ENGINE PERFORMANCE – Saturn Vue 2005 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.2L VIN D

2.2L VIN D, Engine Performance Wiring Diagram (1 of 3) for Saturn Vue 2005

List of elements for 2.2L VIN D, Engine Performance Wiring Diagram (1 of 3) for Saturn Vue 2005:

• (in a/c high side press line) a/c refrigerant pressure sensor
• (left rear of engine) g105
• (m/t)
• A/c press +5v
• A/c press lo
• A/c press sig
• A/c relay
• A/t
• A12
• Accelerator pedal position sensor (on accel pedal linkage arm)
• Air conditioning system cooling fans system
• App 1 5v ref
• App 1 lo
• App 1 sig
• App 2 5v ref
• App 2 lo
• App 2 sig
• B12
• Back-up fuse 10a
• Battery
• Body control module (below front of center floor console)
• Brake fuse 15a
• Can high
• Can low
• Class 2 serial data
• Computer data lines system
• Cool fan rly
• Cooling fans system
• Cruise control system
• Cruise fuse 2a
• Cruise/ brake switch (on brake pedal bracket)
• Cruz on/off
• Cruz res/acl
• Cruz set/cst
• Crz brake sw
• Data link connector (lower left side of dash)
• Ecm/tcm fuse 10a
• Electronic brake control module (near left front shock tower)
• Engine control module (on intake manifold, under ignition coil housing)
• Engine oil pressure switch (on engine block, near oil filter)
• Exterior lights system
• Fuel relay
• G107 (at rear of engine)
• Hot at all times
• Hot in run or start
• Ign 1 fuse 10 a
• Ignition
• Instrument panel cluster (ipc)
• Instrument panel fuse block (behind center of dash)
• Kw2000
• Logic
• M/t w/ abs
• M/t w/o abs
• Main relay
• Malfunction indicator lamp (mil)
• Mil control
• Oil press
• Output speed sensor
• Pnk
• Powertrain fuse 10a
• Rly 2 ctrl
• S304 (in body harness, near cross car breakout)
• Stop lamp switch (on brake pedal bracket)
• Stop sw
• Tan
• Transmission control module (left side of engine compt)
• Underhood fuse block (left side of engine compt)
• Vehicle speed sensor (at rear of transmission)
• Vss

2.2L VIN D, Engine Performance Wiring Diagram (2 of 3) for Saturn Vue 2005

List of elements for 2.2L VIN D, Engine Performance Wiring Diagram (2 of 3) for Saturn Vue 2005:

• 1-4 coil ctrl
• 2-3 coil ctrl
• A pnk
• A10
• Bare
• C2 c2
• Cam sig out
• Csi pickup
• F11
• For diagnostics
• Fuel pump fuse 10a
• Fuel pump relay
• Fuel tank pressure sensor (top of primary fuel pump & sender assembly)
• G101
• G105 (at left rear of engine)
• G403
• Ground
• Hot at all times
• Ic 1-4
• Ic 2-3
• Ign volt
• Ignition
• Ignition control module (top of engine, center of valve cover, above cylinder 4)
• Jumper harness)
• Knock sensor (on left side of engine block, near starter)
• Manifold absolute pressure sensor (on intake manifold)
• Nca
• Pnk
• Primary fuel pump & sender assembly (inside left side of fuel tank)
• Secondary fuel pump & sender assembly (inside right side of fuel tank)
• Sp101 (behind left front headlight)
• Sp403 (at right rear of storage compartment)
• To spark plugs
• Underhood fuse block (left side of engine compt)

2.2L VIN D, Engine Performance Wiring Diagram (3 of 3) for Saturn Vue 2005

List of elements for 2.2L VIN D, Engine Performance Wiring Diagram (3 of 3) for Saturn Vue 2005:

• (at rear of engine) evaporative emissions canister purge solenoid
• (in engine harness, at breakout for throttle actuator control module)
• (in fuel injector harness, near c150) s101
• (on evap canister, in front of fuel tank) evaporative emissions canister vent solenoid
• (on left side of engine block, above starter) crankshaft position sensor
• (on top of engine, under fuel rail) fuel injectors
• B11
• Bare
• Ckp hi
• Ckp lo
• Cmp input
• Ect sens
• Emiss fuse 10a
• Engine control module (on intake manifold, under ignition coil housing)
• Engine coolant temperature sensor (on thermostat housing)
• Etc fuse 15a
• Evap purge
• Evap vent
• F ho2s hi
• F ho2s htr
• F ho2s lo
• Ftp +5v
• Ftp sig
• Fuel lvl sig
• Gen b term
• Heated oxygen sensor 1 (right rear of engine, in exhaust manifold)
• Heated oxygen sensor 2 (in exhaust manifold, behind catalytic converter)
• Hot at all times
• Hot in run or start
• Iat sens
• Ic 1-4
• Ic 2-3
• Ign inj fuse 15a
• Inj 1 ctrl
• Inj 2 ctrl
• Inj 3 ctrl
• Inj 4 ctrl
• Intake air temperature sensor (in engine compt, in air cleaner duct)
• Knk shield
• Knock sens
• Lo ref
• Main relay
• Main rly ign
• Map +5v
• Map lo
• Map sig
• Nca
• Pnk
• R ho2s hi
• R ho2s htr
• R ho2s lo
• Red
• S109
• S110
• Starting/charging system
• Tan
• Throttle actuator control module (at left rear side of engine, on throttle body)
• Throttle hi
• Throttle lo
• Tp 1 +5v
• Tp 1 lo
• Tp 1 sig
• Tp 2 +5v
• Tp 2 lo
• Tp 2 sig
• Underhood fuse block (left side of engine compt)

3.5L VIN 4

3.5L VIN 4, Engine Performance Wiring Diagram (1 of 5) for Saturn Vue 2005

List of elements for 3.5L VIN 4, Engine Performance Wiring Diagram (1 of 5) for Saturn Vue 2005:

• (at rear of engine) g107
• (at rear of engine, on throttle body) throttle actuator control module
• (at right side of engine, under intake air duct) splice pack sp114
• (in eng harn, in ckp sensor circuit)
• (in eng harn, in map sensor circuit) s115
• (on intake manifold) manifold absolute pressure sensor
• 3rd cltch sw
• 4th cltch sw
• 5 volt ref
• A/c ref sig
• Air conditioning system
• Automatic transmission output speed sensor (top of automatic transmission)
• C1 (partial)
• Camshaft position sensor (on top left front of engine)
• Ckp sens a
• Ckp sens b
• Cltch vlv 1
• Cltch vlv 2
• Cmp pos sig
• Crankshaft position sensor (lower front of engine, near crankshaft)
• Ect sens sig
• Egr pos
• Etc cntrl
• Etc ctrl
• Etc sig
• Fuel injectors (on top of engine, under fuel rails)
• G107 (at rear of engine)
• G107 (rear of engine)
• Gen field
• Gen turn on
• Gnd
• Ho2s htr
• Ho2s htr low
• Ho2s input
• Ho2s low
• Ho2s low ref
• Ho2s pump
• Ho2s ref
• Ho2s sig
• Iat sens 2
• Ign 1
• Ign coil 1
• Ign coil 2
• Ign coil 3
• Ign coil 4
• Ign coil 5
• Ign coil 6
• Inj 1
• Inj 2
• Inj 3
• Inj 4
• Inj 5
• Inj 6
• Iss high sig
• Ks sig
• Low ref
• Map sens sig
• Minhibit
• Mot inhibit
• Oil press sw
• Oss high sig
• Powertrain control module (in engine compt, mounted near right strut tower)
• Ra oil press
• Red
• Rocker arm oil pressure switch (at lower right front of engine, above oil filter)
• S129
• S132
• S133
• S135
• Splice pack sp113 (at right side of engine, under intake air duct)
• Splice pack sp114 (at right side of engine, under intake air duct)
• Ssv 1
• Ssv 2
• Ssv 3
• Starting/ chrging system
• Tcc enable
• Tcc vlv
• Tcc vlv low
• Tft sens sig

3.5L VIN 4, Engine Performance Wiring Diagram (2 of 5) for Saturn Vue 2005

List of elements for 3.5L VIN 4, Engine Performance Wiring Diagram (2 of 5) for Saturn Vue 2005:

• (at rear of automatic transmission)
• (at rear of automatic transmission) automatic transmission fluid temperature sensor
• (in a/c pressure sensor circuit)
• (in automatic transmission)
• (in automatic transmission) clutch pressure control solenoid valves
• (in bank 1 ho2 sensors circuit)
• (in bank 2 ho2 sensors circuit)
• (in egr valve circuit)
• (in tft sensor circuit)
• (on oil pump housing, lower right front of engine) engine oil pressure switch
• 3rd clutch pressure switch
• 4th clutch pressure switch
• Air conditioning system
• Automatic input shaft speed sensor (at top of automatic transmission)
• Engine coolant temperature sensor (at rear of engine)
• Exhaust gas recirculation valve (left rear of engine)
• G107 (rear of engine)
• Heated oxygen sensor (b1, s1) (on right exhaust manifold)
• Heated oxygen sensor (b1, s2) (downstream of right catalytic converter)
• Heated oxygen sensor (b2, s1) (on left exhaust manifold)
• Heated oxygen sensor (b2, s2) (downstream of left catalytic converter)
• Intake air temperature sensor 2 (left side of engine, on front of intake manifold)
• Nca
• Red
• S112
• S119
• S120
• S121
• S122
• S123
• S124
• S135
• Splice pack sp113 (right side of engine, under intake air duct)
• Splice pack sp114 (right side of engine)
• Splice pack sp114 (right side of engine, under intake air duct)
• Torque converter clutch pressure control solenoid valve

3.5L VIN 4, Engine Performance Wiring Diagram (3 of 5) for Saturn Vue 2005

List of elements for 3.5L VIN 4, Engine Performance Wiring Diagram (3 of 5) for Saturn Vue 2005:

• (at top of engine, above corresponding cylinder)
• (in front of fuel tank) evaporative emissions canister vent solenoid
• (top rear of engine, near rear valve cover) evaporative canister purge emissions solenoid valve
• Automatic transmission
• Brake fuse 15a
• Etc fuse 15a
• G107 (rear of engine)
• G109 (right front of engine, near generator)
• Hot at all times
• Hot in run or start
• Ignition control module 1
• Ignition control module 2
• Ignition control module 3
• Ignition control module 4
• Ignition control module 5
• Ignition control module 6
• Knock sensor (top center of engine, under intake manifold)
• Nca
• Pnk
• Red
• S125
• S130
• S131
• S134
• S304 (body harness, near cross car breakout)
• Shift solenoid valves
• Splice pack sp113 (right side of engine, under intake air duct)
• Splice pack sp114 (right side of engine, under intake air duct)
• Stop lamp switch (on brake pedal bracket)
• Torque converter clutch enable solenoid valve
• Underhood fuse block (left side of engine compt)

3.5L VIN 4, Engine Performance Wiring Diagram (4 of 5) for Saturn Vue 2005

List of elements for 3.5L VIN 4, Engine Performance Wiring Diagram (4 of 5) for Saturn Vue 2005:

• Class 2 serial data
• Computer data lines system
• D10
• D11
• Ecm/cam fuse 15a
• Emiss fuse 10a
• For diagnostics
• Fuel pump fuse 10a
• Fuel pump relay
• G101
• G403
• Hot at all times
• Hot in run or start
• Ign 1 fuse 10a
• Injectors fuse 10a
• Instrument panel cluster (ipc)
• Instrument panel fuse block (behind center of dash)
• Logic
• Main relay
• Malfunction indicator lamp (mil)
• Mil control
• Pnk
• Primary fuel pump sender assembly (inside left side of fuel tank)
• Red
• S401
• Secondary fuel pump sender assembly (inside right side of fuel tank)
• Sp101 (behind left front headlight)
• Sp403 (at right rear of storage compt)
• Splice pack sp113 (right side of engine, under intake air duct)
• Underhood fuse block (left side of engine compt)

3.5L VIN 4, Engine Performance Wiring Diagram (5 of 5) for Saturn Vue 2005

List of elements for 3.5L VIN 4, Engine Performance Wiring Diagram (5 of 5) for Saturn Vue 2005:

• (at top of automatic transmission) park/neutral position (pnp) switch
• (partial)
• 5 volt
• A/c cmp rel
• A/t
• Accelerator pedal position sensor (on accelerator pedal linkage arm)
• Air conditioning system
• Batt
• Can hi
• Can low
• Cc on sw
• Cc res/acc
• Cc set/cst
• Cooling fans system
• Cruise control system
• Data link connector (lower left side of dash)
• Drive sig
• Ecm/tcm fuse 10a
• Egr sol
• Electronic brake control module (near left front shock tower)
• Evap sol
• Evap vent
• F lvl sens
• F pmp rel
• F10
• Forward sig
• Ftp sens
• Fuel tank pressure sensor (on top of primary fuel pump & sender assembly)
• G107 (at rear of engine)
• G107 (rear of engine)
• Gnd
• Hi spd fan
• Hot at all times
• Hot in run or start
• Iat sens 1
• Ign 1
• Ing 1
• Int sig
• Intake air temperature sensor 1 (right side of eng compt)
• Low erf
• Low ref
• Low sig
• Low spd fan
• Main rel
• Nca
• Neutral sig
• Park sig
• Powertrain control module (in engine compt, mounted near right strut tower)
• Pwr train fuse 10a
• Ra oil sol
• Red
• Rev sig
• Rocker arm oil control solenoid (lower right front of engine)
• S112
• Sens 1
• Sens 2
• Sens1 sig
• Sens2 sig
• Ser data
• Splice pack sp114 (at right side of engine, under intake air duct)
• Starting/ charging system
• Stp lp sw
• Tan
• Tcc brk sw
• Underhood fuse block (left side of engine compt)