TRANSMISSION – Ford RV Cutaway E350 Super Duty 2005 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

5.4L

5.4L, A/T Wiring Diagram, with 4R70E/4R75E (1 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 5.4L, A/T Wiring Diagram, with 4R70E/4R75E (1 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (at left side of transmission) digital transmission range (dtr) sensor
• (at rear of transmission) output shaft speed (oss) sensor
• (left side of transmission) turbine shaft speed (tss) sensor
• (window regulator relay switch harn, near breakout to steering column)
• 4r70e/4r75e transmission
• C175a
• C175b
• C175c
• C220a
• Can +
• Can -
• Data link connector (below left side of dash)
• Dtr tr1
• Dtr tr2
• Dtr tr3
• Dtr tr4
• Electronic pressure control solenoid
• Electronic throttle control (etc) motor (top right front of engine)
• Engine controls system
• Epc sol
• Etc return
• Etc wot cntrl
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Iat sensor
• Instrument cluster
• Maf sensor
• Mass air flow (maf) sensor (at center of engine compt)
• Oss sig
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Prog sig
• Red
• S136 (engine control sensor harn, near breakout to left rear of engine)
• S172
• S198 (near breakout to center rear of trans)
• S228 (main harn, near breakout to left side of dash)
• S269
• Shift sol a
• Shift sol b
• Shift solenoids
• Signal return
• Tcc sol
• Tft sensor sig
• Throttle position sensor (top of engine, near air intake)
• Torque converter clutch solenoid
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return
• Tr-p ground
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission fluid temperature sensor
• Tss sensor

5.4L, A/T Wiring Diagram, with 4R70E/4R75E (2 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 5.4L, A/T Wiring Diagram, with 4R70E/4R75E (2 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (ends in harness)
• (engine control harn, near breakout to left rear of engine compt) s135
• (engine control sensor harn, near breakout to left rear of engine compt) s142
• (transmission harn, near breakout to center rear of trans) s100
• Accelerator pedal position (app) sensor (behind left side of dash, above accelerator pedal)
• App sensor 2 pwr
• App sensor 2 rtn
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (above brake pedal)
• C175a
• Central junction box (behind left side of dash)
• Cluster pwr
• Engine controls system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G100 (left side of engine compt)
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition (st/run)
• Nca
• O/d off
• Od cancel sw
• Overdrive cancel switch
• Overhead console (if equipped)
• Pcm ap sensor
• Pcm power diode
• Pcm power relay
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Red
• S1021
• S1033
• S1065 (except stripped chassis)
• S127 (stripped chassis)
• S172
• S174 (engine control harn, in breakout to c110)
• S216
• Tan
• Tcil ctrl
• Vss +

5.4L, A/T Wiring Diagram, with Torqshift (1 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 5.4L, A/T Wiring Diagram, with Torqshift (1 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (at rear of transmission) output shaft speed sensor
• (transmission harn, in breakout to right side of transmission)
• (transmission harn, near breakout to center rear of transmission)
• (window regulator relay switch harn, near breakout to steering column)
• C175a
• C175b
• C175c
• C220a
• Can +
• Can -
• Cyl head temp
• Cylinder head temperature sensor (top front
• Data link connector (below left side of dash)
• Electronic throttle control motor (top right front of engine)
• Engine controls system
• Etc return
• Etc wot cntrl
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Iat sensor
• Instrument cluster
• Intermediate shaft speed sensor
• Iss sensor
• Maf sensor
• Mass air flow (maf) sensor (at center of engine compt)
• Of left cyl head)
• Oss sensor
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Pressure control (pc-a) solenoid
• Prog sig
• Red
• Ref voltage
• S1037 (transmission harn, near breakout to top center transmission)
• S123
• S136 (engine control sensor harn, near breakout to left rear of engine)
• S172
• S198
• S228 (main harn, near breakout to left side of dash)
• S269
• Shift sol a
• Shift sol b
• Shift sol c
• Shift sol d
• Shift sol e
• Shift solenoid pressure control a (sspc-a)
• Shift solenoid pressure control b (sspc-b)
• Shift solenoid pressure control c (sspc-c)
• Shift solenoid pressure control d (sspc-d)
• Shift solenoid pressure control e (sspc-e)
• Signal return
• Speed sensor assembly (left side of transmission)
• Tcc sol
• Tft sensor
• Throttle position sensor (top of engine, near air intake)
• Torqshift transmission
• Torque converter clutch solenoid
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return
• Transmission fluid temperature sensor
• Transmission range sensor assembly (tr-p)
• Trs sensor
• Tss sensor
• Turbine shaft speed sensor

