ENGINE PERFORMANCE
4.6L
4.6L, Engine Performance Wiring Diagram (1 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for 4.6L, Engine Performance Wiring Diagram (1 of 4) for Ford Expedition 2004:
- (engine sensor harn, near breakout to therostatic expansion valve switch assy) s110
- (engine sensor harn, near breakout to therostatic expansion valve switch assy) s111
- (left b-pillar) g300
- (right rear of engine compt)
- A/c clu rly ctrl
- A/c system
- Ac term signal
- Acc
- Anti-theft system
- Battery
- Bps switch output
- C175b
- C270a
- C270b
- C270d
- C270f
- C270g
- C270k
- Canister vent
- Central junction box (right kick panel)
- Charging system
- Cruise control system
- Data link connector (under driver side dash panel)
- Electronic suspension, navigation, wiper/washer, and sound systems (vehicle speed signal)
- Evap valve
- F pump rly ctrl
- Fuel pump assembly (fuel tank)
- Fuel pump relay
- Fuel tank pressure transducer sensor (in fuel tank)
- Fuse
- Fuse 10a
- Fuse 15a
- Fuse 7.5a
- G102
- Gen comm cir
- Gen monitor
- Ground
- Hot at all times
- Hot in run or start
- Iat input
- Ignition switch
- Inertia fuel shut-off switch (left rear corner of cargo area)
- Instrument cluster system
- Lock
- Maf output
- Maf sig rtn
- Module prog sig
- Nca
- Od cancel sw
- Off
- Overdrive cancel switch
- Pcm power diode
- Pcm power relay
- Powertrain control module (right side of firewall)
- Pres sensor
- Red
- Red/pnk
- Ref voltage
- Run
- Rx sig
- S108
- S133
- S203
- S454
- Scp -
- Scp bus +
- Servo common
- Servo sig a
- Servo sig b
- Servo sig c
- Signal return
- Spd ctrl sw in
- St and run sig
- St rly ctrl
- St whl ctrl gnd
- Start
- Starting system
- Sw power out
- Tan
- Theft ind ctrl
- Tps signal
- Transmission system
- Tx sig
- Vss+
4.6L, Engine Performance Wiring Diagram (2 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 4.6L, Engine Performance Wiring Diagram (2 of 4) for Ford Expedition 2004:
- (above rear axle) evap canister vent control solenoid
- (engine crtl harn, near breakout to intake air temperature sensor) s125
- Coils on plug
- Crankshaft position sensor (lower front of engine)
- Differential pressure feedback egr (dpfe) sensor (top left side of engine)
- G102 (right rear of engine compt)
- Ignition trans- former capacitor 1 (top right front of engine)
- Ignition trans- former capacitor 2 (top left front of engine)
- Inlet manifold runner control module (4.6l) (top front of engine)
- Intake air temperature (iat) sensor (in intake system)
- Mass airflow (maf) sensor (in intake system)
- Nca
- Red
- S108
- S124
- S127 (engine ctrl harn, near breakout to fuel injector 7)
- S129
- S132
- Throttle position (tp) sensor (on throttle body)
4.6L, Engine Performance Wiring Diagram (3 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 4.6L, Engine Performance Wiring Diagram (3 of 4) for Ford Expedition 2004:
- (left rear of engine compt)
- 4r70w transmission
- A/c system
- Egr vacuum regulator solenoid (left side of engine)
- Electronic pressure control solenoid
- Fuel injectors
- Idle air control (iac) valve (on throttle body)
- Output shaft speed (oss) sensor (rear of transmission)
- Red
- S105 (eng cntl harn, near breakout to brake fluid level switch)
- S109 (eng ctrl sensor harn, near breakout to thermostatic expansion valve switch assy)
- S126 (eng ctrl sensor harn, near breakout to idle air control valve)
- S131 (eng ctrl sensor harn, near breakout to ign capacitor 2)
