Diagram sections — 24 (55 total)
AIR CONDITIONING ANTI-LOCK BRAKES BODY COMPUTER COMPUTER DATA LINES CRUISE CONTROL ENGINE PERFORMANCE EXTERIOR LIGHTS GROUND DISTRIBUTION HEADLIGHTS HORN INSTRUMENT CLUSTER INTERIOR LIGHTS POWER DISTRIBUTION POWER DOOR LOCKS POWER MIRRORS POWER SEATS POWER WINDOWS RADIO SHIFT INTERLOCKS STARTING/CHARGING SUPPLEMENTAL RESTRAINTS TRANSMISSION WARNING SYSTEMS WIPER/WASHER
AIR CONDITIONING A/C Wiring Diagram for Ford Ranger Splash 1996 List of elements for A/C Wiring Diagram for Ford Ranger Splash 1996: 36 (top center of left fender apron) A/c clutch diode A/c clutch field coil A/c pressure cutoff switch (left fron of engine on a/c line) A/c-heater control assembly Blend door actuator (behind right side of i/p) Blower motor Blower motor fuse 40a Blower motor relay (in relay box 2) Blower motor resistor assembly (right rear of engine comparment) Blower switch C231 C233 C234 Clutch cycling pressure switch (right rear of engine compartment, on accumulator) Def Engine compartment fuse/relay box Flr Flr/def Fuse 15a Fuse 7.5a G102 Hot at all times Hot in run I/p fuse panel Illumi- nation Interior lights system Max Norm Off Pan/flr Panel Pcm power relay Powertrain control module (right rear of engine compartment, through safety wall) Red Wide open throttle a/c cutoff relay (in engine compartment fuse/relay box) Heater Wiring Diagram for Ford Ranger Splash 1996 List of elements for Heater Wiring Diagram for Ford Ranger Splash 1996: 23 (top center of left fender apron) Blower motor Blower motor fuse 40a Blower motor relay (in relay box 2) Blower motor resistor assembly (right rear of engine comparment) Blower switch C233 C234 Def Engine compartment fuse/relay box Flr Flr/def Fuse 7.5a G102 Heater control assembly Hot at all times Hot in run I/p fuse panel Illumi- nation Interior lights system Off Pan/flr Panel
ANTI-LOCK BRAKES All-Wheel ABS Wiring Diagram for Ford Ranger Splash 1996 List of elements for All-Wheel ABS Wiring Diagram for Ford Ranger Splash 1996: 63 (4wabs) hydraulic unit (left side of engine compartment) (4wabs) indicator ctrl (4wabs) main relay (relay box #3: left rear of engine compt.) (4wabs) pmp rly coil (-) g-switch #2 (4wabs) pump motor relay (relay box #3) (4wabs) relay coil (-) (bottom of i/p, near steering column) 1400 ohms 4wabs diode 4wabs main relay maxi fuse 9 30a 4wabs pump motor 4wabs pump relay maxi fuse 10 30a Acceleration sensor (on inside of left frame rail) Anti-lock brakes indicator Brake on/off (boo) switch (on brake pedal support) Brake on/off sw feed C215 C216 Data link connector (dlc) Diagnostic circuit Dump valve Engine compartment fuse/relay box (left rear of engine compt.) Four wheel anti- lock brake system (4wabs) control module (left front of engine compartment) Fuse 10a Fuse 15a Fuse 7.5a G-switch #1 G-switch status G104 (top center of left fender apron) G108 (left side of upper radiator support) Ground Hot at all times Hot in run Hot in run or start I/p fuse panel (behind left side of i/p) Ignition (hot in run) Instrument cluster Iso valve Left front Left front dump valve Left front iso valve Left front sensor (hi) Left front sensor (lo) Left front wheel speed sensor Motor speed sensor (hi) Nca Pnk Rear Rear axle sensor Rear dump valve Rear iso valve Rear sensor (high) Rear sensor (low) Red/pnk Right front Right front dump valve Right front iso valve Right front sensor (hi) Right front sensor (lo) Right front wheel speed sensor Tan Tan/red Vehicle ref. voltage Rear Wheel ABS Wiring Diagram for Ford Ranger Splash 1996 List of elements for Rear Wheel ABS Wiring Diagram for Ford Ranger Splash 1996: 53 1.2 ohms 22k ohms 4.0 ohms Abs ind Acc Boo switch input Brake fluid level sig Brake fluid level switch (left rear of engine compartment, on brake fluid reservoir) Brake ind Brake on/off (boo) switch (behind left side of i/p, on brake pedal support) C141 C215 C216 Daytime running lamps (drl) module (left side of lower radiator support) Diag/keep alive input Diff speed sens (hi) Diff speed sens (lo) Dump sol output Engine compartment fuse/relay box (left rear of engine compt.) Fuse 11 7.5a Fuse 13 15a Fuse 14 20a Fuse 9 10a G104 (top center of left fender apron) G108 (left side of upper radiator support) Gnd Ground Hot at all times Hot in run Hot in run or start I/p fuse panel (behind left side of i/p) Ignition switch Instrument cluster Iso sol output Isolation solenoid Lock Nca Off Power input Rabs diode Rabs ind ctrl Rabs resistor Rabs test connector (c244) (behind right side of i/p) Rabs test connector (on rear of engine compartment fuse/relay box) Rear anti-lock brake system (rabs) module (behind lower center of i/p, left side of ashtray assembly) Rear anti-lock brake system (rabs) proportioning valve switch assembly (below left side of vehicle, on inside of left frame rail) Rear axle sensor (top of rear differential) Red Red/pnk Run Start Valve reset input Valve reset switch
BODY COMPUTER Body Computer Wiring Diagrams (1 of 2) for Ford Ranger Splash 1996 List of elements for Body Computer Wiring Diagrams (1 of 2) for Ford Ranger Splash 1996: 71 (1032) (behind i/p, bottom of steering column) (csm) diagnostic connector 4wd mode sw input 4wd mode switch (w/ electronic shift control) Anti-theft system (rt door disarm sw) Battery Battery saver relay ctrl C221 C224 Computer data lines system ((dlc) pin 7) Ctm diagnostic Door ajar ind ctrl Down window command input Engine controls system (vss) Fuse 7.5a G104 (top center of left fender apron) G108 (left side of upper radiator support) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Gnd Hot at all times Hot in acc or run Hot in run Hot in start I/p fuse panel (behind left side of i/p) Ignition (acc/run) Ignition (run) Ignition (start) Ignition key warning input Illuminated entry input Instrument cluster system (c215 pin 10) Interior lamp relay ctrl Interior lights system (left/right entry switches) Interior lights system (relay pin 2) Interval delay/wash input Left door ajar input Left/right door disarm input Multi- function switch (left side of steering column) One touch down relay out One touch down sense (hi) One touch down sense (lo) Park sense Park/headlamps on input Pwr windows system (left motor ground) Pwr windows system (left motor power) Pwr windows system (master control sw) Pwr windows system (module pin 2) Pwr windows system (module pin 3) Red Right door ajar input Run/park relay ctrl Seat belt ind ctrl Seat belt input Self test iso link Tan/red Up window command input Vehicle speed sensor Warning system (clock spring assembly) Warning system (i/c c216 pin 10) Warning system (left door ajar sw) Warning system (main lite sw/park lp relay) Warning system (right door ajar sw) Warning system (seatbelt switch) Washer pump relay ctrl Wiper hi-lo relay ctrl Wiper mode select sw input Wiper/washer system (hi/low relay pin 5) Wiper/washer system (multi-function sw pin 1) Wiper/washer system (multi-function sw pin 6) Wiper/washer system (run/park relay pin 5) Wiper/washer system (washer pump relay) Wiper/washer system (wiper motor pin 6) Body Computer Wiring Diagrams (2 of 2) for Ford Ranger Splash 1996 List of elements for Body Computer Wiring Diagrams (2 of 2) for Ford Ranger Splash 1996: 38 4wd high range ind ctrl 4wd low range ind ctrl 4wd mode switch (w/ electronic shift control) 4wd mode switch output 4wd out A/t Anti-theft system ((rap) module c409 pin 10) Anti-theft system ((rap) module c410 pin 11) Brake on/off (boo) sw input Brake on/off (boo) switch (on brake pedal support) C222 C223 Ccw relay ctrl Cw relay ctrl Door ajar output (rap module) Electric shift control module (behind center of i/p) Electric shift relay Electric shift relay ctrl Fuse 15a G123 (right side of safety wall) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Gnd (m/t) neutral sense in (a/t) Hot at all times I/p fuse panel (behind left side of i/p) Illum entry out (rap module) Instrument cluster system (c214 pin 2) Instrument cluster system (c214 pin 3) M/t Nca Relay box #1 (behind i/p, right side of steering column) Touch drive switch a input Touch drive switch b input Touch drive switch c input Touch drive switch d input Transfer case assembly Transmission range (tr) sensor (left side of transmission) W/ 4wd & electronic shift control W/ electronic shift control
