AIR CONDITIONING
Compressor Wiring Diagram for Saturn Ion Red Line 2006
List of elements for Compressor Wiring Diagram for Saturn Ion Red Line 2006:
- (at rear of engine, near coolant overflow container) (2.0l) powertrain control module (pcm)
- (not used)
- +5v
- 2.0l
- 2.2l
- 2.4l
- A/c clutch relay
- A/c compressor clutch (at lower left front of engine)
- A/c diode
- A/c fuse 5 10a
- A/c on led
- A/c on/off
- A/c press
- A/c refrigerant pressure sensor (on lower left side of engine, below generator)
- A/c relay
- A/c request
- A/c switch
- A10
- Aa1
- Aa2
- Aa3
- Aa4
- B11
- Body control module (bcm) (at lower center of dash)
- Class 2 data
- Ect sens
- Engine control module (ecm) (2.2l & 2.4l) (at left side of engine compt)
- Engine coolant temperature (ect) sensor (2.0l: on top of engine, near right front corner of camshaft cover) (2.2l, 2.4l: on right rear side of engine, near exhaust manifold)
- F10
- G101 (behind left front headlamp)
- G203 (behind lower left side of dash, left of steering column)
- Hot at all times
- Hot in run or start
- Hvac control assembly
- Hvac fan switch
- Hvac fuse 7.5a
- Ign 3 volt
- Logic
- Low ref
- Off
- Red
- Run (ign 3) fuse 48 30a
- Run relay
- Run relay ctrl
- Run/ crank relay
- S101 (in forward lamp harness, near underhood fuse block connector)
- S233 (in i/p harness, approximately 20 cm from radio c1 breakout)
- Underhood fuse block (at left rear side of engine compartment)
Manual A/C Wiring Diagram (1 of 2) for Saturn Ion Red Line 2006
List of elements for Manual A/C Wiring Diagram (1 of 2) for Saturn Ion Red Line 2006:
- (at rear of engine, near coolant overflow container) powertrain control module (pcm)
- (not used)
- +5v
- A/c clutch relay
- A/c compressor clutch (at lower left front of engine)
- A/c diode
- A/c fuse 5 10a
- A/c ind
- A/c press
- A/c relay
- A/c request sig
- A/c sig sw
- A/c switch
- A10
- Bi-lvl
- Blend
- Class 2 data
- Cooling fan relay ctrl
- Cooling fan s/p relay ctrl
- Def
- Ect sens
- Engine coolant temperature (ect) sensor (on top of engine, near right front corner of camshaft cover)
- F10
- G101 (behind left front headlamp)
- Hot at all times
- Hot in run or start
- Htr
- Hvac control assembly
- Hvac fan switch
- Ign 3 volt
- Illum
- Interior lights system
- Logic
- Low ref
- Mode sw sig
- Mode switch
- Off
- Rec dr ctrl a
- Rec dr ctrl b
- Rec sw sig
- Recirc ind
- Recirc switch
- Run/ crank relay
- S101 (in forward lamp harness, near underhood fuse block connector)
- Tan
- Underhood fuse block (at left rear side of engine compartment)
- Vent
Manual A/C Wiring Diagram (2 of 2) for Saturn Ion Red Line 2006
List of elements for Manual A/C Wiring Diagram (2 of 2) for Saturn Ion Red Line 2006:
- (attached to right side of radiator) cooling fan 2
- (in engine harness, 1 cm from oil pressure switch) s160
- (in engine harness, 5 cm from starter cable breakout) s156
- (in front of engine compt, attached to top center of radiator) cooling fan s/p relay
- (not used)
- (on lower left rear of engine, above starter)
- 87a
- A/c refrigerant pressure sensor (on lower left side of engine, below generator)
- A/c request
- Aa1
- Aa2
- Aa3
- Aa4
- B11
- Blower motor (behind lower right side of dash, behind glove compt)
- Blower motor resistor assembly (behind lower right side of dash, behind glove compt)
- Body control module (bcm) (at lower center of dash)
- Class 2 data
- Cooling fan 1 (attached to left side of radiator)
- Cooling fan 1 fuse 45 30a
- Cooling fan 1 relay
- Cooling fan 2 fuse 44 30a
- Cooling fan 2 relay (in front of engine compt, attached to top right corner of radiator)
- E1 c1
- Early production
- G105
- G203 (behind lower left side of dash, left of steering column)
- Hot at all times
- Hvac fuse 7.5a
- Late production
- Logic
- Motor breakout)
- Nca
- Recirculation actuator (behind lower right side of dash, near "a" pillar)
- Red
- Run (ign 3) fuse 48 30a
- Run relay
- Run relay ctrl
- S158 (in engine harness, 6 cm from starter solenoid breakout)
- S233 (in i/p harness, approximately 20 cm from radio c1 breakout)
- Tan
- Underhood fuse block (at left rear side of engine compartment)
