind right side of i/p)
• Rear blower motor resistor (in i/p console)
• Rear integrated control panel (ricp)
• Red
• Relay signal
• S100
• S133
• S154
• S158
• S161
• S205
• S206
• S209
• S211
• S229
• S231 (body harn, in i/p console)
• S241
• S263
• Sensor ground
• Sun load sensor (top right side of i/p, above glove box)
• Sunload sens input
• Wot a/c relay (in power distribution box)

A/C Wiring Diagram, Manual A/C for Ford Explorer 1997

List of elements for A/C Wiring Diagram, Manual A/C for Ford Explorer 1997:

• (body harn, in i/p console)
• (eng harn, between a/c clutch diode & a/c comp clutch solenoid breakout)
• (eng harn, rear of engine compt)
• (in auxiliary relay box 2)
• (left rear corner of engine compartment)
• A/c clutch cycling pressure switch (right side of engine compartment)
• A/c clutch diode
• A/c compres- sor clutch solenoid
• A/c pressure cutoff switch (left side of engine compartment)
• Blend door actuator (behind right side of i/p, on a/c plenum)
• Blower motor
• Blower motor relay (in auxiliary relay box 2)
• Blower motor resistor (near blower motor)
• Blower motor switch
• C231
• C276
• Cold
• Def
• Def/flr
• Flr
• Fuse 15a
• Fuse 50a
• Fuse 7.5a
• G103 (right side of engine compartment)
• G104
• G201 (right side of i/p)
• Heater-a/c control assembly
• High speed blower relay
• Hot at all times
• Hot in run
• Illumi- nation
• Interior fuse panel
• Interior lights system
• Low
• Max
• Med
• Norm
• Off
• Pan/flr
• Panel
• Pcm power relay
• Power distribution box
• Powertrain control module (pcm) (on right side of safety wall)
• Rear air door actuator
• Rear blower motor
• Rear blower motor relay (behind right side of i/p)
• Rear blower motor resistor (in i/p console)
• Rear inte- grated control panel
• Red
• S100
• S133 (eng harn, near a/c comp clutch solenoid)
• S144
• S158 (engine harn, left side of eng compt)
• S170 (i/p harness, near blower motor breakout)
• S171
• S200 (i/p harness, near radio breakout)
• S229 (i/p harn, behind center of i/p)
• S231
• S240 (i/p harn, near right door jamb)
• S257 (i/p harn, near blower motor switch breakout)
• Solid state
• Temperature control potentiometer
• Warm
• Wot a/c relay (in power distribution box)

ANTI-LOCK BRAKES

Anti-lock Brake Wiring Diagrams for Ford Explorer 1997

List of elements for Anti-lock Brake Wiring Diagrams for Ford Explorer 1997:

• (left front of engine compartment, near radiator) g108
• (near breakout to 4wabs pump motor)
• (near breakout to relay module) s255
• 4wabs control module (left rear corner of engine compartment)
• 4wabs hydraulic unit (left side of engine compartment)
• 4wabs main relay
• 4wabs pump motor (left side of engine compt)
• 4wabs pump relay
• 87a
• Abs diode
• Acceleration sensor (left frame rail, under driver seat)
• Anti-lock brakes indicator
• Auxiliary relay box #1
• Brake on/off (boo) switch (on brake pedal support)
• Brake on/off sw feed
• C282
• C287
• C288
• Datalink connector (behind left side of i/p)
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 7.5a
• G-switch #1
• G-switch status
• G104 (left rear corner of engine compt, at fender apron)
• Gem iso link
• Generic electronic module (gem) (behind center of i/p)
• Ground
• Hot at all times
• Hot in run
• Hot in run or start
• Ignition
• Instrument cluster
• Interior interior fuse panel
• L fnt dump valve
• L fnt iso valve
• L fnt sensor (hi)
• L fnt sensor (lo)
• Left front dump valve
• Left front iso valve
• Left front wheel 4wabs sensor
• Motor speed sens #2
• Nca
• Pnk
• Power
• Power power distribution distribution box box
• Powertrain control module (at right kick panel)
• Pump motor rly ctrl g-switch #2
• Rear axle sensor
• Rear dump valve
• Rear iso valve
• Rear sensor (hi)
• Rear sensor (lo)
• Red/pnk
• Relay coil (-)
• Right front dump valve
• Right front iso valve
• Right front wheel 4wabs sensor
• Rt fnt dump valve
• Rt fnt iso valve
• Rt fnt sensor (hi)
• Rt fnt sensor (lo)
• S137
• S155
• S173
• S173 (near breakout to 4wabs pump motor)
• S174
• S212
• S213
• S601
• Tan
• Tan/ red
• Tan/red
• Warning lamp

ANTI-THEFT

Anti-theft Wiring Diagram for Ford Explorer 1997

List of elements for Anti-theft Wiring Diagram for Ford Explorer 1997:

• "r" input
• (i/p harn, left side of i/p behind kick panel) s229
• (i/p harn, near breakout to relay module)
• (left rear of engine compt) compartment)
• (right side of i/p)
• * w/o cellular
• ** w/ cellular
• 1/2
• 3/4
• 5/6
• 7/8
• 9/0
• Ant
• Antenna
• Anti- theft hood switch (closed w/ hood open)
• Anti- theft relay (in relay module)
• Anti-theft indicator
• Bat
• Boo sw
• Brake on/off switch
• C280
• C281
• C286
• C287
• C336
• C338
• Com
• Data
• Data link connector
• Disarm
• Door ajar
• Door locks
• Electronic suspension system
• Exterior lights (tr sensor-a/t) (backup sw-m/t)
• Fuse 12 20a
• Fuse 13 15a
• Fuse 20 7.5a
• Fuse 24 10a
• G104 *
• G105 (right side of engine compt)
• G1o0 (left front of engine compt.)
• G201 **
• G412 (rear of vehicle)
• G500 (left front door)
• G600 (right front door)
• Generic electronic module (behind center of i/p)
• Ground
• Headlights system (autolamps)
• Hood sw
• Horn rly
• Horns system
• Hot at all times
• Hot in accy or run
• Hot in start
• Ig tamper
• Ign
• Ignition cylinder tamper switch
• Illumination
• Ind led
• Instrument cluster
• Int lights
• Interior fuse panel (left side of i/p)
• Keyless entry switch assembly
• Kypd illum
• Left front door disarm switch (closed if opened w/ key)
• Liftgate disarm switch (closed if opened w/key)
• Lo beam
• Lock all
• Mem 1
• Mem 2
• Memory system
• Nca
• Phone
• Power distribution box (left side of engine compt, at fender apron)
• Red
• Remote anti-theft personality module (left rear quarter panel)
• Right front door disarm switch (closed if opened w/key)
• S161
• S212 (i/p harn, near breakout to datalink connector)
• S229
• S232
• S245
• S255
• S258
• S407
• S500
• S602
• Starting/ charging system
• Strtr int
• Unlck all
• Unlck lf

BODY COMPUTER

Body Computer Wiring Diagrams (1 of 2) for Ford Explorer 1997

List of elements for Body Computer Wiring Diagrams (1 of 2) for Ford Explorer 1997:

• (early prod)
• (front)
• (front-rear)
• * central timer
• Acc delay relay ctrl
• Anti-theft system
• Battery saver relay ctrl
• Brake/run relay ctrl
• C280
• C283
• Central timer module diagnostic connector (behind center of i/p)
• Computer data lines system
• Ctm diagnostic in
• Current sense high
• Current sense low
• Defogger system
• Defrost relay ctrl
• Defrost sw in
• Diagnostic in
• Door ajar ind ctrl
• Door disarm in
• Door handle sw in
• Door locks system
• Door unlock rly ctrl
• Down in
• Engine controls system (vehicle speed sensor)
• Fasten belt ind ctrl
• Fuse 7.5a
• G100 (left front of engine compt, near radiator)
• G104 (w/o cellular phone) (left rear corner of engine compartment, at fender apron)
• G201 (w/ cellular phone) (right side of i/p)
• Generic electronic module (behind center of i/p)
• Gnd
• Hot at all times
• Hot in acc or run
• Hot in run
• Hot in start
• Ignition (acc/run)
• Ignition (run)
• Ignition (start)
• Instrument cluster system
• Interior fuse panel
• Interior lamp relay ctrl
• Interior lights system
• Interval/delay wash in
• Key in ignition sw
• Lf door ajar
• Liftgate in
• Lr door ajar in
• Memory systems
• Module connectors
• One-touch down relay ctrl
• Park sense
• Park/headlamps on in
• Power distribution system
• Power window system
• Power-battery
• Power-battery
• Rf door ajar
• Rr door ajar in
• S200
• S232
• S241
• S242
• S245
• S250 (i/p harn, in breakout to gem module)
• Seat belt warn sw in
• Signal return
• Sound tone in
• Tan/red
• Up in
• Vehicle speed sensor in
• Warning system
• Washer pump ctrl
• Wiper mode select sw
• Wiper speed ctrl
• Wiper/washer system

Body Computer Wiring Diagrams (2 of 2) for Ford Explorer 1997

List of elements for Body Computer Wiring Diagrams (2 of 2) for Ford Explorer 1997:

• (early prod)
• (i/p harn, in breakout to gem module) s251
• (i/p harn, in breakout to gem module) s252
• (i/p harn, near breakout to relay module) s255
• (rear)
• 4-high to 4-low relay ctrl
• 4-low to 4-high relay ctrl
• 4wd contact plate out
• 4x4 high range ind ctrl
• 4x4 low range ind cntrl
• 4x4 low signal input
• 4x4 mode sw in
• 4x4 mode switch
• A/t
• Air ride control in
• Anti-lock brake in
• Anti-lock brakes system
• Anti-theft system
• Anti-theft system (interior lights control)
• Brake on/off sw in
• Brake on/off switch
• C281
• C282
• Contact plate a
• Contact plate b
• Contact plate c
• Contact plate d
• Door ajar out
• Electronic shift motor transfer case
• Electronic suspension system
• Front speed sensor in
• Fuse 15a
• G203 (right kick panel)
• Generic electronic module (behind center of i/p)
• Gnd (m/t) neutral sense in (a/t)
• Hot at all times
• Illuminated entry out rear wiper down relay ctrl
• Instrument cluster system
• Interior fuse panel
• M/t
• Rear speed sensor in
• Rear wiper high
• Rear wiper low
• Rear wiper mode select in
• Rear wiper park sense
• Rear wiper up relay
• S108
• S212 (i/p harn, near breakout to datalink conn)
• Speed sensor pwr
• Tan
• Torque on demand relay (right side of i/p)
• Torque-on-demand out
• Transfer case shift relay (behind center of i/p)
• Transmission range sensor (left side of transmission)
• Wiper/washer system

COMPUTER DATA LINES

Computer Data Lines for Ford Explorer 1997

List of elements for Computer Data Lines for Ford Explorer 1997:

• (at left rear quarter panel)
• (behind left side of i/p) data link connector (dlc)
• (near breakout to relay module) s255
• 4wabs control module (left side of engine compt)
• Air bag diagnostic monitor (right side of i/p)
• Automatic ride control (arc) module (left center of i/p)
• C2000
• C280
• C283
• C297
• C336
• Dlc bus (+)
• Dlc bus (-)
• Electronic automatic temperature control (eatc) module (behind center of i/p)
• Fuse 5 10a
• G104 (left front of engine compt, near radiator)
• G104 (w/o lux) (left rear corner of engine compt)
• G201 (w/ lux) (right side of i/p)
• Generic electronic module (gem) (behind center of i/p)
• Hot at all times
• Interior fuse panel
• Powertrain control module (pcm) (mounted through cowl panel)
• Remote anti-theft personality (rap) module
• S205
• S206
• S230
• S232

CRUISE CONTROL

Cruise Control Wiring Diagram for Ford Explorer 1997

List of elements for Cruise Control Wiring Diagram for Ford Explorer 1997:

• A/t w/ high series console
• A/t w/o high series console
• Accel
• Back light
• Brake on/off (boo) switch (on brake pedal support)
• Brake press input
• Brake pressure switch (left rear corner of engine compt)
• C286
• C338
• Clutch pedal position (cpp) switch (on clutch pedal arm)
• Clutch pedal position (cpp) switch jumper (left side of i/p, taped to main harness)
• Coast
• Fuse 15a
• Fuse 7.5a
• G100 (left front of engine compt, near radiator)
• G104 (left rear corner of engine compartment, at fender apron)
• Ground
• Headlamp switch
• Horn relay (in power distri- bution box)
• Horn switches
• Hot at all times
• Hot in run
• Ignition
• Ignition cylinder tamper switch
• Indicator control
• Instrument cluster
• Interior fuse panel
• Interior lights system
• M/t
• Maxi fuse 11 20a
• Nca
• Off
• Ohms
• Power distribution box
• Remote anti-theft personality (rap) module (left rear quarter panel)
• Resume
• S113
• S134
• S156
• S157
• S168 (engine harn, near breakout to 4wabs control module)
• S212 (main harn, near breakout to data link conn)
• Set/
• Speed cont sw gnd
• Speed cont sw in
• Speed control indicator lamp
• Speed control servo/ amplifier assembly (right rear of engine compartment)
• Speed control/ horn switch assembly (in steering column assembly)
• Vehicle speed input
• Vehicle speed sensor (vss) (on transmission)

DEFOGGERS

Defogger Wiring Diagram for Ford Explorer 1997

List of elements for Defogger Wiring Diagram for Ford Explorer 1997:

