ENGINE PERFORMANCE – Hyundai Santa Fe GLS 2006 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.7L

2.7L, Engine Performance Wiring Diagram (1 of 4) for Hyundai Santa Fe GLS 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (1 of 4) for Hyundai Santa Fe GLS 2006:

• (ecu)
• (pins 11-16)
• (pins 2-6)
• (pins 2-7)
• (pins 27-28)
• (pins 39-41)
• (pins 43-45)
• (pins 49-52)
• (pins 8-12)
• 02s heating
• Air temp gnd
• Air temp in
• Air temperature sensor (on right front of intake manifold)
• Battery
• C23-m
• C23-p
• C23-v
• Ckp sens gnd
• Ckp sig
• Close
• Diode z07 (behind left rear quarter- panel)
• E/r-d
• E/r-f
• E/r-g
• Ect sens gnd
• Ect sens in
• Ecu (b+) fuse 15a
• Eng ctrl rly
• Engine compartment junction block (on left side of engine compt)
• Engine control module (ecm) (below center of dash)
• Engine control relay
• Engine coolant temperature sensor & sender (on rear of left cylinder head)
• Fuel cut sensor
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pump check connector
• Fuel pump relay
• Fuel sender & fuel pump motor (inside fuel tank, beneath left rear seat)
• Fuse 10a
• Fusible link 40a
• G02 (under center console, near srs control module)
• G11 (behind left rear quarterpanel trim, near speaker)
• Gnd
• Hot at all times
• Hot in on or start
• I/p-l
• I/p-m
• Injection sig
• Injectors (at top of engine)
• Instrument cluster system
• Joint connector m04 (behind lower left end of dash)
• K-line
• Ks1 sig in
• Ks2 sig in
• Maf sens gnd
• Maf sig
• Memory pwr
• Nca
• O2s heating
• On/start in
• Open
• Passenger compartment junction block (behind lower left end of dash)
• Pcs vlv ctrl
• Pnk
• Ps sw in
• Purge control solenoid valve (on right side of intake manifold)
• Red
• Sens
• Sens gnd
• To ecu 3 fuse (diagram 2 of 4)
• Tp sens pwr
• Tp sens sig

2.7L, Engine Performance Wiring Diagram (2 of 4) for Hyundai Santa Fe GLS 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (2 of 4) for Hyundai Santa Fe GLS 2006:

• (behind lower left end of dash) data link connector
• (behind lower left end of dash) joint connector mo5
• (behind lower left end of dash) multipurpose check connector
• E/r-g
• E/r-h
• Ecu 1 fuse 20a
• Ecu 2 fuse 20a
• Ecu 3 fuse 10a
• Engine compartment junction block (on left side of engine compt)
• From engine a control relay (diagram 1 of 4)
• Immobilizer control module (canada) (behind center of dash)
• Knock sensor 1 (on top right rear of engine, below intake manifold)
• Knock sensor 2 (on top right rear of engine, below intake manifold)
• Nca
• Oxygen sensor (b1/s1) (on right exhaust manifold)
• Oxygen sensor (b1/s2) (on lower right side of engine)
• Oxygen sensor (b2/s1) (on left exhaust manifold)
• Oxygen sensor (b2/s2) (on lower left side of engine)
• Pnk
• Power steering switch (on top of power steering pump, on front of engine)
• Red

2.7L, Engine Performance Wiring Diagram (3 of 4) for Hyundai Santa Fe GLS 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (3 of 4) for Hyundai Santa Fe GLS 2006:

• (not used)
• (on right side of engine compt) cruise control module
• (on right side of transaxle) vehicle speed sensor
• Camshaft position sensor (on rear of left cyl head)
• Canister close valve (beneath center of vehicle, above drive shaft)
• Crankshaft position sensor (on left rear of engine)
• E/r-d
• Engine compartment junction e/r-g block (on left side of engine compt)
• Etacm
• Fuse 10a
• G02 (under center console, near srs control module)
• Hot in on or start
• I/p-b
• I/p-l
• I/p-m
• Idle speed control actuator (on left side of throttle body, on bracket)
• Instrument cluster system
• Joint connector c33 (at left front of engine compt)
• Joint connector m06 (behind lower left end of dash)
• M13-3
• Mass air flow sensor (on left rear of engine compartment, in air intake duct)
• Nca
• Passenger compartment junction block (behind lower left end of dash)
• Pnk
• Red
• Throttle position sensor (on left side of throttle body)

2.7L, Engine Performance Wiring Diagram (4 of 4) for Hyundai Santa Fe GLS 2006

List of elements for 2.7L, Engine Performance Wiring Diagram (4 of 4) for Hyundai Santa Fe GLS 2006:

• (at left rear of engine compt, below brake master cylinder) abs control module
• (below center of dash) tcm
• A/c on ip
• A/c rly ctrl
• A/c sig in
• A/c sig ip
• Air conditioning system
• C23-f
• C23-z
• C24-1
• C24-c
• Can
• Ccv
• Chck eng ind
• Cmp sens gnd
• Cmp sig
• Cond fan rly
• Cooling fans system
• Engine control module (ecm) (below center of dash)
• Ftp sens sig
• Ftps
• Fuel pmp rly
• Fuel sender
• Fuel tank pressure sensor (above left rear of fuel tank, beneath vehicle)
• G02 (under center console, near srs control module)
• Gnd
• Ign coil ctrl
• Ignition coil (on left rear of engine)
• Instrument cluster
• Instrument cluster system
• M15-1
• M15-2
• Micom
• Mil (check engine ind)
• Nca
• Rad fan rly
• Red
• Right front wheel sensor (w/o abs) (on right front wheel hub assembly)
• Spark plugs
• Tachometer
• Vss
• Whl spd in

3.5L

3.5L, Engine Performance Wiring Diagram (1 of 5) for Hyundai Santa Fe GLS 2006

List of elements for 3.5L, Engine Performance Wiring Diagram (1 of 5) for Hyundai Santa Fe GLS 2006:

• inj 2
• (at right rear of engine) ets motor
• (ecu)
• A/c rly ctrl
• A/c sig in
• Afs sig
• Air conditioning system
• Ats sig
• Battery
• C121-a
• C121-b
• Ccv ctrl
• Ckp sens sig
• Close
• Cmp sens sig
• Condenser
• Cooling fans system
• Cooling sig in
• Cruise control system
• Cruise ctrl
• Diode z07 (behind left rear quarter- panel)
• E/r-d
• E/r-f
• E/r-g
• E/r-h
• Ect sens
• Ecu (b+) fuse 15a
• Ecu 3 fuse 10a
• Egr sol ctrl
• Egr solenoid (at right side of engine)
• Eng ctrl rly
• Eng lamp ctrl
• Engine compartment junction block (on left side of engine compt)
• Engine control relay
• Etc motor
• Fan rly (hi)
• Fan rly (lo)
• Fuel cut sensor
• Fuel pmp ctrl
• Fuel pump check connector
• Fuel pump relay
• Fuel sender
• Fuel sender & fuel pump motor (inside fuel tank, beneath left rear seat)
• Fusible link 40a
• G103 (under center console)
• G11 (behind left rear quarterpanel trim)
• Gnd
• Hot at all times
• Htr
• Ign coil 1,4
• Ign coil 2,5
• Ign coil 3,6
• Ign det sig
• Ign timing adj
• Ignition coil 1 (at top left of engine)
• Ignition coil 2 (at top left of engine)
• Ignition coil 3 (at top left of engine)
• Inj 1
• Inj 3
• Inj 4
• Inj 5
• Inj 6
• Inj sig
• Injectors (at top of engine)
• Instrument cluster system
• Joint connector m04 (behind lower left end of dash)
• Memory power
• Memory pwr
• Motor
• Nca
• Open
• P/n sig
• Pnk
• Power steering switch (at right front of engine)
• Powertrain control module (pcm) (below center of dash)
• Ps sw in
• Pur sol ctrl
• Purge control solenoid valve (at right rear of engine)
• Red
• Rly ctrl
• Sens gnd
• Sens pwr
• Set ctrl
• Sig in
• Starting/ charging system
• Sw in
• To ecu fuse 2 (diagram 2 of 5)
• To spark plugs
• Valve ctrl
• Variable intake sensor (at right front of engine)
• W/ immobilizer
• W/o immobilizer

3.5L, Engine Performance Wiring Diagram (2 of 5) for Hyundai Santa Fe GLS 2006

List of elements for 3.5L, Engine Performance Wiring Diagram (2 of 5) for Hyundai Santa Fe GLS 2006:

• (at right rear of engine) limp home valve
• (diagram 1 of 5)
• Atm fuse 20a
• Canister close valve (beneath center of vehicle, above drive shaft)
• Close
• E/r-f
• E/r-g
• E/r-h
• Ecu 1 fuse 20a
• Ecu 2 fuse 20a
• Engine compartment junction block (on left side of engine compt)
• From engine control relay a
• From injectors b
• G103 (under center console)
• Ground
• Hot at all times
• Ignition failure sensor (at rear of engine)
• Joint connector c133 (at left front of engine compt)
• Joint connector c168 (under center of dash)
• Map sensor (on right side of engine)
• Nca
• Open
• Oxygen sensor (b1/s1) (at right rear of engine)
• Oxygen sensor (b1/s2) (at right rear of engine)
• Oxygen sensor (b2/s1) (at left rear of engine)
• Oxygen sensor (b2/s2) (at left rear of engine)
• Pnk
• Power
• Red
• Variable intake motor (at right front of engine)

