Wiring Diagram VW TOURAN 2016 - Fuse holder C - Diagnostic connection
SC | Fuse holder C |
SC5 | Fuse 5 on fuse holder C |
SC8 | Fuse 8 on fuse holder C |
SC35 | Fuse 35 on fuse holder C |
T16c | 16-pin connector, black |
U31 | Diagnostic connection |
44 | Earth point, lower part of left A-pillar |
238 | Earth connection 1, in interior wiring harness |
277 | Earth connection 3, in interior wiring harness |
286 | Earth connection 8, in interior wiring harness |
A1 | Positive connection (30a), in dash panel wiring harness |
A20 | Positive connection (15a), in dash panel wiring harness |
Wiring Diagram VW TOURAN 2016 - Data bus diagnostic interface - Display unit for front information display and operating unit control unit - Control unit 1 for information electronics - Reversing camera - Fuse holder B
J533 | Data bus diagnostic interface |
J685 | Display unit for front information display and operating unit control unit |
J794 | Control unit 1 for information electronics |
R189 | Reversing camera |
SB | Fuse holder B |
SB18 | Fuse 18 on fuse holder B |
T8b | 8-pin connector, black |
T10a | 10-pin connector, black |
T10k | 10-pin connector, black |
T12a | 12-pin connector, grey |
T12b | 12-pin connector, black |
T17d | 17-pin connector, blue |
T17i | 17-pin connector, blue |
T20c | 20-pin connector, red |
THK | Coupling point on rear lid |
TIUL | Coupling point in interior, below left |
238 | Earth connection 1, in interior wiring harness |
A178 | Connection (infotainment CAN bus, high), in dash panel wiring harness |
A179 | Connection (infotainment CAN bus, low), in dash panel wiring harness |
A192 | Positive connection 3 (15a) in dash panel wiring harness |
B769 | Connection 2 (CAN bus diagnosis, high), in main wiring harness |
B779 | Connection 2 (CAN bus diagnosis, low), in main wiring harness |
* | see applicable current flow diagram |
*2 | Only models with no start/stop system |
*3 | Only models with auxiliary coolant heater |
Wiring Diagram VW TOURAN 2016 - Heater and air conditioning controls - Operating and display unit for rear air conditioning system - Pressure sender for refrigerant circuit - Fresh air blower control unit - Electronically controlled damping control unit - Auxiliary heater control unit - Data bus diagnostic interface - Remote control receiver for auxiliary coolant heater - Auxiliary air heater element
EX21 | Heater and air conditioning controls |
E265 | Operating and display unit for rear air conditioning system |
G805 | Pressure sender for refrigerant circuit |
J126 | Fresh air blower control unit |
J250 | Electronically controlled damping control unit |
J364 | Auxiliary heater control unit |
J533 | Data bus diagnostic interface |
R149 | Remote control receiver for auxiliary coolant heater |
T2ce | 2-pin connector, black |
T3av | 3-pin connector, black |
T4as | 4-pin connector, black |
T6al | 6-pin connector, black |
T6p | 6-pin connector, blue |
T6v | 6-pin connector, black |
T17a | 17-pin connector, red |
T17h | 17-pin connector, black |
T17n | 17-pin connector, red |
T17s | 17-pin connector, black |
T20c | 20-pin connector, red |
T20d | 20-pin connector, black |
T47 | 47-pin connector, black |
TI | Coupling point in interior |
TIUR | Coupling point in interior, below right |
Z35 | Auxiliary air heater element |
A178 | Connection (infotainment CAN bus, high), in dash panel wiring harness |
A179 | Connection (infotainment CAN bus, low), in dash panel wiring harness |
A209 | Connection 1 (LIN bus) in dash panel wiring harness |
B663 | Connection (running gear sensors CAN bus, high), in main wiring harness |
B664 | Connection (running gear sensors CAN bus, low), in main wiring harness |
