ENGINE PERFORMANCE
5.8L
5.8L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford Cab & Chassis F350 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for 5.8L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, near brake warning resistor/diode assembly) s136
- (engine control sensor harness, near breakout to pcm)
- (fuel charge harness, near breakout to distributor)
- (fuel charge harness, near breakout to ignition coil)
- (low range indicator)
- A/c clutch sig
- Air conditioning system
- Aird solenoid
- Bbp feed
- Body builder power feed
- Case gnd
- Ckp sensor
- Coil
- Data link (+)
- Data link (-)
- Data link connector (right side of dash)
- Data link feps
- Distributor (top front of engine)
- Distributor ignition shield
- Ect sens
- Egr solnd ctrl
- Engine compartment fuse box
- Fuel pump mon
- Fuse 20a
- Fuse 30a
- G104 (rear of left fender apron)
- G108 (left front radiator support)
- G203 (right kick panel)
- Hot at all times
- Hot in start or run
- Iat sens
- Idm
- Idm (fto)
- Ign gnd
- Ignition coil (left side of engine, above valve cover)
- Ignition control module (left rear side of engine compartment, on fender apron)
- Instrument cluster system
- Low rnge 4x4
- Maf sig rtn
- Mil
- Misfire sens
- Nca
- Pcm power diode
- Pcm power relay
- Pip
- Pnk
- Power
- Powertrain control module (top left side of firewall)
- Pwr gnd
- Pwr grd
- Radio capacitor (left side of engine, near coil)
- Red
- Red/
- Rr ho2s sig
- S102
- S104
- S145
- S148
- S171
- S199
- S216
- Spout
- Spout check connector (left rear of engine compartment, near icm)
- Trans ctrl sw
- Trans temp
- Tss 1
- Tss 2
- Vss (-)
5.8L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford Cab & Chassis F350 1997
List of elements for 5.8L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford Cab & Chassis F350 1997:
- (fuel charge harness, near breakout to fuel injector 3)
- C250
- C251
- C252
- Delta pressure feedback egr sensor (5.8l - on top right front of of engine) (7.5l - on lrft side of throttle body)
- Engine compartment fuse box
- Engine coolant temperature sensor (left front of engine, near distributor)
- Fuel pump relay
- Fuse 20a
- Hot at all times
- Instrument cluster
- Intake air temperature sensor (top center of engine, behind distributor)
- Malfunction indicator input
- Misfire sensor (center front of engine, on timing chain cover)
- Misfire sensor shield
- Nca
- Psom vehicle speed output
- Red
- Rpm input
- S135 (fuel charge harness, near breakout to canister purge solenoid)
- S151
- S246 (main harness, near breakout to speed control amplifier)
- Throttle position sensor (top left front of engine, on throttle body)
5.8L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford Cab & Chassis F350 1997
List of elements for 5.8L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
- (fuel charge harness, near breakout to act solenoid)
- (fuel charge harness, near breakout to fuel injector 3)
- (not used)
- 5.8l
- 7.5l
- Coast clutch solenoid
- E4od transmission
- Egr control solenoid (5.8l - on ignition coil support bracket) (7.5l - in left side of engine compt)
- Electronic pressure control solenoid
- Front tank fuel pump/ fuel gauge sender
- Fuel tank selector switch
- G108 (on upper left radiator support)
- Idle air control valve (on throttle body)
- Inertia fuel shut-off switch (behind right kick panel)
- Injectors fuel
- Nca
- Rear tank fuel pump/ fuel gauge sender
- Red
- S137
- S149
- S151
- S169
- S400
- Secondary air injection bypass (airb) solenoid (7.5l) (near ignition coil)
- Secondary air injection diverter (aird) solenoid (7.5l) (rear of left valve cover)
- Shift solenoids
- Ss1
- Ss2
- Tan
- Tan/ red
- Tan/red
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Vapor management valve (center of engine)
