TRANSMISSION – Ford Ranger 2000 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

2.5L

2.5L, A/T Wiring Diagram, 4R44E for Ford Ranger 2000

List of elements for 2.5L, A/T Wiring Diagram, 4R44E for Ford Ranger 2000:

• (engine control sensor harness, near breakout to ground g123)
• (engine control sensor harness, near right rear of engine)
• (left side of radiator support) g108
• (near battery junction box) s121
• (right side of firewall) g123
• 4-wheel anti- lock brake system module (left front of eng compt)
• 4r44e automatic transmission (left side of transmission)
• 4wabs
• Battery junction box
• Battery junction box (left rear of engine compt)
• Bpp
• Brake pedal position switch (on brake pedal support)
• C111
• C214
• C216
• Ccs
• Central junction box (behind left side of dash)
• Coast clutch solenoid (css)
• Cse gnd
• Data link connector (dlc) (partial) (fastened to bottom of dash, near steering column)
• Digital transmission range sensor (left side of trans)
• Dlc
• Dlc (+)
• Dlc (-)
• Drl module, back-up lamps, pulse vacuum hublock solenoid switch
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls (ignition coil, radio noise capacitor)
• Engine controls system
• Engine coolant temperature (ect) sensor (top right front of eng, in water outlet tube)
• Epc
• Fuse 19 25a
• Fuse 6 15a
• Fuse 9 7.5a
• G108 (left side of upper radiator support)
• Generic electronic module (gem)/ central timer module (ctm) (center of dash)
• Hot at all times
• Hot in run
• Hot in start or run
• Instrument cluster
• Instrument cluster, cruise control
• Kapwr
• Malfunction indicator lamp (mil)
• Mil
• O/d off
• Passive anti-theft system module
• Pcm memory fuse 6 10a
• Pcm power diode
• Pcm power fuse 8 30a
• Pcm power relay
• Pcm/hego fuse 13 15a
• Power
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Pwr gnd
• R p
• Rabs
• Red
• S100 (engine control sensor harness, near breakout to tp sensor)
• S102 (eng cntrl sens harn, near breakout to intake air temp (iat) sensor)
• S103
• S104 (engine control sensor harness, near breakout to ground g123, right side of firewall)
• S105 (eng cntrl sens harn, near left side of trans)
• S106
• S109
• S118
• S139 (dash panel to headlamp junction harn)
• S228 (main harn, near bottom of steering column)
• Shift solenoid (ssa)
• Shift solenoid (ssb)
• Shift solenoid (ssc)
• Sig rtn
• Ss1
• Ss2
• Ss3
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top right side of engine, on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vref
• Vss
• Vss output

4WD Wiring Diagram for Ford Ranger 2000

List of elements for 4WD Wiring Diagram for Ford Ranger 2000:

• (behind dash, right side of steering column) relay box
• (main harn, near central junction box breakout) s235 red/pnk
• (rabs)
• (rwabs)
• 1.1k ohms
• 3.9k ohms
• 4 wheel drive fuse 3 20a
• 4-wheel anti- lock brake system module (left front of eng compt)
• 4wd hi ind
• 4wd ind ctrl
• 4wd lo ind
• 4wd mode sw
• 4wd mode switch
• 4wd output
• Battery junction box (left rear of engine compt)
• Battery saver relay
• Boo sw input
• Brake pedal position switch (on brake pedal support)
• C214
• C221
• C223
• C224
• Ccw relay
• Ccw rly ctrl
• Central junction box (behind left side of dash)
• Clutch
• Cw relay
• Cw rly ctrl
• Digital transmission range (dtr) sensor (left side of transmission)
• Drl module, backup lamps
• Elc rly ctrl
• Electric clutch relay
• Electric shift control module (behind center of dash)
• Engine controls, cruise control
• Fuse 26 10a
• Fuse 6 15a
• Fuse 9 7.5a
• G200 (behind left kick panel)
• Generic electronic module (gem) (behind center of dash)
• Hot at all times
• Hot in run
• Illumination
• Instrument cluster
• Interior lights (instrument illumination)
• Multifunction switch
• Nca
• Neutral sw in
• Of firewall) g123
• Ohms
• Powertrain control module
• Pulse vacuum hublock solenoid (on right front of vehicle)
• Pvh
• Rear axle sensor (top of readifferential)
• Red/pnk
• Rly ctrl
• S107
• S126
• S139 (dash panel to headlamp junction harn)
• S209
• S218
• S221 (main harn, near breakout to central junction box)
• S228 (main harness, near breakout to instrument cluster)
• S235 (main harn, near central junction box breakout)
• Shift motor
• Spd sens
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Touch drive
• Transfer case assembly (below vehicle, behind transmission)
• Transmission control switch
• Vss
• Vss output

