| A | Battery |
| B | Starter |
| C | Alternator |
| C1 | Voltage regulator |
| D | Ignition/starter switch |
| J59 | X-contact relief relay |
| S162 | Fuse 1 (30) in fuse holder on battery |
| S163 | Fuse 2 (30) in fuse holder on battery |
| S176 | Fuse 4 (30) in fuse holder on battery |
| S177 | Fuse 5 (30) in fuse holder on battery |
| S229 | Fuse on fuse holder |
| T2k | 2-pin connector, on engine |
| T4l | 4-pin connector, on engine |
| T6l | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| 500 | Screw connection 1 (30), on relay plate |
| 501 | Screw connection 2 (30), on relay plate |
| 502 | Screw connection 1 (30a), on relay plate |
| A2 | Positive connection (15), in dash panel wiring harness |
| A32 | Positive connection (30), in dash panel wiring harness |
| * | only models with air conditioning system |
| ** | only models with auxiliary heater |
| F8 | Kick-down switch |
| F60 | Idling speed switch |
| G79 | Accelerator position sender |
| J52 | Glow plug relay |
| J248 | Diesel direct injection system control unit |
| J317 | Terminal 30 voltage supply relay |
| Q6 | Engine glow plug |
| T2j | 2-pin connector, in engine compartment |
| T6l | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T6m | 6-pin connector, on accelerator |
| T10 | 10-pin connector, orange, in connector protective housing, on left in plenum chamber |
| T10h | 10-pin connector, blue, in connector protective housing, on left in plenum chamber |
| T121 | 121-pin connector |
| 504 | Screw connection 1 (87F), on relay plate |
| A104 | Positive connection 2 (15), in dash panel wiring harness |
| * | Wire W for self-diagnosis |
| G2 | Coolant temperature display sender |
| G28 | Engine speed sender |
| G62 | Coolant temperature display sender |
| G71 | Intake manifold pressure sender |
| G72 | Intake manifold temperature sender |
| J248 | Diesel direct injection system control unit |
| J293 | Radiator fan control unit |
| T3d | 3-pin connector, near intake manifold |
| T6na | 6-pin connector |
| T10d | 10-pin connector, green, in connector protective housing, on left in plenum chamber |
| T14a | 14-pin connector, in left wiring harness |
| T121 | 121-pin connector |
| 200 | Earth connection (screening), in engine compartment wiring harness |
| E35 | Air conditioning system switch |
| G40 | Hall sender |
| G81 | Fuel temperature sender |
| J248 | Diesel direct injection system control unit |
| J255 | Climatronic control unit |
| J293 | Radiator fan control unit |
| N240 | Unit injector valve, No. 1 cyl. |
| N241 | Unit injector valve, No. 2 cyl. |
| N242 | Unit injector valve, No. 3 cyl. |
| N243 | Unit injector valve, No. 4 cyl. |
| T8l | 8-pin connector |
| T8x | 8-pin connector, near injection pump |
| T10 | 10-pin connector, orange, in connector protective housing, on left in plenum chamber |
| T10d | 10-pin connector, green, in connector protective housing, on left in plenum chamber |
| T12e | 12-pin connector |
| T14 | 14-pin connector |
| T16b | 16-pin connector |
| T121 | 121-pin connector |
| * | only models with multifunction display |
| G70 | Air mass meter |
| J104 | ABS control unit with EDL |
| J248 | Diesel direct injection system control unit |
| N18 | Exhaust gas recirculation valve |
| N75 | Charge pressure control solenoid valve |
| N239 | Variable intake manifold flap change-over valve |
| S10 | Fuse in relay plate fuse holder |
| S237 | Fuse on fuse holder |
| T10d | 10-pin connector, green, in connector protective housing, on left in plenum chamber |
| T10y | 10-pin connector, on front of engine |
| T14a | 14-pin connector, in left wiring harness |
| T25 | 25-pin connector |
| T47 | 47-pin connector |
| T121 | 121-pin connector |
| A80 | Connection 1 (X), in dash panel wiring harness |
| D102 | Connection 2, in engine compartment wiring harness |
| * | only models with auxiliary heater |
| ** | only models up to October 2001 |
| *** | only models from November 2001 |
| E45 | Cruise control system switch (00671) |
| E227 | Cruise control system (CCS) SET button |
| F | Brake light switch (00526-2131) |
| F36 | Clutch pedal switch (00650) |
| F47 | Cruise control system brake pedal switch/diesel direct injection system (00629) |
| J248 | Diesel direct injection system control unit |
