AUTOMOTIVE ELECTRICIANS PORTAL - FZCO

Chevrolet Malibu Hybrid 2008 – 2008 09 GENERAL MOTORS Malibu

Chevrolet Malibu Hybrid 2008 - 2008-09 GENERAL MOTORS Malibu


Chevrolet Malibu Hybrid 2008 - BUZZERS, RELAYS & TIMERS


Chevrolet Malibu Hybrid 2008 BUZZERS, RELAYS & TIMERS LOCATION

Component Location
ACCESSORY Relay Bottom of body control module. See Fig. 56.
A/C CLUTCH Relay Underhood fuse block. See Fig. 54.
AIR PUMP Relay Underhood fuse block. See Fig. 54.
B/U LP Relay Rear fuse block. See Fig. 55.
COOL/FAN SER/PAR Relay Underhood fuse block. See Fig. 54.
COOL/FAN 1 Relay Underhood fuse block. See Fig. 54.
COOL/FAN 2 Relay Underhood fuse block. See Fig. 54.
Door Lock (PCB) Relay Integral to body control module.
Door Unlock (PCB) Relay Integral to body control module.
DR Door Unlock (PCB) Relay Integral to body control module.
DRL Relay Underhood fuse block. See Fig. 54.
FRT FOG Relay Underhood fuse block. See Fig. 54.
FUEL/PMP Relay Rear fuse block. See Fig. 55.
HI/BEAM Relay Underhood fuse block. See Fig. 54.
HORN Relay Underhood fuse block. See Fig. 54.
HVAC BLOWER HIGH Relay Body control module. See Fig. 57.
Interior Light (PCB) Relay Integral to body control module.
LO/BEAM Relay Underhood fuse block. See Fig. 54.
Main Contactor Relay Behind rear seat. See Fig. 11.
POWER/TRN Relay Underhood fuse block. See Fig. 54.
PRK LP Relay Rear fuse block. See Fig. 55.
RUN/CRANK Relay Underhood fuse block. See Fig. 54.
RUN Relay Bottom of body control module. See Fig. 56.
R/WDO DEFOG Relay Rear fuse block. See Fig. 55.
START Relay Underhood fuse block. See Fig. 54.
STOP LP Relay Underhood fuse block. See Fig. 54.
TRANS PMP MTR Relay Underhood fuse block. See Fig. 54.
TRUNK Relay Rear fuse block. See Fig. 55.
WPR 1 Relay Underhood fuse block. See Fig. 54.
WPR 2 Relay Underhood fuse block. See Fig. 54.


Chevrolet Malibu Hybrid 2008 - CIRCUIT PROTECTION DEVICES



Chevrolet Malibu Hybrid 2008 CIRCUIT PROTECTION DEVICES LOCATION

Component Location
Fuse Block - Rear Left side of trunk. See Fig. 53.
Fuse Block - Underhood (2.4L HO, 3.5L, 3.6L) Left side of engine compartment. See Fig. 15.
Fuse Block - Underhood (2.4L Hybrid) Left side of engine compartment. See Fig. 16.
Fusible Link Lower left rear of engine.


Chevrolet Malibu Hybrid 2008 - CONTROL UNITS



Chevrolet Malibu Hybrid 2008 CONTROL UNITS LOCATION

Component Location
Accessory AC/DC Power Control Module Right rear of trunk. See Fig. 28.
Adjustable Pedal Module Left side of dash. See Fig. 23.
Blower Motor Control Module Rear of HVAC case. See Fig. 20.
Body Control Module (BCM) Under center console. See Fig. 21.
Electric Power Steering (EPS) Module On steering column. See Fig. 22.
Electronic Brake Control Module (EBCM) (2.4L HO, 3.5L, 3.6L) Left front strut tower. See Fig. 15.
Electronic Brake Control Module (EBCM) (2.4L Hybrid) Left front strut tower. See Fig. 16.
Engine Control Module (ECM) (2.4L HO, 3.5L, 3.6L) Left front of engine compartment. See Fig. 15.
Engine Control Module (ECM) (2.4L Hybrid) Left rear of engine compartment. See Fig. 16.
Generator Battery Disconnect Control Module Behind rear seat. See Fig. 11.
Heated Seat Control Module - Driver Under driver's seat. See Fig. 25.
Heated Seat Control Module - Passenger Under front passenger's seat. See Fig. 26.
HVAC Control Module Center of dash. See Fig. 18.
Ignition Control Module (ICM) Top right of engine. See Fig. 4.
Inflatable Restraint Front Passenger Presence System (PPS) Module In front passenger's seat cushion. See Fig. 26.
Inflatable Restraint Sensing & Diagnostic Module (SDM) Under center console. See Fig. 29.
Power Steering Control Module On steering column. See Fig. 45.
Radio Antenna Module Right rear of roof. See Fig. 28.
Starter Generator Control Module (SGCM) Left front of engine compartment. See Fig. 16.
Sunroof Control Module Center rear of sunroof. See Fig. 52.
Theft Deterrent Module (TDM) On ignition key cylinder housing. See Fig. 21.
Transmission Control Module (TCM) (BAS/4T45 Mild Hybrid) Left side of engine compartment. See Fig. 16.
Transmission Control Module (TCM) (4 Speed) Lower left front of engine compartment. See Fig. 15.
Vehicle Communications Interface Module (VCIM) Right side of dash. See Fig. 21.


