ENGINE PERFORMANCE – Ford Ranger 1996 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.3L

2.3L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1996

List of elements for 2.3L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1996:

• (case) ground
• (ckp) sensor (+)
• (ckp) sensor (-)
• (css) sol
• (ect) sensor
• (evr) ctrl
• (ho2s) #2
• (iat) sensor
• (maf) sensor rtn
• (mil)
• (pf) sensor
• (psp) switch
• (pwr) ground
• (tft) sensor
• 4x4 indicator sw
• A/c psi cutoff
• C209
• C214
• C216
• Crankshaft position (ckp) sensor (lower right front of engine)
• Data link connector (dlc) (fastened to bottom of i/p, near steering column)
• Dlc
• Dlc bus (+)
• Dlc bus (-)
• Engine compartment fuse/relay box (left rear of engine compartment)
• Fuel pmp monitor
• Fuse 25a
• Fuse 7.5a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• G123 (right side of safety wall
• G123 (right side of safety wall)
• Hot at all times
• Hot in run or start
• I/p fuse panel (behind left side of i/p)
• Ignition coil #1
• Ignition coil #2
• Instrument cluster
• Instrument clusters system
• Malfunction indicator lamp (mil)
• Octane adjust
• Pcm power diode
• Pcm power maxi fuse 13 30a
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compartment, through safety wall)
• Primary coil (top right side of engine)
• Radio noise capacitor (near secondary coil)
• Red
• Secondary coil (top right front of engine)
• Shift sol 1
• Shift sol 2
• Tachometer
• Tachometer test connector (left rear engine compt.)
• Trans ctrl (tcs)
• Transmission system (w/ manual shift: 4x4 indicator switch; w/ electric shift: generic electronic module)

2.3L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1996

List of elements for 2.3L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1996:

• A/c clutch diode (left front engine compt.)
• A/c clutch field coil (left front of engine)
• A/t
• Air conditioning system (a/c pressure cutoff switch)
• Clutch pedal position (cpp) switch (clutch pedal support)
• Clutch pedal position (cpp) switch jumper (left side of i/p)
• Differential pressure feedback egr (dpfe) sensor (right rear of engine)
• Engine compartment fuse/relay box (left rear of engine compartment)
• Engine coolant temperature (ect) sensor (top right front of engine)
• Evaporative emissions (evap) canister purge solenoid (left front engine compt.)
• Fuel pump relay
• Fuel sys/ anti-theft maxi fuse 12 20a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• Horn/pcm memory power maxi fuse 4 20a
• Hot at all times
• Intake air temperature (iat) sensor (right side of engine compt.)
• M/t
• Nca
• Octane adjust shorting bar (near pcm)
• Power distribution system
• Power steering pressure (psp) switch (left front of engine compt.)
• Power steering pressure (psp) switch jumper (left front of engine compt.)
• Purge flow (pf) sensor (left front of engine compt.)
• Red
• Throttle position (tp) sensor (top right side of engine)
• W/ pwr steering
• W/o pwr steering
• Wide open throttle a/c cutoff (wac) relay

2.3L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1996

List of elements for 2.3L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1996:

• (below glove box) inertia fuel shut-off (ifs)
• C214
• Egr vacuum regulator (evr) solenoid (right side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Fuel injectors (top of cylinders)
• Fuel pump module (top of fuel tank)
• Fuel reset switch indica- or c214
• Fuse 15a
• Fuse 7.5a
• G200 (behind left cowl panel)
• Ho2s fuse 20 15a
• Hot in run
• Hot in run or start
• I/p fuse panel (behind left side of i/p)
• Instrument cluster
• Power distribution system (main light switch)
• Red
• Tan
• Trans- mission control indicator lamp
• Transmission control switch (tcs)

2.3L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1996

List of elements for 2.3L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1996:

• (b+) power
• (boo) switch
• (cmp) sensor
• (dpfe) sensor
• (epc) solenoid
• (evap) solenoid
• (ho2s) #1
• (ho2s) #1 htr
• (ho2s) #2 htr
• (iac) solenoid
• (left side of transaxle) transmission range (tr) sensor
• (maf) sensor
• (pcm relay) pwr
• (pwr) ground
• (tcc) solenoid
• (tcil) lp output
• (tp) sensor
• (tr) sensor
• (tss) sensor
• (vss) input
• 4r44e/4r55e automatic transmission (left side of transmission)
• A/c (wot) relay
• Brake on/ off (boo) switch
• Camshaft position (cmp) sensor (behind oil pump pulley)
• Coast clutch (css) solenoid
• Cruise control system (speed ctrl servo/ amplifier assembly), instrument cluster system (speedometer), body computer system (generic electronic module/central timer module)
• Electronic pressure control (epc) solenoid
• Fuel inj (#1)
• Fuel inj (#2)
• Fuel inj (#3)
• Fuel inj (#4)
• Fuel pmp rly
• Fuse 15a
• G108 (left side of upper radiator support)
• G123 (right side of safety wall)
• Heated oxygen sensor (ho2s) #1 (lower right side of engine)
• Heated oxygen sensor (ho2s) #2 (lower right side of engine)
• Hot at all times
• I/p fuse panel (behind left side of i/p)
• Idle air control (iac) valve (top right rear of engine)
• Ignition coil #3
• Ignition coil #4
• Mass air flow (maf) sensor (air cleaner assembly)
• Nca
• Powertrain control module (pcm) (right rear of engine compartment, through safety wall)
• Red
• Ref volt
• Shift sol 3
• Shift solenoids
• Signal rtn
• Tan
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature (tft) sensor
• Turbine shaft speed sensor (tss)
• Vehicle speed sensor (vss) (left rear of trans./transfer case)

3.0L

3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1996

List of elements for 3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1996:

• (case) ground
• (ckp) sensor (+)
• (ckp) sensor (-)
• (css) sol
• (ect) sensor
• (evr) ctrl
• (ho2s) #3
• (iat) sensor
• (maf) sensor rtn
• (mil)
• (pf) sensor
• (pwr) ground
• (tft) sensor
• 4x4 indicator sw
• A/c psi cutoff
• C209
• C214
• C216
• Crankshaft position (ckp) sensor (lower front of engine)
• Data link connector (dlc) (fastened to bottom of i/p, near steering column)
• Dlc
• Dlc bus (+)
• Dlc bus (-)
• Engine compartment fuse/relay box (left rear of engine compartment)
• Fuel pmp monitor
• Fuse 25a
• Fuse 7.5a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• G123 (right side of safety wall
• G123 (right side of safety wall)
• Hot at all times
• Hot in run or start
• I/p fuse panel (behind left side of i/p)
• Ignition coil #1
• Ignition coil #3
• Ignition coil (top right side of engine)
• Instrument cluster
• Instrument clusters system
• Malfunction indicator lamp (mil)
• Octane adjust
• Pcm power diode
• Pcm power maxi fuse 13 30a
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compartment, through safety wall)
• Radio noise capacitor (near ignition coil)
• Red
• Shift sol 1
• Shift sol 2
• Tachometer
• Tachometer test connector (left rear engine compt.)
• Trans ctrl (tcs)
• Transmission system (w/ manual shift: 4x4 indicator switch; w/ electric shift: generic electronic module)

3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1996

List of elements for 3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1996:

• A/c clutch diode (left front engine compt.)
• A/c clutch field coil (left front of engine)
• A/t
• Air conditioning system (a/c pressure cutoff switch)
• Clutch pedal position (cpp) switch (clutch pedal support)
• Clutch pedal position (cpp) switch jumper (left side of i/p)
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Engine compartment fuse/relay box (left rear of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine)
• Evaporative emissions (evap) canister purge solenoid (left front engine compt.)
• Fuel pump relay
• Fuel sys/ anti-theft maxi fuse 12 20a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• Horn/pcm memory power maxi fuse 4 20a
• Hot at all times
• Intake air temperature (iat) sensor (right side of engine compt.)
• M/t
• Nca
• Octane adjust shorting bar (near pcm)
• Power distribution system
• Purge flow (pf) sensor (left front of engine compt.)
• Red
• Throttle position (tp) sensor (top left front of engine)
• Wide open throttle a/c cutoff (wac) relay