5.4L, A/T Wiring Diagram, with Torqshift (2 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 5.4L, A/T Wiring Diagram, with Torqshift (2 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (ends in harness)
• (engine control harn, near breakout to left rear of engine compt) s135
• (engine control sensor harn, near breakout to left rear of engine compt) s142
• Accelerator pedal position (app) sensor (behind left side of dash, above accelerator pedal)
• App sensor 2 pwr
• App sensor 2 rtn
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (above brake pedal)
• C175a
• Central junction box (behind left side of dash)
• Cluster pwr
• Engine controls system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G100 (left side of engine compt)
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition (st/run)
• Nca
• O/d off
• Od cancel sw
• Overhead console (if equipped)
• Pcm ap sensor
• Pcm power diode
• Pcm power relay
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Red
• S1021
• S1033
• S1065 (except stripped chassis)
• S127 (stripped chassis)
• S172
• S174 (engine control harn, in breakout to c110)
• S216
• Tan
• Tcil ctrl
• Tow/haul switch
• Vss +

6.0L DIESEL

6.0L Diesel, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 6.0L Diesel, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (ends in harness)
• (engine control sensor harn, near breakout to left rear of engine compt) s1059
• (engine control sensor harn, near breakout to right side of engine compt)
• (engine ctrl sensor harn, near breakout for c131) s135
• (left side of engine compt) g100
• (right rear of engine compt) g107
• (window regulator relay switch harn, near breakout to steering column)
• Accel pdl sens
• Accelerator pedal position sensor (behind left side of dash, above accelerator pedal)
• Aps2
• Aps3
• Battery junction box (right front of engine compt)
• Brake pedal position switch (on bracket, above brake pedal)
• C176a
• C176c
• C220a
• Central junction box (behind left side of dash)
• Coolant temp
• Data link connector (below left side of dash)
• Dlc can h
• Dlc can l
• Engine controls system
• Engine coolant temperature sensor (upper
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G107 (right rear of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Iat sensor
• Ignition
• Instrument cluster
• Left front of engine)
• Maf sensor
• Mass air- flow sensor (left front of engine compt)
• Overhead console (if equipped)
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left rear of engine compt, near brake master cylinder)
• Prog sig
• Red
• Ref voltage
• S1033
• S1065
• S1068 (engine control sensor harn, near breakout to c127)
• S136
• S138 (engine control sensor harn, near breakout for c131)
• S142 red
• S172
• S228 (main harn, near breakout to left side of dash)
• S269
• Sensor harn, in breakout to c219)
• Signal return
• Stoplamp sw
• Tan
• Tow/haul sw
• Vbatt
• Vss+