COMPUTER DATA LINES Computer Data Lines for Ford Ranger Splash 1996 List of elements for Computer Data Lines for Ford Ranger Splash 1996: 20 (behind center of i/p) generic electronic module (gem)/ central timer module (ctm) (behind right side of cowl panel) air bag diagnostic monitor (right rear of engine compt, through safety wall) powertrain control module (pcm) 4 wheel anti- lock brake system (4wabs) module (left front of engine compt) C221 C250 C410 Data + Data - Data link connector (dlc) (fastened to bottom of i/p, near steering column) Dlc Fuse 10a G104 (top center of left fender apron) G108 (left side of upper radiator support) Hot at all times I/p fuse panel Remote anti- theft person- ality (rap) module (left rear corner of cab) S205 S225 (main harn, near breakout to generic electronic module) S244
CRUISE CONTROL Cruise Control Wiring Diagram for Ford Ranger Splash 1996 List of elements for Cruise Control Wiring Diagram for Ford Ranger Splash 1996: 50 1.4k ohms 15a 7.5a A/t Accel Anti- theft system Brake on/off (boo) switch (on brake pedal support) Brake press input Brake pressure switch (left side of engine compart- ment) C215 C219 C221 C224 Clock spring assembly (top of steering column) Clutch pedal position (cpp) switch (top of clutch pedal support) Clutch pedal position (cpp) switch jumper (left of steering column) Coast Engine compartment fuse/relay panel (left rear of engine compartment) Fuse 10 Fuse 13 G104 (top center of left fender apron) G108 (left side of upper radiator support) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Ground Horn relay (in eng compt fuse/ panel) Horn switches Horn/pcm memory power maxi fuse 4 20a Horns system Hot at all times Hot in run I/p fuse panel (behind left side of i/p) Ignition key warning switch Instrument cluster Interior lights system M/t Nca Off Ohms Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Pwr (hot in run) Resume Set/ Speed control servo/ amplifier assembly (right rear of engine compartment) Speed control switch assembly Speed ctrl sw gnd Speed ctrl sw in Steering wheel assembly Vehicle speed in Vehicle speed sensor (vss) (left rear of trans./ transfer case) Vss input
ENGINE PERFORMANCE
2.3L 2.3L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger Splash 1996 List of elements for 2.3L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger Splash 1996: 55 (case) ground (ckp) sensor (+) (ckp) sensor (-) (css) sol (ect) sensor (evr) ctrl (ho2s) #2 (iat) sensor (maf) sensor rtn (mil) (pf) sensor (psp) switch (pwr) ground (tft) sensor 4x4 indicator sw A/c psi cutoff C209 C214 C216 Crankshaft position (ckp) sensor (lower right front of engine) Data link connector (dlc) (fastened to bottom of i/p, near steering column) Dlc Dlc bus (+) Dlc bus (-) Engine compartment fuse/relay box (left rear of engine compartment) Fuel pmp monitor Fuse 25a Fuse 7.5a G104 (top center of left fender apron) G108 (left side of radiator support) G123 (right side of safety wall G123 (right side of safety wall) Hot at all times Hot in run or start I/p fuse panel (behind left side of i/p) Ignition coil #1 Ignition coil #2 Instrument cluster Instrument clusters system Malfunction indicator lamp (mil) Octane adjust Pcm power diode Pcm power maxi fuse 13 30a Pcm power relay Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Primary coil (top right side of engine) Radio noise capacitor (near secondary coil) Red Secondary coil (top right front of engine) Shift sol 1 Shift sol 2 Tachometer Tachometer test connector (left rear engine compt.) Trans ctrl (tcs) Transmission system (w/ manual shift: 4x4 indicator switch; w/ electric shift: generic electronic module) 2.3L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger Splash 1996 List of elements for 2.3L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger Splash 1996: 29 A/c clutch diode (left front engine compt.) A/c clutch field coil (left front of engine) A/t Air conditioning system (a/c pressure cutoff switch) Clutch pedal position (cpp) switch (clutch pedal support) Clutch pedal position (cpp) switch jumper (left side of i/p) Differential pressure feedback egr (dpfe) sensor (right rear of engine) Engine compartment fuse/relay box (left rear of engine compartment) Engine coolant temperature (ect) sensor (top right front of engine) Evaporative emissions (evap) canister purge solenoid (left front engine compt.) Fuel pump relay Fuel sys/ anti-theft maxi fuse 12 20a G104 (top center of left fender apron) G108 (left side of radiator support) Horn/pcm memory power maxi fuse 4 20a Hot at all times Intake air temperature (iat) sensor (right side of engine compt.) M/t Nca Octane adjust shorting bar (near pcm) Power distribution system Power steering pressure (psp) switch (left front of engine compt.) Power steering pressure (psp) switch jumper (left front of engine compt.) Purge flow (pf) sensor (left front of engine compt.) Red Throttle position (tp) sensor (top right side of engine) W/ pwr steering W/o pwr steering Wide open throttle a/c cutoff (wac) relay 2.3L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger Splash 1996 List of elements for 2.3L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger Splash 1996: 20 (below glove box) inertia fuel shut-off (ifs) C214 Egr vacuum regulator (evr) solenoid (right side of engine) Engine compartment fuse/relay box (left rear of engine compt.) Fuel injectors (top of cylinders) Fuel pump module (top of fuel tank) Fuel reset switch indica- or c214 Fuse 15a Fuse 7.5a G200 (behind left cowl panel) Ho2s fuse 20 15a Hot in run Hot in run or start I/p fuse panel (behind left side of i/p) Instrument cluster Power distribution system (main light switch) Red Tan Trans- mission control indicator lamp Transmission control switch (tcs) 2.3L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger Splash 1996 List of elements for 2.3L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger Splash 1996: 55 (b+) power (boo) switch (cmp) sensor (dpfe) sensor (epc) solenoid (evap) solenoid (ho2s) #1 (ho2s) #1 htr (ho2s) #2 htr (iac) solenoid (left side of transaxle) transmission range (tr) sensor (maf) sensor (pcm relay) pwr (pwr) ground (tcc) solenoid (tcil) lp output (tp) sensor (tr) sensor (tss) sensor (vss) input 4r44e/4r55e automatic transmission (left side of transmission) A/c (wot) relay Brake on/ off (boo) switch Camshaft position (cmp) sensor (behind oil pump pulley) Coast clutch (css) solenoid Cruise control system (speed ctrl servo/ amplifier assembly), instrument cluster system (speedometer), body computer system (generic electronic module/central timer module) Electronic pressure control (epc) solenoid Fuel inj (#1) Fuel inj (#2) Fuel inj (#3) Fuel inj (#4) Fuel pmp rly Fuse 15a G108 (left side of upper radiator support) G123 (right side of safety wall) Heated oxygen sensor (ho2s) #1 (lower right side of engine) Heated oxygen sensor (ho2s) #2 (lower right side of engine) Hot at all times I/p fuse panel (behind left side of i/p) Idle air control (iac) valve (top right rear of engine) Ignition coil #3 Ignition coil #4 Mass air flow (maf) sensor (air cleaner assembly) Nca Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Red Ref volt Shift sol 3 Shift solenoids Signal rtn Tan Torque converter clutch (tcc) solenoid Transmission fluid temperature (tft) sensor Turbine shaft speed sensor (tss) Vehicle speed sensor (vss) (left rear of trans./transfer case)
