TRANSMISSION – Ford Pickup Heritage F150 2004 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

4WD Wiring Diagram, Electronic for Ford Pickup Heritage F150 2004

List of elements for 4WD Wiring Diagram, Electronic for Ford Pickup Heritage F150 2004:

• (behind left side of dash)
• (left side of vehicle underbody) s142
• (right side of engine compt) 4x2 center axle disconnect solenoid
• (right side of engine compt) 4x4 center axle disconnect solenoid
• (under left side of dash) central junction box
• 1.1k ohms
• 3.9k ohms
• 4wd high ind
• 4wd low ind
• 4wd low out
• 4wd output
• 4x2 sol
• 4x4 high ind
• 4x4 mode sw
• 4x4 sol
• Abs control module
• Auxiliary relay box 3 (behind right center of dash)
• Batt
• Battery junction box (left side of engine compt)
• Bpp sw input
• Brake pedal position switch (under left side of dash)
• Brake pressure switch
• Brake shift interlock
• C175
• C201a
• C201c
• C201d
• C220a
• C220b
• C270a
• C270b
• Central junction box (under left side of dash)
• Computer data lines system
• Digital transmission range (dtr) sensor (left side of transmission)
• Exterior lights system
• Flasher relay, overhead console
• Four-wheel drive switch
• Fuse 10a
• Fuse 30a
• Fuse 5a
• G102 (right rear of engine compt)
• G200 (at right front footwell)
• G201 (at left front footwell)
• Gem module
• Generic electronic module (gem) (behind left side of dash)
• H2l
• H2l rly ctrl
• Hot at all times
• Hot in run
• Illumination
• Instrument cluster
• Interior lights (instrument illumination)
• L2h
• L2h rly ctrl
• Magnetic clutch
• Neutral sw in
• Off
• Ohms
• Powertrain control module (right side of engine compt)
• Red
• S102
• S120
• S201
• S202
• S207
• S213
• S228
• S232
• S238 (under dash, near steering column)
• S265
• S274
• S297
• Shift motor
• Sig return
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Tan/red
• Tcec rly ctrl
• Trailer tow battery charge relay
• Transfer case assembly (below vehicle, behind trans)
• Transfer case electric clutch relay
• Transfer case relay module (behind center of dash)
• Wiper/washer (multi-function switch)

4WD Wiring Diagram, Mechanical for Ford Pickup Heritage F150 2004

List of elements for 4WD Wiring Diagram, Mechanical for Ford Pickup Heritage F150 2004:

• (right side of engine compt) 4x2 center axle disconnect solenoid
• (right side of engine compt) 4x4 center axle disconnect solenoid
• (right side of engine compt) powertrain control module
• 4wd hi ind
• 4wd high ind
• 4wd low ind
• 4x2
• 4x2 sol
• 4x4 high/ low indicator switch (left side of transmission)
• 4x4 lo in
• 4x4 sol
• 4x4 sw in
• Abs control module
• Auxiliary relay box 3 (behind right center of dash)
• Battery junction box (left side of engine compt)
• Brake shift interlock
• C175
• C201c
• C220a
• C220b
• C270a
• C270b
• Central junction box (under left side of dash)
• Computer data lines system
• Flasher relay, overhead console
• Fuse 10a
• Fuse 30a
• Fuse 5a
• Gem module
• Generic electronic module (gem) (behind left side of dash)
• Hot at all times
• Hot in run
• Instrument cluster
• Magnetic clutch
• Mechanical shift-on-the -fly relay
• Not used
• Red
• S120
• S142 (left side of vehicle underbody)
• S228
• S232 (behind left side of dash)
• S265
• Scp bus+
• Scp bus-
• Sotf relay
• Tan/red
• Trailer tow battery charge relay
• Transfer case assembly

4.2L

4.2L, A/T Wiring Diagram, 4R70W for Ford Pickup Heritage F150 2004

List of elements for 4.2L, A/T Wiring Diagram, 4R70W for Ford Pickup Heritage F150 2004:

• (near breakout to c110)
• (near breakout to g101)
• (near center of dash) data link connector
• (right rear of engine compt)
• (right rear of engine compt) g107
• (top rear of engine)
• 4.2l
• 4.6l, 5.4l
• 4r70w transmission
• 4wd circuit
• 4wd low
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• C175
• C270b
• Central junction box (under left side of dash)
• Cht
• Cylinder head temperature (cht) sensor (4.2l: rear of left cyl head) (4.6l/5.4l: top rear of engine)
• Data
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor
• Instrument cluster system
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127 (left side of vehicle underbody)
• S135
• S136
• S137
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S297 (behind left side of dash)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tcss
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transfer case speed sensor (left rear of trans)
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Vpwr
• Vref