- Shift solenoids
- Tan
- Tan/ red
- Tan/red
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Vapor management valve
4.6L, Engine Performance Wiring Diagram (4 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 4.6L, Engine Performance Wiring Diagram (4 of 4) for Ford Expedition 2004:
- (left front of engine) cylinder head temperature (cht) sensor
- (near breakout to h02s 11)
- (near breakout to pcm)
- (pins 4-10 not used)
- (rear of engine) knock sensor (4.6l)
- (right rear of engine) knock sensor (5.4l)
- 4.6l
- 5.4l
- C175e
- C175t
- Camshaft position sensor (on front of left cyl head)
- Ckp +
- Ckp -
- Cmp input
- Cop 1 ctrl
- Cop 2 ctrl
- Cop 3 ctrl
- Cop 4 ctrl
- Cop 5 ctrl
- Cop 6 ctrl
- Cop 7 ctrl
- Cop 8 ctrl
- Cyl head tmp sns
- Digital transmission range sensor (left side of transmission)
- Dpfe input
- Dtr, tr1
- Dtr, tr2
- Dtr, tr3a
- Dtr, tr4
- Early production
- Epc sol ctrl
- Evr ctrl
- Heated oxygen sensor (ho2s) 11 (on right exhaust downpipe)
- Heated oxygen sensor (ho2s) 12 (on rear of exhaust system)
- Heated oxygen sensor (ho2s) 21 (on left exhaust downpipe)
- Heated oxygen sensor (ho2s) 22 (on rear of exhaust system)
- Ho2s 11 htr
- Ho2s 11 input
- Ho2s 12 htr
- Ho2s 12 input
- Ho2s 21 htr
- Ho2s 21 input
- Ho2s 22 htr
- Ho2s 22 input
- Iac ctrl
- Imrc module
- Inj 1 ctrl
- Inj 2 ctrl
- Inj 3 ctrl
- Inj 4 ctrl
- Inj 5 ctrl
- Inj 6 ctrl
- Inj 7 ctrl
- Inj 8 ctrl
- Ks 1 +
- Ks 1 -
- Ks 2 +
- Ks 2 -
- Nca
- Oss sensor
- Powertrain control module (right side of firewall)
- R n
- Reference voltage
- S128
- S138
- S140
- Shift sol a
- Shift sol b
- Signal return
- Tan
- Tan/red
- Tcc solenoid
- Tft input
- Tps input
5.4L
5.4L, Engine Performance Wiring Diagram (1 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 5.4L, Engine Performance Wiring Diagram (1 of 4) for Ford Expedition 2004:
- (engine sensor harn, near breakout to therostatic expansion valve switch assy) s110
- (engine sensor harn, near breakout to therostatic expansion valve switch assy) s111
- (left b-pillar) g300
- (right rear of engine compt)
- A/c clu rly ctrl
- A/c system
- Ac term signal
- Acc
- Anti-theft system
- Battery
- Bps switch output
- C175b
- C270a
- C270b
- C270d
- C270f
- C270g
- C270k
- Canister vent
- Central junction box (right kick panel)
- Charging system
- Cruise control system
- Data link connector (under driver side dash panel)
- Electronic suspension, navigation, wiper/washer, and sound systems (vehicle speed signal)
- Evap valve
- F pump rly ctrl
- Fuel pump assembly (fuel tank)
- Fuel pump relay
- Fuel tank pressure transducer sensor (in fuel tank)
- Fuse
- Fuse 10a
- Fuse 15a
- Fuse 7.5a
- G102
- Gen comm cir
- Gen monitor
- Ground
- Hot at all times
- Hot in run or start
- Iat input
- Ignition switch
- Inertia fuel shut-off switch (left rear corner of cargo area)
- Instrument cluster system
- Lock
- Maf output
- Maf sig rtn
- Module prog sig
- Nca
- Od cancel sw
- Off
- Overdrive cancel switch
- Pcm power diode
- Pcm power relay
- Powertrain control module (right side of firewall)
- Pres sensor
- Red
- Red/pnk
- Ref voltage
- Run
- Rx sig
- S108
- S133
- S203
- S454
- Scp -
- Scp bus +
- Servo common
- Servo sig a
- Servo sig b
- Servo sig c
- Signal return
- Spd ctrl sw in
- St and run sig
- St rly ctrl
- St whl ctrl gnd
- Start
- Starting system
- Sw power out
- Tan
- Theft ind ctrl
- Tps signal
- Transmission system
- Tx sig
- Vss+
