TRANSMISSION
5.4L
5.4L, A/T Wiring Diagram, with 4R100 Transmission (1 of 2) for Ford RV Cutaway E350 Super Duty 2004
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for 5.4L, A/T Wiring Diagram, with 4R100 Transmission (1 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (1)
- (2)
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl sens harn, near breakout to c1033)
- (in eng ctrl sens
- (in main wiring harn, near breakout to left side of dash)
- (in window reg rly sw harn, near breakout to steering column)
- (not used) c237
- (window reg rly sw harn, rear breakout to c237)
- (window reg rly sw harn, rear breakout to c248)
- 6.8l
- Bpp
- Brake pedal position switch (on bracket, above brake pedal)
- Ccs
- Central junction box (behind left side of dash)
- Cht
- Data (+)
- Data (-)
- Data link connector (behind left side of dash, below left side of dash)
- Digital transmission range sensor
- Epc
- Except stripped chassis
- Exterior lights system
- Fuel tank pressure transducer sensor
- Fuse 10a
- Fuse 15a
- Gen data
- Gnd
- Harn, near breakout to c237)
- Hot at all times
- Hot in run or start
- Instrument cluster system
- Kapwr
- Maf
- Multifunction switch, deavtiator switch
- Nca
- Od off
- Oss
- Others
- Overdrive cancel switch
- Overhead console
- Powertrain control module (pcm) (in eng compt, on left side of firewall)
- Pwr in
- Red
- S134 (eng ctrl sens harn, near breakout to rear of eng compt)
- S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
- S138
- S140
- S169
- S172
- S216
- S224 s220 (main wiring harn, near breakout to left side of dash)
- S228 s182
- S231 s283 (main wiring harn, in breakout to left side of dash)
- S269 s184
- Sig rtn
- Speed control servo
- Ssa
- Ssb
- Stripped chassis
- Tcc
- Tcil
- Tcs
- Tft
- Tps
- Tr1
- Tr2
- Tr3
- Tr4
- Tss
- Vehicle security module
- Vref
- Vss
5.4L, A/T Wiring Diagram, with 4R100 Transmission (2 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 5.4L, A/T Wiring Diagram, with 4R100 Transmission (2 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl harn, near breakout to left rear of eng compt) s136
- (in battery junction box)
- (in eng ctrl
- (in eng ctrl sens & fuel charging warning harn, at left center of eng)
- (in eng ctrl sens harn, near breakout to left rear of eng compt)
- (in headlamp lead wiring harn, in breakout to c1046)
- (in trans ctrl selector neutral sw, near breakout at top of transmission)
- (in trans ctrl selector neutral sw: w/o ngv: near breakout at rear of eng, w/ ngv: near breakout at right side of transmission)
- (top center of engine compt)
- 4r100 transmission
- Battery junction box
- Battery junction box (left side of engine compt)
- Central junction box (behind left side of dash)
- Coast clutch solenoid
- Cylinder head temperature sensor (on top front of left cylinder head)
- Electronic pressure control solenoid
- Engine controls system
- Except stripped chassis
- Fuse 10a
- Fuse 30a
- Gasoline
- Hot at all times
- Hot in run or start
- Ignition coil, radio noise capacitor
- Mass airflow (maf) sensor (at center of engine compt)
- Natural gas vehicle
- Output shaft speed sensor (left side of transmission)
- Pcm power diode
- Pcm power relay
- Red
- S100
- S102
- S1033
- S127 s1065
- S140
- S142
- S157
- S158
- Sens harn, near breakout to center of eng compt)
- Shift solenoid a
- Shift solenoid b
- Stripped chassis
- Throttle position sensor (tps) (on top of engine, near air intake)
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Turbine shaft sensor (at left side of transmission)
5.4L, A/T Wiring Diagram, with 4R70E/4R75E (1 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 5.4L, A/T Wiring Diagram, with 4R70E/4R75E (1 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl sens harn, near breakout to c1033)
- (in eng ctrl sens harn, near breakout to c237)
- (in main
- (in window reg rly sw harn, near breakout to steering column)
- (main wiring harn, near breakout to left side of dash)
- (not used) c237
- (window reg rly sw harn, rear breakout to c248)
- Bpp
- Brake pedal position switch (on bracket, above brake pedal)
- Central junction box (behind left side of dash)
- Cht
- Data (+)
- Data (-)
- Data link connector (behind left side of dash, below left side of dash)