5.8L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford Cab & Chassis F350 1997
List of elements for 5.8L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, in breakout to engine compt. fuse panel box)
- (engine control sensor harness, near breakout to pcm)
- (main harness, near breakout to clutch pedal position switch or jumper) s240
- (not used)
- 5.8l
- 7.5l
- Airb solenoid
- Batt
- Brake on/off
- Brake on/off (boo) switch (on bracket, above brake pedal)
- Coast clutch
- Dpfe sens
- Epc sol
- Fuel inj 1
- Fuel inj 2
- Fuel inj 3
- Fuel inj 4
- Fuel inj 5
- Fuel inj 6
- Fuel inj 7
- Fuel inj 8
- Fuel pump ctrl
- Fuse 10a
- Fuse 15a
- Fuse panel
- G101 (right fender apron, right side of battery)
- H02s heater ctrl
- Heated oxygen sensor 11 (near top of transmission)
- Heated oxygen sensor 12 (near rear of transmission)
- Heated oxygen sensor 21 (near left side of transmission)
- Hot at all times
- Hot in run or start
- Iac sol
- Lf ho2s sig
- Maf sens in
- Mass air flow sensor (right front side of engine compartment)
- Misfire in
- Nca
- Power
- Power gnd
- Powertrain control module (top left side of firewall)
- Pwr gnd
- Red
- Ref volt
- Rf ho2s sig
- S106
- S122
- S123
- S146
- S215
- S236
- Sig rtn
- Tan
- Tan/red
- Tcc sol
- Tp sens in
- Tr sens in
- Trans ctrl ind
- Trans- mission control switch
- Transmission range sensor (lower left side of transmission)
- Vapor valve
- Vss (+)
5.8L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford Cab & Chassis F350 1997
List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford Cab & Chassis F350 1997:
- #1 shift solenoid
- #2 shift solenoid
- (behind bottom of right kick panel) g203
- (engine control sensor harness, near breakout near breakout to pcm)
- (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
- (fuel charge harness, near breakout to distributor)
- (left rear of engine compt, on bracket) data link connector
- (left side of firewall) powertrain control module
- (low range indicator)
- (main harness, near breakout to clutch pedal position switch or jumper)
- (right front of engine compt, on fender apron)
- (top left side of brake/ clutch pedal support)
- (top of upper left radiator support)
- A/c demand sig
- A/c system
- Accs
- Air conditioning system
- Airb solnd ctrl
- Aird solnd ctrl
- Boo
- Brake on/off (boo) switch
- C198
- C250
- C251
- Ccs
- Ckp sensor
- Coast clutch solenoid
- Coil
- Coil wire
- Cse gnd
- Distributor
- E40d transmission
- Ect
- Egr cntrl solnd.
- Egr valve pos
- Electronic pres- sure control solenoid
- Engine compartment fuse box
- Epc
- Evap can solnd.
- Fp enable
- Fpm
- Fuse 13 15a
- Fuse 17 10a
- Fuse 22 20a
- Fuse 30a
- Fuse panel
- G101
- G104 (rear of left fender apron)
- G108
- Gnd
- Ho2s ground
- Ho2s sig input
- Hot at all times
- Hot in run or start
- Hot in start or run
- Iac
- Iat
- Idm
- Idm (fto)
- Ign gnd
- Ignition coil (left rear of engine)
- Ignition control module (left rear of engine compartment, on fender apron)
- Inj 1, 4, 5, 8
- Inj 2, 3, 6, 7
- Instrument cluster
- Instrument cluster system
- Kapwr
- Low range ind
- Malfunction indicator
- Map sensor input
- Nca
- Pcm power diode
- Pcm power relay
- Pip
- Pnk
- Pwr
- Pwr gnd
- Radio capacitor (left side of engine, near ignition coil)
- Red
- S102
- S106
- S136
- S145
- S148
- S169
- S171
- S199
- S215
- S216
- S236
- S240
- S246 (main harness, near breakout to speed control amplifier)
- Sig rtn
- Speed control servo/amplifier assembly (near master cylinder)
- Spout
- Spout check connector (left rear of engine compt, taped to harness, near ignition control module)
- Sto/mil
- Tan
- Tcc
- Tcil
- Tcs
- Tft sensor input
- Torque con- verter clutch solenoid
- Tps input
- Tr sensor input
