All Wiring Diagrams for Chevrolet Malibu LT 2004

AIR CONDITIONING

Automatic A/C Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for Automatic A/C Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• (behind grille, on left side of impact bar) ambient air temperature sensor
• (center console, front of body control module)
• (center console, front of body control module) g203
• A/c clu fuse 1 10a
• A/c clutch relay
• A/c compressor clutch
• A/c request ind
• A/c request switch
• A10
• A11
• A11 c2
• A12
• A2 c1
• A3 c1
• B1 c1
• B10
• B10 c2
• B11
• B12
• B9 c3
• Bat
• Batt
• Blower motor (below right side of dash)
• Blower motor control module (right side of dash, rear of hvac case)
• Blower motor switch
• Blr mtr spd ctrl
• Blr spd req sig
• C/fan 1 fuse 17 30a
• C/fan 2 fuse 18 30a
• C1 e3
• C2 a5
• C2 c4
• C3 b8
• Computer data lines system
• Cool fan 1 relay
• Cool fan 2 relay
• Cool ser/par relay
• Dr ctrl a
• Dr ctrl b
• E1 c2
• E8 c1
• Fresh air ind
• G106 (on trans, near pnp switch)
• G201
• Grd
• Hot at all times
• Hot in run or start
• Hvac control module (center of dash)
• Ign 3
• Inside air temperature sensor
• Interior lights system
• Left cooling fan
• Lmp sply voltage
• Logic
• Low ref
• Low spd gmlan
• Mode switch
• Recirculation actuator
• Recirculation ind
• Right cooling fan
• Sply voltage
• Tan
• Temp sens sig
• Temperature control
• Underhood fuse block (left side of engine compt)

Automatic A/C Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for Automatic A/C Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• 5v ref
• A/c refrigerant pressure sensor (right front strut tower)
• Air temperature actuator (top left side of dash)
• Ambient air temperature sensor sig
• Ambient light sensor (top of dash trim pad)
• Ambient light sensor low ref
• Body control module (bcm) (below right side of dash, near blower motor)
• C4 b6
• C4 e2
• Clu rly ctrl
• Computer data lines system
• Data link connector (dlc) (below left side of dash)
• Ect sens sig
• Engine controls system
• Engine coolant temperature (ect) sensor (left side of rear cyl head)
• Exterior lights system
• Grd
• High spd gm lan
• High spd rly ctrl
• High speed gm lan serial data +
• High speed gm lan serial data -
• Hot at all times
• Hvac ctrl (batt) fuse 10a
• Hvac ctrl (ign) fuse 10a
• Logic
• Low ref
• Low spd rly ctrl
• Low speed gm lan serial data
• Lower air temp sensor (under right side of dash, near console)
• Mode actuator (right kick panel)
• Powertrain control module (pcm) (front of battery)
• Recirculation actuator (top left side of dash)
• Run relay
• Run rly ctrl
• S106 (3 cm from breakout to fuel inj 3)
• Sens sig
• Sun load sensor sig
• Tan
• Upper air temp sensor (above accelerator pedal, on upper duct)

Compressor Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Compressor Wiring Diagram for Chevrolet Malibu LT 2004:

• (auto a/c)
• (man a/c)
• 2.2l 3.5l
• 5v ref
• A/c clu fuse 1 10a
• A/c clutch relay
• A/c compressor clutch
• A/c refrigerant pressure sensor (right front strut tower)
• A/c req sig
• A/c request ind
• A/c request switch
• Auto a/c
• Body control module (bcm) (below right side of dash, near blower motor)
• Clu rly ctrl
• Computer data lines system
• E1 c2
• E8 c1
• G106 (on trans, near pnp switch)
• High spd gm lan
• High speed gm lan serial data +
• High speed gm lan serial data -
• Hot at all times
• Hot in run or start
• Hvac control module (center of dash)
• Logic
• Low ref
• Low spd gmlan
• Low speed gm lan serial data
• Man a/c
• Mode switch
• Powertrain control module (pcm) (front of battery)
• Sens sig
• Tan
• Temperature control
• Underhood fuse block (left side of engine compt)

Manual A/C Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for Manual A/C Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• (center console, front of body control module)
• A/c clu fuse 1 10a
• A/c clutch relay
• A/c compressor clutch
• A/c req sig
• A/c request ind
• A/c request switch
• A10
• A11
• A11 c2
• A12
• A2 c1
• A3 c1
• B1 c1
• B10
• B10 c2
• B11
• B12
• Batt
• Blower motor resistor assembly (on rear of hvac case)
• Blower motor switch
• C/fan 1 fuse 17 30a
• C/fan 2 fuse 18 30a
• C1 e3
• C2 g
• Cool fan 1 relay
• Cool fan 2 relay
• Cool ser/par relay
• Defogger system
• Dr ctrl a
• Dr ctrl b
• E1 c2
• E8 c1
• Exterior lights system
• Fresh air ind
• G106 (on trans, near pnp switch)
• G201
• Grd
• High
• Hot at all times
• Hot in run or start
• Hvac control module (center of dash)
• Ign 3
• Interior lights system
• Left cooling fan
• Lmp sply voltage
• Logic
• Low
• Low ref
• Mode dr ctrl
• Mode dr pos sig
• Mode switch
• Off
• Pk lmp sply
• Rear def ind
• Rear defog sw sig
• Recirculation ind
• Recirculation switch
• Right cooling fan
• Tan
• Temp dr ctrl
• Temperature control switch
• Underhood fuse block (left side of engine compt)

Manual A/C Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for Manual A/C Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• 5v ref
• A/c refrigerant pressure sensor (right front strut tower)
• A/c req sig
• After blow
• Air temperature actuator (top left side of dash)
• Body control module (bcm) (below right side of dash, near blower motor)
• C4 b3
• Clu rly ctrl
• Computer data lines system
• D4 c4
• Data link connector (dlc) (below left side of dash)
• Ect sens sig
• Engine coolant temperature (ect) sensor (top rear of eng)
• G203 (center console, front of body control module)
• Grd
• High spd gm lan
• High spd rly ctrl
• High speed gm lan serial data +
• High speed gm lan serial data -
• Hot at all times
• Hvac blower fuse 20a
• Hvac blower high relay
• Hvac ctrl (batt) fuse 10a
• Hvac ctrl (ign) fuse 10a
• Logic
• Low ref
• Low spd rly ctrl
• Mode actuator (right kick panel)
• Powertrain control module (pcm) (front of battery)
• Recirculation actuator (top left side of dash)
• Run relay
• Run rly ctrl
• Sens sig
• Tan

ANTI-LOCK BRAKES

Anti-lock Brakes Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for Anti-lock Brakes Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• (near windshield wiper fluid reservoir)
• A10
• A11
• A12
• A13
• A14
• Abs fuse 15 10a
• Abs fuse 24 60a
• Abs ind
• B10
• B11
• B12
• B13
• B14
• Bat
• Brake ind
• C10
• C11
• C12
• C13
• C14
• Computer data lines system
• Electronic brake control module (ebcm) (left front of engine compt)
• G109
• Gmlan serial data (+)
• Gmlan serial data (-)
• Hot at all times
• Hot in run or start
• Ign 1 voltage
• Instrument panel cluster
• Left front wheel speed sensor
• Left rear wheel speed sensor
• Lf wheel sens sply voltage
• Lf wheel spd sens sig
• Logic
• Low speed
• Low speed gmlan serial data
• Low traction ind
• Lr wheel sens sply voltage
• Lr wheel spd sens sig
• Nca
• Pnk
• Rf wheel sens sply voltage
• Rf wheel spd sens sig
• Right front wheel speed sensor
• Right rear wheel speed sensor
• Rr wheel sens sply voltage
• Rr wheel spd sens sig
• Serial data gmlan
• Sig grd
• Tan
• Traction off ind
• Underhood fuse block (left side of engine compt)

Anti-lock Brakes Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for Anti-lock Brakes Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• 5v ref
• Body control module (bcm) (below right side of dash)
• Brake fluid level sensor
• Brake fluid level switch (master cylinder reservoir)
• Brake pedal position sensor (on brake pedal support)
• Brk pos sens sig
• Computer data lines system
• Data bus (-) gmlan serial high speed
• G109 (near windshield wiper fluid reservoir)
• G305 (right kick panel)
• Gmlan serial data
• Gmlan serial data bus (+)
• High speed
• High speed gmlan serial data bus (+)
• High speed gmlan serial data bus (-)
• Interior lights system
• Logic
• Low ref
• Low speed
• Pnk
• Powertrain control module (pcm) (front of battery)
• Serial data gmlan low speed
• Signal
• Tan
• Trac ctrl sw sig
• Traction control switch

ANTI-THEFT

Anti-theft Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Anti-theft Wiring Diagram for Chevrolet Malibu LT 2004:

• (center console, front of body control module)
• 1.3k ohms theft resistor
• 5 volt ref
• Acc
• Acc volt
• Acc volt sig
• Ajar
• Ajar switch signal
• B10
• Battery
• C4 c3
• Cluster/ theft fuse 10a
• Cntrl
• Computer data lines system
• Control body module (below right side of dash, near blower motor)
• Data link connector (below left side of dash)
• Door lock
• Door lock fuse 15a
• Dr door key cyl resistor 620 ohms
• Driver door lock actuator
• Driver door lock switch
• Exterior lights system
• G201
• G301 (behind right rear seat back)
• Ground
• Headlight system
• Headlp high beam rel
• High spd gmlan serial data
• Horn relay control
• Horns system
• Hot at all times
• Hvac control module
• Ignition switch
• Instrument panel cluster
• Interior lights system
• Key in ignition switch
• Left rear door lock actuator
• Lock
• Logic
• Low spd gmlan
• Low spd serial
• Off
• Off/run/ crank sig
• Park lp relay cntrl
• Passenger lock actuator
• Passenger lock switch
• Radio
• Rear fuse block
• Release system
• Remote control door lock receiver (on rear package shelf)
• Right rear door lock actuator
• Run
• Security ind
• Serial data
• Signal key switch drvr dr
• Signal lck/unlck
• Start
• Sw sig lid ajar rr compt
• Tan
• Theft deterrent control module (attached to ignition key cylinder)
• Unlock
• Vehicle communications interface module
• W/ auto air conditioning
• W/ vehicle communi- cations
• W/o auto air conditioning
• W/o vehicle communi- cations

BODY CONTROL MODULES

Body Control Modules Wiring Diagram (1 of 4) for Chevrolet Malibu LT 2004

List of elements for Body Control Modules Wiring Diagram (1 of 4) for Chevrolet Malibu LT 2004:

