A | Battery |
B | Starter |
C | Alternator |
C1 | Voltage regulator |
D | Ignition/starter switch |
F26 | Thermo-time switch (located on the water spigot on the front of the engine cylinder head) |
N17 | Cold start valve (located on the end of the inlet manifold) |
Ta | Connector, single, white, strapped to the harness at the battery positiv pole |
T2a/ | Connector, 2-pin, black, behind the fuse box |
T2b/ | Connector, 2-pin, white, behind the fuse box |
4 | Earthing strap, battery - body-gearbox |
G40 | Hall sender unit (located on the distributer) |
J143 | Control unit for idling speed boost (located on the fuse box) |
N16 | Two-way valve for increased idling speed (located in the engine compartment and attached to the right hand side spring cup/shock tower) |
N41 | TSI control module (located in the centre of the waterbox) |
N | Ignition coil |
O | Ignition distributor |
P | Spark plug connectors |
Q | Spark plugs |
Tb | Connector, single, black, strapped to the engine harness in the engine compartment, left hand side |
T4a/ | Connector, 4-pin, white, behind the fuse box |
G6 | Fuel pump (located under the vehicle, at the rear left hand side) |
J17 | Fuel pump relay |
N9 | Warm-up valve (located on the front of the engine block) |
N11 | Idling enrichment valve (located on the back of the inlet mainfold) |
S5 | Fuse, 15 amp, for the fuel pump, warm-up valve and idling-enrichment valve |
Td | Connector, single, white, behind the fuse box |
F60 | Idling switch (located on the throttle body in the engine compartment) |
F66 | Coolant shortage indicator switch (located in the coolant reservoir) |
F93 | Diaphragm pressure switch (located in the engine compartment at the K-jetronic fuel-metering unit) |
G2 | Coolant temperature gauge sender (located in the water spigot on the front of the cylinder head) |
J120 | Coolant shortage/coolant temperature control module (located on the fuse box) |
Te | Connector, single, white, in the left hand side of the waterbox |
Tf | Connector, single, bare, in the left hand side of the waterbox |
Tg | Connector, single, white, behind the fuse box |
T2c/ | Connector, 2-pin, white, in the left hand side of the waterbox |
T4a/ | Connector, 4-pin, white, behind the fuse box |
85 | Earth connection in engine wiring harness |
F9 | Handbrake warning system contact (located at the handbrake) |
F34 | Brake fluid level warning contact (located in the brake fluid filler bottle) |
J29 | Blocking diode (blue) for the alarm system (located behind the fuse box) |
K7 | Dual brake and handbrake warning light |
Tc | Connector, single, white, behind the fuse box |
T2d/ | Connector, 2-pin, white, behind the dash panel, at the choke lever blanking plate |
T6a/ | Connector, 6-pin, white, behind the fuse box |
G | Fuel gauge sender unit |
G1 | Fuel gauge |
G3 | Coolant temperature gauge |
J6 | Voltage regulator (+ 10 volts) |
K28 | Warning lamp for coolant temperature/coolant shortage |
S18 | Fuse, 15 amp, for instrument cluster and coolant shortage/coolant temperature controle module |
Th | Connector, single, black, behind the fuse box |
Tj | Connector, single, black sheathed, in the cross-member beneath the passenger seat |
Tk | Connector, single, bare, in the cross-member beneath the passenger seat |
T6a/ | Connector, 6-pin, white, behind the fuse box |
30 | Earth point, on the earth rosette, behind the dash panel next to the fuse box |
86 | Earth connection in the SBBR (rear) wiring harness |
G8 | Oil temperature sender (located on the front of the engine block) |
G9 | Oil temperature gauge (located in the console) |
G10 | Oil pressure sender (located on the front of the engine block) |
G11 | Oil pressure gauge (located in the console) |
G14 | Voltmeter (located in the console) |
L24 | Oil temperature gauge light bulb (located in the oil temperature gauge) |
L25 | Voltmeter light bulb (located in the voltmeter) |
L27 | Oil pressure gauge light bulb (located in the oil pressure gauge) |
T2e/ | Connector, 2-pin, white, behind the fuse box |
T2f/ | Connector, 2-pin, white, behind the dash panel, in the centre |
T3a/ | Connector, 3-pin, white/black, behind the dash panel, in the centre |
J12 | Main beam headlight relay |
L1 | Twin filament bulb, left hand side |
L2 | Twin filament bulb, right hand side |
L13 | Main beam headlight, left hand side |
L14 | Main beam headlight, right hand side |
M1 | Side light bulb, left hand side |
M3 | Side light bulb, right hand side |
S9 | Fuse, 10 amp, high beam warning light, right hand side high beam headlight |
S10 | Fuse, 10 amp, main beam headlight relay, left hand side high beam headlight |
S20 | Fuse, 10 amp, number plate lights, cigar lighter light bulb, emergency lights warning lamp, heated rear window switch warning lamp |
S21 | Fuse, 10 amp, low beam headlight, right side |
S22 | Fuse, 10 amp, low beam headlight, left side |
S51 | Fuse, 15 amp, for the main beam headlights (located on fuse box) |
T2g/ | Connector, 2-pin, white, behind the right hand side main beam headlight |
T2h/ | Connector, 2-pin, white, behind the left hand side main beam headlight |
X | Number plate lights |
11 | Earth point, at the battery box |
50 | Earth point, in the luggage compartment (under the carpet) |
151 | Earth connection in the front wiring harness |
M2 | Tail light bulb, right hand side |
M4 | Tail light bulb, left hand side |
M5 | Front left hand side turn signal bulb |
M6 | Rear left hand side turn signal bulb |
M7 | Front right hand side turn signal bulb |
M8 | Rear right hand side turn signal bulb |
M9 | Brake light bulb, left hand side |
M10 | Brake light bulb, right hand side |
M16 | Reverse light bulb, left hand side |
M17 | Reverse light bulb, right hand side |
T6a/ | Connector, 6-pin, white, behind the dash panel near the fuse box |
50 | Earth point, in the luggage compartment (under the carpet) |
151 | Earth connection in the front wiring harness |
E4 | Headlight dipper/flasher switch |
F | Brake light switch (located on the brake booster in the engine compartment) |
F4 | Reverse light switch (located on the gearbox) |
S2 | Fuse, 10 amp, for the brake lights |
S15 | Fuse, 10 amp, for the reverse lights |
TI | Connector, single, black, behind the fuse box |
E15 | Heated rear window switch |
K10 | Heated rear window warning lamp |
L39 | Heated rear window switch bulb |
R | Philips DC 363 radio/tape unit |
R4 | Rear left hand side loudspeaker |
R5 | Rear right hand side loudspeaker |
S13 | Fuse, 20 amp, for the heated rear window and the heated rear window warning lamp |
S29 | Fuse, 2.5 amp, for the radio/tape system (located behind the radio/tape unit) |
Tm | Connector, single, black/white, at the left hand side C-post |
Tn | Connector, single, white, in the dash panel behind the radio/tape unit |
Tp | Connector, single, white, in the dash panel behind the radio/tape unit |
To | Connector, single, white, in the centre of the rear roof cross-member |
T2j/ | Connector, 2-pin, white, near the fuse box |
T3a/ | Connector, 3-pin, white/black, behind the dash panel, in the centre |
T4b/ | Connector, 4-pin, white, in the dash panel behind the radio/tape unit |
Z1 | Heated rear window |
73 | Earth point, under the headlining in the centre of the rear roof cross-member |
J30 | Rear window wiper/washer relay |
S12 | Fuse, 15 amp, for the rear wiper motor and the console instrumentation |
Tq | Connector, single, white, in the left hand side C-post near the SBBR light cluster |
Tr | Connector, single, white, in the left hand side C-post near the SBBR light cluster |
V12 | Rear wiper motor |
V13 | Rear window washer pump motor |
73 | Earth point under the headlining in the centre of the rear roof cross-member |
F2 | Front left hand side door contact switch |
F3 | Front right hand side door contact switch |
F5 | Luggage compartment light switch |
F10 | Rear left hand side door contact switch |
F11 | Rear right hand side door contact switch |
W | Interior light |
W3 | Luggage compartment light |
S3 | Fuse, 15 amp, for the interior lights, cigarette lighter, clock and radio/tape system |
Ts | Connector, single, white, in the left hand side C-post above the SBBR light cluster |
