Diagram sections — 26 (72 total)
ANTI-LOCK BRAKES COMPUTER DATA LINES CRUISE CONTROL DEFOGGERS ELECTRONIC POWER STEERING ENGINE PERFORMANCE EXTERIOR LIGHTS GROUND DISTRIBUTION HEADLIGHTS HORN INSTRUMENT CLUSTER INTERIOR LIGHTS POWER ANTENNA POWER DISTRIBUTION POWER DOOR LOCKS POWER MIRRORS POWER SEATS POWER TOP/SUNROOF POWER WINDOWS RADIO SHIFT INTERLOCKS STARTING/CHARGING SUPPLEMENTAL RESTRAINTS TRANSMISSION TRUNK, TAILGATE, FUEL DOOR WIPER/WASHER
ANTI-LOCK BRAKES
3.0L 3.0L, Anti-lock Brake Wiring Diagrams for Mercury Sable GS 1994 List of elements for 3.0L, Anti-lock Brake Wiring Diagrams for Mercury Sable GS 1994: 98 #18 (front of left (front of left fender apron) (front of right (front of right fender apron) (left fender apron) (left front of engine compt) (lower left front of engine compt) (on brake fluid reservoir) (on brake pedal support) (right fender apron) (right rear of engine compt (right rear of engine compt, 10a 15a 30a 40a 87a Abs data link conn Abs diode Abs motor relay Abs relay Abs test conn input Accy All times Anti/ Anti/lock Anti/lock brake control module Anti/lock brake fluid level sw Anti/lock brake motor relay Anti/lock brake pedal travel sw Anti/lock brake power relay Anti/lock ind Brake Brake sensor Brake sw Brake sw input Cluster Compt Engine Feed Fender apron) Fluid level sw input Fuse Fuse box G100 G109 Ground Hot Hot at Hot at all times Hot in I/p In run Indicator Inlet Instrument L fnt brake sensor L fnt valve inlet L fnt valve outlet L rear brake sensor L rear valve inlet L rear valve outlet Left front Left rear Lock Mod Mtr Nca Near a/c accumulater) Outlet Panel Pnk Pnk 498 Pump mtr spd sensor Red/ Red/pnk Red/pnk 523 Right front Right rear Rt fnt brake sensor Rt fnt valve inlet Rt fnt valve outlet Rt rear brake sensor Rt rear valve inlet Rt rear valve outlet Run power Solenoid ctrl valve body Start or run Stop lt sw Sw reference volt Switched power Tan Tan 495 Tan/red Tan/red 201 Tan/red 510 Taped to harness)
3.8L 3.8L, Anti-lock Brake Wiring Diagrams for Mercury Sable GS 1994 List of elements for 3.8L, Anti-lock Brake Wiring Diagrams for Mercury Sable GS 1994: 98 #18 (front of left (front of left fender apron) (front of right (front of right fender apron) (left fender apron) (left front of engine compt) (lower left front of engine compt) (on brake fluid reservoir) (on brake pedal support) (right fender apron) (right rear of engine compt (right rear of engine compt, 10a 15a 30a 40a 87a Abs data link conn Abs diode Abs motor relay Abs relay Abs test conn input Accy All times Anti/ Anti/lock Anti/lock brake control module Anti/lock brake fluid level sw Anti/lock brake motor relay Anti/lock brake pedal travel sw Anti/lock brake power relay Anti/lock ind Brake Brake sensor Brake sw Brake sw input Cluster Compt Engine Feed Fender apron) Fluid level sw input Fuse Fuse box G100 G109 Ground Hot Hot at Hot at all times Hot in I/p In run Indicator Inlet Instrument L fnt brake sensor L fnt valve inlet L fnt valve outlet L rear brake sensor L rear valve inlet L rear valve outlet Left front Left rear Lock Mod Mtr Nca Near a/c accumulater) Outlet Panel Pnk Pnk 498 Pump mtr spd sensor Red/ Red/pnk Red/pnk 523 Right front Right rear Rt fnt brake sensor Rt fnt valve inlet Rt fnt valve outlet Rt rear brake sensor Rt rear valve inlet Rt rear valve outlet Run power Solenoid ctrl valve body Start or run Stop lt sw Sw reference volt Switched power Tan Tan 495 Tan/red Tan/red 201 Tan/red 510 Taped to harness)
COMPUTER DATA LINES
3.0L 3.0L, Computer Data Lines for Mercury Sable GS 1994 List of elements for 3.0L, Computer Data Lines for Mercury Sable GS 1994: 13 Constant control relay module Data (+) Data (-) Data link connector (on pcm cover) Fp gnd Malfunction indicator (instrument cluster) Powertrain control module Sig rtn Sti Sti data link connector (on pcm cover) Sto/mil Tan/ red
3.8L 3.8L, Computer Data Lines for Mercury Sable GS 1994 List of elements for 3.8L, Computer Data Lines for Mercury Sable GS 1994: 13 Constant control relay module Data (+) Data (-) Data link connector (on pcm cover) Fp gnd Malfunction indicator (instrument cluster) Powertrain control module Sig rtn Sti Sti data link connector (on pcm cover) Sto/mil Tan/ red
CRUISE CONTROL
3.0L 3.0L, Cruise Control Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.0L, Cruise Control Wiring Diagram for Mercury Sable GS 1994: 57 (left front (left side of i/p (left strut (on brake (on transaxle) 100/150 15a 40/75 50,000 Accel Assembly At all Brake on/off sw Brake on/off sw in Clockspring Coast Control sws input Cruise control Cruise control amplifier Entry Feedback pot pos Feedback pot sig Fender apron) Fuse G104 Ground Horn Hot I/p In acc Keyless Module Near top of cowl panel) Off Ohms Or run Panel Pedal support) Power input Relay Remote Resume Sensor (vss) Servo Set/ Sol feed Sw assembly Sws Times Tower) Vac sol Vacuum sol control Vehicle speed Vent sol Vent sol control Vss ground Vss signal
3.8L 3.8L, Cruise Control Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.8L, Cruise Control Wiring Diagram for Mercury Sable GS 1994: 57 (left front (left side of i/p (left strut (on brake (on transaxle) 100/150 15a 40/75 50,000 Accel Assembly At all Brake on/off sw Brake on/off sw in Clockspring Coast Control sws input Cruise control Cruise control amplifier Entry Feedback pot pos Feedback pot sig Fender apron) Fuse G104 Ground Horn Hot I/p In acc Keyless Module Near top of cowl panel) Off Ohms Or run Panel Pedal support) Power input Relay Remote Resume Sensor (vss) Servo Set/ Sol feed Sw assembly Sws Times Tower) Vac sol Vacuum sol control Vehicle speed Vent sol Vent sol control Vss ground Vss signal
DEFOGGERS Defogger Wiring Diagram for Mercury Sable GS 1994 List of elements for Defogger Wiring Diagram for Mercury Sable GS 1994: 20 Engine compartment fuse box Fuse 15a G104 (left front fender apron) G401 (right front of trunk near trunk lid hinge) G405 (right of rear cargo area) Hot at all times Hot in run I/p fuse panel Interior lights system (i/p dimming rheostat) Liftgate defrost control Off On ind Rear def fuse 40a Rear window defrost grid Rear window defrost timer Sedan Solid state Switch illumination Wagon Wiper/washer systems (lift gate wiper motor)
ELECTRONIC POWER STEERING Electronic Power Steering Wiring Diagram for Mercury Sable GS 1994 List of elements for Electronic Power Steering Wiring Diagram for Mercury Sable GS 1994: 24 (not used) (others) (sho) (top left side of upper radiator support) (top right front of fender apron) *** **** 43 to Data link conn Fuse 15a G101 G104 (left fender apron) G108 Ground Hot in run I/p fuse panel Nca Sho only Stepper motor Vaps data link connector (left rear of engine compart- ment) Variable assist power steering (vaps) module (behind left side of i/p, right side of steering column) Variable assist stepper motor (lower left rear of engine compart- ment, on power steering gear) Vehicle speed sensor (vss) (left rear of transmission) Vss
ENGINE PERFORMANCE
3.0L
3.8L 3.8L, Engine Performance Wiring Diagrams (1 of 2) for Mercury Sable GS 1994 List of elements for 3.8L, Engine Performance Wiring Diagrams (1 of 2) for Mercury Sable GS 1994: 99 (above throttle body) (in air intake assembly) (left front of engine) (lower left side (near intake manifold) (on power steering gear) (on throttle body) (on transaxle) (right of battery tray) (right side of safety wall) (top left front of engine) (top left side Accs Axode (ax4s) transaxle Boo Canister purge sol Canp Conn (rear of Cont. Cse gnd Data + Data - Dol Ect Egr (pfe) sens Egr vacuum regulator sol Engine compt, Engine coolant temp (ect) sens Epc Evr Fender apron) Fpm Fuel injectors G104 (left G108 (top left G309 (right side Hfc Ho2s-f Ho2s-r Iac Iat Idle air ctrl valve Idm Ign gnd Inj1 Inj2 Inj3 Inj4 Inj5 Inj6 Intake air temp (iat) sens Kapwr Lfc Maf Maf rtn Manual lever postion sens Mass airflow (maf) sens Mlp Of engine) Of safety wall) Of transaxle) On pcm cover) Pfe Pip Pnk Power steering pres sw Powertrain ctrl module (pcm) Pressure feedback Psp Pwr Pwr gnd Red Red 361 Refrig. Side of radiator Sig rtn Spout Ss1 Ss2 Ss3 Sti Sti data link Sto/mil Support) Tan Tan 555 Tan/red Tan/red 201 Tcc Throttle position sens Tot Tss Turbine shaft speed sens Vehice speed sensor Vpwr Vref Vss + Vss - Wac