- Transmission fluid temp sensor
- Tss 1
- Tss 2
- Vip dlc
- Vpwr
- Vref
- Vss ground
- Vss signal input
5.8L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford Cab & Chassis F350 1997
List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
- (engine control sensor harness, near breakout to left head- lamp)
- (engine control sensor harness, near breakout to powertrain control module)
- (fuel charge harn, near breakout to fuel inj 5)
- (fuel charge harn, near breakout to fuel inj 8)
- (fuel charge harness, near breakout to air charge temperature solenoid)
- (fuel charge harness, near breakout to canister purge solenoid)
- (fuel charge harness, near breakout to fuel injector 3)
- (not used)
- (on upper left radiator support) g108
- (on upper radiator support)
- 5.8l
- 7.5l
- A/t
- C199
- Data link connector (left rear of engine compt, on bracket)
- Egr control solenoid (on ignition coil support bracket)
- Egr valve position sensor (top right front of engine)
- Engine compart- ment fuse box
- Engine compartment fuse box
- Engine coolant temperature sensor (5.8l - on thermostat housing) (7.5l - on left side of distributor)
- Evap canister purge solenoid (right front of engine)
- Front tank fuel pump/ fuel gauge sender
- Fuel injectors
- Fuel pump relay
- Fuel tank selector switch
- Fuse 16 20a
- Fuse 5 15a
- G108
- Heated oxygen sensor no.11 (near top of trans)
- Hot at all times
- Hot in run
- Idle air control valve (top of throttle body)
- Inertia fuel shut-off switch (behind right kick panel)
- Intake air temperature sensor (top center front of engine, near intake runner #6)
- M/t
- Manifold absolute pressure sensor (top right side of firewall)
- Nca
- Rear tank fuel pump/ fuel gauge sender
- Red
- S102
- S122
- S134
- S135
- S137
- S146
- S149
- S151
- S159
- S160
- S163
- S165
- S400
- Secondary air injection bypass solenoid (7.5l) (near rear of left valve cover)
- Secondary air injection diverter solenoid (near rear of left valve cover)
- Starting/ charging system
- Tan
- Tcil
- Throttle position sensor (top right front of engine, on throttle body)
- Transmission control switch
- Transmission range sensor (left side of transmission)
7.3L
7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (1 of 3) for Ford Cab & Chassis F350 1997
List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (1 of 3) for Ford Cab & Chassis F350 1997:
- "wait to start" indicator
- (engine control sensor harness, near breakout to brake warning resistor/ diode assembly)
- (engine control sensor harness, near breakout to pcm)
- (in main harness, near breakout to lower center of dash)
- (left side of firewall)
- (power lumbar/bolster harness, near breakout to lower center of dash)
- 4x4 hi/low indicator switch (front of transfer case)
- Acc
- Aux rpm input
- Auxiliary powertrain control connector (center of dash)
- Brake press sw
- Brake warning ind
- C250
- C251
- Cam pos sens
- Ccs
- Cruise control system
- Data link connector (behind lower center of dash)
- Diesel warning lamps display
- Dlc
- Ebp
- Engine compartment fuse box
- Engine oil temperature (eot) sensor (front top of engine)
- Eot
- Fuse 10a
- Fuse 15a
- Fuse 20a
- Fuse 30a
- Fuse 3a
- Fuse panel
- G104 (rear of left fender apron)
- G108 (left front of engine compart- ment, on upper radiator support)
- Glow plug relay
- Gnd
- Hot at all times
- Hot in run
- Hot in run or start
- Iat
- Idle validation sw
- Idle validation switch (open at idle) (near accele- rator pedal)
- Idm relay
- Ignition switch
- Injection pressure regulator (ipr) (top center of engine)
- Instrument cluster
- Instrument cluster system
- Intake air temper- ature (iat) sensor (top center of engine)
- Lock
- Low range 4x4 sw
- Malfunction indicator lamp (mil)