• (extended sedan)
• (sedan)
• (w/ auto a/c)
• (w/ auto cruise control)
• (w/ keyless remote start)
• (w/ manual a/c)
• (w/ traction control)
• A/c system
• Ambient air temp sens sig
• Anti-lock brakes system
• Battery
• Body control module (below right side of dash, near blower motor)
• Brk fluid level sens sig
• Computer data lines system
• Coolant level sw sig
• Defogger system
• Door lock/unlock signal
• Door locks fuse 15a
• Door locks system
• Driver door key sw sig
• Engine controls system
• Engine controls, instrument cluster systems
• Extended sedan
• Exterior lights system
• Fog lamp rly ctrl
• G305 (right kick panel)
• Ground
• Headlamp hi beam rly ctrl
• Headlights system
• Hood ajar sw
• Horn rly ctrl
• Horns system
• Hot at all times
• Instrument cluster system
• Interior lights fuse 10a
• Lf door ajar sw sig
• Lift gate rel sw sig
• Logic
• Low spd gmlan ser data
• Low speed gmlan ser data
• Park brake sw sig
• Park lamp relay ctrl
• Passenger door ajar sw sig
• Pnk
• Rear compt lid ajar sw sig
• Rear defog rly ctrl
• Rev lamp rly ctrl
• Run/crank rly coil ctrl
• Sedan
• Shift interlock system
• Starting/charging system
• Stop lamp voltage
• Tan
• Tap/up/down enable sig
• Traction ctrl sw sig
• Transmissions system
• Trunk key switch sig
• Trunk release rly ctrl
• Trunk. tailgate, fuel doors system
• Windshield wiper sw sig 2
• Wiper/washer system

Body Control Modules Wiring Diagram (2 of 4) for Chevrolet Malibu LT 2004

List of elements for Body Control Modules Wiring Diagram (2 of 4) for Chevrolet Malibu LT 2004:

• A10
• A11
• A12
• Accessory voltage
• B10
• B11
• B12
• Battery
• Body control module (below right side of dash, near blower motor)
• C11
• C12
• Courtesy lamp ctrl
• D10
• D11
• D12
• Door lock actuator lock ctrl
• Door lock actuator unlock ctrl
• Door locks system
• Drr door lock actuator unlock ctrl
• Engine controls system
• Exterior lights system
• Hot at all times
• Hot in run and crank
• Ibcm (r/c) fuse 21 30a
• Ibcm 1 fuse 20 30a
• Ibcm 2 fuse 25 50a
• Ignition 1 voltage
• Interior lights system
• Logic
• Pnk
• Power distribution, mirrors system
• Power distribution, power tops, mirrors systems
• Power distribution, power windows system
• Power distribution, seats system
• Power distribution, shift interlock system
• Power window master sw lockout sig
• Power windows system
• Run rly fuse 23 60a
• Serial data
• Tan
• Under- hood fuse block
• Windshield washer pump ctrl
• Wiper/washer system

Body Control Modules Wiring Diagram (3 of 4) for Chevrolet Malibu LT 2004

List of elements for Body Control Modules Wiring Diagram (3 of 4) for Chevrolet Malibu LT 2004:

• (a1-a12 not used)
• (w/ manual a/c)
• A/c system
• Accessory voltage
• B10
• B11
• B12
• Battery
• Body control module (below right side of dash, near blower motor)
• C10
• C11
• C12
• D10
• D11
• D12
• Door locks system
• E10
• E11
• E12
• Exterior lights system
• F10
• F11
• F12
• G203 (center console, front of body control module)
• Ground
• High blower mtr ctrl
• Ignition 1 voltage
• Ignition 3 voltage
• Interior lights system
• Logic
• Pnk
• Power distribution
• Power distribution, a/c system
• Power distribution, a/c, computer data lines systems
• Power distribution, anti-theft system
• Power distribution, cruise control system
• Power distribution, electronic power steering system
• Power distribution, instrument cluster system
• Power distribution, navigation system
• Power distribution, seats system
• Power distribution, sound system
• Power distribution, wiper/washer system
• Serial data
• Windshield washer pump ctrl
• Wiper/washer system

Body Control Modules Wiring Diagram (4 of 4) for Chevrolet Malibu LT 2004

List of elements for Body Control Modules Wiring Diagram (4 of 4) for Chevrolet Malibu LT 2004:

• (w/ auto a/c)
• (w/ auto cruise control)
• (w/ manual a/c)
• 5 volt ref
• A/c request sig
• A/c system
• Adjustable pedal inhibit sw
• Anti-theft system
• Body control module (below right side of dash, near blower motor)
• Brake pedal pos sen sig
• Computer data lines system
• Cruise control system
• Cruise ctrl sw sig
• Defogger system
• Drl ambient light sen low ref
• Drl ambient light sen sig
• Exterior lights system
• Flash to pass sig
• Fog lamp rly ctrl
• Front fog lamp sw sig
• G201 (center console, front of body control module)
• Ground
• Hazard switch sig
• Headlamp dimmer sw hi beam sig
• Headlamp low beam rly ctrl
• Headlamps sw off sig
• Headlamps sw on sig
• Headlights system
• High speed gmaln ser bus +
• High speed gmaln ser bus -
• Horn rly ctrl
• Horns system
• I/p lamps dimmer sw sig
• Interior lights system
• Left turn sig sw sig
• Logic
• Low ref
• Low speed gmlan ser data
• Off/run/crank volt sig
• Park lamp sw isg
• Power distribution
• Power distribution, starting/charging system
• Rear defog rly ctrl
• Rear defog sw sig
• Right turn sig sw sig
• Seats system (adjustable pedal circuit)
• Security ind sig
• Serial data
• Sunload sens sig
• Tan
• Windshield wiper sw sig 1
• Wiper/washer system

COMPUTER DATA LINES

Computer Data Lines Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Computer Data Lines Wiring Diagram for Chevrolet Malibu LT 2004:

• B10
• B11
• B12
• Body control module (bcm) (below right side of dash)
• Class 2 serial data
• Data link connector (below left side of dash, near steering column)
• Digital radio receiver
• Dvd player
• Electronic brake control module (ebcm) (inside left front fender)
• Front of body control module)
• G201 (center console, front of body control module)
• G203 (center console,
• Gmlan data bus +
• Gmlan data bus -
• High speed gmlan serial data bus +
• High speed gmlan serial data bus -
• Hot at all times
• Hs gmlan data bus +
• Hs gmlan data bus -
• Hvac control module (center of dash)
• Hvac ctrl (batt) fuse 10a
• Inflatable restraint sensing & diagnostic module (sdm) (under center console, under the carpet)
• Instrument panel cluster (ipc)
• Low speed gmlan serial data
• Ls gmlan data
• Power steering control module (left of steering column)
• Powertrain control module (pcm) (front of battery)
• Radio
• Tan
• Theft deterrent control module (attached to ignition key cylinder housing)
• Vehicle communication interface module (vcim) (behind right side of dash, behind i/p compt)
• W/ abs
• W/ auto a/c
• W/ dvd player
• W/ navi
• W/ radio receiver
• W/o abs
• W/o auto a/c
• W/o dvd player
• W/o navi
• W/o radio receiver

COOLING FAN

Cooling Fan Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Cooling Fan Wiring Diagram for Chevrolet Malibu LT 2004:

• (2.2l vin f) c1
• (3.5l vin 8) c1
• A11
• B10
• Body control module (below right side of dash, near blower motor)
• C/fan 1 fuse 17 30a
• C/fan 2 fuse 18 15a
• Computer data lines system
• Cool fan 1 relay 28
• Cool fan 2 relay 30
• Cool lev sw sig
• Cool ser/ par relay
• Coolant level switch (on eng coolant surge tank)
• Coolant temp ind
• Driver information center
• G106 (2.2l: on engine, below generator) (3.5l: on transmission, near park/neutral position switch)
• G109 (near windshield wiper fluid reservoir)
• High speed cooling fan relay ctrl
• Hot at all times
• Instrument panel cluster
• Left cooling fan
• Low coolant
• Low spd data
• Low speed cooling fan relay ctrl
• Powertrain control module (pcm) (front of battery)
• Radio
• Right cooling fan
• Underhood fuse block (left side of engine compt)

CRUISE CONTROL

Cruise Control Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Cruise Control Wiring Diagram for Chevrolet Malibu LT 2004:

• (behind inflatable restraint wheel module) s201
• (on rear of transmission) vehicle speed sensor (vss)
• 5 volt reference
• Body control module (right end of dash)
• Brake pedal position sens sig
• Brake pedal position sensor (on brake pedal support)
• Computer data lines system
• Cruise control switch signal
• Cruise indicator
• G201 (center console, front of body control module)
• Gmlan
• Ground
• Hot at all times
• Hot w/ run/crank relay energized
• Ibcm (r/c) fuse 21 30a
• Ibcm 2 fuse 25 50a
• Inflatable restraint steering wheel module coil
• Instrument panel cluster
• Interior lights fuse 25 50a
• Left steering wheel controls
• Logic
• Low reference
• Low speed gmlan serial data
• On/off
• Pnk
• Powertrain control module (at front of battery)
• R/a
• Right steering wheel controls
• Run/crank fuse 2a
• S/c
• Stop lamp switch signal
• Stp sig
• Switch signal
• Tan
• Throttle actuator control module (on intake manifold)
• Underhood fuse block (left side of engine compartment)
• Vss sig high
• Vss sig low
• W/ 2.2l
• W/ 3.5l
• W/ accessory control steering wheel
• W/o accessory control steering wheel

DEFOGGERS

Defoggers Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Defoggers Wiring Diagram for Chevrolet Malibu LT 2004:

• (extended sedan) g302 (behind rear seat, on left quarterpanel)
• (left kick panel)
• B12
• Body control module (below right side of dash, near blower motor)
• C12
• Computer data lines system
• Defog ind
• Defog switch
• Driver outside rearview mirror
• G201 (center console, front of body control module)
• G301 (sedan) (behind right rear seat back)
• G302 (extended sedan: behind rear seat, on left quarterpanel) (sedan: behind left rear seat)
• G303
• Hot at all times
• Htd mir fuse 24 10a
• Hvac control module (auto a/c) (center of dash)
• Hvac control module (manual a/c) (center of dash)
• Logic
• Low spd gmlan ser data
• Low speed gmlan ser data
• Nca
• Passenger outside rearview mirror
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rear window defogger grid
• Rr defog fuse 23 30a
• Rr defog relay
• Rr defog rly ctrl
• Rr defog sw sig
• Tan

ELECTRONIC POWER STEERING

Electronic Power Steering Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Electronic Power Steering Wiring Diagram for Chevrolet Malibu LT 2004:

