Wiring Diagram VW NEW BEETLE 2010 - TCS and ESP button - ABS control unit
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO A | Battery |
D | Ignition/starter switch |
E1 | Light switch |
E20 | Switches and instruments illumination regulator |
E256 | TCS and ESP button |
F9 | Handbrake warning switch |
J89 | Daytime running lights changeover relay |
J104 | ABS control unit |
J285 | Control unit in dash panel insert |
L71 | Traction control switch illumination bulb |
S9 | Fuse in relay plate fuse holder |
S178 | Fuse 6 (30) in fuse holder on battery |
S179 | Fuse 7 (30) in fuse holder on battery |
T3 | 3-pin connector, in fuse holder/battery |
T3k | 3-pin connector |
T6j | 6-pin connector |
T8 | 8-pin connector |
T9c | 9-pin connector |
T17 | 17-pin connector |
T32 | 32-pin connector |
T47a | 47-pin connector, on ABS control unit |
42 | Earth point, next to steering column |
49 | Earth point, near steering column |
81 | Earth connection 1, in dash panel wiring harness |
99 | Earth connection, in console wiring harness |
135 | Earth connection 2, in dash panel wiring harness |
A2 | Positive connection (15), in dash panel wiring harness |
A4 | Positive connection (58b), in dash panel wiring harness |
A38 | Positive connection 2 (15a), in dash panel wiring harness |
A132 | Connection (TCS/ESP), in dash panel wiring harness |
1) | applicable up to June 2007 |
2) | from July 2007 |
Wiring Diagram VW NEW BEETLE 2010 - Steering angle sender - ABS control unit - ABS hydraulic pump
G85 | Steering angle sender |
J104 | ABS control unit |
J220 | Motronic control unit |
J248 | Diesel direct injection system control unit |
N133 | Rear right ABS inlet valve |
N134 | Rear left ABS inlet valve |
N135 | Rear right ABS outlet valve |
N136 | Rear left ABS outlet valve |
S15 | Fuse in relay plate fuse holder |
T6k | 6-pin connector |
T47a | 47-pin connector, on ABS control unit |
T94 | 94-pin connector |
T121 | 121-pin connector |
V64 | ABS hydraulic pump |
501 | Screw connection 2 (30), on relay plate |
A121 | Connection (high bus), in dash panel wiring harness |
A122 | Connection (low bus), in dash panel wiring harness |
A167 | Positive connection 3 (30a), in dash panel wiring harness |
1) | applicable up to June 2007 |
2) | from July 2007 |
Wiring Diagram VW NEW BEETLE 2010 - Rear right speed sensor - front right speed sensor - rear left speed sensor - front left speed sensor - ABS control unit
G44 | Rear right speed sensor |
G45 | Front right speed sensor |
G46 | Rear left speed sensor |
G47 | Front left speed sensor |
J104 | ABS control unit |
N99 | Front right ABS inlet valve |
N100 | Front right ABS outlet valve |
N101 | Front left ABS inlet valve |
N102 | Front left ABS outlet valve |
T47a | 47-pin connector, on ABS control unit |
608 | Earth point, in centre of plenum chamber |
D146 | Connection (rear left speed sensor +), in engine compartment wiring harness |
D147 | Connection (rear left speed sensor -), in engine compartment wiring harness |
D148 | Connection (rear right speed sensor +), in engine compartment wiring harness |
D149 | Connection (rear right speed sensor -), in engine compartment wiring harness |
1) | applicable up to June 2007 |
2) | from July 2007 |
Wiring Diagram VW NEW BEETLE 2010 - Brake pressure sender 1 - ESP sensor unit - ABS control unit
F | Brake light switch |
G200 | Lateral acceleration sender |
G201 | Brake pressure sender 1 |
G202 | Yaw rate sender |
G419 | ESP sensor unit |
J104 | ABS control unit |
J220 | Motronic control unit |
J248 | Diesel direct injection system control unit |
N225 | Vehicle stabilization program switch valve 1 |
N226 | Vehicle stabilization program switch valve 2 |
N227 | Vehicle stabilization program high pressure valve 1 |
N228 | Vehicle stabilization program high pressure valve 2 |
T4y | 4-pin connector, on F |
T16 | 16-pin connector, diagnostic connector, under left steering column |
T47a | 47-pin connector, on ABS control unit |
T94 | 94-pin connector |
T121 | 121-pin connector |
A76 | Connection (diagnosis wire K), in dash panel wiring harness |
B131 | Connection (54), in interior wiring harness |
* | for models with engine codes BPR and BPS only |
** | for models with engine code BEW only 1) |
1) | applicable up to June 2007 |
2) | from July 2007 |
Wiring Diagram VW NEW BEETLE 2010 - Brake fluid level warning contact - front left brake pad wear sender - control unit in dash panel insert
F34 | Brake fluid level warning contact |
G34 | Front left brake pad wear sender |
H2 | Treble tone horn |
J285 | Control unit in dash panel insert |
J533 | Data bus diagnostic interface |
K32 | Brake pad warning lamp |
K47 | ABS warning lamp |
K118 | Brake system warning lamp |
K155 | ESP and TCS warning lamp |
M5 | Front left turn signal bulb |
T32 | 32-pin connector, blue, on dash panel insert |
T32a | 32-pin connector, green, on dash panel insert |
119 | Earth connection 1, in headlight wiring harness |
120 | Earth connection 2, in headlight wiring harness |
642 | Earth point, electronically controlled fan |
A76 | Connection (diagnosis wire K), in dash panel wiring harness |
D55 | Connection (left brake wear indicator) in engine compartment wiring harness |
D56 | Connection (left brake wear indicator) in engine compartment wiring harness |