• (body harn, 50 mm from breakout to instrument cluster)
• (w/ cellular phone) (right side of i/p)
• (w/o cellular phone) (left rear corner of engine compt. at fender apron)
• C280
• C283
• Defrost on/off switch
• Defrost relay control
• Defrost switch input
• Fuse 10a
• Fuse 30a
• Fuse 7.5a
• G104
• G201
• G406 (on center of liftgate)
• G500 (left front door)
• G600 (right front door)
• Generic electronic module (behind center of i/p)
• Heated rear window switch
• Hot at all times
• Hot in run
• Illum
• Interior fuse panel
• Interior lights system
• Left power/ heated mirror
• On indicator
• Power distribution box
• Rear window defrost grid
• Rear window defrost relay (behind top right side of i/p)
• Right power/ heated mirror
• S162
• S221
• S222
• S229
• S405 (body harn, near breakout to heated glass)
• S500
• S602

ELECTRONIC SUSPENSION

Electronic Suspension Wiring Diagram (1 of 2) for Ford Explorer 1997

List of elements for Electronic Suspension Wiring Diagram (1 of 2) for Ford Explorer 1997:

• (i/p harn, near breakout to inst cluster)
• (left rear corner of engine compartment, on fender apron)
• 4x4 high sig
• 4x4 low sig
• Arc accel sig
• Arc compr rly
• Arc off/on sw
• Automatic ride control (arc) module (left center of i/p)
• Automatic ride control compressor assembly (at rear of vehicle)
• Automatic ride control off/on switch (rear of vehicle)
• Automatic ride control relay
• Auxiliary relay box #3 (left rear of engine compartment)
• Brake on/off sw
• C2000
• C2001
• Comp vent sol
• Door ajar in
• Engine controls system
• Front fill sol
• Fuse 18 15a
• Fuse 3 50a
• G100 (w/o cellular phone) (left rear corner of engine compt.)
• G104
• G104 (left rear corner of engine compt, at fender apron)
• G105 (right side of engine compt)
• G1oo (left front of engine compt, near radiator)
• G200 (left kick panel)
• G201 (w/ cellular phone) (right side of i/p)
• Gnd
• Height sen power
• Hot at all times
• Iso link
• Left front shock actuator (at left front shock)
• Left rear shock actuator (at left rear shock)
• Lf height sen
• Lf shock actuator
• Lf shock pos in
• Lr shock actuator
• Lr shock pos in
• Nca
• Pcm accel sig
• Pnk
• Power (hot in run)
• Power distribution box
• Powertrain control module (pcm) (right rear of engine compt.)
• Rear fill sol
• Rear gate sol
• Rear height sen
• Red
• Rf shock actuator
• Rf shock pos in
• Right front shock actuator (at right front shock)
• Right rear shock actuator (at right rear shock)
• Rr shock actuator
• Rr shock pos in
• S153
• S157
• S159
• S230
• S232
• S247
• S253
• S351
• Steering sensor
• Steering sensor (in steering column)
• Vehicle speed sensor (on transmission)
• Vss (+)
• Warning sig

Electronic Suspension Wiring Diagram (2 of 2) for Ford Explorer 1997

List of elements for Electronic Suspension Wiring Diagram (2 of 2) for Ford Explorer 1997:

• (i/p harn, near breakout to relay module)
• 4wabs control module (left side of engine compt)
• Air bag diagnostic monitor (behind right side of i/p)
• Brake on/off switch (on brake pedal)
• C2008
• C2009
• C233
• C280
• C281
• C282
• C336
• Data link connector (behind left side of i/p)
• Front fill solenoid (left rear corner of engine compt)
• Fuse 13 15a
• Fuse 1o 7.5a
• G100 (left front of engine compt, near radiator)
• G200 (left kick panel)
• Generic electronic module (gem) (behind center of i/p)
• Hot at all times
• Hot in run
• Interior fuse panel
• Left front height sensor (at left front shock)
• Message center (in instrument panel console)
• Rear fill solenoid (on rear axle)
• Rear gate solenoid (left rear corner of vehicle)
• Rear height sensor (left rear corner of vehicle)
• Remote anti-theft personality (rap) module (left rear quarter panel)
• S160
• S212 (i/p harn, near breakout to datalink conn)
• S241
• S255
• S256 (i/p harn, near breakout to inst cluster)
• S258
• S351

ENGINE PERFORMANCE

4.0L

4.0L OHV, Engine Performance Wiring Diagrams (1 of 4) for Ford Explorer 1997

List of elements for 4.0L OHV, Engine Performance Wiring Diagrams (1 of 4) for Ford Explorer 1997:

• (near breakout for injector 3)
• (not used)
• (right kick panel)
• A/c hi press
• A/c system (wot a/c relay)
• Case gnd
• Ckp sensor (+)
• Ckp sensor (-)
• Crankshaft position sensor (lower front of engine)
• Crankshaft position sensor shield
• Data link
• Data link (+)
• Data link (-)
• Data link connector (behind left side of i/p)
• Ect sens
• Evr ctrl
• Fuel level in
• Fuel pump mon
• Fuse 25a
• Fuse 30a
• G100 (left front of engine compt. near radiator)
• G104 (left rear corner of engine compt., at fender apron)
• G203
• G203 (right kick panel)
• Ho2s 2 sig
• Hot at all times
• Hot in run or start
• Iat sens
• Ign coil
• Ign coil 1
• Ignition coil (above valve cover)
• Instrument cluster system
• Interior fuse panel
• Maf sig rtn
• Mil
• Octane adjust
• Pcm power diode
• Pcm power relay
• Power distribution box
• Powertrain control module (right side of engine compt, through cowl panel)
• Pwr gnd
• Radio noise capacitor (left of ignition coil)
• Red
• S105
• S108
• S116
• S118
• S128 (75 mm from branch to wot a/c relay)
• S137
• S157
• Spark plugs
• Tachometer
• Tachometer data link connector (near blower motor)
• Vss (-)

4.0L OHV, Engine Performance Wiring Diagrams (2 of 4) for Ford Explorer 1997

List of elements for 4.0L OHV, Engine Performance Wiring Diagrams (2 of 4) for Ford Explorer 1997:

• (100 mm from breakout for throttle position sensor)
• (405 mm from breakout to bmap sensor)
• (behind right kick panel) inertia fuel shut-off switch
• (near breakout for injector 6)
• (near breakout for instrument cluster)
• (speedometer/ odometer) vehicle speed input
• C2009
• C286
• C287
• C288
• Differential pressure feedback egr sensor (rear of engine compt.)
• Engine coolant temperature sensor (top front of engine)
• Fuel pump
• Fuel pump relay
• Fuel reset switch indicator input
• Fuel tank assembly
• Fuse 20a
• G200 (left kick panel)
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (on intake manifold)
• Malfunction indicator input
• Message center
• Nca
• Octane adjust (shorting bar) (right rear corner of engine compt.)
• Power distribution box
• Pressure transducer
• Red
• Red/pnk
• Remote anti-theft personality module
• S106 (in breakout for powertrain control module)
• S136
• S146
• S166
• S201
• S235
• S275
• Tach input
• Tachometer input
• Throttle position sensor (on throttle body)

4.0L OHV, Engine Performance Wiring Diagrams (3 of 4) for Ford Explorer 1997

List of elements for 4.0L OHV, Engine Performance Wiring Diagrams (3 of 4) for Ford Explorer 1997:

• (135 mm from branch to fuel pump relay)
• (30 mm from branch to fuel injector 4)
• (center of i/p) generic electronic module
• (near breakout to fuel injector 6)
• (near rear view mirror) compass/ outside air temperature module
• (right rear of engine compt.) speed control servo/ amplifier assembly
• (transmission) vehicle speed sensor
• A/c system (wot a/c relay)
• C283
• Canister vent solenoid (under the spare tire, between the canisters)
• Egr vacuum regulator solenoid (left side of engine)
• Fuel injectors
• Idle air control valve (left side of intake manifold)
• Red
• Red/pnk
• S123
• S124
• S167
• S168 (near breakout to 4wabs control module)
• S169 (near breakout to fuel injector 6)
• S247 (near breakout to instrument cluster)
• Tan
• Vapor management valve (left front corner of engine compt.)

4.0L OHV, Engine Performance Wiring Diagrams (4 of 4) for Ford Explorer 1997

List of elements for 4.0L OHV, Engine Performance Wiring Diagrams (4 of 4) for Ford Explorer 1997:

• (in breakout at rear of engine compartment)
• (in breakout for powertrain control module) s101
• A/c system (wot a/c relay)
• Cam pos in
• Camshaft position sensor (rear of engine)
• Camshaft position sensor shield
• Clutch pedal position switch
• Cpp
• Dpfe sens
• Evap
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pump ctrl
• Fuse 15a (mini)
• Fuse 20a (maxi)
• G100 (left front of engine compt., near radiator)
• G203 (right kick panel)
• Heated oxygen sensor 1 (on exhaust pipe)
• Heated oxygen sensor 2 (on exhaust pipe)
• Heated oxygen sensor 3 (on exhaust pipe)
• Heater ctrl
• Ho2s 1
• Ho2s 1 sig
• Ho2s 2
• Ho2s 2 sig
• Ho2s 3
• Hot at all times
• Iac sol
• Ign coil 3
• Kapwr (+)
• Maf sens in
• Mass air flow sensor (right side of of engine compt.)
• Nca
• Power
• Power distribution box
• Power gnd
• Powertrain control module (right side of engine compt, through cowl panel)
• Press trnsducr
• Pwr gnd
• Red
• Red/pnk
• Ref volt
• S105
• S108
• S113
• S142
• S179
• S180
• Shift sol 3
• Sig rtn
• Tan
• Tcc sol
• Tp sens in
• Vapor valve
• Vpwr
• Vss (+)
• Wac

4.0L SOHC, Engine Performance Wiring Diagrams (1 of 4) for Ford Explorer 1997

List of elements for 4.0L SOHC, Engine Performance Wiring Diagrams (1 of 4) for Ford Explorer 1997:

• (left front of engine compt., near radiator) g100
• (right kick panel)
• A/c hi press
• Air conditioning system (wot a/c relay)
• Air susp input
• Awd indicator
• Case gnd
• Ckp sensor (+)
• Ckp sensor (-)
• Crankshaft position sensor (lower front of engine)
• Crankshaft position sensor shield
• Data link
• Data link (+)
• Data link (-)
• Data link connector (behind left side of i/p)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Ect sens
• Electronic suspension system
• Evr ctrl
• Fuel flow rate
• Fuel level in
• Fuel pump mon
• Fuse 10a
• Fuse 25a
• Fuse 30a
• G100 (left front of engine compt. near radiator)
• G104 (left rear corner of engine compt., at fender apron)
• G203
• G203 (right kick panel)
• Ho2s 2 sig
• Hot at all times
• Hot in run
• Hot in run or start
• Iac valve
• Iat sens
• Ign coil 1
• Ign coil 2
• Ignition coil (above valve cover)
• Instrument cluster system
• Interior fuse panel
• Maf sig rtn
• Mil
• Oss
• Pcm power diode
• Pcm power relay
• Power distribution box
• Powertrain control module (right side of engine compt)
• Pwr gnd
• R n
• Radio noise capacitor (left of ignition coil)
• Red
• S105
• S108
• S116
• S118
• S128 (75 mm from branch to wot a/c relay)
• S157
• S162
• S205
• S206
• Shift sol 1
• Shift sol 2
• Shift sol 4
• Spark plugs
• Tachometer
• Tachometer data link connector (near blower motor)
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2a
• Tr4a
• Trans ctrl sw
• Trans temp
• Transmission control switch
• Vss (-)/gnd

4.0L SOHC, Engine Performance Wiring Diagrams (2 of 4) for Ford Explorer 1997

List of elements for 4.0L SOHC, Engine Performance Wiring Diagrams (2 of 4) for Ford Explorer 1997:

• (100 mm from breakout for throttle position sensor)
• (405 mm from breakout for map sensor)
• (behind right kick panel) inertia fuel shut-off switch
• (near breakout to i/p)
• (speedometer/ odometer) vehicle speed input
• 4wd "low range" ind input
• C2008
• C2009
• C286
• C287
• Differential pressure feedback egr sensor (rear of engine compt.)
• Engine coolant temperature sensor (left of throttle body)
• Fuel flow rate input
• Fuel pump
• Fuel pump relay
• Fuel reset switch indicator input
• Fuel tank assembly
• Fuse 20a
• G100 (left front of eng compt, near radiator)
• G200 (left kick panel)
• Hot at all times
• Inlet air control valve (near intake manifold)
• Instrument cluster
• Intake air temperature sensor (on intake manifold)
• Knock sensor (near intake manifold)
• Knock sensor shield 1
• Knock sensor shield 2
• Malfunction indicator input
• Message center
• Nca
• Output shaft speed sensor (left rear of transmission)
• Power distribution box
• Pressure transducer
• Red
• Red/pnk
• Remote anti-theft personality module
• S105
• S109 (near breakout for left front park/turn lamp)
• S136
• S146
• S235
• S248
• S275
• Tach input
• Tcil ground input
• Throttle position sensor (on throttle body)

4.0L SOHC, Engine Performance Wiring Diagrams (3 of 4) for Ford Explorer 1997

List of elements for 4.0L SOHC, Engine Performance Wiring Diagrams (3 of 4) for Ford Explorer 1997:

• (135 mm from branch to fuel pump relay)
• (30 mm from branch to fuel injector 4)
• (center of i/p) generic electronic module
• (left of center i/p) automatic ride control module
• (near breakout to fuel injector 6)
• (near breakout to trans. connector)
• (near rear view mirror) compass/ outside air temperature module
• (right rear of eng compt) speed control servo/ amplifier assembly
• (transmission) vehicle speed sensor
• 5r55e transmission
• Air conditioning system (wot a/c relay)
• C2008
• C283
• Canister vent solenoid (under the spare tire, between the canisters)
• Egr vacuum regulator solenoid (left side of engine)
• Electronic pressure control solenoid
• Fuel injectors
• Idle air control valve (left side of intake manifold)
• Message center
• Red
• Red/pnk
• S123
• S124
• S125
• S166
• S167
• S168 (near breakout to 4wabs control module)
• S169
• S247 (near breakout to i/p)
• Shift solenoids
• Ss1
• Ss2
• Ss3
• Ss4
• Tan
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Turbine shaft speed sensor
• Vapor management valve (left front corner of engine compt.)