3.0L 3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger Splash 1996 List of elements for 3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger Splash 1996: 53 (case) ground (ckp) sensor (+) (ckp) sensor (-) (css) sol (ect) sensor (evr) ctrl (ho2s) #3 (iat) sensor (maf) sensor rtn (mil) (pf) sensor (pwr) ground (tft) sensor 4x4 indicator sw A/c psi cutoff C209 C214 C216 Crankshaft position (ckp) sensor (lower front of engine) Data link connector (dlc) (fastened to bottom of i/p, near steering column) Dlc Dlc bus (+) Dlc bus (-) Engine compartment fuse/relay box (left rear of engine compartment) Fuel pmp monitor Fuse 25a Fuse 7.5a G104 (top center of left fender apron) G108 (left side of radiator support) G123 (right side of safety wall G123 (right side of safety wall) Hot at all times Hot in run or start I/p fuse panel (behind left side of i/p) Ignition coil #1 Ignition coil #3 Ignition coil (top right side of engine) Instrument cluster Instrument clusters system Malfunction indicator lamp (mil) Octane adjust Pcm power diode Pcm power maxi fuse 13 30a Pcm power relay Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Radio noise capacitor (near ignition coil) Red Shift sol 1 Shift sol 2 Tachometer Tachometer test connector (left rear engine compt.) Trans ctrl (tcs) Transmission system (w/ manual shift: 4x4 indicator switch; w/ electric shift: generic electronic module) 3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger Splash 1996 List of elements for 3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger Splash 1996: 25 A/c clutch diode (left front engine compt.) A/c clutch field coil (left front of engine) A/t Air conditioning system (a/c pressure cutoff switch) Clutch pedal position (cpp) switch (clutch pedal support) Clutch pedal position (cpp) switch jumper (left side of i/p) Differential pressure feedback egr (dpfe) sensor (left side of engine) Engine compartment fuse/relay box (left rear of engine compartment) Engine coolant temperature (ect) sensor (top front of engine) Evaporative emissions (evap) canister purge solenoid (left front engine compt.) Fuel pump relay Fuel sys/ anti-theft maxi fuse 12 20a G104 (top center of left fender apron) G108 (left side of radiator support) Horn/pcm memory power maxi fuse 4 20a Hot at all times Intake air temperature (iat) sensor (right side of engine compt.) M/t Nca Octane adjust shorting bar (near pcm) Power distribution system Purge flow (pf) sensor (left front of engine compt.) Red Throttle position (tp) sensor (top left front of engine) Wide open throttle a/c cutoff (wac) relay 3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger Splash 1996 List of elements for 3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger Splash 1996: 20 (below glove box) inertia fuel shut-off (ifs) C214 Egr vacuum regulator (evr) solenoid (right side of engine) Engine compartment fuse/relay box (left rear of engine compt.) Fuel injectors (top of cylinders) Fuel pump module (top of fuel tank) Fuel reset switch indica- or c214 Fuse 15a Fuse 7.5a G200 (behind left cowl panel) Ho2s fuse 20 15a Hot in run Hot in run or start I/p fuse panel (behind left side of i/p) Instrument cluster Power distribution system (main light switch) Red Tan Trans- mission control indicator lamp Transmission control switch (tcs) 3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger Splash 1996 List of elements for 3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger Splash 1996: 59 (b+) power (boo) switch (cmp) sensor (dpfe) sensor (epc) solenoid (evap) solenoid (ho2s) #1 (ho2s) #1 htr (ho2s) #2 (ho2s) #2 htr (ho2s) #3 htr (iac) solenoid (left side of transaxle) transmission range (tr) sensor (maf) sensor (pcm relay) pwr (pwr) ground (tcc) solenoid (tcil) lp output (tp) sensor (tr) sensor (tss) sensor (vss) input 4r44e/4r55e automatic transmission (left side of transmission) A/c (wot) relay Brake on/ off (boo) switch Camshaft position (cmp) sensor (top rear of engine) Coast clutch (css) solenoid Cruise control system (speed ctrl servo/ amplifier assembly), instrument cluster system (speedometer), body computer system (generic electronic module/central timer module) Electronic pressure control (epc) solenoid Fuel inj (#1) Fuel inj (#2) Fuel inj (#3) Fuel inj (#4) Fuel inj (#5) Fuel inj (#6) Fuel pmp rly Fuse 15a G108 (left side of upper radiator support) G123 (right side of safety wall) Heated oxygen sensor (ho2s) #1 (lower right side of engine compt.) Heated oxygen sensor (ho2s) #2 (lower left rear of engine compt.) Heated oxygen sensor (ho2s) #3 (near right side of transmission) Hot at all times I/p fuse panel (behind left side of i/p) Idle air control (iac) valve (top left front of engine) Ignition coil #2 Mass air flow (maf) sensor (air cleaner assembly) Nca Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Red Ref volt Shift sol 3 Shift solenoids Signal rtn Tan Torque converter clutch (tcc) solenoid Transmission fluid temperature (tft) sensor Turbine shaft speed sensor (tss) Vehicle speed sensor (vss) (left rear of trans./transfer case)
4.0L 4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger Splash 1996 List of elements for 4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger Splash 1996: 53 (case) ground (ckp) sensor (+) (ckp) sensor (-) (css) sol (ect) sensor (evr) ctrl (ho2s) #3 (iat) sensor (maf) sensor rtn (mil) (pf) sensor (pwr) ground (tft) sensor 4x4 indicator sw A/c psi cutoff C209 C214 C216 Crankshaft position (ckp) sensor (lower front of engine) Data link connector (dlc) (fastened to bottom of i/p, near steering column) Dlc Dlc bus (+) Dlc bus (-) Engine compartment fuse/relay box (left rear of engine compartment) Fuel pmp monitor Fuse 25a Fuse 7.5a G104 (top center of left fender apron) G108 (left side of radiator support) G123 (right side of safety wall G123 (right side of safety wall) Hot at all times Hot in run or start I/p fuse panel (behind left side of i/p) Ignition coil #1 Ignition coil #2 Ignition coil (top right rear of engine) Instrument cluster Instrument clusters system Malfunction indicator lamp (mil) Octane adjust Pcm power diode Pcm power maxi fuse 13 30a Pcm power relay Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Radio noise capacitor (near ignition coil) Red Shift sol 1 Shift sol 2 Tachometer Tachometer test connector (left rear engine compt.) Trans ctrl (tcs) Transmission system (w/ manual shift: 4x4 indicator switch; w/ electric shift: generic electronic module) 4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger Splash 1996 List of elements for 4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger Splash 1996: 25 A/c clutch diode (left front engine compt.) A/c clutch field coil (left front of engine) A/t Air conditioning system (a/c pressure cutoff switch) Clutch pedal position (cpp) switch (clutch pedal support) Clutch pedal position (cpp) switch jumper (left side of i/p) Differential pressure feedback egr (dpfe) sensor (left side of engine) Engine compartment fuse/relay box (left rear of engine compartment) Engine coolant temperature (ect) sensor (top front of engine) Evaporative emissions (evap) canister purge solenoid (left front engine compt.) Fuel pump relay Fuel sys/ anti-theft maxi fuse 12 20a G104 (top center of left fender apron) G108 (left side of radiator support) Horn/pcm memory power maxi fuse 4 20a Hot at all times Intake air temperature (iat) sensor (front of engine, on air intake assembly) M/t Nca Octane adjust shorting bar (near pcm) Power distribution system Purge flow (pf) sensor (left front of engine compt.) Red Throttle position (tp) sensor (top left front of engine) Wide open throttle a/c cutoff (wac) relay 4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger Splash 1996 List of elements for 4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger Splash 1996: 20 (below glove box) inertia fuel shut-off (ifs) C214 Egr vacuum regulator (evr) solenoid (left rear of engine) Engine compartment fuse/relay box (left rear of engine compt.) Fuel injectors (top of cylinders) Fuel pump module (top of fuel tank) Fuel reset switch indica- or c214 Fuse 15a Fuse 7.5a G200 (behind left cowl panel) Ho2s fuse 20 15a Hot in run Hot in run or start I/p fuse panel (behind left side of i/p) Instrument cluster Power distribution system (main light switch) Red Tan Trans- mission control indicator lamp Transmission control switch (tcs) 4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger Splash 1996 List of elements for 4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger Splash 1996: 59 (b+) power (boo) switch (cmp) sensor (dpfe) sensor (epc) solenoid (evap) solenoid (ho2s) #1 (ho2s) #1 htr (ho2s) #2 (ho2s) #2 htr (ho2s) #3 htr (iac) solenoid (left side of transaxle) transmission range (tr) sensor (maf) sensor (pcm relay) pwr (pwr) ground (tcc) solenoid (tcil) lp output (tp) sensor (tr) sensor (tss) sensor (vss) input 4r44e/4r55e automatic transmission (left side of transmission) A/c (wot) relay Brake on/ off (boo) switch Camshaft position (cmp) sensor (top rear of engine) Coast clutch (css) solenoid Cruise control system (speed ctrl servo/ amplifier assembly), instrument cluster system (speedometer), body computer system (generic electronic module/central timer module) Electronic pressure control (epc) solenoid Fuel inj (#1) Fuel inj (#2) Fuel inj (#3) Fuel inj (#4) Fuel inj (#5) Fuel inj (#6) Fuel pmp rly Fuse 15a G108 (left side of upper radiator support) G123 (right side of safety wall) Heated oxygen sensor (ho2s) #1 (lower right side of engine compt.) Heated oxygen sensor (ho2s) #2 (lower left rear of engine compt.) Heated oxygen sensor (ho2s) #3 (near right side of transmission) Hot at all times I/p fuse panel (behind left side of i/p) Idle air control (iac) valve (top left rear of engine) Ignition coil #3 Mass air flow (maf) sensor (air cleaner assembly) Nca Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Red Ref volt Shift sol 3 Shift solenoids Signal rtn Tan Torque converter clutch (tcc) solenoid Transmission fluid temperature (tft) sensor Turbine shaft speed sensor (tss) Vehicle speed sensor (vss) (left rear of trans./transfer case)