- Nca
- Off
- Pcm dlc
- Pcm power diode
- Pcm power relay
- Power take-off feed
- Powertrain control module (pcm)
- Pto feed
- Pwr gnd
- Red
- Run
- S101
- S105
- S125
- S157
- S166 (engine control sensor harness, near breakout to pcm)
- S174
- S206
- S215
- S241
- S243
- Speed ctrl gnd
- Ss1
- Start
- Tachometer
- Tcil
- Tcs
- Tft
- Vss gnd
7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (2 of 3) for Ford Cab & Chassis F350 1997
List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (2 of 3) for Ford Cab & Chassis F350 1997:
- (engine control harness, near breakout to engine compt fuse box)
- (engine control sensor harness, near breakout to left headlamp)
- (engine control sensor harness, near breakout to starter relay)
- (left front of engine compartment, on radiator support)
- (left side of firewall)
- A/c cyl press sw
- Accelerator pedal position sensor (under left side of dash)
- Accl pdl pos sens
- Air conditioning system
- Baro
- Barometric pressure (baro) sensor (below dash, at base of steering column)
- Boo
- C252
- Camshaft position (cmp) sensor (front center of engine)
- Cid sig
- Cmp rtn
- Cruise control system
- Epc
- Epr
- Exhaust back pressure (ebp) sensor (right side of engine)
- Exhaust pressure regulator (epr) (top center of engine)
- Fuel delivery sig
- G108
- G203 (behind bottom of right kick panel)
- Glow plug ctrl
- Gnd
- Icp
- Idm enable out
- Idm sig in
- Injection control pressure (icp) sensor (top left side of engine)
- Instrument cluster
- Ipr
- Kapwr
- Manifold absolute pressure (map) sensor (top right side of firewall)
- Map
- Nca
- Powertrain control module (pcm)
- Programmable speedometer/ odometer module
- Pwr gnd
- Red
- S106
- S126
- S129 (pia harness, in breakout to ect)
- S163
- S164
- S192
- S216
- S235 (main harn, in breakout to throttle position sensor)
- Sig rtn
- Speed ctrl gnd
- Tcc
- Tcil
- Tcs
- Tr sensor
- Transmission control switch
- Vpwr
- Vref
- Vss
- Vss out
- Wait to start out
7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (3 of 3) for Ford Cab & Chassis F350 1997
List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (3 of 3) for Ford Cab & Chassis F350 1997:
- #1 shift solenoid
- #2 shift solenoid
- (backup lamp switch to rear lamp feed harness, in breakout)
- (in pia harn)
- (left side of engine compartment)
- (main harness, near breakout to clutch pedal position switch or jumper)
- (pia harness, near breakout to fuel charge pump motor)
- (pia harness, near breakout to fuel charge pump motor) s141
- Brake on/off (boo) switch (on bracket, above brake pedal)
- Cid sig in
- Coast clutch solenoid
- E4od transmission
- Electronic pressure control solenoid
- Engine compart- ment fuse box
- Fuel delivery sig
- Fuel inj feed left
- Fuel inj feed right
- Fuel injector #1
- Fuel injector #2
- Fuel injector #3
- Fuel injector #4
- Fuel injector #5
- Fuel injector #6
- Fuel injector #7
- Fuel injector #8
- Fuel injectors/ glow plugs (1,3)
- Fuel injectors/ glow plugs (2,4)
- Fuel injectors/ glow plugs (5,7)
- Fuel injectors/ glow plugs (6,8)
- Fuel line heater (right side of engine, on top of fuel filter/heater)
- Fuse 15a
- Fuse 30a
- Fuse panel
- Glow plug relay (top center rear of engine)
- Hot at all times
- Hot in run or start
- Idm feedback sig
- Inj shield gnd
- Injector driver module (idm)
- Nca
- Pwr gnd
- Red
- S112
- S113
- S128
- S142
- S143
- S146
- S236
- S240
- Sig rtn
- Tan
- Tan/red
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Transmission range (tr) sensor
- Vpwr
7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (1 of 3) for Ford Cab & Chassis F350 1997
List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (1 of 3) for Ford Cab & Chassis F350 1997:
- "wait to start" indicator
- (a/t)