6.0L Diesel, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 6.0L Diesel, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (in trans ctrl selector neutral switch harn, in breakout to right side of transmission)
• (in trans ctrl selector neutral switch harn, near breakout to center rear of transmission)
• (in trans ctrl selector neutral switch harn, near breakout to top center of transmission)
• Auxiliary relay box 1 (right rear of engine compt)
• C176b
• Central junction box (behind left side of dash)
• Fuse 10a
• Hot in run or start
• Intermediate shaft speed sensor
• Iss sig
• Nca
• Oss sig
• Output shaft speed sensor (at rear of transmission)
• Pc sol pwr
• Pc-a sol
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Pressure control (pc-a) solenoid
• Ref volt
• Rev lmp ctrl
• Reversing lamp relay
• S1037
• S123
• S198
• S216
• Shift solenoid pressure control a (sspc-a)
• Shift solenoid pressure control b (sspc-b)
• Shift solenoid pressure control c (sspc-c)
• Shift solenoid pressure control d (sspc-d)
• Shift solenoid pressure control e (sspc-e)
• Sig trn
• Speed sensor assembly (left side of transmission)
• Sspc-a crl
• Sspc-b ctrl
• Sspc-c crl
• Sspc-d ctrl
• Sspc-e ctrl
• Tcc sol ctrl
• Tcil ctrl
• Tft sens sig
• Torqshift transmission (right side of transmission)
• Torque converter clutch solenoid
• Tow/haul switch (or overdrive cancel switch)
• Tr-p gnd
• Tr-p sig
• Transmission fluid temperature sensor
• Transmission range sensor assembly (tr-p)
• Tss sig
• Turbine shaft speed sensor

6.8L

6.8L, A/T Wiring Diagram, with Torqshift (1 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 6.8L, A/T Wiring Diagram, with Torqshift (1 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (at rear of transmission) output shaft speed sensor
• (transmission harn, in breakout to right side of transmission)
• (transmission harn, near breakout to center rear of transmission)
• (window regulator relay switch harn, near breakout to steering column)
• C175a
• C175b
• C175c
• C220a
• Can +
• Can -
• Cyl head temp
• Cylinder head temperature sensor (top front
• Data link connector (below left side of dash)
• Electronic throttle control motor (top right front of engine)
• Engine controls system
• Etc return
• Etc wot cntrl
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Iat sensor
• Instrument cluster
• Intermediate shaft speed sensor
• Iss sensor
• Maf sensor
• Mass air flow (maf) sensor (at center of engine compt)
• Of left cyl head)
• Oss sensor
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Pressure control (pc-a) solenoid
• Prog sig
• Red
• Ref voltage
• S1037 (transmission harn, near breakout to top center transmission)
• S123
• S136 (engine control sensor harn, near breakout to left rear of engine)
• S172
• S198
• S228 (main harn, near breakout to left side of dash)
• S269
• Shift sol a
• Shift sol b
• Shift sol c
• Shift sol d
• Shift sol e
• Shift solenoid pressure control a (sspc-a)
• Shift solenoid pressure control b (sspc-b)
• Shift solenoid pressure control c (sspc-c)
• Shift solenoid pressure control d (sspc-d)
• Shift solenoid pressure control e (sspc-e)
• Signal return
• Speed sensor assembly (left side of transmission)
• Tcc sol
• Tft sensor
• Throttle position sensor (top of engine, near air intake)
• Torqshift transmission
• Torque converter clutch solenoid
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return
• Transmission fluid temperature sensor
• Transmission range sensor assembly (tr-p)
• Trs sensor
• Tss sensor
• Turbine shaft speed sensor

6.8L, A/T Wiring Diagram, with Torqshift (2 of 2) for Ford RV Cutaway E350 Super Duty 2005

List of elements for 6.8L, A/T Wiring Diagram, with Torqshift (2 of 2) for Ford RV Cutaway E350 Super Duty 2005:

• (ends in harness)
• (engine control harn, near breakout to left rear of engine compt) s135
• (engine control sensor harn, near breakout to left rear of engine compt) s142
• Accelerator pedal position (app) sensor (behind left side of dash, above accelerator pedal)
• App sensor 2 pwr
• App sensor 2 rtn
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (above brake pedal)
• C175a
• Central junction box (behind left side of dash)
• Cluster pwr
• Engine controls system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G100 (left side of engine compt)
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition (st/run)
• Nca
• O/d off
• Od cancel sw
• Overhead console (if equipped)
• Pcm ap sensor
• Pcm power diode
• Pcm power relay
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Red
• S1021
• S1033
• S1065 (except stripped chassis)
• S127 (stripped chassis)
• S172
• S174 (engine control harn, in breakout to c110)
• S216
• Tan
• Tcil ctrl
• Tow/haul switch
• Vss +