4.6L

4.6L, A/T Wiring Diagram, 4R70W for Ford Pickup Heritage F150 2004

List of elements for 4.6L, A/T Wiring Diagram, 4R70W for Ford Pickup Heritage F150 2004:

• (near breakout to c110)
• (near breakout to g101)
• (near center of dash) data link connector
• (right rear of engine compt)
• (right rear of engine compt) g107
• (top rear of engine)
• 4.2l
• 4.6l, 5.4l
• 4r70w transmission
• 4wd circuit
• 4wd low
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• C175
• C270b
• Central junction box (under left side of dash)
• Cht
• Cylinder head temperature (cht) sensor (4.2l: rear of left cyl head) (4.6l/5.4l: top rear of engine)
• Data
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor
• Instrument cluster system
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127 (left side of vehicle underbody)
• S135
• S136
• S137
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S297 (behind left side of dash)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tcss
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transfer case speed sensor (left rear of trans)
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Vpwr
• Vref

5.4L

5.4L, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004

List of elements for 5.4L, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004:

• (bi- fuel)
• (left side of vehicle underbody)
• (near breakout to c110)
• (near breakout to g101)
• (right rear of engine compt)
• (right rear of engine compt) g107
• (right side of engine compt) powertrain control module (pcm)
• (top rear of engine)
• 4r100 transmission
• 4wd circuit
• 4wd low
• 5.4l super- charged
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• Brake pressure switch
• C175
• C270b
• Ccs
• Central junction box (under left side of dash)
• Cht
• Coast clutch control
• Computer data lines system
• Cylinder head temperature (cht) sensor (top rear of engine)
• Data
• Data link connector (near center of dash)
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G102 (ngv) (right rear of engine compt)
• G104 (except ngv) (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor, ngv timer
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127
• S135
• S136
• S137 (excpt ngv)
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S274
• S297 (behind left side of dash)
• S4021 (near breakout to c432)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Tss
• Turbine shaft speed sensor (left rear of trans)
• Vpwr
• Vref

5.4L, A/T Wiring Diagram, 4R70W for Ford Pickup Heritage F150 2004

List of elements for 5.4L, A/T Wiring Diagram, 4R70W for Ford Pickup Heritage F150 2004:

• (near breakout to c110)
• (near breakout to g101)
• (near center of dash) data link connector
• (right rear of engine compt)
• (right rear of engine compt) g107
• (top rear of engine)
• 4.2l
• 4.6l, 5.4l
• 4r70w transmission
• 4wd circuit
• 4wd low
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• C175
• C270b
• Central junction box (under left side of dash)
• Cht
• Cylinder head temperature (cht) sensor (4.2l: rear of left cyl head) (4.6l/5.4l: top rear of engine)
• Data
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor
• Instrument cluster system
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pnk
• Powertrain control module (pcm) (right side of engine compt)
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127 (left side of vehicle underbody)
• S135
• S136
• S137
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S297 (behind left side of dash)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tcss
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transfer case speed sensor (left rear of trans)
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Vpwr
• Vref

5.4L BI-FUEL GAS/CNG

5.4L Bi-Fuel Gas/CNG, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004

List of elements for 5.4L Bi-Fuel Gas/CNG, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004:

• (bi- fuel)
• (left side of vehicle underbody)
• (near breakout to c110)
• (near breakout to g101)
• (right rear of engine compt)
• (right rear of engine compt) g107
• (right side of engine compt) powertrain control module (pcm)
• (top rear of engine)
• 4r100 transmission
• 4wd circuit
• 4wd low
• 5.4l super- charged
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• Brake pressure switch
• C175
• C270b
• Ccs
• Central junction box (under left side of dash)
• Cht
• Coast clutch control
• Computer data lines system
• Cylinder head temperature (cht) sensor (top rear of engine)
• Data
• Data link connector (near center of dash)
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G102 (ngv) (right rear of engine compt)
• G104 (except ngv) (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor, ngv timer
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127
• S135
• S136
• S137 (excpt ngv)
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S274
• S297 (behind left side of dash)
• S4021 (near breakout to c432)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Tss
• Turbine shaft speed sensor (left rear of trans)
• Vpwr
• Vref