Chevrolet Malibu Hybrid 2008 - MOTORS



Chevrolet Malibu Hybrid 2008 MOTORS LOCATION

Component Location
Adjustable Pedal Actuator Left side of dash. See Fig. 23.
Air Temperature Actuator Center of HVAC module. See Fig. 19.
Blower Motor Right side of HVAC module. See Fig. 20.
Door Latch - Driver Driver's door. See Fig. 31.
Door Latch - Left Rear Left rear door. See Fig. 33.
Door Latch - Passenger Front passenger's door. See Fig. 32.
Door Latch - Right Rear Right rear door. See Fig. 33.
Engine Cooling Fan - Left Behind left side of radiator. See Fig. 13.
Engine Cooling Fan - Right Behind right side of radiator. See Fig. 13.
Fuel Pump & Sender Assembly In fuel tank. See Fig. 36.
Generator Battery Vent Fan Behind rear seat. See Fig. 11.
Heater Coolant Pump Middle rear of engine.
Mode Actuator Right side of HVAC module. See Fig. 19.
Recirculation Actuator Left side of HVAC module. See Fig. 19.
Seat Front Vertical Motor - Driver Under driver's seat. See Fig. 25.
Seat Front Vertical Motor - Passenger Under front passenger's seat. See Fig. 26.
Seat Horizontal Motor - Driver Under driver's seat. See Fig. 25.
Seat Horizontal Motor - Passenger Under front passenger's seat. See Fig. 26.
Seat Rear Vertical Motor - Driver Driver's seat back. See Fig. 25.
Seat Rear Vertical Motor - Passenger Under front passenger's seat. See Fig. 26.
Seat Recline Motor - Driver Driver's seat back. See Fig. 25.
Seat Vertical Motor - Driver Under driver's seat.
Starter Generator Control Module (SGCM) Coolant Pump Next to A/C compressor.
Starter Motor (2.4L) Lower left rear of engine. See Fig. 8.
Starter Motor (3.5L) Lower left rear of engine. See Fig. 5.
Starter Motor (3.6L) Lower left rear of engine. See Fig. 1.
Sunroof Motor Center rear of sunroof. See Fig. 52.
Throttle Actuator (3.5L) Integral to throttle body. See Fig. 5.
Throttle Body (2.4L) Left side of engine. See Fig. 8.
Throttle Body (3.5L) Top rear of engine. See Fig. 5.
Throttle Body (3.6L) Top left rear of engine. See Fig. 58.
Window Motor (LF, RF, LR, RR) In respective door.
Windshield Washer Fluid Pump Bottom of washer fluid reservoir. See Fig. 13.
Windshield Wiper Motor (2.4L HO, 3.5L, 3.6L) Left rear of engine compartment. See Fig. 15.
Windshield Wiper Motor (2.4L Hybrid) Left rear of engine compartment. See Fig. 16.


