VW TRANSPORTER 2005

Wiring Diagram VW TRANSPORTER 2005 - Battery - alternator - starter - fuses - terminal 30 voltage supply relay

A	Battery
B	Starter
C	Alternator
C1	Voltage regulator
J207	Starter inhibitor relay
J317	Terminal 30 voltage supply relay
J519	Onboard supply control unit
SA1	Fuse 1 on fuse holder A
SA4	Fuse 4 on fuse holder A
SA6	Fuse 6 on fuse holder A
SA7	Fuse 7 on fuse holder A
T6bz	6-pin connector, light-pink, coupling station on electronics box, in engine compartment
T10a	10-pin connector, brown, coupling station on electronics box, in engine compartment
T10m	10-pin connector, light-pink, coupling station on electronics box, in engine compartment
T18a	18-pin connector, brown
14	Earth point, on gearbox
624	Earth point, starter battery
D50	Positive connection (30), in engine compartment wiring harness
D97	Connection (50), in engine compartment right wiring harness
D101	Connection 1, in engine compartment wiring harness
*	Cross-section 4.0 possible
**	fuse rating depends on equipment ⇒ Fitting Locations
***	applicable from June 2004
****	models with automatic gearbox / electric interface only ⇒ applicable Current Flow Diagram
	for models with manual gearbox only
	for models with automatic gearbox only

Wiring Diagram VW TRANSPORTER 2005 - Glow plug relay - additional coolant pump relay - glow plugs - fuses - ignition/starter switch

Получить доступ ко всем электросхемам автомобиля

D	Ignition/starter switch
J52	Glow plug relay
J496	Additional coolant pump relay
J708	Residual heat relay
Q10	Glow plug 1
Q11	Glow plug 2
Q12	Glow plug 3
Q13	Glow plug 4
Q14	Glow plug 5
SB23	Fuse 23 on fuse holder B
SD2	Fuse 2 on fuse holder D
SD33	Fuse 33 on fuse holder D
T5b	5-pin connector, black, on front left cylinder head
T6q	6-pin connector, brown, coupling station on electronics box, in engine compartment
T6bk	6-pin connector, grey, coupling station on electronics box, in engine compartment
T10a	10-pin connector, brown, coupling station on electronics box, in engine compartment
T10h	10-pin connector, orange, coupling station on electronics box, in engine compartment
D98	Connection (glow plugs), in engine compartment wiring harness
D177	Connection 2 (glow plugs), in engine compartment wiring harness
D180	Connection (87a), in engine compartment wiring harness
*	applicable from June 2004 up to December 2004
**	Cross-section 4.0 possible
***	⇒ auxiliary coolant heater Current Flow Diagram
****	for models with manual gearbox only
	for models with manual gearbox and without electric interface only

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - unit injector valves

Получить доступ ко всем электросхемам автомобиля

J623	Engine control unit
N240	Unit injector valve, No. 1 cyl.
N241	Unit injector valve, No. 2 cyl.
N242	Unit injector valve, No. 3 cyl.
N243	Unit injector valve, No. 4 cyl.
N244	Unit injector valve, No. 5 cyl.
SD32	Fuse 32 on fuse holder D
T6r	6-pin connector, in engine compartment
T60	60-pin connector
T94	94-pin connector
250	Earth connection, in diesel engine wiring harness
D95	Connection (injectors), in engine compartment wiring harness
D113	Connection 11, in engine compartment wiring harness

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - fuel temperature sender - fuel pump relay - exhaust gas recirculation valve - charge pressure control solenoid valve - charge pressure control solenoid valve

Получить доступ ко всем электросхемам автомобиля

G81	Fuel temperature sender
J17	Fuel pump relay
J623	Engine control unit
N18	Exhaust gas recirculation valve
N75	Charge pressure control solenoid valve
N239	Variable intake manifold flap change-over valve
SD10	Fuse 10 on fuse holder D
SD14	Fuse 14 on fuse holder D
SD30	Fuse 30 on fuse holder D
T6q	6-pin connector, brown, coupling station on electronics box, in engine compartment
T6bz	6-pin connector, light-pink, coupling station on electronics box, in engine compartment
T8b	8-pin connector, black, in engine compartment
T10c	10-pin connector, yellow, coupling station on electronics box, in engine compartment
T10m	10-pin connector, light-pink, coupling station on electronics box, in engine compartment
T60	60-pin connector
T94	94-pin connector
D114	Connection 12, in engine compartment wiring harness
*	applicable up to May 2004
**	applicable from June 2004
***	applicable from January 2006

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - engine speed sender - charge air pressure sender - Hall sender - intake air temperature sender

Получить доступ ко всем электросхемам автомобиля

E45	Cruise control system switch
G28	Engine speed sender
G31	Charge air pressure sender
G40	Hall sender
G42	Intake air temperature sender
J623	Engine control unit
T3a	3-pin connector, black, on front of engine
T3b	3-pin connector, grey, on front of engine
T10	10-pin connector, black, coupling station on electronics box, in engine compartment
T10a	10-pin connector, brown, coupling station on electronics box, in engine compartment
T10l	10-pin connector, light-green, coupling station on electronics box, in engine compartment
T41	41-pin connector
T60	60-pin connector
T94	94-pin connector
B441	Connection (CCS), in main wiring harness
B464	Connection (speed signal), in main wiring harness
*	for models with cruise control system only

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - coolant temperature sender - air mass meter - heater element for crankcase breather

Получить доступ ко всем электросхемам автомобиля

G62	Coolant temperature sender
G70	Air mass meter
J623	Engine control unit
N79	Heater element for crankcase breather
SB34	Fuse 34 on fuse holder B
SD12	Fuse 12 on fuse holder D
SD20	Fuse 20 on fuse holder D
T10	10-pin connector, black, coupling station on electronics box, in engine compartment
T60	60-pin connector
T94	94-pin connector
131	Earth connection 2, in engine compartment wiring harness
D17	Positive connection 1 (15), in engine harness
D136	Positive connection 2 (15a), in engine compartment wiring harness

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - brake pedal switch - brake light switch - clutch pedal switch - brake light bulbs

Получить доступ ко всем электросхемам автомобиля

F	Brake light switch
F36	Clutch pedal switch
F47	Brake pedal switch
J293	Radiator fan control unit
J419	Brake light additional relay
J623	Engine control unit
J671	Radiator fan control unit 2
M9	Left brake light bulb
M10	Right brake light bulb
M25	High level brake light bulb
SB9	Fuse 9 on fuse holder B
SD19	Fuse 19 on fuse holder D
T10	10-pin connector, black, coupling station on electronics box, in engine compartment
T10h	10-pin connector, orange, coupling station on electronics box, in engine compartment
T10n	10-pin connector, black, coupling station on electronics box, in engine compartment
T94	94-pin connector
B131	Connection (54), in interior wiring harness
B278	Positive connection 2 (15a), in main wiring harness
*	for models with ESP only ⇒ ABS Current Flow Diagram
**	for models without ESP only
***	for models with air conditioning system only ⇒ Current Flow Diagram for radiator fan
****	applicable from June 2004
	for models with manual gearbox only

Wiring Diagram VW TRANSPORTER 2005 - Radiator fan control unit - radiator fan - radiator fan control unit - accelerator position sender - idling speed switch - kick-down switch

Получить доступ ко всем электросхемам автомобиля

F8	Kick-down switch
F60	Idling speed switch
G79	Accelerator position sender
G83	Radiator outlet coolant temperature sender
J293	Radiator fan control unit
J623	Engine control unit
SD1	Fuse 1 on fuse holder D
T2	2-pin connector, black
T2b	2-pin connector, black
T2c	2-pin connector, black, near radiator fan
T3u	3-pin connector, black
T6t	6-pin connector
T6u	6-pin connector, black
T10d	10-pin connector, blue, coupling station on electronics box, in engine compartment
T10e	10-pin connector, white, coupling station on electronics box, in engine compartment
T10h	10-pin connector, orange, coupling station on electronics box, in engine compartment
T10n	10-pin connector, black, coupling station on electronics box, in engine compartment
T60	60-pin connector
T94	94-pin connector
V7	Radiator fan
29	Earth point, near radiator fan control unit
D159	Connection (high bus), in engine compartment wiring harness
D160	Connection (low bus), in engine compartment wiring harness
D166	Connection (K-diagnosis wiring), in engine compartment wiring harness
*	for models without air conditioning system only
**	applicable from January 2006

Wiring Diagram VW TRANSPORTER 2005 - Dash panel inser - data bus diagnostic interface - fuel gauge sender - fuel system pressurisation pump - warning lamps

Получить доступ ко всем электросхемам автомобиля

G	Fuel gauge sender
G1	Fuel gauge
G6	Fuel system pressurisation pump
J285	Control unit in dash panel insert
J533	Data bus diagnostic interface
J708	Residual heat relay
K29	Glow period warning lamp
T6j	6-pin connector, red, coupling station under driver seat
T16	16-pin connector, diagnostic connector
T32	32-pin connector, blue
T32a	32-pin connector, green
366	Earth connection 1, in main wiring harness
410	Earth connection 1 (sender earth), in main wiring harness
637	Earth point, airbag control unit
B383	Connection 1 (drive train CAN bus, high), in main wiring harness
B390	Connection 1 (drive train CAN bus, low), in main wiring harness
B429	Connection (EFPR), in main wiring harness
B444	Connection 1 (diagnosis), in main wiring harness
*	depends on equipment ⇒ utilisation of residual heat/ auxiliary coolant heater Current Flow Diagram

Wiring Diagram VW TRANSPORTER 2005 - Control unit in dash panel insert - oil pressure switch - oil level and oil temperature sender - warning lamps

Получить доступ ко всем электросхемам автомобиля

F1	Oil pressure switch
G266	Oil level and oil temperature sender
J285	Control unit in dash panel insert
K3	Oil pressure warning lamp
K38	Oil level warning lamp
SC6	Fuse 6 on fuse holder C
T10a	10-pin connector, brown, coupling station on electronics box, in engine compartment
T10b	10-pin connector, red, coupling station on electronics box, in engine compartment
T32	32-pin connector, blue
T32a	32-pin connector, green
TV7	Terminal 31 wiring junction
12	Earth point, on left in engine compartment
281	Earth connection 1, in engine harness
*	for models with automatic gearbox only
**	for models with manual gearbox only
***	for models with extended servicing intervals only

VW TRANSPORTER 2005 Overview:

Overview:

Получить доступ ко всем электросхемам автомобиля

1 -	Relay carrier electronics box

2 -	Relay carrier 1, cockpit

3 -	Relay carrier 2, cockpit

4 -	Relay carrier on left of seat box

Note

The chamber marked as “vacant” can be fitted with a relay or a pin connector. See Fitting Locations "interior single fuses" and "coupling station"!

