TRANSMISSION – Ford Cab & Chassis F350 1997 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

5.8L

5.8L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford Cab & Chassis F350 1997

List of elements for 5.8L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford Cab & Chassis F350 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range sensor)
• (behind bottom of right kick panel) g203
• (engine control sensor harness, near breakout to brake warn resistor/diode assembly)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (engine control sensor harness, near breakout to powertrain control module (pcm))
• (fuel charge harness, near breakout to canister purge solenoid) (5.8l engine) (no location available) (7.5l engine)
• (fuel charge harness, near breakout to fuel injector 4) (5.8l engine) (no location available) (7.5l engine)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier)
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Cse gnd
• Data
• E40d transmission
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender pnl)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ign
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Malfunction indicator lamp (mil)
• Manifold absolute pressure (map) sensor (right side of firewall)
• Map
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S163
• S169
• S215
• S216
• S236
• S240 (main harness, near breakout to clutch pedal position switch or jumper)
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vip data link connector (left rear of engine compt, on bracket)
• Vip data link connector (partial) (left rear of engine compt, on bracket)
• Vref
• Vss gnd
• Vss input
• Vss output
• Warning chime module

5.8L, Transmission Wiring Diagram, California Except Super Duty for Ford Cab & Chassis F350 1997

List of elements for 5.8L, Transmission Wiring Diagram, California Except Super Duty for Ford Cab & Chassis F350 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range (tr) sensor)
• (behind bottom of right kick panel) g203
• (dash engine gauge feed harness, near breakout to throttle position sensor (tps))
• (dash engine harness, near breakout to egr control solenoid)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (left front of engine compartment, top of upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier) s246
• (right front of engine, compartment, on front of fender apron) g101
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of dash, before glove compt)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender panel)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, on front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow sensor (right front of engine compartment)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S169
• S215
• S216
• S236
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output
• Warning chime module

7.3L

7.3L DI Turbo Diesel, Transmission Wiring Diagram for Ford Cab & Chassis F350 1997

List of elements for 7.3L DI Turbo Diesel, Transmission Wiring Diagram for Ford Cab & Chassis F350 1997:

• (backup lamp switch to rear lamp feed harness, in break out to e40d transmission)
• (backup lamp switch to rear lamp feed harness, in breakout to tr sensor sensor)
• (engine control sensor harness, near breakout to powertrain control module (pcm)) s157
• (engine control sensor harness, near breakout to starter relay)
• (engine control sensor harness, near left headlamp)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, in breakout to throttle position sensor)
• (main harness, near breakout to speed ctrl amplifier)
• (main harness, near breakout to, harness in-line connector, behind lower center of dash)
• 49 states (or) super duty
• 4x4 ind
• Accelerator pedal sensor (ap) (under left side of dash)
• Acel pdl
• Amb
• Ap sens
• Aux data
• Auxiliary powertrain control (behind center of dash)
• Baro
• Barometric pressure (baro) sensor (at base of steering column)
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• California except super duty
• Chk eng
• Coast clutch solenoid
• Cpps
• Data link connector (behind lower right side of dash, below glove compartment)
• Diesel warning lamps display, warning chime module, fuel water switch,
• E40d transmission (below center of vehicle)
• Electronic pressure control solenoid
• Eng oil
• Engine compartment fuse box
• Engine compartment fuse box in engine compt, on left inner fender panel)
• Engine controls
• Engine oil temperature (eot) sensor (right side of engine)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front of engine compartment, on upper radiator support)
• G203 (behind bottom of right kick panel)
• Gen data
• Glow plug relay, fuel line heater
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Instrument cluster
• Intake air temperature (iat) sensor (top center of engine)
• Kapwr
• Low vacuum warning switch
• Malfunction indicator lamp (mil) "check engine light"
• Manifold absolute pressure sensor (top right side firewall)
• Map
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of firewall)
• Psom module
• Pwr in
• Rabs module, hazard flasher
• Red
• S101
• S106
• S114
• S126
• S129 (pia harness, in breakout to engine coolant temp sensor)
• S143
• S146
• S163
• S164
• S215
• S216
• S235
• S236
• S240 (main harness, near breakout to clutch pedal position switch or jumper)
• S241
• S243
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tft
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output

7.5L

7.5L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford Cab & Chassis F350 1997

List of elements for 7.5L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford Cab & Chassis F350 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range sensor)
• (behind bottom of right kick panel) g203
• (engine control sensor harness, near breakout to brake warn resistor/diode assembly)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (engine control sensor harness, near breakout to powertrain control module (pcm))
• (fuel charge harness, near breakout to canister purge solenoid) (5.8l engine) (no location available) (7.5l engine)
• (fuel charge harness, near breakout to fuel injector 4) (5.8l engine) (no location available) (7.5l engine)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier)
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Cse gnd
• Data
• E40d transmission
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender pnl)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ign
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Malfunction indicator lamp (mil)
• Manifold absolute pressure (map) sensor (right side of firewall)
• Map
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S163
• S169
• S215
• S216
• S236
• S240 (main harness, near breakout to clutch pedal position switch or jumper)
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vip data link connector (left rear of engine compt, on bracket)
• Vip data link connector (partial) (left rear of engine compt, on bracket)
• Vref
• Vss gnd
• Vss input
• Vss output
• Warning chime module

7.5L, Transmission Wiring Diagram, California Except Super Duty for Ford Cab & Chassis F350 1997

List of elements for 7.5L, Transmission Wiring Diagram, California Except Super Duty for Ford Cab & Chassis F350 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range (tr) sensor)
• (behind bottom of right kick panel) g203
• (dash engine gauge feed harness, near breakout to throttle position sensor (tps))
• (dash engine harness, near breakout to egr control solenoid)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (left front of engine compartment, top of upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier) s246
• (right front of engine, compartment, on front of fender apron) g101
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of dash, before glove compt)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender panel)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, on front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow sensor (right front of engine compartment)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S169
• S215
• S216
• S236
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output
• Warning chime module