• Body control module (below right side of dash)
• Computer data lines system
• Eps fuse 2a
• Eps fuse 41 80a
• G103 (top left of front strut tower)
• Ground
• High speed gmlan serial data +
• High speed gmlan serial data -
• Hot at all times
• Hot in run or start
• Ign 1 volt
• Logic
• Lt ast mtr cntl
• Pnk
• Position
• Power steering control module (left of steering column)
• Power steering motor
• Red
• Rt ast mtr cntl
• Steer shaft torque sens sig 1
• Steer shaft torque sens sig 2
• Steer wheel position sen low ref
• Steer wheel position sen signal 1
• Steer wheel position sen signal 2
• Steering column assembly
• Steering wheel pos sen 5 volt ref
• Tan
• Torque
• Torque position sensor
• Underhood fuse block (left side of engine compart)

ENGINE PERFORMANCE

2.2L VIN F

2.2L VIN F, Engine Performance Wiring Diagram (1 of 4) for Chevrolet Malibu LT 2004

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (1 of 4) for Chevrolet Malibu LT 2004:

• (left side of eng compt) underhood fuse block
• (right rear of engine, on engine to trans stud) g105
• 5v ref
• A/c refrigerant pressure sensor (left of right front strut tower)
• Acc voltage
• Accy
• Air conditioning system
• App sens 1 sig
• App sens 2 sig
• B10
• Bat
• Body control module (bcm) (below right side of dash, near blower motor)
• C10
• Clu rly ctrl
• Computer data lines system
• Cooling fans system
• Crank voltage
• Data link connector (dlc) (near steering column)
• Evap sol ctrl
• Evaporative emissions (evap) canister vent solenoid (above fuel tank)
• F pmp rly ctrl
• Fan rly ctrl
• Fuel pres sig
• Fuel tank pressure (ftp) sensor (under rear of vehicle)
• G109 (near wind- shield wiper fluid reservoir)
• Gmlan data
• Hot at all times
• Hot in run or start
• Ign 1
• Ign 1 fuse 3 15a
• Info not available
• Inj fuse 5 10a
• Lo rly ctrl
• Low ref
• Lvl sens sig
• Main rly ctrl
• Mil ctrl
• Park neutral position (pnp) switch (top of transmission)
• Pcm fuse 13 10a
• Pcm ign 1 fuse 16 10a
• Pnk
• Power distribution system
• Powertrain control module (pcm) (front of battery)
• Refrig pres sig
• Rly coil ctrl
• Rly coil sply
• Rly hi ctrl
• Run/ crank relay 32
• Run/crank fuse 2a
• Serial data
• Starting circuit
• Stop lp sig
• Tan
• Tap enable sig
• Tap sw sig
• Trans fuse 4 10a

2.2L VIN F, Engine Performance Wiring Diagram (2 of 4) for Chevrolet Malibu LT 2004

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (2 of 4) for Chevrolet Malibu LT 2004:

• (attached to accelerator pedal) accelerator pedal position (app) sensor
• (below center console shifter) a/t shift lock control solenoid
• (left side of eng compt) underhood fuse block
• 1-2 shift solenoid (1-2 ss) valve
• 2-3 shift solenoid (2-3 ss) valve
• Automatic transmission
• Automatic transmission fluid pressure (tfp) manual valve position switch
• Automatic transmission fluid temp (tft) sensor
• Automatic transmission input shaft speed (at iss) sensor
• B11
• C11
• D11
• D12
• Drive
• E11
• Emission 1 fuse 6 10a
• Engine oil pressure (eop) switch (right side of engine)
• Etc fuse 2 15a
• Fuel injectors
• G303 (left kick panel)
• Hot at all times
• Pnk
• Pnk e
• Powertrain relay 33
• Pressure control (pc) solenoid valve
• Red
• Red a
• Rev
• S130
• Tan
• Tan m
• Tap up/ tap down switch
• Tcc release
• Torque converter clutch pulse width modulation (tcc pwm) solenoid valve

2.2L VIN F, Engine Performance Wiring Diagram (3 of 4) for Chevrolet Malibu LT 2004

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (3 of 4) for Chevrolet Malibu LT 2004:

• (in fuel tank) fuel pump & sender assembly
• (on transmission) vehicle speed sensor (vss)
• A10
• At iss hi sig
• At iss low sig
• Computer data lines system
• Emission 2 fuse 5 10a
• Evap purge sol ctrl
• Evaporative emissions (evap) canister purge solenoid (top rear of engine)
• Fuel fuse 25 15a
• Fuel level sensor
• Fuel pump
• Fuel relay 37
• G301 (behind right rear seat back)
• G302 (sedan: behind left rear seat, extended sedan: behind rear seat, on left quarterpanel)
• Gmlan data
• Hot at all times
• Ign
• Instrument panel cluster (ipc)
• Logic
• Low ref
• Malfunc- tion indicator lamp
• Oil press sw sig
• Pc sol vlv hi ctrl
• Pc sol vlv low ctrl
• Pnk
• Powertrain control module (pcm) (front of battery)
• Rear fuse block (extended sedan: left rear of pass compt, sedan: left rear quarterpanel)
• Shft sol vlv 1 hi ctrl
• Shft sol vlv 2 hi ctrl
• Tan
• Tcc pwm sol vlv ctrl
• Tft sens sig
• Trans press sens sig
• Trans press sens sig c
• Trans press sw sig b
• Trans range sw sig b
• Trans range sw sig p
• Trans sw sig a
• Trans sw sig c
• Vss low ref
• Vss sig

2.2L VIN F, Engine Performance Wiring Diagram (4 of 4) for Chevrolet Malibu LT 2004

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (4 of 4) for Chevrolet Malibu LT 2004:

• (between exhaust manifold & catalytic converter) heated oxygen (ho2s) sensor 1
• (on engine, below generator)
• (on upper intake manifold) throttle actuator control (tac) module
• (rear of catalytic converter) heated oxygen (ho2s) sensor 2
• (right rear of eng, on eng to trans stud)
• (top rear of engine) ignition control module (icm)
• 5v ref
• Charging circuit
• Ckp 1 sig
• Cmp sig
• Crankshaft position (ckp) sensor (top right side of engine, near engine oil pressure switch)
• Ctrl a
• Ctrl b
• Ect sig
• Engine coolant temperature (ect) sensor (top rear of engine)
• G105
• G105 (right rear of engine, on eng to trans stud)
• G106
• Gen sig
• Gnd
• Grd
• Ho2s hi sig
• Ho2s lo ctrl
• Ho2s low sig
• Iat sens sig
• Ic timing b
• Ic timing ctrl
• Ign 1
• Inj 1 ctrl
• Inj 2 ctrl
• Inj 3 ctrl
• Inj 4 ctrl
• Knock sensor (ks) (left side of engine, near oil dipstick)
• Ks sig
• Low ref
• Maf sig
• Manifold absolute pressure (map) sensor (front of engine, at cylinder 3 intake port)
• Map sig
• Mass air flow (maf) (w/ intake air temperature (iat) sensor) (on air intake duct assembly)
• Nca
• Pnk
• Powertrain control module (pcm) (front of battery)
• Tac ctrl 1
• Tac ctrl 2
• Tan
• Tps 1 sig
• Tps 2 sig

3.5L VIN 8

3.5L VIN 8, Engine Performance Wiring Diagram (1 of 5) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, Engine Performance Wiring Diagram (1 of 5) for Chevrolet Malibu LT 2004:

• (left side of eng compt) underhood fuse block
• (right rear of engine, on engine to trans stud) g105
• 5v ref a
• 5v ref b
• A/c refrigerant pressure sensor (left of right front strut tower)
• Acc voltage
• Accy
• Air conditioning system
• B10
• Bat
• Body control module (bcm) (below right side of dash, near blower motor)
• C10
• Cl rly ctrl
• Computer data lines system
• Cooling fans system
• Crank voltage
• Data link connector (dlc) (near steering column)
• Evap sol ctrl
• Evaporative emissions (evap) canister vent solenoid (above fuel tank)
• Exterior lights system
• F pmp rly ctrl
• Fan rly ctrl
• Fuel tank pressure (ftp) sensor (under rear of vehicle)
• G109 (near wind- shield wiper fluid reservoir)
• Gmlan data
• Hot at all times
• Hot in run or start
• Ign 1
• Ign 1 fuse 3 15a
• Inj fuse 5 10a
• Low ref
• Lvl sens sig
• Main rly ctrl
• Mil ctrl
• Park neutral position (pnp) switch (top of transmission)
• Pcm fuse 13 10a
• Pcm ign 1 fuse 16 10a
• Pnk
• Powertrain control module (pcm) (front of battery)
• Press sens sig
• Rly coil ctrl
• Rly hi ctrl
• Run/ crank fuse 2a
• Run/ crank relay 32
• Serial data
• Starting circuit
• Stop lp sig
• Tan
• Tap enable sig
• Tap sw sig
• Trans fuse 4 10a
• Vss

3.5L VIN 8, Engine Performance Wiring Diagram (2 of 5) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, Engine Performance Wiring Diagram (2 of 5) for Chevrolet Malibu LT 2004:

• (7.5 cm from breakout to pcm) s118
• (attached to accelerator pedal) accelerator pedal position (app) sensor
• (below center console shifter) a/t shift lock control solenoid
• (left side of eng compt) underhood fuse block
• 5v ref
• App sens 1
• App sens 2
• B11
• C11
• D11
• E11
• Emission 1 fuse 6 10a
• Etc fuse 2 15a
• Evaporative emissions (evap) canister purge solenoid (near throttle body)
• G105 (right rear of eng, on eng to trans stud)
• G303 (left kick panel)
• Grd
• Hot at all times
• Ign 1
• Knock sensor (ks) 1 (rear center of engine)
• Knock sensor (ks) 2 (lower left side of eng)
• Low ref
• Nca
• Pnk
• Powertrain relay 33
• S119 (15 cm from breakout to pcm) nca
• Serial data
• Stop lp sw
• Tan
• Tap up/ tap down switch
• Throttle actuator control (tac) module (on intake manifold)
• Vss

3.5L VIN 8, Engine Performance Wiring Diagram (3 of 5) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, Engine Performance Wiring Diagram (3 of 5) for Chevrolet Malibu LT 2004:

• 1-2 shift solenoid (1-2 ss) valve
• 2-3 shift solenoid (2-3 ss) valve
• Automatic transmission
• Automatic transmission fluid pressure (tfp) manual valve position switch
• Automatic transmission fluid temp (tft) sensor
• Automatic transmission input shaft speed (at iss) sensor
• Computer data lines system
• Drive
• Fuel injectors
• Gmlan data
• Ign
• Instrument panel cluster (ipc)
• Logic
• Malfunc- tion indicator lamp
• Pnk
• Pnk e
• Pressure control (pc) solenoid valve
• Red
• Red a
• Rev
• S130 pnk
• Tan
• Tan m
• Tcc release
• Torque converter clutch pulse width modulation (tcc pwm) solenoid valve

3.5L VIN 8, Engine Performance Wiring Diagram (4 of 5) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, Engine Performance Wiring Diagram (4 of 5) for Chevrolet Malibu LT 2004:

• (in fuel tank) fuel pump & sender assembly
• (on transmission) vehicle speed sensor (vss)
• (sedan: behind left rear seat, extended sedan: behind rear seat, on left quarterpanel)
• (top right side of eng) ignition control module (icm)
• 1-2 sol vlv ctrl
• 2-3 sol vlv ctrl
• A10
• At iss hi sig
• At iss low sig
• Emission 2 fuse 5 10a
• Fuel fuse 25 15a
• Fuel level sensor
• Fuel pump
• Fuel relay 37
• G106 (on eng, below generator)
• G301 (behind right rear seat back)
• G302
• Grd
• Ho2s hi sig (1/2)
• Ho2s hi sig (2/2)
• Ho2s lo ctrl (1/2)
• Ho2s lo ctrl (2/2)
• Ho2s lo sig (1/2)
• Ho2s lo sig (2/2)
• Hot at all times
• Iat sens sig
• Ic 1 ctrl
• Ic 2 ctrl
• Ic 3 ctrl
• Ign 1
• Low ref
• Maf sens sig
• Pc sol vlv hi ctrl
• Pc sol vlv lo ctrl
• Pnk
• Powertrain control module (pcm) (front of battery)
• Rear fuse block (extended sedan: left rear of pass compt, sedan: left rear quarterpanel)
• Tan
• Tcc pwm sol vlv ctrl
• Tcc release sw sig
• Tft sens sig
• Trans press sens sig b
• Trans press sens sig c
• Trans range sw sig a
• Trans range sw sig b
• Trans range sw sig c
• Trans range sw sig p
• Vss high sig
• Vss low sig

3.5L VIN 8, Engine Performance Wiring Diagram (5 of 5) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, Engine Performance Wiring Diagram (5 of 5) for Chevrolet Malibu LT 2004:

• (3 cm from breakout to fuel inj 3)
• (after catalytic converter) heated oxygen sensor (ho2s) bank 1 sensor 2
• (after catalytic converter) heated oxygen sensor (ho2s) bank 2 sensor 2
• (center of rear exhaust manifold) heated oxygen sensor (ho2s) bank 1 sensor 1
• (on exhaust manifold) heated oxygen sensor (ho2s) bank 2 sensor 1
• (top rear of engine) exhaust gas recirculation (egr) valve
• 12v ref
• 5v ref
• 5v ref a
• A tan
• Camshaft position (cmp) sensor (on front of engine)
• Charging circuit
• Cmp sens sig
• Crankshaft position (ckp) sensor (lower rear of engine, near knock sensor)
• Drain wire
• Ect sens sig
• Egr pos sig
• Egr sol ctrl
• Egr sol lo
• Eng spd sig
• Engine coolant temperature (ect) sensor (left side of rear cyl head)
• Engine oil pressure (eop) switch (lower left side of eng)
• Evap sol
• G105 (right rear of engine, on eng to trans stud)
• Gen sig
• Grd
• Ho2s lo ctrl
• Ho2s lo ref
• Ho2s low
• Ho2s low ref
• Ho2s ref v
• Ic 1 ctrl
• Ic 2 ctrl
• Ic 3 ctrl
• Inj 1 ctrl
• Inj 2 ctrl
• Inj 3 ctrl
• Inj 4 ctrl
• Inj 5 ctrl
• Inj 6 ctrl
• Ks 1 sig
• Ks 2 sig
• Low ref
• Manifold absolute pressure (map) sensor (in upper intake manifold)
• Map sens sig
• Mass air flow (maf) (w/ intake air temperature (iat) sensor) (on air intake duct assembly)
• Nca
• Oil press
• Powertrain control module (pcm) (front of battery)
• S106
• Serial data
• Tan

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Back-up Lamps Wiring Diagram for Chevrolet Malibu LT 2004:

• 2.2l
• 3.5l
• Backup lp fuse 17 10a
• Backup lp relay 33
• Body control module (below right side of dash, near blower motor)
• Bu lmp sup vlt
• Computer data lines system
• G105 (right rear of engine, on engine to transmission stud)
• G401 (left rear side of rear compt)
• G403 (left rear side of rear compt)
• Hi spd ser data +
• Hi spd ser data -
• Hot at all times
• Inside rearview mirror
• Left backup lamp
• Left tail/ stop & turn signal lamp
• Park/neutral position switch
• Powertrain control module (front of battery)
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rev lmp rly ctrl
• Right backup lamp
• Right tail/ stop & turn signal lamp
• Tan
• Trs sig a
• Trs sig b

Exterior Lamps Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• 5v ref
• A12
• Ambient light sensor
• Auto
• B a
• B b
• Body control module (below right side of dash, near blower motor)
• Brake pedal position sensor
• Brk pos sens sig
• C12
• Center high mounted stop lamp
• Drl amb lght sen sig
• F11
• G101 (near windshield wiper fluid reservoir)
• G102 (on core support, behind right headlamp)
• G201 (center console, front of body control module)
• G302 (behind left rear seat)
• Hazard sw sig
• Head
• Hi spd ser data +
• Hi spd ser data -
• Hi spd ser data bus
• Hot at all times
• Hvac control module (center of dash)
• Left
• Left front park/ turn signal lamp
• Lf trn sig vlt
• Low ref
• Lt trn sig sw
• Off
• Park
• Park lamp relay 27
• Park lamps fuse 6 10a
• Prk lmp rly cntl
• Prk lmp sup vlt
• Prk lmp sw on sig
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rear seat audio controller unit
• Rf trn sig vlt
• Right
• Right front park/ turn signal lamp
• Rt trn sig sw
• Tan
• Turn signal/ multifunction switch
• Under- hood fuse block
• W/ auto a/c a
• W/ manual a/c
• W/ manual a/c b

Exterior Lamps Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• Batt
• Body control module (below right side of dash, near blower motor)
• Brake lamp diagnostic resistor
• C10
• C11
• Chime
• Cluster/ theft fuse 10a
• Computer data lines system
• Extended sedan
• G109 (near windshield
• G201 (base of left "a" pillar)
• G302 (behind left rear seat)
• G401 (left rear side of rear compt)
• G403 (left rear side of rear compt)
• Hazard switch
• Hi spd ser data +
• Hi spd ser data -
• Hot at all times
• Instrument panel cluster
• Interior lights system
• Left backup lamp
• Left license lamp
• Left tail lamp
• Left tail/ stop & turn signal lamp
• Left turn sig ind
• License lamp
• Low spd ser data
• Nca
• Powertrain control module (front of battery)
• Right backup lamp
• Right license lamp
• Right tail lamp
• Right tail/ stop & turn signal lamp
• Right turn sig ind
• Sedan
• Tan
• Under- hood fuse block
• Under- hood fuse block (on left side of engine compt)
• Wiper fluid reservoir)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Chevrolet Malibu LT 2004

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Chevrolet Malibu LT 2004:

• (3.5l)
• (3.5l) c
• (if equipped) adjustable pedal module
• (if equipped) electronic brake control module
• (if equipped) vehicle communi- cation interface module
• A/c compressor clutch
• A12
• B (2.2l)
• Battery
• Body control module
• Brake fluid level switch
• Brake lamp diagnostic resistor
• C10
• Cool ser/par relay 29
• Coolant level switch
• Data link connector
• Extended sedan
• Frt fog relay 36
• G103 (top of left front strut tower)
• G104 (left side of engine compt)
• G105 (right rear of engine, on engine to transmission stud)
• G106 (2.2l: on engine, below generator) (3.5l: on transmission, near park/neutral position switch)
• G109 (near windshield wiper fluid reservoir)
• G201 (center console, front of body control module)
• Horn switch
• Hvac control module
• Ignition control module
• Inflatable restraint steering wheel module coil
• Instrument panel cluster
• Left steering wheel controls
• Mass air flow/ intake air sensor
• Park/ neutral position switch
• Power steering control module
• Powertrain control module
• Radio
• Right cooling fan
• Right steering wheel controls
• Run/crank relay 32
• S201 (behind inflatable restraint wheel module)
• Sedan
• Theft deterrent control module
• Throttle actuator control module
• Turn signal/ multifunction switch
• Underhood fuse block
• W/ accessory electronic system
• W/ cruise
• W/o accessory electronic system
• W/o cruise
• Windshield wiper motor
• Wiper 1 relay 39
• Wiper 2 relay 40

Ground Distribution Wiring Diagram (2 of 4) for Chevrolet Malibu LT 2004

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Chevrolet Malibu LT 2004:

• (extended sedan) license lamp
• (left rear side of rear compt)
• Adjustable pedal position switch
• Blower motor
• Blower motor control module
• Body control module
• Data link connector
• Dimmer switch
• Driver door lock actuator
• Driver door lock switch
• E12
• Fog lamp switch
• Fuel pump & sender assembly
• G101 (near windshield wiper fluid reservoir)
• G102 (on core support, behind right headlamp)
• G203 (center console, front of body control module)
• G301 (behind right rear seat back)
• G401 (left rear side of rear compt)
• G403
• Hazard switch
• Hood ajar switch
• Horn assembly
• Left backup lamp
• Left front fog lamp
• Left front park/ turn signal lamp
• Left headlamp high beam
• Left headlamp low beam
• Left rear door lock actuator
• Left tail- lamp
• Left tail/ stop & turn signal lamp
• Passenger door lock actuator
• Passenger door lock switch
• Rear window defogger grid
• Right backup lamp
• Right front fog lamp
• Right front park/ turn signal lamp
• Right headlamp high beam
• Right headlamp low beam
• Right rear door lock actuator
• Right tail- lamp
• Right tail/ stop & turn signal lamp
• Wind- shield fluid level pump
• Wind- shield fluid level switch

Ground Distribution Wiring Diagram (3 of 4) for Chevrolet Malibu LT 2004

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Chevrolet Malibu LT 2004:

• (extended sedan) cargo lamp switch
• (extended sedan) liftgate release switch
• (extended sedan) rear compartment lid latch
• (extended sedan) rear window defogger grid
• (sedan) left license lamp
• (sedan) rear compartment exterior lid release switch
• (sedan) rear compartment lid pulldown actuator
• (sedan) right license lamp
• Center high mounted stop lamp
• Dome reading lamp
• Extended sedan
• Front courtesy/ reading lamps
• Fuel relay 37
• G302 (behind left rear seat)
• Left vanity mirror lamp
• Nca
• Right vanity mirror lamp
• Rr defog relay 26
• Sedan
• Sunroof control module
• Underhood fuse block

Ground Distribution Wiring Diagram (4 of 4) for Chevrolet Malibu LT 2004

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Chevrolet Malibu LT 2004:

• (extended sedan) rear auxiliary power outlet
• (left kick panel)
• (right kick panel)
• A w/o electronic traction control
• A/t shift lock control assembly
• B w/ electronic traction control
• Body control module
• Cigar lighter
• Console auxiliary power outlet
• Digital radio receiver
• Driver heated seat control module
• Driver heated seat switch
• Driver outside rearview mirror
• Driver seat adjuster switch
• Driver window switch
• Dvd player
• Front auxiliary power outlet
• G303
• G304 (right kick panel)
• G305
• Garage door opener transmitter
• Inflatable restraint sensing & diagnostic module
• Inside rearview mirror
• Nca
• Outside rearview mirror switch
• Passenger heated seat control module
• Passenger heated seat switch
• Passenger outside rearview mirror
• Passenger window switch
• Rear compart- ment lid release switch
• Rear fuse block
• Rear seat audio controller
• Remote control door lock receiver
• Traction control switch
• W/ dvd player
• W/ rear seat radio controls

HEADLIGHTS

Headlights Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Headlights Wiring Diagram for Chevrolet Malibu LT 2004:

• (center console, front of body control module)
• (w/ auto a/c)
• (w/ manual a/c)
• A12
• Ambient light sensor
• Auto
• B12
• Body control module (below right side of dash, near blower motor
• C10
• Computer data lines system
• D10
• Fog lamp switch
• Fog lmp rly ctrl
• Fog lmp sw sig
• Frt fog lp fuse 10 10a
• Frt fog relay
• Ftp
• Ftp sw sig
• G101 (near wind- shield wiper fluid reservoir)
• G101 (near windshield wiper fluid reservoir)
• G102 (on core support, behind right headlamp)
• G109 (near wind- shield wiper fluid reservoir)
• G201 (center console, front of body control module)
• G203
• Hdlmps off
• Hdlmps on
• Head
• High
• High beam in
• High beam ind
• High beam relay
• Hot at all times
• Instrument panel cluster
• Left front fog lamp
• Left high beam headlamp
• Left low beam headlamp
• Lh high fuse 11 10a
• Lh low fuse 7 10a
• Low
• Low beam in
• Low beam relay
• Lt sen low ref
• Lt sen sig
• Off
• Park
• Rh high fuse 12 10a
• Rh low fuse 9 10a
• Right front fog lamp
• Right high beam headlamp
• Right low beam headlamp
• Ser data
• Turn signal/ multifunction switch
• Underhood fuse block (on left side of engine compt)

HORN

Horn Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Horn Wiring Diagram for Chevrolet Malibu LT 2004:

• (center of console, front of body control module) g201
• B9 c2
• Body control module (bcm) (below right side of dash)
• C2 k
• C3 k
• E4 c3
• G101 (near windshield wiper fluid reservoir)
• Horn assembly
• Horn fuse 8 15a
• Horn relay
• Horn rly ctrl
• Horn switch
• Hot at all times
• Inflatable restraint steering wheel module coil
• Logic
• S201 (w/ cruise)
• Tan
• Underhood fuse block (left side of engine compt)

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Instrument Cluster Wiring Diagram for Chevrolet Malibu LT 2004:

• (center console, front of body control module)
• (fuel inj harn, 4 cm from breakout to fuel inj 3) s106
• 000000 trip
• 2.2l
• 3.5l
• Abs ind
• Acc
• Air bag ind
• Batt ind
• Battery
• Belt switch
• Body control module (bcm) (below right side of dash, near blower motor)
• Brake fluid level
• Brake fluid level switch (on brake master cylinder reservoir)
• Brake ind
• Cluster/ theft fuse 10a
• Computer data lines system
• Coolant temp ind
• Cruise ind
• Ect sens
• Engine controls system
• Engine coolant temp
• Engine coolant temperature sensor (2.2l: top rear of engine) (3.5l: left side of rear cyl head)
• Engine oil pressure switch (2.2l: right side of engine) (3.5l: lower left side of engine)
• Exterior lights system
• Fuel level
• Fuel pump & sender assembly (in fuel tank)
• G109 (near wind- shield wiper fluid reservoir)
• G201
• Ground
• High beam ind
• Hot at all times
• Ignition
• Ignition (run/ start)
• Ignition switch
• Illumination
• Inflatable restraint sensing & diagnostic module (sdm) (under center console, under the carpet)
• Instrument panel cluster (ipc)
• Left turn ind
• Logic
• Low ref
• Low traction ind
• Malfunction ind lamp
• Mil ctrl
• Off
• Oil press
• Oil pressure ind
• Park brake switch
• Park brake switch (on park brake assembly)
• Pnk
• Powertrain control module (in front of battery)
• Right turn ind
• Run
• Seat belt ind
• Seat belt switch
• Security ind
• Security ind signal
• Serial bus
• Serial bus +
• Serial bus -
• Serial data
• Service vehicle soon ind
• Speedometer
• Start
• Tachometer
• Tan
• Traction off ind
• Trip reset
• Trip reset switch
• Vf display

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Courtesy Lamps Wiring Diagram for Chevrolet Malibu LT 2004:

• (not used)
• (sedan: left rear quarterpanel) (extended sedan: left rear of passenger compartment)
• A10
• A5 c4
• Battery+
• Body control module (bcm) (below right side of dash)
• Cargo lamp
• Cargo lamp switch
• Courtesy v+
• Ctsy lp ctrl
• D9 c1
• Dome
• Dome/ reading lamp
• Door
• Door ajar
• E6 c1
• Extended sedan
• F2 c4
• F5 c1
• F5 c3
• Front courtesy/ reading lamps
• Front passenger door ajar
• G301 (behind right rear seat back)
• G302 (behind left rear seat)
• G302 (behind rear seat, on left quarterpanel)
• Hot at all times
• Interior lights fuse 10a
• Latch
• Left rear door ajar
• Left vanity mirror lamp
• Lf door ajar
• Lock actuator
• Off
• Reading
• Rear comp- artment courtesy lamp
• Rear comp- artment lid latch
• Rear fuse block
• Rear fuse block (sedan: left rear quarterpanel) (extended sedan: left rear of passenger compartment)
• Rear lid ajar
• Right rear door ajar
• Right vanity mirror lamp
• Sedan

Instrument Illumination Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Instrument Illumination Wiring Diagram for Chevrolet Malibu LT 2004:

• (w/ uk3)
• (w/o uk3)
• A/t shift lock control assembly
• Adjustable pedal position switch
• B12
• Battery+
• Body control module (bcm) (below right side of dash)
• C1 b
• C1 b3
• C1 d1
• C3 k
• D10
• Dimmer sig
• Dimmer switch
• Driver door lock switch
• Driver heated seat switch
• Driver window switch
• E11
• F11
• Fog lamp switch
• G c2
• G c3
• G201 (center console, front of body control module)
• G203 (center console, front of body control module)
• G301 (behind right rear seat back)
• G303 (left kick panel)
• G305 (right kick panel)
• Hazard switch
• Hot at all times
• Hvac control module
• I/p lamp v+
• Illum
• Illum (4 bulbs)
• Inflatable restraint steering wheel module coil
• Instrument panel cluster (ipc)
• Interior lights fuse 10a
• K c2
• Left steering wheel controls
• Logic
• Low ref
• Nca
• Outside rearview mirror switch
• Park lps fuse 6 10a
• Park lps relay 27
• Pass- enger door lock switch
• Pass- enger window switch
• Passenger heated seat switch
• Pk lamp ctrl
• Pk lamp v+
• Rear comp- artment/ liftgate release switch
• Rear fuse block (sedan: left rear quarterpanel) (extended sedan: left rear of passenger compartment)
• Rear seat audio controller
• Right steering wheel controls
• S201
• S202
• Traction control switch

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 5) for Chevrolet Malibu LT 2004

List of elements for Power Distribution Wiring Diagram (1 of 5) for Chevrolet Malibu LT 2004:

• (if equipped)
• 2.2l
• 3.5l
• A w/o electronic traction control
• Abs fuse 24 60a
• Aux pwr fuse 12 20a
• B w/ electronic traction control
• B12
• Back up lp fuse 17 10a
• Back-up lamp relay 33
• Batt
• Battery
• C12
• Cig/aux fuse 20 20a
• Cigar lighter
• Console auxiliary power outlet
• Digital radio receiver
• Driver heated seat control module
• Driver outside rearview mirror (if equipped)
• Dvd player
• Electronic brake control module
• Eps fuse 41 60a
• Extended sedan
• From htd b st fuse 14 (diagram 1 of 5)
• Front auxiliary power outlet
• G303 (left kick panel)
• Garage door opener transmitter
• Generator
• Htd mir fuse 24 10a
• Htd st fuse 14 15a
• Nca
• Passenger heated seat control module
• Passenger outside rearview mirror (if equipped)
• Pcm fuse 13 10a
• Power steering control module
• Powertrain control module
• Rbec 1 fuse 22 60a
• Rear auxiliary power outlet
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rear window defogger grid
• Red
• Remote control door lock receiver
• Rke/xm dvd/ugd fuse 16 7.5a
• Rr defog fuse 23 30a
• Rr defog relay 26
• Starter
• Sun rf fuse 10 15a
• Sunroof control module
• To back up lp fuse (diagram 1 of 5)
• To ibcm 2 fuse 25 (diagram 2 of 5)
• Underhood fuse block (on left side of engine compt)

Power Distribution Wiring Diagram (2 of 5) for Chevrolet Malibu LT 2004

List of elements for Power Distribution Wiring Diagram (2 of 5) for Chevrolet Malibu LT 2004:

• (2.2l)
• (3.5l)
• (under left front seat) s301
• 2.2l
• 3.5l
• A/c clu fuse 1 10a
• A/c clutch relay 34
• Accessory relay
• B11
• Body control module (below right side of dash, near blower motor)
• C11
• D11
• D12
• Door locks fuse 15a
• Driver heated seat control module
• Driver heated seat switch
• Driver window switch
• E11
• Emissions 1 fuse 6 10a
• Etc fuse 2 15a
• Evaporative emission canister purge solenoid
• From eps a fuse 41 (diagram 1 of 5)
• Heated oxygen sensor bank 1 sensor 1
• Heated oxygen sensor bank 1 sensor 2
• Heated oxygen sensor bank 2 sensor 1
• Heated oxygen sensor bank 2 sensor 2
• Heated oxygen sensor sensor 2
• Ibcm 2 fuse 25 50a
• Inside rearview mirror (w/ light sensitive mirror)
• Logic
• Mass air flow/ air intake temperature sensor
• Passenger heated seat control module
• Passenger heated seat switch
• Passenger window switch
• Power windows fuse 30a
• Powertrain control module
• Powertrain control module (2.2l)
• Powertrain relay 33
• Rear fuse block
• Rly ctrl
• Roof/heat seat fuse 20a
• Sunroof control module (if equipped)
• Throttle actuator control module
• To ibcm 1 fuse 20 (diagram 3 of 5)
• To interior lights fuse (diagram 4 of 5)
• Under- hood fuse block (on left side of engine compt)
• Windshield wiper/ washer switch
• Wiper sw fuse 10a