EXTERIOR LIGHTS Back-up Lamps Wiring Diagram for Ford Ranger Splash 1996 List of elements for Back-up Lamps Wiring Diagram for Ford Ranger Splash 1996: 10 A/t Backup lamp switch (left side of transmission) Fuse 10a G200 (behind left kick panel) Hot in run I/p fuse panel Left backup lamp M/t Right backup lamp Transmission range (tr) sensor (rear left side of transmission) Exterior Lamps Wiring Diagram for Ford Ranger Splash 1996 List of elements for Exterior Lamps Wiring Diagram for Ford Ranger Splash 1996: 52 (not used) Anti- theft Brake on/ off (boo) switch (on brake pedal support) C214 C215 C221 C253 C409 Flasher (behind left side of i/p, on fuse panel) Fuse 10a Fuse 15a Fuse 7.5a G104 (top center of left fender apron) G105 (right side of engine compartment, on upper fender apron) G200 (behind left cowl panel) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Ground Hazard Hazard sw out Head Hot at all times Hot in run I/p fuse panel Ignition Instrument cluster Instrument illumination dimming module (top left side of i/p) Left front park/ turn lamp Left license lamp Left rear park/ stop lamp Left rear turn lamp Left turn Left turn indicator Main light switch Multi-function switch (top left side of steering column) Normal Off Outside cargo/ high mount stop lamp Park Park lamps relay Power Relay box #1 (behind i/p, right of steering column) Remote anti- theft personality (rap) module (left rear corner of cab) Right front park/ turn lamp Right license lamp Right rear park/ stop lamp Right rear turn lamp Right turn Right turn indicator Turn signal sw W/ anti- theft W/o anti- theft W/o w/ anti- theft
GROUND DISTRIBUTION Ground Distribution Wiring Diagram (1 of 2) for Ford Ranger Splash 1996 List of elements for Ground Distribution Wiring Diagram (1 of 2) for Ford Ranger Splash 1996: 79 (2.3l) (3.0l/4.0l only) camshaft position (cmp) sensor (3.0l/4.0l) 3.0l/4.0l only 4 wheel anti-lock brake system (4wabs) hydraulic unit 4 wheel anti-lock brake system (4wabs) main relay 4 wheel anti-lock brake system (4wabs) module 4wd mode switch A/c clutch diode A/c clutch field coil Air bag diagnostic monitor All lock relay All unlock relay Auxiliary power socket Battery Blend door actuator Brake fluid level switch C214 C215 C216 C221 C224 C228 C233 C234 C235 C236 C250 C251 C410 Cigar lighter Clock- spring assembly Data link connector (dlc) Electric shift control module Engine air cleaner assembly Engine compartment fuse/relay box Engine compartment lamp Flasher Fog lamp switch Fuel pump module G100 (lower left front of engine compartment, on frame rail) G100 (lower left front of engine compartment) G104 (top center of left fender apron) G108 (left side of upper radiator support) G114 (left rear of engine) G120 (right side of engine) Generic electronic module (gem)/ central timer module (ctm) Gnd Heater or a/c- heater control assembly Ignition switch Ignition tamper switch Instrument cluster Instrument illumination dimmimg module Left fog lamp Left front park/turn lamp Left headlamp Main light switch Mass air flow (maf) sensor Passive de- activation (pad) module Pcm power relay Power window relay Powertrain control module (pcm) Purge flow (pf) sensor Radio Rear anti-lock brake system (rabs) module Rear anti-lock brake system (rabs) proportioning valve switch assembly Relay box #1 Relay box #3 Remote anti-theft personality (rap) module Right door ajar switch Right door disarm switch Right door lock switch Right illuminated entry switch Shift lock actuator Speed control servo/ amplifier assembly Vehicle speed sensor (vss) W/ 4wabs W/o 4wabs Windshield wiper motor Ground Distribution Wiring Diagram (2 of 2) for Ford Ranger Splash 1996 List of elements for Ground Distribution Wiring Diagram (2 of 2) for Ford Ranger Splash 1996: 39 Amplifier Anti-theft hood switch C223 Camshaft position sensor (cmp) shield Cd changer Crankshaft position sensor (ckp) shield Fuel pump module G105 (right side of engine compartment, on upper fender apron) G123 (right side of safety wall) G200 (behind left cowl panel) G203 (behind right cowl panel) Generic electronic module (gem)/central timer module (ctm) Left backup lamp Left door ajar switch Left door disarm switch Left door lock switch Left illuminated entry switch Left license lamp Left power bolster lumbar motor Left rear park/stop lamp Left rear turn lamp Left seat control switch M/t only Master window control switch Outside cargo/high mount stop lamp Power mirror switch Powertrain control module (pcm) Radio Right backup lamp Right fog lamp Right front park/turn lamp Right headlamp Right license lamp Right power lumbar motor Right rear park/stop lamp Right rear turn lamp Seat belt switch Transmission range (tr) sensor Windshield washer pump
HEADLIGHTS Headlight Wiring Diagram, with DRL for Ford Ranger Splash 1996 List of elements for Headlight Wiring Diagram, with DRL for Ford Ranger Splash 1996: 63 (top center of left fender apron) A/t Acc Back-up lamp switch (top left side of transmission) Battery pwr in Brake fluid level switch (on brake fluid reservoir) Brake indicator C215 C216 C254 Daytime running lamps (drl) module (left side of lower radiator support) Dimmer switch Drl disable Drl sys/ fog lamps fuse 15 15 a Engine compartment fuse/relay box (left rear of engine compt.) Flash- to-pass switch Fog lamp relay (engine compt. fuse/re- lay box) Fog lamp switch Fuse 10a Fuse 15a Fuse 7.5a G104 G105 (right side of engine compartment, on upper fender apron) Gnd Head Headlamps maxi fuse 11 20a Hi beam indicator Hi beam indicator out Hot at all times Hot in run Hot in start or run I/p fuse panel (behind left side of i/p) Ignition in Ignition switch Instrument cluster Interior lights system (instrument illumination) Left fog lamp Left head- lamp Lo beam in Lock M/t Main light switch Multi-function switch (top left side of steering column) Nca Off On indicator Park Park brake in Park brake switch (on park brake assembly) Pass Pulsed voltage to hi beams Rabs diode Rabs resistor Rear anti-lock brake system (rabs) module (behind lower center of i/p, left side of ashtray assembly) Right fog lamp Right head- lamp Run Start Switch illumination Transmission range (tr) sensor (left side of transmission) W/ 4wabs W/ rabs W/ rabs only Headlight Wiring Diagram, without DRL for Ford Ranger Splash 1996 List of elements for Headlight Wiring Diagram, without DRL for Ford Ranger Splash 1996: 31 C215 C254 Dimmer switch Drl sys/ fog lamps fuse 15 15a Engine compartment fuse/relay box (left rear of engine compt.) Flash- to-pass switch Fog lamp relay (engine compt. fuse/re- lay box) Fog lamp switch Fuse 10a Fuse 15a G104 (top center of left fender apron) G105 (right side of engine compartment, on upper fender apron) Head Headlamps maxi fuse 11 20a Hi beam indicator Hot at all times I/p fuse panel (behind left side of i/p) Instrument cluster Interior lights system (instrument illumination) Left fog lamp Left head- lamp Main light switch Multi-function switch (top left side of steering column) Nca Off On indicator Park Pass Right fog lamp Right head- lamp Switch illumination
HORN Horn Wiring Diagram for Ford Ranger Splash 1996 List of elements for Horn Wiring Diagram for Ford Ranger Splash 1996: 18 (left front of engine compt) (top of steering column) clock spring assembly C219 C409 Clock- spring assembly Cruise control system Engine compartment fuse/relay box (left rear of engine compt.) Engine controls system ((pcm) pin 55) G108 (left side of upper radiator support) High pitch horn Horn relay (engine compartment fuse/relay box) Horn switches Horn/pcm memory power maxi fuse 4 20a Hot at all times Low pitch horn Nca Remote anti-theft personality (rap) module (left rear corner of cab) Steering wheel assembly