No.		Function/component		Location		Figure on page
1	-	Battery isolation relay -J7-	-	Relay carrier on left of seat box	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
2	-	Auxiliary heater relay -J8-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
3	-	Fuel pump relay -J17-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
4	-	Headlight washer system relay -J39-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
5	-	Electric fuel pump 2 relay -J49-	-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
6	-	Glow plug relay -J52-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
7	-	X-contact relief relay -J59-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
8	-	Automatic gearbox relay -J60-	-	Relay carrier electronics box (1.9 l - diesel engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
9	-	Alarm system control unit -J85-	-	Relay carrier (2), cockpit	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
10	-	Magnetic clutch control unit -J153-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
11	-	Rear fresh air blower relay -J163-	-	Relay carrier (2), cockpit	---	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter
12	-	Automatic glow period control unit -J179-	-	Relay carrier electronics box (1.9 l - diesel engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
13	-	Switch-over relay 1 for roof ventilator -J180-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
14	-	Switch-over relay 2 for roof ventilator -J181-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
15	-	Differential lock control unit -J187-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
16	-	Starter inhibitor relay -J207-	-	Relay carrier electronics box (1.9 l - diesel engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
17	-	Cut-out relay for air conditioning system magnetic coupling -J246-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
18	-	Secondary air pump relay -J299-	-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
19	-	Terminal 30 voltage supply relay -J317-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
20	-	Rotating light relay -J326-	-	Relay carrier (1), cockpit	-	from June 2003 → chapter
			-	Relay carrier (2), cockpit	--	from February 2004 → chapter from June 2004 → chapter
			-	Relay carrier on left of seat box	--	from August 2006 → chapter from June 2007 → chapter
21	-	Folding exterior mirror control unit -J351-	-	Relay carrier (2), cockpit	--	from August 2006 → chapter from June 2007 → chapter
22	-	Brake light additional relay -J419-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
23	-	Taxi alarm system 2 control unit -J430-	-	Relay carrier (2), cockpit	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
24	-	Multifunction steering wheel control unit -J453-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
25	-	Alarm system relay 1 -J460-	-	Relay carrier (2), cockpit	--	from February 2004 → chapter from June 2004 → chapter
			-	Relay carrier on left of seat box	--	from August 2006 → chapter from June 2007 → chapter
26	-	Fresh air blower isolation relay -J487-	-	Relay carrier (1), cockpit	---	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter
			-	Relay carrier (2), cockpit	---	from January 2006 → chapter from August 2006 → chapter from June 2007 → chapter
27	-	Auxiliary coolant heater relay -J493-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
28	-	Additional coolant pump relay -J496-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
29	-	Power steering control unit -J500-	-	Relay carrier electronics box (1.9 l - diesel engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-	from March 2003 → chapter
30	-	Taxi alarm remote control, control unit -J601-	-	Relay carrier on left of seat box	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
31	-	Residual heat relay -J708-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
32	-	Dual signal inverter relay -J741-	-	Relay carrier on left of seat box	-	from March 2003 → chapter
			-	Relay carrier (2), cockpit	-	from June 2003 → chapter
			-	Relay carrier (1), cockpit	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from March 2003

t	In electronics box in engine compartment

For engine codes AXB and AXC

Pos. -

Connector/designation

1 -	Glow plug relay -J52-

2 -	Fuel pump relay -J17-

3 -	Magnetic clutch control unit -J153-

4 -	Cut-out relay for air conditioning system magnetic coupling -J246-

5 -

Vacant

6 -	Terminal 30 voltage supply relay -J317-

7 -	Additional coolant pump relay -J496-

8 -	Power steering control unit -J500-

2B -	Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from June 2004

t	In electronics box in engine compartment

for engine codes AXB, AXC, BRR and BRS

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (103) ²⁾

-	Glow plug relay -J52- (100) ³⁾

-	Automatic glow period control unit -J179- (457) ⁴⁾

2 -	Fuel pump relay -J17- (53)

vacant¹⁾

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Fuel pump relay -J17- (53) ¹⁾

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

3C -	Starter inhibitor relay -J207- (53)

Note

t	¹⁾ applicable from January 2006

t	²⁾ for engine codes AXB and AXC only

t	³⁾ applicable from June 2006 and engine codes AXB and AXC

t	⁴⁾ for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from August 2006

t	In electronics box in engine compartment

for engine codes AXB, AXC, BRR and BRS

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (100) ¹⁾

-	Automatic glow period control unit -J179- (457) ²⁾

2 -

Vacant

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Fuel pump relay -J17- (53)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

3C -	Starter inhibitor relay -J207- (53)

Note

t	¹⁾ for engine codes AXB and AXC only

t	²⁾ for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from June 2007

t	In electronics box in engine compartment

for engine codes AXB, AXC, BRR and BRS

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (100) ¹⁾

-	Automatic glow period control unit -J179- (457) ²⁾

2 -

Vacant

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Fuel pump relay -J17- (53)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

3C -	Starter inhibitor relay -J207- (53)

Note

t	¹⁾ for engine codes AXB and AXC only

t	²⁾ for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from November 2007

t	In electronics box in engine compartment

for engine codes AXB, AXC, BRR and BRS

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (100) ¹⁾

-	Automatic glow period control unit -J179- (457) ²⁾

2 -

Vacant

3 -	Magnetic clutch control unit -J153- (454)

4 -

Vacant

5 -

Vacant

-	Starter inhibitor relay -J207- (449)

6 -	Terminal 30 voltage supply relay -J317- (643)

7 -	Fuel pump relay -J17- (449)

-	Additional coolant pump relay -J496- (449)

8 -

Vacant

-	Cut-out relay for air conditioning system magnetic coupling -J246- (449)

Note

t	¹⁾ for engine codes AXB and AXC only

t	²⁾ for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from March 2003

t	In electronics box in engine compartment

For engine code AXA

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299-

2 -	Fuel pump relay -J17-

3 -	Magnetic clutch control unit -J153-

4 -	Cut-out relay for air conditioning system magnetic coupling -J246-

5 -	Electric fuel pump 2 relay -J49-

6 -	Terminal 30 voltage supply relay -J317-

7 -	Additional coolant pump relay -J496-

8 -	Power steering control unit -J500-

2B -	Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from June 2004

t	In electronics box in engine compartment

For engine code AXA

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Fuel pump relay -J17- (167)

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Electric fuel pump 2 relay -J49- (404)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

3C -	Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from August 2006

t	In electronics box in engine compartment

For engine code AXA

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Fuel pump relay -J17- (167)

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Electric fuel pump 2 relay -J49- (404)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

3C -	Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from June 2007

t	In electronics box in engine compartment

For engine code AXA

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Fuel pump relay -J17- (167)

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Electric fuel pump 2 relay -J49- (404)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

3C -	Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from November 2007

t	In electronics box in engine compartment

For engine code AXA

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -

Vacant

-	Electric fuel pump 2 relay -J49- (449)

3 -	Magnetic clutch control unit -J153- (454)

4 -	Fuel pump relay -J17- (643)

5 -

Vacant

-	Starter inhibitor relay -J207- (449)

6 -	Terminal 30 voltage supply relay -J317- (643)

7 -

Vacant

-	Additional coolant pump relay -J496- (449)

8 -

Vacant

-	Cut-out relay for air conditioning system magnetic coupling -J246- (449)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from March 2003

t	In electronics box in engine compartment

For engine codes AXD and AXE

Pos. -

Connector/designation

1 -	Glow plug relay -J52-

2 -	Fuel pump relay -J17-

3 -

Vacant

4 -	Starter inhibitor relay -J207-

5 -

Vacant

6 -	Terminal 30 voltage supply relay -J317-

7 -	Additional coolant pump relay -J496-

8 -	Power steering control unit -J500-

2B -	Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from June 2004

t	In electronics box in engine compartment

for engine codes AXD, AXE, BLJ, BNZ and BPC

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (103) ²⁾

-	Glow plug relay -J52- (100) ³⁾

-	Automatic glow period control unit -J179- (475) ⁴⁾

2 -	Fuel pump relay -J17- (53)

3 -

Vacant

4 -

Vacant

5 -	Fuel pump relay -J17- (53) ¹⁾

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

2B -	Automatic gearbox relay -J60- (53)

3C -	Starter inhibitor relay -J207- (53)

Note

t	¹⁾ applicable from January 2006

t	²⁾ for engine codes AXD, AXE and BLJ only

t	³⁾ applicable from June 2006 and engine codes AXD, AXE, BLJ

t	⁴⁾ for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from August 2006

t	In electronics box in engine compartment

for engine codes AXD, AXE, BLJ, BNZ and BPC

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (100) ¹⁾

-	Automatic glow period control unit -J179- (475) ²⁾

2 -

Vacant

3 -

Vacant

4 -

Vacant

5 -	Fuel pump relay -J17- (53)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

2B -	Automatic gearbox relay -J60- (53)

3C -	Starter inhibitor relay -J207- (53)

Note

t	¹⁾ for engine codes AXD, AXE and BJL only

t	²⁾ for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from June 2007

t	In electronics box in engine compartment

for engine codes AXD, AXE, BLJ, BNZ and BPC

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (100) ¹⁾

-	Automatic glow period control unit -J179- (475) ²⁾

2 -

Vacant

3 -

Vacant

4 -

Vacant

5 -	Fuel pump relay -J17- (53)

6 -	Terminal 30 voltage supply relay -J317- (109)

7 -	Additional coolant pump relay -J496- (53)

8 -

Vacant

2B -	Automatic gearbox relay -J60- (53)

3C -	Starter inhibitor relay -J207- (53)

Note

t	¹⁾ for engine codes AXD, AXE and BLJ only

t	²⁾ for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from November 2007

t	In electronics box in engine compartment

for engine codes AXD, AXE, BLJ, BNZ and BPC

Pos. -

Connector/designation

1 -	Glow plug relay -J52- (100) ¹⁾

-	Automatic glow period control unit -J179- (475) ²⁾

2 -

Vacant

3 -

Vacant

4 -

Vacant

5 -	Automatic gearbox relay -J60- (449)

-	Starter inhibitor relay -J207- (449)

6 -	Terminal 30 voltage supply relay -J317- (643)

7 -	Fuel pump relay -J17- (449)

-	Additional coolant pump relay -J496- (449)