* | see applicable current flow diagram |
Wiring Diagram VW TOURAN 2016 - ABS control unit - Adaptive cruise control unit - Parking aid control unit - Power steering control unit - Data bus diagnostic interface - Control unit for cornering light and headlight range control
J104 | ABS control unit |
J428 | Adaptive cruise control unit |
J446 | Parking aid control unit |
J500 | Power steering control unit |
J533 | Data bus diagnostic interface |
J745 | Control unit for cornering light and headlight range control |
T3br | 3-pin connector, black |
T6ai | 6-pin connector, black |
T6w | 6-pin connector, black |
T8ac | 8-pin connector, black |
T17c | 17-pin connector, brown |
T17l | 17-pin connector, brown |
T26 | 26-pin connector, black |
T26b | 26-pin connector, black |
T46 | 46-pin connector, black |
TIUL | Coupling point in interior, below left |
TML | Coupling point in engine compartment, left |
B663 | Connection (running gear sensors CAN bus, high), in main wiring harness |
B664 | Connection (running gear sensors CAN bus, low), in main wiring harness |
B668 | Connection 2 (CAN bus extended high), in main wiring harness |
B669 | Connection 2 (CAN bus extended low), in main wiring harness |
B672 | Connection 1 (running gear/dash panel insert CAN bus, high), in main wiring harness |
B676 | Connection 1 (running gear/dash panel insert CAN bus, low), in main wiring harness |
* | see applicable current flow diagram |
*2 | According to equipment |
Wiring Diagram VW TOURAN 2016 - Alternator with voltage regulator - Battery monitor control unit - Data bus diagnostic interface - Mechatronic unit for dual clutch gearbox - Control unit for cornering light and headlight range control - Front left headlight - Front right headlight - DC/AC converter with socket - 12 V - 230 V
CX1 | Alternator with voltage regulator |
J367 | Battery monitor control unit |
J533 | Data bus diagnostic interface |
J743 | Mechatronic unit for dual clutch gearbox |
J745 | Control unit for cornering light and headlight range control |
MX1 | Front left headlight |
MX2 | Front right headlight |
T2bk | 2-pin connector, black |
T2fa | 2-pin connector, black |
T3ak | 3-pin connector, black |
T4an | 4-pin connector, black |
T4br | 4-pin connector, black |
T14k | 14-pin connector, black |
T14o | 14-pin connector, black |
T17c | 17-pin connector, brown |
T17l | 17-pin connector, brown |
T20c | 20-pin connector, red |
T25 | 25-pin connector, black |
T26b | 26-pin connector, black |
TIUL | Coupling point in interior, below left |
TML | Coupling point in engine compartment, left |
U13 | DC/AC converter with socket, 12 V - 230 V |
A227 | Connection 2 (LIN bus) in dash panel wiring harness |
B383 | Connection 1 (powertrain CAN bus, high), in main wiring harness |
B384 | Connection 2 (powertrain CAN bus, high), in main wiring harness |
B390 | Connection 1 (powertrain CAN bus, low), in main wiring harness |
B391 | Connection 2 (powertrain CAN bus, low), in main wiring harness |
B698 | Connection 3 (LIN bus) in main wiring harness |
C67 | Connection (CAN bus, high), in headlight wiring harness |
C68 | Connection (CAN bus, low), in headlight wiring harness |
* | see applicable current flow diagram |
*2 | see applicable current flow diagram for engine |
*3 | According to equipment |
Wiring Diagram VW TOURAN 2016 - Selector lever - NOx sender - Airbag control unit - Tyre Pressure Monitoring System control unit - Data bus diagnostic interface - Engine control unit - Lane change assist control unit - Control unit for front left belt tensioner - Control unit for front right belt tensioner
E313 | Selector lever |