T2k/ | Connector, 2-pin, white, behind the dash panel near the fuse box |
T2L/ | Connector, 2-pin, white, behind the fuse box |
T3b/ | Connector, 3-pin, white, in the cross-member under the passenger seat |
T6a/ | Connector, 6-pin, white, behind the dash panel near the fuse box |
74 | Earth point under the headlining at the interior light |
E9 | Fresh air blower control switch |
L16 | Fresh air controls light bulb |
N23 | Series resistance for the fresh air blower motor (located in the centre of the waterbox ) |
S14 | Fuse, 20 amp, for the fresh air blower motor and the lighting switch light bulb |
Tt | Connector, single, black/white, behind the dash panel, centre |
Tu | Connector, single, black/white, behind the dash panel, centre |
T2m/ | Connector, 2-pin, white, behind the dash panel, centre |
V2 | Fresh air blower motor |
30 | Earth point, on the earth rosette near the fuse box |
A | Battery |
B | Starter |
C | Alternator |
C1 | Voltage regulator |
D | Ignition/starter switch |
F26 | Thermo-time switch (located on the water spigot on the front of the cylinder head) |
N17 | Cold start valve (located on the end of the inlet manifold) |
Ta | Connector, single, white, strapped to the harness at the battery positiv pole |
Tv | Connector, single, white, at battery + ve pole |
Tw | Connector, single, white, below the dash panel at the air conditioner unit |
T2a/ | Connector, 2-pin, black, behind the fuse box |
T2b/ | Connector, 2-pin, white, behind the fuse box |
4 | Earth strap, battery - body-gearbox |
F60 | Idling switch (located on the throttle body in the engine compartment) |
F66 | Coolant shortage indicator switch (located in the coolant reservoir) |
F93 | Diaphragm pressure switch (located in the engine compartment at the K-jetronic fuel-metering unit) |
G2 | Coolant temperature gauge sender (located in the water spigot on the front of the cylinder head) |
J120 | Coolant shortage/coolant temperature control module (located on the fuse box) |
N16 | Two-way valve for increased idling speed (located in the engine compartment and attached to right side spring cup/shock tower) |
Te | Connector, single, white, in the left hand side of the waterbox |
Tf | Connector, single, bare, in the left hand side of the waterbox |
Tg | Connector, single, white, behind the fuse box |
T2c/ | Connector, 2-pin, white, in the left hand side of the waterbox |
T4a/ | Connector, 4-pin, white, behind the fuse box |
85 | Earth connection in the engine wiring harness |
G | Fuel gauge sender unit (located on the top of the fuel tank) |
G1 | Fuel gauge |
G3 | Coolant temperature gauge |
J6 | Voltage regulator (+ 10 volts) |
K28 | Warning lamp for the coolant temperature/coolant shortage |
S18 | Fuse, 15 amp, for the instrument cluster and the coolant shortage/coolant temperature controle module |
Th | Connector, single, black, behind the fuse box |
Tj | Connector, single, black sheath, in the cross-member beneath the passenger seat |
Tk | Connector, single, bare, in the cross-member beneath the passenger seat |
Tx | Connector, single, clear sheath, below the dash panel at the air conditioner unit |
T6a/ | Connector, 6-pin, white, behind the fuse box |
30 | Earth point, on the earth rosette, behind the dash panel next to the fuse box |
86 | Earth connection in the SBBR (rear) wiring harness |
J30 | Rear window wiper/washer relay |
S12 | Fuse, 15 amp, for the rear wiper motor and the console instrumentation |
Tq | Connector, single, white, in the left hand side C-post near the SBBR light cluster |
Tr | Connector, single, white, in the left hand side C-post near the SBBR light cluster |
V12 | Rear wiper motor |
V13 | Rear window washer pump motor |
73 | Earth point under the headlining in the centre of the rear roof cross-member |
F18 | Radiator fan thermo-switch (located on the left hand side of the radiator) |
J32 | Air conditioner relay (located on the air conditioner unit under the dash panel) |
J101 | Radiator fan 2nd stage relay (located in the front left side of the engine compartment) |
