GROUND DISTRIBUTION – Ford Excursion 2004 – SYSTEM WIRING DIAGRAMS

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Ford Excursion 2004

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Ford Excursion 2004:

• (6.8l) heated positive crankcase ventilation (pcv) element
• (at left rear side of engine compartment) auxiliary relay box 2
• (at left rear side of engine compt) (diesel)
• (at left rear side of engine compt) (except diesel)
• (at right frame rail, in engine compt)
• (behind lower left side of dash) central junction box (cjb)
• (diesel)
• (diesel) a/c clutch field coil
• (diesel) air filter sensor
• (diesel) dual pressure switch
• (diesel) fuel injector control module (ficm)
• (diesel) powertrain control module (pcm)
• (except diesel)
• (except diesel) powertrain control module (pcm)
• (except diesel, base) left front side lamp
• (not used)
• A/c clutch field coil
• A/c compressor clutch diode
• Automatic a/c
• Auxiliary relay box 4
• Auxiliary relay box 5
• Battery
• Battery 2
• Battery charge trailer tow relay
• Brake fluid level switch
• C1381a
• C1388c
• C175
• C270f
• C270h
• Crankshaft position sensor shield
• Data link connector (dlc)
• Daytime running lamps (drl) relay 1
• Daytime running lamps (drl) relay 2
• Diesel
• Except base, except diesel
• Except diesel
• Front blower motor speed controller
• Front heater blower motor resistor
• Fuel heater relay
• G100 (at left rear side of engine compt)
• G101 (at left side of engine compt)
• G102 (at right side of engine compt)
• G104 (in engine compt, at right fender)
• G106 (at right frame rail, in engine compt)
• G108 (at right side of engine compt)
• G109 (at left side of engine)
• G203 (under right side of dash)
• Harness, near breakout for g108)
• Horn
• Left front fog lamp
• Left front park/ turn lamp
• Left front side lamp
• Left headlamp
• Left turn trailer tow relay
• Manual a/c
• Mass air flow (maf) sensor
• Nca
• Parking lamp trailer tow relay
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm)
• Restraints control module
• Reversing lamp trailer tow relay
• Right front fog lamp
• Right front park/ turn lamp
• Right front side lamp
• Right headlamp
• Right turn trailer tow relay
• S102 (in engine control harness, near breakout for g101)
• S106
• S117 (diesel) (near break- out for powertrain control module)
• S145 (near breakout for c110)
• S161 (near crankshaft breakout position for c110) sensor shield
• S167
• S195 (near breakout for injector driver module)
• Speed control servo
• Starter relay
• Vacuum pump motor
• Windshield wiper motor

Ground Distribution Wiring Diagram (2 of 4) for Ford Excursion 2004

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Ford Excursion 2004:

• (at left rear side of engine compartment) auxiliary relay box 3
• (behind glove box) auxiliary relay box 1
• (behind lower left side of dash) central junction box (cjb)
• (diesel) fuel heater
• (diesel) fuel pump
• (except diesel) powertrain control module (pcm)
• (in engine control harness, near breakout for left front wheel speed sensor)
• (manual a/c)
• (w/ automatic a/c) electronic automatic temperature control (eatc) module
• (w/ memory) adjustable pedal switch
• (w/ overhead console) trip computer module
• (w/o memory) adjustable pedal switch
• 87a
• Adjustable pedal switch
• Air bag sliding contact
• Automatic a/c
• Auxiliary a/c relay
• Blower motor relay
• Brake pedal position switch
• Brake shift interlock
• C202b
• C205a
• C205b
• C218a
• C220c
• C228a
• C270a
• C281a
• C290a
• C294a
• C294b
• C294c
• C341c
• Console power point
• Data link connector (dlc)
• Driver seat module
• Driver side front seat adjust switch
• Electro- chromatic inside mirror unit
• For c1010) (m/t: at breakout for left auxiliary relay box 3)
• Four- wheel drive control module
• Four- wheel drive switch
• Front cigar lighter
• Function selector switch assembly
• G201 (behind left side of dash)
• G202 (behind left side of dash)
• G300 (on vehicle floor, in left front footwell)
• Glove box lamp
• Indicator flasher relay
• Instrument cluster
• Instrument panel power point
• Left vanity mirror lamp
• Main light switch
• Memory set switch
• Multi-function switch
• Nca
• Parking aid disable switch
• Parking brake switch
• Passive anti-theft transceiver module
• Radio
• Rear integrated control panel (ricp)
• Rear window defrost switch
• Right vanity mirror lamp
• S201 (in main harness, near breakout for instrument cluster)
• S217 (in main harness, near breakout for instrument cluster)
• S218 (in main harness, near breakout for instrument cluster)
• S257 (in main harness, near breakout to temperature blend door actuator)
• S290 (in main harness, near breakout to radio)
• S314 (power and heated seats w/ memory) (in body main harness, near grommet on left side of vehicle floor)
• S324 (in console panel harness, near breakout for power point console)
• S936 (in overhead console harness, near breakout for electrochromatic inside mirror unit)
• Steering wheel/ speed control switch
• Sunload sensor
• Temperature blend door actuator
• Trailer electronic brake control connector
• Transfer case high to low relay
• Transfer case low to high relay
• W/ electronic shift on the fly
• W/ rear audio controls
• Windshield wiper motor