G295 | NOx sender |
J234 | Airbag control unit |
J502 | Tyre Pressure Monitoring System control unit |
J533 | Data bus diagnostic interface |
J623 | Engine control unit |
J769 | Lane change assist control unit |
J854 | Control unit for front left belt tensioner |
J855 | Control unit for front right belt tensioner |
T4bk | 4-pin connector, grey |
T5o | 5-pin connector, colourless |
T5p | 5-pin connector, colourless |
T5u | 5-pin connector, black |
T8w | 8-pin connector, black |
T10n | 10-pin connector, black |
T20c | 20-pin connector, red |
T90 | 90-pin connector, yellow |
T90a | 90-pin connector, yellow |
T91a | 91-pin connector, black |
B108 | Connection 1 (CAN bus extended high), in main wiring harness |
B109 | Connection 1 (CAN bus extended low), in main wiring harness |
B383 | Connection 1 (powertrain CAN bus, high), in main wiring harness |
B384 | Connection 2 (powertrain CAN bus, high), in main wiring harness |
B390 | Connection 1 (powertrain CAN bus, low), in main wiring harness |
B391 | Connection 2 (powertrain CAN bus, low), in main wiring harness |
B710 | Connection 5 (LIN bus) in main wiring harness |
* | see applicable current flow diagram |
Wiring Diagram VW TOURAN 2016 - Interior mirror - Data bus diagnostic interface - Lane change assist control unit 2
EX5 | Interior mirror |
J533 | Data bus diagnostic interface |
J770 | Lane change assist control unit 2 |
T8t | 8-pin connector, black |
T8x | 8-pin connector, black |
T17b | 17-pin connector, black |
T17k | 17-pin connector, black |
TIUL | Coupling point in interior, below left |
B108 | Connection 1 (CAN bus extended high), in main wiring harness |
B109 | Connection 1 (CAN bus extended low), in main wiring harness |
* | see applicable current flow diagram |
*2 | According to equipment |
Wiring Diagram VW TOURAN 2016 - Data bus diagnostic interface - Rear lid control unit - Rear lid power opening control unit - Interface for entry and start system - Front camera for driver assist systems
J533 | Data bus diagnostic interface |
J605 | Rear lid control unit |
J938 | Rear lid power opening control unit |
J965 | Interface for entry and start system |
R242 | Front camera for driver assist systems |
T4bj | 4-pin connector, black |
T6r | 6-pin connector, black |
T12g | 12-pin connector, black |
T20c | 20-pin connector, red |
T32b | 32-pin connector, black |
T40 | 40-pin connector, black |
TH | Coupling point for roof |
B108 | Connection 1 (CAN bus extended high), in main wiring harness |
B109 | Connection 1 (CAN bus extended low), in main wiring harness |
B398 | Connection 2 (convenience CAN bus, high), in main wiring harness |
B407 | Connection 2 (convenience CAN bus, low), in main wiring harness |
Wiring Diagram VW TOURAN 2016 - Trailer detector control unit - Front passenger door control unit - Rear right door control unit - Data bus diagnostic interface - Rear right window regulator motor
J345 | Trailer detector control unit |
J387 | Front passenger door control unit |
J389 | Rear right door control unit |
J533 | Data bus diagnostic interface |
T10d | 10-pin connector, black |
T10o | 10-pin connector, black |
T19a | 19-pin connector, black |
T19c | 19-pin connector, black |
T20b | 20-pin connector, black |
T20f | 20-pin connector, black |
T27a | 27-pin connector, black |
T27c | 27-pin connector, black |
TTHR | Coupling point on rear right door |
TTVR | Coupling point on front right door |
V27 | Rear right window regulator motor |
B398 | Connection 2 (convenience CAN bus, high), in main wiring harness |
B407 | Connection 2 (convenience CAN bus, low), in main wiring harness |
B506 | Connection (convenience CAN bus, high), in interior wiring harness |