Chevrolet Malibu Hybrid 2008 - SENDING UNITS & SENSORS



Chevrolet Malibu Hybrid 2008 SENDING UNITS & SENSORS LOCATION

Component Location
Accelerator Pedal Position (APP) Sensor Left side of dash. See Fig. 23.
A/C Refrigerant Pressure Sensor - Electronic Controls Right rear of engine compartment. See Fig. 13.
A/C Refrigerant Pressure Sensor-Manual Controls (3.5L) On high pressure line, at compressor.
A/C Refrigerant Pressure Sensor-Manual Controls (3.6L) Left side of engine compartment, mounted on A/C line.
Adjustable Pedal Position Sensor Left side of dash. See Fig. 21.
Air Temperature Sensor - Lower Lower center of HVAC module. See Fig. 19.
Air Temperature Sensor - Upper Center of HVAC module. See Fig. 19.
Ambient Air Temperature Sensor Center front of engine compartment. See Fig. 14.
Ambient Light Sensor Top center of dash. See Fig. 18.
Automatic Transmission Fluid Temperature (TFT) Sensor (4 Speed) In automatic transmission. See Fig. 12.
Automatic Transmission Input Shaft Speed (ISS) Sensor (4 Speed) In automatic transmission. See Fig. 12.
Automatic Transmission Input Shaft Speed (ISS) Sensor (6 Speed) In automatic transmission. See Fig. 59.
Automatic Transmission Output Shaft Speed (OSS) Sensor (4 Speed) In automatic transmission. See Fig. 12.
Automatic Transmission Output Shaft Speed (OSS) Sensor (6 Speed) In automatic transmission. See Fig. 59.
Battery Current Sensor (Rear) Behind rear seat. See Fig. 11.
Battery Current Sensor (2.4L HO, 3.5L, 3.6L) Under battery. See Fig. 15.
Battery Current Sensor (2.4L Hybrid) Near battery. See Fig. 16.
Brake Booster Vacuum Sensor On power brake booster. See Fig. 16.
Brake Fluid Pressure Sensor On EBCM. See Fig. 61.
Brake Master Cylinder Pressure Sensor Below master cylinder. See Fig. 16.
Brake Pedal Position (BPP) Sensor Left side of dash. See Fig. 21.
Camshaft Position (CMP) Sensor Top center front of engine. See Fig. 7.
Camshaft Position (CMP) Sensor - Bank 1 Exhaust Front of right cylinder bank. See Fig. 58.
Camshaft Position (CMP) Sensor - Bank 1 Intake Front of right cylinder bank. See Fig. 58.
Camshaft Position (CMP) Sensor - Bank 2 Exhaust Front of left cylinder bank. See Fig. 58.
Camshaft Position (CMP) Sensor - Bank 2 Intake Front of left cylinder bank. See Fig. 58.
Camshaft Position (CMP) Sensor - Exhaust Right rear of engine. See Fig. 8.
Camshaft Position (CMP) Sensor - Intake Left rear of engine. See Fig. 8.
Crankshaft Position (CKP) Sensor (2.4L BAS) Lower left rear of engine.
Crankshaft Position (CKP) Sensor (2.4L HO) Lower left rear of engine.
Crankshaft Position (CKP) Sensor (3.5L) Lower right side of engine. See Fig. 3.
Crankshaft Position (CKP) Sensor (3.6L) Lower right rear of engine. See Fig. 1.
Engine Coolant Temperature (ECT) Sensor (2.4L) Lower right rear of engine. See Fig. 9.
Engine Coolant Temperature (ECT) Sensor (3.5L) In front cylinder head, below throttle body. See Fig. 3.
Engine Coolant Temperature (ECT) Sensor (3.6L) Left side of engine. See Fig. 58.
Engine Oil Level Sensor Bottom of engine oil pan. See Fig. 1.
Engine Oil Pressure (EOP) Sensor Lower left side of engine. See Fig. 3.
Fuel Tank Pressure (FTP) Sensor Integral to fuel pump & sender assembly. See Fig. 36.
Generator Battery Temperature Sensor 1 Behind rear seat, on side of generator battery 1. See Fig. 11.
Generator Battery Temperature Sensor 2 Behind rear seat, on side of generator battery 2. See Fig. 11.
Generator Battery Temperature Sensor 3 Behind rear seat, on side of generator battery 3. See Fig. 11.
Heated Oxygen Sensor (HO2S) Bank 1 Sensor 1 (3.5L) Right exhaust manifold. See Fig. 4.
Heated Oxygen Sensor (HO2S) Bank 1 Sensor 1 (3.6L) Right exhaust manifold. See Fig. 6.
Heated Oxygen Sensor (HO2S) Bank 1 Sensor 2 (3.6L) Downstream of right catalytic converter. See Fig. 6.
Heated Oxygen Sensor (HO2S) Bank 2 Sensor 1 (3.5L) Left exhaust manifold. See Fig. 5.
Heated Oxygen Sensor (HO2S) Bank 2 Sensor 1 (3.6L) Left exhaust manifold. See Fig. 6.
Heated Oxygen Sensor (HO2S) Bank 2 Sensor 2 (3.6L) Downstream of left catalytic converter. See Fig. 6.
Heated Oxygen Sensor (HO2S) 1 Upstream of catalytic converter. See Fig. 9.
Heated Oxygen Sensor (HO2S) 2 Downstream of catalytic converter. See Fig. 9.
Inflatable Restraint Front End Sensor - Left Left front of engine compartment. See Fig. 14.
Inflatable Restraint Front End Sensor - Right Right front of engine compartment. See Fig. 14.
Inflatable Restraint Front Passenger Presence System (PPS) Sensor In front passenger's seat cushion.
Inflatable Restraint Side Impact (SIS) Sensor - Left Driver's door. See Fig. 31.
Inflatable Restraint Side Impact (SIS) Sensor - Right Front passenger's door. See Fig. 32.
Knock Sensor (KS) Above starter motor. See Fig. 9.
Knock Sensor (KS) 1 (3.5L) Lower left side of engine. See Fig. 3.
Knock Sensor (KS) 1 (3.6L) Lower left side of engine. See Fig. 1.
Knock Sensor (KS) 2 (3.5L) Lower right side of engine. See Fig. 3.
Knock Sensor (KS) 2 (3.6L) Lower right side of engine. See Fig. 1.
Manifold Absolute Pressure (MAP) Sensor (2.4L) Top left side of engine. See Fig. 8.
Manifold Absolute Pressure (MAP) Sensor (3.5L) Top of engine. See Fig. 4.
Manifold Absolute Pressure (MAP) Sensor (3.6L) Top rear of engine. See Fig. 58.
Mass Air Flow (MAF)/ Intake Air Temperature (IAT) Sensor (2.4L HO, 3.5L, 3.6L) At air cleaner. See Fig. 15.
Mass Air Flow (MAF)/ Intake Air Temperature (IAT) Sensor (2.4L Hybrid) At air cleaner. See Fig. 16.
Steering Wheel Position Sensor Base of steering column. See Fig. 63.
Sunload Sensor Center of dash. See Fig. 18.
Tire Pressure Sensor (LF, LR, RF, RR) Inside respective valve stems. See Fig. 35.
Wheel Speed Sensor (Left/Right Front & Left/Right Rear) Respective wheel hub assemblies. See Fig. 34.
Yaw & Lateral Accelerometer Sensor Under center console. See Fig. 29.