EXTERIOR LIGHTS Exterior Light Wiring Diagram, Sedan with Lamp Monitor for Mercury Sable GS 1994 List of elements for Exterior Light Wiring Diagram, Sedan with Lamp Monitor for Mercury Sable GS 1994: 66 (ffv) (except ffv) + - 0.010 0.005 resistance wires 0.100 0.001 0.238 0.005 0.256 0.005 0.350 0.005 resistance wires 22a Auto- lamp dual coil relay Brake 0n/off switch (on top of brake pedal support) Digital clock Dimmer switch Electronic flasher (behind left side of i/p, above i/p fuse panel) Engine compt fuse box Fuse 10a Fuse 15a Fuse 20a Fuse 5a G100 (front of left fender apron) G101 (top front of right fender apron) G104 (center of left front fender apron) G407 (in trunk, on latch brace) Hazard Hazard switch Head Headlamps fuse 60a High mount stop lamps Hot Hot at all times I/p fuse panel In run Instrument cluster Lamp out warning module (behind left side of i/p, right of i/p fuse panel) Lcd dimming relay Left backup lamp Left laser lamps Left rear stop/ park/ turn lamps Left stop/ turn lamp reference Left stop/turn lamp sense Left turn ind. Main lamp switch Manual lever position sensor (top left side of transaxle) Multi- function switch Normal Off Park Park lamp reference Park lamp sense Pass Red/ Remote keyless entry module Right backup lamp Right front park/ turn lamp Right laser lamps Right license lamp Right rear stop/ park/ turn lamps Right stop/ turn lamp reference Right stop/turn lamp sense Right turn ind. Solid state Turn left Turn right Turn switches W/o autolamps Warning chime module With autolamps Exterior Light Wiring Diagram, Sedan without Lamp Monitor for Mercury Sable GS 1994 List of elements for Exterior Light Wiring Diagram, Sedan without Lamp Monitor for Mercury Sable GS 1994: 53 (ffv) (except ffv) (not used) 22a Auto- lamp dual coil relay Brake 0n/off switch (on top of brake pedal support) Digital clock Dimmer switch Electronic flasher (behind left side of i/p, above i/p fuse panel) Engine compt fuse box Fuse 10a Fuse 15a Fuse 20a Fuse 5a G100 (front of left fender apron) G101 (top front of right fender apron) G104 (center of left front fender apron) G407 (in trunk, on latch brace) Hazard Hazard switch Head Headlamps fuse 60a High mount stop lamps Hot Hot at all times I/p fuse panel In run Instrument cluster Lcd dimming relay Left backup lamp Left laser lamps Left rear stop/ park/ turn lamps Left turn ind. Main lamp switch Manual lever position sensor (top left side of transaxle) Multi- function switch Normal Off Park Pass Red/ Right backup lamp Right front park/ turn lamp Right laser lamps Right license lamp Right rear stop/ park/ turn lamps Right turn ind. Solid state Turn left Turn right Turn switches W/o autolamps Warning chime module With autolamps Exterior Light Wiring Diagram, Wagon for Mercury Sable GS 1994 List of elements for Exterior Light Wiring Diagram, Wagon for Mercury Sable GS 1994: 68 (ffv) (except ffv) + - 0.010 0.005 resistance wires 0.100 0.001 resistance wire 0.238 0.005 0.350 0.001 resistance wire 22a Auto- lamp dual coil relay Brake 0n/off switch (on top of brake pedal support) Digital clock Dimmer switch Electronic flasher (behind left side of i/p, above i/p fuse panel) Engine compt fuse box Fuse 10a Fuse 15a Fuse 20a Fuse 5a G100 (front of left fender apron) G101 (top front of right fender apron) G104 (center of left front fender apron) G404 (left rear corner of cargo area) Hazard Hazard switch Head Headlamps fuse 60a High mount stop lamps Hot Hot at all times I/p fuse panel In run Instrument cluster Lamp out warning module (behind left side of i/p, right of i/p fuse panel) Lcd dimming relay Left rear side marker lamp Left backup lamp Left laser lamps Left license lamp Left rear stop/ park/ turn lamp Left stop/ turn lamp reference Left stop/ turn lamp sense Left turn ind. Main lamp switch Manual lever position sensor (top left side of transaxle) Multi- function switch Normal Off Park Park lamp reference Park lamp sense Pass Red/ Remote keyless entry module Right backup lamp Right front park/ turn lamp Right laser lamps Right license lamp Right rear side marker lamp Right rear stop/ park/ turn lamp Right stop/ turn lamp reference Right stop/ turn lamp sense Right turn ind. Solid state Turn left Turn right Turn switches W/o autolamps Warning chime module With autolamps
GROUND DISTRIBUTION Ground Distribution Wiring Diagram (1 of 5) for Mercury Sable GS 1994 List of elements for Ground Distribution Wiring Diagram (1 of 5) for Mercury Sable GS 1994: 84 (front of left (left fender apron) (lower left front of engine) (top front of engine) (top left side of (top left side of upper radiator suppot) (top right front of fender apron) (top right side of safety wall) 3.0l 3.0l flexible fuel vehicle 3.2l 3.2l 3.2l Airflow All except sho Amplifier Analog cluster Assist Assmbly Battery Cid Cluster Composition Constant Containment Control Coolant Cooling Cornering Crankshaft Cruise Cylinder Fan Fender apron) Flexible fuel vehicle Fog lt Fuel Fuel gauge Fuel pump/ G100 G101 G104 G108 G110 G123 G125 Headlt Heated Icm Identification Ignition Instrument Left Left front Mass Module Motor Oxygen Park/turn Pcm Position Postion Power Powertrain Pump Radiator Radiator support) Refrigerant Relay Right Right front Sender Sensor Sensor #1 Sensor #2 Sensor shield Servo/ Shield Sho Speed Steering Variable Vehicle Washer Windshield Ground Distribution Wiring Diagram (2 of 5) for Mercury Sable GS 1994 List of elements for Ground Distribution Wiring Diagram (2 of 5) for Mercury Sable GS 1994: 94 (front of left (front of right fender apron) (left front fender apron) (sho only) (top front of right fender apron) (top left radiator support) Abs All except All except sho All excxept sho All models All models without power windows All others Amplifier Analog Anti/lock Ashtray Assembly Assembly/ Assist Brake Brake pump Cigar Clock Cluster Connector Control Control/sw Coolant Cornering Courtesy Cruise Cylinder Data link Digital Door Door lock Fender apron) Fuel gauge Fuel pump/ G100 G101 G104 G108 G109 Headlt Horn sw Illum Instrument Left Left front Left laser Left lock Left rear Lighter Mirror Module Motor Motor speed Not Only Park/ Power Powertrain Prndl Pump Relay Right Right front Right laser Right rear Sable only Sender Sensor Sensor shield Shield Sho Sho only Speed Spring Steering Taurus Taurus w/o abs Temperature Turn lt Used Variable Vehicle W/o abs Washer Windshield With abs With power door locks Without power door locks Ground Distribution Wiring Diagram (4 of 5) for Mercury Sable GS 1994 List of elements for Ground Distribution Wiring Diagram (4 of 5) for Mercury Sable GS 1994: 86 (base models only) (base taurus only) (left fender apron) 3.2l sho A/c Accessory Actuator Airbag Amplifier Analog cluster, except police package Antenna Ashtray Base models Brake Cd player Chime Cigar Clock Cluster Cold Compartment Control Courtesy Cruise Defrost Defrost/ Diagnostic Digital Dimming Eatc Elec/ Engine Except Except 3.0l sho Except sho Except sho and base taurus Flasher Fluid Fog Ground I/p Ignition Illum Instrument Left Level Liftgate Lighter Lock Lock out Lockout Low oil Lt out Main Module Monitor Motor Only Plyer Police Power Radio Rear Redundant Relay Rhestat Right Sable Shift Sho only Taurus Timer Tronic Wagon Warning Washer Window Windshield Wiper Wiper/ Wiper/washer With With eatc With eatc, except sho With police package Without Ground Distribution Wiring Diagram (5 of 5) for Mercury Sable GS 1994 List of elements for Ground Distribution Wiring Diagram (5 of 5) for Mercury Sable GS 1994: 45 (in trunk, on latch brace) (left rear corner of cargo area) All except sho All others Assembly Back-up Cargo Compartment Entry G404 G407 Hi level Hi mount Illum Latch Left Left rear License Liftgate Lsim Luggage Marker Mercury Module Motor Park/ Park/stop/ Pump Rear side Relay Release Right Right rear Sable sedan Sho Solenoid Standard Station wagon taurus/sable Stop lt Stop lts Stop/ Taurus sedan Trunk lid Turn lt Washer