J157 | Evaporator blower motor relay (located on the air conditioner unit under the dash panel) |
S1 | Fuse, 30 amp, for the radiator fan |
S104 | Fuse, 5 amp, for the air conditioner relay, air conditioner control module and the evaporator blower motor relay (located on the air conditioner unit under the dash panel) |
S105 | Fuse, 20 amp, for evaporator blower motor and air conditioner control module (located on air conditioner unit under the dash panel) |
Ty | Connector, single, white, at the air conditioner unit under the dash panel |
Tz | Connector, single, white, at the air conditioner unit under the dash panel |
TA | Connector, single, white, at the air conditioner unit under the dash panel |
T2n/ | Connector, 2-pin, black, in the engine compartment behind the left headlight |
T2p/ | Connector, 2-pin, white, in the engine compartment behind the left headlight |
T2q/ | Connector, 2-pin, white, at the air conditioner unit under the dash panel |
T8a/ | Connector, 8-pin, white, below dash panel at the air conditioner unit |
V7 | Radiator fan |
F23 | High pressure switch for air conditioner (located in engine compartment, right side) |
F45 | Air conditioner thermo-switch (located on the a/c compressor in the engine compartment) |
F189 | Air conditioner control potentiometer |
G57 | Temperature sensor in the evaporator air inlet (located inside the air conditioner unit) |
J127 | Control and regulating unit for the air conditioner (located on air conditioner unit) |
J246 | Cut-out module for a/c compressor (located behind the dash panel, top left hand side) |
N25 | Air conditioner magnetic coupling |
N62 | Two-way valve for idling-speed boost (located in the centre of the waterbox) |
TB | Connector, single, white, at the air conditioner unit under the dash panel |
TC | Connector, single, clear sleeve, on compressor |
TD | Connector, single, clear sleeve, on compressor |
TE | Connector, single, white, behind the fuse box |
T2r/ | Connector, 2-pin, white, at the air conditioner unit under the dash panel |
T2s/ | Connector, 2-pin, white, behind the dash panel, behind the air conditioner control potentiometer |
T2t/ | Connector, 2-pin, white, at the air conditioner unit under the dash panel |
T8a/ | Connector, 8-pin, white, at the air conditioner unit under the dash panel |
L9 | Connection -1- in air conditioner wiring harness |
11 | Earth point on the battery box |
30 | Earth point, on the earth rosette, next to fuse box |
E30 | Air conditioner switch |
J28 | Blocking diode for the air conditioner (located at the air conditioner unit under the dash panel) |
N81 | Series resistance for the evaporator blower motor (located inside the air conditioner unit) |
S64 | Thermal fuse for the evaporator blower motor series resistance (located with the series resistances inside the air conditioner unit) |
T2q/ | Connector, 2-pin, white, at the air conditioner unit under the dash panel |
T4c/ | Connector, 4-pin, white, at the air conditioner unit under the dash panel |
V20 | Evaporator blower motor (located in the air conditioner unit under the dash panel) |
L10 | Connection -2- in the air conditioner wiring harness |
30 | Earth point on the earth rosette above the fuse box |
97 | Earth connection -1- in the air conditioner wiring harness |
F60 | Idling switch (located on the throttle body in the engine compartment |
F66 | Coolant shortage indicator switch (located in the coolant reservoir) |
F93 | Diaphragm pressure switch (located in the engine compartment at the K-jetronic fuel-metering unit |
G2 | Coolant temperature gauge sender (located in the water spigot on front of cylinder head) |
J120 | Coolant shortage/coolant temperature control module (located on the fuse box) |
N16 | Two-way valve for increased idling speed (located in the engine compartment and attached to right side spring cup/shock tower) |
Te | Connector, single, white, in the left side of the waterbox |
Tf | Connector, single, bare, in the left side of the waterbox |
Tg | Connector, single, white, behind the fuse box |
TF | Connector, single, black |
T2c/ | Connector, 2-pin, white, in the left side of the waterbox |