Chevrolet Malibu Hybrid 2008 - SOLENOIDS & SOLENOID VALVES



Chevrolet Malibu Hybrid 2008 SOLENOIDS & SOLENOID VALVES LOCATION

Component Location
A/C Compressor Clutch (2.4L) Front of A/C compressor. See Fig. 8.
A/C Compressor Clutch (3.5L) Front of A/C compressor. See Fig. 5.
A/C Compressor Clutch (3.6L) Front of A/C compressor. See Fig. 58.
Automatic Transmission Shift Lock Control Solenoid On floor shifter. See Fig. 24.
Camshaft Position (CMP) Actuator Solenoid Valve Center of timing cover.
Camshaft Position (CMP) Actuator Solenoid Valve - Bank 1 Exhaust Front of right cylinder bank. See Fig. 58.
Camshaft Position (CMP) Actuator Solenoid Valve - Bank 1 Intake Front of right cylinder bank. See Fig. 58.
Camshaft Position (CMP) Actuator Solenoid Valve - Bank 2 Exhaust Front of left cylinder bank. See Fig. 58.
Camshaft Position (CMP) Actuator Solenoid Valve - Bank 2 Intake Front of left cylinder bank. See Fig. 58.
Camshaft Position (CMP) Actuator Solenoid Valve - Exhaust Top front of engine. See Fig. 8.
Camshaft Position (CMP) Actuator Solenoid Valve - Intake Top front of engine. See Fig. 8.
Control Solenoid Valve Assembly (W/TCM) (6 Speed) Rear of automatic transmission. See Fig. 59.
Evaporative Emission (EVAP) Canister Purge Solenoid Valve (2.4L) Top rear of engine. See Fig. 8.
Evaporative Emission (EVAP) Canister Purge Solenoid Valve (3.5L) Top left rear of engine. See Fig. 5.
Evaporative Emission (EVAP) Canister Purge Solenoid Valve (3.6L) Top right front of engine. See Fig. 58.
Evaporative Emission (EVAP) Canister Vent Solenoid Valve Right rear of fuel tank. See Fig. 36.
Fuel Injector 1 (2.4L) Top of cylinder No. 1. See Fig. 10.
Fuel Injector 1 (3.5L) Top of cylinder No. 1. See Fig. 7.
Fuel Injector 1 (3.6L) Top of cylinder No. 1. See Fig. 2.
Fuel Injector 2 (2.4L) Top of cylinder No. 2. See Fig. 10.
Fuel Injector 2 (3.5L) Top of cylinder No. 2. See Fig. 7.
Fuel Injector 2 (3.6L) Top of cylinder No. 2. See Fig. 2.
Fuel Injector 3 (2.4L) Top of cylinder No. 3. See Fig. 10.
Fuel Injector 3 (3.5L) Top of cylinder No. 3. See Fig. 7.
Fuel Injector 3 (3.6L) Top of cylinder No. 3. See Fig. 2.
Fuel Injector 4 (2.4L) Top of cylinder No. 4. See Fig. 10.
Fuel Injector 4 (3.5L) Top of cylinder No. 4. See Fig. 7.
Fuel Injector 4 (3.6L) Top of cylinder No. 4. See Fig. 2.
Fuel Injector 5 (3.5L) Top of cylinder No. 5. See Fig. 7.
Fuel Injector 5 (3.6L) Top of cylinder No. 5. See Fig. 2.
Fuel Injector 6 (3.5L) Top of cylinder No. 6. See Fig. 7.
Fuel Injector 6 (3.6L) Top of cylinder No. 6. See Fig. 2.
Intake Manifold Tuning (IMT) Solenoid Valve Top right front of engine. See Fig. 58.
Pressure Control (PC) Solenoid Valve (4 Speed) In automatic transmission. See Fig. 12.
Starter Solenoid (2.4L) Integral to starter motor. See Fig. 8.
Starter Solenoid (3.5L) Integral to starter motor. See Fig. 5.
Starter Solenoid (3.6L) Integral to starter motor. See Fig. 1.
Torque Converter Clutch (TCC) Pulse Width Modulation (PWM) Solenoid Valve (4 Speed) In automatic transmission. See Fig. 12.
1-2, 4-3 Shift Solenoid (SS) Valve Assembly (4 Speed) In automatic transmission. See Fig. 12.
2-3 Shift Solenoid (SS) Valve Assembly (4 Speed) In automatic transmission. See Fig. 12.