HEADLIGHTS Autolamps Wiring Diagram, with DRL for Mercury Sable GS 1994 List of elements for Autolamps Wiring Diagram, with DRL for Mercury Sable GS 1994: 75 indicator control (behind left side of inst panel, taped to main harness, near fuse panel) (behind lower center of inst panel, above warning chime module) (center of left front fender apron) (front of left front fender apron) 15a 196k 87a Acc Autolamp control switch Autolamp dual coil relay (behind center of inst Battery power Brake fluid level sw (on brake fluid reservoir) Brake ind (inst clstr) Daytime running lamps (drl) module (lower left front of engine compt) Delay output Delayed exit input Drl disable Engine compt fuse block Engine compt fuse panel Fog lamp in-line fuse Fog lamp relay (behind lower center of inst panel, on left inst panel vertical brace) Fog light switch Fuse 10a Fuse 15a Fuse 20a Fuse panel 40a G100 G101 (top front of right front fender apron) G104 G206 Head Head lamps fuse 60a Hi-beam indicator Hot at all times Hot in run or start Ignition input Ignition power Ignition switch Inst panel dimmimg rheostat Inst panel fuse block Inst panel fuse panel Instrument cluster Interior lts Lamps out warning module Lcd dimming relay Left fog light Left headlight Light sensor/ amplifier (top left side of inst panel, above inst clstr) Lo beam input Lock Main light switch Max Min Multi- function switch Not used Off On indica- tor On indicator On/off Panel, on right vertical brace) Park Park switch switch (on top of park brake support) Pass Pulsed voltage Resistance wire (.o74 +/- .001 ohms) Right fog light Right headlight Run Start Switch illumination W/ lamp out warning W/o lamp out warning Autolamps Wiring Diagram, without DRL for Mercury Sable GS 1994 List of elements for Autolamps Wiring Diagram, without DRL for Mercury Sable GS 1994: 63 (behind left side of inst panel, taped to main harness, near fuse panel) (behind lower center of inst panel, above warning chime module) (center of left front fender apron) (front of left front fender apron) 15a 196k 87a Autolamp control switch Autolamp dual coil relay (behind center of inst Battery power Daytime running lamps (drl) jumper (lower left front of engine compt) Delay output Delayed exit input Dimming/passing switch Engine compt fuse block Engine compt fuse panel Fog lamp in-line fuse Fog lamp relay (behind lower center of inst panel, on left inst panel vertical brace) Fog light switch Fuse 10a Fuse 20a Fuse panel Fuse panel 40a G100 G101 (top front of right front fender apron) G104 G206 Head Head lamps fuse 60a Hi-beam indicator Hot at all times Hot in run or start I/p Ignition power Inst panel dimming rheostat Inst panel fuse block Instrument cluster Interior lts Lamps out warning module Lcd dimming relay Left fog light Left headlight Light sensor/ amplifier (top left side of inst panel, above inst clstr) Main light switch Max Min Multi- function switch Not used Off On indica- tor On indicator On/off Panel, on right vertical brace) Park Pass Resistance wire (.o74 +/- .001 ohms) Right fog light Right headlight Switch illumination W/ lamp out warning W/o lamp out warning Headlamps Wiring Diagram, with DRL for Mercury Sable GS 1994 List of elements for Headlamps Wiring Diagram, with DRL for Mercury Sable GS 1994: 35 (center of left front fender apron) g104 (front of left front fender apron) g100 (top front of right front fender apron) g101 Acc Battery power Brake fluid level sw (on brake fluid reservoir) Brake ind (inst clstr) Daytime running lamps (drl) module (lower left front of engine compt) Drl disable Fuse 15a Fuse 20a Head Hi-beam indicator Hot at all times Hot in run or start I/p fuse panel Ignition input Ignition switch Indicator control Instrument cluster Left headlight Lo beam input Lock Main light switch Multi- function switch Off Park Park switch switch (on top of park brake support) Pass Pulsed voltage Right headlight Run Start Headlamps Wiring Diagram, without DRL for Mercury Sable GS 1994 List of elements for Headlamps Wiring Diagram, without DRL for Mercury Sable GS 1994: 19 Fuse 20a Fuse panel G100 (front of left front fender apron) G101 (top front of right front fender apron) G104 (center of left front fender apron) Head Hi-beam indicator Hot at all times I/p Instrument cluster Left headlight Main light switch Multi- function switch Off Park Pass Right headlight Headlamps/Fog Lamps Wiring Diagram, with DRL for Mercury Sable GS 1994 List of elements for Headlamps/Fog Lamps Wiring Diagram, with DRL for Mercury Sable GS 1994: 54 (behind left side of inst panel, taped to main harness, near fuse panel) (front of left front fender apron) 15a 87a Acc Battery power Brake fluid level sw (on brake fluid reservoir) Brake ind (inst clstr) Daytime running lamps (drl) module (lower left front of engine compt) Drl disable Engine compt fuse block Fog lamp in-line fuse Fog light switch Fuse 15a Fuse 20a Fuse panel 40a G100 G101 (top front of right front fender apron) G104 (center of left front fender apron) Head Hi-beam indicator Hot at all times Hot in run or start Ignition input Ignition switch Indicator control Inst panel dimming rheostat Inst panel fuse block Inst panel fuse panel Instrument cluster Lamps out warning module Left fog light Left headlight Lo beam input Lock Main light switch Multi- function switch Not used Off On indica- tor Park Park switch switch (on top of park brake support) Pass Pulsed voltage Resistance wire (.o74 +/- .001 ohms) Right fog light Right headlight Run Start Switch illumination W/ lamp out warning W/o lamp out warning Headlamps/Fog Lamps Wiring Diagram, without DRL for Mercury Sable GS 1994 List of elements for Headlamps/Fog Lamps Wiring Diagram, without DRL for Mercury Sable GS 1994: 39 (behind left side of inst panel, taped to main harness, near fuse panel) (front of left front fender apron) 15a 87a Daytime running lamps (drl) jumper (lower left front of engine compt) Engine compt fuse block Fog lamp in-line fuse Fog lamp relay (behind lower center of inst panel, on left inst panel vertical brace) Fog light switch Fuse 20a Fuse panel 40a G100 G101 (top front of right front fender apron) G104 (center of left front fender apron) Head Hi-beam indicator Hot at all times I/p fuse panel Inst panel dimming rheostat Inst panel fuse block Instrument cluster Lamp out warning module Left fog light Left headlight Main light switch Multi- function switch Not used Off On indica- tor Park Pass Resistance wire (.o74 +/- .001 ohms) Right fog light Right headlight Switch illumination W/ lamp out warning W/o lamp out warning
HORN Horn Wiring Diagram for Mercury Sable GS 1994 List of elements for Horn Wiring Diagram for Mercury Sable GS 1994: 19 (left front fender apron) g104 3.0l sho 3.2l sho Anti-theft system C.b. 12 20a Clockspring assembly Cruise control system Except sho High pitch horn (front left of engine compt) Horn Horn relay (below center of i/p on left vertical brace) Hot at all times I/p fuse block Low pitch horn (front left of engine compt) Powertrain control module (top right side of safety wall) Speed control servo assembly (left side of engine compt) Switches
INSTRUMENT CLUSTER