Power Distribution Wiring Diagram (3 of 5) for Chevrolet Malibu LT 2004

List of elements for Power Distribution Wiring Diagram (3 of 5) for Chevrolet Malibu LT 2004:

• (not used)
• 1.3k ohm theft resistor
• Acc
• Acc vlt sig
• Airbag (batt) fuse 10a
• Body control module
• Body control module (below right side of dash, near blower motor)
• Cluster/ theft fuse 10a
• D11
• Data link connector
• From a/c clu fuse 1 c (diagram 2 of 5)
• High beam relay 35
• Horn fuse 8 15a
• Horn relay
• Hvac control module
• Hvac ctrl (batt) fuse 10a
• Ibcm 1 fuse 20 30a
• Ign 1 vlt sig
• Ign sensor fuse 2a
• Ignition switch
• Inflatable restraint sensing & diagnostic module
• Instrument panel cluster
• Key in ignition switch
• Logic
• Low beam relay 38
• Off
• Off/crnk/run
• Pnk
• Radio
• Radio fuse 10a
• Run
• Start
• Theft deterrent control module
• To run rly fuse 19 (diagram 4 of 5)
• Underhood fuse block (on left side of engine compt)

Power Distribution Wiring Diagram (4 of 5) for Chevrolet Malibu LT 2004

List of elements for Power Distribution Wiring Diagram (4 of 5) for Chevrolet Malibu LT 2004:

• (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel) rear fuse block
• (not used)
• Adjustable pedal module (if equipped)
• Adjustable pedal position switch (if equipped)
• Blower motor control module
• Body control module (below right side of dash, near blower motor)
• D10
• Driver seat adjuster switch
• Drv st fuse 2 30a
• E10
• Emissions fuse 2 10a
• Evaporative emissions canister vent solenoid valve
• From door d locks fuse (diagram 2 of 5)
• From horn fuse 8 e (diagram 3 of 5)
• Frt fog lp fuse 10 10a
• Frt fog relay
• Fuel fuse 25 15a
• Fuel relay
• Hvac blower fuse 20a
• Hvac blower high relay
• Hvac control module
• Hvac head ecc fuse 10a
• Inadvertent power outlet relay
• Interior lights fuse 10a
• Logic
• Onstar fuse 10a
• Outside rearview mirror switch
• Park lps fuse 6 10a
• Park lps relay
• Pedal fuse 10a
• Power mirrors fuse 2a
• Rbec 2 fuse 23 60a
• Rly ctrl
• Run relay
• Run rly fuse 19 30a
• To run crank relay 32 (diagram 5 of 5)
• Trunk fuse 22 10a
• Trunk relay
• Underhood fuse block (on left side of engine compt)
• Vehicle communication interface module (if equipped)
• Wiper 1 fuse 14 25a
• Wiper 1 relay

Power Distribution Wiring Diagram (5 of 5) for Chevrolet Malibu LT 2004

List of elements for Power Distribution Wiring Diagram (5 of 5) for Chevrolet Malibu LT 2004:

• (2.2l)
• (2.2l: in fuel inj wiring harn) (3.5l: fuel inj wiring harn, 4 cm from breakout to fuel injector 2)
• (3.5l)
• (if equipped)
• (near wind- shield wiper fluid reservoir) g109
• (not used)
• (on left side of engine compt) underhood fuse block
• 1-2 solenoid valve
• 2-3 solenoid valve
• A/t shift lock control assembly
• Abs fuse 15 10a
• Air bag ign fuse 10a
• B10
• Body control module
• Body control module (below right side of dash, near blower motor)
• C10
• Cruise control on/off switch (if equipped)
• Electronic brake control module
• Eps fuse 2a
• From wiper fuse 14 (diagram 4 of 5)
• Fuel injector
• Ibcm (r/c) fuse 21 30a
• Ign 1 fuse 3 15a
• Ignition control module
• Inflatable restraint sensing & diagnostic module
• Inflatable restraint steering wheel module coil
• Inj fuse 5 10a
• Park/ neutral position switch
• Pcm ign 1 fuse 16 10a
• Pnk
• Power steering control module
• Powertrain control module
• Red
• Rly hi ctrl
• Run crank fuse 2a
• Run/ crank relay 32
• S103
• S130
• Torque converter clutch pulse width modulation solenoid valve
• Trans fuse 4 10a

POWER DOOR LOCKS

Power Door Locks Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Power Door Locks Wiring Diagram for Chevrolet Malibu LT 2004:

• (below left side of dash) data link connector
• (below right side of dash, near blower motor) body control module
• Ajar
• Ajar switch pass dr
• Antenna
• B10
• C4 c3
• Cntrl act unlock door lock
• Door lock
• Door lock act lock cntrl
• Door lock fuse 15a
• Dr door key cyl resistor 620 ohms
• Driver door lock actuator
• Driver door lock switch
• Drvr dr ajar switch signal
• G301 (behind right rear seat back)
• G305 (right kick panel)
• Ground
• Hot at all times
• Instrument panel cluster
• Interior lights system
• Left rear door lock actuator
• Lock
• Logic
• Low spd gmlan
• Nca
• Passenger lock actuator
• Passenger lock switch
• Radio
• Rear fuse block
• Remote control door lock receiver (if equipped) (on rear package shelf)
• Right rear door lock actuator
• Rke/xm/ dvd/ugd fuse 16 7.5a
• Serial data
• Serial data gmlan low spd
• Signal
• Signal key switch drvr dr
• Signal lck/unlck
• Tan
• Trunk rel relay control
• Trunk release relay
• Unlk cntrl lock act drvr dr
• Unlock
• Vehicle communications interface module
• W/ vehicle communications
• W/o vehicle communi- cations

POWER MIRRORS

Automatic Day/Night Mirror Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Automatic Day/Night Mirror Wiring Diagram for Chevrolet Malibu LT 2004:

• (resets to daytime high reflectivity in reverse)
• Ambient light sensor (windshield side)
• Backup lamp pwr
• Backup lp fuse 17 10a
• Backup lp relay 33
• Body control module (below right side of dash, near blower motor)
• Exterior lights system
• G305 (right kick panel)
• Ground
• Headlight sensor (mirror side)
• High sensitivity setting
• Hot at all times
• Hot in acc and run
• Ign
• Inside rearview mirror
• Logic
• Low sensitivity setting
• Max
• Min
• Off
• Power tops system
• Rear fuse block
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rev lmp rly ctrl
• Roof/heat seat fuse 20a

Power Mirrors Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Power Mirrors Wiring Diagram for Chevrolet Malibu LT 2004:

• (left kick panel)
• Body control module (below right side of dash, near blower motor)
• Defogger system
• Down
• Driver
• Driver electric outside rearview mirror
• G303
• Hot at all times
• Left
• Left/ right
• Nca
• Outside rearview mirror switch
• Passenger
• Passenger electric outside rearview mirror
• Power mirrors fuse 2a
• Right
• Up/ down
• W/ remote control outside heated mirrors

POWER SEATS

2-Way Adjustable Power Seat Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for 2-Way Adjustable Power Seat Wiring Diagram for Chevrolet Malibu LT 2004:

• (left kick panel)
• Driver seat adjuster switch (2-way)
• Drv st fuse 2 30a
• Fwd
• G303
• Hot at all times
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rwd
• Seat vertical motor

6-Way Power Seat Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for 6-Way Power Seat Wiring Diagram for Chevrolet Malibu LT 2004:

• (left kick panel)
• Driver seat adjuster switch (6-way)
• Drv st fuse 2 30a
• Front down
• Front up
• Fwd
• G303
• Hot at all times
• Rear down
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rear up
• Rwd
• Seat front vertical motor
• Seat horizontal motor
• Seat rear vertical motor
• Tan

Adjustable Pedal Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Adjustable Pedal Wiring Diagram for Chevrolet Malibu LT 2004:

• Adj pedal inhibit sw
• Adjustable pedals actuator
• Adjustable pedals module
• Adjustable pedals position sensor (left of steering wheel)
• Adjustable pedals position switch
• Battery
• Body control module (below right side of dash, near blower motor)
• D10
• Enable sig
• Fwd
• G201 (center console, front of body control module)
• Gnd
• Hot at all times
• Inhibit sig
• Logic
• Low ref
• Pedal fuse 10a
• Pnk
• Rwd
• Sens sig

Heated Seats Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Heated Seats Wiring Diagram for Chevrolet Malibu LT 2004:

• (left kick panel) g303
• (under left front seat) s301
• Accy vlt
• Accy voltage
• Battery
• Body control module below right side of dash, near blower motor)
• Driver heated seat back element
• Driver heated seat control module
• Driver heated seat cushion element
• Driver heated seat cushion temperature sensor
• Driver heated seat switch
• Ground
• Heated seat sw sig
• High
• Hot at all times
• Hot in run and acc
• Htd seat fuse 14 15a
• Logic
• Low
• Off
• Passenger heated seat back element
• Passenger heated seat control module
• Passenger heated seat cushion element
• Passenger heated seat cushion temperature sensor
• Passenger heated seat switch
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Red
• Roof/ heat seat fuse 20a
• Seat back element ctrl
• Seat back element voltage
• Seat cushion element ctrl
• Seat cushion element voltage
• Seat cushion temp sen low ref
• Seat cushion temp sen sig

POWER TOP/SUNROOF

Power Top/Sunroof Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Power Top/Sunroof Wiring Diagram for Chevrolet Malibu LT 2004:

• (sedan: left rear seat, extended sedan: behind rear seat, on left quarter panel)
• Battery positive voltage
• Body control module (bcm) (below right side of dash, near blower motor)
• C4 f2
• Close
• G302
• Ground
• Hot at all times
• Hot in accy & run
• Logic
• Open
• Rear fuse block (sedan: left rear quarter panel) extended sedan: left rear of passenger compt)
• Roof/heat seat fuse 10 20a
• Sun rf fuse 10 15a
• Sun roof switch
• Sunroof control module (rear of sunroof)
• Sunroof motor
• Sunroof motor close control
• Sunroof motor close signal
• Sunroof motor open control
• Sunroof motor open signal
• Sunroof switch low reference

POWER WINDOWS

Power Windows Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Power Windows Wiring Diagram for Chevrolet Malibu LT 2004:

• (left kick panel)
• A11
• B11
• Body control module (bcm) (below right side of dash, near blower motor)
• C11
• Down
• Driver window motor
• Dwn
• Ecb
• Express
• Express down module
• Front passenger window motor
• Front passenger window switch
• G301 (behind right rear seat back)
• G303
• Hot w/ accessory relay energized
• Illumination lamp
• Interior lights system
• Left front
• Left rear
• Left rear window motor
• Left rear window switch
• Lock out switch
• Power window switch- driver
• Power windows fuse 30a
• Right front
• Right rear
• Right rear window motor
• Right rear window switch
• Tan