3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1996

List of elements for 3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1996:

• (below glove box) inertia fuel shut-off (ifs)
• C214
• Egr vacuum regulator (evr) solenoid (right side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Fuel injectors (top of cylinders)
• Fuel pump module (top of fuel tank)
• Fuel reset switch indica- or c214
• Fuse 15a
• Fuse 7.5a
• G200 (behind left cowl panel)
• Ho2s fuse 20 15a
• Hot in run
• Hot in run or start
• I/p fuse panel (behind left side of i/p)
• Instrument cluster
• Power distribution system (main light switch)
• Red
• Tan
• Trans- mission control indicator lamp
• Transmission control switch (tcs)

3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1996

List of elements for 3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1996:

• (b+) power
• (boo) switch
• (cmp) sensor
• (dpfe) sensor
• (epc) solenoid
• (evap) solenoid
• (ho2s) #1
• (ho2s) #1 htr
• (ho2s) #2
• (ho2s) #2 htr
• (ho2s) #3 htr
• (iac) solenoid
• (left side of transaxle) transmission range (tr) sensor
• (maf) sensor
• (pcm relay) pwr
• (pwr) ground
• (tcc) solenoid
• (tcil) lp output
• (tp) sensor
• (tr) sensor
• (tss) sensor
• (vss) input
• 4r44e/4r55e automatic transmission (left side of transmission)
• A/c (wot) relay
• Brake on/ off (boo) switch
• Camshaft position (cmp) sensor (top rear of engine)
• Coast clutch (css) solenoid
• Cruise control system (speed ctrl servo/ amplifier assembly), instrument cluster system (speedometer), body computer system (generic electronic module/central timer module)
• Electronic pressure control (epc) solenoid
• Fuel inj (#1)
• Fuel inj (#2)
• Fuel inj (#3)
• Fuel inj (#4)
• Fuel inj (#5)
• Fuel inj (#6)
• Fuel pmp rly
• Fuse 15a
• G108 (left side of upper radiator support)
• G123 (right side of safety wall)
• Heated oxygen sensor (ho2s) #1 (lower right side of engine compt.)
• Heated oxygen sensor (ho2s) #2 (lower left rear of engine compt.)
• Heated oxygen sensor (ho2s) #3 (near right side of transmission)
• Hot at all times
• I/p fuse panel (behind left side of i/p)
• Idle air control (iac) valve (top left front of engine)
• Ignition coil #2
• Mass air flow (maf) sensor (air cleaner assembly)
• Nca
• Powertrain control module (pcm) (right rear of engine compartment, through safety wall)
• Red
• Ref volt
• Shift sol 3
• Shift solenoids
• Signal rtn
• Tan
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature (tft) sensor
• Turbine shaft speed sensor (tss)
• Vehicle speed sensor (vss) (left rear of trans./transfer case)

4.0L

4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1996

List of elements for 4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1996:

• (case) ground
• (ckp) sensor (+)
• (ckp) sensor (-)
• (css) sol
• (ect) sensor
• (evr) ctrl
• (ho2s) #3
• (iat) sensor
• (maf) sensor rtn
• (mil)
• (pf) sensor
• (pwr) ground
• (tft) sensor
• 4x4 indicator sw
• A/c psi cutoff
• C209
• C214
• C216
• Crankshaft position (ckp) sensor (lower front of engine)
• Data link connector (dlc) (fastened to bottom of i/p, near steering column)
• Dlc
• Dlc bus (+)
• Dlc bus (-)
• Engine compartment fuse/relay box (left rear of engine compartment)
• Fuel pmp monitor
• Fuse 25a
• Fuse 7.5a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• G123 (right side of safety wall
• G123 (right side of safety wall)
• Hot at all times
• Hot in run or start
• I/p fuse panel (behind left side of i/p)
• Ignition coil #1
• Ignition coil #2
• Ignition coil (top right rear of engine)
• Instrument cluster
• Instrument clusters system
• Malfunction indicator lamp (mil)
• Octane adjust
• Pcm power diode
• Pcm power maxi fuse 13 30a
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compartment, through safety wall)
• Radio noise capacitor (near ignition coil)
• Red
• Shift sol 1
• Shift sol 2
• Tachometer
• Tachometer test connector (left rear engine compt.)
• Trans ctrl (tcs)
• Transmission system (w/ manual shift: 4x4 indicator switch; w/ electric shift: generic electronic module)