INSTRUMENT CLUSTER Instrument Cluster Wiring Diagram for Ford Ranger Splash 1996 List of elements for Instrument Cluster Wiring Diagram for Ford Ranger Splash 1996: 83 4wd low range indicator check gauge speedometer (left rear of trans./ transfer case) vehicle speed sensor (vss) 3.0l/4.0l only 4.32k ohms 4w- abs 4wd hi range indicator 4x4 indicator switch (top front of transfer case assembly) Acc Air bag indi- cator Anti-lock brake indicator Anti-lock brakes system Anti-lock brakes system (rabs module pin2) Anti-theft system (rap module c409, pin 16) Body computer system (gem/ctm) Brake fluid level switch (brake fluid reser- voir) Brake indicator C168 C214 C215 C216 C223 Charge gauge Charge indi- cator Daytime running lamps (drl) module (left side of lower radiator support) Door ajar indicator Electronic shift control Engine controls system (pcm pin 48) Engine controls system (pcm pin2) Engine coolant temperature gauge Engine coolant temperature sender (3.0l/4.0l: top front of engine; 2.3l: left rear of engine) Engine oil pressure gauge Engine oil pressure switch (4.0l: lower left front of engine; 3.0l: right rear of engine; 2.3l: left rear of cylinder head) Exterior lights (system multi- function sw) Exterior lights system multi-function sw) Fuel gauge Fuel pump module (top center of fuel tank) Fuel reset switch indicator Fuse 15a Fuse 7.5a G104 (top center of left fender apron) G108 (left side of upper radiator support) Generator/ voltage regulator Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Gnd Head Headlights system High beam indi- cator Hot at all times Hot in hi or pass Hot in run or start I/p fuse panel (behind left side of i/p) Ignition switch Inertia fuel shut-off (ifs) (below glove box) Instrument cluster Instrument cluster illumination Instrument illumination dimming module (top left side of i/p) Interior lights system (instrument illumination) Left turn indicator Lock Main light switch Manual shift control Multi-function indicator lamp (mil) Off Ohms Park Park brake switch (on park brake assembly) Powertrain control module (pcm) (right rear of engine compt., through saftey wall) Rabs Rabs diode (engine compartment fuse/relay box) Red Right turn indicator Run Seat belt indicator Slosh module Start Tachometer Theft indi- cator Transmission control indicator lamp W/ drl W/o drl Warning systems
INTERIOR LIGHTS Courtesy Lamps Wiring Diagram for Ford Ranger Splash 1996 List of elements for Courtesy Lamps Wiring Diagram for Ford Ranger Splash 1996: 37 (behind center of i/p) electric shift control module (top left side of i/p) instrument illumination dimming module Battery saver relay Battery saver relay control C221 C224 Dome Dome lamp Dome/ map lamp Electric shift relay Engine compartment fuse/relay box (left rear of engine compartment) Engine compartment lamp Except xl model Exterior lights system Fuse 10a G104 (top center of left fender apron) G200 (behind left cowl panel) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Glove box lamp & switch High mount stop lamp Hot at all times I/p fuse panel (behind left side of i/p) Illuminated entry input Interior lamp relay Interior lamp relay control Left door ajar switch Left door ajar switch input Left illuminated entry switch Outside cargo lamp Outside cargo/ high mount stop lamp Park lamps maxi fuse 7 20a Pnk Relay box #1 (behind i/p, right of steering column) Right door ajar switch Right door ajar switch input Right illuminated entry switch Xl model Instrument Illumination Wiring Diagram for Ford Ranger Splash 1996 List of elements for Instrument Illumination Wiring Diagram for Ford Ranger Splash 1996: 43 (6 bulbs) 15a 4wd mode switch 7.5a Anti- theft system C201 C214 C215 C225 C228 C233 C236 Clockspring assembly (top of steering column) Courtesy lamps circuit Dome Exterior lights system Fog lamp switch Fuse G104 (top center of left fender apron) G108 (left side of upper radiator support) Head Heater or a/c-heater control assembly Horn switches Hot at all times Hot in start or run I/p fuse panel (behind left side of i/p) Ignition key warning switch Illumination Instrument cluster Instrument cluster system Instrument illumin- ation dimming module (top left side of i/p) Main light switch Nca Off Park Radio Remote anti-theft personality (rap) module (left rear corner of cab) Solid state Speed control switch assembly (steering wheel assembly) Theft W/ anti- theft W/o anti- W/o anti- theft
POWER DISTRIBUTION Power Distribution Wiring Diagram (1 of 3) for Ford Ranger Splash 1996 List of elements for Power Distribution Wiring Diagram (1 of 3) for Ford Ranger Splash 1996: 70 (not used) 4 wheel anti- lock brake system (4wabs) main relay 4 wheel anti-lock brake system (4wabs) module A/c- heater control assembly A/t Acc Air bag diagnostic monitor Back-up lamp switch Battery Blend door actuator Blower motor relay Brake pressure switch C177 C178 C224 C228 C251 C256 C410 Clutch pedal position (ccp) switch Daytime runing lamps (drl) module Engine compartment fuse/relay box Flasher Fuse (not used) Fuse 10a Fuse 10a (4wabs) Fuse 15a Fuse 20a (rabs) Fuse 30a Fuse 7.5a Generator/ voltage regulator Generic electronic module (gem) Generic electronic module (gem)/ central timer module (ctm) I/p fuse panel Ignition maxi fuse 1 50a Ignition switch Lock M/t Nca Off Passive de- activation (pad) module Power window relay Radio Rear anti- lock brake system (rabs) module Red Relay box #1 Relay box #2 Relay box #3 Remote anti-theft personality (rap) module Run Shift lock actuator Speed control servo/ amplifier assembly Sta Start Starter interrupt relay Starter motor/ solenoid Starter relay To i/p fuse panel, fuse 15 To i/p fuse/panel maxi fuse 2 Transmission control switch (tcs) Transmission range (tr) sensor W/ anti- theft W/ pad W/o anti- theft W/o pad W/o rap w/ rap Washer pump relay Windshield wiper motor Wiper hi-lo relay Wiper run/ park relay Power Distribution Wiring Diagram (2 of 3) for Ford Ranger Splash 1996 List of elements for Power Distribution Wiring Diagram (2 of 3) for Ford Ranger Splash 1996: 77 4wabs main relay 4wabs main relay maxi fuse 9 30a 4wabs pump motor relay 4wabs pump relay maxi fuse 10 30a All lock relay All unlock relay Amplifier Battery saver relay Blower motor maxi fuse 6 40a Blower motor relay Brake on/off (boo) switch C216 C224 C228 C254 C409 C414 Cd changer Cigar lighter Data link connector (dlc) Daytime running lamps (drl) module Dimmer switch Driver's unlock relay Drl sys/fog lamps fuse 15 15a Engine compartment fuse/relay box Engine compartment fuse/relay panel Exterior lights system Flash- to-pass switch Flasher Fog lamp relay From ignition maxi fuse 1 Fuel pump relay Fuel sys/ anti-theft maxi fuse 12 20a Fuse (not used) Fuse 10a Fuse 15a Fuse 7.5a Fuse i5a G104 (top center of left fender apron) Generic electronic module (gem)/ central timer module (ctm) Head Head- lamps maxi fuse 11 20a Headlights system I/p fuse panal maxi fuse 2 50a I/p fuse panel Instrument cluster Instrument illumination dimming module Interior lights system Left power bolster switch Left power lumbar switch Left seat control switch Low Main light switch Multi- function switch Nca Off Park Park lamps maxi fuse 7 20a Park lamps relay Pass Pnk Power lock/ window/seat maxi fuse 5 20a Power mirror switch Power window relay Rabs test connector Radio Red Regular cab w/ cd Relay box #1 Relay box #2 Relay box #3 Remote anti- theft personality (rap) module Right power lumbar switch Super cab Super cab only To pcm power maxi fuse 13 W/ premium sound Power Distribution Wiring Diagram (3 of 3) for Ford Ranger Splash 1996 List of elements for Power Distribution Wiring Diagram (3 of 3) for Ford Ranger Splash 1996: 57 3.0l/ 4.0l only 4 wheel drive fuse 16 20a Air bag diagnostic monitor Air bag fuse 19 10a Amplifier Auxiliary power socket C111 C168 C214 C215 C216 C250 C251 C414 Cd changer Cluster Electric shift control module Electric shift relay Engine compartment fuse/relay box Engine compartment fuse/relay panel Engine compt. fuse/relay box Engine controls system From fuel c sys/ anti- theft maxi fuse 12 From ignition b Fuse (not used) Fuse 25a Fuse 7.5a G104 (top center of left fender apron) Generator fuse 17 15a Generator voltage regulator Heated oxygen sensor (ho2s) #1 Heated oxygen sensor (ho2s) #2 Heated oxygen sensor (ho2s) #3 Ho2s fuse 20 15a Horn relay Horn/pcm memory power maxi fuse 4 20a I/p fuse panel Ignition coil (3.0l/4.0l) Instrument Instrument cluster Jbl fuse 22 20a Main light switch Nca Pcm power diode Pcm power maxi fuse 13 30a Pcm power relay Power point fuse 21 30a Powertrain control module (pcm) Primary ignition coil (2.3l) Rabs resistor Radio noise capacitor Red Regular cab w/ cd Relay box #1 Secondary ignition coil (2.3l) Super cab and regular cab w/o cd Switch, term. i1