Chevrolet Malibu Hybrid 2008 - SWITCHES



Chevrolet Malibu Hybrid 2008 SWITCHES LOCATION

Component Location
Automatic Transmission Fluid Pressure (TFP) Manual Valve Position Switch (4 Speed) In automatic transmission. See Fig. 12.
Battery Disconnect Switch Behind rear seat. See Fig. 11.
Brake Fluid Level Switch (2.4L HO, 3.5L, 3.6L) On brake master cylinder reservoir. See Fig. 15.
Brake Fluid Level Switch (2.4L Hybrid) On brake master cylinder reservoir. See Fig. 16.
Engine Oil Pressure (EOP) Switch (2.4L) Lower left rear of engine. See Fig. 8.
Engine Oil Pressure (EOP) Switch (3.6L) Lower left front of engine. See Fig. 1.
Hood Ajar Switch On hood latch. See Fig. 17.
Internal Mode Switch (IMS) Top of automatic transmission. See Fig. 12.
Park Brake Switch Left kick panel. See Fig. 62.
Park/Neutral Position (PNP) Switch (4 Speed) On automatic transmission. See Fig. 60.
Seat Belt Switch - Driver Integral to driver's seat belt buckle assembly. See Fig. 25.
Seat Belt Switch - Passenger Integral to front passenger's seat belt buckle assembly. See Fig. 26.
Transmission Manual Shift Shaft Switch (4 Speed) In automatic transmission. See Fig. 12.
Transmission Manual Shift Shaft Switch (6 Speed) In automatic transmission. See Fig. 59.
Windshield Washer Fluid Level Switch Bottom of washer fluid reservoir. See Fig. 13.


Chevrolet Malibu Hybrid 2008 - MISCELLANEOUS



Chevrolet Malibu Hybrid 2008 MISCELLANEOUS LOCATION

Component Location
Audio Amplifier Right rear of trunk. See Fig. 28.
Battery Left side of engine compartment.
Blower Motor Resistor Right side of dash. See Fig. 20.
Cellular & Digital Radio Antenna Center rear of roof. See Fig. 28.
Cellular Telephone Microphone Center front of roof. See Fig. 51.
Data Link Connector (DLC) Left side of dash. See Fig. 18.
Digital Radio Receiver Under center of rear package shelf. See Fig. 28.
Engine Block Heater Lower right side of engine. See Fig. 3.
Engine Cooling Fan Diode - Left Engine harness, between left cooling fan & crankshaft position sensor.
Engine Cooling Fan Diode - Right Engine harness, between right cooling fan & A/C compressor breakout.
Generator Battery 1 Behind rear seat. See Fig. 11.
Generator Battery 2 Behind rear seat. See Fig. 11.
Generator Battery 3 Behind rear seat. See Fig. 11.
Generator (2.4L HO) Lower left front of engine. See Fig. 8.
Generator (3.5L) Top right front of engine. See Fig. 5.
Generator (3.6L) Left front of engine. See Fig. 58.
Heated Seat Element - Driver Back Driver's seat back. See Fig. 25.
Heated Seat Element - Driver Cushion Driver's seat cushion. See Fig. 25.
Heated Seat Element - Passenger Back Front passenger's seat back. See Fig. 26.
Heated Seat Element - Passenger Cushion Front passenger's seat cushion. See Fig. 26.
Horn Assembly Left front of engine compartment. See Fig. 13.
Ignition Coil Integral to ignition control module. See Fig. 4.
Ignition Coil 1 (2.4L) Above cylinder No. 1. See Fig. 8.
Ignition Coil 1 (3.6L) Top of right cylinder bank. See Fig. 1.
Ignition Coil 2 (2.4L) Above cylinder No. 2. See Fig. 8.
Ignition Coil 2 (3.6L) Top of left cylinder bank. See Fig. 58.
Ignition Coil 3 (2.4L) Above cylinder No. 3. See Fig. 8.
Ignition Coil 3 (3.6L) Top of right cylinder bank. See Fig. 1.
Ignition Coil 4 (2.4L) Above cylinder No. 4. See Fig. 8.
Ignition Coil 4 (3.6L) Top of left cylinder bank. See Fig. 58.
Ignition Coil 5 (3.6L) Top of right cylinder bank. See Fig. 1.
Ignition Coil 6 (3.6L) Top of left cylinder bank. See Fig. 58.
Inflatable Restraint I/P Module Right side of dash. See Fig. 21.
Inflatable Restraint Roof Rail Module - Left Front Rear of left roof rail. See Fig. 29.
Inflatable Restraint Roof Rail Module - Right Front Rear of right roof rail. See Fig. 29.
Inflatable Restraint Side Impact Module - Left Left side of driver's seat back. See Fig. 27.
Inflatable Restraint Side Impact Module - Right Right side of front passenger's seat back. See Fig. 27.
Inflatable Restraint Steering Wheel Module In steering wheel. See Fig. 18.
Inflatable Restraint Steering Wheel Module Coil Top of steering column. See Fig. 22.
Remote Control Door Lock Receiver (RCDLR) Under center of rear window shelf. See Fig. 28.
Remote Start Antenna Right rear of roof. See Fig. 28.
Seat Belt Pretensioner - Driver Base of left "B" pillar. See Fig. 30.
Seat Belt Pretensioner - Passenger Base of right "B" pillar. See Fig. 30.
Starter Generator Lower left front of engine. See Fig. 8.
Windshield Wiper High Speed Diode Body harness, between main branch & brake sensors breakout.
Windshield Wiper Low Speed Diode Body harness, between main branch & brake sensors breakout.


