GROUND DISTRIBUTION – Ford Econoline E150 2004 – SYSTEM WIRING DIAGRAMS

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 3) for Ford Econoline E150 2004

List of elements for Ground Distribution Wiring Diagram (1 of 3) for Ford Econoline E150 2004:

• (4.6l & 6.8l) heated positive crankcase ventilation (pcv) element
• (5.4l cng) fuel rail cutoff valve
• (5.4l cng) natural gas vehicle (ngv) module
• (at right rear of engine compt) auxiliary relay box 1
• (at right rear of engine compt) battery junction box (bjb)
• (at right rear of engine compt) g107
• (cutaway) left rear lamp assembly
• (cutaway) right rear lamp assembly
• (diesel) a/c clutch field coil
• (diesel) dual pressure switch
• (diesel) fuel injector control module
• (diesel) powertrain control module (pcm)
• (diesel: at right rear of engine compt) (except diesel: at left side of engine compt) battery junction box (bjb)
• (except diesel) fuel pump relay
• (except diesel) powertrain control module (pcm)
• (except diesel: at left side of engine compt) (diesel: at left rear of engine compt) g100
• (near breakout to rear left of engine compt) (5.4l cng) s1069
• (not used)
• 5.4l cng
• 6.8l
• A/c clutch field coil
• A/c compressor clutch diode
• Base w/ trailer
• Battery
• Battery charge
• Battery ii (w/ auxiliary battery)
• Blower motor relay
• Blower motor resistor
• Brake fluid level switch
• C1388c
• C176a
• C310a
• Crankshaft position sensor shield
• Data link connector (dlc)
• Diesel
• Except cutaway with 138" wheel base
• Except diesel
• Except van with 138" wheel base w/ trailer
• Fuel heater
• Fuel injector 1 shield
• Fuel injector 2 shield
• Fuel injector 3 shield
• Fuel injector 4 shield
• Fuel injector 5 shield
• Fuel injector 6 shield
• Fuel injector 7 shield
• Fuel injector 8 shield
• Fuel pump
• G108 (diesel) (on left side of engine)
• G110 (on right frame rail)
• G111 (at right side of engine compt)
• G117 (at right side of engine compt)
• G118 (at lower right side of engine compt)
• G119 (at right front of engine)
• G120 (at right rear of engine)
• G201 (under driver seat)
• Harness, in breakout to left side of engine compt) s172
• In breakout to c134)
• Left turn trailer tow relay
• Mass air flow (maf) sensor
• Natural gas vehicle (ngv) module
• Natural gas vehicle (ngv) timer jumper
• Nca
• Parking lamp
• Pcm power relay
• Powertrain control module
• Powertrain control module (pcm) shield
• Restraints control module
• Reversing lamp
• Right turn trailer tow relay
• S1035 (in engine control sensor wiring harness, near breakout to starter relay)
• S1051 (5.4l cng) (near breakout to front of engine)
• S1061 (in engine control sensor & fuel charge wiring harness, near breakout to left rear of engine)
• S1066 (in fuel pump feed jumper wiring harness, near breakout for c1386)
• S140 (in engine control sensor harness, near breakout to left rear of engine compt)
• S170 (in engine control sensor harness, in breakout to c134)
• S307 (in fuel tank sender wiring harness, near breakout to fuel tank)
• S432
• Tow class ii or van w/ 138" wheel base w/o trailer tow
• Trailer tow connector (4-pin)
• Trailer tow relay
• Van with 138" wheel
• W/ trailer tow class i
• W/ trailer tow class ii
• Windshield washer pump motor

Ground Distribution Wiring Diagram (2 of 3) for Ford Econoline E150 2004

List of elements for Ground Distribution Wiring Diagram (2 of 3) for Ford Econoline E150 2004:

• (at left rear of engine compt) auxiliary relay box 1
• (at left side of engine compartment) battery junction box (bjb)
• (at right side of dash) g200
• (cutaway) left rear lamp assembly
• (cutaway) right rear lamp assembly
• (late production) horn
• (not used)
• (w/ five fuel tanks) extended range fuel tank valve 1
• (w/ five fuel tanks) extended range fuel tank valve 2
• 5.4l cng
• Abs control module
• Air bag sliding contact
• Alternative fuel control module (afcm) diode
• Battery charge trailer tow relay
• Blower motor relay
• Brake fluid level switch
• Brake shift interlock
• C176a
• C2188a
• C218b
• C220a
• C220b
• C294b
• C294c
• C294e
• C3077a
• Diesel
• Except 5.4l cng
• Except diesel
• Except van w/ 138" wheel base & trailer tow class ii
• Front aft-axle fuel tank valve
• Front cigar lighter
• Front function selector switch assembly
• Fuel pump driver module
• Fuel pump shield
• G102 (at left front of vehicle)
• G103 (at right front of vehicle)
• G105 (at left rear of engine compt)
• G121 (at left side of engine compt)
• G202 (at left side of dash)
• G302 (cutaway: at rear underbody of vehicle) (except cutaway: at rear of vehicle, near fuel pump module)
• G401 (at left side of vehicle rear end)
• Instrument cluster
• Left front park/turn lamp
• Left headlamp
• Left turn trailer tow relay
• Left video display
• Main light switch
• Midship fuel tank valve
• Nca
• Parking brake switch
• Parking lamp trailer tow relay
• Pony tank valve
• Power point
• Powertrain control module
• Radio
• Rear aft-axle fuel tank valve
• Rear seat entertainment (rse) module
• Reversing lamp trailer tow relay
• Right front park/turn lamp
• Right headlamp
• Right turn trailer tow relay
• Right video display
• S1005 (in engine control sensor wiring harness, near breakout to c146)
• S1029 (in engine control sensor wiring harness, near breakout to g105)
• S202 (near breakout to center of dash)
• S204 (in main wiring harness, near breakout to center of dash)
• S207 (in main wiring harness, near breakout to center of dash)
• S214 (in main wiring harness, near breakout to g203)
• S297 (near breakout to c311)
• S312 (near breakout to fuel tank)
• S317 (in fuel tank sender wiring harness, near breakout to fuel tank)
• S320 (in breakout to rear underside of vehicle)
• S322 (w/ 5 fuel tanks) (near breakout to c3149)
• S323 (near center of console)
• To c421)
• To fuel tank)
• Trailer tow connector (7-pin)
• Trailer tow connector, 4-pin
• Van w/ 138" wheel base & trailer tow class ii
• Video cassette player
• W/ 138" wheel base
• W/ 158" wheel base or higher
• W/ aero headlamps
• W/ rse
• W/ sealed beam headlamps
• W/ trailer tow class i
• W/ trailer tow class ii
• W/o 138" wheel base
• Wiper control module (wcm)

Ground Distribution Wiring Diagram (3 of 3) for Ford Econoline E150 2004

List of elements for Ground Distribution Wiring Diagram (3 of 3) for Ford Econoline E150 2004:

• (at right side of vehicle rear end) s406
• (diesel) auxiliary powertrain control module (apcm)
• (except cutaway) power point
• (in taillight wiring harness, near breakout to c411) s402
• (in window regulator relay switch harness, near breakout to left side of dash) s250
• (near breakout to c3052) s233
• (w/ daytime running lamps) daytime running lamps (drl) module
• (w/ overhead console) overhead console
• (w/ power locks) master window/door lock/unlock switch
• (w/ power mirrors) exterior rear view mirror switch
• (w/ power seats) driver side front seat adjust switch
• (w/ remote keyless entry) rear doors door lock switch
• (w/ remote keyless entry) vehicle security module (vsm)
• C203a
• C203b
• C3077a
• Cargo lamp
• Cutaway
• Data link connector (dlc)
• Diesel
• Driver safety belt retractor pretensioner
• Electronic flasher module
• Ends in harness
• Except cutaway
• Except diesel
• Front interior/ map lamps assembly
• Front passenger window/door lock switch
• G204 (at left kick panel)
• G400 (at left side of vehicle rear end)
• High mounted stoplamp
• Interior lamp
• Left front door ajar switch
• Left rear park/stop/ turn lamp
• Left reversing lamp
• Left video display
• License plate lamp
• Nca
• Power point console 1
• Power point console 2
• Rear a/c blower speed relay 1
• Rear a/c blower speed relay 2
• Rear doors door ajar switch
• Rear interior lamp
• Rear seat entertainment (rse) module
• Resistor
• Right front door ajar switch
• Right rear park/stop/ turn lamp
• Right reversing lamp
• Right side door ajar switch
• Right sliding door ajar switch
• Right video display
• S117 (near breakout to left side of engine compt)
• S223 (near breakout to steering column)
• S300 (near breakout to c311)
• S414 (w/ remote keyless entry)
• S500 (near breakout in top of driver door)
• S600 (near breakout to center of passenger door)
• S915 (near breakout to c925)
• Speed control servo
• Temperature blend door actuator
• Trailer electronic brake control connector
• W/ auxiliary a/c
• W/ conversion
• W/ full headliner
• W/ hinged side door
• W/ rear seat entertainment
• W/ remote keyless entry
• W/ rse
• W/ sliding cargo door
• W/o full headliner
• W/o remote keyless entry