5.4L, Engine Performance Wiring Diagram (2 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 5.4L, Engine Performance Wiring Diagram (2 of 4) for Ford Expedition 2004:
- (above rear axle) evap canister vent control solenoid
- (engine crtl harn, near breakout to intake air temperature sensor) s125
- Coils on plug
- Crankshaft position sensor (lower front of engine)
- Differential pressure feedback egr (dpfe) sensor (top left side of engine)
- G102 (right rear of engine compt)
- Ignition trans- former capacitor 1 (top right front of engine)
- Ignition trans- former capacitor 2 (top left front of engine)
- Inlet manifold runner control module (4.6l) (top front of engine)
- Intake air temperature (iat) sensor (in intake system)
- Mass airflow (maf) sensor (in intake system)
- Nca
- Red
- S108
- S124
- S127 (engine ctrl harn, near breakout to fuel injector 7)
- S129
- S132
- Throttle position (tp) sensor (on throttle body)
5.4L, Engine Performance Wiring Diagram (3 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 5.4L, Engine Performance Wiring Diagram (3 of 4) for Ford Expedition 2004:
- (left rear of engine compt)
- 4r70w transmission
- A/c system
- Egr vacuum regulator solenoid (left side of engine)
- Electronic pressure control solenoid
- Fuel injectors
- Idle air control (iac) valve (on throttle body)
- Output shaft speed (oss) sensor (rear of transmission)
- Red
- S105 (eng cntl harn, near breakout to brake fluid level switch)
- S109 (eng ctrl sensor harn, near breakout to thermostatic expansion valve switch assy)
- S126 (eng ctrl sensor harn, near breakout to idle air control valve)
- S131 (eng ctrl sensor harn, near breakout to ign capacitor 2)
- Shift solenoids
- Tan
- Tan/ red
- Tan/red
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Vapor management valve
5.4L, Engine Performance Wiring Diagram (4 of 4) for Ford Expedition 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO קבל גישה לכל מכוניות דיאגרמות החיווטList of elements for 5.4L, Engine Performance Wiring Diagram (4 of 4) for Ford Expedition 2004:
- (left front of engine) cylinder head temperature (cht) sensor
- (near breakout to h02s 11)
- (near breakout to pcm)
- (pins 4-10 not used)
- (rear of engine) knock sensor (4.6l)
- (right rear of engine) knock sensor (5.4l)
- 4.6l
- 5.4l
- C175e
- C175t
- Camshaft position sensor (on front of left cyl head)
- Ckp +
- Ckp -
- Cmp input
- Cop 1 ctrl
- Cop 2 ctrl
- Cop 3 ctrl
- Cop 4 ctrl
- Cop 5 ctrl
- Cop 6 ctrl
- Cop 7 ctrl
- Cop 8 ctrl
- Cyl head tmp sns
- Digital transmission range sensor (left side of transmission)
- Dpfe input
- Dtr, tr1
- Dtr, tr2
- Dtr, tr3a
- Dtr, tr4
- Early production
- Epc sol ctrl
- Evr ctrl
- Heated oxygen sensor (ho2s) 11 (on right exhaust downpipe)
- Heated oxygen sensor (ho2s) 12 (on rear of exhaust system)
- Heated oxygen sensor (ho2s) 21 (on left exhaust downpipe)
- Heated oxygen sensor (ho2s) 22 (on rear of exhaust system)
- Ho2s 11 htr
- Ho2s 11 input
- Ho2s 12 htr
- Ho2s 12 input
- Ho2s 21 htr
- Ho2s 21 input
- Ho2s 22 htr
- Ho2s 22 input
- Iac ctrl
- Imrc module
- Inj 1 ctrl
- Inj 2 ctrl
- Inj 3 ctrl
- Inj 4 ctrl
- Inj 5 ctrl
- Inj 6 ctrl
- Inj 7 ctrl
- Inj 8 ctrl
- Ks 1 +
- Ks 1 -
- Ks 2 +
- Ks 2 -
- Nca
- Oss sensor
- Powertrain control module (right side of firewall)
- R n
- Reference voltage
- S128
- S138
- S140
- Shift sol a
- Shift sol b
- Signal return
- Tan
- Tan/red
- Tcc solenoid
- Tft input
- Tps input