AIR CONDITIONING – Ford Mustang 2007 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

4.0L

4.0L, Manual A/C Wiring Diagram (1 of 2) for Ford Mustang 2007

List of elements for 4.0L, Manual A/C Wiring Diagram (1 of 2) for Ford Mustang 2007:

• (in main harness, near breakout to audio unit) s202
• (in main harness, near breakout to audio unit) s203
• (near breakout to climate control unit) s200
• (right front of engine compt)
• (right side of radiator support) g100
• A/c clu req
• A/c clutch cycling pressure switch (left rear corner of engine compt)
• A/c clutch field coil (lower left side of engine)
• A/c clutch relay
• A/c compressor clutch diode
• Blend dr act
• Blower motor relay
• Blower motor resistor (behind right side of dash, in a/c heater plenum)
• Blwr mtr rly
• Bussed electrical center (bec)
• C1035a e2
• C1035b f8
• C1035c f5
• C2280a
• C2280b
• C2280h
• C294a
• C294b
• Climate control module (behind center of dash)
• Def mode act
• Defrost mode actuator (behind right side of dash)
• Driv htd seat
• Floor mode actuator (behind left center of dash)
• Flr mode act
• Front blower motor (behind right side of dash, in a/c heater plenum)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G200 (behind right side of dash)
• G201 (behind right side of dash)
• Ground
• High
• Hot at all times
• Hot in run or acc
• Hot in start or run
• Illum
• Low
• Low current board
• Memory systems
• Pass htd seat
• Pnk
• Rear def ind
• Rear def sw
• Recirc dr mtr
• Recirculation door motor (behind dash,on evaporator assembly)
• Red
• S201 (in main harness, near breakout to audio unit)
• S211 (in heater blower motor harness, near breakout to c212)
• Smart junction box (sjb) (at right kick panel)
• Temperature blend door actuator (behind dash, on evaporator assembly)
• V batt
• V ign
• Vref
• Vref gnd

4.0L, Manual A/C Wiring Diagram (2 of 2) for Ford Mustang 2007

List of elements for 4.0L, Manual A/C Wiring Diagram (2 of 2) for Ford Mustang 2007:

• (in engine control sensor & fuel charge harness, on top of engine) s103
• A/c pressure transducer sensor (left front of engine compt)
• A12
• Acp
• Bussed electrical center (bec) (right front of engine compartment)
• C1035b
• C1035c
• C11
• C12
• C175b
• C175e
• Ect sig
• Engine coolant temperature sensor (on top front of engine)
• Engine cooling fan motor (right front of engine compt)
• F12
• Fuse 15a
• Fuse 40a
• G100 (right side of radiator support)
• High speed engine cooling fan relay
• Hot at all times
• Low speed engine cooling fan relay
• Powertrain control module (pcm) (right front of engine compt)
• Ref volt
• Rly ctrl
• S102 (in engine control sensor & fuel charge harness, near breakout to egr system module)
• Sig ret
• Sw sig
• Tan/red

4.6L

4.6L, Manual A/C Wiring Diagram (1 of 2) for Ford Mustang 2007

List of elements for 4.6L, Manual A/C Wiring Diagram (1 of 2) for Ford Mustang 2007:

• (in main harness, behind center of dash) s202
• (in main harness, behind center of dash) s203
• (near breakout to climate control unit) s200
• (right front of engine compt)
• (right side of radiator support) g100
• A/c clutch
• A/c clutch cycling pressure switch (left rear corner of engine compt)
• A/c clutch field coil (right front side of engine)
• A/c clutch relay
• A/c compressor clutch diode
• Blend dr act
• Blower motor relay
• Blower motor resistor (behind right side of dash, in a/c heater plenum)
• Blwr mtr rly
• Bussed electrical center (bec)
• C1035a c1
• C1035a e2
• C1035b f8
• C1035c f5
• C2280a
• C2280b
• C2280h
• C294a
• C294b
• Climate control module (behind center of dash)
• Def mode act
• Defrost mode actuator (behind right side of dash)
• Driv htd seat
• Floor mode actuator (behind left center of dash)
• Flr mode act
• Front blower motor (behind right side of dash, in a/c heater plenum)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G200 (behind right side of dash)
• G201 (behind right side of dash)
• Ground
• High
• Hot at all times
• Hot in run or acc
• Hot in start or run
• Illum
• Low
• Low current board
• Memory systems
• Pass htd seat
• Pnk
• Rear def ind
• Rear def sw
• Recirc dr mtr
• Recirculation door motor (behind dash, on evaporator assembly)
• Red
• S100 (near breakout to ignition transformer capacitor 1)
• S201 (in main harness,near breakout to audio unit)
• S211 (in heater blower motor harness, near breakout to c212)
• Smart junction box (sjb) (at right kick panel)
• Temperature blend door actuator (behind dash, on evaporator assembly)
• V batt
• V ign
• Vref
• Vref gnd

4.6L, Manual A/C Wiring Diagram (2 of 2) for Ford Mustang 2007

List of elements for 4.6L, Manual A/C Wiring Diagram (2 of 2) for Ford Mustang 2007:

• (in engine control sensor & fuel charge harness, near breakout to heated oxygen sensor 21) s102
• A12
• Accr
• Accs
• Bussed electrical center (bec) (right front of engine compartment)
• C1035b
• C1035c
• C11
• C12
• C175b
• C175e
• Cylinder head temperature sensor (4.6l: right rear of engine) (5.4l: rear of right cylinder bank)
• Dual pressure switch (left front of engine compt)
• Engine cooling fan motor (right front of engine compt)
• F12
• Fuse 15a
• Fuse 40a
• G100 (right side of radiator support)
• High speed engine cooling fan relay
• Hot at all times
• Low speed engine cooling fan relay
• Powertrain control module (pcm) (right front of engine compt)
• Rly ctrl
• S100
• Sensor sig
• Sig ret
• Sw sig
• Tan/red

5.4L

5.4L, Manual A/C Wiring Diagram (1 of 2) for Ford Mustang 2007

List of elements for 5.4L, Manual A/C Wiring Diagram (1 of 2) for Ford Mustang 2007:

• (in main harness, behind center of dash) s202
• (in main harness, behind center of dash) s203
• (near breakout to climate control unit) s200
• (right front of engine compt)
• (right side of radiator support) g100
• A/c clutch
• A/c clutch cycling pressure switch (left rear corner of engine compt)
• A/c clutch field coil (right front side of engine)
• A/c clutch relay
• A/c compressor clutch diode
• Blend dr act
• Blower motor relay
• Blower motor resistor (behind right side of dash, in a/c heater plenum)
• Blwr mtr rly
• Bussed electrical center (bec)
• C1035a c1
• C1035a e2
• C1035b f8
• C1035c f5
• C2280a
• C2280b
• C2280h
• C294a
• C294b
• Climate control module (behind center of dash)
• Def mode act
• Defrost mode actuator (behind right side of dash)
• Driv htd seat
• Floor mode actuator (behind left center of dash)
• Flr mode act
• Front blower motor (behind right side of dash, in a/c heater plenum)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G200 (behind right side of dash)
• G201 (behind right side of dash)
• Ground
• High
• Hot at all times
• Hot in run or acc
• Hot in start or run
• Illum
• Low
• Low current board
• Memory systems
• Pass htd seat
• Pnk
• Rear def ind
• Rear def sw
• Recirc dr mtr
• Recirculation door motor (behind dash, on evaporator assembly)
• Red
• S100 (near breakout to ignition transformer capacitor 1)
• S201 (in main harness,near breakout to audio unit)
• S211 (in heater blower motor harness, near breakout to c212)
• Smart junction box (sjb) (at right kick panel)
• Temperature blend door actuator (behind dash, on evaporator assembly)
• V batt
• V ign
• Vref
• Vref gnd

5.4L, Manual A/C Wiring Diagram (2 of 2) for Ford Mustang 2007

List of elements for 5.4L, Manual A/C Wiring Diagram (2 of 2) for Ford Mustang 2007:

• (in engine control sensor & fuel charge harness, near breakout to heated oxygen sensor 21) s102
• A12
• Accr
• Accs
• Bussed electrical center (bec) (right front of engine compartment)
• C1035b
• C1035c
• C11
• C12
• C175b
• C175e
• Cylinder head temperature sensor (4.6l: right rear of engine) (5.4l: rear of right cylinder bank)
• Dual pressure switch (left front of engine compt)
• Engine cooling fan motor (right front of engine compt)
• F12
• Fuse 15a
• Fuse 40a
• G100 (right side of radiator support)
• High speed engine cooling fan relay
• Hot at all times
• Low speed engine cooling fan relay
• Powertrain control module (pcm) (right front of engine compt)
• Rly ctrl
• S100
• Sensor sig
• Sig ret
• Sw sig
• Tan/red