8 -

Vacant

Note

t	¹⁾ for engine codes AXD, AXE and BLJ only

t	²⁾ for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from March 2003

t	In electronics box in engine compartment

For engine codes BDL and BDM

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299-

2 -	Terminal 30 voltage supply relay -J317-

3 -	Magnetic clutch control unit -J153-

4 -	Cut-out relay for air conditioning system magnetic coupling -J246-

5 -	Electric fuel pump 2 relay -J49-

-	Additional coolant pump relay -J496-

6 -	Fuel pump relay -J17-

7 -	Starter inhibitor relay -J207-

8 -	Power steering control unit -J500-

2B -	Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from June 2004

t	In electronics box in engine compartment

For engine codes BDL, BDM and BKK

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Terminal 30 voltage supply relay -J317- (428)

-	Terminal 30 voltage supply relay -J317- (614) ¹⁾

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Electric fuel pump 2 relay -J49- (404)

-	Additional coolant pump relay -J496- (404)

6 -	Fuel pump relay -J17- (167)

7 -

Vacant

8 -

Vacant

2B -	Automatic gearbox relay -J60- (53)

3C -	Starter inhibitor relay -J207- (53)

Note

¹⁾ applicable from June 2006

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from August 2006

t	In electronics box in engine compartment

For engine codes BDL, BDM and BKK

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Terminal 30 voltage supply relay -J317- (614)

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Electric fuel pump 2 relay -J49- (404)

-	Additional coolant pump relay -J496- (404)

6 -	Fuel pump relay -J17- (167)

7 -

Vacant

8 -

Vacant

2B -	Automatic gearbox relay -J60- (53)

3C -	Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from June 2007

t	In electronics box in engine compartment

For engine codes BDL, BDM and BKK

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Terminal 30 voltage supply relay -J317- (614)

3 -	Magnetic clutch control unit -J153- (KL2)

4 -	Cut-out relay for air conditioning system magnetic coupling -J246- (53)

5 -	Electric fuel pump 2 relay -J49- (404)

-	Additional coolant pump relay -J496- (404)

6 -	Fuel pump relay -J17- (167)

7 -

Vacant

8 -

Vacant

2B -	Automatic gearbox relay -J60- (53)

3C -	Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from November 2007

t	In electronics box in engine compartment

For engine codes BDL, BDM and BKK

Pos. -

Connector/designation

1 -	Secondary air pump relay -J299- (100)

2 -	Additional coolant pump relay -J496- (449)

-	Electric fuel pump 2 relay -J49- (449)

3 -	Magnetic clutch control unit -J153- (454)

4 -

Vacant

5 -	Automatic gearbox relay -J60- (449)

-	Starter inhibitor relay -J207- (449)

6 -	Terminal 30 voltage supply relay -J317- (100)

7 -	Fuel pump relay -J17- (643)

8 -

Vacant

-	Cut-out relay for air conditioning system magnetic coupling -J246- (449)

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from March 2003

t	On left in seat box

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -

Vacant

4 -

Vacant

5 -

Vacant

6 -

vacant¹⁾

-	Battery isolation relay -J7-²⁾

7 -

Vacant

8 -	Battery isolation relay -J7-¹⁾

vacant²⁾

3) -	Dual signal inverter relay -J741-¹⁾

Note

t	¹⁾ applicable up to May 2003

t	²⁾ applicable from June 2003

t	³⁾ position is depends on equipment

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from February 2004

t	On left in seat box

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -

Vacant

4 -	Taxi alarm remote control, control unit -J601-¹⁾

5 -

Vacant

6 -	Battery isolation relay -J7-

7 -

Vacant

8 -

Vacant

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from June 2004

t	On left in seat box

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -

Vacant

4 -	Taxi alarm remote control, control unit -J601-¹⁾

5 -

Vacant

6 -	Battery isolation relay -J7- (100)

7 -

Vacant

8 -

Vacant

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from August 2006

t	On left in seat box

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -

Vacant

4 -	Taxi alarm remote control, control unit -J601-¹⁾

5 -

Vacant

6 -	Battery isolation relay -J7- (100)

7 -

Vacant

8 -	Rotating light relay -J326- (406)

-	Alarm system relay 1 -J460-¹⁾

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from June 2007

t	On left in seat box

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -

Vacant

4 -	Taxi alarm remote control, control unit -J601-¹⁾

5 -

Vacant

6 -	Battery isolation relay -J7- (100)

7 -

Vacant

8 -	Rotating light relay -J326- (486)

-	Alarm system relay 1 -J460- (53) ¹⁾

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from March 2003

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -	Auxiliary heater relay -J8-

-	Residual heat relay -J708-

2 -	Headlight washer system relay -J39-

3 -	Brake light additional relay -J419-

4 -	Rotating light relay -J326-¹⁾

5 -	X-contact relief relay -J59-

6 -	Fresh air blower isolation relay -J487-

7 -	Auxiliary coolant heater relay -J493-

8 -

Vacant

Note

¹⁾ applicable from June 2003

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from February 2004

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -	Auxiliary heater relay -J8-

-	Residual heat relay -J708-

2 -	Headlight washer system relay -J39-

3 -	Brake light additional relay -J419-

4 -	Dual signal inverter relay -J741-

5 -	X-contact relief relay -J59-

6 -	Fresh air blower isolation relay -J487-

7 -	Auxiliary coolant heater relay -J493-

8 -

Vacant

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), June 2004

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -	Auxiliary heater relay -J8- (404)

-	Residual heat relay -J708- (404)

2 -	Headlight washer system relay -J39- (53)

3 -	Brake light additional relay -J419- (404/480)

4 -	Dual signal inverter relay -J741- (472) ³⁾

vacant¹⁾

5 -	X-contact relief relay -J59- (100)

6 -	Fresh air blower isolation relay -J487- (53) ²⁾

7 -	Auxiliary coolant heater relay -J493- (53)

8 -

vacant³⁾

-	Dual signal inverter relay -J741- (472) ¹⁾

Note

t	¹⁾ applicable from January 2006

t	²⁾ is dropped from September 2004

t	³⁾ up to December 2005

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from August 2006

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -	Auxiliary heater relay -J8- (404)

-	Residual heat relay -J708- (404)

2 -	Headlight washer system relay -J39- (53)

3 -	Brake light additional relay -J419- (404/480)

4 -

Vacant

5 -	X-contact relief relay -J59- (100)

6 -	Dual signal inverter relay -J741- (472)

7 -	Auxiliary coolant heater relay -J493- (53)

8 -

Vacant

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from June 2007

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -	Auxiliary heater relay -J8- (404)

-	Residual heat relay -J708- (404)

2 -	Headlight washer system relay -J39- (53)

3 -	Brake light additional relay -J419- (404/480)

4 -

Vacant

5 -	X-contact relief relay -J59- (100)

6 -

Vacant

7 -	Dual signal inverter relay -J741- (472)

8 -	Auxiliary coolant heater relay -J493- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from March 2003

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -	Dual signal inverter relay -J741-¹⁾

4 -	Differential lock control unit -J187-

5 -	Switch-over relay 1 for roof ventilator -J180-

-	Switch-over relay 2 for roof ventilator -J181-

6 -	Multifunction steering wheel control unit -J453-

7 -	Multifunction steering wheel control unit -J453-

8 -	Rear fresh air blower relay -J163-

Note

¹⁾ applicable from June 2003

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from February 2004

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -	Rotating light relay -J326-

-	Alarm system relay 1 -J460-¹⁾

4 -	Differential lock control unit -J187-

5 -	Switch-over relay 1 for roof ventilator -J180-

-	Switch-over relay 2 for roof ventilator -J181-

-	Taxi alarm system 2 control unit -J430-¹⁾

6 -	Multifunction steering wheel control unit -J453-

-	Alarm system control unit -J85-¹⁾

7 -	Multifunction steering wheel control unit -J453-

-	Alarm system control unit -J85-¹⁾

8 -	Rear fresh air blower relay -J163-

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from June 2004

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -

Vacant

2 -

Vacant

3 -	Rotating light relay -J326- (406)

-	Alarm system relay 1 -J460-³⁾

4 -	Differential lock control unit -J187- (468)

5 -	Switch-over relay 1 for roof ventilator -J180- (404)

-	Switch-over relay 2 for roof ventilator -J181- (404)

-	Taxi alarm system 2 control unit -J430-³⁾

6 -	Alarm system control unit -J85-³⁾

-	Multifunction steering wheel control unit -J453- (451)

7 -	Alarm system control unit -J85-³⁾

-	Multifunction steering wheel control unit -J453- (451)

8 -	Rear fresh air blower relay -J163-¹⁾

-	Fresh air blower isolation relay -J487- (53) ²⁾

Note

t	¹⁾ applicable up to December 2005

t	²⁾ applicable from January 2006

t	³⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from August 2006

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -	Folding exterior mirror control unit -J351- (361)

2 -	Folding exterior mirror control unit -J351- (361)

3 -

Vacant

4 -	Differential lock control unit -J187- (468)

5 -	Alarm system control unit -J85-¹⁾

-	Multifunction steering wheel control unit -J453- (451)

6 -	Alarm system control unit -J85-¹⁾

-	Multifunction steering wheel control unit -J453- (451)

7 -	Switch-over relay 1 for roof ventilator -J180- (404)

-	Switch-over relay 2 for roof ventilator -J181- (404)

-	Taxi alarm system 2 control unit -J430-¹⁾

8 -	Fresh air blower isolation relay -J487- (53)

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from June 2007

t	Under dash panel (centre, under the fuses)

Pos. -

Connector/designation

1 -

Vacant

2 -	Folding exterior mirror control unit -J351- (361)

3 -	Folding exterior mirror control unit -J351- (361)

4 -	Differential lock control unit -J187- (468)

5 -	Alarm system control unit -J85- (73) ¹⁾

-	Multifunction steering wheel control unit -J453- (451)

6 -	Alarm system control unit -J85- (73) ¹⁾

-	Multifunction steering wheel control unit -J453- (451)

7 -	Switch-over relay 1 for roof ventilator -J180- (404)

-	Switch-over relay 2 for roof ventilator -J181- (404)

-	Taxi alarm system 2 control unit -J430- (53) ¹⁾

8 -	Fresh air blower isolation relay -J487- (53)

Note

¹⁾ for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Engine compartment

Engine compartment

Получить доступ ко всем электросхемам автомобиля

1 -	Electronics box, in engine compartment

2 -	Fuse holder D -SD- , in engine compartment

3 -	Fuse holder A -SA- , in electronics box

4 -	Upper housing half for fuse holder, in engine compartment

5 -	Pin connectors on engine control unit, in electronics box

6 -	Engine control unit -J623- , in electronics box

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Engine control unit -J623- (Diesel engine)

Pin connector:

B -	94-pin connector -T94- , on wiring harness

C -	60-pin connector -T60- , on wiring harness

Note

Designation as diesel direct injection system control unit -J248- possible

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Engine control unit -J623- (Petrol engine)

Pin connector:

B -	81-pin connector -T81- or 121-pin connector -T121- , on wiring harness

C -	40-pin connector -T40- or 121-pin connector -T121- , on wiring harness

Note

Designation as Motronic control unit -J220- possible

VW TRANSPORTER 2005 ABS control unit J104

ABS control unit -J104-

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	ABS control unit -J104-

Pin connector:

B -	47-pin connector -T47- , on wiring harness

VW TRANSPORTER 2005 Automatic gearbox control unit J217

Automatic gearbox control unit -J217-

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Automatic gearbox control unit -J217-

Pin connector:

B -	52-pin connector -T52- , on wiring harness

VW TRANSPORTER 2005 Radiator fan control unit J293

Radiator fan control unit -J293-

Location:

in engine compartment, on left of longitudinal member ⇒ -arrow-

VW TRANSPORTER 2005 Radiator fan control unit J293

Получить доступ ко всем электросхемам автомобиля

Pin connector:

1 -	2-pin connector -T2b-

2 -	2-pin connector -T2- , black

3 -	6-pin connector -T6u- , black

Note

for models without air conditioning system only

Получить доступ ко всем электросхемам автомобиля

Pin connector:

1 -	3-pin connector -T3u- , black

2 -	2-pin connector -T2d- , black

3 -	2-pin connector -T2- , black

4 -	2-pin connector -T2b- , brown

Note

t	for models with air conditioning system and radiator fan control unit 1 only

t	for engine codes AXA, AXB, AXC, AXD, AXE, BDL, BDM, BKK, BLJ only

Получить доступ ко всем электросхемам автомобиля

Pin connector:

Note

Radiator fan control unit 2 -J671- on radiator fan

1 -	3-pin connector -T3u- , black

2 -	2-pin connector -T2d- , black

3 -	2-pin connector -T2- , black

Note

t	for models with air conditioning system and 2 radiator fan control units only

t	for engine codes AXD, AXE, BDL, BDM, BKK, BLJ only

VW TRANSPORTER 2005 Onboard supply control unit J519

Onboard supply control unit -J519-

Получить доступ ко всем электросхемам автомобиля

Location:

under dash panel ⇒ -position 1-

Note

Connector assignment: See Fitting Locations: Pin connector assigment of selected connections

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005 Control unit in dash panel insert J285

Control unit in dash panel insert -J285-

t	32-pin connector -T32- , blue

⇒ -Position 1 up to 32-

Note

Connector assignment: See Fitting Locations: Pin connector assigment of selected connections

VW TRANSPORTER 2005 Control unit in dash panel insert J285

Получить доступ ко всем электросхемам автомобиля

Control unit in dash panel insert -J285-

t	32-pin connector -T32a- , green

⇒ -Position 1 up to 32-

Note

t	Connector assignment: See Fitting Locations: Pin connector assigment of selected connections

t	Immobilizer control unit -J362- in control unit in dash panel insert -J285- integrated

t	data bus diagnostic interface -J533- in control unit in dash panel insert -J285- integrated

VW TRANSPORTER 2005 Parking aid control unit J446

Parking aid control unit -J446-

Получить доступ ко всем электросхемам автомобиля

Location:

Behind the dash panel, left

1 -	Parking aid control unit -J446-

Pin connectors:

2 -	16-pin connector -T16h- , white¹⁾

-	16-pin connector -T16h- , brown²⁾

3 -	12-pin connector -T12s- , white¹⁾

-	12-pin connector -T12s- , black²⁾

4 -	12-pin connector -T12r- , black¹⁾

-	12-pin connector -T12r- , brown²⁾

Note

t	¹⁾ applicable up to January 2004

t	²⁾ applicable from February 2004

VW TRANSPORTER 2005 Driver door control unit J386

Driver door control unit -J386-

Получить доступ ко всем электросхемам автомобиля

Location:

In the front left door ⇒ -position A-

VW TRANSPORTER 2005 Airbag control unit J234

Airbag control unit -J234-

Получить доступ ко всем электросхемам автомобиля

Location:

under dash panel, centre ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Airbag control unit -J234-

Pin connector:

B -	75-pin connector -T75- , on wiring harness

Anti-theft and tilt system control unit -J529-

Location:

1 -	Roof console

2 -	Anti-theft and tilt system control unit -J529-

VW TRANSPORTER 2005 Interior monitor send and receive module 2 G305

Interior monitor send and receive module 2 -G305-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Interior monitor send and receive module 2 -G305- , in rear headliner

VW TRANSPORTER 2005 Heated front seats control unit J774

Heated front seats control unit -J774-

Получить доступ ко всем электросхемам автомобиля

Fitting Locations:

A -	Heated front seats control unit -J774- , behind the dash panel, near relay carrier

behind the dash panel, near relay carrier

Note

applicable from January 2006

VW TRANSPORTER 2005 Sliding sunroof adjustment control unit J245

Sliding sunroof adjustment control unit -J245-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Sliding sunroof adjustment control unit -J245- , on sliding/tilting sunroof

VW TRANSPORTER 2005 Aerial selection control unit J515

Aerial selection control unit -J515-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Aerial selection control unit -J515- , above the rear right side window

VW TRANSPORTER 2005 Mobile telephone operating electronics control unit J412

Mobile telephone operating electronics control unit -J412-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Mobile telephone operating electronics control unit -J412- , behind the glove compartment

2 -	18-pin connector -T18c-¹⁾

-	54-pin connector -T54-²⁾

Note

t	¹ applicable up to October 2007

t	² applicable from November 2007

Получить доступ ко всем электросхемам автомобиля

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Mobile telephone operating electronics control unit -J412-

Pin connector:

B -	54-pin connector -T54-

VW TRANSPORTER 2005 Traffic information control unit J559

Traffic information control unit -J559-

Location:

1 -	Traffic information control unit -J559- , behind the dash panel, left

Note

Location on heater, in the centre possible → Anchor

VW TRANSPORTER 2005 Traffic information control unit J559

Traffic information control unit -J559-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Traffic information control unit -J559- , on heater, in the centre

Note

Location on heater, behind the left dash panel possible → Anchor

VW TRANSPORTER 2005 Front passenger door control unit J387

Front passenger door control unit -J387-

Получить доступ ко всем электросхемам автомобиля

Location:

A -	Front passenger door control unit -J387- , in the front right door

VW TRANSPORTER 2005 Gearshift indicator control unit J98

Gearshift indicator control unit -J98-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Clip locking

2 -	Gearshift indicator control unit -J98- , unter selector lever

Note

in Workshop Manual designated as circuit board

VW TRANSPORTER 2005 Rotating light and siren system control unit J23

Rotating light and siren system control unit -J23-

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Rotating light and siren system control unit -J23- , on dash panel, under cover bonnet

VW TRANSPORTER 2005

Left sliding door control unit -J558- (electric sliding door)

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Left sliding door control unit -J558- , on left D-pillar

2 -	6-pin connector -T6ag- , black

3 -	12-pin connector -T12k- , black

4 -	10-pin connector -T10aw- , black

5 -	6-pin connector -T6ah- , light-brown

Note

Electric sliding door with power latching system

VW TRANSPORTER 2005

Left sliding door control unit -J558- (power latching system, without electric sliding door)

Получить доступ ко всем электросхемам автомобиля

Location:

A -	Left sliding door control unit -J558- , on left D-pillar

-	8-pin connector -T8x- , black

Note

Mechanical sliding door with power latching system

VW TRANSPORTER 2005 Rear lid control unit J605

Rear lid control unit -J605-

Получить доступ ко всем электросхемам автомобиля

Location:

B -	Rear lid control unit -J605- , on left D-pillar

-	8-pin connector -T8w- , black

VW TRANSPORTER 2005

Right sliding door control unit -J731- (electric sliding door)

Получить доступ ко всем электросхемам автомобиля

Location:

1 -	Right sliding door control unit -J731- , on right D-pillar

2 -	6-pin connector -T6aj- , black

3 -	12-pin connector -T12l- , black

4 -	10-pin connector -T10ax- , black

5 -	6-pin connector -T6ak- , light-brown

Note

Electric sliding door with power latching system

VW TRANSPORTER 2005

Right sliding door control unit -J731- (power latching system, without electric sliding door)

Получить доступ ко всем электросхемам автомобиля

Location:

A -	Right sliding door control unit -J731- , on right D-pillar

-	8-pin connector -T8y- , black

Note

Mechanical sliding door with power latching system

VW TRANSPORTER 2005 Convenience system central control unit J393

Convenience system central control unit -J393-

Получить доступ ко всем электросхемам автомобиля

Location:

A -	Convenience system central control unit -J393- , under the seat on front right

Получить доступ ко всем электросхемам автомобиля

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Convenience system central control unit -J393-

Pin connector:

B -	12-pin connector -T12b- , on wiring harness

C -	23-pin connector -T23- , on wiring harness

D -	12-pin connector -T12c- , on wiring harness

VW TRANSPORTER 2005

CD changer -R41- ,amplifier -R12- and voice amplification control unit -J656-

Получить доступ ко всем электросхемам автомобиля

A -	CD changer -R41- , under the seat on front right

B -	Amplifier -R12- , under the seat on front right

C -	Voice amplification control unit -J656- , under the seat on front right

VW TRANSPORTER 2005 Four-wheel drive control unit J492

Four-wheel drive control unit -J492-

Location:

1 -	Four-wheel drive control unit -J492- , on the rear axle final drive, in front left area

VW TRANSPORTER 2005 Four-wheel drive control unit J492

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005 Overview:

Overview:

Получить доступ ко всем электросхемам автомобиля

1 -	Ignition/starter switch -D-

q	On steering column

q	Connector assigment → chapter

2 -	Onboard power supply control unit -J519-

q	Below the dash panel

q	Connector assigment → chapter

3 -	Steering column switch -T41-

q	On steering column

q	Connector assigment → chapter

4 -	Diagnosis connection -T16-

q	Left under dash panel

q	Connector assigment → chapter

5 -	Control unit in dash panel insert -J285-

q	Pin connector -T32- → chapter

q	Pin connector -T32a- → chapter

Contact assignment of pin connector on ignition/starter switch -D-

1 -	Terminal 50

2 -	Terminal 75

3 -	Terminal 30

4 -	Terminal P

5 -	terminal 50b

6 -	Terminal 15

7 -	Terminal 30

8 -	terminal 86s

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005 Onboard power supply control unit -J519-

Onboard power supply control unit -J519-

Connector assigment:

Получить доступ ко всем электросхемам автомобиля

A -	Pin connector, T6, black → chapter

B -	Pin connector, T6a, brown → chapter

C -	Pin connector, T6b, red → chapter

D -	Pin connector, T5, black → chapter

E -	Pin connector, T5a, brown → chapter

F -	Pin connector, T6c, black → chapter

G -	Pin connector, T18, black → chapter

H -	Pin connector, T6d, brown → chapter

I -	Pin connector, T18a, brown → chapter

J -	Pin connector, T6e, red → chapter

K -

Vacant

VW TRANSPORTER 2005 Contact assignment of pin connector -T6-, on onboard supply control unit (Item A)