B507 | Connection (convenience CAN bus, low), in interior wiring harness |
* | Only models with no rear right door control unit |
*2 | Only models with rear right door control unit |
Wiring Diagram VW TOURAN 2016 - Driver door control unit - Rear left door control unit - Steering column electronics control unit - Data bus diagnostic interface - Control unit for electronic steering column lock - Dash panel insert - Rear left window regulator motor
J386 | Driver door control unit |
J388 | Rear left door control unit |
J527 | Steering column electronics control unit |
J533 | Data bus diagnostic interface |
J764 | Control unit for electronic steering column lock |
KX2 | Dash panel insert |
T4bc | 4-pin connector, black |
T10c | 10-pin connector, black |
T16e | 16-pin connector, black |
T18 | 18-pin connector, black |
T19 | 19-pin connector, black |
T19b | 19-pin connector, black |
T20 | 20-pin connector, black |
T20a | 20-pin connector, black |
T20c | 20-pin connector, red |
T27 | 27-pin connector, black |
T27b | 27-pin connector, black |
TTHL | Coupling point on rear left door |
TTVL | Coupling point on front left door |
V26 | Rear left window regulator motor |
B506 | Connection (convenience CAN bus, high), in interior wiring harness |
B507 | Connection (convenience CAN bus, low), in interior wiring harness |
* | Only models with no rear left door control unit |
*2 | Only models with rear left door control unit |
Wiring Diagram VW TOURAN 2016 - Rain and light sensor - Anti-theft alarm sensor - Alarm horn - Wiper motor control unit - Onboard supply control unit
G397 | Rain and light sensor |
G578 | Anti-theft alarm sensor |
H12 | Alarm horn |
J400 | Wiper motor control unit |
J519 | Onboard supply control unit |
T3am | 3-pin connector, black |
T3ax | 3-pin connector, black |
T4bv | 4-pin connector, black |
T4p | 4-pin connector, black |
T16 | 16-pin connector, brown |
T16g | 16-pin connector, brown |
T46b | 46-pin connector, black |
T73 | 73-pin connector, black |
T73a | 73-pin connector, black |
TH | Coupling point for roof |
* | see applicable current flow diagram |
*2 | Only left-hand drive models |
*3 | Only right-hand drive models |
VW TOURAN 2016 Overview of fuse holders
1 - | Fuse holder C -SC- |
q | Fitting location, left-hand drive models → Chapter |
q | Fitting location, right-hand drive models → Chapter |
q | Fuse assignment from September 2015 → Chapter |
2 - | Fuse holder A -SA- |
q | Fitting location → Chapter |
q | Fuse assignment from September 2015 → Chapter |
Fuse holder B -SB- |
q | Fitting location → Chapter |
q | Fuse assignment from September 2015 → Chapter |
Fitting location of fuse holder C -SC- |
Fitting location, fuse holder C -SC- , left-hand drive |
1 - | Fuse holder C -SC- |
Fuse colours for J-Case fuse: |
t | 50 A - red |
t | 40 A - green |
t | 30 A - pink |
Fuse colours for ATO flat fuse: |
t | 40 A - orange |
t | 30 A - light green |
t | 25 A - natural (white) |
t | 20 A - yellow |
t | 15 A - light blue |
t | 10 A - red |
t | 7.5 A - brown |
t | 5 A - light brown |
t | 1A - black |
Fuse colours, for mini fuses: |
t | 20 A - yellow |
t | 15 A - light blue |
t | 10 A - red |
t | 7.5 A - brown |
t | 5 A - light brown |
t | 1A - black |
|
Fitting location, fuse holder C -SC- , right-hand drive |
1 - | Fuse holder C -SC- |
Fuse colours for J-Case fuse: |
t | 50 A - red |
t | 40 A - green |
t | 30 A - pink |
Fuse colours for ATO flat fuse: |
t | 40 A - orange |
t | 30 A - light green |
t | 25 A - natural (white) |
t | 20 A - yellow |
t | 15 A - light blue |
t | 10 A - red |
t | 7.5 A - brown |
t | 5 A - light brown |
t | 1A - black |