4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1996

List of elements for 4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1996:

• A/c clutch diode (left front engine compt.)
• A/c clutch field coil (left front of engine)
• A/t
• Air conditioning system (a/c pressure cutoff switch)
• Clutch pedal position (cpp) switch (clutch pedal support)
• Clutch pedal position (cpp) switch jumper (left side of i/p)
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Engine compartment fuse/relay box (left rear of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine)
• Evaporative emissions (evap) canister purge solenoid (left front engine compt.)
• Fuel pump relay
• Fuel sys/ anti-theft maxi fuse 12 20a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• Horn/pcm memory power maxi fuse 4 20a
• Hot at all times
• Intake air temperature (iat) sensor (front of engine, on air intake assembly)
• M/t
• Nca
• Octane adjust shorting bar (near pcm)
• Power distribution system
• Purge flow (pf) sensor (left front of engine compt.)
• Red
• Throttle position (tp) sensor (top left front of engine)
• Wide open throttle a/c cutoff (wac) relay

4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1996

List of elements for 4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1996:

• (below glove box) inertia fuel shut-off (ifs)
• C214
• Egr vacuum regulator (evr) solenoid (left rear of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Fuel injectors (top of cylinders)
• Fuel pump module (top of fuel tank)
• Fuel reset switch indica- or c214
• Fuse 15a
• Fuse 7.5a
• G200 (behind left cowl panel)
• Ho2s fuse 20 15a
• Hot in run
• Hot in run or start
• I/p fuse panel (behind left side of i/p)
• Instrument cluster
• Power distribution system (main light switch)
• Red
• Tan
• Trans- mission control indicator lamp
• Transmission control switch (tcs)

4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1996

List of elements for 4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1996:

• (b+) power
• (boo) switch
• (cmp) sensor
• (dpfe) sensor
• (epc) solenoid
• (evap) solenoid
• (ho2s) #1
• (ho2s) #1 htr
• (ho2s) #2
• (ho2s) #2 htr
• (ho2s) #3 htr
• (iac) solenoid
• (left side of transaxle) transmission range (tr) sensor
• (maf) sensor
• (pcm relay) pwr
• (pwr) ground
• (tcc) solenoid
• (tcil) lp output
• (tp) sensor
• (tr) sensor
• (tss) sensor
• (vss) input
• 4r44e/4r55e automatic transmission (left side of transmission)
• A/c (wot) relay
• Brake on/ off (boo) switch
• Camshaft position (cmp) sensor (top rear of engine)
• Coast clutch (css) solenoid
• Cruise control system (speed ctrl servo/ amplifier assembly), instrument cluster system (speedometer), body computer system (generic electronic module/central timer module)
• Electronic pressure control (epc) solenoid
• Fuel inj (#1)
• Fuel inj (#2)
• Fuel inj (#3)
• Fuel inj (#4)
• Fuel inj (#5)
• Fuel inj (#6)
• Fuel pmp rly
• Fuse 15a
• G108 (left side of upper radiator support)
• G123 (right side of safety wall)
• Heated oxygen sensor (ho2s) #1 (lower right side of engine compt.)
• Heated oxygen sensor (ho2s) #2 (lower left rear of engine compt.)
• Heated oxygen sensor (ho2s) #3 (near right side of transmission)
• Hot at all times
• I/p fuse panel (behind left side of i/p)
• Idle air control (iac) valve (top left rear of engine)
• Ignition coil #3
• Mass air flow (maf) sensor (air cleaner assembly)
• Nca
• Powertrain control module (pcm) (right rear of engine compartment, through safety wall)
• Red
• Ref volt
• Shift sol 3
• Shift solenoids
• Signal rtn
• Tan
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature (tft) sensor
• Turbine shaft speed sensor (tss)
• Vehicle speed sensor (vss) (left rear of trans./transfer case)