Wiring Diagram VW NEW BEETLE 2003 - Starter inhibitor and reversing light relay
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO B | Starter |
D | Ignition/starter switch |
J226 | Starter inhibitor and reversing light relay |
J285 | Control unit with display in dash panel insert |
M17 | Reversing light bulb, right |
S15 | Fuse 15 in fuse box |
T6 | 6-pin connector, brown, coupling station electronics box, on left in plenum chamber |
T10a | 10-pin connector, grey, coupling station electronics box, on left in plenum chamber |
T32 | 32-pin connector, blue, on dash panel insert |
114 | Earth connection, in automatic gearbox wiring harness |
501 | Screw connection -2- (30), on relay plate |
A32 | Positive (+) connection (30), in dash panel wiring harness |
A40 | Positive (+) connection -1- (30), in instruments wiring harness |
A167 | Positive (+) connection -3- (30a), in dash panel wiring harness |
B182 | Connection (RF), in interior wiring harness |
* | Depends upon equipment |
Wiring Diagram VW NEW BEETLE 2003 - Automatic gearbox control unit - multifunction switch - kick-down switch
F | Brake light switch |
F125 | Multi-function switch |
J... | Engine control unit, in plenum chamber, centre |
J217 | Automatic gearbox control unit, in plenum chamber, centre |
J293 | Radiator fan control unit |
T8 | 8-pin connector |
T10 | 10-pin connector, orange, in protective housing for connectors, on left in plenum chamber |
T10a | 10-pin connector, grey, coupling station electronics box, on left in plenum chamber |
T16 | 16-pin connector, diagnostic connector |
T68 | 68-pin connector, on automatic gearbox control unit |
114 | Earth connection, in automatic gearbox wiring harness |
609 | Earth point, on right in plenum chamber |
A18 | Connection (54), in dash panel wiring harness |
A76 | Connection (diagnosis wire K), in dash panel wiring harness |
A167 | Positive (+) connection -3- (30a), in dash panel wiring harness |
* | Depends upon equipment |
** | Only models with air conditioner (compressor switch off) |
Wiring Diagram VW NEW BEETLE 2003 - Automatic gearbox control unit - solenoid valves
G93 | Gearbox oil temperature sender |
J217 | Automatic gearbox control unit, in plenum chamber, centre |
J248 | Diesel direct injection system control unit |
N88 | Solenoid valve 1 |
N89 | Solenoid valve 2 |
N90 | Solenoid valve 3 |
N91 | Solenoid valve 4 |
N92 | Solenoid valve 5 |
N93 | Solenoid valve 6 |
N94 | Solenoid valve 7 |
T12e | 12-pin connector, on gearbox |
T68 | 68-pin connector, on automatic gearbox control unit |
* | Only models with diesel engine 66 kW |
Wiring Diagram VW NEW BEETLE 2003 - Automatic gearbox control unit - gearbox speed sender - vehicle speed sender
G38 | Gearbox speed sender |
G68 | Vehicle speed sender |
J... | Engine control unit, in plenum chamber, centre |
J217 | Automatic gearbox control unit |
J285 | Control unit with display in dash panel insert |
J533 | Data bus diagnostic interface |
T2i | 2-pin connector, on gearbox |
T3l | 3-pin connector, on gearbox |
T10d | 10-pin connector, white, in protective housing for connectors, on left in plenum chamber |
T32 | 32-pin connector, blue, on dash panel insert |
T32a | 26-pin connector, green, on dash panel insert |
T68 | 68-pin connector, on automatic gearbox control unit |
A121 | Connection (high bus), in dash panel wiring harness |
A122 | Connection (low bus), in dash panel wiring harness |
Wiring Diagram VW NEW BEETLE 2003 - Automatic gearbox control unit - selector lever lock solenoid
D | Ignition/starter switch |
E1 | Light switch |
J29 | Diode |
J217 | Automatic gearbox control unit |
K142 | Selector lever position P/N warning lamp |
L101 | Selector lever display illumination |
N110 | Selector lever lock solenoid |
S7 | Fuse 7 in fuse box |
S11 | Fuse 11 in fuse box |
S231 | Fuse 31 in fuse box |
T6m | 6-pin connector, in engine compartment |
T6n | 6-pin connector, on vacuum pump for brakes |
T10a | 10-pin connector, grey, coupling station electronics box, in plenum chamber |
T68 | 68-pin connector |
V192 | Vacuum pump for brakes |
135 | Earth connection -2-, in dash panel wiring harness |
A2 | Positive (+) connection (15), in dash panel wiring harness |
A4 | Positive (+) connection (58b), in dash panel wiring harness |
A38 | Positive (+) connection -2- (15a), in dash panel wiring harness |
A53 | Positive (+) connection (53b), in dash panel wiring harness |
A70 | Connection (15a, fuse 231), in dash panel wiring harness |
B135 | Connection -1- (15a), in interior wiring harness |
U8 | Connection (15a), in automatic gearbox wiring harness |
| Vehicles with engine codes AUM, AWU, AYD, BFS, BFQ only, valid up to February 2003 |
* | ⇒ applicable engine Current Flow Diagram |
** | Depends upon equipment |
VW NEW BEETLE 2003 Overview of relay carrier
Overview of relay carrier | | | 1 - | Relay on the 13 position additional relay carrier above the relay plate |