Fuse colours, for mini fuses: |
t | 20 A - yellow |
t | 15 A - light blue |
t | 10 A - red |
t | 7.5 A - brown |
t | 5 A - light brown |
t | 1A - black |
|
Fuse assignment of fuse holder C -SC- |
Fuse assignment of fuse holder C -SC- , from September 2015 |
Slot | Current flow diagram designation | Nominal value | Function/component | Terminal | ||
SC1 | Fuse 1 on fuse holder C -SC1- | 30 A | Control unit for reducing-agent heater -J891- | 30 | ||
SC2 | Fuse 2 on fuse holder C -SC2- | 10 A | Steering column electronics control unit -J527-6) | 30 | ||
SC3 | not assigned | - | - | |||
SC4 | Fuse 4 on fuse holder C -SC4- | 10 A | Onboard supply control unit -J519-
| 30 | ||
SC5 | Fuse 5 on fuse holder C -SC5- | 5 A | Data bus diagnostic interface -J533- | 30 | ||
SC6 | Fuse 6 on fuse holder C -SC6- | 5 A | Selector lever -E313- | 30 | ||
SC7 | Fuse 7 on fuse holder C -SC7- | 10 A | Heater and air conditioning controls -EX21- | 30 | ||
Heater control unit -J65- | ||||||
Climatronic control unit -J255- | ||||||
Air conditioning system control unit -J301- | ||||||
Remote control receiver for auxiliary coolant heater -R149- | ||||||
Heated rear window relay -J9- | ||||||
Tyre Pressure Monitoring System control unit -J502- | ||||||
SC8 | Fuse 8 on fuse holder C -SC8- | 10 A | Rotary light switch -EX1- | 30 | ||
Electromechanical parking brake button -E538- | ||||||
Rain and light sensor -G397- | ||||||
Diagnostic connection -U31- | ||||||
Anti-theft alarm sensor -G578- | ||||||
SC9 | Fuse 9 on fuse holder C -SC9- | 5 A | Steering column electronics control unit -J527- | 30 | ||
SC10 | Fuse 10 on fuse holder C -SC10- | 7.5 A | Display unit for front information display and operating unit control unit -J685- | 30 | ||
TV tuner -RX6- | ||||||
SC11 | Fuse 11 on fuse holder C -SC11- | 25 A | Control unit for front left belt tensioner -J854- | 30 | ||
SC12 | Fuse 12 on fuse holder C -SC12- | 20 A | Control unit 1 for information electronics -J794- | 30 | ||
SC13 | Fuse 13 on fuse holder C -SC13- | 15 A | Electronically controlled damping control unit -J250- | 30 | ||
SC14 | Fuse 14 on fuse holder C -SC14- | 30 A | Fresh air blower control unit -J126- | 30 | ||
SC15 | Fuse 15 on fuse holder C -SC15- | 10 A | Control unit for electronic steering column lock -J764- | 30 | ||
SC16 | Fuse 16 on fuse holder C -SC16- | 7.5 A | Control unit 1 for information electronics -J794- | 30 | ||
Two-way signal amplifier for mobile telephone/data services -J984- | ||||||
Storage compartment with interface for mobile telephone -R265- | ||||||
Chip card reader -D8- | ||||||
USB hub -R293- | ||||||
SC17 | Fuse 17 on fuse holder C -SC17- | 5 A | Dash panel insert -KX2- | 30 | ||
Control unit in dash panel insert -J285- | ||||||
SC18 | Fuse 18 on fuse holder C -SC18- | 7.5 A | Reversing camera -R189- | 30 | ||
SC19 | Fuse 19 on fuse holder C -SC19- | 7.5 A | Interface for entry and start system -J965- | 30 | ||
SC20 | Fuse 20 on fuse holder C -SC20- | 7.5 A | Relay for reducing agent metering system -J963- | 30 | ||
Delivery unit for reducing agent metering system -GX19- | ||||||
SC21 | not assigned | - | - | |||
SC22 | Fuse 22 on fuse holder C -SC22- | 15 A | Trailer detector control unit -J345- | 30 | ||
SC23 | Fuse 23 on fuse holder C -SC23- | 40 A | Onboard supply control unit -J519-
| 30 | ||
SC24 | Fuse 24 on fuse holder C -SC24- | 30 A | Sliding sunroof adjustment control unit -J245- | 30 | ||
Sunroof roller blind control unit -J394- | ||||||
SC25 | Fuse 25 on fuse holder C -SC25- | 30 A | Driver door control unit -J386- 1) | 30 | ||
Rear left window regulator motor -V26- 1) | 30 | |||||
Front passenger door control unit -J387-2) | ||||||