Contact assignment of pin connector -T6-, on onboard supply control unit (Item A)

Pin		Assignment/Component	Terminal
1	-	636 - Earth point onboard supply control unit	31
2	-	Vacant
3	-	B129 - Connection (interior light, 31l), in interior wiring harness	TK
4	-	B153 - Connection (RTS), in interior wiring harness (output right turn signal)	BLR
5	-	SB36 - Fuse 36 on fuse holder B (turn signal input)	30a
6	-	B152 - Connection (LTS), in interior wiring harness (output left turn signal)	BLL

VW TRANSPORTER 2005 Contact assignment of pin connector -T6a-, on onboard supply control unit (Item A)

Contact assignment of pin connector -T6a-, on onboard supply control unit (Item A)

Pin		Assignment/Component		Terminal
1	-	Z5 - Front passenger side heated exterior mirror (output)
2	-	Z4 - Driver side heated exterior mirror (output)
3	-	SB16 - Fuse 16 on fuse holder B (input)		15
4	-	SB20 - Fuse 20 on fuse holder C (input heated exterior mirror)		30a
5	-	SB17 - Fuse 17 on fuse holder C (interior light output) SC24 - Fuse 24 on fuse holder C (interior light output)	¹) ¹)	30g 30g
5	-	B315 - Positive connection 1 (30a), in main wiring harrness (interior light output)	²)	30g
6	-	SB7 - Fuse 7 on fuse holder C (interior light input)	¹)	30a
6	-	SB17 - Fuse 17 on fuse holder C (interior light input)	²)	30a

Note

t	¹) for models with roof console only

t	²) for models without roof console only

VW TRANSPORTER 2005 Contact assignment of pin connector -T6b-, on onboard supply control unit (Item C)

Contact assignment of pin connector -T6b-, on onboard supply control unit (Item C)

Pin		Assignment/Component	Terminal
1	-	Vacant
2	-	SC35 - Fuse 35 on fuse holder C	RFL
3	-	Vacant
4	-	Vacant
5	-	Vacant
6	-	B520-Connection (RL), in main wiring harness	RFL

VW TRANSPORTER 2005 Contact assignment of pin connector -T5-, on onboard supply control unit (Item D)

Contact assignment of pin connector -T5-, on onboard supply control unit (Item D)

Pin		Assignment/Component	Terminal
1	-	J49-Electric fuel pump 2 relay	85
2	-	V - Windscreen wiper motor, Pin 1 (speed 2)	53b
3	-	V - Windscreen wiper motor, Pin 2 (speed 1)	53
4	-	370 - Earth connection 5, in main wiring harness	31
5	-	SB32 - Fuse 32 on fuse holder (windscreen wiper motor input)	30a

VW TRANSPORTER 2005 Contact assignment of pin connector -T5a-, on onboard supply control unit (Item E)

Contact assignment of pin connector -T5a-, on onboard supply control unit (Item E)

Pin		Assignment/Component	Terminal
1	-	SB3 - Fuse 3 on fuse holder B (input)	30a
2	-	H1 - Horn or dual tone horn (output) C13 - Positive connection in dual tone horn wiring harness (output)
3	-	SB13 - Fuse 13 on fuse holder B (horn or dual tone horn input)	30a
4	-	Z1-Heated rear window (output)
5	-	S41-Heated rear window fuse (input)	30a

VW TRANSPORTER 2005 Contact assignment of pin connector -T6c-, on onboard supply control unit (Item F)

Contact assignment of pin connector -T6c-, on onboard supply control unit (Item F)

Pin		Assignment/Component	Terminal
1	-	Vacant
2	-	Vacant
3	-	B441-Connection (CCS), in main wiring harness, GND on/off
4	-	E45-Cruise control system switch, T41 Pin 31, GND R
5	-	E45-Cruise control system switch, T41 Pin 27, GND memory
6	-	E45-Cruise control system switch, T41 Pin 30, GND memory

VW TRANSPORTER 2005 Contact assignment of pin connector -T18-, on onboard supply control unit (Item G)

Contact assignment of pin connector -T18-, on onboard supply control unit (Item G)

Pin		Assignment/Component	Terminal
1	-	B406-Connection 1 (convenience CAN bus, low), in main wiring harness	CAN-L
2	-	B397-Connection 1 (convenience CAN bus, high), in main wiring harness	CAN-H
3	-	Vacant
4	-	E2-Turn signal switch, T41 Pin 32 (right turn signal input)	BLR
5	-	SD18 - Fuse 18 on fuse holder D (input battery voltage measurement, positive)	30A
6	-	A - Battery (input battery voltage measurement, negative)	31
7	-	F2 - Driver door contact switch (input)
8	-	Vacant
9	-	O4 - Positive connection (30as), in seat heating wiring harness (deactivate - output J131, J132)
10	-	E3 - Hazard warning light switch (input)
11	-	F11 - Rear right door contact switch (J741 Pin 7), (input)
12	-	E2-Turn signal switch, T41 Pin 34 (left turn signal input)	BLL
13	-	F10 - Rear left door contact switch (J741 Pin 8), (input)
14	-	E15 - Heated rear window switch (input)
15	-	H-Horn plate, T41 Pin 10 (input)
16	-	F266 - Bonnet contact switch (input)
17	-	F3 - Front passenger door contact switch (input)
18	-	E231 - Exterior mirror heater button (input)

VW TRANSPORTER 2005 Contact assignment of pin connector -T6d-, on onboard supply control unit (Item H)

Contact assignment of pin connector -T6d-, on onboard supply control unit (Item H)

Pin		Assignment/Component		Terminal
1	-	J245 - Sliding sunroof adjustment control unit (output)
2	-	E180 - Heated windscreen switch (input)	¹)
3	-	G213 - Rain sensor, (signal - input)
4	-	J39 - Headlight washer system relay (output)		85
5	-	K122-Heated windscreen warning lamp	¹)
6	-	G213 - Rain sensor (GND)		31

VW TRANSPORTER 2005 Contact assignment of pin connector -T18a-, on onboard supply control unit (Item I)

Contact assignment of pin connector -T18a-, on onboard supply control unit (Item I)

Pin		Assignment/Component	Terminal
1	-	Vacant
2	-	K10 - Heated rear window warning lamp (output)
3	-	Vacant
4	-	F5 - Luggage compartment light switch (input via B475)
5	-	F111 - Rear lid contact switch (input via B534)
6	-	SB35 - Fuse 35 on fuse holder B (input via B340)	58d
7	-	V - Windscreen wiper motor (input)
8	-	D - Ignition/starter switch, Pin 8 (input - S-contact via SB19 and B518)	86s
9	-	E34 - Rear wiper switch, T41 Pin 20 (input - windscreen and rear window washer pump)
10	-	F4 - Reversing light switch (input - reversing lights via B520)	RFL
11	-	E38-Intermittent wipe regulator, T41 Pin 17 (input - intermittent)	INT
12	-	D-Ignition/starter switch, Pin 8 (input)	50b
13	-	C - Alternator (input - battery charge)	61
14	-	E22-Intermittent wiper switch, T41 Pin 16 (input - windscreen wiper speed 2)	53b
15	-	D-Ignition/starter switch, Pin 2 (input - X-contact via B173)	X
16	-	K6-Hazard warning light system warning lamp
17	-	Vacant
18	-	E22-Intermittent wiper switch, T41 Pin 16 (input - windscreen wiper speed 1)	53

VW TRANSPORTER 2005 Contact assignment of pin connector -T6e-, on onboard supply control unit (Item J)

Contact assignment of pin connector -T6e-, on onboard supply control unit (Item J)

Pin		Assignment/Component		Terminal
1	-	A18 - Windscreen heater voltage transformer (output)	¹)
2	- -	J7 - Battery isolation relay (output) J713 - Second battery charging circuit relay (output)		85 85
3	-	J207 - Starter inhibitor relay (output)		50a
4	-	J98 - Gearshift indicator control unit (output)
5	-	G213 - Rain sensor (voltage supply - output)		15
6	-	F125 - Multifunction switch (input - release AG)

Note

¹) is still not delivered

VW TRANSPORTER 2005 Contact assignment of pin connector -T41-, on steering column switch

Contact assignment of pin connector -T41-, on steering column switch

1 -	T41/1 - Steering angle sender (vacant)

2 -	T41/2 - Steering angle sender (CAN-low)

3 -	T41/3 - Steering angle sender (CAN-high)

4 -	T41/4 - Steering angle sender (terminal 31)

5 -	T41/5 - Steering angle sender (terminal 30)

6 -	T41/6 - Steering angle sender (terminal 15)

7 -	T41/7 - Airbag +

8 -	T41/8 - Airbag -

9 -	T41/9 - Horn 31/ multifunction steering wheel -

10 -	T41/10 - Horn 71a/ multifunction steering wheel - data wire

11 -	T41/11 - multifunction steering wheel +

12 -	T41/12 - vacant

13 -	T41/13 - vacant

14 -	T41/14 - vacant

15 -	T41/15 - terminal 53b, wiper 2nd speed

16 -	T41/16 - terminal 53b, wiper 1nd speed

17 -	T41/17 - wiper potentiometer

18 -	T41/18 - Multifunction indicator reset

19 -	T41/19 - Terminal 31

20 -	T41/20 - Terminal 53c

21 -	T41/21 - Rear wiper

22 -	T41/22 - Terminal 15

23 -	T41/23 - Multifunction indicator -

24 -	T41/24 - Multifunction indicator +

25 -	T41/25 - vacant

26 -	T41/26 - CCS - on/off

27 -	T41/27 - CCS memory

28 -	T41/28 - CCS terminal 15a

29 -	T41/29 - CCS - on/off

30 -	T41/30 - CCS SET

31 -	T41/31 - CCS resume

32 -	T41/32 - Right turn signal

33 -	T41/33 - Turn signal terminal 31

34 -	T41/34 - Left turn signal

35 -	T41/35 - Right parking light

36 -	T41/36 - Parking light (input)

37 -	T41/37 - Left parking light

38 -	T41/38 - Flasher terminal 30

39 -	T41/39 - Main beam terminal 56a

40 -	T41/40 - Dipped beam terminal 56b

41 -	T41/41 - Dipped beam/ main beam terminal 56

VW TRANSPORTER 2005 Contact assignment of pin connector -T41-, on steering column switch

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005 Contact assignment of pin connector -T16-, on diagnosis pin connector

Contact assignment of pin connector -T16-, on diagnosis pin connector

1 -	T16/1 - Terminal 15

4 -	T16/4 - Terminal 31

5 -	T16/5 - Terminal 31

6 -	T16/6 - CAN-H (motor, switched)

7 -	T16/7 K-diagnosis wiring

14 -	T16/14 - CAN-I (motor, switched)

16 -	T16/16 - Terminal 30

VW TRANSPORTER 2005 Control unit in dash panel insert -J285-

Control unit in dash panel insert -J285-

Note

The connector assignment on the dash panel insert despends on the equipment, the country and the engine version of the vehicle.