4.0L SOHC, Engine Performance Wiring Diagrams (4 of 4) for Ford Explorer 1997

List of elements for 4.0L SOHC, Engine Performance Wiring Diagrams (4 of 4) for Ford Explorer 1997:

• (breakout for power- train control module)
• (in breakout to rear of engine compt)
• (left rear of transmission) overdrive drum speed sensor
• (left side of i/p, taped to harness) clutch pedal position switch jumper
• (near breakout for instrument cluster)
• (near breakout to auxiliary relay box 3)
• 270 ohms
• Air conditioning system (wot a/c relay)
• Brake on/off
• Brake on/off switch
• Cam pos in
• Camshaft position sensor (rear of engine)
• Camshaft position sensor shield
• Digital transmission range sensor (dtr sensor-a/t) (left side of transmission)
• Dpfe sens
• Epc sol
• Evap
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pump ctrl
• Fuse 15a
• Fuse 15a (mini)
• Fuse 20a (maxi)
• G100 (left front of engine compt. near radiator)
• G203 (right kick panel)
• Heated oxygen sensor 1 (on exhaust pipe)
• Heated oxygen sensor 2 (on exhaust pipe)
• Heated oxygen sensor 3 (on exhaust pipe)
• Heated oxygen sensor 4 (on exhaust pipe)
• Heater ctrl
• Ho2s 1
• Ho2s 1 sig
• Ho2s 2
• Ho2s 2 sig
• Ho2s 3
• Ho2s 4
• Ho2s 4 sig
• Hot at all times
• Iac sol
• Ign coil 3
• Interior fuse panel
• Kapwr (+)
• Knock sens
• Maf sens in
• Mass air flow sensor (right side of of engine compt.)
• Nca
• O/d drum spd
• Power
• Power distribution box
• Power gnd
• Powertrain control module (right side of engine compt.)
• Press trnsducr
• Pwr gnd
• Red
• Red/pnk
• Ref volt
• S101
• S105
• S108
• S113
• S135 (in breakout to rear of engine compt.)
• S142
• S147
• S179
• S180
• S201
• Shift sol 3
• Sig rtn
• Tan
• Tcc sol
• Tp sens in
• Tr3a
• Trans ctrl ind
• Tss
• Vapor valve
• Vpwr
• Vss (+)
• Wac

5.0L

5.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Explorer 1997

List of elements for 5.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Explorer 1997:

• (75 mm from branch to wot a/c relay)
• (left front of engine compt., near radiator) g100
• (near breakout for injector 3)
• (right kick panel)
• A/c hi press
• Air conditioning system (wot a/c relay)
• Air susp input
• Case gnd
• Ckp sensor (+)
• Ckp sensor (-)
• Crankshaft position sensor (lower front of engine)
• Crankshaft position sensor shield
• Data link
• Data link (+)
• Data link (-)
• Data link connector (behind left side of i/p)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Ect sens
• Electronic suspension system
• Evr ctrl
• Fuel flow rate
• Fuel level in
• Fuel pump mon
• Fuse 10a
• Fuse 25a
• Fuse 30a
• G100 (left front of engine compt. near radiator)
• G104 (left rear corner of engine compt., at fender apron)
• G203
• G203 (right kick panel)
• Ho2s 3 sig
• Hot at all times
• Hot in run
• Hot in run or start
• Iat sens
• Ign coil 1
• Ign coil 2
• Ignition coils 1 & 2
• Ignition coils 3 & 4
• Instrument cluster system
• Interior fuse panel
• Maf sig rtn
• Mil
• Octane adjust
• Pcm power diode
• Pcm power relay
• Power distribution box
• Powertrain control module (right side of engine compt)
• Pwr gnd
• R n
• Radio noise capacitor (left of ignition coil)
• Red
• S105
• S108
• S116
• S118
• S128
• S157
• S162
• Shift sol 1
• Shift sol 2
• Spark plugs
• Tachometer
• Tachometer data link connector (near blower motor)
• To dtr sensor (diagram 4 of 4)
• Tr1
• Tr2a
• Tr4a
• Trans ctrl sw
• Trans temp
• Transmission control switch
• Vss (-)/gnd

5.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Explorer 1997

List of elements for 5.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Explorer 1997:

• (100 mm from breakout for throttle position sensor)
• (behind right kick panel) inertia fuel shut-off switch
• (near breakout for injector 6)
• (speedometer/ odometer) vehicle speed input
• 1997.25
• C2008
• C2009
• C286
• C287
• Differential pressure feedback egr sensor (rear of engine compt.)
• Egr valve position sensor (right rear of engine)
• Engine coolant temperature sensor (top front of engine)
• Fuel flow rate input
• Fuel pump
• Fuel pump relay
• Fuel reset switch indicator input
• Fuel tank assembly
• Fuse 20a
• G200 (left kick panel)
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (downstream of cleaner assembly)
• Malfunction indicator input
• Message center
• Nca
• Octane adjust (shorting bar) (top left front of engine compt.)
• Output shaft speed sensor (left rear of transmission)
• Power distribution box
• Pressure transducer
• Red
• Red/pnk
• Remote anti-theft personality module
• S106 (in breakout for powertrain control module)
• S146
• S166
• S235
• S275
• Tach input
• Tachometer input
• Throttle position sensor (on throttle body)
• Transmission control indicator input

5.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Explorer 1997

List of elements for 5.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Explorer 1997:

• (135 mm from branch to fuel pump relay)
• (30 mm from branch to fuel injector 4)
• (center of i/p) generic electronic module
• (in breakout for powertrain control module)
• (near breakout for fuel injector 7
• (near breakout to fuel injector 6)
• (near rear view mirror) compass/ outside air temperature module
• (right rear of engine compt.) speed control servo/ amplifier assembly
• (transmission) vehicle speed sensor
• 4r70w transmission
• Air conditioning system (wot a/c relay)
• C2008
• C283
• Canister vent solenoid (under the spare tire, between the canisters
• Egr vacuum regulator solenoid (top right of engine)
• Electronic pressure control solenoid
• Fuel injectors
• Idle air control valve (top right of engine, on throttle body)
• Message center
• Red
• Red/pnk
• S101
• S117
• S123
• S124
• S167
• S168 (near breakout to 4wabs control module)
• S169
• S247 (near breakout to i/p)
• Shift solenoids
• Ss1
• Ss2
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve (left front corner of engine compt.)

5.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Explorer 1997

List of elements for 5.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Explorer 1997:

• (left side of i/p, taped to harness) clutch pedal position switch jumper
• (near breakout for instrument cluster)
• (near breakout to auxiliary relay box 3)
• (near breakout to egr valve position sensor)
• 270 ohms
• Air conditioning system (wot a/c relay)
• Brake on/off
• Brake on/off switch
• Cam pos in
• Camshaft position sensor (rear of engine)
• Camshaft position sensor shield
• Digital transmission range sensor (dtr sensor-a/t) (left side of transmission)
• Dpfe sens
• Epc sol
• Evap
• Evp sens
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuse 15a
• Fuse 20a (maxi)
• Fuse 20a (mini)
• G100 (left front of engine compt. near radiator)
• G203 (right kick panel)
• Heated oxygen sensor 1 (on exhaust pipe)
• Heated oxygen sensor 2 (on exhaust pipe)
• Heated oxygen sensor 3 (on exhaust pipe)
• Heated oxygen sensor 4 (on exhaust pipe)
• Heater ctrl
• Ho2s 1
• Ho2s 1 sig
• Ho2s 2
• Ho2s 2 sig
• Ho2s 3
• Ho2s 4
• Ho2s 4 sig
• Hot at all times
• Iac sol
• Ign coil 3
• Ign coil 4
• Interior fuse panel
• Kapwr (+)
• Maf sens in
• Mass air flow sensor (right side of of engine compt.)
• Nca
• Oss (+)
• Power
• Power distribution box
• Power gnd
• Powertrain control module (right side of engine compt)
• Press trnsducr
• Pwr gnd
• Red
• Red/pnk
• Ref volt
• S105
• S108
• S113
• S119
• S135 (in breakout to rear of engine compt.)
• S142
• S147
• S201
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr sens
• Trans ctrl ind
• Vapor valve
• Vpwr
• Vss (+)
• Wac

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Ford Explorer 1997

List of elements for Back-up Lamps Wiring Diagram for Ford Explorer 1997:

• (body harn, near liftgate washer pump motor breakout)
• (left kick panel)
• A/t w/ dtr
• A/t w/o dtr
• Backup lamp switch (left side of transmission)
• C336
• Day/night mirror/ auto lamp sensor (in rear-view mirror)
• Digital transmission range (dtr) switch (left side of transmission)
• Fuse 10a
• G200
• Hot in run
• Interior fuse panel
• Left backup lamp
• M/t
• Remote anti-theft personality module (at left rear quarter panel)
• Right backup lamp
• S162
• S235
• S302
• S307
• Transmission range (tr) switch (left side of transmission)

Exterior Lamps Wiring Diagram for Ford Explorer 1997

List of elements for Exterior Lamps Wiring Diagram for Ford Explorer 1997:

• (body harn, near left license lamp breakout)
• (body harn, near liftgate washer pump motor breakout)
• (body harn, near right stop/park lamp breakout)
• (eng harn, near left front park/ turn lamp breakout)
• (eng harn, near left front side marker lamp breakout) s177
• (eng harn, near right front side marker lamp breakout)
• (i/p harn, near relay module breakout) s244
• (left rear corner of engine compt., at fender apron) (w/o lux) g104
• (rear)
• (right side of engine compt.)
• (right side of i/p) (w/ lux)
• (right side of i/p) (w/ lux) g201
• * w/ center
• ** w/o center
• Anti-theft system
• At fender apron) (w/o lux g104
• Ballast
• Batt
• Brake on/off switch (behind steering column)
• C216
• C217
• C280
• C286
• C287
• Console
• Day/night mirror/ autolamp sensor (in rear-view mirror)
• Dimmer relay (in relay module)
• Fuse 10a
• Fuse 15a
• Fuse 7.5a
• G104 (left rear corner of engine compt., at fender apron)
• G105
• G105 (right side of engine compt.)
• G200 (left kick panel)
• G201
• G412 (rear of vehicle)
• Generic electronic module (gem) (behind center of i/p)
• Gnd
• Hazard
• Head
• Headlamp switch
• High mount stop lamp assembly
• Hot at all times
• Hot in run
• Ign (run)
• Instrument cluster
• Interior fuse panel
• Lamp out warning module (in instrument panel console)
• Lamps on
• Left front park/ turn lamps
• Left front side marker lamp
• Left license lamp
• Left stop/park lamp
• Left turn indicator
• Left turn signal lamp (rear)
• Multi-function
• Nca
• Normal
• Off
• Park
• Park lamp relay (in relay module)
• Relay ctrl
• Right front park/ turn lamps
• Right front side marker lamp
• Right license lamp
• Right stop/park lamp
• Right turn indicator
• Right turn signal lamp
• S102
• S103
• S109
• S110 (eng harn, near right front park/ turn lamp breakout)
• S161
• S178
• S229
• S230
• S235
• S267 (i/p harn, near left kick panel)
• S300
• S301
• S302
• S305
• S400
• S402
• Switch
• Trailer tow park lamp relay (in auxiliary relay box 4)
• Trailer/camper adapter circuit (stop/turn relays)
• Turn left
• Turn right
• Turn/hazard control
• Turn/hazard flasher (in steering column)
• Vehicles with job 1 date of july 29, 1996
• W/ lamp out warning
• W/ trailer tow
• W/o lamp out warning

Lamp Outage Module Wiring Diagram for Ford Explorer 1997

List of elements for Lamp Outage Module Wiring Diagram for Ford Explorer 1997:

• Brake lamp out
• C2008
• C2009
• Exterior lights circuit (brake on/off switch)
• Exterior lights circuit (park lamp relay)
• Exterior lights circuit (rear lamps)
• Fuse 7.5a
• G104 (w/o lux) (left rear corner of engine compartment, at fender apron)
• G201 (w/lux) (right side of i/p)
• Ground
• Headlamp input
• Headlamp out
• Headlamp ref
• Headlights system (interior fuse panel)
• Headlights system (left headlamp)
• Headlights system (right headlamp)
• Hot in run
• Ignition (run)
• Interior fuse panel
• L headlamp output
• Lamp out warning
• Lamp out warning module (in instrument panel console)
• Message center
• Prk lamp output
• Pwr
• R headlamp output
• R prk lamp input
• R prk lamp out
• S210
• S231
• Stop lamp input
• Stop lamp output

Trailer/Camper Adapter Wiring Diagram for Ford Explorer 1997

List of elements for Trailer/Camper Adapter Wiring Diagram for Ford Explorer 1997:

• (license lamps)
• (park lamp relay)
• 4wabs main relay (in auxiliary relay box 1)
• 87a
• Exterior lamps circuit
• Exterior lamps circuit (multi-function switch)
• Fuse 20a
• G104 (left rear corner of engine compt, at fender apron)
• G200 (left kick panel)
• Hot at all times
• License lamps
• Power distribution box
• S114
• S155
• S302
• S400
• To trailer left turn/stop lamp
• To trailer right turn/stop lamp
• To trailer tail lamps
• Trailer tow left turn/ stop relay (in auxiliary relay box #1)
• Trailer tow park lamp relay (in auxiliary relay box #4)
• Trailer tow right turn/ stop relay (in auxiliary realy box #1)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Ford Explorer 1997