Rear right window regulator motor -V27- 2) | ||||||
SC26 | Fuse 26 on fuse holder C -SC26- | 30 A | Onboard supply control unit -J519-
| 30 | ||
SC27 | not assigned | - | - | |||
SC28 | Fuse 28 on fuse holder C -SC28- | 25 A | Trailer detector control unit -J345- | 30 | ||
SC29 | not assigned | - | - | |||
SC30 | not assigned | - | - | |||
SC31 | Fuse 31 on fuse holder C -SC31- | 40 A | Onboard supply control unit -J519-
| 30 | ||
SC32 | Fuse 32 on fuse holder C -SC32- | 7.5 A | Front camera for driver assist systems -R242- | 15 | ||
10 A8) | Adaptive cruise control unit -J428- | |||||
Parking aid control unit -J446- | ||||||
Park assist steering control unit -J791- | ||||||
Blind Spot Monitor control unit -J1086- | ||||||
Blind Spot Monitor control unit 2 -J1087- | ||||||
SC33 | Fuse 33 on fuse holder C -SC33- | 5 A | Airbag control unit -J234- | 15 | ||
Front passenger airbag deactivated warning lamp -K145- | ||||||
SC34 | Fuse 34 on fuse holder C -SC34- | 7.5 A | Rotary light switch -EX1- | 15 | ||
Interior mirror -EX5- | ||||||
Relay for power sockets -J807- | ||||||
Reversing light switch -F4- | ||||||
Pressure sender for refrigerant circuit -G805- | ||||||
Air quality sensor -G238- | ||||||
Electromechanical parking brake button -E538- | ||||||
Auxiliary air heater element -Z35- | ||||||
SC35 | Fuse 35 on fuse holder C -SC35- | 10 A | Diagnostic connection -U31- | 15 | ||
Headlight range control and instrument illumination regulator -EX14- | ||||||
Control unit for cornering light and headlight range control -J745- | ||||||
Left headlight range control motor -V48- | ||||||
Right headlight range control motor -V49- | ||||||
Front left headlight -MX1- | ||||||
Front right headlight -MX2- | ||||||
SC36 | Fuse 36 on fuse holder C -SC36- | 10 A 5 A9) | Front right headlight -MX2- | 15 | ||
Control unit for right daytime running light and side light -J861- | ||||||
SC37 | Fuse 37 on fuse holder C -SC37- | 10 A 5 A9) | Front left headlight -MX1- | 15 | ||
Control unit for left daytime running light and side light -J860- | ||||||
SC38 | Fuse 38 on fuse holder C -SC38- | 25 A | Trailer detector control unit -J345- | 30 | ||
SC39 | Fuse 39 on fuse holder C -SC39- | 30 A | Front passenger door control unit -J387-1) | 30 | ||
Rear right window regulator motor -V27- 1) | ||||||
Driver door control unit -J386- 2) | ||||||
Rear left window regulator motor -V26- 2) | ||||||
SC404), 5) | Fuse 40 on fuse holder C -SC40- | 20 A | Cigarette lighter -U1- 3) | 154) / 305) | ||
12 V socket -U5- | ||||||
12 V socket 2 -U18- | ||||||
12 V socket 3 -U19- | ||||||
SC41 | Fuse 41 on fuse holder C -SC41- | 25 A | Control unit for front right belt tensioner -J855- | 30 | ||
SC42 | Fuse 42 on fuse holder C -SC42- | 40 A | Onboard supply control unit -J519-
| 30 | ||
SC43 | Fuse 43 on fuse holder C -SC43- | 30 A | Onboard supply control unit -J519- | 30 | ||
SC44 | Fuse 44 on fuse holder C -SC44- | 15 A | Trailer detector control unit -J345- | 30 | ||
SC45 | Fuse 45 on fuse holder C -SC45- | 15 A | Driver seat lumbar support adjustment switch -E176- | 30 | ||
Massage control unit -J740- | ||||||
SC46 | Fuse 46 on fuse holder C -SC46- | 30 A | DC/AC converter with socket, 12 V - 230 V -U13- | 30 | ||
SC47 | Fuse 47 on fuse holder C -SC47- | 15 A | Rear window wiper motor -V12- | 15 | ||
SC48 | not assigned | - | - | |||
SC49 | Fuse 49 on fuse holder C -SC49- | 5 A | Clutch position sender -G476- | 15 | ||
Starter relay 1 -J906- | ||||||
Starter relay 2 -J907- | ||||||
SC50 | Fuse 50 on fuse holder C -SC50- | 40 A | Rear lid control unit -J605- | 30 | ||
