ENGINE PERFORMANCE
4.0L
4.0L, Engine Performance Wiring Diagram (1 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for 4.0L, Engine Performance Wiring Diagram (1 of 4) for Ford Explorer 2004:
- (near breakout to a/c clutch cycling press sw)
- (near breakout to left horn) s168
- (near breakout to left side of dash)
- (near breakout to right wheel speed sensor) s129
- A/c sw
- A/c system
- Ac demand
- Accelerator pedal position sensor (under left side of dash)
- Anti theft system
- Anti-theft system
- Audio unit
- Battery junction box (left side of engine compt)
- Brake in
- Brake pressure switch (mounted on master cylinder)
- C1117
- C175b
- C240a
- C290a
- Can bus +
- Can bus -
- Can vent
- Charging system
- Control module)
- Cruise control system
- Data link connector (behind left side of dash)
- Dr ajar
- Evap pu
- Evaporative emission (evap) canister vent valve (right rear of vehicle)
- Feps
- Fpm
- Fuse 15a
- Fuse 20a
- Fuse 2a
- Fuse 40a
- G101 (left front of engine compt)
- G103 (right front of engine compt)
- G104 (right rear of engine compt)
- G105 (right rear of eng compt)
- Ground
- Hot at all times
- Hot in run or start
- Iat in
- Ind ctrl
- J/c 1
- J/c 2
- Maf out
- Mass airflow (maf) sensor (right front of engine compartment)
- Od off
- Passive anti-theft transceiver (on steering column)
- Pcm power diode
- Pcm power relay
- Pos 1
- Pos 2
- Pos 3
- Powertrain control module (at right side engine bulkhead)
- Press sw
- Red
- Red/pnk
- Rtn
- S127 (near breakout to a/c clutch cycling pressure switch)
- S130
- S131 (near breakout to powertrain
- S132
- S209
- S212
- Sens rtn
- Sig ret
- Sig rtn
- Srs
- St mtr
- Starting system
- Tan
- Tank press
- Transmission controls system (4wd circuit)
- Tx sig
- Vapor manage- ment valve (left rear of engine compt)
- Vbatt
- Vpwr
- Vref
- Vss
- W/ 4x4
- W/ audiophile
- W/ ivd
- W/o audiophile
- W/o ivd
- Windshield wiper motor (left rear of engine compt)
4.0L, Engine Performance Wiring Diagram (2 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagram (2 of 4) for Ford Explorer 2004:
- (above brake pedal) brake pedal position switch
- (near breakout to powertrain control module)
- (on lower left of a/t) transmission solenoid body assembly
- Abs control module (left front of engine compt)
- Battery junction box (behind left side of dash)
- C175t
- C270c
- Central junction box (behind left side of dash)
- Fuse 15a
- Fuse 5a
- G103 (right front of engine compt)
- H2os 12 htr
- H2os 12 in
- H2os 22 htr
- H2os 22 in
- Hot at all times
- Hot in run or start
- Iss
- J/c 2 (in battery junction box)
- Nca
- Oss
- Pcs a
- Pcs b
- Pcs c
- Positive crankcase ventilation heater
- Powertrain control module (at right side engine bulkhead)
- Press ctrl sol a
- Press ctrl sol b
- Press ctrl sol c
- Red/pnk
- Redundant pedal switch (under left side of dash)
- S101
- S120 (w/ ivd: near breakout to left horn w/o ivd: near breakout to windshield washer motor)
- S171
- Shift sol a
- Shift sol b
- Shift sol c
- Shift sol d
- Sig rtn
- Ss a
- Ss b
- Ss c
- Ss d
- Tcc sol
- Transmission control switch
- Transmission controls system (4wd circuit)
- Transmission fluid temperature sensor
- Tss
- Turbine shaft speed (tss) sensor (a/t) (top left of trans)
- Vref
- W/ ivd
4.0L, Engine Performance Wiring Diagram (3 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagram (3 of 4) for Ford Explorer 2004:
- (lower left side of transmission) digital transmission range sensor
- (near breakout to digital transmission range sensor) s100
- (near breakout to powertrain control module)
- Battery junction box (left side of engine compt)
- C220b
- C270a
- C270f
- Central junction box (behind left side of dash)
- Flex fuel sender module
- Fuel gauge
- Fuel pump
- Fuel pump relay
- Fuel tank assembly
- Fuel tank pressure transducer sensor
- Fuse 10a
- Fuse 20a
- G101 (left front of engine compt)
- Heated oxygen sensor (ho2s) 11 (in right exhaust pipe before catalytic converter)