| S13 | Fuse in relay plate fuse holder |
| T10d | 10-pin connector, green, in connector protective housing, on left in plenum chamber |
| T10e | 10-pin connector, black, in connector protective housing, on left in plenum chamber |
| T10s | 10-pin connector, right next to steering column |
| T121 | 121-pin connector |
| A98 | Positive connection 4 (30), in dash panel wiring harness |
| W1 | Positive connection 1 (54), in rear wiring harness |
| J248 | Diesel direct injection system control unit |
| J359 | Low heat output relay (01193) |
| J360 | High heat output relay (01194) |
| N51 | Intake manifold preheating heater element |
| Q7 | Coolant heating element |
| T6l | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T10 | 10-pin connector, orange, in connector protective housing, on left in plenum chamber |
| T10e | 10-pin connector, black, in connector protective housing, on left in plenum chamber |
| T10y | 10-pin connector, on front of engine |
| T121 | 121-pin connector |
| 10 | Earth point, in plenum chamber |
| 131 | Earth connection 2, in engine compartment wiring harness |
| A27 | Connection (speed signal), in dash panel wiring harness |
| D50 | Positive connection (30), in engine compartment wiring harness |
| D74 | Connection (86), in engine compartment wiring harness |
| D98 | Connection (glow plugs), in engine compartment wiring harness |
| D111 | Connection 9, in engine compartment wiring harness |
| * | only models with auxiliary heater |
| ** | for models with additional glow plug only |
| G | Fuel gauge sender |
| G6 | Fuel system pressurisation pump |
| G32 | Coolant shortage indicator sender |
| G169 | Fuel gauge sender 2 |
| J17 | Fuel pump relay |
| S5 | Fuse in relay plate fuse holder |
| T6l | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T10d | 10-pin connector, green, in connector protective housing, on left in plenum chamber |
| T14a | 14-pin connector, in left wiring harness |
| 81 | Earth connection 1, in dash panel wiring harness |
| 269 | Earth connection (sender earth) 1, in dash panel wiring harness |
| A20 | Connection (15a), in dash panel wiring harness |
| A71 | Connection (86), in dash panel wiring harness |
| A100 | Connection 2 (87), in dash panel wiring harness |
| B168 | Connection (86), in interior wiring harness |
| B429 | Connection (EFPR), in main wiring harness |
| * | only for 2V |
| D | Ignition/starter switch |
| F1 | Oil pressure switch |
| G22 | Speedometer |
| G266 | Oil level and oil temperature sender |
| J285 | Control unit with display in dash panel insert |
| K3 | Oil pressure warning lamp |
| K83 | Exhaust emissions warning lamp |
| S7 | Fuse in relay plate fuse holder |
| T14a | 14-pin connector, in left wiring harness |
| T32 | 32-pin connector, blue, on dash panel insert |
| T32a | 32-pin connector, green, on dash panel insert |
| 10 | Earth point, in plenum chamber |
| 85 | Earth connection 1, in engine compartment wiring harness |
| A20 | Connection (15a), in dash panel wiring harness |
| B163 | Positive connection 1 (15), in interior wiring harness |
| * | only models with extended servicing intervals |
| G1 | Fuel gauge (00664) |
| G3 | Coolant temperature gauge |
| G21 | Speedometer (00663) |
| H11 | Oil pressure warning buzzer |
| J285 | Control unit with display in dash panel insert (01317) |
| K2 | Alternator warning lamp |
| K28 | Coolant temperature and coolant shortage warning lamp |
| K105 | Reserve fuel warning lamp (01082) |
| T32 | 32-pin connector, blue, on dash panel insert |
| T32a | 32-pin connector, green, on dash panel insert |
| * | Wire W for self-diagnosis |
| E86 | Multifunction display call-up button |
| E109 | Multifunction display memory switch |
| G5 | Rev. counter (00662) |
| J119 | Multifunction display |
| J255 | Climatronic control unit (01320) |
| J285 | Control unit with display in dash panel insert (01317) |
| K29 | Glow period warning lamp (00626) |
| T6d | 6-pin connector |
| T12d | 12-pin connector, on Climatronic |
| T16b | 16-pin connector |
| T32 | 32-pin connector, blue, on dash panel insert |
| T32a | 32-pin connector, green, on dash panel insert |
| A27 | Connection (speed signal), in dash panel wiring harness |
| * | only models with multifunction display |
English