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Ford Explorer 1997:

• power distribution box)
• (i/p harness, near breakout for general electronic module) s229
• (i/p harness, near breakout to i/p) s214
• (i/p harness, near breakout to radio) s200
• (i/p harness, near breakout to rear blower motor) s231
• (w/ eatc)
• (w/o eatc)
• 4x4 mode switch
• A/c compressor clutch diode
• A/c compressor clutch solenoid
• Anti-theft hood switch
• Ashtray illumination
• Automatic ride control relay
• Auxiliary power
• Auxiliary relay box #2
• Auxiliary relay box #3
• Battery
• Battery ground
• Blend door actuator
• Blower motor relay
• Brake fluid level warning switch
• C2003
• C2004
• C2009
• C228
• C276
• C283
• C286
• C287
• C288
• C291
• C297
• Cigar lighter
• Data link connector
• Dimmer module
• Electronic automatic temperature control (eatc) module
• Fog lamp switch
• G104 (left rear corner of engine compartment, at fender apron)
• G105 (right side of engine compartment)
• G201 (right side of i/p)
• Generic electronic module (gem)
• Headlamp switch
• Heated rear window switch
• Heater-a/c control assembly (w/o eatc)
• Instrument cluster
• Lamp out warning module
• Left front shock actuator
• Liftgate wiper/ washer switch
• Low washer fluid level sensor
• Message center
• Message center switch assembly
• Power antenna module
• Radio or front control unit
• Rear integrated control panel (ricp)
• Right fog lamp
• Right front shock actuator
• Right front side marker lamp
• S153 (engine harness, near breakout to
• S154 (engine harness, near breakout to
• S161 (engine harness, near breakout for anti-theft hood switch)
• S230 (i/p harness, near breakout for dlc)
• Shift lock actuator
• Steering sensor
• Torque on demand (tod) relay
• Transfer case shift relay
• Turn/ hazard flasher
• Under hood lamp
• W/ eatc only
• W/ high series console
• W/ lux
• W/ message center
• W/o high series console
• W/o lux
• W/o message center
• Washer pump motor
• Wiper motor

Ground Distribution Wiring Diagram (2 of 4) for Ford Explorer 1997

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Ford Explorer 1997:

• (early prod.)
• (engine harness, near breakout to 4wabs control module) s137
• (engine harness, near breakout to ignition control module) s155
• (late prod.)
• 4.0l sohc
• 4wabs control module
• 4wabs main relay
• 4wabs pump motor
• 4x4 mode switch
• 87a
• A/t w/o dtr
• Air bag diagnostic monitor
• Automatic ride control (arc) module
• Auxiliary relay box #1
• Auxiliary relay box #2
• Blower motor speed controller
• C2000
• C2009
• C232
• C233
• C280
• C282
• C287
• C291
• C336
• C338
• C350
• Camshaft position (cmp) sensor
• Ckp sensor shield
• Cmp sensor shield
• Data link connector
• Digital transmission range sensor
• Fuel tank assembly
• G100 (left front of engine compartment, near radiator)
• G104 (left rear corner of engine compartment, at fender apron)
• G105 (right side of engine compartment)
• G203 (right kick panel)
• Generic electronic module (gem)
• Hi-speed blower relay
• Ignition cylinder tamper switch
• Instrument cluster
• Knock sensor
• Knock sensor #2 shield
• Left fog lamp
• Left front height sensor
• Left front park/ turn lamp
• Left front side marker lamp
• Left headlamp
• Low engine oil/ temperature switch
• M/t
• Mass air flow (maf) sensor
• Memory seat module
• Message center
• Message center switch assembly
• Nca
• Pcm power relay
• Power distribution box
• Powertrain control module (pcm)
• Rear height sensor
• Rear wiper down relay
• Rear wiper up relay
• Remote anti-theft personality (rap) module
• Right front park/ turn lamp
• Right headlamp
• S102 (engine harness, 100mm from branch to left headlamp)
• S103 (engine harness, 75mm from breakout to right headlamp)
• S105 (engine harness, in breakout for pcm)
• S156 (engine harness, near breakout to auxiliary relay box #1)
• S157 (engine harness, near breakout to fuel injector #6)
• S160
• S232 (body harness, near breakout to rear window defrost relay)
• S233
• S234 (body harness, near breakout to conn c324, driver's door seat buckle)
• Speed control servo/ amplifier assembly
• Speed control/ horn switch assembly
• Trailer tow left turn/stop relay
• Trailer tow right turn/stop relay
• Transmission range sensor
• Vehicle speed sensor (vss)
• W/ dtr
• W/ eatc
• W/o eatc

Ground Distribution Wiring Diagram (3 of 4) for Ford Explorer 1997

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Ford Explorer 1997:

• (body harness, 90mm from breakout to conn c326, left rear door jamb) s235
• (body harness, near breakout to liftgate washer pump motor) s302
• 2 door
• 4 door
• 4 door only
• 4 door w/power equipment group only
• 87a
• Air ride control (arc) compressor assembly
• Auxiliary relay box #4
• Breakout to right stop/park lamp) s301
• Cargo lamp
• Compass/ outside air temperature module
• Day/night mirror/ autolamp sensor
• Door lock relay
• Door unlock relay
• Front fill solenoid
• Fuel tank assembly
• G200 (left kick panel)
• G500 (left front door, near master window control switch)
• G500 (near left front door speaker)
• G600 (near right front door speaker)
• G600 (right front door)
• G700 (left rear door)
• G700 (near left rear door lock motor)
• G800 (near right rear door lock motor)
• G800 (right rear door)
• Keyless entry switch assembly
• Left backup lamp
• Left front door courtesy lamp
• Left front door disarm switch
• Left front power door lock switch
• Left front power seat control switch
• Left front power window switch
• Left license lamp
• Left power bolster/ lumbar motor
• Left power/ heated mirror
• Left rear power window switch
• Left rear shock actuator
• Left stop/ park lamp
• Left turn signal lamp (rear)
• Liftgate lock switch
• Liftgate washer pump motor
• Master window/ door lock control switch
• Memory seat module
• Moonroof control switch
• Moonroof motor
• Nca
• Power mirror switch
• Rear fill solenoid
• Rear gate solenoid
• Right backup lamp
• Right front door courtesy lamp
• Right front door disarm switch
• Right front power door lock switch
• Right front power seat control switch
• Right front power window switch
• Right license lamp
• Right power lumbar motor
• Right power/ heated mirror
• Right rear power window switch
• Right rear shock actuator
• Right stop/ park lamp
• Right turn signal lamp (rear)
• S202 (body harness, near breakout to right vanity mirror lamp switch)
• S234 (body harness, near breakout to conn c324, in driver's seat belt buckle)
• S321 (memory seats)
• S500 (body harness, 30mm from branch for left front door lock actuator)
• S602 (body harness, near breakout for g600)
• S800 (body harness, breakout to right rear power window switch)
• Seatbelt warning switch
• Trailer tow park lamp relay
• Trailer/ camper adapter (trailer ground wire)
• W/ electronic group only
• W/ power equipment group only
• W/o power equipment group
• W/o power equipment group only

Ground Distribution Wiring Diagram (4 of 4) for Ford Explorer 1997

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Ford Explorer 1997:

• Amplifier
• C228
• Cd changer
• Front control unit
• G105 (right rear of engine compartment, on cowl panel)
• G412 (rear center of vehicle, in liftgate)
• G412 (rear of vehicle)
• High mount stop lamp
• Left liftgate ajar switch
• Liftgate disarm switch
• Liftgate wiper disable switch
• Liftgate wiper motor
• Mobil telephone transceiver
• Nca
• Rear integrated control panel (ricp)
• Remote chassis unit
• Right liftgate ajar switch
• S352 (body harness, near breakout to rear chasis unit)
• S407 (body harness, near breakout to left rear door ajar switch)
• Sub-woofer amplifier
• W/ cd changer
• W/ high series console
• W/ lux radio
• W/ power equipment group
• W/ premium sound
• W/o high series console
• W/o power equipment group

HEADLIGHTS

Headlamps Wiring Diagram, with Autolamps for Ford Explorer 1997

List of elements for Headlamps Wiring Diagram, with Autolamps for Ford Explorer 1997:

• (eng compt harn, near left front of eng compt)
• (eng compt harn, near left headlamp breakout) s112
• (i/p harn, near left kick panel) s267
• C210
• C280
• C287
• C338
• C350
• Day/night mirror/ autolamp sensor (mounted in rear view mirror)
• Day/nt mir out
• Dimmer relay
• Dimmer switch
• Exterior lights system
• Flash-to- pass switch
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse 7.5a
• G104 (left rear corner of engine compartment, at fender apron)
• G104 (left rear corner of engine compt., at fender apron)
• G105 (right side of engine compartment)
• G200 (left kick panel)
• Generic electronic module (gem) (behind center of i/p)
• Ground
• Head
• Headlamp relay
• Headlamp switch
• Headlamps circuit (w/ drl) (daytime running lamps module pin 6)
• Headlamps circuit (w/ drl) (daytime running lamps module pin 8)
• Headlamps/ fog lamps circuit
• Hi beam indicator
• Hot at all times
• Hot at all times interior fuse panel
• Hot at all times power distribution box
• Hot in start or run
• Ignition
• Instrument cluster
• Interior fuse panel
• Lamp out warning module (in instrument panel console)
• Left headlamp
• Memory seat module (below left front seat)
• Mirrors system (automatic day/night miror)
• Multi- function switch
• Off
• Park
• Park lamp relay
• Pass
• Power
• Relay module (behind center of i/p)
• Relay output
• Remote anti-theft personality (rap) module (at left rear quarter panel)
• Right headlamp
• S103
• S111
• S155
• S202
• S209
• S213
• S229
• S237
• S238
• S266 (i/p harn, near headlamp switch breakout)
• W/ drl
• W/ lamp out warning
• W/ memory seat
• W/o drl
• W/o lamp out warning
• W/o memory seat

Headlamps Wiring Diagram, with DRL for Ford Explorer 1997

List of elements for Headlamps Wiring Diagram, with DRL for Ford Explorer 1997:

• (eng compt harn, near left front of eng compt) s111
• (eng compt harn, near left headlamp breakout)
• (i/p harn, near headlamp switch breakout)
• Acc
• Battery
• Brake fluid level warning switch (mounted on left side of master cylinder)
• Brake indicator
• C210
• C216
• C287
• C288
• Daytime running lamps (drl) module (left front corner of engine compt)
• Dimmer switch
• Drl disable
• Flash-to- pass switch
• Fuse 11 20a
• Fuse 11 7.5a
• Fuse 26 10a
• Fuse 33 15a
• Fuse 4 10a
• Fuse 8 10a
• Fuse 8 15a
• G104 (left rear corner of (left rear corner of engine compt., at engine compt., at fender apron) fender apron)
• G104 (left rear corner of engine compartment, at fender apron)
• G105 (right side of engine compartment)
• Head
• Headlamp switch
• Headlamps
• Headlamps circuit (w/ autolamps)
• Headlamps/ fog lamps circuit (fog lamp relay)
• Hi beam ind feed
• Hi beam indicator
• Hot at all times
• Hot in run
• Hot in run or start
• Ign feed
• Ignition switch
• Instrument cluster
• Interior fuse panel
• Lamp out warning module (in instrument panel console)
• Left headlamp
• Lock
• Low
• Multi- function switch
• Normal
• Off
• Park
• Parking brake switch (right side of parking brake lever)
• Pass
• Power distribution box
• Right headlamp
• Run
• S103
• S112
• S115
• S153
• S155
• S176 (eng compt harn, near brake press switch breakout)
• S213
• S229
• S237
• S266
• Start
• W/ lamp out warning
• W/o lamp out warning

Headlamps/Fog Lamps Wiring Diagram, without DRL for Ford Explorer 1997

List of elements for Headlamps/Fog Lamps Wiring Diagram, without DRL for Ford Explorer 1997:

• (eng compt harn, near left front of eng compartment) s172
• (eng compt harn, near left front of eng compt) s111
• (i/p harn, near headlamp switch breakout)
• C210
• C216
• C287
• Dimmer switch
• Flash-to- pass
• Fog lamp relay
• Fog lamp switch
• Fuse 15a
• Fuse 20a
• Fuse 33 15a
• Fuse 4 10a
• Fuse 8 10a
• G104 (left rear corner of engine compartment, at fender apron)
• G104 (left rear corner of engine compt., at fender apron)
• G105 (right side of engine compartment)
• G105 (right side of engine compartment)
• Head
• Headlamp switch
• Hi beam indicator
• Hot at all times
• Illum
• Instrument cluster
• Interior fuse panel
• Interior lights system
• Lamp out warning module (in instrument panel console)
• Left fog lamp
• Left headlamp
• Multi- function switch
• Off
• Park
• Pass
• Power distribution box
• Right fog lamp
• Right headlamp
• S103
• S112 (eng compt harn, near left headlamp breakout)
• S115
• S155
• S161
• S229
• S237
• S266
• W/ fog lamps only
• W/ lamp out warning
• W/o lamp out warning

HORN

Horn Wiring Diagram for Ford Explorer 1997

List of elements for Horn Wiring Diagram for Ford Explorer 1997:

• C338
• Front of radiator support)
• G100 (left front of engine compt, near radiator)
• High pitch horn (left
• Horn relay (in power distribution box)
• Horn switches
• Hot at all times
• Ignition cylinder tamper switch
• Low pitch horn (left
• Maxi fuse 11 20a
• Nca
• Power distribution box (left fender apron)
• Remote anti-theft personality module (left rear quarter panel)
• S113
• S232
• Speed control/ horn switch assembly