Получить доступ ко всем электросхемам автомобиля

T32 - 32 pin connector, blue

1 -	T32/1 - Terminal 15, positive

2 -	T32/2 - vacant

3 -	T32/3 - Speed signal-output

4 -	T32/4 - vacant

5 -	T32/5 - Fuel gauge sender

6 -	T32/6 - Warning lamp for daytime running lights

7 -	T32/7 - Terminal 31, sender earth

8 -	T32/8 - vacant

9 -	T32/9 - Terminal 31, earth

10 -	T32/10 - Oil pressure switch

11 -	T32/11 - vacant

12 -	T32/12 - vacant

13 -	T32/13 - vacant

14 -	T32/14 - Rear fog light warning lamp

15 -	T32/15 - vacant

16 -	T32/16 - vacant

17 -	T32/17 - Main beam warning lamp

18 -	T32/18 - vacant

19 -	T32/19 - vacant

20 -	T32/20 - vacant

21 -	T32/21 - vacant

22 -	T32/22 - Coolant shortage warning lamp

23 -	T32/23 - Terminal 30, positive

24 -	T32/24 - Terminal 31, earth

25 -	T32/25 - Self-diagnosis/ K-wire

26 -	T32/26 - Right parking light - input signal

27 -	T32/27 - Left parking light - input signal

28 -	T32/28 - Speed signal-input

29 -	T32/29 - Brake system warning lamp

30 -	T32/30 - S-contact

31 -	T32/31 - Belt switch warning lamp

32 -	T32/32 - vacant

Получить доступ ко всем электросхемам автомобиля

T32a - 32-pin connector, green

1 -	T32a/1 - Radio clock receiver, + 5 V

2 -	T32a/2 - Immobilizer reader coil

3 -	T32a/3 - Radio clock receiver, sender cable

4 -	T32a/4 - CAN

5 -	T3a2/5 - vacant

6 -	T32a/6 - Washer fluid level warning lamp

7 -	T32a/7 - Brake pad warning lamp

8 -	T32a/8 - CAN-H (convenience)

9 -	T32a/9 - CAN-L (convenience)

10 -	T32a/10 - Radio clock receiver, earth

11 -	T32a/11 - vacant

12 -	T32a/12 - vacant

13 -	T32a/13 - Handbrake warning-input

14 -	T32a/14 - vacant

15 -	T32a/15 - CAN-H (info)

16 -	T32a/16 - CAN-L (info)

17 -	T32a/17 - Immobilizer reader coil

18 -	T32a/18 - Oil level and oil temperature sender

19 -	T32a/19 - CAN-H (drive train)

20 -	T32a/20 - CAN-L (drive train)

21 -	T32a/21 - vacant

22 -	T32a/22 - vacant

23 -	T32a/23 - Multifunction indicator - up

24 -	T32a/24 - Multifunction indicator - down

25 -	T32a/25 - Multifunction indicator 1/2 - reset

26 -	T32a/26 - Ambient temperature sensor

27 -	T32a/27 - CAN-H (out)

28 -	T32a/28 - CAN-L (out)

29 -	T32a/29 - vacant

30 -	T32a/30 - vacant

31 -	T32a/31 - vacant

32 -	T32a/32 - vacant

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Overview of earth points in engine compartment

Overview of earth points in engine compartment

Получить доступ ко всем электросхемам автомобиля

1 -	Earth point, on left in engine compartment -12-

q	Location → page 801/2

2 -	Earth point, on right in engine compartment -13-

q	Location → page 801/2

3 -	Earth point, on gearbox -14-

q	Location → page 801/3

4 -	Earth point, on engine block -18-

q	Location → page 801/5

5 -	Earth point, near radiator fan control unit -29-

q	Location → page 801/3

6 -	Earth point, on left in plenum chamber -607-

q	Location → page 801/4

7 -	Earth point, starter battery -624-

q	Location → page 801/4

8 -	Earth point 2, on left in engine compartment -640-

q	Location → page 801/3

Note:

♦ Earth points for camper ⇒ Fitting Locations for camper

Transporter	Fitting Locations	No. 801 / 2

12	Earth point, on left in engine compartment ⇒ -arrow A-

TV7 -

Terminal 31 wiring junction

Earth point 1 ⇒ -arrow a-

Earth point 2 ⇒ -arrow b-

Earth point 3 ⇒ -arrow c-

Note:

♦ near headlight

Получить доступ ко всем электросхемам автомобиля

13	Earth point, in engine compartment, right ⇒ -arrow-

Note:

♦ near horn or dual tone horn

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 3

14	Earth point, on gearbox ⇒ -arrow-

Note:

♦ near starter

Получить доступ ко всем электросхемам автомобиля

29	Earth point, near radiator fan control unit ⇒ -arrow A-

640	Earth point 2, on left in engine compartment ⇒ -arrow B-

Note:

♦ on longitudinal member

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 4

607	Earth point, on left in plenum chamber ⇒ -arrow-

Note:

♦ near windscreen wiper motor

Получить доступ ко всем электросхемам автомобиля

624	Earth point, starter battery ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 5

18	Earth point on engine block ⇒ -arrow A-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 6

Overview of earth points in passenger compartment

Получить доступ ко всем электросхемам автомобиля

1 -	Earth point, under driver seat -34-

q	Location → page 801/8

2 -	Earth point, under front passenger seat -35-

q	Location → page 801/8

3 -	Earth point, near bulkhead -49-

q	Location → page 801/9

4 -	Earth point, on top end of steering column -605-

q	Location → page 801/10

5 -	Earth point (audio), under centre console, front -610-

q	Location → page 801/9

6 -	Earth point, onboard supply control unit -636-

q	Location → page 801/9

7 -	Earth point, airbag control unit -637-

q	Location → page 801/9

Transporter	Fitting Locations	No. 801 / 7

Получить доступ ко всем электросхемам автомобиля

8 -	Earth point, right A-pillar -638-

q	Location → page 801/10

9 -	Earth point, left A-pillar -639-

q	Location → page 801/11

10 -	Earth point 2, left A-pillar -670-

q	Location → page 801/11

Transporter	Fitting Locations	No. 801 / 8

34	Earth point under driver seat ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

35	Earth point under front passenger seat ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 9

49	Earth point, near bulkhead ⇒ -arrow D-

610	Earth point (audio), under centre console, front ⇒ -arrow B-

636	Earth point, onboard supply control unit ⇒ -arrow C-

637	Earth point, airbag control unit ⇒ -arrow A-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 10

605	Earth point, on top end of steering column ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

638	Earth point, right A-pillar ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 11

639	Earth point, left A-pillar ⇒ -arrow A-

670	Earth point 2, left A-pillar ⇒ -arrow B-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 12

Earth point, in luggage compartment

Получить доступ ко всем электросхемам автомобиля

1 -	Earth point, left D-pillar -653-

q	Location ⇒ from page → 801/13

2 -	Earth point, right D-pillar -654-

q	Location ⇒ from page → 801/14

3 -	Earth point 2, left D-pillar -668-

q	Location ⇒ from page → 801/13

4 -	Earth point 2, right D-pillar -669-

q	Location ⇒ from page → 801/14

Note:

♦ Earth points for camper ⇒ Fitting Locations for camper

Transporter	Fitting Locations	No. 801 / 13

653	Earth point, left D-pillar ⇒ -arrow A-

668	Earth point 2, left D-pillar ⇒ -arrow B-

Note:

♦ for models with short wheel base only

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 14

653	Earth point, left D-pillar ⇒ -arrow B-

668	Earth point 2, left D-pillar ⇒ -arrow A-

Note:

♦ for models with long wheel base only

Получить доступ ко всем электросхемам автомобиля

654	Earth point, right D-pillar ⇒ -arrow A-

669	Earth point 2, right D-pillar ⇒ -arrow B-

Note:

♦ for models with long wheel base only

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 15

654	Earth point, right D-pillar ⇒ -arrow A-

669	Earth point 2, right D-pillar ⇒ -arrow B-

Note:

♦ for models with short wheel base only

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No. 801 / 16

Earth points platform/double cab

Получить доступ ко всем электросхемам автомобиля

1 -	Earth point, on left of rear cross member -68-

q	Location → page 801/17

Transporter	Fitting Locations	No. 801 / 17

68	Earth point, on left of rear cross member ⇒ -arrow A-

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2005 Overview of fuse carrier

Overview of fuse carrier

Получить доступ ко всем электросхемам автомобиля

1 -	Fuses (SB) on fuse holder B, in centre of dash panel

q	Location: → Chapter

q	Position of fuses, from March 2003 → chapter

q	Position of fuses, from June 2004 → chapter

q	Position of fuses, from August 2006 → chapter

q	Position of fuses, from November 2007 → chapter

2 -	Fuses (SC) on fuse holder C, in centre of dash panel

q	Location: → Chapter

q	Position of fuses, from March 2003 → chapter

q	Position of fuses, from June 2004 → chapter

q	Position of fuses, from August 2006 → chapter

q	Position of fuses, from November 2007 → chapter

VW TRANSPORTER 2005 Fuse (SB) on fuse holder B

Fuse (SB) on fuse holder B

Location:

Получить доступ ко всем электросхемам автомобиля

t	In the upper fuse box on centre of dash panel

Fuse colours

40 A - blue

30 A - green

25 A - white

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

–	Back to overview → chapter

Position of fuses, from March 2003

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	30 A	- - -	J18 - X-contact relay J487 - Fresh air blower isolation relay V306-Rear blower Bitron regulation motor³⁾	30
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay⁵⁾	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 3²⁾	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 6²⁾	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	15 A	-	F - Brake light switch¹⁾	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch²⁾	30
10	-	SB10 - Fuse 10 on fuse holder B	5 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	- -	E20 - Switches and instruments illumination regulator X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	- -	J419-Brake light additional relay⁴⁾ J234 - Airbag control unit⁵⁾	15
14	-	SB14 - Fuse 14 on fuse holder B	30 A	- - - -	E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor	30 or 75x
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - -	E30 - Air conditioning system switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	15
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple⁶⁾ U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	10 A	- - -	J285 - Control unit in dash panel insert K45 - Front differential lock warning lamp T16 - 16-pin connector, diagnostic connector	15
23	-	SB23 - Fuse 23 on fuse holder B	25 A	-	U10 -Trailer socket⁴⁾	30
			25 A	-	B-Starter⁸⁾	50
			5 A	-	J207 - Starter inhibitor relay⁷⁾	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- -	E30 - Air conditioning system switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch⁵⁾	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 4⁶⁾	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 7⁶⁾	56a
29	-	SB29 - Fuse 29 on fuse holder B		-	Vacant	-
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - -	G22-Speedometer sender G70 - Air mass meter J60 - Automatic gearbox relay J623 - Engine control unit	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note

t	¹⁾ applicable up to August 2003

t	²⁾ applicable from September 2003

t	³⁾ applicable from June 2003

t	⁴⁾ applicable up to January 2004

t	⁵⁾ applicable from February 2004

t	⁶⁾ for models with electric interface only (UF1)

t	⁷⁾ applicable from February 2004, manual gearbox with electric interface

t	⁸⁾ applicable from February 2004, for manual gearbox without electric interface only