POWER DOOR LOCKS Door Lock Wiring Diagram for Ford Ranger Splash 1996 List of elements for Door Lock Wiring Diagram for Ford Ranger Splash 1996: 14 All lock relay All unlock relay Engine compartment fuse/relay box (left rear of engine compt.) G104 (top center of left fender apron) G200 (behind left cowl panel) Hot at all times Left door lock motor Left door lock switch Lock Power lock/ window/seat maxi fuse 5 20a Relay box #1 (behind i/p, right of steering column) Right door lock motor Right door lock switch Unlock Keyless Entry & Anti-Theft Wiring Diagram for Ford Ranger Splash 1996 List of elements for Keyless Entry & Anti-Theft Wiring Diagram for Ford Ranger Splash 1996: 63 (closed when door is unlocked w/ key) left door disarm switch (dlc) in All lock relay All unlock relay Anti-theft hood switch C214 C219 C221 C222 C409 C410 Clock spring assembly (top of steering column) Cruise control system Data link connector (dlc) (fastened to bottom of i/p, near steering column) Door ajar Door ajar in Door disarm in Driver's unlock relay (right side of i/p) Engine compartment fuse/relay box (left rear of engine compt.) Exterior lights system Fuel sys/ anti-theft maxi fuse 12 20a Fuse 10a Fuse 7.5a G104 (top center of left fender apron) G105 (right side of engine compartment, on upper fender apron) G108 (left side of upper radiator support) G200 (behind left cowl panel) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Ground Hood sw in Horn rly out Horns system Hot at all times Hot in acc or run Hot in start I/p fuse panel (left side of i/p) Ign tamper sw in Ignition tamper switch Illum entry Illum entry ctrl Instrument cluster Key sw in Left door lock motor Left door lock switch Lock Lock in/out Nca Park lp rly ctrl Power lock/ window/seat maxi fuse 5 20a Pwr (bat) Pwr (ign) Relay box #1 (behind i/p, right of steering column) Remote anti-theft personality (rap) module (left rear corner of cab) Right door disarm switch (closed when door is unlocked w/ key) Right door lock motor Right door lock switch Start rly ctrl Starter interrupt relay (relay box #1: behind i/p, right of steering column) Starting/ charging system Theft indicator Unlock Unlock drv's dr Unlock in/out
POWER MIRRORS Power Mirror Wiring Diagram for Ford Ranger Splash 1996 List of elements for Power Mirror Wiring Diagram for Ford Ranger Splash 1996: 14 Direct- tional switch Fuse 7.5a G200 (behind left kick panel) Hot at all times I/p fuse panel (behind left side of i/p) L/r motor Left power mirror Left/ right switch Nca Power mirror switch Red Right power mirror S300 Up/dn motor
POWER SEATS Driver Power Seat Wiring Diagram for Ford Ranger Splash 1996 List of elements for Driver Power Seat Wiring Diagram for Ford Ranger Splash 1996: 17 Engine compartment fuse/relay box (left rear of engine compt.) Entire seat Front height motor Front of seat Fwd Fwd/rwd motor G200 (behind left cowl panel) Hot at all times Left seat control switch Lumbar circuit Lumbar circuit (left pwr bolster lumbar motor) Nca Power lock/ window/seat maxi fuse 5 20a Power seat motor Rear height motor Rear of seat Rwd Lumbar Wiring Diagram for Ford Ranger Splash 1996 List of elements for Lumbar Wiring Diagram for Ford Ranger Splash 1996: 12 Engine compartment fuse/relay box (left rear of engine compt.) G200 (behind left cowl panel) Hot at all times Left power bolster lumbar motor Left power bolster switch (super cab only) Left power lumbar switch Nca Power lock/ window/seat maxi fuse 5 20a Power seat circuit Red Right power lumbar motor Right power lumbar switch
POWER WINDOWS Power Window Wiring Diagram for Ford Ranger Splash 1996 List of elements for Power Window Wiring Diagram for Ford Ranger Splash 1996: 26 C224 Down Down comnd in Down sense(hi) Down sense(lo) Engine compartment fuse/relay box (left rear of engine compt) Fuse 10a G104 (top center of left fender apron) G200 (behind left cowl panel) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Hot at all times Hot in accy or run I/p fuse panel (behind left side of i/p) Left Left power window motor Master window control switch One touch down module (relay box #1: behind i/p, right of steering column) Otd relay out Power lock/ window/seat maxi fuse 5 20a Power window relay (under right side of i/p) Red Right Right power window motor Right window switch Up comnd in Wiper/ washer system
RADIO Base Radio for Ford Ranger Splash 1996 List of elements for Base Radio for Ford Ranger Splash 1996: 31 (1996-97) (1995) Antenna C229 Fuse 10a 15a Fuse 7.5a 10a Fused ignition G104 (top center of left fender apron) G203 (behind right kick panel) Ground Hot at all times Hot in run or acc I/p fuse panel (behind left side of dash) Ilumination Interior lights system L front spkr (+) L front spkr (-) L rear spkr (+) L rear spkr (-) Left door speaker Left rear speaker Nca Power (b+) R front spkr (+) R front spkr (-) R rear spkr (+) R rear spkr (-) Radio Right door speaker Right rear speaker S209 S238 Premium Sound Radio Wiring Diagram for Ford Ranger Splash 1996 List of elements for Premium Sound Radio Wiring Diagram for Ford Ranger Splash 1996: 58 (1997) (1998) (behind right kick panel) g203 (benind right kick panel) g203 Amplifier (right rear of cab) Antenna Audio on C228 C243 C414 C415 Cd changer Engine compartment fuse/relay box (left rear of engine compt) Fuse 1 (jbl) 22 (jbl) 20a Fuse 10a Fuse 7.5a Fused ignition G104 (top center of left fender apron) G203 (behind right kick panel) Ground Hot at all times Hot in run or acc I/p fuse panel (behind left side of dash) Illulminaton Interior lights system L front (+) L front (-) L front sig (+) L front sig (-) L rear (+) L rear (-) L rear sig (+) L rear sig (-) Left door speaker Left rear speaker Logic mute Nca Power (b+) Protocal b Protocol a Protocol b R front (+) R front (-) R front sig (+) R front sig (-) R rear (+) R rear (-) R rear sig (+) R rear sig (-) Radio Regular cab w/ cd Right door speaker Right rear speaker S209 S228 Shield Super cab Super cab & regular cab w/o cd Tan
SHIFT INTERLOCKS Shift Interlock Wiring Diagram for Ford Ranger Splash 1996 List of elements for Shift Interlock Wiring Diagram for Ford Ranger Splash 1996: 10 (brake pedal support) Brake on/off (boo)switch Fuse 10 7.5a Fuse 13 15a G104 (top center of left fender apron) Hot at all times Hot in run I/p fuse panel (behind left side of i/p) Shift lock actuator (on upper steering column) Solid state
STARTING/CHARGING Charging Wiring Diagram for Ford Ranger Splash 1996 List of elements for Charging Wiring Diagram for Ford Ranger Splash 1996: 29 (left fender apron, (right side of engine) (2.3l) g120 470 ohms Acc At starter relay) Battery C168 C169 C177 C216 Charge indicator Engine compartment fuse/relay box (left rear of engine compt.) Fuse 15a Fuse 17 generator 15a Fuse link a G100 (lower left front of engine compt.) G100 (lower left front of engine compt., on frame rail) G114 (3.0l/4.0l) (left rear of engine) Generator/ voltage regulator I/p fuse panel (behind left side of i/p) Ignition switch Instrument cluster Lock Maxi fuse 1 ignition 50a Off Red Start run Starter motor/ solenoid Starter relay (left fender apron, near battery) Starting Wiring Diagram, A/T for Ford Ranger Splash 1996 List of elements for Starting Wiring Diagram, A/T for Ford Ranger Splash 1996: 29 (left side of trans.) transmission range (tr) sensor (right side of engine) (2.3l) g120 Acc Battery C178 C409 Charging circuit Clutch pedal position (cpp) switch jumper (left side of steering column) Engine compartment fuse/relay box (left rear of engine compt.) Fuse 10a G100 (lower left front of engine compt.) G100 (lower left front of engine compt., on frame rail) G114 (3.0l/4.ol) (left rear of engine) I/p fuse panel (behind left side of i/p) Ignition switch Lock Maxi fuse 1 ignition 50a Off Pnk Red Remote anti- theft person- ality (rap) module (left rear corner of cab) Run Sta Start Starter interrupt relay (in relay box #1) Starter motor/ solenoid Starter relay (left fender apron, near battery) W/ anti- theft W/o anti- theft Starting Wiring Diagram, M/T Base for Ford Ranger Splash 1996 List of elements for Starting Wiring Diagram, M/T Base for Ford Ranger Splash 1996: 28 (right side of engine) (2.3l) g120 Acc Battery C178 C409 Charging circuit Clutch pedal position (cpp) switch (top of clutch pedal support) Engine compartment fuse/relay box (left rear of engine compt.) Fuse 10a G100 (lower left front of engine compt.) G100 (lower left front of engine compt., on frame rail) G114 (3.0l/4.ol) (left rear of engine) I/p fuse panel (behind left side of i/p) Ignition switch Lock Maxi fuse 1 ignition 50a Off Pnk Red Remote anti- theft person- ality (rap) module (left rear corner of cab) Run Sta Start Starter interrupt relay (in relay box #1) Starter motor/ solenoid Starter relay (left fender apron, near battery) W/ anti- theft W/o anti- theft
