SUPPLEMENTAL RESTRAINTS – Ford Explorer 2002 – SYSTEM WIRING DIAGRAMS

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram, Early Production for Ford Explorer 2002

List of elements for Supplemental Restraint Wiring Diagram, Early Production for Ford Explorer 2002:

• (behind left side of dash)
• (center console) g205
• (under center console) s227
• Abs control module (left front side of engine compartment)
• Air bag indicator
• Air bag sliding contact
• Air bag tone driver
• Battery
• Battery junction box (bjb) (left side of engine compartment, at fender apron)
• C1117
• C201a
• C2041a
• C2041b
• C220a
• C220b
• C228b
• C270h
• Central junction box (cjb) (behind left side of dash)
• Data link connector (dlc) (partial)
• Driver 1 side air curtain sensor (under driver seat)
• Driver 2 side air curtain sensor (left "b" pillar)
• Driver air bag unit
• Driver safety belt retractor pretensioner (left "b" pillar)
• Driver side air curtain module (left "b" pillar)
• Electronic automatic temperature control (eatc) module (under left dash panel)
• Feed
• Fuse f1.15 5a
• Fuse f2.28 10a
• Generic electronic module (gem) (behind right side of dash)
• Ground
• Hot at all times
• Hot in run or start
• If equipped
• Ignition
• Indicator ctrl
• Instrument cluster
• Iso bus
• J/c 1
• Microprocessor
• Nca
• Passenger 1 side air curtain sensor (under passenger seat)
• Passenger 2 side air curtain sensor (right "b" pillar)
• Passenger air bag module
• Passenger safety belt retractor pretensioner (right "b" pillar)
• Passenger side air curtain module (right "b" pillar) (if equipped)
• Pin shorting bars engaged when module connector is disconnected from harness (shorting bars are connected between pins: 2-3 & 5-6 c2041a 3-4 & 6-7 c2041b
• Resistor a (left "b" pillar)
• Restraint control module (rcm) (below center console)
• Return
• S226 (under center console)
• S228 (behind center dash panel)
• S232 (behind center dash panel)
• Shorting bar
• Tone driver
• W/o side air curtain
• W/side air curtain

Supplemental Restraint Wiring Diagram, Late Production (1 of 2) for Ford Explorer 2002

List of elements for Supplemental Restraint Wiring Diagram, Late Production (1 of 2) for Ford Explorer 2002:

• (center console) g205
• (under center console) g301
• Air bag ind ctrl
• Air bag stage 1+
• Air bag stage 1-
• Air bag stage 2+
• Air bag stage 2-
• Battery
• Battery junction box (bjb) (left side of engine compartment, at fender apron)
• C1117
• C220a
• C220b
• C228b
• C270e
• C310a
• C310b
• Central junction box (cjb) (behind left side of dash)
• Data bus
• Data link connector (dlc) (partial) (behind left side of dash)
• Driver 1 side impact sensor (under driver's seat)
• Driver safety belt buckle pretensioner (left "b" pillar)
• Driver's safety belt buckle switch (under driver's seat)
• Electronic automatic temperature control (eatc) module (under left dash panel)
• Fuse f1.15 15a
• Fuse f2.19 10a
• Hot at all times
• Hot in run or start
• If equipped
• Ignition
• Instrument cluster
• J/c 1
• Logic ground
• Micro- processor
• Nca
• Note: 1: unbuckled 2: buckled
• Passenger 1 side impact sensor (under passenger's seat)
• Passenger safety belt buckle pretensioner (right "b" pillar)
• Passenger's safety belt buckle switch (under passenger's seat)
• Pin shorting bars engaged when module connector is disconnected from harness (shorting bars are connected between pins: 1-2, 3-4, 5-6 & 13-14 c310a 3-4 & 5-6 c310b
• Ref/gnd
• Restraint control module (rcm) (below center console)
• S228 (behind center dash panel)
• S232 (behind center dash panel)
• S333 (right "d" pillar)
• See note
• Shorting bar
• Signal
• Signal +
• Signal -
• Tone driver

Supplemental Restraint Wiring Diagram, Late Production (2 of 2) for Ford Explorer 2002

List of elements for Supplemental Restraint Wiring Diagram, Late Production (2 of 2) for Ford Explorer 2002:

• Air bag sliding contact
• Driver 2 side impact sensor (left "b" pillar)
• Driver air bag unit
• Front impact severity sensor (right front side of vehicle)
• Left safety canopy (left "b" pillar)
• Left seat track position sensor (under driver's seat)
• Nca
• Passenger 2 side impact sensor (right "b" pillar)
• Passenger air bag module
• Resistor a (left "b" pillar)
• Right safety canopy (right "b" pillar) (if equipped)
• Shorting bar
• W/o side air curtain
• W/side air curtain