1) | applicable up to June 2007 |
2) | from July 2007 |
VW NEW BEETLE 2010 Overview of relay carrier
Overview of relay carrier | | | 1 - | Relay on the 13 position additional relay carrier above the relay plate |
2 - | Relay carrier in protective housing |
q | in left engine compartment |
q | not for engine code BEW |
q | Relay positions, from model year 2002 up to model year 2005 → chapter |
q | Position of relays, from model year 2006 → chapter |
3 - | Additional relay carrier |
q | in centre plenum chamber |
q | for engine code BEW only |
New Beetle | Fitting Locations | No. 802 / 2 |
|
Relay positions - relay on relay plate |
1 - | Dual tone horn relay -J4- (53) |
2 - | X-contact relief relay -J59- (100), (213) |
4 - | Fuel pump relay -J17- (409) |
4 - | Glow plug relay -J52- (103) |
q | engine codes ALH, ATD, AXR, BSW only |
5 - | Automatic intermittent wash and wipe relay -J31- (377), (192), (389) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 3 |
|
VW NEW BEETLE 2010 Relay positions on the 13 position additional relay carrier above the relay plate
Relay positions on the 13 position additional relay carrier above the relay plate |
3 - | Starter inhibitor relay, clutch pedal switch -J434- (53) |
4 - | Fog light relay -J5- (53) |
7 - | Daytime running lights change-over relay -J89- (173) |
q | daytime running lights only |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 4 |
|
8 - | Heated exterior mirror relay -J99- (53) |
q | only models with mechanical window regulator |
9 - | Alarm horn relay -J641- |
10 - | Turn signals relay for anti-theft alarm -J237- |
10 - | Radiator fan 3rd speed relay -J135- (100) |
10 - | Secondary air pump relay -J299- (100) |
q | only petrol engines, from July 2005 |
10 - | Low heat output relay -J359- (100) |
q | engine code BEW only, from June 2003 up to December 2006 |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 5 |
|
11 - | Starter inhibitor and reversing light relay -J226- (126) |
q | only for automatic gearbox 01M |
11 - | Starter inhibitor relay -J207- (176) |
q | only for 6-speed automatic gearbox 09G, with Tiptronic |
12 - | Terminal 30 voltage supply relay -J317- (109) |
q | for engine codes BPR, BPS only |
q | models with diesel engines only |
13 - | High heat output relay -J360- (53) |
q | engine code BEW only, from June 2003 up to December 2006 |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 6 |
|
VW NEW BEETLE 2010 Relay positions of relay carrier, in protective housing on left in engine compartment (from model year 2002 up to model year 2005)
Relay positions of relay carrier, in protective housing on left in engine compartment (from model year 2002 up to model year 2005) |
1 - | Secondary air pump relay -J299- (100) |
1 - | High heat output relay -J360- (100) |
2 - | Motronic current supply relay -J271- (458) |
2 - | Low heat output relay -J359- (53) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 7 |
|
VW NEW BEETLE 2010 Additional relay carrier, in centre plenum chamber (from June 2003 up to December 2006)Additional relay carrier, in centre plenum chamber (from June 2003 up to December 2006) | | | |
Pfeil - | Automatic glow period control unit -J179-, in centre plenum chamber | | | |
New Beetle | Fitting Locations | No. 802 / 8 |
|
VW NEW BEETLE 2010 Overview of relay carrier, from July 2009
Overview of relay carrier, from July 2009 |
q | Relay positions ⇒ page 802/9 |
1 - | Relay on the 13 position additional relay carrier above the relay plate |
q | Relay positions ⇒ page 802/10 |
New Beetle | Fitting Locations | No. 802 / 9 |
|
Relay positions - relay on relay plate, from July 2009 |
1 - | Dual tone horn relay -J4- (53) |
2 - | X-contact relief relay -J59- (100) |
4 - | Fuel pump relay -J17- (409) |
4 - | Glow plug relay -J52- (103) |
5 - | Automatic intermittent wash and wipe relay -J31- (377), (192) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 10 |
|
VW NEW BEETLE 2010 Relay positions on the 13 position additional relay carrier above the relay plate
Relay positions on the 13 position additional relay carrier above the relay plate |
1 - | Starter inhibitor relay, clutch pedal switch -J434- (434) |
2 - | Rear lid remote release relay -J398- (438) |
3 - | Folding exterior mirror control unit -J351- (361) |
4 - | Starter inhibitor relay, clutch pedal switch -J434- (465) |
5 - | Fuel pump relay -J17- (449) |
6 - | Radiator fan 3rd speed relay -J135- (100) |
7 - | Daytime running lights change-over relay -J89- (173) |
q | daytime running lights only |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 11 |
|
8 - | Fuel tank flap release relay -J677- (53) |
9 - | Window regulator relay -J51- (53) |
10 - | High heat output relay -J360- (100) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |
New Beetle | Fitting Locations | No. 802 / 12 |
|
10 - | Starter inhibitor and reversing light relay -J226- (126) |
q | only for automatic gearbox 01M |
11 - | Terminal 30 voltage supply relay -J317- (109) |
q | for engine codes BPR, BPS only |
q | models with diesel engines only |
12 - | Low heat output relay -J359- (429) |
Note
The number in brackets behind the part designation denotes the control number on the housing. |