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram (1 of 2) for Ford Explorer 1997

List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Ford Explorer 1997:

• "anti-theft" indicator
• "brake" indicator
• "door ajar" indicator
• "fasten seatbelt" indicator
• (4.ol)
• (5.0l)
• (center of i/p) s274
• (early prod)
• (eng compt harn, near a/c relay)
• (eng compt harn, near gem) s275
• (i/p harn, near breakout to inst cluster)
• (late prod)
• 4.0l
• 4.32k
• 4wd indicator (hi-range)
• 4wd indicator (lo-range)
• 5.0l
• Acc
• Air bag indicator
• Anti-lock brakes system
• Anti-lock indicator
• Anti-theft system
• Brake fluid level warning switch (brake fluid reservoir) low
• C286
• C287
• C288
• Charge indicator
• Check gauge
• Cruise control system
• Daytime running lamps (drl) module (left front corner of eng. compt.)
• Dc out
• Dimmer module (left side of steering column)
• Dimmer relay (in relay module, behind center of i/p)
• Engine controls system
• Engine controls system (late prod only)
• Engine coolant temperature gauge
• Engine coolant temperature sender (left front of engine)
• Engine oil pressure gauge
• Engine oil pressure switch (next to power steering pump)
• Exterior lights system
• Fuel guage
• Fuel reset switch indicator
• Fuel tank assembly
• Fuse 15a
• Fuse 7.5a
• G100 (left front of engine compt., near radiator)
• G104 (left rear corner of engine compt., at fender apron)
• G104 (w/o cellular phone) (left rear corner of engine compt., at fender apron)
• G201 (w/ cellular phone) (right side of i/p)
• Head
• Headlamp switch
• Headlights system
• Hi beam
• Hot at all times
• Hot in run or start
• Ignition switch
• Illumination lamps
• Instrument cluster
• Interior fuse panel (left side of i/p)
• Interior lights system
• Left turn
• Lock
• Malfunction indicator lamp
• Off
• Park
• Parking brake switch (on parking brake lever)
• Right turn
• Run
• S128
• S153
• S176 (eng compt harn, near breakout to brk press switch)
• S213
• S214
• S228
• S229
• S232
• S234
• S242
• S264
• S276
• Slosh module
• Speed control indicator
• Speedometer/ odometer
• Start
• Starting/charging system
• Tachometer
• Tachometer data link connector (right rear corner of engine compt)
• Transmission control indicator (tcil)
• Voltmeter
• W/ drl
• W/o drl
• Warning system

Instrument Cluster Wiring Diagram (2 of 2) for Ford Explorer 1997

List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Ford Explorer 1997:

• (arc) disable switch input
• (arc) warning input oil temp/ level sense english/metric output (gem) to message center
• (i/p harn, near breakout to instr
• 1/c2008
• 10/c2008
• 11/c2008
• 12/c2008
• 2/c2008
• 21/c2009
• 22/c2009
• 23/c2009
• 24/c2009
• 25/c2009
• 26/c2009
• 27/c2009
• 28/c2009
• 29/c2009
• 3/c2008
• 30/c2009
• 31/c2009
• 32/c2009
• 33/c2009
• 34/c2009
• 35/c2009
• 36/c2009
• 4/c2008
• 5.0l only
• 5/c2008
• 6/c2008
• 7/c2008
• 8/c2008
• 9/c2008
• Air conditioning system
• Battery
• Brake
• C2008
• C2009
• C280
• Cluster) s247
• Electronic suspension system
• Engine select
• Engine temp sense
• Fuel flow input
• Fuel flow rate output
• Fuel level input
• Fuse 10a
• Fuse 7.5a
• G100 (left front of engine compt., near radiator)
• G104 (left rear corner of engine compt., at fender apron)
• G104 (w/o cellular phone) (left rear corner of engine compt., at fender apron)
• G105 (right side of engine compt.)
• G201 (w/ cellular phone) (right side of i/p)
• Generic electronic module (behind center of i/p)
• Ground
• Head
• Hot at all times
• Hot in run
• Illumination feed
• Interior fuse panel (left side of i/p)
• Interior lights system
• Lamp out warning
• Lamp out warning module (in console)
• Low engine oil/ temperature switch (left side of engine, at oil pan)
• Low washer fluid level switch (in washer reservoir)
• Low washer fluid sense
• Message center
• Message center switch assembly
• Message center switch input
• Oil temp/ level sense
• Powertrain control module (mounted through cowl panel)
• Red
• S137
• S157
• S161
• S168 (engine compt harn, near 4wabs ctrl module)
• S209
• S231
• S233
• S241
• Sound tone request
• Speed sensor input
• Switch bank
• Switch bank
• Tach input
• Tail
• Vehicle speed sensor (right side of transmission)

Overhead Console Wiring Diagram for Ford Explorer 1997

List of elements for Overhead Console Wiring Diagram for Ford Explorer 1997:

• (left front of engine compt., front of radiator)
• Compass
• Compass/outside air temperature module
• Engine controls system (vehicle speed sensor)
• Fuse 7.5a
• G200 (left kick panel)
• Hot in run
• Interior fuse panel
• Interior lights system (courtesy lamps circuit)
• Interior lights system (instrument illumination circuit)
• Microprocessor
• Outside air temperature sensor
• S202
• S241
• Thermometer

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram for Ford Explorer 1997

List of elements for Courtesy Lamps Wiring Diagram for Ford Explorer 1997:

• (i/p harn, near left kick panel)
• Auxiliary relay box #4 (left rear of vehicle, above wheelwell)
• Bat saver rly ctrl
• Battery saver relay
• C280
• C283
• Cargo lamp
• Central timer module (ctm)/ generic electronic module (gem) (behind center of i/p)
• Compass/ outside air temperature module
• Dimmer module (left side of steering column)
• Dome lamp
• Dome lamp switch
• Fuse 27 10a
• Fuse 8 30a
• G104 (left rear corner of engine compartment, at fender apron)
• G200 (left kick panel)
• G412 (rear center of vehicle, in lifgate)
• G412 (rear of vehicle)
• G500 (left front door, near master window control switch)
• G600 (right front door)
• Glove box lamp and switch
• Hot at all times
• Int lamp rly ctrl
• Interior fuse panel
• Interior lamp relay
• Left front door ajar switch
• Left front door courtesy lamp
• Left liftgate ajar switch
• Left rear door ajar switch
• Left vanity mirror lamp/switch
• Lf door ajar input
• Liftgate disable/ajar
• Liftgate wiper disable switch (w/ power equipment group)
• Lr door ajar input
• Map lamp
• Nca
• Pnk
• Power distribution box
• Rear dome lamp
• Rear map lamp
• Relay module (behind center of i/p)
• Rf door ajar input
• Right front door ajar switch
• Right front door courtesy lamp
• Right liftgate ajar switch
• Right rear door ajar switch
• Right vanity mirror lamp/switch
• Rr door ajar input
• S104
• S203
• S234
• S238
• S246
• S302
• S322
• S407
• S500
• S602
• Underhood lamp
• W/ overhead console only
• W/ power equipment group
• W/o overhead console only

Instrument Illumination Wiring Diagram (1 of 2) for Ford Explorer 1997

List of elements for Instrument Illumination Wiring Diagram (1 of 2) for Ford Explorer 1997:

• (2-door)** (4-door)
• (3)
• (4-door) (2-door)**
• (i/p harn, near instrument cluster breakout)
• (i/p harn, behind center of i/p)
• (i/p harn, near left kick panel) s267
• (left front door harn, near left front door courtesy lamp breakout) s501
• (left rear corner of engine compt, at fender apron)
• (right side of i/p)
• ** mountaineer vehicles w/ job 1 date of april 1, 1996)
• 4x4 mode switch
• Anti-theft system
• Ashtray illum- ination
• C276
• C280
• C286
• C287
• C297
• C298
• Central timer module (ctm)/ generic electronic module (gem) (behind center of i/p)
• Clock spring
• Courtesy lamps circuit
• Day/night mirror/ autolamp sensor
• Dimmer module (left side of steering column)
• Dome lamp switch
• Door) s601
• Electronic automatic temperature control (eatc) module
• Exterior lights system
• Fog lamp switch
• Front panel illumination
• Fuse 3 15a
• Fuse 7 7.5a
• G100 (left front of engine compartment, near radiator)
• G104 (w/o lux)
• G201 (w/ lux)
• G500 (left front door, near master window control switch)
• G600 (right front door)
• G700 (near left rear door lock motor)
• G800 (near right rear door lock motor)
• Gnd
• Head
• Headlamp switch
• Heated rear window switch
• Heater-a/c control assembly illumination
• Hot at all times
• Ignition cylinder tamper switch
• Illumination
• Illumination (2)
• Instrument cluster
• Interior fuse panel
• Left front power door lock switch (2-door)
• Left front power window switch
• Left rear power window switch
• Liftgate wiper/ washer switch
• Master window/ * door lock control switch (4-door)
• Message center switch assembly
• Nca
• Off
• Park
• Park lamp relay
• Red/ (body harn, near left rear door jamb) s240
• Relay ctrl
• Relay module (behind center of i/p)
• Right front power door lock switch
• Right front power window switch
• Right rear power window switch
• S200
• S229
• S230
• S232
• S233
• S244
• S264
• S500
• S602
• S700
• S800
• Solid state
• Speed control/ horn switch assembly
• To dimmer relay (relay module) (diagram 2 of 2)
• To splice s228 (diagram 2 0f 2)
• W/ autolamps
• W/ eatc
• W/ high series console only
• W/o eatc
• W/o high series console

Instrument Illumination Wiring Diagram (2 of 2) for Ford Explorer 1997

List of elements for Instrument Illumination Wiring Diagram (2 of 2) for Ford Explorer 1997:

• (diagram 1 of 2)
• (i/p harn, near instrument cluster breakout) s228
• C2008
• C2009
• C228
• C286
• C297
• C298
• Compass/ outside air temperature module
• Dimmer relay
• Dimming indicators (power)
• Electronic automatic temperature control (eatc) module
• From dimmer module (diagram 1 of 2)
• From park lamp relay (relay module)
• From park lamp relay (relay module) (diagram 1 of 2)
• Fuse 11 7.5a
• G100 (left front of engine compt, near radiator)
• G104 (w/o lux) (left rear corner of engine compt, at fender apron)
• G105 (w/o lux radio) (right rear of engine compt, on cowl panel)
• G200 (left kick panel)
• G201 (w/ lux (right side of i/p)
• G412 (rear of vehicle)
• G412 (w/ lux radio) (rear of vehicle)
• Gnd
• Head
• Headlamp relay
• Headlamp switch
• Hot in run or start
• Instrument cluster
• Instrument illumination
• Interior fuse panel
• Message center
• Off
• Park
• Radio or front control unit
• Rear integrated control panel (ricp)
• Relay module (center of i/p)
• S200
• S202
• S208 (w/ message center)
• S213
• S230
• S233
• S252 (w/ lux radio)

MEMORY SYSTEMS

Memory System Wiring Diagrams for Ford Explorer 1997

List of elements for Memory System Wiring Diagrams for Ford Explorer 1997:

• (at left rear quarter panel)
• C335
• C338
• C350
• C351
• C352
• Entire seat
• Front height motor
• Front mtr-l
• Front of seat
• Front sensor
• Fuse 28 7.5a
• Fuse 5 30a
• Fuse 9 10a
• Fwd
• Fwd/ rwd motor
• G100 (left front of engine compt, near radiator)
• G200 (left kick panel)
• Ground
• Hall effect sensor
• Horizontal mtr-l
• Horizontal sensor
• Hot at all times
• Hot in start
• Interior fuse panel
• Left front power seat control switch
• Left front seat motor assembly
• Mem 1
• Mem 2
• Mem seat sw enable
• Mem seat sw lp drive
• Mem seat sw lp enable
• Mem seat sw postn #1
• Mem seat sw postn #2
• Mem seat sw set
• Memory seat module (below left front seat)
• Memory seat switch
• Nca
• Personality (rap) module
• Power
• Power distribution box
• Rear height motor
• Rear mtr-l
• Rear of seat
• Rear sensor
• Remote anti-theft
• Rwd
• S209
• S234
• S303
• S317
• S321
• Seats system (left power lumbar seat switch)
• Sensor +
• Sensor -
• Set
• Start

POWER ANTENNA

Power Antenna Wiring Diagram for Ford Explorer 1997

List of elements for Power Antenna Wiring Diagram for Ford Explorer 1997:

• Antenna control
• Battery
• C332
• C364
• Fuse 7.5a
• G104 (left rear corner of engine compt, at fender apron)
• G201 (right side of i/p)
• Ground
• Hot at all times
• Hot in acc or run
• Hot in start
• Ignition
• Interior fuse panel
• Mirrors system
• Nca
• Phone
• Power antenna module (right rear of vehicle)
• Power antenna motor (base of right "a" pillar)
• Radio on input
• Radio on output
• Red/ pnk
• Remote chassis unit (right rear sidewall)
• S154
• S200
• S245
• S355
• Start input
• Start signal
• W/ cellular
• W/o cellular phone

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 5) for Ford Explorer 1997

List of elements for Power Distribution Wiring Diagram (1 of 5) for Ford Explorer 1997:

• (early prod.)
• (eatc)
• (engine harness, near breakout for for fuel injector #3) s118
• (engine harness, near breakout to 4wabs control module) s115
• (engine harness, near breakout to conn c123, behind battery) s134
• (engine harness, near breakout to conn c146, left rear of engine compt) s116
• (i/p harness, in breakout to headlamp switch) s162
• (i/p harness, in breakout to ignition switch) s204
• (i/p harness, near breakout to i/p)
• (i/p harness, near breakout to i/p) s213
• (interior fuse panel)
• (late prod.)
• (late production) (early production)
• (not used)
• 4.0l & 5.0l
• 4wabs control module
• 4wabs main relay
• 5.0l
• A/t w/o dtr
• A1 (not used)
• Acc
• Air bag diagnostic monitor
• Air bag diagnostic monitor (eatc only)
• Air bag diagnostic monitor (w/o eatc)
• Automatic ride control module
• Auxiliary relay box #1 (left side of engine compt)
• Auxiliary relay box #2 (right front of engine compt)
• Backup lamp switch
• Battery
• Blend door actuator
• Blower motor relay
• Brake fluid level warning switch
• Brake pressure switch
• C122
• C2001
• C2008
• C231
• C232
• C233
• C283
• C286
• C287
• C288
• C297
• C332
• Compass/ outside air temperature module
• Day/night mirror/ autolamp sensor
• Daytime running lamps (drl) module
• Digital transmission range sensor
• Dimmer relay
• Electronic automatic temperature control (eatc) module module (eatc)
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 7.5a
• Fuse maxi 60a
• Generator/ voltage regulator
• Generic electronic module (gem)
• Heater-a/c control assembly
• Ignition coil
• Ignition switch
• Instrument cluster
• Interior fuse panel (left side of i/p)
• Lamp out warning module
• Lock
• M/t
• Message center
• Off
• Pcm power diode
• Pcm power relay
• Pnk
• Power distribution box (left side of engine compt)
• Radio noise capacitor
• Rear blower motor relay
• Rear integrated control panel (ricp)
• Rear window defrost relay
• Red
• Relay module (center of i/p)
• Run
• S141
• S211
• S240 (body harness, in breakout to conn c323, left rear door jamb)
• S241
• Shift lock actuator
• Speed control servo/ amplifier assembly
• Start
• Starter motor
• Starter relay
• Steering sensor
• To fuse 20 (diagram 4 of 5)
• To fuse 24 (diagram 4 of 5)
• To fuse 5 (power distribution box) diagram 2 of 5)
• Transmission control switch (tcs)
• Transmission range (tr) sensor
• Turn/ hazard flasher
• W/ eatc
• W/o eatc

Power Distribution Wiring Diagram (2 of 5) for Ford Explorer 1997

List of elements for Power Distribution Wiring Diagram (2 of 5) for Ford Explorer 1997:

• (body harness, in breakout for liftgate washer pump motor) s303
• (early production)
• 15a
• 20a
• 30a
• 4wabs main relay
• 4wabs pump relay
• 50a
• Accy delay relay
• Air bag diagnostic monitor
• Amplifier
• Auxiliary relay box #1 (left side of engine compt)
• Auxiliary relay box #2 (right front of engine compt)
• Auxiliary relay box #4 (left rear of vehicle, above wheel well)
• Blower motor relay
• C121
• C232
• C335
• C338
• C350
• Daytime running lamps (drl) module
• Door
• Door lock relay
• Door unlock relay
• Driver's door unlock relay
• Engine controls system
• Fog lamp relay
• From a fuse 1 (power distri- bution box) (diagram 1 of 5)
• Fuel pump relay
• Fuse
• Fuse maxi 30a
• Fuse mini 15a or 20a
• Generator/ voltage regulator
• Horn relay
• Left front power seat control switch
• Left power lumbar seat switch
• Maxi
• Memory seat module
• Mini
• Mini fuse 4 or 20a
• Nca
• Pcm power relay
• Power distribution box (left side of engine compt)
• Powertrain control module (pcm)
• Rear window defrost relay
• Rear wiper down relay
• Rear wiper up relay
• Red
• Relay module (center of i/p)
• Remote anti-theft personality (rap) module
• Remote chassis unit (radio)
• Right front power seat control switch
• Right power lumbar seat switch
• S113 (engine harness, near breakout to power distribution box)
• S114 (engine harness, near breakout to power distribution box)
• S219 (late production)
• S236 (i/p harness, near breakout to headlamp switch)
• S239 (i/p harness, near breakout to conn c213, right corner of i/p)
• S317
• Sub woofer amplifier
• To fuse 8 (power distri- bution box) (diagram 3 of 5)
• Trailer tow left turn/stop relay
• Trailer tow park lamp relay
• Trailer tow right turn/stop relay
• Transfer case shift relay
• W/ electronics group only
• W/ jbl
• W/ memory seat
• W/ power equipment group
• W/ premium sound
• W/o memory seat

Power Distribution Wiring Diagram (3 of 5) for Ford Explorer 1997

List of elements for Power Distribution Wiring Diagram (3 of 5) for Ford Explorer 1997:

• (body harness, in breakout to conn c267, left "a" pillar) s334
• (diagram 2 of 5)
• (i/p harness, near breakout for i/p) s246
• (i/p harness, near breakout to conn c291, left side of i/p) s237
• (i/p harness, near breakout to g204) s322
• (i/p harness, near breakout to relay module) s238
• 15a
• 20a
• 30a
• 50a
• Accy delay relay
• Automatic ride control (arc) off/on switch
• Automatic ride control relay
• Auxiliary relay box #1 (left side of engine compt)
• Auxiliary relay box #3 (left rear of engine compt)
• Auxiliary relay box #4 (left rear of vehicle, above wheel well)
• Battery saver relay
• C280
• Compass/ outside air temperature module
• Defogger system
• Dimmer module
• Dimmer relay
• Dimmer switch
• Exterior lights system
• Flash- to-pass switch
• From maxi d fuse 5 (power distribution box)
• Fuse 10a
• Fuse 15a
• Fuse 1oa
• Fuse 7.5a
• Generic electronic module (gem)
• Glove box lamp & switch
• Head
• Head- lamp switch
• Headlamp relay (w/ autolamps)
• Headlamp switch
• Headlights system
• Interior fuse panel (left side of i/p)
• Interior lamp relay
• Left vanity mirror lamp
• Low
• Map lamp
• Maxi fuse
• Mini fuse
• Multi- function switch
• Nca
• Off
• Park
• Park lamp relay
• Pass
• Pnk
• Power distribution box (left side of engine compt)
• Rear map lamp
• Rear wiper down relay
• Rear wiper up relay
• Relay module (center of i/p)
• Right vanity mirror lamp
• S266 (i/p harness, near breakout to headlamp switch)
• To maxi fuse 3 (power distribution box) (diagram 4 of 5)
• Transfer case shift relay
• Underhood lamp
• W/o overhead console

Power Distribution Wiring Diagram (4 of 5) for Ford Explorer 1997

List of elements for Power Distribution Wiring Diagram (4 of 5) for Ford Explorer 1997:

• (adaptive suspension)
• (body harness, near breakout power antenna module) s355
• (diagram 1 of 5)
• (engine harness, near breakout power distribution box) s163
• (i/p harness, near breakout for i/p) s245
• (other)
• A/t
• Anti-theft relay
• Auxiliary power
• Auxiliary relay box #2 (right front of engine compt)
• Brake on/off (boo) switch
• C2009
• C228
• C283
• C291
• C297
• C335
• C336
• C350
• C364
• C435
• Clutch pedal position (cpp) switch
• Clutch pedal position (cpp) switch jumper
• Data link connector
• Day/night mirror/autolamp sensor
• Electronic automatic temperature control (eatc) module
• From ignition switch
• From maxi e fuse 12 (power distribution box) (diagram 3 of 5)
• Front washer pump relay
• Fuse 10a
• Fuse 15a
• Fuse 2 (interior fuse panel) (diagram 5 of 5)
• Fuse 30a
• Fuse 7.5a
• G104 (left rear corner of engine compt. at fender apron)
• Generic electronic module (gem)
• Interior fuse panel (left side of i/p)
• Liftgate wiper/washer switch
• M/t
• Maxi fuse 60a
• Memory seat module
• Message center
• Mini fuse 30a
• Mobile telephone transceiver
• Pnk
• Power antenna module
• Power distribution box (left side of engine compt)
• Power mirror switch
• Radio or front control unit
• Red
• Relay module (center of i/p)
• Remote anti-theft/ personality (rap) module
• Remote chassis unit (radio)
• S165 (engine harness, near breakout for conn c115, left rear of engine compt)
• S200
• S209
• S212 (i/p harness, near breakout to dlc)
• S408
• Starter relay
• To fuse (interior fuse panel) (diagram 5 of 5)
• To ignition switch
• Transmission range (tr) sensor
• W/ memory seat
• W/o center console only
• W/o memory seat
• Wiper hi-lo relay
• Wiper motor
• Wiper run relay

Power Distribution Wiring Diagram (5 of 5) for Ford Explorer 1997

List of elements for Power Distribution Wiring Diagram (5 of 5) for Ford Explorer 1997:

• (i/p harness, near breakout to cd changer) s243
• (i/p harness, near breakout to radio) s242
• C228
• C283
• C288
• Cd changer
• Cigar lighter
• From brake on/off switch (diagram 4 of 5)
• From fuse (interior fuse panel) (diagram 4 of 5)
• Front control unit
• Fuse 10a
• Fuse 15a
• Fuse 7.5a
• G104 (left rear corner of engine compartment, at fender apron)
• Generic electronic module (gem)
• High mount stoplamp
• Instrument cluster
• Interior fuse panel (left side of i/p)
• Radio
• Rear blower motor relay
• Rear integrated control panel (ricp)
• S200
• Turn/hazard flasher
• W/ am/fm
• W/ premium sound

POWER DOOR LOCKS

Power Door Lock Wiring Diagram for Ford Explorer 1997

List of elements for Power Door Lock Wiring Diagram for Ford Explorer 1997:

• (520 mm from breakout 10 pin conn, inside left rear door jamb) s337
• 2 door
• 4 door
• 87a
• Auxiliary relay box #4 (left rear of vehicle, above wheelwell)
• C280
• C336
• C338
• Door lock relay
• Door unlock relay
• Driver's door unlock relay
• G200 (left kick panel)
• G500 (left front door)
• G600 (right front door)
• Generic electronic module (behind center of i/p)
• Hot at all times
• Left front door lock motor
• Left rear door lock motor
• Lifgate lock switch
• Liftgate lock motor
• Lock
• Master window/ door lock control switch
• Maxi fuse 10 30a
• Power distribution box (left side of engine compt, at fender apron)
• Remote anti-theft personality module (w/ keyless entry only) (left rear quarter panel)
• Right front door lock motor
• Right front power door lock switch
• Right rear door lock motor
• S302
• S303
• S338 (near breakout to 10 pin conn, inside left rear door jamb)
• S339 (510 mm from breakout to 10 pin conn, inside left rear door jamb)
• S340 (near break- out to 10 pin conn, inside left rear door jamb)
• S500
• S602
• Unlck
• Unlock
• W/ electronic group
• W/o electronic group

POWER MIRRORS

Photochromic Mirror Wiring Diagram for Ford Explorer 1997

List of elements for Photochromic Mirror Wiring Diagram for Ford Explorer 1997:

• (body harn, main branch to break out for liftgate washer pump motor) s307
• (left kick panel)
• A/t
• Anti-theft system (remote anti-theft personality (rap) module)
• Backup lamp switch (left side of transmission)
• Day/night mirror/ autolamp sensor (mounted in rear view mirror)
• Exterior lights
• Exterior lights system (park lamp relay)
• Fuse 10a
• Fuse 7.5a
• G200
• Hot at all times
• Hot in run
• Hot in run and start
• Interior fuse panel
• M/t
• Park/ neutral position switch (left side of transmission)
• S162
• S202
• S209
• S213
• System (backup lamps)

Power Mirror Wiring Diagram for Ford Explorer 1997

List of elements for Power Mirror Wiring Diagram for Ford Explorer 1997:

• Direct- tional switch
• Fuse 7.5a
• G500 (left front door, near master window control switch)
• Hot at all times
• Interior fuse panel
• L/r motor
• Left power mirror
• Left/ right switch
• Power antenna system
• Power mirror switch
• Red
• Right power mirror
• S500
• Up/dn motor

POWER SEATS

Power & Lumbar Seat Wiring Diagram for Ford Explorer 1997

List of elements for Power & Lumbar Seat Wiring Diagram for Ford Explorer 1997:

• Entire seat
• Front height motor
• Front of seat
• Fwd/rwd motor
• G200 (left kick panel)
• Hot at all times
• Inflate
• Left front power seat control switch
• Left front seat motor assembly
• Left lumbar air bladder
• Left power lumbar motor
• Left power lumbar seat switch
• Maxi fuse 10 30a
• Nca
• Power distribution box
• Rear height motor
• Rear of seat
• Red
• Right front power seat control switch
• Right front seat motor assembly
• Right lumbar air bladder
• Right power lumbar motor
• Right power lumbar seat switch
• Rwd fwd
• S231
• S235
• S301
• S303
• Vent

POWER TOP/SUNROOF

Power Top/Sunroof Wiring Diagrams for Ford Explorer 1997

List of elements for Power Top/Sunroof Wiring Diagrams for Ford Explorer 1997:

• (near breakout to relay module) s259
• Accy delay relay
• Accy delay relay ctrl
• Battery saver relay
• Battery saver relay ctrl
• C283
• Ccw stop sw
• Close
• Clutch
• Cw stop sw
• Fuse 10a
• G200 (left kick panel)
• Generic electronic module (behind center of i/p)
• Hot at all times
• Interior fuse panel
• Maxi fuse 10 30a
• Maxi fuse 8 30a
• Moonroof control switch
• Moonroof motor (center rear of roof)
• Nca
• Open
• Pnk
• Power distribution box
• Power windows and transmission systems
• Red
• Relay module (behind center of i/p)
• S202
• S236
• S238
• S246

POWER WINDOWS

Power Window Wiring Diagram, 2 Door for Ford Explorer 1997

List of elements for Power Window Wiring Diagram, 2 Door for Ford Explorer 1997:

• (i/p harn, near break- out to relay module) s259
• (near breakout to left power mirror) s504
• (near breakout to radio) s271
• (near breakout to radio) s272
• Accessory delay relay (in relay module)
• Accy delay
• Batt saver
• Battery saver relay (in relay module)
• C283
• Current hi
• Current low
• Down input
• Fuse 10a
• G500 (left front door)
• G600 (right front door)
• Generic elec- tronic module (behind center of i/p)
• Hot at all times
• Interior fuse panel
• Interior lights system
• Left front power window motor
• Left front power window switch
• Left front switch
• M m
• Maxi fuse 10 30a
• Maxi fuse 8 30a
• One touch dn
• One touch down relay (in relay module)
• Pnk
• Power distribution box (left side of engine compt, at fender apron)
• Power tops system
• Red
• Resistance wire (0.015 +/- 0.001 ohm)
• Right front power window motor
• Right front power window switch
• Right front switch
• S237
• S238
• S246
• S260 (near break- out to park brake switch)
• S270 (i/p harn, near breakout to relay module)
• S500
• S602
• Transmissions system
• Up input

Power Window Wiring Diagram, 4 Door for Ford Explorer 1997

List of elements for Power Window Wiring Diagram, 4 Door for Ford Explorer 1997:

• (i/p harn, near break- out to relay module) s259
• (i/p harn, near breakout to relay module) s314
• (near breakout to radio) s271
• (near breakout to radio) s272
• Accessory delay relay (in relay module)
• Accy delay
• Batt saver
• Battery saver relay (in relay module)
• C283
• Current hi
• Current low
• Down input
• Fuse 10a
• G500 (left front door)
• G600 (right front door)
• G700 (near left rear door lock motor)
• G800 (near right rear door lock motor)
• Generic elec- tronic module (behind center of i/p)
• Hot at all times
• Interior fuse panel
• Interior lights system
• Left front power window motor
• Left front switch
• Left rear power window motor
• Left rear power window switch
• Left rear switch
• Master window/ door lock control switch
• Maxi fuse 10 30a
• Maxi fuse 8 30a
• One touch dn
• One touch down relay (in relay module)
• Pnk
• Power distribution box (left side of engine compt, at fender apron)
• Power tops system
• Red
• Resistance wire (0.015 +/- 0.001 ohm)
• Right front power window motor
• Right front power window switch
• Right front switch
• Right rear power window motor
• Right rear power window switch
• Right rear switch
• S237
• S238
• S246
• S260 (near break- out to park brake switch)
• S270 (i/p harn, near breakout to relay module)
• S500
• S602
• S700
• S800
• Transmissions system
• Up input
• Window lock switch

RADIO

Base Radio for Ford Explorer 1997

List of elements for Base Radio for Ford Explorer 1997:

• Antenna
• C228
• C229
• Fuse 10a
• Fuse 7.5a
• Fused ignition
• G104 (rear of left front fender)
• G901 (right "a" pillar)
• Ground
• Hot at all times
• Hot in run or acc
• Illuminaton
• Interior fuse panel (left side of vehicle, below dash)
• Interior lights system
• L front spkr
• L rear spkr
• Left front speaker
• Left rear speaker
• Nca
• Power (b+)
• R front spkr
• R rear spkr
• Radio
• Right front speaker
• Right rear speaker
• S200
• S245

JBL System for Ford Explorer 1997

List of elements for JBL System for Ford Explorer 1997:

• Antenna
• Audio on
• C228
• C256
• C264
• C265
• C332
• C333
• C386
• C387
• C388
• Cd changer
• Cd lt sig in
• Cd lt sig out
• Cd rt sig in
• Cd rt sig out
• Cellular telephone
• Front control unit
• Fuse 10a
• Fuse 30a
• Fuse 7.5a
• Fused ignition
• G104 (rear of left front fender)
• G412 (rear of vehicle)
• Ground
• Hot at all times
• Hot in run or acc
• Hot in start
• Illulminaton
• Illumination
• In (+)
• In (-)
• Interior fuse panel (left side of vehicle, below dash)
• Interior lights system
• L front sig (+)
• L front sig (-)
• L rear sig (+)
• L rear sig (-)
• Left front speaker
• Left rear speaker
• Left sig (+)
• Left sig (-)
• Mute
• Nca
• Out (+)
• Out (-)
• Phone
• Pnk
• Pnone
• Power (b+)
• Power antenna
• Power antenna system
• Power distribution box (left side of engine compt)
• Protocol a
• Protocol b
• R front sig (+)
• R front sig (-)
• R rear sig (+)
• R rear sig (-)
• Rear integrated control panel
• Remote chassis unit (right rear side of vehicle)
• Right front speaker
• Right rear speaker
• Right sig (+)
• Right sig (-)
• S200
• S231
• S243
• S245
• S352
• S355
• Shield
• Starter signal
• Subwoofer
• Subwoofer (+)
• Subwoofer (-)
• Subwoofer amplifier (right rear side of vehicle)
• Tan
• Tape left (+)
• Tape left (-)
• Tape right (+)
• Tape right (-)

Premium Sound Radio Wiring Diagram, with CD Player for Ford Explorer 1997

List of elements for Premium Sound Radio Wiring Diagram, with CD Player for Ford Explorer 1997:

• (dash harn, near breakout to radio)
• (dash harn, near breakout to rear blower motor)
• (dash harn, near breakout to rear integrated control panel)
• (right "a" pillar) g901
• Amplifier (right rear side of vehicle)
• Antenna
• Audio on
• C2003
• C228
• C256
• C331
• C332
• Cd changer
• Cd left (+)
• Cd left (-)
• Cd right (+)
• Cd right (-)
• Fuse 10a
• Fuse 30a
• Fuse 7.5a
• Fused ignition
• G104 (rear of left front fender)
• G201 (under right side of dash)
• G901 (right "a" pillar)
• Ground
• Hot at all times
• Hot in run or acc
• Iillumination
• Illulminaton
• Interior fuse panel (left side of vehicle, below dash)
• Interior lights system
• L front (+)
• L front (-)
• L front (_)
• L front sig (+)
• L front sig (-)
• L rear (+)
• L rear (-)
• L rear sig (+)
• L rear sig (-)
• Left front speaker
• Left rear speaker
• Left sig (+)
• Left sig (-)
• Logic mute
• Nca
• Power (+)
• Power (b+)
• Power distribution box (left side of engine compt)
• Protocal a
• Protocal b
• Protocol a
• Protocol b
• R front (+)
• R front (-)
• R front sig (+)
• R front sig (-)
• R rear (+)
• R rear (-)
• R rear sig (+)
• R rear sig (-)
• Radio
• Rear integrated control panel
• Right front speaker
• Right rear speaker
• Right sig (+)
• Right sig (-)
• S200
• S231
• S243
• S245
• S277
• S278
• S279
• S280
• S281
• Shield
• Tan

Premium Sound Radio Wiring Diagram, without CD Player for Ford Explorer 1997

List of elements for Premium Sound Radio Wiring Diagram, without CD Player for Ford Explorer 1997:

• (right "a" pillar) g901
• Amplifier (right rear side of vehicle)
• Antenna
• C228
• C256
• C332
• Fuse 10a
• Fuse 30a
• Fuse 7.5a
• Fused ignition
• G104 (rear of left front fender)
• G901 (right "a" pillar)
• Ground
• Hot at all times
• Hot in run or acc
• Illulminaton
• Interior fuse panel (left side of vehicle, below dash)
• Interior lights system
• L front (+)
• L front (-)
• L front (_)
• L front sig (+)
• L front sig (-)
• L rear (+)
• L rear (-)
• L rear sig (+)
• L rear sig (-)
• Left front speaker
• Left rear speaker
• Logic mute
• Nca
• Power (b+)
• Power distribution box (left side of engine compt)
• R front (+)
• R front (-)
• R front sig (+)
• R front sig (-)
• R rear (+)
• R rear (-)
• R rear sig (+)
• R rear sig (-)
• Radio
• Right front speaker
• Right rear speaker
• S200
• S245
• Shield

SHIFT INTERLOCKS

Shift Interlock Wiring Diagram for Ford Explorer 1997

List of elements for Shift Interlock Wiring Diagram for Ford Explorer 1997:

• Brake on/ off switch (behind steering column)
• Connector)
• Exterior lights system
• Fuse 10 7.5a
• Fuse 13 15a
• G201 (right side of i/p)
• Hot at all times
• Hot in run
• Interior fuse panel (below left side of i/p)
• S230
• S241
• Shift lock actuator (in steering column)
• Solid state

STARTING/CHARGING

Charging Wiring Diagram for Ford Explorer 1997

List of elements for Charging Wiring Diagram for Ford Explorer 1997:

• 4.0l only
• Battery
• Battery ground
• C120
• C121
• C122
• C126
• C128
• C288
• Charge warning lamp
• Fuse 7.5a
• Generator/ voltage regulator
• Hot in start or run
• Instru- ment cluster
• Interior fuse panel
• Mini fuse 6 15a
• Ohms
• Power distrib- ution box
• Red
• Starter motor
• Starter relay (left fender apron)

Starting Wiring Diagram, A/T for Ford Explorer 1997

List of elements for Starting Wiring Diagram, A/T for Ford Explorer 1997:

• (not used) (left side of i/p)
• (w/ dtr sensor) (w/ tr sensor)
• (w/ tr sensor) (w/ dtr sensor)
• Acc
• Anti- theft relay
• Battery
• Battery ground
• C112 c176
• C126
• C176 c112
• C338
• C364
• Charging circuit
• Clutch pedal position (ccp) switch jumper (left of i/p)
• Digital transmission range (dtr) sensor/ transmission range (tr) sensor (left side of trans selector/ left side of trans)
• Fuse 10a
• Fuse 7.5a
• Ignition switch
• Interior fuse panel
• Lock
• Maxi fuse 14 60a
• Off
• Pnk
• Power antenna module (left rear of vehicle)
• Power distri- bution box
• Red
• Relay module (center of i/p)
• Remote anti-theft personality (rap) module (left rear quarter panel)
• Remote chassis unit (radio)
• Run
• S165
• S204
• Start
• Starter motor (left front of engine compt)
• Starter relay (at left front fender apron)
• W/ hi series console
• W/ rap module
• W/o hi series console
• W/o rap mod- ule

Starting Wiring Diagram, M/T for Ford Explorer 1997

List of elements for Starting Wiring Diagram, M/T for Ford Explorer 1997:

• (not used) (left side of i/p)
• Acc
• Anti- theft relay
• Battery
• Battery ground
• C126
• C338
• C364
• Charging circuit
• Clutch pedal position (ccp) switch (behind left side of i/p)
• Fuse 10a
• Fuse 7.5a
• Ignition switch
• Interior fuse panel
• Lock
• Maxi fuse 14 60a
• Off
• Pnk
• Power antenna module (left rear of vehicle)
• Power distribution box
• Red
• Relay module (center of i/p)
• Remote anti-theft personality (rap) module (left rear quarter panel)
• Remote chassis unit (radio)
• Run
• S165
• S204
• Start
• Starter motor (left front of engine compt)
• Starter relay (at left front fender apron)
• W/ rap module
• W/o rap mod- ule

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Ford Explorer 1997

List of elements for Supplemental Restraint Wiring Diagram for Ford Explorer 1997:

• (i/p harn, near relay module breakout)
• (i/p harn, right side of i/p)
• * early prod mountaineer vehicles
• Air bag clock- spring assembly
• Air bag diagnostic monitor (right side of i/p)
• Air bag ind
• Air bag indicator
• C232
• C233
• C288
• Data link
• Data link connector (dlc) (behind left side of i/p)
• Driver air bag
• Drvr air bag
• Fuse 4* or 7 10a
• Fuse 7.5a
• G100 (left front of engine compt)
• Gnd
• Hot at all times
• Hot in run
• Hot in run and start
• Instrument cluster
• Interior fuse panel
• L crash sens
• Left primary crash sensor (left front of engine compartment)
• Nca
• Pass air bag
• Passenger air bag
• Power distribution box
• Pwr (bat)
• Pwr (run)
• R crash sens
• Red
• Right primary crash sensor (right front of engine compartment)
• S232 (body harn, near rear wnd def rel breakout)
• S239
• S255
• Shorting bar

TRANSMISSION

4.0L

4.0L OHV, Transmission Wiring Diagram, 5R55E for Ford Explorer 1997

List of elements for 4.0L OHV, Transmission Wiring Diagram, 5R55E for Ford Explorer 1997:

• (135 mm from branch to fuel pump relay) s123
• (at breakout to 2-pin conn at left front corner of eng compt)
• (left front of eng compt near radiator) g100
• (left front of engine compt near radiator)
• (left rear of transmission)
• (near break- out to fuel injector 6)
• (near breakout to transmission conn)
• (right kick panel)
• 5r55e automatic transmission
• Air conditioning system
• Brake on/off switch (behind steering column)
• C172
• C286
• C287
• Data link connector (partial) (behind left side of dash)
• Day/night mirror
• Digital transmission range sensor (left side of transmission)
• Dimmer relay & instrument cluster
• Electronic pressure control solenoid
• Engine controls system
• Engine controls system (ignition)
• Engine coolant temperature sensor (front of engine left of throttle body)
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 7.5a
• G100
• G203
• Heated oxygen sensors
• Horn relay (power distribution box)
• Hot at all times
• Hot in run
• Hot in run or start
• Instrument cluster
• Instrument cluster system (headlamp switch)
• Interior fuse panel
• Malfunction indicator lamp (check engine)
• Maxi fuse 20a
• Maxi fuse 30a
• O/d off indicator lamp (tcil)
• Output shaft speed sensor
• Overdrive drum speed sensor (left rear of transmission)
• Pcm power relay
• Pcm power relay diode
• Power distribution box
• Powertrain control module (through (firewall)
• R p
• Rear window defrost relay, drl module & backup lamps switch
• Red
• S101 (in break- out for pcm)
• S105
• S113
• S116
• S125
• S136 (40 cm from bmap sensor breakout)
• S137
• S147 (near breakout to auxiliary relay box 3)
• S162
• S166
• S167 (near breakout to fuel injector 6)
• S169
• S180
• S205
• S206
• S213
• Shift solenoid
• Throttle postion sensor
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Turbine shaft speed sensor
• Vehicle speed sensor (on transmission)
• Vss out