3.5L, Engine Performance Wiring Diagram (3 of 5) for Hyundai Santa Fe GLS 2006

List of elements for 3.5L, Engine Performance Wiring Diagram (3 of 5) for Hyundai Santa Fe GLS 2006:

• (above brake pedal, on bracket) stop lamp switch
• (at rear of engine) engine coolant temperature sensor & sender
• (under center of dash) fail safety relay
• Cancel
• Clock spring
• Cruise on/off
• Cruise remote control switch
• Exterior lights system
• Fuse 10a
• Fuse 15a
• G07 (behind left front kick panel)
• Hot at all times
• Hot in on
• I/p-j
• I/p-l
• I/p-m
• Instrument cluster system
• Joint connector c134 (under center console)
• Joint connector m06 (behind lower left end of dash)
• Left
• M20-4 (advanced air bag) (depowered air bag) m20-3
• Multi- function switch
• Nca
• Passenger compartment junction block (behind lower left end of dash)
• Pnk
• Red
• Resume/ accel
• Right
• Sender
• Sensor
• Set/ coast
• Steering wheel

3.5L, Engine Performance Wiring Diagram (4 of 5) for Hyundai Santa Fe GLS 2006

List of elements for 3.5L, Engine Performance Wiring Diagram (4 of 5) for Hyundai Santa Fe GLS 2006:

• (behind lower left end of dash) data link connector
• (behind lower left end of dash) multipurpose check connector
• (on right side of transaxle) vehicle speed sensor
• Accel position sensor (at rear of engine)
• Camshaft position sensor (at left front of engine)
• Crankshaft position sensor (at left front of engine)
• Cruise control module (on right side of engine compt)
• E/r-d
• Engine compartment junction block (on left side of e/r-g engine compt)
• Etacm
• Fuel tank pressure sensor (above left rear of fuel tank, beneath vehicle)
• Fuse 10a
• G103 (under center console)
• Hot in on or start
• I/p-b
• I/p-l
• I/p-m
• Idle switch
• Immobilizer control module (canada) (behind center of dash)
• Instrument cluster system
• Joint connector c133 (at left front of engine compt)
• Joint connector c135 (under center console)
• Joint connector m05 (behind lower left end of dash)
• Joint connector mo6 (behind lower left end of dash)
• Knock sensor (at left rear of engine)
• M13-3
• Maf sensor
• Nca
• Passenger compartment junction block (behind lower left end of dash)
• Pnk
• Red
• Red red
• Throttle position sensor (on left side of throttle body)

3.5L, Engine Performance Wiring Diagram (5 of 5) for Hyundai Santa Fe GLS 2006

List of elements for 3.5L, Engine Performance Wiring Diagram (5 of 5) for Hyundai Santa Fe GLS 2006:

• "5"
• (behind left rear quarterpanel trim, near speaker)
• (behind left front kick panel) g07
• (on top rear of transaxle) transaxle range switch
• 2nd
• A/c sw on
• A/t pulse generator "a" (on left front of transaxle)
• A/t pulse generator "b" (on top front of transaxle)
• Air conditioning system
• Anti-lock brakes & transmissions systems
• Atm control relay (under center console)
• Atm solenoid valve (at top of transaxle)
• Battery
• C121-c
• C121-d
• Can high
• Can low
• D input
• Dcc
• Down shift
• Ecm flash
• Ftps sig
• Fuel sens
• Fuel temperature sensor (inside fuel tank, beneath left rear seat)
• G104 (under center console)
• G11
• Gnd
• Idle sw
• Instrument cluster
• Joint connector c135 (under center console)
• K-line
• Ks sig
• M15-2
• M15-3
• Map sens sig
• Micom
• Mil ind
• N input
• Normal
• O/t
• Oil temp sensor
• On/start in
• P input
• Pnk
• Powertrain control module (pcm) (below center of dash)
• Pulse gen a
• Pulse gen b
• R input
• Red
• Select
• Select sw
• Select switch
• Sens gnd
• Sens pwr
• Sens pwr 5v
• Sens pwr(5v)
• Sens sig
• Sig
• Sport mode switch
• Starting/ charging system
• Stop lmp sw
• Up shift
• Vss in