- (engine control sensor harness, near breakout to brake warning resistor/ diode assembly)
- (engine control sensor harness, near breakout to pcm)
- (in main harness, near breakout to lower center of dash)
- (left side of firewall)
- (m/t)
- (power lumbar/bolster harness, near breakout to center of dash)
- 4x4 hi/low indicator switch (front of transfer case)
- A/t
- Acc
- Aux rpm input
- Auxiliary powertrain control connector (center of dash)
- Brake press sw
- Brake warning ind
- C250
- C251
- Clutch pedal position switch (top right side of brake/clutch pedal support)
- Cruise control system
- Data link connector (behind lower center of dash)
- Diesel warning lamps display
- Dlc
- Ebp
- Engine compartment fuse box
- Engine oil temperature (eot) sensor (front top of engine)
- Eot
- Fuse 10a
- Fuse 15a
- Fuse 20a
- Fuse 30a
- Fuse 3a
- Fuse panel
- G104 (rear of left fender apron)
- G108 (left front of engine compart- ment, on upper radiator support)
- Gnd
- Hot at all times
- Hot in run
- Hot in run or start
- Iat
- Idle validation sw
- Idle validation switch (open at idle) (near accele- rator pedal)
- Idm relay
- Ignition switch
- Injection pressure regulator (ipr) (top center of engine)
- Instrument cluster
- Instrument cluster system
- Intake air temper- ature (iat) sensor (top center of engine)
- Lock
- Low range 4x4 sw
- M/t
- Malfunction indicator lamp (mil)
- Map
- Nca
- Off
- Pcm dlc
- Pcm power diode
- Pcm power relay
- Power take-off feed
- Powertrain control module (pcm)
- Pto feed
- Pwr gnd
- Red
- Run
- S101
- S105
- S125
- S157
- S166 (engine control sensor harness, near breakout to pcm)
- S174
- S206
- S215
- S241
- S242
- S243
- Speed ctrl gnd
- Ss1
- Ss2
- Start
- Tcc
- Tcs or cpp
- Tft
- Vss gnd
7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (2 of 3) for Ford Cab & Chassis F350 1997
List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (2 of 3) for Ford Cab & Chassis F350 1997:
-
-
- (engine control sensor harness, near breakout to engine compartment fuse box)
- (engine control sensor harness, near breakout to left headlamp)
- (engine control sensor harness, near breakout to starter relay)
- (left front of engine compartment, on radiator support)
- (left side of firewall)
- A/c cyl press sw
- Accelerator pedal position sensor (under left side of dash)
- Accl pdl pos sens
- Air conditioning system
- Baro
- Barometric pressure (baro) sensor (below dash, at base of steering column)
- Boo
- C252
- Cam pos sens
- Camshaft position (cmp) sensor (front center of engine)
- Ccs
- Cid sig
- Cmp rtn
- Cruise control system
- Epc
- Epr
- Exhaust back pressure (ebp) sensor (right side of engine)
- Exhaust pressure regulator (epr) (top center of engine)
- Fuel delivery sig
- G108
- G203 (behind bottom of right kick panel)
- Glow plug ctrl
- Gnd
- Icp
- Idm enable out
- Idm sig in
- Injection control pressure (icp) sensor (top left side of engine)
- Instrument cluster
- Instrument cluster system
- Ipr
- Kapwr
- Manifold absolute pressure (map) sensor (top right side of firewall)
- Nca
- Powertrain control module (pcm)
- Programmable speedometer/ odometer module
- Pwr gnd
- Red
- S106
- S126
- S129 (pia harness, in breakout to ect)
- S163
- S164
- S192
- S216
- S235 (main harness, in breakout to throttle position sensor)
- Sig rtn
- Speed ctrl gnd
- Tachometer
- Tcil
- Tcs
- Tr sensor
- Transmission control switch
- Vpwr
- Vref
- Vss
- Vss out
- Wait to start out
7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (3 of 3) for Ford Cab & Chassis F350 1997
List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (3 of 3) for Ford Cab & Chassis F350 1997:
- #1 shift solenoid
- #2 shift solenoid
- (backup lamp switch to rear lamp feed harness, in breakout to transmission)