RADIO

4-Speaker System Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for 4-Speaker System Wiring Diagram for Chevrolet Malibu LT 2004:

• A10
• A11
• A12
• Antenna amplifier module
• B10
• B11
• B12
• Battery
• Body control module (below right side of dash, near blower motor)
• Cell phone low ref
• Cell phone voice sig
• Computer data lines system
• G201 (center console, front of body control module)
• Gmlan ser data
• Ground
• Hot at all times
• Left front door speaker
• Left rear speaker
• Lf speaker (+)
• Lf speaker (-)
• Logic
• Lr speaker (+)
• Lr speaker (-)
• Nca
• Pnk
• Radio
• Radio antenna
• Radio fuse 10a
• Rear window antenna module
• Rf speaker (+)
• Rf speaker (-)
• Right front door speaker
• Right rear speaker
• Rr speaker (+)
• Rr speaker (-)
• Tan
• Vehicle communication interface module (w/ on star)

6-Speaker System Wiring Diagram, with DVD (1 of 2) for Chevrolet Malibu LT 2004

List of elements for 6-Speaker System Wiring Diagram, with DVD (1 of 2) for Chevrolet Malibu LT 2004:

• (right kick panel) g305
• 10 volt ref
• A10
• A11
• A12
• Audio common
• B10
• B11
• B12
• Bare
• Battery
• Body control module (below right side of dash, near blower motor)
• Cell phone low ref
• Cell phone voice sig
• Computer data lines system
• Digital radio antenna
• Digital radio receiver (w/ digital audio system)
• Drain wire
• G201 (center console, front of body control module)
• Gmlan ser data
• Ground
• Hot at all times
• Inflatable restraint steering wheel module coil
• Left steering wheel controls
• Lf speaker (+)
• Lf speaker (-)
• Lr speaker (+)
• Lr speaker (-)
• Lt audio sig (+)
• Nca
• Ohms
• Radio
• Radio antenna
• Radio fuse 10a
• Rear block fuse (left rear of passenger compt)
• Rf speaker (+)
• Rf speaker (-)
• Right steering wheel controls
• Rke/xm dvd/ugd fuse 16 7.5a
• Rr speaker (+)
• Rr speaker (-)
• Rt audio sig (+)
• S203 (behind inflatable restraint wheel module)
• Strng whl ctrls sig
• Tan
• Vehicle communication interface module (w/ on star)

6-Speaker System Wiring Diagram, with DVD (2 of 2) for Chevrolet Malibu LT 2004

List of elements for 6-Speaker System Wiring Diagram, with DVD (2 of 2) for Chevrolet Malibu LT 2004:

• (right kick panel) g305
• Audio common
• Bare
• Battery
• Braided ground strap
• Bright ctrl
• Computer data lines system
• Drain wire
• Dvd player
• Gmlan ser data
• Ground
• Left front door speaker
• Left front door tweeter
• Left rear door speaker
• Lr speaker (-)
• Lt audio sig (-)
• Nca
• Red
• Right front door speaker
• Right front door tweeter
• Right rear door speaker
• Rr speaker (+)
• Rr speaker (-)
• Rt audio sig (+)
• Select 1
• Select 2
• Tan
• Video 8v
• Video ground
• Video screen
• Video signal

6-Speaker System Wiring Diagram, with Rear Controls (1 of 2) for Chevrolet Malibu LT 2004

List of elements for 6-Speaker System Wiring Diagram, with Rear Controls (1 of 2) for Chevrolet Malibu LT 2004:

• (right kick panel) g305
• 10 volt ref
• A10
• A11
• A12
• Audio common
• B10
• B11
• B12
• Bare
• Battery
• Body control module (below right side of dash, near blower motor)
• Cell phone low ref
• Cell phone voice sig
• Computer data lines system
• Digital radio antenna
• Digital radio receiver (w/ digital audio system)
• Drain wire
• G201 (center console, front of body control module)
• Gmlan ser data
• Ground
• Hot at all times
• Lf speaker (+)
• Lf speaker (-)
• Lr speaker (+)
• Lr speaker (-)
• Lt audio sig (+)
• Nca
• Radio
• Radio antenna
• Radio fuse 10a
• Rear block fuse (left rear of passenger compt)
• Rem radio ctrl sig
• Rf speaker (+)
• Rf speaker (-)
• Rke/xm dvd/ugd fuse 16 7.5a
• Rr speaker (+)
• Rr speaker (-)
• Rsa enable sig
• Rt audio sig (+)
• Strng whl ctrls sig
• Tan
• Vehicle communication interface module (w/ on star)

6-Speaker System Wiring Diagram, with Rear Controls (2 of 2) for Chevrolet Malibu LT 2004

List of elements for 6-Speaker System Wiring Diagram, with Rear Controls (2 of 2) for Chevrolet Malibu LT 2004:

• 10 volt ref
• Exterior lights system
• G305 (right kick panel)
• Ground
• I/p lamp volt
• Inflatable restraint steering wheel module coil
• Interior lights system
• Left front door speaker
• Left front door tweeter
• Left rear door speaker
• Left steering wheel controls
• Lr speaker (-)
• Ohms
• Prk lmps voltage
• Rear seat audio controller
• Rem radio ctrl sig
• Right front door speaker
• Right front door tweeter
• Right rear door speaker
• Right steering wheel controls
• Rr speaker (+)
• Rr speaker (-)
• Rsa enable sig
• S203 (behind inflatable restraint wheel module)
• Tan

6-Speaker System Wiring Diagram, without DVD or Rear Controls (1 of 2) for Chevrolet Malibu LT 2004

List of elements for 6-Speaker System Wiring Diagram, without DVD or Rear Controls (1 of 2) for Chevrolet Malibu LT 2004:

• (right kick panel) g305
• 10 volt ref
• A10
• A11
• A12
• Antenna amplifier module
• Audio common
• B10
• B11
• B12
• Bare
• Battery
• Body control module (below right side of dash, near blower motor)
• Cell phone low ref
• Cell phone voice sig
• Computer data lines system
• Digital radio antenna
• Digital radio receiver (w/ digital audio system)
• Drain wire
• Extended sedan
• G201 (center console, front of body control module)
• Gmlan ser data
• Ground
• Hot at all times
• Lf speaker (+)
• Lf speaker (-)
• Logic
• Lr speaker (+)
• Lr speaker (-)
• Lt audio sig (+)
• Nca
• Pnk
• Radio
• Radio antenna
• Radio fuse 10a
• Rear fuse block (extended sedan: left rear of passenger compt) (sedan: left rear quarterpanel)
• Rear window antenna module
• Rf speaker (+)
• Rf speaker (-)
• Rke/xm dvd/ugd fuse 16 7.5a
• Rr speaker (+)
• Rr speaker (-)
• Rt audio sig (+)
• Sedan
• Strng whl ctrls sig
• Tan
• Vehicle communication interface module (w/ onstar)

6-Speaker System Wiring Diagram, without DVD or Rear Controls (2 of 2) for Chevrolet Malibu LT 2004

List of elements for 6-Speaker System Wiring Diagram, without DVD or Rear Controls (2 of 2) for Chevrolet Malibu LT 2004:

• Inflatable restraint steering wheel module coil
• Left front door speaker
• Left front door tweeter
• Left rear speaker (sedan) left rear door speaker (extended sedan)
• Left steering wheel controls
• Ohms
• Right front door speaker
• Right front door tweeter
• Right rear speaker (sedan) right rear door speaker (extended sedan)
• Right steering wheel controls
• S203 (behind inflatable restraint wheel module)
• Tan

SHIFT INTERLOCK

Shift Interlock Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Shift Interlock Wiring Diagram for Chevrolet Malibu LT 2004:

• 1k ohm
• 3k ohm
• 5 volt reference
• A/t shift lock control assembly
• A/t shift lock control solenoid
• Battery
• Body control module (bcm) (below right side of dash, near blower motor)
• Brake pedal position sensor (on brake pedal support)
• Brake pedal position sensor signal
• Door locks fuse 15a
• G303 (left kick panel)
• G305 (right kick panel)
• Ground
• Hot at all times
• Interior lights fuse 10a
• Logic
• Low reference

STARTING/CHARGING

Charging Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Charging Wiring Diagram for Chevrolet Malibu LT 2004:

• (2.2l)
• 2.2l
• 3.5l
• 3.5l 2.2l
• Battery
• Charge indicator
• Class 2 serial data
• Computer data lines system
• G104 (left side of engine compt)
• G105 (right rear of eng, on eng to trans stud)
• Generator
• Generator field duty cycle signal
• Generator turn on signal
• High speed gmlan serial data bus +
• High speed gmlan serial data bus -
• Instrument panel cluster (ipc)
• Low speed gmlan serial data
• Power distribution system
• Powertrain control module (pcm) (front of battery)
• Red
• Starter
• Tan

Starting Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Starting Wiring Diagram for Chevrolet Malibu LT 2004:

• (2.2l)
• (below right side of dash) body control module (bcm)
• (left side of eng compt) underhood fuse block
• (near windshield wiper fluid reservoir)
• 2.2l
• 3.5l
• 5v ref
• A3 c2
• Acc
• B10
• Battery
• C1 c2
• C10
• C4 d1
• Computer data lines system
• D10 c1
• D12 c1
• Door lock lock/unlock signal
• Door locks system
• E11
• Ecm high speed gmlan serial data bus +
• Ecm high speed gmlan serial data bus -
• Exterior lights system
• G101
• G104 (left side of engine compt)
• G105 (right rear of eng, on eng to trans stud)
• G109 (near windshield wiper fluid reservoir)
• Generator
• Hazard switch signal
• High speed gmlan serial data bus +
• High speed gmlan serial data bus -
• Hood ajar switch
• Hood ajar switch signal
• Hot at all times
• Ign 1 fuse 3 15a
• Ignition sensor fuse 2a
• Ignition switch
• Key-in ignition switch
• Lock
• Logic
• Nca
• Off/run crank voltage signal
• Park/neutral position (pnp) switch (top of transmission)
• Pnk
• Power distribution system
• Powertrain control module (pcm) (front of battery)
• Red
• Run
• Run/crank relay 32
• Run/crank relay coil control
• Serial data
• Start
• Starter
• Starter fuse 26 30a
• Starter relay 31
• Starter rly coil ctrl
• Starter rly coil sply voltage
• Tan
• Underhood fuse block (left side of eng compt)