3.0L

3.0L, A/T Wiring Diagram, 4R44E for Ford Ranger 2000

List of elements for 3.0L, A/T Wiring Diagram, 4R44E for Ford Ranger 2000:

• (eng cntrl sens harn, top left rear of eng)
• (engine control sensor harness, near breakout to ground g123)
• (engine control sensor harness, near breakout to ground g123, right side of firewall)
• (engine control sensor harness, near left rear of engine)
• (engine control sensor harness, near left side of engine)
• (engine control sensor harness, near left side of trans)
• (engine control sensor harness, near top left rear of engine)
• (left side of radiator support) g108
• (near battery junction box)
• (right side of firewall) g123
• 4-wheel anti- lock brake system module (left front of eng compt)
• 4r44e automatic transmission (left side of transmission)
• 4wabs
• Battery junction box
• Battery junction box (left rear of engine compt)
• Bpp
• Brake pedal position switch (on brake pedal support)
• C111
• C214
• C216
• Ccs
• Central junction box (behind left side of dash)
• Coast clutch solenoid (css)
• Cse gnd
• Data link connector (dlc) (partial) (fastened to bottom of dash, near steering column)
• Digital transmission range sensor (left side of trans)
• Dlc
• Dlc (+)
• Dlc (-)
• Drl module, back-up lamps, pulse vacuum hublock solenoid switch
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls (ho2s sensor, evr solenoid)
• Engine controls (ignition coil, radio noise capacitor)
• Engine controls system
• Engine coolant temperature (ect) sensor (top front of engine)
• Epc
• Fuse 19 25a
• Fuse 6 15a
• Fuse 9 7.5a
• G108 (left side of upper radiator support)
• Generic electronic module (gem)/ central timer module (ctm) (center of dash)
• Hot at all times
• Hot in run
• Hot in start or run
• Instrument cluster
• Instrument cluster, cruise control
• Kapwr
• Malfunction indicator lamp (mil)
• Mil
• O/d off
• Passive anti-theft system module
• Pcm memory fuse 6 10a
• Pcm power diode
• Pcm power fuse 8 30a
• Pcm power relay
• Pcm/hego fuse 13 15a
• Power
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Pwr gnd
• R p
• Rabs
• Red
• S100
• S1002
• S102
• S103
• S104
• S106
• S109
• S112
• S118
• S121
• S139 (dash panel to headlamp junction harn)
• S228 (main harn, near bottom of steering column)
• Shift solenoid (ssa)
• Shift solenoid (ssb)
• Shift solenoid (ssc)
• Sig rtn
• Ss1
• Ss2
• Ss3
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top left front of engine, on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vref
• Vss
• Vss output

4WD Wiring Diagram for Ford Ranger 2000

List of elements for 4WD Wiring Diagram for Ford Ranger 2000:

• (behind dash, right side of steering column) relay box
• (main harn, near central junction box breakout) s235 red/pnk
• (rabs)
• (rwabs)
• 1.1k ohms
• 3.9k ohms
• 4 wheel drive fuse 3 20a
• 4-wheel anti- lock brake system module (left front of eng compt)
• 4wd hi ind
• 4wd ind ctrl
• 4wd lo ind
• 4wd mode sw
• 4wd mode switch
• 4wd output
• Battery junction box (left rear of engine compt)
• Battery saver relay
• Boo sw input
• Brake pedal position switch (on brake pedal support)
• C214
• C221
• C223
• C224
• Ccw relay
• Ccw rly ctrl
• Central junction box (behind left side of dash)
• Clutch
• Cw relay
• Cw rly ctrl
• Digital transmission range (dtr) sensor (left side of transmission)
• Drl module, backup lamps
• Elc rly ctrl
• Electric clutch relay
• Electric shift control module (behind center of dash)
• Engine controls, cruise control
• Fuse 26 10a
• Fuse 6 15a
• Fuse 9 7.5a
• G200 (behind left kick panel)
• Generic electronic module (gem) (behind center of dash)
• Hot at all times
• Hot in run
• Illumination
• Instrument cluster
• Interior lights (instrument illumination)
• Multifunction switch
• Nca
• Neutral sw in
• Of firewall) g123
• Ohms
• Powertrain control module
• Pulse vacuum hublock solenoid (on right front of vehicle)
• Pvh
• Rear axle sensor (top of readifferential)
• Red/pnk
• Rly ctrl
• S107
• S126
• S139 (dash panel to headlamp junction harn)
• S209
• S218
• S221 (main harn, near breakout to central junction box)
• S228 (main harness, near breakout to instrument cluster)
• S235 (main harn, near central junction box breakout)
• Shift motor
• Spd sens
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Touch drive
• Transfer case assembly (below vehicle, behind transmission)
• Transmission control switch
• Vss
• Vss output

