AIR CONDITIONING – Jeep Wrangler Sport 2004 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Heater Wiring Diagram for Jeep Wrangler Sport 2004

List of elements for Heater Wiring Diagram for Jeep Wrangler Sport 2004:

• (behind center of dash, near breakout to cigar lighter) s207
• (behind left end of dash) g200
• (behind right end of dash) g202
• A/c- heater control
• Blend door actuator (on heater-a/c housing)
• Blower motor (on right rear of engine compartment)
• Blower motor relay (on hvac) (near right end of heater-a/c housing)
• Blower motor resistor block (under right side of dash, on hvac module)
• Defrost
• Fuse 10a
• Fuse 40a
• Fuse block (under right center of dash)
• G202 (behind right end of dash)
• Heat
• High
• Hot at all times
• Hot in run
• Interior lights system
• Low
• Mix
• Off
• Power distribution center (on right side of engine comptartment)
• S207 (behind center of dash, near breakout to cigar lighter)
• S208 (near breakout to blower motor)
• Tan
• Vent

Manual A/C Wiring Diagram for Jeep Wrangler Sport 2004

List of elements for Manual A/C Wiring Diagram for Jeep Wrangler Sport 2004:

• (2.4l)
• (2.4l) high speed radiator fan relay
• (2.4l: near right headlamp) g190
• (4.0l base)
• (4.0l)
• (at right center of firewall, near breakout to g101) s103
• (behind left end of dash) g200
• (behind right end of dash) g202
• (near breakout to blower motor) s208
• (near compressor) (2.4l) a/c pressure transducer
• 2.4l
• 4.0l
• A/c comp relay ctrl
• A/c compressor clutch (2.4l: right front of engine) (4.0l: lower left front of engine)
• A/c compressor clutch relay (in power distribution center)
• A/c high pressure switch (on a/c compressor discharge line)
• A/c low pressure switch (on a/c accumulator)
• A/c pressure signal
• A/c request signal
• A/c select input
• A/c- heater control
• A10
• Blend door actuator
• Blower motor (on right rear of engine compartment)
• Blower motor relay (on hvac) (near right end of heater-a/c housing)
• Blower motor resistor block (under right side of dash, on hvac module)
• C13
• C18
• C21
• C24
• C27
• C90
• D10
• D11
• D13
• D14
• Defrost
• Ect sensor
• Engine coolant temperature sensor (on thermostat housing)
• Firewall, near breakout to g100) s102
• Fuse 10a
• Fuse 40a
• Fuse block (under right center of dash)
• G105 (2.4l: near left engine mount) (4.0l: right rear of engine block)
• G200 (behind left end of dash)
• G202 (behind right end of dash)
• Heat
• High
• High speed radiator
• Hot at all times
• Hot in run
• Hot in run or start
• Interior lights system
• Low
• Low speed radiator
• Low speed radiator fan relay
• Max
• Mix
• Nca
• Norm
• Off
• Position sensor)
• Power distribution center (on right side of engine compt)
• Powertrain control module (in right rear of engine compt, on firewall)
• Radiator fan motor (on right radiator fan shroud)
• Radiator fan motor circuit breaker (2.4l: on right radiator fan shroud)
• S123 (2.4l: near breakout for ignition coil pack)
• S127
• S127 (near breakout to idle air control motor)
• S176 (in fuel injector harness)
• S180
• S207 (behind center of dash, near breakout to cigar lighter)
• Sens ground
• Sensor ground
• Tan
• Vacuum/ electric mode switch
• Vent