3.0L 3.0L, Analog Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994 List of elements for 3.0L, Analog Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994: 98 (in top of fuel tank) (left front (master cyl reservoir) (rear of engine) (top left side of engine) A10 A11 A12 A13 A14 A15 A16 A17 A18 Acc Airbag diagnostic monitor (right side of i/p near top of cowl) Airbag ind Alternator Anti-lock brake ind Anti-lock system B10 B11 B12 B13 B14 Bk lt out Brake fluid level sw Brake ind Charge ind Check oil ind Coolant temp sender Data link connector (on pcm cover) Door ajar ind Door open in Door sill) Fasten belts ind Fluid level sw Fuel gauge Fuel pump/ fuel gauge sender Fuse #18 10a Fuse #8 15a G104 (center of left front fender apron) G108 (top left side of upper radiator support) G309 Gnd Ground Hazard lts Headlight on in Headlights Headlt out Hi beam ind Hot at all times Hot in start or run I/p dimming rheostat I/p fuse panel I/p fuse panel) I/p, right side of Ignition key warning (part of ignition sw) Ignition switch Ignition system Illumination lights (6) Indicator control Instrument cluster Key in ign sw in Left front door jamb switch Left side of Left turn ind Light out ind Light out warning module (behind lower Lock Low fuel ind Low washer Low washer fluid ind Malfunction ind Module Nca Off Oil press ind Oil press sw Powertrain control module (top right side of safety wall) Red/pnk Right turn ind Rr pk lt out Run Seat belt buckle switch in Seat belt ind output Seat belt switch (drivers' seat belt buckle) Slosh module Start Start/run power Sto/mil Tachometer Tan/red Tan/red 17 Temp gauge Turn/stop/ Warning chime module (behind lower center of i/p) Wiper ctrl 3.0L, Analog Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994 List of elements for 3.0L, Analog Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994: 39 (below left side of (center of left frt fender apron) Acc All other models All police & base models All times Base models Daytime running lamps (drl) module (lower left front of engine compartment) Daytime running lamps jumper (lower left front of engine compartment) Except police & G104 G404 (left rear corner of cargo area) Gnd Head Hot at I/p on parking brake) Ignition switch Left front door latch switch Left rear door latch switch Liftgate latch switch (part of latch assy) Light sw Lock Low oil level relay (on left i/p vertical brace) Low oil level switch (lower center rear of engine) Main Off Park Park brake Park brake switch (below left side of i/p on parking brake) Remote keyless entry module (sedan)(behind rear seat under left side package tray) (wagon)(in rear of left quarter panel behind wheel well) Right front door latch switch Right rear door latch switch Run Start Switch W/ autolamps W/ drl W/o autolamps W/o drl 3.0L, Electronic Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994 List of elements for 3.0L, Electronic Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994: 85 (3.0l ffv only) 1994 vftc c Acc Air bag ind Anti-lock brake ind Battery Battery power Brake fluid level sw (in master cylinder reservoir) Brake input Brakelt out C255 C256 Charge ind Charging system Check oil Common ground Coolant temp Coolant temp sender (top left side of engine) Cruise control amplifier Data input fuel flow Door ajar sw input Door latch sws Eatc module (in center of i/p) Electronic automatic temp ctrl module (center of i/p) English/metric English/metric output Fuel level Fuel pump/ fuel gauge sender 10 ohms empty 170 ohms full (in top of tank) Fuse #16 5a Fuse #18 10a Fuse #5 15a G104 (center of left front fender apron) Gnd Headlight out warning Headlt out Hi-beam ind Hot at all times Hot in run Hot in run or start Hot in start or run I/p dimming rheostat I/p fuse panel Ignition sw Ignition system Illum Illum ground Illum positive Input signal Instrument cluster Lamp out warning module (right side of i/p fuse panel) Left turn signal Lock Low fluid warning Low oil level sw (lower center of engine Main light sw Malfunction ind Off Ohms Oil pres sw (rear of engine) Oil pressure Positive data Power board ground Prndl illum Rear lt out warning Red Right turn signal Run Seat belt ind input Signal ground Speed input Start Switch module (on right side of instrument cluster) Tach input Taillt out Tan/red Tone output Turn/stop/ hazard lts Vehicle speed sensor (on trans- axle) Vss input W/ eatc W/o eatc 3.0L, Electronic Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994 List of elements for 3.0L, Electronic Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994: 59 (lower left front of engine compt) (right rear of engine compt, on pcm cover) 3.0l ffv only Abs data link connector (right rear of engine compt) Airbag diagnostic monitor (behind right side of i/p near top of cowl panel) All engines Anti-lock brake control module (on right front fender apron) Anti-lock brake diode (right rear of engine compt, taped to harness) Anti-lock brakes Data(+) Data(-) Dlc Door open in Drl jumper Drl module Fuse #6 15a Fuse #8 15a G309 (left front door sill) Ground Head Headlights (hi-beams) Hot at all times Hot in accy or run I/p fuse panel Ignition key warning sw (part of ignition sw) Ind ctrl Key-in-ign sw in Lamps on in Left front door jamb sw Low washer fluid level sw (in washer fluid reservoir) Main light sw Nca Off Park Park brake sw (part of park brake assembly) Powertrain control module (top right side of safety wall) Red/pnk Run/accy power Seat belt buckled in Seat belt ind out Seat belt sw (in left front seat belt buckle) Solid state St0/mil Start/run power Tan/red Tone generator Vip data link connector Vip data link connector (right rear of engine compt, on pcm cover) W/ autolamps W/ daytime running lamps W/o autolamps W/o daytime running lamps Warning chime module (behind lower center of i/p) Windshield washer motor (in windshield washer fluid reservoir) Wiper control module (pin #4) 3.0L, Lamp Monitor Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.0L, Lamp Monitor Wiring Diagram for Mercury Sable GS 1994: 43 Acc Analog cluster Brake lamp out output Bulb proveout input C251 C255 C256 Digital cluster Exterior lights Fuse 18 10a Fuse 6 15a G104 (center of left front fender apron) Ground Headlamp out output Headlamp out warning Headlamp reference Headlamp sense Headlights Hot at all times Hot in run or acc Hot in run or start I/p fuse panel Ignition Ignition switch Instru- ment cluster Lamp out indicator Lamp out warning module sho-(behind top right side of i/p, above glove box) except sho-(behind lower left side of i/p, right of i/p fuse panel) Left brake lamp sense Left stop/ turn lamp reference Lock Off Park lamp reference Park lamp sense Power Rear lamp out warning Rear park lamp out output Red Right brake lamp sense Right stop/ turn lamp reference Run Sedan only Sta Start