SUPPLEMENTAL RESTRAINTS

Supplemental Restraints Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for Supplemental Restraints Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• Airbag (batt) fuse 10a
• Airbag (ign) fuse 10a
• Body control module (under front end of center console, under dash)
• Case ground
• Computer data lines system
• D11
• Driver seat belt buckle switch
• Driver seat belt pretensioner
• Driver seat position sensor
• G304 (behind right kick panel)
• Ground
• High control
• Hot at all times
• Hot in run or start
• Ignition 1
• Inflatable restraint sensing & diagnostic module (sdm) (under center console, rear of shifter)
• Left inflatable restraint front end discriminating sensor (on left side of front impact bar)
• Left inflatable restraint side impact module (on left "c" pillar & over left doors)
• Left inflatable restraint side impact sensing module (in left front door toward bottom)
• Low control
• Low ref
• Nca
• Passenger seat belt pretensioner
• Pnk
• Right inflatable restraint front end discriminating module (on right side of front impact bar)
• Right inflatable restraint side impact module (on right "c" pillar & over right doors)
• Right inflatable restraint side impact sensing module (in right front door toward bottom)
• Serial data
• Shorting bar
• Shorting clip
• Signal
• Tan
• Twisted pair wires
• Voltage

Supplemental Restraints Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for Supplemental Restraints Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• Air bag indicator
• Batt
• Body control module (under front end of center console, under dash)
• Computer data lines system
• Inflatable restraint i/p module
• Inflatable restraint steering wheel module
• Inflatable restraint steering wheel module coil
• Instrument panel cluster
• Logic
• Pnk
• Serial data
• Shorting bar
• Shorting clip
• Stage 1
• Stage 2
• Tan
• Twisted pair wires
• Vehicle communications interface module (behind right side of dash)
• W/ vehicle communications
• W/o vehicle communications

TRANSMISSION

2.2L VIN F

2.2L VIN F, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for 2.2L VIN F, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• 1-2 shift sol
• 2-3 shift sol
• 5v ref
• A/t sensor hi
• A/t sensor lo
• App sens 1 sig
• App sens sig
• Automatic transaxle (4t40-e/ 4t45-e)
• Automatic transaxle fluid pressure manual valve position switch
• Automatic transaxle fluid temperature sensor
• Automatic transaxle input shaft speed sensor
• Battery in
• Computer data lines system
• D12
• Ect sensor in
• Engine coolant temperature sensor (top rear of engine)
• Etc fuse 10a
• G105 (right rear of eng, on eng to trans stud)
• Gmlan data
• Gnd
• Hot at all times
• Hot in run or start
• Hot with powertrain relay energized
• Ignition (1) in
• Info not available
• Instrument cluster
• Low ref
• Mil ctrl
• Pc sol hi
• Pc sol lo
• Pcm fuse 13 10a
• Pcm ign1 fuse 10a
• Pnk
• Powertrain control module (front of battery)
• Pressure control sol
• Red
• Rev,d,2,1
• Service engine soon indicator
• Stop lp sw
• Tan
• Tap sw sig
• Tcc pwm sol
• Tcc release
• Tcc release in
• Tft sensor gnd
• Tft sensor in
• Tr sw in-a
• Tr sw in-b
• Tr sw in-c
• Tr sw in-p
• Trans fuse 4 10a
• Trans range b
• Trans range c
• Underhood fuse block (left side of engine compt)
• Vehicle speed sensor (rear of transaxle)
• Vss hi (signal)
• Vss lo (ground)

2.2L VIN F, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for 2.2L VIN F, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• (below center console shifter) a/t shift lock control solenoid
• 5v ref
• Body control module (bcm) (below right side of dash, near blower motor)
• Brake pedal position sens sig
• Brake pedal position sensor (on brake pedal support)
• Computer data lines system
• G105 (right rear of eng, on eng to trans stud)
• G303 (left kick panel)
• Gmlan data +
• Gmlan data -
• Hot in run or start
• Low ref
• Park/neutral position switch (top of transaxle)
• Pnk
• Run/ crank fuse 2a
• Tan
• Tap enable sig
• Tap up/ tap down switch
• Throttle actuator control (tac) module (on intake manifold)

3.5L VIN 8

3.5L VIN 8, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu LT 2004:

• 1-2 shift sol
• 2-3 shift sol
• A/t sensor hi
• A/t sensor lo
• Automatic transaxle (4t40-e/ 4t45-e)
• Automatic transaxle fluid pressure manual valve position switch
• Automatic transaxle fluid temperature sensor
• Automatic transaxle input shaft speed sensor
• Battery in
• Computer data lines system
• D12
• Ect sensor in
• Engine coolant temperature sensor (top rear of engine)
• Etc fuse 10a
• Exterior lights system
• G105 (right rear of eng, on eng to trans stud)
• Gmlan data
• Gnd
• Hot at all times
• Hot in run or start
• Hot with powertrain relay energized
• Ignition (1) in
• Instrument cluster
• Low ref
• Mil ctrl
• Pc sol hi
• Pc sol lo
• Pcm fuse 13 10a
• Pcm ign1 fuse 10a
• Pnk
• Powertrain control module (front of battery)
• Pressure control sol
• Red
• Rev,d,2,1
• Service engine soon indicator
• Stop lp sw
• Tan
• Tap sw sig
• Tcc pwm sol
• Tcc release
• Tcc release in
• Tft sensor gnd
• Tft sensor in
• Tr sw in-a
• Tr sw in-b
• Tr sw in-c
• Tr sw in-p
• Trans fuse 4 10a
• Trans range b
• Trans range c
• Underhood fuse block (left side of engine compt)
• Vehicle speed sensor (rear of transaxle)
• Vss hi (signal)
• Vss lo (ground)

3.5L VIN 8, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004

List of elements for 3.5L VIN 8, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu LT 2004:

• (below center console shifter) a/t shift lock control solenoid
• 5v ref
• Accelerator pedal position (app) sensor (attached to accelerator pedal)
• App sens 1
• App sens 2
• Body control module (bcm) (below right side of dash, near blower motor)
• Brake pedal position sens sig
• Brake pedal position sensor (on brake pedal support)
• Computer data lines system
• G105 (right rear of eng, on eng to trans stud)
• G303 (left kick panel)
• Gmlan data +
• Gmlan data -
• Hot in run or start
• Low ref
• Park/neutral position switch (top of transaxle)
• Pnk
• Run/ crank fuse 2a
• Serial data
• Stop lp sw
• Tan
• Tap enable sig
• Tap up/ tap down switch
• Throttle actuator control (tac) module (on intake manifold)

TRUNK, TAILGATE, FUEL DOOR

Trunk, Tailgate, Fuel Door Wiring Diagram, 4 Door for Chevrolet Malibu LT 2004

List of elements for Trunk, Tailgate, Fuel Door Wiring Diagram, 4 Door for Chevrolet Malibu LT 2004:

• (left kick panel)
• Ajar
• B10
• Body control module (below right side of dash, near blower motor)
• C10
• Computer data lines system
• E10
• Exterior rear compartment lid release switch
• F10
• G302 (behind left rear seat)
• G303
• Hot at all times
• Lftgt rel sw sig
• Lo spd gmlan ser data
• Logic
• Nca
• Radio
• Rear compartment lid latch
• Rear compartment/ liftgate release switch
• Rear fuse block (left rear quarterpanel)
• Remote control door lock receiver (on rear package shelf)
• Rr compt lid ajar sw
• Serial data
• Tan
• Trnk rel rly ctrl
• Trunk ajar
• Trunk fuse 22 10a
• Trunk rel sw pwr
• Trunk relay

Trunk, Tailgate, Fuel Door Wiring Diagram, 5 Door for Chevrolet Malibu LT 2004

List of elements for Trunk, Tailgate, Fuel Door Wiring Diagram, 5 Door for Chevrolet Malibu LT 2004:

• (left kick panel)
• B10
• Body control module (below right side of dash, near blower motor)
• C10
• Cargo lamp switch
• Computer data lines system
• Door locks system
• Drvr dr key sw sig
• E10
• F10
• G302 (behind left rear seat)
• G303
• Gate ajar
• Hot at all times
• Lftgt rel sw sig
• Liftgate release switch
• Lo spd gmlan ser data
• Logic
• Radio
• Rear compartment lid latch
• Rear compartment/ liftgate release switch
• Rear fuse block (left rear of passenger compt)
• Remote control door lock receiver (on rear package shelf)
• Rr compt lid ajar sw
• Serial data
• Trnk rel rly ctrl
• Trunk fuse 22 10a
• Trunk relay

WARNING SYSTEMS

Warning Systems Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Warning Systems Wiring Diagram for Chevrolet Malibu LT 2004:

• (under center console, under carpet)
• Ajar
• Auto
• Body control module (bcm) (behind right side of dash)
• Chime
• Computer data lines system
• Driver door lock actuator
• G201 (center of console, front of body control module)
• G301 (behind right rear seat back)
• Ground distribution system
• Head
• Hot at all times
• Ign
• Ign sensor fuse 2a
• Ignition switch
• Inflatable restraint sensing & diagnostic module (sdm)
• Instrument panel cluster (ipc)
• Key in ignition switch
• Left rear door lock actuator
• Left seat belt sw
• Lf door ajar switch sig
• Logic
• Low ref
• Low spd gmlan serial data
• Low spd gmlan serial data bus
• Low speed gmlan serial data
• Off
• Off/run/ crank voltage
• Park
• Park lamp switch sig
• Pass door ajar switch sig
• Passenger door lock actuator
• Pnk
• Right rear door lock actuator
• Seat belt ind
• Seat belt switch
• Turn signal/ multifunction switch

WIPER/WASHER

Wiper/Washer Wiring Diagram for Chevrolet Malibu LT 2004

List of elements for Wiper/Washer Wiring Diagram for Chevrolet Malibu LT 2004:

• .75k
• 1.02k
• 1.4k
• 1.78k
• 1.87k
• 2.61k
• Accessory relay
• Accessory relay control
• B10
• Body control module (below right side of dash, near blower motor)
• C10
• C12
• Computer data lines system
• Delay switch
• Display
• Fuse block underhood (on left side of eng compt)
• G101 (near windshield wiper fluid reservoir)
• G109 (near windshield wiper fluid reservoir)
• High
• Hot at all times
• Int
• Logic
• Low
• Low speed washer fluid
• Mist
• Off
• Radio
• Washer switch
• Windshield washer fluid level switch (left front wheelwell, bottom of reservoir)
• Windshield washer fluid pump (left front wheelwell, bottom of reservoir)
• Windshield washer pump control
• Windshield wiper motor assembly (on left rear of eng compt)
• Windshield wiper motor park switch signal
• Windshield wiper switch signal 1
• Windshield wiper switch signal 2
• Windshield wiper/ washer switch
• Wiper 1 relay 39
• Wiper 2 relay 40
• Wiper fuse 14 25a
• Wiper sw fuse 10a
• Wiper switch