–	Back to overview → chapter

Position of fuses, from June 2004

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay	30
1	-	SB1 - Fuse 1 on fuse holder B	30 A	-	V306-Rear blower Bitron regulation motor	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 3²⁾	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 6²⁾	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)¹⁾	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch	30
10	-	SB10 - Fuse 10 on fuse holder B	10 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	-	X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	-	J234 - Airbag control unit	15
14	-	SB14 - Fuse 14 on fuse holder B	30 A	- - - -	E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor	30 or 75x
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - - - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	15³⁾ 15⁴⁾ 75x⁵⁾
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 1²⁾	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple²⁾ U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	10 A	- - -	J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector	15
23	-	SB23 - Fuse 23 on fuse holder B	40 A	-	B-Starter⁶⁾	50
			25 A	-	B-Starter⁷⁾	50
			30 A	-	B-Starter⁸⁾	50
			5 A	-	J207 - Starter inhibitor relay⁹⁾	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 4²⁾	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 7²⁾	56a
29	-	SB29 - Fuse 29 on fuse holder B	10 A	-	J741-Dual signal inverter relay	30
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - - - - - - - - -	J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note

t	¹⁾ for models with roof console only

t	²⁾ for models with electric interface only (UF1)

t	³⁾ for models with Climatronic only

t	⁴⁾ for models without Climatronic only, applicable up to December 2005

t	⁵⁾ for models without Climatronic only, applicable from January 2006

t	⁶⁾ for models with manual gearbox and without electric interface only, applicable up to December 2004

t	⁷⁾ for models with manual gearbox and without electric interface only, applicable from January 2005 up to December 2005

t	⁸⁾ for models with manual gearbox and without electric interface only, applicable from January 2006

t	⁹⁾ for models with manual gearbox and electric interface only

–	Back to overview → chapter

Fuse location from August 2006

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay	30
1	-	SB1 - Fuse 1 on fuse holder B	30 A	-	V306-Rear blower Bitron regulation motor	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 3²⁾	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 6²⁾	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)¹⁾	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch	30
10	-	SB10 - Fuse 10 on fuse holder B	10 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	-	X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	-	J234 - Airbag control unit	15
14	-	SB14 - Fuse 14 on fuse holder B	30 A	- - - -	E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor	30 or 75x
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - - - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	15³⁾ 75x⁴⁾
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 1²⁾	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple²⁾ U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	10 A	- - - -	J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector T16j - 16-pin connector, diagnostic connector 2⁵⁾	15
23	-	SB23 - Fuse 23 on fuse holder B	30 A	-	B-Starter⁶⁾	50
23	-	SB23 - Fuse 23 on fuse holder B	5 A	-	J207 - Starter inhibitor relay⁷⁾	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 4²⁾	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 7²⁾	56a
29	-	SB29 - Fuse 29 on fuse holder B	10 A	-	J741-Dual signal inverter relay	30
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - - - - - - - - -	J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note

t	¹⁾ for models with roof console only

t	²⁾ for models with electric interface only (UF1)

t	³⁾ for models with Climatronic only

t	⁴⁾ for models without Climatronic only

t	⁵⁾ applicable from June 2007

t	⁶⁾ for models with manual gearbox and without electric interface only

t	⁷⁾ for models with manual gearbox and electric interface only

–	Back to overview → chapter

Position of fuses, from November 2007

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay	30
1	-	SB1 - Fuse 1 on fuse holder B	30 A	-	V306-Rear blower Bitron regulation motor	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 3²⁾	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 6²⁾	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)¹⁾	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch	30
10	-	SB10 - Fuse 10 on fuse holder B	10 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	-	X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	-	J234 - Airbag control unit	15
14	-	SB14 - Fuse 14 on fuse holder B	-	-	Vacant	-
14	-	SB14 - Fuse 14 on fuse holder B	30 A	-	E4 - Headlight dipper/flasher switch⁵⁾	30
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - - - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	15³⁾ 75x⁴⁾
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 1²⁾	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple²⁾ U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	7,5 A	- - - -	J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector T16j - 16-pin connector, diagnostic connector 2	15
23	-	SB23 - Fuse 23 on fuse holder B	30 A	-	B-Starter⁶⁾	50
23	-	SB23 - Fuse 23 on fuse holder B	5 A	- -	J207 - Starter inhibitor relay⁷⁾ T10bj-10-pin connector, yellow⁷⁾	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 4²⁾	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 7²⁾	56a
29	-	SB29 - Fuse 29 on fuse holder B	10 A	-	J741-Dual signal inverter relay	30
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - - - - - - - - -	J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note

t	¹⁾ for models with roof console only

t	²⁾ for models with electric interface only (UF1)

t	³⁾ for models with Climatronic only

t	⁴⁾ for models without Climatronic only

t	⁵⁾ applicable from June 2008

t	⁶⁾ for models with manual gearbox and without electric interface only

t	⁷⁾ for models with manual gearbox and electric interface only

–	Back to overview → chapter

Fuses (SC) on fuse holder C

Location:

Получить доступ ко всем электросхемам автомобиля

t	In the lower fuse box on centre of dash panel

Fuse colours

30 A - blue

30 A - green

25 A - white

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

–	Back to overview → chapter

Position of fuses, from March 2003

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	15 A	-	U18 - 12 V socket -2-	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G303 - Interior monitor send and receive module 1 G305 - Interior monitor send and receive module 2	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower V321 - Left auxiliary blower	75x
4	-	SC4 - Fuse 4 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
5	-	SC5-Fuse 5 on fuse holder C	15 A	-	J698-Refrigerator box	30
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	J180 - Switch-over relay 1 for roof ventilator	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	20 A	- - - -	J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J493-Auxiliary coolant heater relay¹⁾	75x
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay²⁾	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	-	J503 - Control unit with display for radio and navigation system	15
17	-	SC17 - Fuse 17 on fuse holder C	5 A 7,5 A	- -	E265 - Rear Climatronic operating and display unit¹⁾ J519 - Onboard power supply control unit (interior light)²⁾	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	- -	E179 - Rear fresh air blower switch E265 - Rear Climatronic operating and display unit²⁾	15 30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	G303 - Interior monitor send and receive module 1	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	5 A³⁾ 10 A⁴⁾	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment¹⁾	15
25	-	SC25 - Fuse 25 on fuse holder C	15 A	- - - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator G59 - Driver seat temperature sensor G60 - Front passenger seat temperature sensor	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 8⁶⁾^,⁷⁾	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	-	E43 - Mirror adjustment switch	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	J493-Auxiliary coolant heater relay¹⁾	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph	15
34	-	SC34 - Fuse 34 on fuse holder C	20 A	-	V192 - Vacuum pump for brakes¹⁾	75x
34	-	SC34 - Fuse 34 on fuse holder C	25 A	-	U10 -Trailer socket²⁾	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard power supply control unit	30
36	-	SC36 - Fuse 36 on fuse holder C	15 A	-	U20 - 12 V socket -4-⁵⁾	30
			5 A	- -	E153 - Operating and display unit for camping equipment⁶⁾ Special vehicles⁶⁾^,⁷⁾	15
			5 A	- -		15

Note

t	¹⁾ applicable up to January 2004

t	²⁾ applicable from February 2004

t	³⁾ applicable up to May 2003

t	⁴⁾ applicable from June 2003

t	⁵⁾ applicable up to May 2004

t	⁶⁾ applicable from March 2004

t	⁷⁾ for models with electric interface only (UF1)

–	Back to overview → chapter

Position of fuses, from June 2004

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	25 A	-	U10 -Trailer socket	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower V321 - Left auxiliary blower	75x
4	-	SC4 - Fuse 4 on fuse holder C	10 A	-	J492 - Four-wheel drive control unit	15
5	-	SC5-Fuse 5 on fuse holder C	10 A	-	T6bn-6-pin connector, grey	75x
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	B320 - Positive connection -6- (30), in main wiring harrness¹⁾	30
7	-	SC7 - Fuse 7 on fuse holder C	15 A	-	U20 - 12 V socket -4-²⁾	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	15 A	-	J605 - Rear lid control unit	30
11	-	SC11 - Fuse 11 on fuse holder C	20 A	- - - - -	H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay	15
12	-	SC12 - Fuse 12 on fuse holder C	10 A	-	J419-Brake light additional relay³⁾^,⁷⁾	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	- -	J503 - Control unit with display for radio and navigation system J412 - Mobile telephone operating electronics control unit	15
17	-	SC17 - Fuse 17 on fuse holder C	7,5 A	- -	J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E179 - Rear fresh air blower switch	15
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E265 - Rear Climatronic operating and display unit	30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	J529-Anti-theft and tilt system control unit	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	10 A	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	7,5 A	-	B250-Positive connection in roof wiring harness (interior lighting)	30g
25	-	SC25 - Fuse 25 on fuse holder C	15 A	- - - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J131 - Heated driver seat control unit J132 - Heated front passenger seat control unit	75x
25	-	SC25 - Fuse 25 on fuse holder C	25 A	-	J774 -Heated front seats control unit⁷⁾	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph⁴⁾	30
26	-	SC26 - Fuse 26 on fuse holder C	15 A	-	U18 - 12 V socket -2-⁵⁾	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 8⁶⁾	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	-	E43 - Mirror adjustment switch	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	J493-Auxiliary coolant heater relay	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph	15
34	-	SC34 - Fuse 34 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard supply control unit (reversing light models with automatic gearbox)	30
36	-	SC36 - Fuse 36 on fuse holder C	5 A	- -	E153 - Operating and display unit for camping equipment Special vehicles⁶⁾	15