- (left side of engine compartment)
- (main harness, near breakout to clutch pedal position switch or jumper)
- (pia harness, near breakout to fuel charge pump motor)
- (pia harness, near breakout to fuel charge pump motor) s141
- Brake on/off (boo) switch (brake/clutch pedal support)
- Cid sig in
- Coast clutch solenoid
- E4od transmission
- Electronic pressure control solenoid
- Engine compart- ment fuse box
- Fuel delivery sig
- Fuel inj feed left
- Fuel inj feed right
- Fuel injector #1
- Fuel injector #2
- Fuel injector #3
- Fuel injector #4
- Fuel injector #5
- Fuel injector #6
- Fuel injector #7
- Fuel injector #8
- Fuel injectors/ glow plugs (1,3)
- Fuel injectors/ glow plugs (2,4)
- Fuel injectors/ glow plugs (5,7)
- Fuel injectors/ glow plugs (6,8)
- Fuel line heater (right side of engine, on top of fuel filter/heater)
- Fuse 15a
- Fuse 30a
- Fuse panel
- Glow plug relay (top center rear of engine)
- Hot at all times
- Hot in run or start
- Idm feedback sig
- Inj shield gnd
- Injector driver module (idm)
- Nca
- Pwr gnd
- Red
- S112 (in pia harn)
- S113 (in pia harn)
- S128
- S142
- S143
- S146
- S236
- S240
- Sig rtn
- Tan
- Tan/red
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Transmission range (tr) sensor
- Vpwr
7.5L
7.5L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford Cab & Chassis F350 1997
List of elements for 7.5L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, near brake warning resistor/diode assembly) s136
- (engine control sensor harness, near breakout to pcm)
- (fuel charge harness, near breakout to distributor)
- (fuel charge harness, near breakout to ignition coil)
- (low range indicator)
- A/c clutch sig
- Air conditioning system
- Aird solenoid
- Bbp feed
- Body builder power feed
- Case gnd
- Ckp sensor
- Coil
- Data link (+)
- Data link (-)
- Data link connector (right side of dash)
- Data link feps
- Distributor (top front of engine)
- Distributor ignition shield
- Ect sens
- Egr solnd ctrl
- Engine compartment fuse box
- Fuel pump mon
- Fuse 20a
- Fuse 30a
- G104 (rear of left fender apron)
- G108 (left front radiator support)
- G203 (right kick panel)
- Hot at all times
- Hot in start or run
- Iat sens
- Idm
- Idm (fto)
- Ign gnd
- Ignition coil (left side of engine, above valve cover)
- Ignition control module (left rear side of engine compartment, on fender apron)
- Instrument cluster system
- Low rnge 4x4
- Maf sig rtn
- Mil
- Misfire sens
- Nca
- Pcm power diode
- Pcm power relay
- Pip
- Pnk
- Power
- Powertrain control module (top left side of firewall)
- Pwr gnd
- Pwr grd
- Radio capacitor (left side of engine, near coil)
- Red
- Red/
- Rr ho2s sig
- S102
- S104
- S145
- S148
- S171
- S199
- S216
- Spout
- Spout check connector (left rear of engine compartment, near icm)
- Trans ctrl sw
- Trans temp
- Tss 1
- Tss 2
- Vss (-)
7.5L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford Cab & Chassis F350 1997
List of elements for 7.5L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford Cab & Chassis F350 1997:
- (fuel charge harness, near breakout to fuel injector 3)
- C250
- C251
- C252
- Delta pressure feedback egr sensor (5.8l - on top right front of of engine) (7.5l - on lrft side of throttle body)
- Engine compartment fuse box
- Engine coolant temperature sensor (left front of engine, near distributor)
- Fuel pump relay
- Fuse 20a
- Hot at all times
- Instrument cluster
- Intake air temperature sensor (top center of engine, behind distributor)
- Malfunction indicator input
- Misfire sensor (center front of engine, on timing chain cover)
- Misfire sensor shield
- Nca
- Psom vehicle speed output
- Red
- Rpm input
- S135 (fuel charge harness, near breakout to canister purge solenoid)
- S151