4.0L SOHC, Transmission Wiring Diagram, 5R55E for Ford Explorer 1997

List of elements for 4.0L SOHC, Transmission Wiring Diagram, 5R55E for Ford Explorer 1997:

• (135 mm from branch to fuel pump relay) s123
• (at breakout to 2-pin conn at left front corner of eng compt)
• (left front of eng compt near radiator) g100
• (left front of engine compt near radiator)
• (left rear of transmission)
• (near break- out to fuel injector 6)
• (near breakout to transmission conn)
• (right kick panel)
• 5r55e automatic transmission
• Air conditioning system
• Brake on/off switch (behind steering column)
• C172
• C286
• C287
• Data link connector (partial) (behind left side of dash)
• Day/night mirror
• Digital transmission range sensor (left side of transmission)
• Dimmer relay & instrument cluster
• Electronic pressure control solenoid
• Engine controls system
• Engine controls system (ignition)
• Engine coolant temperature sensor (front of engine left of throttle body)
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 7.5a
• G100
• G203
• Heated oxygen sensors
• Horn relay (power distribution box)
• Hot at all times
• Hot in run
• Hot in run or start
• Instrument cluster
• Instrument cluster system (headlamp switch)
• Interior fuse panel
• Malfunction indicator lamp (check engine)
• Maxi fuse 20a
• Maxi fuse 30a
• O/d off indicator lamp (tcil)
• Output shaft speed sensor
• Overdrive drum speed sensor (left rear of transmission)
• Pcm power relay
• Pcm power relay diode
• Power distribution box
• Powertrain control module (through (firewall)
• R p
• Rear window defrost relay, drl module & backup lamps switch
• Red
• S101 (in break- out for pcm)
• S105
• S113
• S116
• S125
• S136 (40 cm from bmap sensor breakout)
• S137
• S147 (near breakout to auxiliary relay box 3)
• S162
• S166
• S167 (near breakout to fuel injector 6)
• S169
• S180
• S205
• S206
• S213
• Shift solenoid
• Throttle postion sensor
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Turbine shaft speed sensor
• Vehicle speed sensor (on transmission)
• Vss out

Electronic Transfer Case Wiring Diagram for Ford Explorer 1997

List of elements for Electronic Transfer Case Wiring Diagram for Ford Explorer 1997:

• (440 mm from electronic shift motor transfer case)
• (behind center of dash) relay module
• (in break out to gem) s250
• (left side of automatic transmission)
• (near break out to instrument cluster) s248
• (near break out to relay module)
• (near breakout for instrument cluster) s246
• (near breakout to instrument cluster) s247
• (near breakout to radio)
• (near electronic transfer case)
• (w/ dtr)
• (w/ tr)
• 1.1k ohms
• 3.9k ohms
• 4x4 high range ind
• 4x4 mode switch
• 87a
• A/t
• Accy delay relay
• Anti-lock brakes system
• Battery saver relay
• Brake on/off (boo) switch (behind steering column)
• C280
• C282
• C283
• C286
• Courtesy lamps (interior lights system)
• Digital transmission range sensor (dtr)
• Door locks & power seats
• Early production mountaineer
• Electronic shift motor transfer case
• Explorer & late production
• Front speed sensor
• Fuse 10a
• Fuse 13 15a
• Fuse 20a
• Fuse 28 7.5a
• G104 (rear of left front fender)
• G201 (under right side of dash)
• G203 (right kick panel)
• Generic electronic module (behind center of dash)
• H2l
• Headlamps, interior lamps & exterior lamps systems
• Hot at all times
• Hot in start
• Illumination lamp
• Instrument cluster
• Interior fuse panel
• Interior lights system (instrument illum- ination circuit)
• L2h
• M/t
• Magnetic clutch coil
• Maxi fuse 30a
• Memory seat module
• Mode
• Mountaineer
• Ohms
• Pnk
• Power distribution box
• Power tops & power windows systems
• Rear speed sensor
• S108
• S200
• S212 (near breakout to data link conn)
• S236
• S238
• S249
• S251
• S252
• S259
• Shift motor
• Solid state
• Torque on demand relay (right side of dash)
• Transfer case shift relay (behind center of dash)
• Transmission range sensor (tr)
• Vehicle speed sensor (on transmission)
• Vss out

5.0L

5.0L, Transmission Wiring Diagram, 4R70W for Ford Explorer 1997

List of elements for 5.0L, Transmission Wiring Diagram, 4R70W for Ford Explorer 1997:

• (100 mm from breakout to throttle position sensor)
• (in breakout for powertrain control module) s101
• (in breakout to harness in line connector, rear of engine compt)
• (in breakout to harness in-line connector, rear of engine compartment)
• (left front of engine compartment, near radiator) g100
• (left rear corner of engine compartment, at fender apron) g104
• (near breakout for instrument cluster)
• (near breakout for instrument cluster) s206
• (near breakout to fuel injector 6)
• (near breakout to fuel injector 6) s166
• (power for heated oxygen sensors)
• 4r70w transmission (mounted under center of vehicle)
• 87a
• Backup lamps, rear window defrost relay
• Boo
• Brake on/off (boo) switch (behind steering column)
• C202
• C286
• C288
• Case gnd
• Data
• Data link connector (dlc) (partial) (behind left side of dash)
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls
• Engine coolant temperature (ect) sensor (mounted on front of engine, left of throttle body)
• Epc
• Fuse 11 15a
• Fuse 11 20a
• Fuse 13 15a
• Fuse 19 25a
• Fuse 2 30a
• Fuse 26 10a
• G100 (left front of engine compartment, near radiator)
• G121 (center of firewall)
• Horn relay
• Hot at all times
• Hot in run
• Hot in start or run
• Ignition coils, radio noise capacitor
• Instrument cluster
• Interior fuse panel
• Kapwr
• Malfunction indicator lamp (mil) (check engine)
• Mil
• N d
• Od off
• Oss
• Output shaft speed sensor (left rear of transmission)
• Pcm power diode
• Pcm power relay
• Power distribution box
• Powertrain control module (pcm) (mounted through firewall)
• Pwr gnd
• R p
• Red
• S105
• S113
• S116
• S123 (135 mm from breakout to fuel pump relay)
• S135
• S137
• S146
• S147 (near breakout to auxiliary box 3)
• S157
• S162
• S167
• S169
• S205
• Shift solenoids (ss)
• Sig rtn
• Ss1
• Ss2
• Tan/rg
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (attached to throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of automatic transmission)
• Vehicle speed sensor (vss) (attached to transmission)
• Vpwr
• Vref
• Vss
• W/ dtr sensor
• W/ tr sensor

Electronic Transfer Case Wiring Diagram for Ford Explorer 1997

List of elements for Electronic Transfer Case Wiring Diagram for Ford Explorer 1997:

• (440 mm from electronic shift motor transfer case)
• (behind center of dash) relay module
• (in break out to gem) s250
• (left side of automatic transmission)
• (near break out to instrument cluster) s248
• (near break out to relay module)
• (near breakout for instrument cluster) s246
• (near breakout to instrument cluster) s247
• (near breakout to radio)
• (near electronic transfer case)
• (w/ dtr)
• (w/ tr)
• 1.1k ohms
• 3.9k ohms
• 4x4 high range ind
• 4x4 mode switch
• 87a
• A/t
• Accy delay relay
• Anti-lock brakes system
• Battery saver relay
• Brake on/off (boo) switch (behind steering column)
• C280
• C282
• C283
• C286
• Courtesy lamps (interior lights system)
• Digital transmission range sensor (dtr)
• Door locks & power seats
• Early production mountaineer
• Electronic shift motor transfer case
• Explorer & late production
• Front speed sensor
• Fuse 10a
• Fuse 13 15a
• Fuse 20a
• Fuse 28 7.5a
• G104 (rear of left front fender)
• G201 (under right side of dash)
• G203 (right kick panel)
• Generic electronic module (behind center of dash)
• H2l
• Headlamps, interior lamps & exterior lamps systems
• Hot at all times
• Hot in start
• Illumination lamp
• Instrument cluster
• Interior fuse panel
• Interior lights system (instrument illum- ination circuit)
• L2h
• M/t
• Magnetic clutch coil
• Maxi fuse 30a
• Memory seat module
• Mode
• Mountaineer
• Ohms
• Pnk
• Power distribution box
• Power tops & power windows systems
• Rear speed sensor
• S108
• S200
• S212 (near breakout to data link conn)
• S236
• S238
• S249
• S251
• S252
• S259
• Shift motor
• Solid state
• Torque on demand relay (right side of dash)
• Transfer case shift relay (behind center of dash)
• Transmission range sensor (tr)
• Vehicle speed sensor (on transmission)
• Vss out

WARNING SYSTEMS

Warning System Wiring Diagrams for Ford Explorer 1997

List of elements for Warning System Wiring Diagrams for Ford Explorer 1997:

• (body harn, near left rear door ajar switch breakout)
• Battery
• C280
• C283
• Central timer module (ctm)/ generic electronic module (gem) (behind center of i/p)
• Fuse 7.5a
• G200 (left (kick panel)
• G412 (rear of vehicle)
• Head
• Headlamp switch
• Hot at all times
• Interior fuse panel
• Key in ignition
• Key warning switch (inside steering column)
• Left front door ajar switch
• Left lift- gate ajar switch (left side of lift- gate)
• Left rear door ajar switch
• Lf door ajar
• Lift- gate wiper disable switch (in lift- gate)
• Liftgate input
• Lr door ajar
• Mountaineer w/ job #1 date of 4/1/96 only
• Off
• Park
• Park lamp relay
• Park/head input
• Relay module (behind center of i/p)
• Rf door ajar
• Right front door ajar switch
• Right lift- gate ajar switch (right side of lift- gate)
• Right rear door ajar switch
• Rr door ajar
• S235
• S242
• S409
• Seat belt buckle
• Seat belt warning switch (in seat belt buckle)

WIPER/WASHER

Front Wiper/Washer Wiring Diagram for Ford Explorer 1997

List of elements for Front Wiper/Washer Wiring Diagram for Ford Explorer 1997:

• (engine harn, left rear corner of engine compt) s107
• (left rear corner of engine compt, at fender apron) g104
• (main harn, in breakout to generic electronic s250 module)
• 103k ohms
• 11.3k
• 3.3k ohms
• 4.08k
• Auxiliary relay box #2 (right front of engine compt)
• Body comp- uter system
• Brake/run
• C210
• C280
• Central timer module (ctm)/ generic electronic module (gem) (behind center of i/p)
• Front washer pump motor relay
• Fuse 10a
• Fuse 30a
• G105 (right side of engine compt)
• Hot in acc or run
• Int max
• Int min
• Interior fuse panel
• Interval delay/wash
• Liftgate wiper/ washer switch
• Multi- function switch
• Off
• Off 47.6k ohms
• Ohms
• Park
• Park sense
• Power distri- bution box (left side of engine compt)
• Red
• Run
• S104
• S161
• S163
• Signal return (gnd)
• Tan/ red
• Tan/red
• Washer pump
• Washer pump motor
• Washer switch
• Wiper hi-lo relay
• Wiper mode select
• Wiper motor
• Wiper run relay
• Wiper speed
• Wiper switch

Rear Wiper/Washer Wiring Diagram for Ford Explorer 1997

List of elements for Rear Wiper/Washer Wiring Diagram for Ford Explorer 1997:

• (near breakout to left rear door ajar switch)
• 103k ohms
• 110k ohms
• Auxiliary relay box #1 (right front of engine compt)
• Battery saver relay
• Body computer system
• C280
• C281
• C283
• Central timer module (ctm)/generic electronic module (gem) (behind i/p, left of steering column)
• Disable
• For explorer/ mountaineer w/ vehicle job #1 date of 7/29/96
• For mountaineer w/ vehicle job #1 date of 4/29/96
• Front washer pump motor relay
• Fuse 10a
• G104 (left rear corner of engine compt, at fender apron)
• G104 (w/o lux) (left rear corner of engine compartment, at fender apron)
• G200 (left kick panel)
• G201 (w/ lux) (right side of i/p)
• G412 (rear of vehicle)
• G412 (rear of vehicle, in liftgate)
• Hot at all times
• Hot in acc or run
• Illumination
• Int max
• Int min
• Interior fuse panel
• Interior lights system
• Left liftgate ajar switch
• Liftgate washer pump
• Liftgate wiper disable switch
• Liftgate wiper motor
• Liftgate wiper/ washer switch
• Maxi fuse 8 30a
• Mini fuse 2 15a
• Nca
• Off
• Park sense
• Pnk
• Power distribution box (left side of engine compt)
• Rear wiper down relay
• Rear wiper mode select
• Rear wiper up relay
• Relay module (behind center of i/p)
• Return (gnd)
• Right liftgate ajar switch
• S129
• S155
• S164
• S229
• S238
• S250 (main harness, in breakout to generic electronic module)
• S302
• S407
• S409
• Tan
• W/ power equipment group
• W/ power w/ power equipment equipment group group
• W/o power equipment group
• Washer switch
• Wiper high
• Wiper low
• Wiper park