SUPPLEMENTAL RESTRAINTS Supplemental Restraint Wiring Diagram, with Passenger Deactivation for Ford Ranger Splash 1996 List of elements for Supplemental Restraint Wiring Diagram, with Passenger Deactivation for Ford Ranger Splash 1996: 35 * pin shorting bar is engaged when module connector is disconnected Air bag diagnostic monitor (behind right side of cowl panel) Air bag fuse 19 10a Air bag ind Air bag indicator control C250 C251 Clock- spring assembly Data link Data link connector (left side of i/p) Driver's air bag Drvr air bag Engine compartment fuse/relay box (left rear of engine compt) Fuse 15 7.5a Fuse 6 7.5a G104 (top center of left fender apron) G108 (left upper radiator support) Gnd Hot at all times Hot in run Hot in run or start I/p fuse panel (below left side of i/p) Instrument cluster L crash sens Left primary crash sensor (left front upper radiator support) Nca Off Pass air bag Passenger airbag deactivation module Passenger's air bag Pwr (bat) Pwr (run) R crash sens Right primary crash sensor (right front upper radiator support) Shorting bar Supplemental Restraint Wiring Diagram, without Passenger Deactivation for Ford Ranger Splash 1996 List of elements for Supplemental Restraint Wiring Diagram, without Passenger Deactivation for Ford Ranger Splash 1996: 32 * pin shorting bar is engaged when module connector is disconnected Air bag diagnostic monitor (behind right side of cowl panel) Air bag fuse 19 10a Air bag ind Air bag indicator control C250 C251 Clock- spring assembly Data link Data link connector (left side of i/p) Driver's air bag Drvr air bag Engine compartment fuse/relay box (left rear of engine compt) Fuse 15 7.5a Fuse 6 7.5a G108 (left upper radiator support) Gnd Hot at all times Hot in run Hot in run or start I/p fuse panel (below left side of i/p) Instrument cluster L crash sens Left primary crash sensor (left front upper radiator support) Nca Pass air bag Passenger's air bag Pwr (bat) Pwr (run) R crash sens Right primary crash sensor (right front upper radiator support) Shorting bar
TRANSMISSION
2.3L 2.3L, Transmission Wiring Diagram for Ford Ranger Splash 1996 List of elements for 2.3L, Transmission Wiring Diagram for Ford Ranger Splash 1996: 95 (dash panel to headlamp junction harness, near break out to left headlamp) (engine control sensor extension harness, near break out to harness in-line connector, left rear of engine) (engine control sensor harness, near break out to ground g123, right side of safety wall) (engine control sensor harness, near break out to intake air temperature (iat) sensor (engine control sensor harness, near break out to throttle position (tp) sensor) (left side of upper radiator support) g108 (left side of transmission) transmission range (tr) sensor (left side of upper radiator support) g108 (power for heated oxygen sensors) (right side of safety wall) g123 (top center of left fender apron) g104 4r44e/4r55e automatic transmission (left side of transmission) Boo Brake on/off (boo) switch (on brake pedal support) C111 C214 C216 Case gnd Ccs Coast clutch solenoid (css) Cse gnd Dlc Dlc (+) Dlc (-) Ect Electronic pressure control (epc) solenoid Engine air cleaner assembly Engine compartment fuse/relay box Engine coolant temperature (ect) sensor (top right front of engine, in water outlet tube) Epc Fuse 13 15a Fuse 19 25a Fuse 26 10a Ho2s fuse 20 15a Horn/pcm memory power fuse 4 20a Hot at all times Hot in run Hot in start or run I/p fuse panel Iat Instrument cluster Intake air temperature (iat) sensor (right side of engine compartment, on air intake assembly) Kapwr Maf Maf rtn Malfunction indicator lamp (mil) Mass air flow (maf) sensor Mil N d Nca O/d off Pcm power diode Pcm power fuse 13 30a Pcm power relay Power Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Pwr gnd Red S100 S1002 S1003 S102 (engine control sensor harness, near break out to intake air temperature (iat) sensor) S103 S104 S106 S108 S110 S111 S118 S121 S134 S135 S142 (dash panel to headlamp junction harness, in break out to harness in-line connector, left side of safety wall) S147 Shift solenoid (ss1) Shift solenoid (ss2) Shift solenoid (ss3) Sig rtn Ss1 Ss2 Ss3 Tcc Tcil Tcs Tft Throttle position (tp) sensor (top right side of engine, on throttle body) Torque converter clutch (tcc) solenoid Transmission control indicator lamp (tcil) Transmission control switch (tcs) Transmission fluid temperature (tft) sensor Tss Turbine shaft speed (tss) sensor Vehicle speed sensor (vss) (left rear of transmission) (4x2 models) (left rear of transfer case) (4x4 models) Vref Vss Transfer Case Wiring Diagram for Ford Ranger Splash 1996 List of elements for Transfer Case Wiring Diagram for Ford Ranger Splash 1996: 67 (behind i/p, right side of steering column) relay box 1 (main harness, in break out to generic electronic module (gem) connectors) (main harness, near break out to i/p fuse panel) (top center of left fender apron) g104 1.1k ohms 1995 models 1996 models 3.9k ohms 4 wheel drive fuse 16 20a 4wd hi ind 4wd ind ctrl 4wd lo ind 4wd mode sw 4wd mode switch 4wd motor 4wd output Battery saver relay Boo sw input Brake on/off (boo) switch (on brake pedal support) C214 C221 C223 C224 Ccw relay Ccw rly ctrl Clutch Cw relay Cw rly ctrl Elc rly ctrl Electric shift control module (behind center of i/p) Electric shift relay Engine compartment fuse/relay box Fuse 13 15a Fuse 27 15a (1995 models) 10a (1996 models) G104 (top center of left fender apron) Generic electronic module (gem) (behind center of i/p) Hot at all times I/p fuse panel Illumination Instrument cluster Interior lights system (instrument illum- ination circuit) Nca Neutral sw in Ohms Park lamps fuse 7 20a Pin out for 1995 models only Pin out for 1996 models only Pnk Relay box 1 (behind i/p, right side of steering column) Rly ctrl S107 S209 S215 S216 S218 S221 S224 S228 (main harness, near break out to instrument cluster connectors) S237 Sw a input Sw b input Sw c input Sw d input Touch drive Transfer case assembly (below vehicle, behind transmission) Transmission range (tr) sensor (left side of transmission) Wall) g123
3.0L 3.0L, Transmission Wiring Diagram for Ford Ranger Splash 1996 List of elements for 3.0L, Transmission Wiring Diagram for Ford Ranger Splash 1996: 98 (dash panel to headlamp junction harness, near break out to left headlamp) (engine control sensor extension harness, near break out to harness in-line connector, left rear of engine) (engine control sensor harness, in break out to differential pressure feedback egr (dpfe) sensor) (engine control sensor harness, in break out to harness in-line connector, rear of engine, top of transmission bell housing) (engine control sensor harness, near break out to differential pressure feedback egr (dpfe) sensor) s102 (engine control sensor harness, near break out to egr vacuum regulator (evr) solenoid) (engine control sensor harness, near break out to harness in-line connector, left rear of engine) (engine control sensor harness, near break out to octane adjust shorting bar) (left side of upper radiator support) g108 (left side of transmission) transmission range (tr) sensor (left side of upper radiator support) g108 (power for heated oxygen sensors) (right side of safety wall) g123 (top center of left fender apron) g104 4r44e/4r55e automatic transmission (left side of transmission) Boo Brake on/off (boo) switch (on brake pedal support) C111 C214 C216 Case gnd Coast clutch solenoid (css) Css Dlc Dlc (+) Dlc (-) Ect Electronic pressure control (epc) solenoid Engine air cleaner assembly Engine compartment fuse/relay box Engine coolant temperature (ect) sensor (top front of engine) Epc Fuse 13 15a Fuse 19 25a Fuse 26 10a Ho2s fuse 20 15a Horn/pcm memory power fuse 4 20a Hot at all times Hot in run Hot in start or run I/p fuse panel Iat Instrument cluster Intake air temperature (iat) sensor (right side of engine compartment, on air intake assembly) Kapwr Maf Maf rtn Malfunction indicator lamp (mil) Mass air flow (maf) sensor Mil N d Nca O/d off Pcm power diode Pcm power fuse 13 30a Pcm power relay Power Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Pwr gnd Red S100 S1002 S1003 S103 S104 S106 S108 S110 S111 S112 (engine control sensor harness, near