- S246 (main harness, near breakout to speed control amplifier)
- Throttle position sensor (top left front of engine, on throttle body)
7.5L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford Cab & Chassis F350 1997
List of elements for 7.5L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
- (fuel charge harness, near breakout to act solenoid)
- (fuel charge harness, near breakout to fuel injector 3)
- (not used)
- 5.8l
- 7.5l
- Coast clutch solenoid
- E4od transmission
- Egr control solenoid (5.8l - on ignition coil support bracket) (7.5l - in left side of engine compt)
- Electronic pressure control solenoid
- Front tank fuel pump/ fuel gauge sender
- Fuel tank selector switch
- G108 (on upper left radiator support)
- Idle air control valve (on throttle body)
- Inertia fuel shut-off switch (behind right kick panel)
- Injectors fuel
- Nca
- Rear tank fuel pump/ fuel gauge sender
- Red
- S137
- S149
- S151
- S169
- S400
- Secondary air injection bypass (airb) solenoid (7.5l) (near ignition coil)
- Secondary air injection diverter (aird) solenoid (7.5l) (rear of left valve cover)
- Shift solenoids
- Ss1
- Ss2
- Tan
- Tan/ red
- Tan/red
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Vapor management valve (center of engine)
7.5L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford Cab & Chassis F350 1997
List of elements for 7.5L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, in breakout to engine compt. fuse panel box)
- (engine control sensor harness, near breakout to pcm)
- (main harness, near breakout to clutch pedal position switch or jumper) s240
- (not used)
- 5.8l
- 7.5l
- Airb solenoid
- Batt
- Brake on/off
- Brake on/off (boo) switch (on bracket, above brake pedal)
- Coast clutch
- Dpfe sens
- Epc sol
- Fuel inj 1
- Fuel inj 2
- Fuel inj 3
- Fuel inj 4
- Fuel inj 5
- Fuel inj 6
- Fuel inj 7
- Fuel inj 8
- Fuel pump ctrl
- Fuse 10a
- Fuse 15a
- Fuse panel
- G101 (right fender apron, right side of battery)
- H02s heater ctrl
- Heated oxygen sensor 11 (near top of transmission)
- Heated oxygen sensor 12 (near rear of transmission)
- Heated oxygen sensor 21 (near left side of transmission)
- Hot at all times
- Hot in run or start
- Iac sol
- Lf ho2s sig
- Maf sens in
- Mass air flow sensor (right front side of engine compartment)
- Misfire in
- Nca
- Power
- Power gnd
- Powertrain control module (top left side of firewall)
- Pwr gnd
- Red
- Ref volt
- Rf ho2s sig
- S106
- S122
- S123
- S146
- S215
- S236
- Sig rtn
- Tan
- Tan/red
- Tcc sol
- Tp sens in
- Tr sens in
- Trans ctrl ind
- Trans- mission control switch
- Transmission range sensor (lower left side of transmission)
- Vapor valve
- Vss (+)
7.5L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford Cab & Chassis F350 1997
List of elements for 7.5L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford Cab & Chassis F350 1997:
- #1 shift solenoid
- #2 shift solenoid
- (behind bottom of right kick panel) g203
- (engine control sensor harness, near breakout near breakout to pcm)
- (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
- (fuel charge harness, near breakout to distributor)
- (left rear of engine compt, on bracket) data link connector
- (left side of firewall) powertrain control module
- (low range indicator)
- (main harness, near breakout to clutch pedal position switch or jumper)
- (right front of engine compt, on fender apron)
- (top left side of brake/ clutch pedal support)
- (top of upper left radiator support)
- A/c demand sig
- A/c system
- Accs
- Air conditioning system
- Airb solnd ctrl
- Aird solnd ctrl
- Boo
- Brake on/off (boo) switch
- C198
- C250
- C251
- Ccs
- Ckp sensor
- Coast clutch solenoid
- Coil
- Coil wire
- Cse gnd
- Distributor
- E40d transmission
- Ect
- Egr cntrl solnd.