- Digital transmission range sensor
- Epc
- Except stripped chassis
- Exterior lights system
- Fuel tank pressure transducer sensor
- Fuse 10a
- Fuse 15a
- Gen data
- Gnd
- Hot at all times
- Hot in run or start
- Instrument cluster system
- Kapwr
- Maf
- Multifunction switch, deavtiator switch
- Nca
- Od off
- Oss
- Others
- Overdrive cancel switch
- Overhead console
- Powertrain control module (pcm) (in eng compt, on left side of firewall)
- Pwr in
- Red
- S134 (eng ctrl sens harn, near breakout to rear of eng compt)
- S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
- S138
- S140
- S169
- S172
- S216
- S220 s224 (window reg rly sw harn, rear breakout to c237)
- S228 s182
- S269 s184
- Sig rtn
- Speed control servo
- Ssa
- Ssb
- Stripped chassis
- Tcc
- Tcil
- Tcs
- Tft
- Tps
- Tr1
- Tr2
- Tr3
- Tr4
- Vehicle security module
- Vref
- Vss
- Wiring harn, near breakout to left side of dash)
5.4L, A/T Wiring Diagram, with 4R70E/4R75E (2 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 5.4L, A/T Wiring Diagram, with 4R70E/4R75E (2 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl harn, near breakout to left rear of eng compt)
- (in battery junction box)
- (in eng ctrl sens
- (in eng ctrl sens & fuel charging wiring harn, at left center of eng)
- (in headlamp lead wiring harn, in breakout to c1046)
- (near breakout at rear
- (top center of engine compt)
- 4r70e/4r75e transmission
- Battery junction box
- Battery junction box (left side of engine compt)
- Central junction box (behind left side of dash)
- Cylinder head temperature sensor (on top front of left cylinder head)
- Electronic pressure control solenoid
- Engine controls system
- Except stripped chassis
- Fuse 10a
- Fuse 30a
- Harn, near breakout to center of eng compt)
- Harn, near breakout to left rear of eng compt)
- Hot at all times
- Hot in run or start
- Ignition coil, radio noise capacitor
- Mass airflow (maf) sensor (at center of engine compt)
- Of eng)
- Output shaft speed sensor (left side of transmission)
- Pcm power diode
- Pcm power relay
- Red
- S100
- S102 (near breakout at rear
- S1033
- S1065
- S127
- S136
- S140
- S142
- S157
- S158
- Shift solenoids
- Ssa
- Ssb
- Stripped chassis
- Throttle position sensor (tps) (on top of engine, near air intake)
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
5.4L NGV
5.4L NGV, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 5.4L NGV, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (1)
- (2)
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl sens harn, near breakout to c1033)
- (in eng ctrl sens
- (in main wiring harn, near breakout to left side of dash)
- (in window reg rly sw harn, near breakout to steering column)
- (not used) c237
- (window reg rly sw harn, rear breakout to c237)
- (window reg rly sw harn, rear breakout to c248)
- 6.8l
- Bpp
- Brake pedal position switch (on bracket, above brake pedal)
- Ccs
- Central junction box (behind left side of dash)
- Cht
- Data (+)
- Data (-)
- Data link connector (behind left side of dash, below left side of dash)
- Digital transmission range sensor
- Epc
- Except stripped chassis
- Exterior lights system
- Fuel tank pressure transducer sensor
- Fuse 10a
- Fuse 15a
- Gen data
- Gnd
- Harn, near breakout to c237)
- Hot at all times
- Hot in run or start
- Instrument cluster system
- Kapwr
- Maf
- Multifunction switch, deavtiator switch
- Nca
- Od off
- Oss
- Others
- Overdrive cancel switch
- Overhead console
- Powertrain control module (pcm) (in eng compt, on left side of firewall)
- Pwr in
- Red
- S134 (eng ctrl sens harn, near breakout to rear of eng compt)
- S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
- S138
- S140
- S169
- S172
- S216
- S224 s220 (main wiring harn, near breakout to left side of dash)
- S228 s182
- S231 s283 (main wiring harn, in breakout to left side of dash)
- S269 s184
- Sig rtn
- Speed control servo
- Ssa
- Ssb
- Stripped chassis
- Tcc
- Tcil
- Tcs
- Tft
- Tps
- Tr1
- Tr2
- Tr3
- Tr4
- Tss
- Vehicle security module
- Vref
- Vss
5.4L NGV, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 5.4L NGV, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl harn, near breakout to left rear of eng compt) s136
- (in battery junction box)