T4a/ | Connector, 4-pin, white, behind the fuse box |
85 | Earth connection in the engine wiring harness |
G | Fuel gauge sender unit |
G1 | Fuel gauge |
G3 | Coolant temperature gauge |
J6 | Voltage regulator (+ 10 volts) |
K28 | Warning lamp for coolant temperature/coolant shortage |
S18 | Fuse, 15 amp, for the instrument cluster and the coolant shortage/coolant temperature controle module |
Th | Connector, single, black, behind the fuse box |
Tj | Connector, single, black sheat, in the cross-member beneath the passenger seat |
Tk | Connector, single, bare, in the cross-member beneath passenger seat |
T6a/ | Connector, 6-pin, white, behind the fuse box |
30 | Earth point, on earth rosette, behind the dash panel next to the fuse box |
86 | Earth connection in the (rear) SBBR wiring harness |
J12 | Main beam headlight relay |
L1 | Twin filament bulb, left hand side |
L2 | Twin filament bulb, right hand side |
L13 | Main beam headlight, left hand side |
L14 | Main beam headlight, right hand side |
M1 | Side light bulb, left hand side |
M3 | Side light bulb, right hand side |
S9 | Fuse, 10 amp, high beam warning light, right hand side high beam headlight |
S10 | Fuse, 10 amp, main beam headlight relay, left hand side high beam headlight |
S20 | Fuse, 10 amp, number plate lights, cigar lighter light bulb, emergency lights warning lamp, heated rear window switch warning lamp |
S21 | Fuse, 10 amp, low beam headlight, right side |
S22 | Fuse, 10 amp, low beam headlight, left side |
S51 | Fuse, 15 amp, for the main beam headlights (located on the fuse box) |
T2g/ | Connector, 2-pin, white, behind the right hand side main beam headlight |
T2h/ | Connector, 2-pin, white, behind the left hand side main beam headlight |
X | Number plate lights |
11 | Earth point, at the battery box |
50 | Earth point, in the luggage compartment (under the carpet) |
151 | Earth connection in the front wiring harness |
E30 | Air conditioner switch |
F73 | Low pressure switch for the air conditioner (located in the front left engine compartment) |
G18 | Temperature sensor (located in the air conditioner unit) |
J127 | Control and regulating unit for the air conditioner (located above the steering column on the dash panel cross-member) |
N23 | Series resistance for the fresh air blower (located on the blower motor in the waterbox) |
N25 | Air conditioner magnetic coupling |
N62 | Two-way valve for idling-speed boost (located in engine compartment, right side) |
N81 | Series resistance for evaporator blower (located in the air conditioner unit) |
Tu | Connector, single, black/white, behind dash panel, centre |
TA | Connector, single, white, behind the dash panel on the right side of the air conditioner unit |
TB | Connector, single, black, in the right hand side engine compartment at the magnetic coupling |
TC | Connector, single, black, behind the fuse box |
T2m/ | Connector, 2-pin, white, behind the dash panel on right side of the air conditioner unit |
T2u/ | Connector, 2-pin, white, behind the dash panel on right side of the air conditioner unit |
T2v/ | Connector, 2-pin, white, at air conditioner unit |
V2 | Fresh air blower |
V20 | Evaporator blower motor |
30 | Earth point on the earth rosette, near the fuse box |
97 | Earth connection -1- in air conditioner wiring harness |
F18 | Radiator fan thermo-switch (located on the left hand side of the radiator) |
F23 | High pressure switch for the air conditioner (located in the front right hand side of the engine compartment) |
J26 | Radiator fan 1st stage relay (located in the engine compartment, front left hand side) |
J101 | Radiator fan 2nd stage relay (located in the engine compartment, left hand side) |
N63 | Two-way valve for fresh air and re-circulating air flap (located on the fresh air blower unit) |
S1 | Fuse, 30 amp, for the radiator fan |
T2n/ | Connector, 2-pin, black, in the engine compartment behind left hand side headlight |
T2q/ | Connector, 2-pin, black, behind the fuse box |
V7 | Radiator fan |
97 | Earth connection -1- in the air conditioner harness |