- Egr valve pos
- Electronic pres- sure control solenoid
- Engine compartment fuse box
- Epc
- Evap can solnd.
- Fp enable
- Fpm
- Fuse 13 15a
- Fuse 17 10a
- Fuse 22 20a
- Fuse 30a
- Fuse panel
- G101
- G104 (rear of left fender apron)
- G108
- Gnd
- Ho2s ground
- Ho2s sig input
- Hot at all times
- Hot in run or start
- Hot in start or run
- Iac
- Iat
- Idm
- Idm (fto)
- Ign gnd
- Ignition coil (left rear of engine)
- Ignition control module (left rear of engine compartment, on fender apron)
- Inj 1, 4, 5, 8
- Inj 2, 3, 6, 7
- Instrument cluster
- Instrument cluster system
- Kapwr
- Low range ind
- Malfunction indicator
- Map sensor input
- Nca
- Pcm power diode
- Pcm power relay
- Pip
- Pnk
- Pwr
- Pwr gnd
- Radio capacitor (left side of engine, near ignition coil)
- Red
- S102
- S106
- S136
- S145
- S148
- S169
- S171
- S199
- S215
- S216
- S236
- S240
- S246 (main harness, near breakout to speed control amplifier)
- Sig rtn
- Speed control servo/amplifier assembly (near master cylinder)
- Spout
- Spout check connector (left rear of engine compt, taped to harness, near ignition control module)
- Sto/mil
- Tan
- Tcc
- Tcil
- Tcs
- Tft sensor input
- Torque con- verter clutch solenoid
- Tps input
- Tr sensor input
- Transmission fluid temp sensor
- Tss 1
- Tss 2
- Vip dlc
- Vpwr
- Vref
- Vss ground
- Vss signal input
7.5L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford Cab & Chassis F350 1997
List of elements for 7.5L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford Cab & Chassis F350 1997:
- (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
- (engine control sensor harness, near breakout to left head- lamp)
- (engine control sensor harness, near breakout to powertrain control module)
- (fuel charge harn, near breakout to fuel inj 5)
- (fuel charge harn, near breakout to fuel inj 8)
- (fuel charge harness, near breakout to air charge temperature solenoid)
- (fuel charge harness, near breakout to canister purge solenoid)
- (fuel charge harness, near breakout to fuel injector 3)
- (not used)
- (on upper left radiator support) g108
- (on upper radiator support)
- 5.8l
- 7.5l
- A/t
- C199
- Data link connector (left rear of engine compt, on bracket)
- Egr control solenoid (on ignition coil support bracket)
- Egr valve position sensor (top right front of engine)
- Engine compart- ment fuse box
- Engine compartment fuse box
- Engine coolant temperature sensor (5.8l - on thermostat housing) (7.5l - on left side of distributor)
- Evap canister purge solenoid (right front of engine)
- Front tank fuel pump/ fuel gauge sender
- Fuel injectors
- Fuel pump relay
- Fuel tank selector switch
- Fuse 16 20a
- Fuse 5 15a
- G108
- Heated oxygen sensor no.11 (near top of trans)
- Hot at all times
- Hot in run
- Idle air control valve (top of throttle body)
- Inertia fuel shut-off switch (behind right kick panel)
- Intake air temperature sensor (top center front of engine, near intake runner #6)
- M/t
- Manifold absolute pressure sensor (top right side of firewall)
- Nca
- Rear tank fuel pump/ fuel gauge sender
- Red
- S102
- S122
- S134
- S135
- S137
- S146
- S149
- S151
- S159
- S160
- S163
- S165
- S400
- Secondary air injection bypass solenoid (7.5l) (near rear of left valve cover)
- Secondary air injection diverter solenoid (near rear of left valve cover)
- Starting/ charging system
- Tan
- Tcil
- Throttle position sensor (top right front of engine, on throttle body)
- Transmission control switch
- Transmission range sensor (left side of transmission)