4.0L

4.0L, A/T Wiring Diagram, 5R55E for Ford Ranger 2000

List of elements for 4.0L, A/T Wiring Diagram, 5R55E for Ford Ranger 2000:

• (engine control sensor harness, near breakout to fuel inj 6)
• (engine control sensor harness, near breakout to fuel injector 5)
• (engine control sensor harness, near breakout to powertrain control module)
• (engine control sensor harness, near right side of engine compt)
• (engine control sensor harness, near top rear of engine)
• (fastened to bottom of dash, right of steering column)
• (left side of upper radiator support)
• (left side of upper radiator support) g108
• (near battery junction box)
• (near dtr sensor) output shaft speed sensor
• (right side of firewall) g123
• 4-wheel anti- lock brake system module (left front of eng compt)
• 4wabs
• 5r55e automatic transmission (left side of transmission)
• Battery junction box
• Battery junction box (left rear of engine compt)
• Bpp
• Brake pedal position switch (on brake pedal support)
• C111
• C214
• C216
• Case gnd
• Ccs
• Central junction box (behind left side of dash)
• Coast clutch solenoid (css)
• Connector (dlc) (partial)
• Data link
• Digital transmission range sensor (left side of trans)
• Dlc
• Dlc (+)
• Dlc (-)
• Drl module, backup lamps, pulse vacuum hublock solenoid switch
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls
• Engine controls (ignition coil, radio noise capacitor)
• Engine controls system
• Engine coolant temperature (ect) sensor (top front of engine)
• Epc
• Fuse 19 25a
• Fuse 6 15a
• Fuse 9 7.5a
• G108
• Generic electronic module (gem)/ central timer module (ctm) (center of dash)
• Hot at all times
• Hot in run
• Hot in start or run
• Instrument cluster
• Instrument cluster, cruise control
• Kapwr
• Malfunction indicator lamp (mil)
• Mil
• O/d off
• Oss
• Passive anti-theft system module
• Pcm memory fuse 6 10a
• Pcm power diode
• Pcm power fuse 8 30a
• Pcm power relay
• Pcm/hego fuse 13 15a
• Power
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Pwr gnd
• R p
• Rabs
• Red
• S100 (engine control sensor harness, near breakout to intake air temp (iat) sensor)
• S102 (eng ctrl harn, near breakout to g123)
• S103
• S104
• S106
• S109
• S112
• S113
• S118
• S121
• S139 (dash panel to headlamp junction harn)
• S228 (main harn, near bottom of steering column)
• Shift solenoid (ssa)
• Shift solenoid (ssb)
• Shift solenoid (ssc)
• Sig rtn
• Ss1
• Ss2
• Ss3
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top left front of engine, on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vref
• Vss
• Vss output

4WD Wiring Diagram for Ford Ranger 2000

List of elements for 4WD Wiring Diagram for Ford Ranger 2000:

• (behind dash, right side of steering column) relay box
• (main harn, near central junction box breakout) s235 red/pnk
• (rabs)
• (rwabs)
• 1.1k ohms
• 3.9k ohms
• 4 wheel drive fuse 3 20a
• 4-wheel anti- lock brake system module (left front of eng compt)
• 4wd hi ind
• 4wd ind ctrl
• 4wd lo ind
• 4wd mode sw
• 4wd mode switch
• 4wd output
• Battery junction box (left rear of engine compt)
• Battery saver relay
• Boo sw input
• Brake pedal position switch (on brake pedal support)
• C214
• C221
• C223
• C224
• Ccw relay
• Ccw rly ctrl
• Central junction box (behind left side of dash)
• Clutch
• Cw relay
• Cw rly ctrl
• Digital transmission range (dtr) sensor (left side of transmission)
• Drl module, backup lamps
• Elc rly ctrl
• Electric clutch relay
• Electric shift control module (behind center of dash)
• Engine controls, cruise control
• Fuse 26 10a
• Fuse 6 15a
• Fuse 9 7.5a
• G200 (behind left kick panel)
• Generic electronic module (gem) (behind center of dash)
• Hot at all times
• Hot in run
• Illumination
• Instrument cluster
• Interior lights (instrument illumination)
• Multifunction switch
• Nca
• Neutral sw in
• Of firewall) g123
• Ohms
• Powertrain control module
• Pulse vacuum hublock solenoid (on right front of vehicle)
• Pvh
• Rear axle sensor (top of readifferential)
• Red/pnk
• Rly ctrl
• S107
• S126
• S139 (dash panel to headlamp junction harn)
• S209
• S218
• S221 (main harn, near breakout to central junction box)
• S228 (main harness, near breakout to instrument cluster)
• S235 (main harn, near central junction box breakout)
• Shift motor
• Spd sens
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Touch drive
• Transfer case assembly (below vehicle, behind transmission)
• Transmission control switch
• Vss
• Vss output