Ground Distribution Wiring Diagram (3 of 4) for Ford Excursion 2004

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Ford Excursion 2004:

• (except diesel) fuel tank unit
• 4-pin
• 7-pin
• Abs control module
• C290a
• Dvd player
• G105 (at left front side of engine compt)
• G110 (at top left side of engine)
• G200 (behind left side of dash)
• G400 (at vehicle underbody, chassis left side member)
• G403 (at right ``d" pillar)
• Harness, near breakout for c410)
• Harness, near breakout for left headlight)
• High speed blower motor relay
• Left bank fuel injector shield
• Left front running board lamp
• Left license plate lamp
• Left rear park/ stop/ turn lamp
• Left rear running board lamp
• Left reversing lamp
• Nca
• Near breakout for g400)
• Or parking aid
• Others
• Parking aid module (pam)
• Radio
• Rear a/c control module
• Rear blend door actuator
• Rear integrated control panel (ricp)
• Rear mode door actuator
• Rear power point
• Right bank fuel injector shield
• Right front running board lamp
• Right license plate lamp
• Right rear park/ stop/ turn lamp
• Right rear running board lamp
• Right reversing lamp
• S194 (near breakout for injector driver module)
• S311 (in running board lamps harness, near breakout for left rear running board light)
• S321 (in rear vehicle interior harness, near breakout for rear power point)
• S404 (in rear lamp connector harness, near breakout for c405)
• Trailer tow connector
• W/ auxiliary a/c
• W/ auxiliary a/c w/o parking aid
• W/o auxiliary a/c
• W/o auxiliary a/c or parking aid
• W/o auxiliary a/c w/ parking aid

Ground Distribution Wiring Diagram (4 of 4) for Ford Excursion 2004

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Ford Excursion 2004:

• "c" pillar power point
• (w/ memory)
• C2113a
• C341b
• C402b
• C475a
• C475b
• C475c
• C504a
• C989a
• C989b
• C990b
• Cargo lamp
• Driver safety belt buckle switch)
• Driver seat module
• Driver side door lock switch
• Driver side exterior rear view mirror
• Driver side front door ajar switch
• Driver side front heated seat relay
• Driver side front seat adjust switch
• Driver side rear door ajar switch
• Driver side seat heater switch
• Exterior rear view mirror switch
• For c315)
• For stoplamp)
• Front auxiliary function selector switch assembly
• Front interior/ map lamp assembly
• Front interior/ map lamps assembly
• G301 (at left ``c" pillar)
• G901 (at rear of vehicle roof)
• High mounted stoplamp
• Key pad switch assembly
• Left front door entry lamp
• Left front seat back heater
• Left liftgate ajar switch
• Left power vent window switch
• Left side rail lamp
• Master window adjust switch
• Nca
• Near breakout for g901)
• Others
• Passenger power seat w/o heat
• Passenger side door lock switch
• Passenger side exterior rear view mirror
• Passenger side front door ajar switch
• Passenger side front seat adjust switch
• Passenger side rear door ajar switch
• Passenger side seat heater switch
• Rear auxiliary function selector switch assembly
• Rear interior/ map lamps assembly
• Rear window defrost grid
• Rear wiper motor assembly
• Right front door entry lamp
• Right front seat back heater
• Right liftgate ajar switch
• Right power vent window switch
• Right side rail lamp
• S233 (in body main harness, near grommet for right front door)
• S300 (in body main harness, near breakout for left rear speaker)
• S301 (power seat w/o heat) (near breakout for driver's side seat buckle)
• S301 (w/o memory: near breakout for
• S306 (in body main harness, near breakout for c3049)
• S332 (power seat w/ heat) (w/o memory: in passenger-driver seat jumper harness, near breakout for driver safety belt buckle switch) (w/ memory: in power seats harness, near breakout for c315)
• S335 (w/ heated w/o power seats) s355 (w/ heated w/ power seats) (near breakout for passenger side heated seat switch)
• S440
• S501 (in body main harness, at breakout for driver side door lock switch)
• S935 (in interior lamps harness, near breakout for front auxiliary function selector switch assembly)
• Safety belt buckle switch
• Vehicle security module (vsm)
• W/ auxiliary a/c
• W/ overhead console
• W/ power passenger seat
• W/o auxiliary a/c
• W/o power passenger seat