- (in eng ctrl
- (in eng ctrl sens & fuel charging warning harn, at left center of eng)
- (in eng ctrl sens harn, near breakout to left rear of eng compt)
- (in headlamp lead wiring harn, in breakout to c1046)
- (in trans ctrl selector neutral sw, near breakout at top of transmission)
- (in trans ctrl selector neutral sw: w/o ngv: near breakout at rear of eng, w/ ngv: near breakout at right side of transmission)
- (top center of engine compt)
- 4r100 transmission
- Battery junction box
- Battery junction box (left side of engine compt)
- Central junction box (behind left side of dash)
- Coast clutch solenoid
- Cylinder head temperature sensor (on top front of left cylinder head)
- Electronic pressure control solenoid
- Engine controls system
- Except stripped chassis
- Fuse 10a
- Fuse 30a
- Gasoline
- Hot at all times
- Hot in run or start
- Ignition coil, radio noise capacitor
- Mass airflow (maf) sensor (at center of engine compt)
- Natural gas vehicle
- Output shaft speed sensor (left side of transmission)
- Pcm power diode
- Pcm power relay
- Red
- S100
- S102
- S1033
- S127 s1065
- S140
- S142
- S157
- S158
- Sens harn, near breakout to center of eng compt)
- Shift solenoid a
- Shift solenoid b
- Stripped chassis
- Throttle position sensor (tps) (on top of engine, near air intake)
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Turbine shaft sensor (at left side of transmission)
6.0L DIESEL
6.0L Diesel, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 6.0L Diesel, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (in trans ctrl selector neutral switch harn, in breakout to right side of transmission)
- (in window regulator relay switch harn, near breakout to c237)
- (in window regulator relay switch harn, near breakout to steering column)
- (not used)
- Abs control module
- Aps2 rtn
- Aps2 sig
- Aps3 sig
- Brake on/off
- Brake pedal position switch (on bracket, above brake pedal)
- Brake shift interlock
- C176a
- C176b
- C176c
- C237
- Can h
- Can l
- Central junction box (behind left side of dash)
- Cluster pwr
- Coolant temp
- Data link connector (behind left side of dash)
- Egr mtr
- Exterior lights system
- Fuse 10a
- Fuse 15a
- G107 (at right rear of eng compt)
- G121 (at left side of eng compt)
- Gnd
- Harn, in breakout to c219) s174
- Hot at all times
- Hot in run or start
- Illum
- Iss sig
- Mao to pcm
- Nca
- Od cancel sw
- Oss sig
- Overhead console (if equipped)
- Pc sol pwr
- Pc-a sol
- Pcm acc pedal
- Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
- Pressure control (pc-a) solenoid
- Red
- Ref volt
- Rev lmp ctrl
- S123
- S135 (in eng ctrl sens harn, near breakout to left rear of emg compt)
- S172
- S216
- S224
- S228 (in window regulator relay switch harn, near breakout to c237)
- S269
- Shift solenoid pressure control a (sspc-a)
- Shift solenoid pressure control b (sspc-b)
- Shift solenoid pressure control c (sspc-c)
- Shift solenoid pressure control d (sspc-d)
- Shift solenoid pressure control e (sspc-e)
- Sig rtn
- Sig trn
- Sspc-a crl
- Sspc-b ctrl
- Sspc-c crl
- Sspc-d ctrl
- Sspc-e ctrl
- Star/run +
- Start/run
- Tan
- Tcc sol ctrl
- Tcil ctrl
- Tft sens sig
- Torqshift transmission (at right side of transmission)
- Torque converter clutch solenoid
- Tow/haul switch
- Tr-p gnd
- Tr-p sig
- Trac assist
- Transmission fluid temperature sensor
- Transmission range sensor assembly (tr-p)
- Tss sig
- Vehicle security module
- Vss +
6.0L Diesel, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 6.0L Diesel, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (at left side of transmission) speed sensor assembly
- (in battery junction box)
- (in eng ctrl sens & fuel charging wiring harn, near breakout to rear left of eng compt) s1059
- (in eng ctrl sens & fuel charging wiring harn, near breakout to top front left eng)
- (in trans ctrl selector neutral switch harn, near breakout to top of transmission) s198
- Accelerator pedal position sensor (behind left side of dash, above accelerator pedal)
- Auxiliary powertain control module
- Auxiliary relay box 1 (at right rear of eng compt)
- Battery junction box
- Battery junction box (at right rear of engine compt)
- Central junction box (behind left side of dash)
- Engine controls system