Chevrolet Malibu Hybrid 2008 - CONNECTORS



Chevrolet Malibu Hybrid 2008 CONNECTORS LOCATION

Component Location
X100 (2.4L) (Black/Gray, 20 Pin) Left rear of engine. See Fig. 65.
X100 (3.5L) (Black, 14 Pin) Left rear of engine. See Fig. 41.
X101 (Black, 2 Pin) Left rear of engine compartment. See Fig. 43.
X102 (Black, 2 Pin) Right rear of engine compartment. See Fig. 43.
X103 (Black, 8 Pin) Left front of engine compartment. See Fig. 41.
X108 (2.4L BAS) (Black, 16 Pin) Rear of engine. See Fig. 64.
X108 (2.4L HO) (Black, 16 Pin) Top of transmission. See Fig. 65.
X108 (3.5L) (Black, 16 Pin) Left front of engine compartment. See Fig. 41.
X108 (3.6L) (Black, 8 Pin) Left front of engine compartment. See Fig. 40.
X109 (White, 5 Pin) Left front corner of engine compartment. See Fig. 37.
X110 (White, 5 Pin) Right front corner of engine compartment. See Fig. 37.
X130 (2.4L BAS) (Black, 8 Pin) Top of engine. See Fig. 38.
X130 (2.4L HO) (Black, 8 Pin) Left front of engine. See Fig. 65.
X130 (3.5L) (Black, 16 Pin) Left front of engine. See Fig. 41.
X130 (3.6L) (Black, 8 Pin) Top of engine. See Fig. 40.
X180 (Gray, 2 Pin) Left front of engine compartment. See Fig. 37.
X181 (Gray, 2 Pin) Right front of engine compartment. See Fig. 37.
X206 (Light Gray, 22 Pin) Left side of dash. See Fig. 44.
X207 (Light Gray, 22 Pin) Right side of dash. See Fig. 44.
X208 (Yellow, 4 Pin) Left side of dash. See Fig. 44.
X216 (Yellow, 4 Pin) Right side of dash.
X300 (Black, 12 Pin) Under driver's seat. See Fig. 46.
X303 (Black, 8 Pin) Under floor console. See Fig. 47.
X304 (W/O UK6) (Black, 5 Pin) Under floor console, at shifter. See Fig. 47.
X304 (W/UK6) (Black, 30 Pin) Under floor console, at shifter. See Fig. 47.
X307 (Black, 2 Pin) Under front passenger's seat.
X308 (Yellow, 2 Pin) Under driver's seat. See Fig. 46.
X309 (Yellow, 2 Pin) Under front passenger's seat. See Fig. 47.
X310 (Black, 16 Pin) Under front passenger's seat. See Fig. 47.
X351 (Black, 2 Pin) Left "C" pillar. See Fig. 48.
X401 (White, 5 Pin) Left rear of trunk. See Fig. 68.
X402 (White, 5 Pin) Right rear of trunk. See Fig. 68.
X403 (Black, 4 Pin) Under right rear of vehicle. See Fig. 49.
X404 (Black, 2 Pin) Under left side of rear package shelf.
X407 (Black, 8 Pin) Right side of battery storage compartment. See Fig. 66.
X411 (Yellow, 2 Pin) Left "C" pillar. See Fig. 48.
X412 (Yellow, 2 Pin) Right "C" pillar. See Fig. 49.
X413 (Black, 10 Pin) Under right rear of vehicle. See Fig. 49.
X415 (Black, 12 Pin) Top of left "C" pillar.
X420 (Black, 2 Pin) Inside generator battery assembly.
X495 (Black, 2 Pin) Behind center of rear bumper fascia. See Fig. 50.
X500 (Gray, 40 Pin) Left kick panel. See Fig. 46.
X501 (Gray, 40 Pin) Driver's door.
X600 (Gray, 40 Pin) Right kick panel. See Fig. 47.
X601 (Black, 18 Pin) Front passenger's door.
X700 (Black, 14 Pin) Left "B" pillar. See Fig. 46.
X701 (Black, 8 Pin) Left rear door. See Fig. 67.
X800 (Black, 14 Pin) Right "B" pillar. See Fig. 47.
X801 (Black, 8 Pin) Right rear door. See Fig. 67.