3.8L 3.8L, Analog Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994 List of elements for 3.8L, Analog Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994: 98 (in top of fuel tank) (left front (master cyl reservoir) (rear of engine) (top left side of engine) A10 A11 A12 A13 A14 A15 A16 A17 A18 Acc Airbag diagnostic monitor (right side of i/p near top of cowl) Airbag ind Alternator Anti-lock brake ind Anti-lock system B10 B11 B12 B13 B14 Bk lt out Brake fluid level sw Brake ind Charge ind Check oil ind Coolant temp sender Data link connector (on pcm cover) Door ajar ind Door open in Door sill) Fasten belts ind Fluid level sw Fuel gauge Fuel pump/ fuel gauge sender Fuse #18 10a Fuse #8 15a G104 (center of left front fender apron) G108 (top left side of upper radiator support) G309 Gnd Ground Hazard lts Headlight on in Headlights Headlt out Hi beam ind Hot at all times Hot in start or run I/p dimming rheostat I/p fuse panel I/p fuse panel) I/p, right side of Ignition key warning (part of ignition sw) Ignition switch Ignition system Illumination lights (6) Indicator control Instrument cluster Key in ign sw in Left front door jamb switch Left side of Left turn ind Light out ind Light out warning module (behind lower Lock Low fuel ind Low washer Low washer fluid ind Malfunction ind Module Nca Off Oil press ind Oil press sw Powertrain control module (top right side of safety wall) Red/pnk Right turn ind Rr pk lt out Run Seat belt buckle switch in Seat belt ind output Seat belt switch (drivers' seat belt buckle) Slosh module Start Start/run power Sto/mil Tachometer Tan/red Tan/red 17 Temp gauge Turn/stop/ Warning chime module (behind lower center of i/p) Wiper ctrl 3.8L, Analog Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994 List of elements for 3.8L, Analog Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994: 39 (below left side of (center of left frt fender apron) Acc All other models All police & base models All times Base models Daytime running lamps (drl) module (lower left front of engine compartment) Daytime running lamps jumper (lower left front of engine compartment) Except police & G104 G404 (left rear corner of cargo area) Gnd Head Hot at I/p on parking brake) Ignition switch Left front door latch switch Left rear door latch switch Liftgate latch switch (part of latch assy) Light sw Lock Low oil level relay (on left i/p vertical brace) Low oil level switch (lower center rear of engine) Main Off Park Park brake Park brake switch (below left side of i/p on parking brake) Remote keyless entry module (sedan)(behind rear seat under left side package tray) (wagon)(in rear of left quarter panel behind wheel well) Right front door latch switch Right rear door latch switch Run Start Switch W/ autolamps W/ drl W/o autolamps W/o drl 3.8L, Electronic Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994 List of elements for 3.8L, Electronic Cluster Wiring Diagram (1 of 2) for Mercury Sable GS 1994: 85 (3.0l ffv only) 1994 vftc c Acc Air bag ind Anti-lock brake ind Battery Battery power Brake fluid level sw (in master cylinder reservoir) Brake input Brakelt out C255 C256 Charge ind Charging system Check oil Common ground Coolant temp Coolant temp sender (top left side of engine) Cruise control amplifier Data input fuel flow Door ajar sw input Door latch sws Eatc module (in center of i/p) Electronic automatic temp ctrl module (center of i/p) English/metric English/metric output Fuel level Fuel pump/ fuel gauge sender 10 ohms empty 170 ohms full (in top of tank) Fuse #16 5a Fuse #18 10a Fuse #5 15a G104 (center of left front fender apron) Gnd Headlight out warning Headlt out Hi-beam ind Hot at all times Hot in run Hot in run or start Hot in start or run I/p dimming rheostat I/p fuse panel Ignition sw Ignition system Illum Illum ground Illum positive Input signal Instrument cluster Lamp out warning module (right side of i/p fuse panel) Left turn signal Lock Low fluid warning Low oil level sw (lower center of engine Main light sw Malfunction ind Off Ohms Oil pres sw (rear of engine) Oil pressure Positive data Power board ground Prndl illum Rear lt out warning Red Right turn signal Run Seat belt ind input Signal ground Speed input Start Switch module (on right side of instrument cluster) Tach input Taillt out Tan/red Tone output Turn/stop/ hazard lts Vehicle speed sensor (on trans- axle) Vss input W/ eatc W/o eatc 3.8L, Electronic Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994 List of elements for 3.8L, Electronic Cluster Wiring Diagram (2 of 2) for Mercury Sable GS 1994: 59 (lower left front of engine compt) (right rear of engine compt, on pcm cover) 3.0l ffv only Abs data link connector (right rear of engine compt) Airbag diagnostic monitor (behind right side of i/p near top of cowl panel) All engines Anti-lock brake control module (on right front fender apron) Anti-lock brake diode (right rear of engine compt, taped to harness) Anti-lock brakes Data(+) Data(-) Dlc Door open in Drl jumper Drl module Fuse #6 15a Fuse #8 15a G309 (left front door sill) Ground Head Headlights (hi-beams) Hot at all times Hot in accy or run I/p fuse panel Ignition key warning sw (part of ignition sw) Ind ctrl Key-in-ign sw in Lamps on in Left front door jamb sw Low washer fluid level sw (in washer fluid reservoir) Main light sw Nca Off Park Park brake sw (part of park brake assembly) Powertrain control module (top right side of safety wall) Red/pnk Run/accy power Seat belt buckled in Seat belt ind out Seat belt sw (in left front seat belt buckle) Solid state St0/mil Start/run power Tan/red Tone generator Vip data link connector Vip data link connector (right rear of engine compt, on pcm cover) W/ autolamps W/ daytime running lamps W/o autolamps W/o daytime running lamps Warning chime module (behind lower center of i/p) Windshield washer motor (in windshield washer fluid reservoir) Wiper control module (pin #4) 3.8L, Lamp Monitor Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.8L, Lamp Monitor Wiring Diagram for Mercury Sable GS 1994: 43 Acc Analog cluster Brake lamp out output Bulb proveout input C251 C255 C256 Digital cluster Exterior lights Fuse 18 10a Fuse 6 15a G104 (center of left front fender apron) Ground Headlamp out output Headlamp out warning Headlamp reference Headlamp sense Headlights Hot at all times Hot in run or acc Hot in run or start I/p fuse panel Ignition Ignition switch Instru- ment cluster Lamp out indicator Lamp out warning module sho-(behind top right side of i/p, above glove box) except sho-(behind lower left side of i/p, right of i/p fuse panel) Left brake lamp sense Left stop/ turn lamp reference Lock Off Park lamp reference Park lamp sense Power Rear lamp out warning Rear park lamp out output Red Right brake lamp sense Right stop/ turn lamp reference Run Sedan only Sta Start
INTERIOR LIGHTS Courtesy Lamps Wiring Diagram, Sedan with Remote/Keyless Entry for Mercury Sable GS 1994 List of elements for Courtesy Lamps Wiring Diagram, Sedan with Remote/Keyless Entry for Mercury Sable GS 1994: 57 (center rear of trunk) (left front (left rear corner of cargo area) (not used) 15a All others Battery power Battery saver in Battery saver out C455 C456 C467 Dome Dome lt Door jamb sw in Door sw in Engine compt lt Fender apron) Flex fuel vehicles Fuse 5 Fuse 8 G104 G104 (center of left front fender apron) G309 (left front door sill) G404 G407 Glove box lt Hot at all times Hot in run I/p dimming rheostat I/p fuse panel Illum entry out Illuminated entry module (in rear of qtr panel) Left b-pillar lt Left door handle switch Left front ctsy lt Left front door jamb switch Left i/p ctsy lt Left lock cylinder lt Left rear door jamb switch Left vanity lamp Luggage compt lt Luggage compt mercury sw (center front of trunk lid) Map/ dome lt Nca Remote keyless entry module (left rear quarater panel) Right b-pillar lt Right door handle switch Right front ctsy lt Right front door jamb switch Right i/p ctsy lt Right lock cylinder lt Right rear door jamb switch Right vanity lamp Trunk lt sw W/ moonroof W/o moonroof Courtesy Lamps Wiring Diagram, Sedan without Remote/Keyless Entry for Mercury Sable GS 1994 List of elements for Courtesy Lamps Wiring Diagram, Sedan without Remote/Keyless Entry for Mercury Sable GS 1994: 49 (center rear of trunk) (left front (not used) 15a All others Base Base only Base vehicle only Dome Dome lt Engine compt lt Flex fuel vehicles Fuse 5 Fuse 8 G104 G104 (center of left front fender apron) G309 (left front door sill) G404 (left rear corner of cargo area) G407 Glove box lt Hot at all times Hot in run I/p dimming rheostat I/p fuse panel Illuminated entry module (in rear of qtr panel) Left b-pillar lt Left door handle switch Left front ctsy lt Left front door jamb sw Left i/p ctsy lt Left lock cylinder lt Left rear door jamb switch Left