2 - | Relay carrier in protective housing |
q | in left engine compartment |
q | not for engine code BEW |
q | Relay positions, from model year 2002 up to model year 2005 → chapter |
q | Position of relays, from model year 2006 → chapter |
3 - | Additional relay carrier |
q | in centre plenum chamber |
q | for engine code BEW only |
New Beetle | Fitting Locations | No. 802 / 2 |
|
Relay positions - relay on relay plate |
1 - | Dual tone horn relay -J4- (53) |
2 - | X-contact relief relay -J59- (100), (213) |
4 - | Fuel pump relay -J17- (409) |
4 - | Glow plug relay -J52- (103) |
q | engine codes ALH, ATD, AXR, BSW only |
5 - | Automatic intermittent wash and wipe relay -J31- (377), (192), (389) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 3 |
|
VW NEW BEETLE 2003 Relay positions on the 13 position additional relay carrier above the relay plate
Relay positions on the 13 position additional relay carrier above the relay plate |
3 - | Starter inhibitor relay, clutch pedal switch -J434- (53) |
4 - | Fog light relay -J5- (53) |
7 - | Daytime running lights change-over relay -J89- (173) |
q | daytime running lights only |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 4 |
|
8 - | Heated exterior mirror relay -J99- (53) |
q | only models with mechanical window regulator |
9 - | Alarm horn relay -J641- |
10 - | Turn signals relay for anti-theft alarm -J237- |
10 - | Radiator fan 3rd speed relay -J135- (100) |
10 - | Secondary air pump relay -J299- (100) |
q | only petrol engines, from July 2005 |
10 - | Low heat output relay -J359- (100) |
q | engine code BEW only, from June 2003 up to December 2006 |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 5 |
|
11 - | Starter inhibitor and reversing light relay -J226- (126) |
q | only for automatic gearbox 01M |
11 - | Starter inhibitor relay -J207- (176) |
q | only for 6-speed automatic gearbox 09G, with Tiptronic |
12 - | Terminal 30 voltage supply relay -J317- (109) |
q | for engine codes BPR, BPS only |
q | models with diesel engines only |
13 - | High heat output relay -J360- (53) |
q | engine code BEW only, from June 2003 up to December 2006 |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 6 |
|
VW NEW BEETLE 2003 Relay positions of relay carrier, in protective housing on left in engine compartment (from model year 2002 up to model year 2005)
Relay positions of relay carrier, in protective housing on left in engine compartment (from model year 2002 up to model year 2005) |
1 - | Secondary air pump relay -J299- (100) |
1 - | High heat output relay -J360- (100) |
2 - | Motronic current supply relay -J271- (458) |
2 - | Low heat output relay -J359- (53) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 7 |
|
VW NEW BEETLE 2003 Additional relay carrier, in centre plenum chamber (from June 2003 up to December 2006)Additional relay carrier, in centre plenum chamber (from June 2003 up to December 2006) | | | |
Pfeil - | Automatic glow period control unit -J179-, in centre plenum chamber | | | |
New Beetle | Fitting Locations | No. 802 / 8 |
|
VW NEW BEETLE 2003 Overview of relay carrier, from July 2009
Overview of relay carrier, from July 2009 |
q | Relay positions ⇒ page 802/9 |
1 - | Relay on the 13 position additional relay carrier above the relay plate |
q | Relay positions ⇒ page 802/10 |
New Beetle | Fitting Locations | No. 802 / 9 |
|
Relay positions - relay on relay plate, from July 2009 |
1 - | Dual tone horn relay -J4- (53) |
2 - | X-contact relief relay -J59- (100) |
4 - | Fuel pump relay -J17- (409) |
4 - | Glow plug relay -J52- (103) |
5 - | Automatic intermittent wash and wipe relay -J31- (377), (192) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 10 |
|
VW NEW BEETLE 2003 Relay positions on the 13 position additional relay carrier above the relay plate
Relay positions on the 13 position additional relay carrier above the relay plate |
1 - | Starter inhibitor relay, clutch pedal switch -J434- (434) |
2 - | Rear lid remote release relay -J398- (438) |
3 - | Folding exterior mirror control unit -J351- (361) |
4 - | Starter inhibitor relay, clutch pedal switch -J434- (465) |
5 - | Fuel pump relay -J17- (449) |
6 - | Radiator fan 3rd speed relay -J135- (100) |
7 - | Daytime running lights change-over relay -J89- (173) |
q | daytime running lights only |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 11 |
|
8 - | Fuel tank flap release relay -J677- (53) |
9 - | Window regulator relay -J51- (53) |
10 - | High heat output relay -J360- (100) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 12 |
|
10 - | Starter inhibitor and reversing light relay -J226- (126) |
q | only for automatic gearbox 01M |
11 - | Terminal 30 voltage supply relay -J317- (109) |
q | for engine codes BPR, BPS only |
q | models with diesel engines only |
12 - | Low heat output relay -J359- (429) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |