ENGINE PERFORMANCE – Mercury Sable GS 2001 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

3.0L

3.0L 12-Valve, Engine Performance Wiring Diagrams (1 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 12-Valve, Engine Performance Wiring Diagrams (1 of 4) for Mercury Sable GS 2001:

• (right rear of engine compt)
• A/c system
• Battery junction box (behind radiator)
• Central junction box (under left side of dash)
• Ckp pos sens +
• Ckp pos sens -
• Cooling fans system
• Digital transmission range (dtr) sensor (on top of transmission housing)
• Dtr-tr1
• Dtr-tr2
• Dtr-tr4
• Dual press sw
• Ect sens
• Egr vacuum regulator solenoid (right side of intake manifold)
• Evr
• Ffv
• Fuel pump (on front side of fuel tank)
• Fuel pump relay
• Fuel pump rly
• Fuel sender
• Fuse 20a
• Fuse 2a
• Fuse 30a
• G100 (left front fender)
• G123
• G405 (right rear side of luggage compt)
• Gas
• Ground
• H2os 12
• High spd fan rly
• Hot at all times
• Hot in run or start
• Iat sens
• Ign coil a
• Ign coil b
• Ignition coil (left rear of engine)
• Ignition transformer capacitor (attached to ignition coil)
• Inertia fuel shut-off switch (in cargo area, behind right wheelwell)
• Low spd fan rly
• Maf sens
• Mil ind
• Mod programming
• Nca
• Passive anti-theft transceiver module (near ignition switch)
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right rear corner of engine compt, in firewall)
• R n
• Red
• Rx, signal
• S115 (top left side of engine)
• S117 (top of engine)
• S137
• S140 (left front of engine compt)
• Scp bus (+)
• Scp bus (-)
• Shift sol a
• Shift sol b
• Shift sol c
• Starter rly
• Starting system
• Tach
• Tft sens
• Theft ind
• To dtr sensor (diagram 4 of 4)
• To spark plugs
• Tss
• Tx, signal

3.0L 12-Valve, Engine Performance Wiring Diagrams (2 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 12-Valve, Engine Performance Wiring Diagrams (2 of 4) for Mercury Sable GS 2001:

• (behind center of dash) g206
• (behind instrument cluster) s234
• (behind left side of dash) flex fuel sensor module
• A/c system
• Anti- slosh module
• Anti-lock brakes system
• Anti-theft "on" indicator
• C220a
• C220b
• C270b
• Central junction box (under left side of dash)
• Check fuel cap indicator
• Check transmission indicator
• Crankshaft position sensor (lower right front of engine)
• Data link connector (dlc) (mounted on dash, below steering column)
• Engine coolant temperature sensor (rear of engine block)
• Ffv
• Fuel sender (on fuel tank)
• Fuse 10a
• Fuse 15a
• G123 (right rear of engine compt)
• G123 (right rear side of engine compt)
• G206 (behind center of dash)
• Gas
• Hot at all times
• Hot in run or start
• Instrument cluster
• Malfunction indicator lamp
• Mass airflow (maf) sensor (in engine air intake assembly)
• Red
• S113
• S114
• S129
• S130 (left front of engine compt)
• S134 (left rear side of engine compt)
• S205
• S206
• S214 (under left side of dash)
• S217
• S218 (behind center of dash)
• Speedometer
• Tachometer

3.0L 12-Valve, Engine Performance Wiring Diagrams (3 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 12-Valve, Engine Performance Wiring Diagrams (3 of 4) for Mercury Sable GS 2001:

• (left rear of engine compt)
• (top left rear of engine) s116
• Ax4s/ax4n transmission
• Camshaft position sensor (rear of engine block, between cylinder heads)
• Differential pressure feedback egr (dpfe) sensor (right front of intake manifold)
• Electronic pressure control solenoid
• Evap canister purge valve (right rear of engine compt)
• Fuel tank pressure transducer sensor (at fuel tank)
• Idle air control (iac) valve (on throttle body)
• Nca
• Output shaft speed (oss) sensor (on transaxle)
• Red
• Red/pnk
• S100 (left rear of engine)
• S101 (top of engine)
• S133
• Shift solenoid a
• Shift solenoid b
• Shift solenoid c
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Turbine shaft speed (tss) sensor (rear side of transaxle)

3.0L 12-Valve, Engine Performance Wiring Diagrams (4 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 12-Valve, Engine Performance Wiring Diagrams (4 of 4) for Mercury Sable GS 2001:

• (below spare wheelwell) evap canister vent valve
• (left rear of engine)
• (on top of transmission housing) digital transmission range (dtr) sensor
• (right rear g123 of engine compt)
• (top of engine)
• A/c clutch relay
• A/c clutch rly
• A/c system
• Battery junction box (behind radiator)
• Bpp sw
• Brake pedal position (bpp) switch (upper dash, upper front side of brake pedal)
• C270c
• Cam sens
• Canister vent
• Central junction box (under left side of dash)
• Dpfe sens
• Dtr-tr3a
• Dual press sw
• Epc sol
• Evap purge valve
• From dtr sensor (diagram 1 of 4)
• Ftp sens
• Fuel cap ind
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel injectors
• Fuel pump rly
• Fuse 10a
• Fuse 15a
• Ground
• H2os 11
• H2os 12
• H2os 21
• H2os 22
• Heated oxygen sensor 11 (rear of engine compt, on exhaust manifold)
• Heated oxygen sensor 12 (under vehicle, downstream from catalytic converter 1)
• Heated oxygen sensor 21 (front of engine compt, on exhaust manifold)
• Heated oxygen sensor 22 (under vehicle, downstream from catalytic converter 2)
• Hot at all times
• Iac valve
• Ign coil c
• Maf sens
• Nca
• Oss sens
• Power
• Power (ign)
• Powertrain control module (pcm) (right rear corner of engine compt, in firewall)
• Red
• Red/pnk
• S105
• S114
• S118
• S119 (top of engine)
• S136
• Signal return
• Tan
• Tcc sol
• Tcil
• Tp sens
• Vref
• Vss sens

3.0L 24-Valve, Engine Performance Wiring Diagrams (1 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 24-Valve, Engine Performance Wiring Diagrams (1 of 4) for Mercury Sable GS 2001:

• A/c system
• Battery junction box (behind radiator)
• Central junction box (under left side of dash)
• Ckp pos sens +
• Ckp pos sens -
• Cooling fans system
• Digital transmission range (dtr) sensor (on top of transmission housing)
• Dtr-tr1
• Dtr-tr2
• Dtr-tr4
• Dual press sw
• Ect sens
• Egr
• Fuel pump (on front side of fuel tank)
• Fuel pump relay
• Fuel pump rly
• Fuel sender
• Fuse 20a
• Fuse 2a
• Fuse 30a
• G100 (left front fender)
• G123 (right rear of engine compt)
• G405 (right rear side of luggage compt)
• Ground
• H2os 12
• High spd fan rly
• Hot at all times
• Hot in run or start
• Iat sens
• Ign coil a
• Ign coil b
• Ignition coil (left rear of engine)
• Ignition transformer capacitor (attached to ignition coil)
• Inertia fuel shut-off switch (in cargo area, behind right wheelwell)
• Knock sens
• Low spd fan rly
• Maf sens
• Mil ind
• Mod programming
• Nca
• Passive anti-theft transceiver module (near ignition switch)
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right rear corner of engine compt, in firewall)
• Psp switch
• R n
• Red
• Rx, signal
• S114
• S137
• S140 (left front of engine compt)
• Scp bus (+)
• Scp bus (-)
• Shift sol a
• Shift sol b
• Shift sol c
• Starter rly
• Starting system
• Tach
• Tft sens
• Theft ind
• To dtr sensor (diagram 4 of 4)
• To spark plugs
• Tss sens
• Tx, signal

3.0L 24-Valve, Engine Performance Wiring Diagrams (2 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 24-Valve, Engine Performance Wiring Diagrams (2 of 4) for Mercury Sable GS 2001:

• (behind center of dash)
• (left front of engine compt)
• (left top rear of engine) s103
• A/c system
• Anti- slosh module
• Anti-lock brakes system
• Anti-theft "on" indicator
• C220a
• C220b
• C270b
• Central junction box (under left side of dash)
• Check fuel cap indicator
• Check transmission indicator
• Crankshaft position sensor (lower right front of engine)
• Data link connector (dlc) (mounted on dash, below steering column)
• Egr vacuum regulator solenoid (on front of intake manifold)
• Engine coolant temperature sensor (rear of engine block)
• Fuel sender (on fuel tank)
• Fuse 10a
• Fuse 15a
• G123 (right rear of engine compt)
• G123 (right rear side of engine compt)
• G202 (behind center of dash)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Malfunction indicator lamp
• Mass airflow sensor (in air intake assembly)
• Nca
• Power steering
• Pressure switch (left rear of engine compt)
• Red
• S110 (left side of engine)
• S113
• S114
• S129
• S130
• S134 (left rear side of engine compt)
• S205
• S206
• S214 (under left side of dash)
• S217
• S218
• Speedometer
• Tachometer

3.0L 24-Valve, Engine Performance Wiring Diagrams (3 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 24-Valve, Engine Performance Wiring Diagrams (3 of 4) for Mercury Sable GS 2001:

• (top left side of engine) knock sensor
• Ax4s/ax4n transmission
• Camshaft position sensor (left front of engine, below valve cover)
• Differential pressure feedback egr sensor (on right side of engine)
• Electronic pressure control solenoid
• Evap canister purge valve (right rear of engine compt)
• Fuel tank pressure transducer sensor (at fuel tank)
• Idle air control (iac) valve (on throttle body)
• Nca
• Output shaft speed (oss) sensor (on transaxle)
• Red
• Red/pnk
• S100 (left rear of engine)
• S101 (top of engine)
• S104 (left rear of engine)
• S110 (left side of engine)
• Shift solenoid a
• Shift solenoid b
• Shift solenoid c
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Turbine shaft speed (tss) sensor (rear side of transaxle)

3.0L 24-Valve, Engine Performance Wiring Diagrams (4 of 4) for Mercury Sable GS 2001

List of elements for 3.0L 24-Valve, Engine Performance Wiring Diagrams (4 of 4) for Mercury Sable GS 2001:

• (below spare wheelwell) evap canister vent valve
• (left rear of engine)
• (left side of engine)
• (on top of transmission housing) digital transmission range (dtr) sensor
• A/c clutch relay
• A/c clutch rly
• A/c system
• Battery junction box (behind radiator)
• Bpp sw
• Brake pedal position (bpp) switch (upper dash, upper front side of brake pedal)
• C270c
• Cam sens
• Canister vent
• Central junction box (under left side of dash)
• Dpfe sens
• Dtr-tr3a
• Dual press sw
• Epc sol
• Evap purge valve
• From dtr sensor (diagram 1 of 4)
• Ftp sens
• Fuel cap ind
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel injectors
• Fuel pump rly
• Fuse 10a
• Fuse 15a
• G123 (right rear of engine compt)
• Ground
• H2os 11
• H2os 12
• H2os 21
• H2os 22
• Heated oxygen sensor 11 (rear of engine compt, on exhaust manifold)
• Heated oxygen sensor 12 (under vehicle, downstream from catalytic converter 1)
• Heated oxygen sensor 21 (front of engine compt, on exhaust manifold)
• Heated oxygen sensor 22 (under vehicle, downstream from catalytic converter 2)
• Hot at all times
• Iac valve
• Ign coil c
• Knock sens
• Maf sens
• Nca
• Oss sens
• Power
• Power (ign)
• Powertrain control module (pcm) (right rear corner of engine compt, in firewall)
• Red
• Red/pnk
• S105
• S107 (left side of engine)
• S109 (left side of engine)
• S112
• S114
• S133 (left rear of engine compt)
• S136
• Signal return
• Tan
• Tcc sol
• Tcil
• Tp sens
• Vref
• Vss sens