vanity lamp Luggage compt lt Luggage compt mercury sw (center front of trunk lid) Map/ dome lt Nca Right b-pillar lt Right door handle switch Right front ctsy lt Right front door jamb switch Right i/p ctsy lt Right lock cylinder lt Right rear door jamb switch Right vanity lamp Sedan Sedan only W/ moonroof W/o moonroof Courtesy Lamps Wiring Diagram, Wagon for Mercury Sable GS 1994 List of elements for Courtesy Lamps Wiring Diagram, Wagon for Mercury Sable GS 1994: 63 (left front (left rear corner of cargo area) (left rear of cargo area) (near left rear speaker, in rear lamp harness) (not used) 15a All others Battery power Battery saver in Battery saver out C455 C456 C467 Cargo shell switch/ lt Dome Dome lt Door jamb sw in Door sw in Engine compt lt Fender apron) Flex fuel vehicles Fuse 5 Fuse 6 Fuse 8 G104 G104 (center of left front fender apron) G309 (left front door sill) G404 Glove box lt Hot at all times Hot in accy or run Hot in run I/p dimming rheostat I/p fuse panel Illum entry out Illuminated entry module w/o rke (in rear of qtr panel) Left b-pillar lt Left cargo lt assy Left door handle switch Left front ctsy lt Left front door jamb switch Left i/p ctsy lt Left lock cylinder lt Left rear door jamb switch Left vanity lamp Liftgate mercury switch Map/ dome lt Nca Rear cargo lt diode Remote keyless entry module (left rear quarater panel) Right b-pillar lt Right cargo lt assy Right door handle switch Right front ctsy lt Right front door jamb switch Right i/p ctsy lt Right lock cylinder lt Right rear door jamb switch Right vanity lamp W/ moonroof W/ rear defrost W/o moonroof W/o rear defrost Instrument Illumination Wiring Diagram for Mercury Sable GS 1994 List of elements for Instrument Illumination Wiring Diagram for Mercury Sable GS 1994: 58 (behind lower center of i/p) (center of left front fender apron) (left front door sill) 15a 87a Analog cluster only Ashtray illum C274 C275 Cd player Cigar lighter illum Console ashtray assembly Ctrl illum Digital clock Digital cluster only Electronic automatic temperature ctrl mdl Fog lt sw Fuse 13 Fuse 6 G104 G104 (center of left front fender apron) G206 G206 (behind lower center of i/p) G309 G309 (left front door sill) Head Hot at all times Hot in accy or run Hot with main lt sw in park or head I/p dimming rheostat illumination I/p ashtray assembly I/p dimming rheostat I/p fuse panel Ign Instrument cluster Lcd dimming relay (behind center of i/p) Liftgate defrost/ wiper/ washer control Liftgate wiper/ washer control Main light switch Main lt sw illum Nca Off Park Prndl illum Radio Rear window defrost control Red Redundant radio control Sable wagon Sedan only Taurus wagon W/ autolamps W/ cd player W/ eatc W/o autolamps W/o cd player W/o eatc With console
POWER ANTENNA Power Antenna Wiring Diagram for Mercury Sable GS 1994 List of elements for Power Antenna Wiring Diagram for Mercury Sable GS 1994: 20 Bat C257 Down Fuse 15a Fuse 20a G104 (left front fender apron) Ground Hot at all times Hot in accy or run I/p fuse block Ign Nca Power antenna module (behind right side of i/p, near top of cowl panel) Power antenna motor (in rear of right front fender) Radio Radio on input Radio on output Red/pnk Start input Starting/ charging system
POWER DISTRIBUTION Power Distribution Wiring Diagram (1 of 6) for Mercury Sable GS 1994 List of elements for Power Distribution Wiring Diagram (1 of 6) for Mercury Sable GS 1994: 83 #16 (ex sho) (wagon only) 20a 30a 40a 60a Accessory Analog cluster Anti/lk Anti/lock Ashtray Assembly Battery Block Cb #12 Cluster Compartment Compt Conn Console ashtray Control Control sw Defr Defrost Digital Digital cluster Eatc control Engine Entry Fus Fuse Head Horn relay I/p Instrument Integral alternator/ Keyless Lamps Left door Left power Left seat Liftgate Light sw Link g Link t Lk/seat Lock sw Lumbar seat Mod Module Motor relay Mtr Not used Police Power relay Pwr Rear Rear window Red Regulator Relay Release Remote keyless entry module Right door Right power Right seat Sable Sedan Sho Solenoid Starter motor/ Tan/red Taurus Timer To main W/ eatc W/ power W/o W/o eatc W/o power Wagon Windows Power Distribution Wiring Diagram (2 of 6) for Mercury Sable GS 1994 List of elements for Power Distribution Wiring Diagram (2 of 6) for Mercury Sable GS 1994: 80 #10 (not used) 10a 15a 20a 3.2l 30a 40a 60a Acc Accy All Amplifier Anti/lock Anti/lock brake Block Blw mtr Brake sw Cluster Coil Compartment Constant Control Control module Control relay Controls Cooling Daytime Deactivator Electronic Engine Ex sho Except Fan 50a Fan dropping Feed Fog Fog lamp Fuel pump Function Fuse Fuse 10a Fuse 15a Fuse block I/p Ign Ign sw Ignition In/line Instrument Interrupt Lamp Lock Low fuel Mobile Module Multi/ Not Off Others Panel Pcm relay/ Power relay Powertrain Pump relay Relay Resistor Run Running lts Sho Speaker Sta Start Starting System Telephone To i/p Transceiver Used Wagon Power Distribution Wiring Diagram (3 of 6) for Mercury Sable GS 1994 List of elements for Power Distribution Wiring Diagram (3 of 6) for Mercury Sable GS 1994: 64 (ex police or base (w/ moonroof) (w/o moonroof) 15a Airbag Antenna Base Base or w/ Block Cargo Cargo shell Cd player Clock Compartment lt Defroster Diagnostic Digital Dome Door jamb Door jamb sw Engine Entry Entry module Fuse Glove box Glove box lt I/p I/p dimming Illuminated Left front Left rear Left vanity Liftgate Luggage Map/dome Mercury sw Mirror lt Mirror sw Module Monitor Not used Player Power Radio Remote keyless Remote keyless entry Rheostat Right front Right rear Right vanity Sedan Shell sw/lt Sw & lt Taurus or sable) Vehicle W/ cd W/ keyless W/ moonroof W/ rear W/o cd W/o keyless W/o moonroof W/o rear Wagon Power Distribution Wiring Diagram (4 of 6) for Mercury Sable GS 1994 List of elements for Power Distribution Wiring Diagram (4 of 6) for Mercury Sable GS 1994: 79 #17 #18 (3.0l sho (ex base taurus) (sable only) (w/ keyless 10a 15a 30a A/c/heater Actuator Airbag Amplifier Analog clstr Analog instrument Assist power Blend door Block Blower Blower motor Cluster Control Control sw Controller Daytime running Defrost control Defrost timer Diagnostic Digital Digital clstr Digital instrument Eatc control Entry module Entry) Ex sho Ex w/ From From i/p Function Fuse Fuse block Heated oxygen Heater Heater function I/p Ignition sw Illuminated Instrument Keyless entry Level relay Liftgate defrost/ Light/sensor Low oil Lts module Manual lever Module Monitor Motor Multi/function sw Only) Park/neutral Position sensor Position sw Rear window Selector sw Sensor #1 Sensor #2 Shift lock Sho Speed Steering module Taurus Transmission Variable W/ a/c W/ eatc W/ heater Warning chime Wiper/washer Power Distribution Wiring Diagram (5 of 6) for Mercury Sable GS 1994 List of elements for Power Distribution Wiring Diagram (5 of 6) for Mercury Sable GS 1994: 79 #11 (ex police, base (wagons only) 15a 20a 3.0l/ 3.2l 3.8l 8.25a Accessory All Amplifier And sable Assembly Autolps Base Base taurus Block Cb #14 Cb #2 Chime Clock Control Control sw Defrost/ Digital Door lock control Door lock control sw Ex police, From Fuse Glass I/p Ignition sw Interval Lamp out Lcd dimming Left cargo Left rear Liftgate Liftgate wiper Light sw Lt assembly Master window Master window/ Mobile Module Moonroof Motor One touch Others Police Police, Power antenna Radio Radio control Red Redundant Relay Right cargo Right front window Right rear Sable Servo/amplifier Sho Speed Speed control Taurus Taurus and sable) Telephone To fuse #17 To main Transciever W/o Wagon Warning Window control sw Window down Wiper/washer Power Distribution Wiring Diagram (6 of 6) for Mercury Sable GS 1994 List of elements for Power Distribution Wiring Diagram (6 of 6) for Mercury Sable GS 1994: 58 #13 #15 (3.2l sho only) (engine (ex w/ autolamps) 10a Auto Auto headlamps Auto headlamps/ Base taurus and Base taurus and sable Block Block) Clock Compartment Delayed exit Digital Ex police, Ex police, base Exterior Exterior lts From From head From head lamps Fuse Fuse #4 Fuse #6 Fuse (engine Fuse block) Head Headlamps/ Headlts I/p I/p dimming Ign Illumination Instrument Instrument cluster Lamps fuse Light Lts Main Module Not Off Park Police, base Police, base taurus and sable Rheostat Sable Taurus and Taurus and sable Used W/ autolamps W/o autolamps W/o autolamps, W/o autolamps, ex police, Warning chime