break out to octane adjust shorting bar) S113 S118 S121 S134 S135 S142 (dash panel to headlamp junction harness, in break out to harness in-line connector, left side of safety wall) S147 Shift solenoid (ss1) Shift solenoid (ss2) Shift solenoid (ss3) Sig rtn Ss1 Ss2 Ss3 Tcc Tcil Tcs Tft Throttle position (tp) sensor (top left front of engine, on throttle body) Torque converter clutch (tcc) solenoid Transmission control indicator lamp (tcil) Transmission control switch (tcs) Transmission fluid temperature (tft) sensor Tss Turbine shaft speed (tss) sensor Vehicle speed sensor (vss) (left rear of transmission) (4x2 models) (left rear of transfer case) (4x4 models) Vref Vss Transfer Case Wiring Diagram for Ford Ranger Splash 1996 List of elements for Transfer Case Wiring Diagram for Ford Ranger Splash 1996: 67 (behind i/p, right side of steering column) relay box 1 (main harness, in break out to generic electronic module (gem) connectors) (main harness, near break out to i/p fuse panel) (top center of left fender apron) g104 1.1k ohms 1995 models 1996 models 3.9k ohms 4 wheel drive fuse 16 20a 4wd hi ind 4wd ind ctrl 4wd lo ind 4wd mode sw 4wd mode switch 4wd motor 4wd output Battery saver relay Boo sw input Brake on/off (boo) switch (on brake pedal support) C214 C221 C223 C224 Ccw relay Ccw rly ctrl Clutch Cw relay Cw rly ctrl Elc rly ctrl Electric shift control module (behind center of i/p) Electric shift relay Engine compartment fuse/relay box Fuse 13 15a Fuse 27 15a (1995 models) 10a (1996 models) G104 (top center of left fender apron) Generic electronic module (gem) (behind center of i/p) Hot at all times I/p fuse panel Illumination Instrument cluster Interior lights system (instrument illum- ination circuit) Nca Neutral sw in Ohms Park lamps fuse 7 20a Pin out for 1995 models only Pin out for 1996 models only Pnk Relay box 1 (behind i/p, right side of steering column) Rly ctrl S107 S209 S215 S216 S218 S221 S224 S228 (main harness, near break out to instrument cluster connectors) S237 Sw a input Sw b input Sw c input Sw d input Touch drive Transfer case assembly (below vehicle, behind transmission) Transmission range (tr) sensor (left side of transmission) Wall) g123
4.0L 4.0L, Transmission Wiring Diagram for Ford Ranger Splash 1996 List of elements for 4.0L, Transmission Wiring Diagram for Ford Ranger Splash 1996: 98 (dash panel to headlamp junction harness, near break out to left headlamp) (engine control sensor extension harness, near break out to harness in-line connector, left rear of engine) (engine control sensor harness, in break out to differential pressure feedback egr (dpfe) sensor) (engine control sensor harness, in break out to harness in-line connector, rear of engine, top of transmission bell housing) (engine control sensor harness, near break out to fuel injector 5) (engine control sensor harness, near break out to fuel injector 5) s102 (engine control sensor harness, near break out to fuel injector 6) (engine control sensor harness, near break out to fuel injector 6) s103 (engine control sensor harness, near break out to mass air flow (maf) sensor) (left side of upper radiator support) g108 (left side of transmission) transmission range (tr) sensor (left side of upper radiator support) g108 (power for heated oxygen sensors) (right side of safety wall) g123 (top center of left fender apron) g104 4r44e/4r55e automatic transmission (left side of transmission) Boo Brake on/off (boo) switch (on brake pedal support) C111 C214 C216 Case gnd Ccs Coast clutch solenoid (css) Dlc Dlc (+) Dlc (-) Ect Electronic pressure control (epc) solenoid Engine air cleaner assembly Engine compartment fuse/relay box Engine coolant temperature (ect) sensor (top front of engine) Epc Fuse 13 15a Fuse 19 25a Fuse 26 10a Ho2s fuse 20 15a Horn/pcm memory power fuse 4 20a Hot at all times Hot in run Hot in start or run I/p fuse panel Iat Instrument cluster Intake air temperature (iat) sensor (front of engine, on air intake assembly) Kapwr Maf Maf rtn Malfunction indicator lamp (mil) Mass air flow (maf) sensor Mil N d Nca O/d off Pcm power diode Pcm power fuse 13 30a Pcm power relay Power Powertrain control module (pcm) (right rear of engine compartment, through safety wall) Pwr gnd Red S100 S1002 S1003 S104 S106 S108 S110 S111 S112 (engine control sensor harness, near break out to powertrain control module) S113 S118 S121 S134 S135 S142 (dash panel to headlamp junction harness, in break out to harness in-line connector, left side of safety wall) S147 Shift solenoid (ss1) Shift solenoid (ss2) Shift solenoid (ss3) Sig rtn Ss1 Ss2 Ss3 Tcc Tcil Tcs Tft Throttle position (tp) sensor (top left front of engine, on throttle body) Torque converter clutch (tcc) solenoid Transmission control indicator lamp (tcil) Transmission control switch (tcs) Transmission fluid temperature (tft) sensor Tss Turbine shaft speed (tss) sensor Vehicle speed sensor (vss) (left rear of transmission) (4x2 models) (left rear of transfer case) (4x4 models) Vref Vss Transfer Case Wiring Diagram for Ford Ranger Splash 1996 List of elements for Transfer Case Wiring Diagram for Ford Ranger Splash 1996: 67 (behind i/p, right side of steering column) relay box 1 (main harness, in break out to generic electronic module (gem) connectors) (main harness, near break out to i/p fuse panel) (top center of left fender apron) g104 1.1k ohms 1995 models 1996 models 3.9k ohms 4 wheel drive fuse 16 20a 4wd hi ind 4wd ind ctrl 4wd lo ind 4wd mode sw 4wd mode switch 4wd motor 4wd output Battery saver relay Boo sw input Brake on/off (boo) switch (on brake pedal support) C214 C221 C223 C224 Ccw relay Ccw rly ctrl Clutch Cw relay Cw rly ctrl Elc rly ctrl Electric shift control module (behind center of i/p) Electric shift relay Engine compartment fuse/relay box Fuse 13 15a Fuse 27 15a (1995 models) 10a (1996 models) G104 (top center of left fender apron) Generic electronic module (gem) (behind center of i/p) Hot at all times I/p fuse panel Illumination Instrument cluster Interior lights system (instrument illum- ination circuit) Nca Neutral sw in Ohms Park lamps fuse 7 20a Pin out for 1995 models only Pin out for 1996 models only Pnk Relay box 1 (behind i/p, right side of steering column) Rly ctrl S107 S209 S215 S216 S218 S221 S224 S228 (main harness, near break out to instrument cluster connectors) S237 Sw a input Sw b input Sw c input Sw d input Touch drive Transfer case assembly (below vehicle, behind transmission) Transmission range (tr) sensor (left side of transmission) Wall) g123
WARNING SYSTEMS Warning System Wiring Diagrams for Ford Ranger Splash 1996 List of elements for Warning System Wiring Diagrams for Ford Ranger Splash 1996: 42 (behind i/p, right of steering column) relay box #1 (or 14) Anti- theft system C215 C216 C219 C221 C224 Clock spring assembly (top of steering column) Courtesy lamps Cruise control system Exterior lights system Fuse 15a Fuse 7.5a G104 (top center of left fender apron) G108 (left side of upper radiator support) G200 (behind left cowl panel) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Ground Head Hot at all times Hot in run or start I/p fuse panel (behind left side of i/p) Ign key warn sw Ignition key warning switch (steering wheel assembly) Instrument cluster Left door ajar switch Left door sw in Main light switch Nca Off Park Park lamps relay Pwr (battery) Right door ajar switch Right door sw in Seat belt ind Seat belt indi- cator Seat belt sw in Seat belt switch (in left buckle assembly) W/ anti- theft W/o anti-theft
WIPER/WASHER Wiper/Washer Wiring Diagram for Ford Ranger Splash 1996 List of elements for Wiper/Washer Wiring Diagram for Ford Ranger Splash 1996: 43 (right fromt of engine compartment) relay box #2 103.3k ohms 11.3k 3.3k ohms 4.08k Body computer system C221 C254 Dely/wsh in Engine compartment fuse/relay box (left rear of engine compt.) Fuse 10a Fuse 30a G104 (top center of left fender apron) G105 (right side of engine compt., on upper fender apron) Generic electronic module (gem)/ central timer module (ctm) (behind center of i/p) Hi/lo rly Hot in acc or run I/p fuse panel (behind left side of i/p) Int max Int min Mod sel sw Multi- function switch (top left side of steering column) Nca Nca hi Nca lo Off Off 47.6k ohms Ohms Park sense Power windows system Red Return Run/prk rly Tan/red W/ electronic shift control Washer pump relay Washer switch Windshield washer pump Windshield wiper motor Wiper hi-lo relay Wiper run/ park relay Wiper switch Wsh pmp rly