- Engine coolant temperature sensor (on upper left front of eng)
- Fuel injector control module & fuel heater
- Fuel injector module & mass air flow sensor
- Fuse 10a
- Fuse 30a
- G107 (at right rear of eng compt)
- Hot at all times
- Hot in run or start
- Manifold absolute pressure sensor (on right side of eng compt)
- Output shaft speed sensor (at rear of transmission)
- Pcm power diode
- Pcm power relay
- Position
- Red
- Reversing lamp relay
- S1033
- S1037
- S1058
- S1065
- S1068 (in eng ctrl sensor harn, near breakout to c127)
- S136 (in eng ctrl sensor harn, near breakout to left rear of eng compt)
- S138
- S142 (in eng ctrl sensor harn, near breakout to right side of eng compt)
- S172
- S246
- Tan
- Throttle position sensor (on top of eng, near air intake)
6.8L
6.8L, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 6.8L, A/T Wiring Diagram (1 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (1)
- (2)
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl sens harn, near breakout to c1033)
- (in eng ctrl sens
- (in main wiring harn, near breakout to left side of dash)
- (in window reg rly sw harn, near breakout to steering column)
- (not used) c237
- (window reg rly sw harn, rear breakout to c237)
- (window reg rly sw harn, rear breakout to c248)
- 6.8l
- Bpp
- Brake pedal position switch (on bracket, above brake pedal)
- Ccs
- Central junction box (behind left side of dash)
- Cht
- Data (+)
- Data (-)
- Data link connector (behind left side of dash, below left side of dash)
- Digital transmission range sensor
- Epc
- Except stripped chassis
- Exterior lights system
- Fuel tank pressure transducer sensor
- Fuse 10a
- Fuse 15a
- Gen data
- Gnd
- Harn, near breakout to c237)
- Hot at all times
- Hot in run or start
- Instrument cluster system
- Kapwr
- Maf
- Multifunction switch, deavtiator switch
- Nca
- Od off
- Oss
- Others
- Overdrive cancel switch
- Overhead console
- Powertrain control module (pcm) (in eng compt, on left side of firewall)
- Pwr in
- Red
- S134 (eng ctrl sens harn, near breakout to rear of eng compt)
- S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
- S138
- S140
- S169
- S172
- S216
- S224 s220 (main wiring harn, near breakout to left side of dash)
- S228 s182
- S231 s283 (main wiring harn, in breakout to left side of dash)
- S269 s184
- Sig rtn
- Speed control servo
- Ssa
- Ssb
- Stripped chassis
- Tcc
- Tcil
- Tcs
- Tft
- Tps
- Tr1
- Tr2
- Tr3
- Tr4
- Tss
- Vehicle security module
- Vref
- Vss
6.8L, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2004
List of elements for 6.8L, A/T Wiring Diagram (2 of 2) for Ford RV Cutaway E350 Super Duty 2004:
- (at right rear side of engine compt) g116
- (at right side of engine compt) g107
- (eng ctrl harn, near breakout to left rear of eng compt) s136
- (in battery junction box)
- (in eng ctrl
- (in eng ctrl sens & fuel charging warning harn, at left center of eng)
- (in eng ctrl sens harn, near breakout to left rear of eng compt)
- (in headlamp lead wiring harn, in breakout to c1046)
- (in trans ctrl selector neutral sw, near breakout at top of transmission)
- (in trans ctrl selector neutral sw: w/o ngv: near breakout at rear of eng, w/ ngv: near breakout at right side of transmission)
- (top center of engine compt)
- 4r100 transmission
- Battery junction box
- Battery junction box (left side of engine compt)
- Central junction box (behind left side of dash)
- Coast clutch solenoid
- Cylinder head temperature sensor (on top front of left cylinder head)
- Electronic pressure control solenoid
- Engine controls system
- Except stripped chassis
- Fuse 10a
- Fuse 30a
- Gasoline
- Hot at all times
- Hot in run or start
- Ignition coil, radio noise capacitor
- Mass airflow (maf) sensor (at center of engine compt)
- Natural gas vehicle
- Output shaft speed sensor (left side of transmission)
- Pcm power diode
- Pcm power relay
- Red
- S100
- S102
- S1033
- S127 s1065
- S140
- S142
- S157
- S158
- Sens harn, near breakout to center of eng compt)
- Shift solenoid a
- Shift solenoid b
- Stripped chassis
- Throttle position sensor (tps) (on top of engine, near air intake)
- Torque converter clutch solenoid
- Transmission fluid temperature sensor
- Turbine shaft sensor (at left side of transmission)