POWER DOOR LOCKS Door Lock Wiring Diagram, with Power Windows for Mercury Sable GS 1994 List of elements for Door Lock Wiring Diagram, with Power Windows for Mercury Sable GS 1994: 15 Engine compartment fuse block Fuse 15a G309 (left front door sill) Hot at all times Hot in accy or run I/p fuse block Left front door lock motor Left rear door lock motor Lock Master window/ door lock control switch Pwr lk/seat fuse 40a Right front door lock motor Right front window/door lock control switch Right rear door lock motor Unlock Door Lock Wiring Diagram, without Power Windows for Mercury Sable GS 1994 List of elements for Door Lock Wiring Diagram, without Power Windows for Mercury Sable GS 1994: 11 Engine compartment fuse block G309 (at left front door sill) Hot at all times Left front door lock motor Left front door lock switch Left rear door lock motor Lock Pwr lk/seat fuse 40a Right front door lock motor Right rear door lock motor Unlock Keyless Entry Wiring Diagram for Mercury Sable GS 1994 List of elements for Keyless Entry Wiring Diagram for Mercury Sable GS 1994: 91 (at left front door sill) (behind left rear seat - sedan) (behind left rear wheelwell - wagon) remote keyless entry module (ffv) (except ffv) (not used) 1/2 1/2 in 15a 3/4 3/4 in 5/6 5/6 in 7/8 7/8 in 9/0 9/0 in A/t Antenna Backup lamp switch (top left side of transaxle) Batt+ Batt+ save Batt+ save in Com Ctsy lps out Ctsy/dr sw in Dr ajar in Dr handle in Drvr st sw in Engine compt fuse box Exterior lamps Fuse 5 Fuse 6 Fuse 8 G309 G309 (at left front door sill) G404 (left corner of cargo area) G407 (on trunk lid latch) Gnd Horn output Horns Hot at all times Hot in accy or run Hot in run I/p dim rheo- stat I/p fuse panel Ign Instrument cluster (door ajar switches) Interior lamps Keyless entry keypad switch assembly Keypad common Keypad lp Lamp Left front door handle switch (top rear of left door) Left front door lock motor Left front seat switch Left rear door lock motor Liftgate release relay Liftgate solenoid Lk drs out Lk in Lock Lt frt dr jamb sw Lt rr dr jamb sw M/t Manual lever position sensor (top left side of transaxle) Master window/door lock control switch Nca Park lps out Program a Program b Pwr lk/seat fuse 40a Red Reverse in Right front door handle switch (top rear of right door) Right front door lock motor Right front window/door lock control switch Right rear door lock motor Rke program connector (left side of trunk, above wheelwell) Rt frt dr jamb sw Rt rr dr jamb sw Sedan Sig batt+ Sig gnd Transmitter in Trnk lid out Trnk lmp out Trunk lid solenoid Unlk all out Unlk in Unlk l dr out Unlock Wagon Power Door Lock Wiring Diagram, with Power Windows for Mercury Sable GS 1994 List of elements for Power Door Lock Wiring Diagram, with Power Windows for Mercury Sable GS 1994: 15 Engine compartment fuse block Fuse 15a G309 (left front door sill) Hot at all times Hot in accy or run I/p fuse block Left front door lock motor Left rear door lock motor Lock Master window/ door lock control switch Pwr lk/seat fuse 40a Right front door lock motor Right front window/door lock control switch Right rear door lock motor Unlock Power Door Lock Wiring Diagram, without Power Windows for Mercury Sable GS 1994 List of elements for Power Door Lock Wiring Diagram, without Power Windows for Mercury Sable GS 1994: 11 Engine compartment fuse block G309 (at left front door sill) Hot at all times Left front door lock motor Left front door lock switch Left rear door lock motor Lock Pwr lk/seat fuse 40a Right front door lock motor Right rear door lock motor Unlock
POWER MIRRORS Power Mirror Wiring Diagram for Mercury Sable GS 1994 List of elements for Power Mirror Wiring Diagram for Mercury Sable GS 1994: 13 Direct- tional switch Fuse 15a G309 (left front door sill) Hot at all times I/p fuse panel L/r motor Left power mirror nca Left/ right switch Nca Power mirror switch Red Right power mirror nca Up/dn motor
POWER SEATS Lumbar Wiring Diagram for Mercury Sable GS 1994 List of elements for Lumbar Wiring Diagram for Mercury Sable GS 1994: 15 (at left front door sill) 40a Engine compartment fuse box G309 Hot at all times Inflate vent Left lumbar air bladder Left power lumbar compressor Left power seat switch bladder Nca Pwr lk/seat fuse (1993-94) pwr lk/wdo fuse (1992) Red Right lumbar air bladder Right power lumbar compressor Right power seat switch bladder Power Lumbar Seat Wiring Diagram for Mercury Sable GS 1994 List of elements for Power Lumbar Seat Wiring Diagram for Mercury Sable GS 1994: 15 (at left front door sill) 40a Engine compartment fuse box G309 Hot at all times Inflate vent Left lumbar air bladder Left power lumbar compressor Left power seat switch bladder Nca Pwr lk/seat fuse (1993-94) pwr lk/wdo fuse (1992) Red Right lumbar air bladder Right power lumbar compressor Right power seat switch bladder Power Seat Wiring Diagram for Mercury Sable GS 1994 List of elements for Power Seat Wiring Diagram for Mercury Sable GS 1994: 18 (at left front door sill) (at left front door sill) g309 Engine compartment fuse box Entire seat Front height motor Front of seat Fwd Fwd/rwd motor G309 Hot at all times Left seat control switch Left seat motor assembly Pwr lk/seat fuse (1993-94) pwr lk/wdo fuse (1992) 40a Rear height motor Rear of seat Right seat control switch Right seat motor assembly Rwd
POWER TOP/SUNROOF Moonroof Wiring Diagram for Mercury Sable GS 1994 List of elements for Moonroof Wiring Diagram for Mercury Sable GS 1994: 18 red (at left front door sill) C 1994 vftc C219 Circuit breaker 20a Close/tilt up G309 Hot in accy or run I/p fuse block Limit switch Moon- roof relay (behind top right side of i/p) Moonroof drive assembly (center of windshield header) Moonroof motor Moonroof switch assembly (center of windshield header) Open/tiltdown Red
POWER WINDOWS Power Window Wiring Diagram for Mercury Sable GS 1994 List of elements for Power Window Wiring Diagram for Mercury Sable GS 1994: 21 (8) leds (2 in each rocker switch) 1994 vftc c Circuit breaker 20a Fuse 15a G309 (left front door sill) Hot in accy or run I/p fuse panel Left front window motor Left rear window motor Left rear window switch Lock-out Master window/ door lock control switch Nca One touch window down module (left front door) Red Right front window motor Right rear window motor Right front window/ door lock control switch Right rear window switch Solid state Up down