SC51 | Fuse 51 on fuse holder C -SC51- | 25 A | Operating and display unit for rear air conditioning system -E265- | 30 | ||
SC52 | not assigned | - | - | |||
SC53 | Fuse 53 on fuse holder C -SC53- | 30 A | Heated rear window relay -J9- | 15 |
1) Only left-hand drive models |
2) Only right-hand drive models |
3) Smokers version |
4) Factory fitted with power supply from terminal 15 |
5) Power supply via terminal 30 possible |
6) Only models with steering wheel heating |
7) According to equipment |
8) Only models with blind spot monitor |
9) Only models with LED headlights |
Note:
The fuse SC40 is supplied via terminal 15 from the factory and can be supplied via terminal 30 by reconnecting. If a consumer is connected to the electric socket or to the cigarette lighter, ensure that the consumer is disconnected from the voltage supply when the engine is switched off to prevent the drive battery being discharged. |
Note:
|
1 - | Fuse holder B -SB- |
Fuse colours for J-Case fuse: |
t | 50 A - red |
t | 40 A - green |
t | 30 A - pink |
Fuse colours for ATO flat fuse: |
t | 40 A - orange |
t | 30 A - light green |
t | 25 A - natural (white) |
t | 20 A - yellow |
t | 15 A - light blue |
t | 10 A - red |
t | 7.5 A - brown |
t | 5 A - light brown |
t | 1A - black |
|
Fuse assignment on fuse holder B -SB- |
Fuse assignment of fuse holder B -SB- , from September 2015 |
Slot | Current flow diagram designation | Nominal value | Function/component | Terminal | ||
SB1 | Fuse 1 on fuse holder B -SB1- | 40 A | ABS control unit -J104- | 30 | ||
SB2 | Fuse 2 on fuse holder B -SB2- | 40 A | ABS control unit -J104- | 30 | ||
ABS hydraulic pump -V64- | ||||||
SB3 | Fuse 3 on fuse holder B -SB3- | 15 A 1) 30 A 2) | Engine control unit -J623- | 87 | ||
SB4 | Fuse 4 on fuse holder B -SB4- | 5 A 2) | Oil level and oil temperature sender -G266- | 87 | ||
10 A 1) | Radiator fan control unit -J293- | |||||
Relay for reducing agent metering system -J963-2) | ||||||
Activated charcoal filter solenoid valve 1 -N80-1) | ||||||
Camshaft control valve 1 -N205-1) | ||||||
Exhaust camshaft control valve 1 -N318-1) | ||||||
Valve for oil pressure control -N428-1) | ||||||
Coolant valve for cylinder head -N489- | ||||||
High heat output relay -J360-2) | ||||||
Exhaust gas recirculation cooler changeover valve -N345-2) | ||||||
Low heat output relay -J359-2) | ||||||
Charge pressure control solenoid valve -N75-2) | ||||||
SB5 | Fuse 5 on fuse holder B -SB5- | 10 A | Fuel pressure regulating valve -N276-2) | 87 | ||
Fuel metering valve -N290-2) | ||||||
Camshaft control valve 1 -N205-2) | ||||||
SB6 | Fuse 6 on fuse holder B -SB6- | 5 A | Brake light switch -F- | 87 | ||
SB7 | Fuse 7 on fuse holder B -SB7- | 10 A | Fuel pressure regulating valve -N276-1) | 87 | ||
Charge air cooling pump -V188-1) | ||||||
Valve for oil pressure control -N428-2) | ||||||
Coolant valve for cylinder head -N489-2) | ||||||
Auxiliary pump for heating -V488-2) | ||||||
Radiator blind control motor -V544-4) | ||||||
SB8 | Fuse 8 on fuse holder B -SB8- | 10 A 1) 15 A 2) | Lambda probe 1 before catalytic converter -GX10-
| 87 | ||
Lambda probe 1 after catalytic converter -GX7-
| ||||||
NOx sender -G295-2) | ||||||
SB9 | Fuse 9 on fuse holder B -SB9- | 5 A 2) | Ignition coil 1 with output stage -N70-1) | 87 | ||
20 A 1) | Ignition coil 2 with output stage -N127-1) | |||||
Ignition coil 3 with output stage -N291-1) | ||||||
Ignition coil 4 with output stage -N292-1) | ||||||
Air mass meter -G70-2) | ||||||
Automatic glow period control unit -J179-2) | ||||||
Heater element for crankcase breather -N79-2) | ||||||
SB10 | Fuse 10 on fuse holder B -SB10- | 15 A 1) 20 A 2) | Fuel pump control unit -J538-