Chevrolet Malibu Hybrid 2008 - GROUNDS



Chevrolet Malibu Hybrid 2008 GROUNDS LOCATION

Component Location
G101 Left front corner of engine compartment. See Fig. 37.
G102 Right front corner of engine compartment. See Fig. 37.
G103 Left rear of engine compartment. See Fig. 45.
G104 Left front corner of engine compartment. See Fig. 37.
G105 (2.4L BAS) Lower left rear of engine. See Fig. 38.
G105 (3.5L) On engine transmission stud.
G105 (3.6L) Left side of engine.
G106 (2.4L BAS) Left rear of engine. See Fig. 38.
G106 (2.4L HO) Left rear of engine. See Fig. 65.
G106 (3.5L) Center rear of engine. See Fig. 41.
G106 (3.6L) Right front of engine. See Fig. 39.
G107 (2.4L) Lower left side of engine. See Fig. 65.
G107 (3.5L) Left rear of engine. See Fig. 41.
G107 (3.6L) Center rear of engine. See Fig. 40.
G108 In engine compartment.
G109 Left front corner of engine compartment. See Fig. 37.
G110 (2.4L BAS) Right rear of engine. See Fig. 64.
G110 (2.4L HO) Right rear of engine. See Fig. 42.
G111 Right rear of engine. See Fig. 39.
G113 Left rear of engine. See Fig. 40.
G201 Under center console. See Fig. 44.
G203 Under center console. See Fig. 44.
G301 Right "C" pillar. See Fig. 49.
G302 Left "C" pillar. See Fig. 48.
G303 Left kick panel. See Fig. 46.
G304 Right kick panel. See Fig. 47.
G305 Right kick panel. See Fig. 47.
G401 Left rear of trunk. See Fig. 68.
G402 Right side of battery storage compartment. See Fig. 66.
G403 Left rear of trunk. See Fig. 68.


Chevrolet Malibu Hybrid 2008 - SPLICES



Chevrolet Malibu Hybrid 2008 SPLICES LOCATION

Component Location
J101 Engine harness, 50 mm from inline to transmission breakout.
J102 Engine harness, 80 mm from starter generator X2 breakout.
J103 Engine harness, 100 mm from inline to transmission breakout.
J105 Engine harness, 30 mm from TAC module breakout.
J106 Fuel injector wiring harness, 3 cm from breakout to fuel injector 3.
J109 Left headlamp wiring harness.
J111 Engine harness, 16 cm from battery ground terminal breakout.
J114 Fuel injector harness, between X130 & even numbered fuel injectors.
J118 Engine wiring harness, 7.5 cm from breakout to PCM.
J119 Engine wiring harness, 15 cm from left cooling fan connector breakout. See Fig. 40.
J121 Engine harness, 40 mm from main breakout. See Fig. 42.
J130 Fuel injector harness, 4 cm from breakout to fuel injector 2.
J150 Engine harness, 40 mm from A/C compressor breakout.
J151 Engine harness, 305 mm from main breakout.
J152 Engine harness, 90 mm from A/C compressor breakout.
J153 Engine harness, 355 mm from main breakout.
J198 Engine harness, 5 cm from ignition coil 5 breakout. See Fig. 39.
J199 Engine harness, 5 cm from main branch.
J201 Behind inflatable restraint wheel module.
J202 Behind inflatable restraint wheel module.
J203 Behind inflatable restraint wheel module.
J209 Behind inflatable restraint wheel module.
J301 Driver's heated seat harness, 5 cm from main branch.
J302 Driver's power seat harness, between driver's seat adjuster switch & X300.
J305 Front passenger's presence sensor harness, between inline connector & heated seat control module.
J401 Panoramic roof harness, between sunroof control module & sunroof shade module.
J402 Right tail lamp assembly harness, between inline connector & left rear maps breakout.
J403 Panoramic roof harness, between inline connector X415 & sunroof control module.
J404 Right tail lamp assembly, between inline connector & right rear lamps breakout.
J405 Panoramic roof harness, between sunroof shade module & sunroof control module.
J406 Left tail lamp assembly harness, between inline connector & left rear lamps breakout.
J407 Generator battery assembly harness, between battery disconnect switch & generator battery disconnect control module.
J408 Left tail lamp assembly harness, between inline connector & right rear lamps breakout.
J500 Left trim pad door harness, 6 cm from main branch.


Chevrolet Malibu Hybrid 2008 - COMPONENT LOCATION GRAPHICS


NOTE:
Fig.res may show multiple component locations. - appropriate table for proper figure references.

Chevrolet Malibu Hybrid 2008 - Component Locations -  Left & Right Rear Of Engine (3.6L)
Fig. 1: Chevrolet Malibu Hybrid 2008 - Component Locations - Left & Right Rear Of Engine (3.6L)


Fig. 2: Chevrolet Malibu Hybrid 2008 - Component Locations - Top Of Engine (3.6L)


Fig. 3: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Of Engine (3.5L)


Fig. 4: Chevrolet Malibu Hybrid 2008 - Component Locations - Right Side Of Engine (3.5L)


Fig. 5: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear & Left Side Of Engine (3.5L)


Fig. 6: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine (3.6L)


Fig. 7: Chevrolet Malibu Hybrid 2008 - Component Locations - Top Of Engine (3.5L)


Fig. 8: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear & Left Side Of Engine (2.4L)


Fig. 9: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Side & Rear Of Engine (2.4L)


Fig. 10: Chevrolet Malibu Hybrid 2008 - Component Locations - Top Of Engine (2.4L)


Fig. 11: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Of Vehicle (Hybrid)