RADIO Base Radio for Mercury Sable GS 1994 List of elements for Base Radio for Mercury Sable GS 1994: 36 (left front fender apron) g100 (not used) Batt (b+) C257 C258 C262 Ctrl signal Fuse 11 Fuse 8 15a G206 (lower center of dash) Ground Hot at all times Hot in accy or run I/p fuse panel (behind left side of dash) Ignition Illum Interior lights system Left front door speaker Left rear speaker Lft frt (+) Lft frt (-) Lft rr (+) Lft rr (-) Logic mute Not used Power antenna system Radio Radio "on" Redundant radio control Remote ctrl Right front door speaker Right rear speaker Rt frt (+) Rt frt (-) Rt rr (+) Rt rr (-) JBL with CD Player for Mercury Sable GS 1994 List of elements for JBL with CD Player for Mercury Sable GS 1994: 76 (jbl only) (lft rr (+) (not used) Battery (b+) Body ground C257 or c280 C259 C262 C265 C281 C287 C453 C454 C462 C463 C464 Cd logic Cd player (optional) Ctrl signal Dimming Engine compartment fuse box (left rear of engine compt) Fuse 11 20a Fuse 8 15a Fuse panel 40a G102 (center of left fender apron) G206 (center of dash) G311 (sedan) (center of rear package shelf) G414 (wagon) (left quarter panel) Ground High level or jbl amplifier (sedan: below center of rear package shelf wagon: left rear quarter panel) Hot at all times Hot in acc or run I/p fuse panel (behind left side of dash) Ignition Illum Interior lights system Left front (+) Left front (-) Left front door speaker Left rear (+) Left rear (-) Left rear speaker Lft chnl in Lft chnl out Lft frt (+) Lft frt (-) Lft rr (+) Lft rr (-) Logic mute Loop retrn Loop return Lt frt (+) Mute Mute ctrl Nca Power antenna system Radio Radio "on" Radio choke (w/ jbl only) (under center of rear shelf) Redundant radio control Right front (+) Right front (-) Right front door speaker Right rear (+) Right rear (-) Right rear speaker Rt chnl in Rt chnl out Rt frt (+) Rt frt (-) Rt rr (+) Rt rr (-) Signal (+) Signal (-) Subwoofer amplifier (w/ optional jbl sound system only) (center of rear shelf) Subwoofer assembly Premium Sound Radio Wiring Diagram for Mercury Sable GS 1994 List of elements for Premium Sound Radio Wiring Diagram for Mercury Sable GS 1994: 45 (left front fender) g102 (not used) Amplifier (sedan: below center of rear package shelf wagon: left rear quarter panel) Battery (b+) C257 C262 C281 C451 C452 Ctrl signal Electronic radio Engine compartment fuse box (left rear of engine compt) Fuse 11 20a Fuse 8 15a Fuse panel 40a G206 (center of dash) G311 (sedan) (center or rear package shelf) G414 (wagon) (left quarter panel) Ground Hot at all times Hot in acc or run I/p fuse panel (behind left side of dash) Ignition Illum Interior lights system Left front door speaker Left rear speaker Lft frt (+) Lft frt (-) Lft rr (+) Lft rr (-) Logic mute Nca Power (b+) Power antenna system Radio "on" Radio mute Redundant radio control Right front door speaker Right rear speaker Rt frt (+) Rt frt (-) Rt rr (+) Rt rr (-) Spkr feed
SHIFT INTERLOCKS Shift Interlock Wiring Diagram for Mercury Sable GS 1994 List of elements for Shift Interlock Wiring Diagram for Mercury Sable GS 1994: 16 (3.2l sho only) (continental) (continental) (taurus/sable) (taurus/sable) (taurus/sable) (continental) (top front of left fender apron) (left front fender apron) Brake switch Fuse 15a Fuse panel G100 g104 Hot at all times Hot in run I/p fuse block Nca Shift lock actuator (bottom of steering column) Solid state
STARTING/CHARGING
3.0L 3.0L, Charging Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.0L, Charging Wiring Diagram for Mercury Sable GS 1994: 26 (ground to test) (left upper radiator support) (lower left front of engine) 3.0l sho Acc Alternator warning indicator Battery Engine compt fuse box Except 3.ol sho F screw Field G108 G110 Hot at all times Ignition switch Instrument cluster Integral alternator/ regulator Lock Off Ohms Red Regulator Run Start Starter motor/ solenoid Stator 3.0L, Starting Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.0L, Starting Wiring Diagram for Mercury Sable GS 1994: 21 (lower left front of engine) *except police, base taurus & base sable Acc Battery Engine compt fuse box G108 (top left side of upper radiator support) G110 Hold Ig sw blw mtr fuse 60a Ignition switch Lamp out warning module (above glove box) Lock Manual lever position sensor (top left side of transmission) Off Power antenna module (behind right side of i/p) Power distribution Pull-in Red Run Start Starter motor/ solenoid
3.8L 3.8L, Charging Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.8L, Charging Wiring Diagram for Mercury Sable GS 1994: 26 (ground to test) (left upper radiator support) (lower left front of engine) 3.0l sho Acc Alternator warning indicator Battery Engine compt fuse box Except 3.ol sho F screw Field G108 G110 Hot at all times Ignition switch Instrument cluster Integral alternator/ regulator Lock Off Ohms Red Regulator Run Start Starter motor/ solenoid Stator 3.8L, Starting Wiring Diagram for Mercury Sable GS 1994 List of elements for 3.8L, Starting Wiring Diagram for Mercury Sable GS 1994: 21 (lower left front of engine) *except police, base taurus & base sable Acc Battery Engine compt fuse box G108 (top left side of upper radiator support) G110 Hold Ig sw blw mtr fuse 60a Ignition switch Lamp out warning module (above glove box) Lock Manual lever position sensor (top left side of transmission) Off Power antenna module (behind right side of i/p) Power distribution Pull-in Red Run Start Starter motor/ solenoid
SUPPLEMENTAL RESTRAINTS Supplemental Restraint Wiring Diagram for Mercury Sable GS 1994 List of elements for Supplemental Restraint Wiring Diagram for Mercury Sable GS 1994: 29 Air bag diagnostic module (behind right side of i/p near top of cowl panel) Air bag indicator Battery C276 C277 Center cowl primary crash sensor (top center of safety wall) Center radiator primary crash sensor (top center of upper radiator support) Clock- spring assembly Cowl crash sens feed monitor Cowl crash sens ground monitor rad crash sens grd mon splice Driver's air bag Fuse 15a G104 center of left front fender panel) Ground Hot at all times Hot in run I/p fuse panel Ignition Indicator Instrument cluster Left kick panel safing sensor (behind left cowl panel) Nca Passenger airbag feed monitor passenger air bag return driver air bag return driver airbag feed monitor safing sensor output monitor Passenger's air bag Rad crash sens feed monitor Safing sens feed Safing sensor feed monitor Safing sensor ground monitor cowl crash sensor feed radiator crash sensor feed Shorting bar
TRANSMISSION
TRUNK, TAILGATE, FUEL DOOR Tailgate Release Wiring Diagram for Mercury Sable GS 1994 List of elements for Tailgate Release Wiring Diagram for Mercury Sable GS 1994: 16 (left rear corner of cargo area) (right rear corner of cargo area) C 1994 vftc Engine compartment fuse block Fuse 20a G404 G405 Hot at all times I/p fuse block Liftgate release output Liftgate release relay (right rear corner of cargo area) Liftgate release solenoid (lower right rear of liftgate) Liftgate release switch (left front door sill) Manual lever position sensor (top left side of transaxle) Pwr lk/seat fuse 40a Remote keyless entry module (left rear quarter panel)
WIPER/WASHER Interval Wiper/Washer Wiring Diagram for Mercury Sable GS 1994 List of elements for Interval Wiper/Washer Wiring Diagram for Mercury Sable GS 1994: 44 (left front fender apron) 100k ohms 36.27k 4.08k 7.25k 8.25a Analog cluster C250 C251 C255 C256 Digital cluster Exept sho Fuse 2 G101 (right front fender apron) G104 Gnd Hot in accy or run I/p fuse block Ignition Input Instrument cluster Int max Int min Interval wiper/ washer module (behind center of i/p on left verticle brace) Low washer fluid level indicator Low washer fluid switch Multi- function switch Nca Off Ohms Parked Parking Pump motor control Red Run Sho Washer switch Windshield washer pump motor Windshield wiper motor Wiper motor Wiper motor control Wiper motor position input Wiper/washer switch Rear Wiper/Washer Wiring Diagram for Mercury Sable GS 1994 List of elements for Rear Wiper/Washer Wiring Diagram for Mercury Sable GS 1994: 21 (left front fender apron) 15a Defoggers system (rear window defrost timer) Fuse 6 G104 G401 (sedan: right front of trunk near trunk lid hinge) g405 (wagon: right rear corner of cargo area) G407 (sedan: center rear of trunk on latch brace) g404 (wagon: left rear corner of cargo area) Hot in accy or run I/p fuse block Interior lights system (dimmer rheostat) Liftgate defrost/ wiper/ washer control Liftgate glass Liftgate washer pump motor (in right rear quarter panel) Liftgate wiper motor Momentary on/off switch Park Rear window defrost grid Run Solid state Washer switch Wiper switch