| 87 | ||
SB11 | Fuse 11 on fuse holder B -SB11- | 40 A | Auxiliary air heater element -Z35-2) | 87 | ||
SB12 | Fuse 12 on fuse holder B -SB12- | 40 A | Auxiliary air heater element -Z35-2) | 87 | ||
SB13 | Fuse 13 on fuse holder B -SB13- | 30 A | Mechatronic unit for dual clutch gearbox -J743-
| 30 | ||
15 A | Mechatronic unit for dual clutch gearbox -J743-
| |||||
SB14 | Fuse 14 on fuse holder B -SB14- | 30 A | Heated windscreen relay -J47- | 30 | ||
SB15 | Fuse 15 on fuse holder B -SB15- | 15 A | Horn relay -J413- | 30 | ||
SB16 | not assigned | - | - | |||
SB17 | Fuse 17 on fuse holder B -SB17- | 7.5 A | Main relay -J271- 1) | 30 | ||
Terminal 30 voltage supply relay -J317- 2) | ||||||
Engine control unit -J623- | ||||||
ABS control unit -J104- | ||||||
Heated windscreen relay -J47- | ||||||
SB18 | Fuse 18 on fuse holder B -SB18- | 5 A | Battery monitor control unit -J367- | 30 | ||
Data bus diagnostic interface -J533- 3) | ||||||
SB19 | Fuse 19 on fuse holder B -SB19- | 30 A | Wiper motor control unit -J400- | 30 | ||
SB20 | Fuse 20 on fuse holder B -SB20- | 10 A | Alarm horn -H12- | 30 | ||
SB21 | Fuse 21 on fuse holder B -SB21- | 30A | Heated windscreen relay 2 -J611- | 30 | ||
SB22 | Fuse 22 on fuse holder B -SB22- | 5 A | Engine control unit -J623- | 50 | ||
SB23 | Fuse 23 on fuse holder B -SB23- | 30 A | Starter -B- | 50 | ||
SB24 | Fuse 24 on fuse holder B -SB24- | 40 A | Auxiliary air heater element -Z35-2) | 87 | ||
SB25 | not assigned | - | - | |||
SB26 | not assigned | - | - | |||
SB27 | not assigned | - | - | |||
SB28 | not assigned | - | - | |||
SB29 | not assigned | - | - | |||
SB30 | not assigned | - | - | |||
SB31 | Fuse 31 on fuse holder B -SB31- | 15 A | Vacuum pump for brakes -V192-4) | 87 | ||
SB32 | not assigned | - | - | |||
SB33 | not assigned | - | - | |||
SB34 | not assigned | - | - | |||
SB35 | not assigned | - | - | |||
SB36 | not assigned | - | - | |||
SB37 | Fuse 37 on fuse holder B -SB37- | 20 A | Auxiliary heater control unit -J364- | 30 | ||
SB38 | not assigned | - | - |
1) Only models with petrol engine |
2) for models with diesel engine only |
3 Only models with no start/stop system |
4) According to equipment |
|
Fitting location, fuse holder A -SA- |
1 - | Fuse holder A -SA- |
508 - | Threaded connection (30) on E-box |
Note:
|
Fuse assignment on fuse holder A -SA- |
Fuse assignment of fuse holder A -SA- , from September 2015 |
Screw location | Current flow diagram designation | Nominal value | Function/component | Terminal |
SA1 | Fuse 1 on fuse holder A -SA1- | 125 A | Supply for the fuses: | 30 |
Fuse 4 on fuse holder C -SC4- - Fuse 14 on fuse holder C -SC14- | ||||
Fuse 31 on fuse holder C -SC31- | ||||
Fuse 38 on fuse holder C -SC38- | ||||
Fuse 39 on fuse holder C -SC39- | ||||
Fuse 41 on fuse holder C -SC41- | ||||
Fuse 42 on fuse holder C -SC42- | ||||
Fuse 53 on fuse holder C -SC53- | ||||
Terminal 15 voltage supply relay -J329- | ||||
SA2 | Fuse 2 on fuse holder A -SA2- | 400 A | Alternator with voltage regulator -CX1- | 30 |
508 | 508 Threaded connection (30), on E-box | - | Battery -A- | 30 |
SA3 | Fuse 3 on fuse holder A -SA3- | 80 A | Power steering control unit -J500- | 30 |
SA4 | Fuse 4 on fuse holder A -SA4- | 80 A | Supply for the fuses: | 30 |
Fuse 15 on fuse holder C -SC15- - Fuse 20 on fuse holder C -SC20- | ||||
Fuse 23 on fuse holder C -SC23- - Fuse 26 on fuse holder C -SC26- | ||||
Fuse 28 on fuse holder C -SC28- | ||||
Fuse 43 on fuse holder C -SC43- - Fuse 45 on fuse holder C -SC45- | ||||
SA5 | Fuse 5 on fuse holder A -SA5- | 50 A | Radiator fan -VX57- | 30 |
1) According to equipment |
Back to overview → Chapter |