- Heated oxygen sensor (ho2s) 12 (in right exhaust pipe, after catalytic converter)
- Heated oxygen sensor (ho2s) 21 (in left exhaust pipe before catalytic converter)
- Heated oxygen sensor (ho2s) 22 (in left exhaust pipe, after catalytic converter)
- Hot at all times
- Hot in run or start
- Inertia fuel shutoff switch (base of right "a" pillar)
- Instrument cluster
- Intermediate shaft speed (iss) sensor (top left side of trans)
- J/c 1 (in battery junction box)
- Micro- processor
- N r
- Nca
- Output shaft speed sensor (left rear of trans) (a/t)
- Red
- Red/pnk
- S102
- S103 (near breakout to heated oxygen sensor)
4.0L, Engine Performance Wiring Diagram (4 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.0L, Engine Performance Wiring Diagram (4 of 4) for Ford Explorer 2004:
- (at right "d" pillar) fuel pump driver module
- (at top of engine) ignition coil
- (at top of engine) ignition transformer capacitor
- (near breakout to differential pressure feedback egr sensor) s105
- (near breakout to heated oxygen sensor) s104
- (near breakout to ignition coil) s134
- (not used)
- (on top rear of engine)
- C175e
- Camshaft position sensor (top front of left cyl head)
- Ckp sens +
- Ckp sens -
- Cmp sens
- Crankshaft position sensor (left front of engine)
- Dfpegr sens
- Ect input
- Egr system module (top of engine)
- Egrvr
- Electronic throttle control motor (at top of engine)
- Engine coolant temperature (ect) sensor (top right of engine)
- Fuel injectors
- Fuel pres
- Fuel rail pressure transducer sensor (top rear of engine)
- G105 (right rear side of engine compt)
- G401 (at right "d" pillar)
- Ho2s 11
- Ho2s 11 htr
- Ho2s 21
- Ho2s 21 htr
- Inj 1
- Inj 2
- Inj 3
- Inj 4
- Inj 5
- Inj 6
- Knock sensor
- Ks 1
- Map
- Nca
- Pcm to coil
- Pcm to t1
- Powertrain control module (at right side engine bulkhead)
- Red/pnk
- Return
- S106
- Sig rtn
- Sig1
- Sig2
- Tan
- Temp
- Throttle position (tps) sensor (top of throttle body)
- V ref
- Vref
4.6L
4.6L, Engine Performance Wiring Diagram (1 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.6L, Engine Performance Wiring Diagram (1 of 4) for Ford Explorer 2004:
- (near breakout to a/c clutch cycling press sw)
- (near breakout to left horn) s168
- (near breakout to left side of dash)
- (near breakout to right wheel speed sensor) s129
- A/c sw
- A/c system
- Ac demand
- Accelerator pedal position sensor (under left side of dash)
- Anti theft system
- Anti-theft system
- Audio unit
- Battery junction box (left side of engine compt)
- Brake in
- Brake pressure switch (mounted on master cylinder)
- C1117
- C175b
- C240a
- C290a
- Can bus +
- Can bus -
- Can vent
- Charging system
- Control module)
- Cruise control system
- Data link connector (behind left side of dash)
- Dr ajar
- Evap pu
- Evaporative emission (evap) canister vent valve (right rear of vehicle)
- Feps
- Fpm
- Fuse 15a
- Fuse 20a
- Fuse 2a
- Fuse 40a
- G101 (left front of engine compt)
- G103 (right front of engine compt)
- G104 (right rear of engine compt)
- G105 (right rear of eng compt)
- Ground
- Hot at all times
- Hot in run or start
- Iat in
- Ind ctrl
- J/c 1
- J/c 2
- Maf out
- Mass airflow (maf) sensor (right front of engine compartment)
- Od off
- Passive anti-theft transceiver (on steering column)
- Pcm power diode
- Pcm power relay
- Pos 1
- Pos 2
- Pos 3
- Powertrain control module (at right side engine bulkhead)
- Press sw
- Red
- Red/pnk
- Rtn
- S127 (near breakout to a/c clutch cycling pressure switch)
- S130
- S131 (near breakout to powertrain
- S132
- S209
- S212
- Sens rtn
- Sig ret
- Sig rtn
- St mtr
- Starting system
- Tan
- Tank press
- Transmission controls system (4wd circuit)
- Tx sig
- Vapor manage- ment valve (left rear of engine compt)
- Vbatt
- Vpwr
- Vref
- Vss
- W/ 4x4
- W/ audiophile
- W/ ivd
- W/o audiophile
- W/o ivd
- Windshield wiper motor (left rear of engine compt)
4.6L, Engine Performance Wiring Diagram (2 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.6L, Engine Performance Wiring Diagram (2 of 4) for Ford Explorer 2004:
- (above brake pedal) brake pedal position switch
- (near breakout to powertrain control module)
- (on lower left of a/t) transmission solenoid body assembly
- Abs control module (left front of engine compt)
- Battery junction box (behind left side of dash)
- C175t
- Fuse 15a
- H2os 12 htr
- H2os 12 in
- H2os 22 htr
- H2os 22 in
- Hot at all times
- Iss
- J/c 2 (in battery junction box)
- Nca
- Oss
- Pcs a
- Pcs b
- Pcs c
- Powertrain control module (at right side engine bulkhead)
- Press ctrl sol a
- Press ctrl sol b
- Press ctrl sol c
- Red/pnk
- Redundant pedal switch (under left side of dash)
- S101
- S120 (w/ ivd: near breakout to left horn w/o ivd: near breakout to windshield washer motor)
- S171
- Shift sol a
- Shift sol b
- Shift sol c
- Shift sol d
- Sig rtn
- Ss a
- Ss b
- Ss c
- Ss d
- Tcc sol
- Transmission control switch
- Transmission controls system
- Transmission fluid temperature sensor
- Tss
- Turbine shaft speed (tss) sensor (a/t) (top left of trans)
- Vref
- W/ ivd
4.6L, Engine Performance Wiring Diagram (3 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.6L, Engine Performance Wiring Diagram (3 of 4) for Ford Explorer 2004:
- (lower left side of transmission) digital transmission range sensor
- (near breakout to digital transmission range sensor) s100
- (near breakout to powertrain control module)
- Battery junction box (left side of engine compt)
- C220b
- C270a
- C270f
- Central junction box (behind left side of dash)
- Flex fuel sender module
- Fuel gauge
- Fuel pump
- Fuel pump relay
- Fuel tank assembly
- Fuel tank pressure transducer sensor
- Fuse 10a
- Fuse 20a
- G101 (left front of engine compt)
- Heated oxygen sensor (ho2s) 11 (in right exhaust pipe before catalytic converter)
- Heated oxygen sensor (ho2s) 12 (in right exhaust pipe, after catalytic converter)
- Heated oxygen sensor (ho2s) 21 (in left exhaust pipe before catalytic converter)
- Heated oxygen sensor (ho2s) 22 (in left exhaust pipe, after catalytic converter)
- Hot at all times
- Hot in run or start
- Inertia fuel shutoff switch (base of right "a" pillar)
- Instrument cluster
- Intermediate shaft speed (iss) sensor (top left side of trans)
- J/c 1 (in battery junction box)
- Micro- processor
- N r
- Nca
- Output shaft speed sensor (left rear of trans) (a/t)
- Red
- Red/pnk
- S102
- S103 (near breakout to heated oxygen sensor)
4.6L, Engine Performance Wiring Diagram (4 of 4) for Ford Explorer 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO すべての配線図にアクセスする車List of elements for 4.6L, Engine Performance Wiring Diagram (4 of 4) for Ford Explorer 2004:
- (at rear of engine)
- (at right "d" pillar) fuel pump driver module
- (near breakout to differential pressure feedback egr sensor) s105
- (near breakout to fuel injector)
- (near breakout to fuel injector) s108
- (near breakout to fuel injector) s109
- (near breakout to heated oxygen sensor)
- C175e
- Camshaft position sensor (top front of left cyl head)
- Ckp sens +
- Ckp sens -
- Cmp sens
- Coil on plug
- Cop 1
- Cop 2
- Cop 3
- Cop 4
- Cop 5
- Cop 6
- Cop 7
- Cop 8
- Crankshaft position sensor (left front of engine)
- Cyl temp
- Cylinder head temperature sensor (top front of cylinder head)
- Dfpegr sens
- Egr system module (top of engine)
- Egrvr
- Electronic throttle control motor (at top of engine)
- Fuel pres
- Fuel rail pressure transducer sensor (top rear of engine)
- G105 (right rear side of engine compt)
- G401 (at right "d" pillar)
- Ho2s 11
- Ho2s 11 htr
- Ho2s 21
- Ho2s 21 htr
- Ignition transformer capacitor 1 (engine compt)
- Ignition transformer capacitor 2 (engine compt)
- Inj 1
- Inj 2
- Inj 3
- Inj 4
- Inj 5
- Inj 6
- Inj 7
- Inj 8
- Injec- tors
- Knock sensor
- Ks +
- Ks -
- Map
- Nca
- Powertrain control module (at right side engine bulkhead)
- Red/pnk
- Return
- S104
- S106
- S107
- Sig rtn
- Sig1
- Sig2
- Tan
- Tan/red
- Throttle position (tps) sensor (top of throttle body)
- V ref
- Vref