5.4L BI-FUEL GAS/LPG

5.4L Bi-Fuel Gas/LPG, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004

List of elements for 5.4L Bi-Fuel Gas/LPG, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004:

• (bi- fuel)
• (left side of vehicle underbody)
• (near breakout to c110)
• (near breakout to g101)
• (right rear of engine compt)
• (right rear of engine compt) g107
• (right side of engine compt) powertrain control module (pcm)
• (top rear of engine)
• 4r100 transmission
• 4wd circuit
• 4wd low
• 5.4l super- charged
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• Brake pressure switch
• C175
• C270b
• Ccs
• Central junction box (under left side of dash)
• Cht
• Coast clutch control
• Computer data lines system
• Cylinder head temperature (cht) sensor (top rear of engine)
• Data
• Data link connector (near center of dash)
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G102 (ngv) (right rear of engine compt)
• G104 (except ngv) (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor, ngv timer
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127
• S135
• S136
• S137 (excpt ngv)
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S274
• S297 (behind left side of dash)
• S4021 (near breakout to c432)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Tss
• Turbine shaft speed sensor (left rear of trans)
• Vpwr
• Vref

5.4L CNG

5.4L CNG, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004

List of elements for 5.4L CNG, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004:

• (bi- fuel)
• (left side of vehicle underbody)
• (near breakout to c110)
• (near breakout to g101)
• (right rear of engine compt)
• (right rear of engine compt) g107
• (right side of engine compt) powertrain control module (pcm)
• (top rear of engine)
• 4r100 transmission
• 4wd circuit
• 4wd low
• 5.4l super- charged
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• Brake pressure switch
• C175
• C270b
• Ccs
• Central junction box (under left side of dash)
• Cht
• Coast clutch control
• Computer data lines system
• Cylinder head temperature (cht) sensor (top rear of engine)
• Data
• Data link connector (near center of dash)
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G102 (ngv) (right rear of engine compt)
• G104 (except ngv) (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor, ngv timer
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127
• S135
• S136
• S137 (excpt ngv)
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S274
• S297 (behind left side of dash)
• S4021 (near breakout to c432)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Tss
• Turbine shaft speed sensor (left rear of trans)
• Vpwr
• Vref

5.4L SUPERCHARGED

5.4L Supercharged, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004

List of elements for 5.4L Supercharged, A/T Wiring Diagram, 4R100 for Ford Pickup Heritage F150 2004:

• (bi- fuel)
• (left side of vehicle underbody)
• (near breakout to c110)
• (near breakout to g101)
• (right rear of engine compt)
• (right rear of engine compt) g107
• (right side of engine compt) powertrain control module (pcm)
• (top rear of engine)
• 4r100 transmission
• 4wd circuit
• 4wd low
• 5.4l super- charged
• Abs control module
• Autolamp module, anti-theft & warning systems
• Battery junction box (left side of engine compt)
• Bpp sw
• Brake pedal position switch (under left side of dash)
• Brake pressure switch
• C175
• C270b
• Ccs
• Central junction box (under left side of dash)
• Cht
• Coast clutch control
• Computer data lines system
• Cylinder head temperature (cht) sensor (top rear of engine)
• Data
• Data link connector (near center of dash)
• Digital transmission range sensor (left side of transmission)
• Dlc (+)
• Dlc (-)
• Electronic pressure control solenoid
• Engine controls system
• Epc
• Exterior lights module
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G102 (ngv) (right rear of engine compt)
• G104 (except ngv) (left front of engine compt)
• Hot at all times
• Hot in run or start
• Iat
• Ignition coils, radio noise capacitor, ngv timer
• Instrument cluster, anti- theft system
• Intake air temperature sensor (on air intake)
• Nca
• Oss
• Output shaft speed sensor (left side of trans)
• Pcm power diode
• Pcm power relay
• Pwr gnd
• R p
• Red
• S100
• S1003 (near breakout to c140)
• S105
• S116
• S127
• S135
• S136
• S137 (excpt ngv)
• S138
• S140
• S141
• S155 (left rear of engine compt)
• S160 (near breakout to c192)
• S225
• S237
• S274
• S297 (behind left side of dash)
• S4021 (near breakout to c432)
• Shift solenoid a
• Shift solenoid b
• Sig rtn
• Ss a
• Ss b
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission control switch (tcs) (near steering column)
• Transmission fluid temperature sensor
• Tss
• Turbine shaft speed sensor (left rear of trans)
• Vpwr
• Vref