Fig. 12: Chevrolet Malibu Hybrid 2008 - Component Locations - Automatic Transmission (4 Speed)


Fig. 13: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment


Fig. 14: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment


Fig. 15: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment (2.4L HO, 3.5L, 3.6L)


Fig. 16: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment (2.4L Hybrid)


Fig. 17: Chevrolet Malibu Hybrid 2008 - Component Locations - Front Of Engine Compartment


Fig. 18: Chevrolet Malibu Hybrid 2008 - Component Locations - Dash & Center Console


Fig. 19: Chevrolet Malibu Hybrid 2008 - Component Locations - HVAC Module


Fig. 20: Chevrolet Malibu Hybrid 2008 - Component Locations - HVAC Module


Fig. 21: Chevrolet Malibu Hybrid 2008 - Component Locations - Dash


Fig. 22: Chevrolet Malibu Hybrid 2008 - Component Locations - Steering Column


Fig. 23: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Side Of Dash


Fig. 24: Chevrolet Malibu Hybrid 2008 - Component Locations - Console Shifter


Fig. 25: Chevrolet Malibu Hybrid 2008 - Component Locations - Driver's Heated Seat


Fig. 26: Chevrolet Malibu Hybrid 2008 - Component Locations - Front Passenger's Heated Seat


Fig. 27: Chevrolet Malibu Hybrid 2008 - Component Locations - Front Seats


Fig. 28: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Of Vehicle


Fig. 29: Chevrolet Malibu Hybrid 2008 - Component Locations - Vehicle Overview (Inflatable Restraints)


Fig. 30: Chevrolet Malibu Hybrid 2008 - Component Locations - Left & Right "B" Pillars


Fig. 31: Chevrolet Malibu Hybrid 2008 - Component Locations - Driver's Door


Fig. 32: Chevrolet Malibu Hybrid 2008 - Component Locations - Front Passenger's Door


Fig. 33: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Doors


Fig. 34: Chevrolet Malibu Hybrid 2008 - Component Locations - Front & Rear Wheel Hub Assemblies


Fig. 35: Chevrolet Malibu Hybrid 2008 - Component Locations - Tire Pressure Sensors


Fig. 36: Chevrolet Malibu Hybrid 2008 - Component Locations - Fuel Tank


Fig. 37: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment


Fig. 38: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment (2.4L BAS)


Fig. 39: Chevrolet Malibu Hybrid 2008 - Component Locations - Right Side Of Engine (3.6L)


Fig. 40: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine (3.6L)


Fig. 41: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine (3.5L VVT)


Fig. 42: Chevrolet Malibu Hybrid 2008 - Component Locations - Right Side Of Engine (2.4L HO)


Fig. 43: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment


Fig. 44: Chevrolet Malibu Hybrid 2008 - Component Locations - Dash & Center Console


Fig. 45: Chevrolet Malibu Hybrid 2008 - Component Locations - Steering Column


Fig. 46: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Front Of Passenger Compartment


Fig. 47: Chevrolet Malibu Hybrid 2008 - Component Locations - Right Front Of Passenger Compartment


Fig. 48: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Rear Of Passenger Compartment


Fig. 49: Chevrolet Malibu Hybrid 2008 - Component Locations - Right Rear Of Passenger Compartment


Fig. 50: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Fascia & Trunk Lid


Fig. 51: Chevrolet Malibu Hybrid 2008 - Component Locations - Roof


Fig. 52: Chevrolet Malibu Hybrid 2008 - Component Locations - Sunroof


Fig. 53: Chevrolet Malibu Hybrid 2008 - Component Locations - Trunk


Fig. 54: Chevrolet Malibu Hybrid 2008 - Component Locations - Underhood Fuse Block


Fig. 55: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Fuse Block


Fig. 56: Chevrolet Malibu Hybrid 2008 - Component Locations - Body Control Module (BCM) (Bottom View)


Fig. 57: Chevrolet Malibu Hybrid 2008 - Component Locations - Body Control Module (BCM)


Fig. 58: Chevrolet Malibu Hybrid 2008 - Component Locations - Front & Left Side Of Engine (3.6L)


Fig. 59: Chevrolet Malibu Hybrid 2008 - Component Locations - Automatic Transmission (6 Speed)


Fig. 60: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Rear Of Engine Compartment


Fig. 61: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Rear Of Engine Compartment


Fig. 62: Chevrolet Malibu Hybrid 2008 - Component Locations - Left Kick Panel


Fig. 63: Chevrolet Malibu Hybrid 2008 - Component Locations - Steering Column


Fig. 64: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine Compartment (2.4L BAS)


Fig. 65: Chevrolet Malibu Hybrid 2008 - Component Locations - Engine (2.4L HO)


Fig. 66: Chevrolet Malibu Hybrid 2008 - Component Locations - Hybrid Battery Storage Compartment


Fig. 67: Chevrolet Malibu Hybrid 2008 - Component Locations - Rear Doors


Fig. 68: Chevrolet Malibu Hybrid 2008 - Component Locations - Trunk