Note

t	¹⁾ applicable up to December 2004

t	²⁾ applicable from January 2005

t	³⁾ for models with TSP only

t	⁴⁾ for models with tachograph only

t	⁵⁾ Multivan without tachograph and second battery only

t	⁶⁾ for models with electric interface only (UF1)

t	⁷⁾ applicable from January 2006

–	Back to overview → chapter

Fuse location from August 2006

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	25 A	-	U10 -Trailer socket	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower V321 - Left auxiliary blower	75x
4	-	SC4 - Fuse 4 on fuse holder C	10 A	-	J492 - Four-wheel drive control unit	15
5	-	SC5-Fuse 5 on fuse holder C	10 A	-	T6bn-6-pin connector, grey	75x
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	B320 - Positive connection -6- (30), in main wiring harrness (roof ventilator)	30
7	-	SC7 - Fuse 7 on fuse holder C	15 A	-	U20 - 12 V socket -4-	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	15 A	-	J605 - Rear lid control unit	30
11	-	SC11 - Fuse 11 on fuse holder C	20 A	- - - - -	H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay	15
12	-	SC12 - Fuse 12 on fuse holder C	10 A	-	J419-Brake light additional relay¹⁾	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	- -	J412 - Mobile telephone operating electronics control unit J503 - Control unit with display for radio and navigation system	15
17	-	SC17 - Fuse 17 on fuse holder C	7,5 A	- -	J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E179 - Rear fresh air blower switch	15
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E265 - Rear Climatronic operating and display unit	30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	J529-Anti-theft and tilt system control unit	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	10 A	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	7,5 A	-	B250-Positive connection in roof wiring harness (interior lighting)	30g
25	-	SC25 - Fuse 25 on fuse holder C	25 A	- - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J774 -Heated front seats control unit	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph²⁾	30
26	-	SC26 - Fuse 26 on fuse holder C	15 A	-	U18 - 12 V socket -2-³⁾	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 8⁴⁾	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	- -	E43 - Mirror adjustment switch J386 - Driver door control unit	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	J493-Auxiliary coolant heater relay	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
31	-	SC31 - Fuse 31 on fuse holder C	5 A	-	A11 - Onboard supply charger unit⁵⁾	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph²⁾	15
			15 A	- -	G24 - Tachograph⁶⁾ J351 - Folding exterior mirror control unit⁶⁾	15
			15 A	-	J351 - Folding exterior mirror control unit⁷⁾	15
34	-	SC34 - Fuse 34 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard supply control unit (reversing light models with automatic gearbox)	30
36	-	SC36 - Fuse 36 on fuse holder C	5 A	- -	E153 - Operating and display unit for camping equipment Special vehicles⁴⁾	15

Note

t	¹⁾ for models with TSP only

t	²⁾ for models with tachograph only

t	³⁾ Multivan without tachograph and second battery only

t	⁴⁾ for models with electric interface only (UF1)

t	⁵⁾ for camper only, applicable from November 2006

t	⁶⁾ for models with tachograph and electric folding exterior mirror only

t	⁷⁾ for models with electric folding exterior mirror only

–	Back to overview → chapter

Position of fuses, from November 2007

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	25 A	-	U10 -Trailer socket	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower¹⁾ V321 - Left auxiliary blower¹⁾	75x
			-	-	Vacant²⁾^,¹⁰⁾	-
			30 A	-	J519 - Onboard power supply control unit (heated rear window)¹¹⁾	30
4	-	SC4 - Fuse 4 on fuse holder C	10 A	- - -	E121 - Rear differential lock switch J187-Differential lock control unit J492 - Four-wheel drive control unit	15
5	-	SC5-Fuse 5 on fuse holder C	10 A	-	T6bn-6-pin connector, grey	75x
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	B320 - Positive connection -6- (30), in main wiring harrness (roof ventilator)	30
7	-	SC7 - Fuse 7 on fuse holder C	15 A	-	U20 - 12 V socket -4-	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	15 A	-	J605 - Rear lid control unit	30
11	-	SC11 - Fuse 11 on fuse holder C	20 A	- - - - -	H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay	15
12	-	SC12 - Fuse 12 on fuse holder C	10 A	-	J419-Brake light additional relay³⁾	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	-	J503 - Control unit with display for radio and navigation system	15
17	-	SC17 - Fuse 17 on fuse holder C	7,5 A	- -	J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E179 - Rear fresh air blower switch	15
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E265 - Rear Climatronic operating and display unit	30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	J529-Anti-theft and tilt system control unit	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	10 A	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	7,5 A	-	B250-Positive connection in roof wiring harness (interior lighting)	30g
25	-	SC25 - Fuse 25 on fuse holder C	25 A	- - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J774 -Heated front seats control unit	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph⁷⁾	30
26	-	SC26 - Fuse 26 on fuse holder C	15 A	-	U18 - 12 V socket -2-⁵⁾	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 8⁶⁾	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	- -	E43 - Mirror adjustment switch J386 - Driver door control unit	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	J493-Auxiliary coolant heater relay	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
31	-	SC31 - Fuse 31 on fuse holder C	5 A	-	A11 - Onboard supply charger unit⁴⁾	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph⁷⁾	15
			15 A	- -	G24 - Tachograph⁸⁾ J351 - Folding exterior mirror control unit⁸⁾	15
			15 A	-	J351 - Folding exterior mirror control unit⁹⁾	15
34	-	SC34 - Fuse 34 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard supply control unit (reversing light models with automatic gearbox)	30
36	-	SC36 - Fuse 36 on fuse holder C	5 A	- -	E153 - Operating and display unit for camping equipment T10bh-10-pin connector, purple⁶⁾	15

Note

t	¹⁾ applicable up to May 2008

t	²⁾ applicable from June 2008

t	³⁾ for models with TSP only

t	⁴⁾ for camper only

t	⁵⁾ Multivan without tachograph and second battery only

t	⁶⁾ for models with electric interface only (UF1)

t	⁷⁾ for models with tachograph only

t	⁸⁾ for models with tachograph and electric folding exterior mirror only

t	⁹⁾ for models with electric folding exterior mirror only

t	¹⁰⁾ applicable up to October 2008

t	¹¹⁾ applicable from November 2008

–	Back to overview → chapter

VW TRANSPORTER 2005 — 2.5 l/120 kW — Turbodiesel engine, engine code BLJ . Wiring diagrams, Pin Connector, Location

Wiring Diagram VW TRANSPORTER 2005 - Battery - alternator - starter - fuses - terminal 30 voltage supply relay

Wiring Diagram VW TRANSPORTER 2005 - Glow plug relay - additional coolant pump relay - glow plugs - fuses - ignition/starter switch

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - unit injector valves

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - fuel temperature sender - fuel pump relay - exhaust gas recirculation valve - charge pressure control solenoid valve - charge pressure control solenoid valve

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - engine speed sender - charge air pressure sender - Hall sender - intake air temperature sender

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - coolant temperature sender - air mass meter - heater element for crankcase breather

Wiring Diagram VW TRANSPORTER 2005 - Engine control unit - brake pedal switch - brake light switch - clutch pedal switch - brake light bulbs

Wiring Diagram VW TRANSPORTER 2005 - Radiator fan control unit - radiator fan - radiator fan control unit - accelerator position sender - idling speed switch - kick-down switch

Wiring Diagram VW TRANSPORTER 2005 - Dash panel inser - data bus diagnostic interface - fuel gauge sender - fuel system pressurisation pump - warning lamps

Wiring Diagram VW TRANSPORTER 2005 - Control unit in dash panel insert - oil pressure switch - oil level and oil temperature sender - warning lamps

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Overview:

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Engine compartment

VW TRANSPORTER 2005 ABS control unit J104

VW TRANSPORTER 2005 Automatic gearbox control unit J217

VW TRANSPORTER 2005 Radiator fan control unit J293

VW TRANSPORTER 2005 Onboard supply control unit J519

VW TRANSPORTER 2005 Control unit in dash panel insert J285

VW TRANSPORTER 2005 Parking aid control unit J446

VW TRANSPORTER 2005 Driver door control unit J386

VW TRANSPORTER 2005 Airbag control unit J234

VW TRANSPORTER 2005 Interior monitor send and receive module 2 G305

VW TRANSPORTER 2005 Heated front seats control unit J774

VW TRANSPORTER 2005 Sliding sunroof adjustment control unit J245

VW TRANSPORTER 2005 Aerial selection control unit J515

VW TRANSPORTER 2005 Mobile telephone operating electronics control unit J412

VW TRANSPORTER 2005 Traffic information control unit J559

VW TRANSPORTER 2005 Traffic information control unit J559

VW TRANSPORTER 2005 Front passenger door control unit J387

VW TRANSPORTER 2005 Gearshift indicator control unit J98

VW TRANSPORTER 2005 Rotating light and siren system control unit J23

VW TRANSPORTER 2005

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Rear lid control unit J605

VW TRANSPORTER 2005

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Convenience system central control unit J393

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Four-wheel drive control unit J492

VW TRANSPORTER 2005 Overview:

VW TRANSPORTER 2005 Onboard power supply control unit -J519-

VW TRANSPORTER 2005 Contact assignment of pin connector -T6-, on onboard supply control unit (Item A)

VW TRANSPORTER 2005 Contact assignment of pin connector -T6a-, on onboard supply control unit (Item A)

VW TRANSPORTER 2005 Contact assignment of pin connector -T6b-, on onboard supply control unit (Item C)

VW TRANSPORTER 2005 Contact assignment of pin connector -T5-, on onboard supply control unit (Item D)

VW TRANSPORTER 2005 Contact assignment of pin connector -T5a-, on onboard supply control unit (Item E)

VW TRANSPORTER 2005 Contact assignment of pin connector -T6c-, on onboard supply control unit (Item F)

VW TRANSPORTER 2005 Contact assignment of pin connector -T18-, on onboard supply control unit (Item G)

VW TRANSPORTER 2005 Contact assignment of pin connector -T6d-, on onboard supply control unit (Item H)

VW TRANSPORTER 2005 Contact assignment of pin connector -T18a-, on onboard supply control unit (Item I)

VW TRANSPORTER 2005 Contact assignment of pin connector -T6e-, on onboard supply control unit (Item J)

VW TRANSPORTER 2005 Contact assignment of pin connector -T41-, on steering column switch

VW TRANSPORTER 2005 Contact assignment of pin connector -T16-, on diagnosis pin connector

VW TRANSPORTER 2005 Control unit in dash panel insert -J285-

VW TRANSPORTER 2005

VW TRANSPORTER 2005 Overview of earth points in engine compartment

VW TRANSPORTER 2005 Overview of fuse carrier

VW TRANSPORTER 2005 Fuse (SB) on fuse holder B

Войти

Регистрация

Получить новый пароль