INSTRUMENT CLUSTER – Chevrolet Chevy Express G2500 2000 – SYSTEM WIRING DIAGRAMS

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram (1 of 2) for Chevrolet Chevy Express G2500 2000

List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Chevrolet Chevy Express G2500 2000:

• (4.3l/6.5l/7.4l: left side of eng, on cylinder head, 5.0l/5.7l: left cylinder head, between two front spark plugs)
• (7 bulbs)
• (diesel only)
• (engine harn, 14 cm from knock sensor) (4.3l) (engine harn, 8 cm from injector harn breakout) (5.0/5.7l) (engine harn, 10 cm from input shaft sensor) (7.4l) (engine harn, 4 cm from brake pressure differential switch) (6.5l diesel)
• (not used)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• Acc
• Air bag ind
• Anti-lock brakes system
• Anti-lock brakes warning ind
• Anti-theft system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• Bat ind
• Brake ind ctl
• Brake lamp ctl
• Brake pressure differential switch (part of electronic brake control module, left frame rail)
• Brake psi in
• Brake warning ind
• Check gauges ind
• Check gauges lamp driver
• Daytime running lamps control module (under left side of dash, taped to harness)
• Diesel only
• Diode-i d101
• Drl lamp ind
• Electronic brake control module (ebcm) (left framerail, near center of vehicle)
• Eng-i mini fuse 20a
• Engine controls system
• Engine coolant temperature gauge sensor
• Exterior lights system
• Fuel gauge
• G101 (right side of engine compt, near fender well)
• G117 (5.0, 5.7, 7.4l) (rear of right cylinder head)
• G125 (4.3, 6.5l) (at generator bracket)
• G125 (front of engine, near thermostat housing)
• G200 (behind left kick panel)
• Gauges fuse 4 10a
• Gnd
• Headlights system
• High beam ind
• Hot in run or start
• I/p fuse block (lower left kick panel)
• Ign
• Ign feed
• Ignition switch
• Illumin- ation lamps
• Ind ctrl
• Instrument cluster
• Interior lights system
• Left turn ind
• Lock
• Low coolant ind (diesel)
• Low engine coolant level indicator module (diesel only) (under left side of dash)
• Low engine coolant level indicator sensor (diesel only) (under coolant recovery/surge tank)
• Off
• Oil pressure gauge
• Park/neutral position switch (left side of transmission)
• Pk brake
• Pnk
• Prndl circuit board
• Right turn ind
• Run
• S101
• S118
• S130
• S156
• S201
• S202
• S216
• S254
• Safety belt ind
• Security ind
• Service engine soon ind
• Service throttle soon ind (diesel)
• Solid state
• Speedometer/ odometer
• Start
• Starting/charging system
• Tan
• Temp gauge
• Underhood fuse/relay center (left side of eng compt)
• Underhood fuse/relay center (on left side of eng compt)
• Volt- meter
• Wait to start ind (diesel)
• Warning system
• Water in fuel ind (diesel)
• Water-in-fuel sensor (diesel only) (left frame rail, near center of vehicle)

Instrument Cluster Wiring Diagram (2 of 2) for Chevrolet Chevy Express G2500 2000

List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Chevrolet Chevy Express G2500 2000:

• (behind center of dash)
• (diesel only)
• (i/p harn, approx 21 cm from hvac switch breakout) s247
• +5v ref
• 1.5k
• Anti-lock brakes system
• Batt
• Brake fuse 18 10a
• Diesel
• Engine oil pressure gauge sender (top rear of engine)
• Engine oil pressure gauge sensor (top rear of engine)
• Fuel level
• Fuel pump & sender (in fuel tank)
• Fuel sender buffer module
• Fuel sig
• Fuel tank level sender (in fuel tank)
• G116 (left side of engine compt, under brake master cylinder)
• G125 (front of engine, near thermostat housing)
• Gasoline
• Gnd
• Hot in acc or run
• Hot in run
• I/p fuse block (lower left kick panel)
• Ign
• Ignition
• Inline diode d202 (near park brake switch)
• Low flow
• Low pres.
• P/b booster fluid flow & pressure alarm delay module
• P/b booster fluid flow alarm
• P/b booster fluid flow alarm switch
• P/b booster fluid pressure alarm switch
• Park brake warning switch
• Passlock module (behind center of dash)
• Pnk
• Powertrain control module (behind center of dash)
• Radio
• Resistor r208 (w/ uj1) (near i/p fuse block)
• S210
• S238 (i/p harn, 4 cm from cluster breakout)
• S246 (i/p harn, approx 25 cm from hvac switch breakout)
• S254
• Sens gnd
• Sense sw
• Sig in
• Tan
• Tank signal
• Trans fuse 20 10a
• Twisted pair
• Vehicle control module (on left side of eng compt)
• Vehicle speed sensor (left side of transmission)
• Vehicle speed sensor buffer (diesel only) (below dash, near steering column)
• Vss high
• Vss low
• Vss out
• Vss sen
• W/ p/b booster warning option, rpo code-uj1