AIR CONDITIONING – Dodge Grand Caravan EL 2002 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Automatic A/C Wiring Diagram for Dodge Grand Caravan EL 2002

List of elements for Automatic A/C Wiring Diagram for Dodge Grand Caravan EL 2002:

163

• (above starter) g103
• (behind right side of dash) front blower motor
• (in breakout to instrument panel speaker)
• (left "b" pillar) g300
• (left headlamp area) g102
• (near breakout for ground above starter) s106
• (near breakout for ignition coil pack)
• (near breakout for instrument panel switch bank)
• (near breakout to a/c compressor clutch) s142
• 87a
• A/c clutch rly
• A/c compressor clutch (on left front of engine)
• A/c compressor clutch relay
• A/c on
• A/c on ind
• A/c press sig
• A/c pressure transducer (top front of engine near throttle body)
• A/c switch
• A114
• Atc remote sensor (above auto temp control)
• Auto temperature control
• Bi-level
• Body control module (behind left side of dash)
• C121
• C13
• C132
• C133
• C135
• C154
• C161
• C169
• C18
• C200
• C21
• C32
• C33
• C35
• C53
• C54
• C56
• C59
• C61
• C900
• C905
• Coil
• Contact
• D17
• D18
• D22
• D25
• D40
• Data link connector (dlc) (below left side of dash)
• Def
• Defogger system
• Delay on
• Delay sw
• Diagnostic junction port
• Driver
• Driver a blnd
• Driver a mode dr
• Driver a recirc dr
• Driver b blnd
• Driver b mode dr
• Driver b recirc dr
• Driver blend door actuator
• E12
• Engine controls system
• Evap temp sensor
• Evaporator temperature sensor (on expansion valve)
• F504
• F600
• F855
• Floor
• Front blower ctrl
• Front blower module (on hvac housing)
• Front blower motor relay
• Front control module
• Front/ rear blower relay
• Fuse 15a
• Fuse 25a
• Fuse 40a
• G200 (right side of dash)
• Gnd
• Ground
• Hot at all times
• Hot in run or start
• Hvac control
• Ign protected
• Ignition
• Ignition (run)
• Ignition output (run)
• Integrated power module (ipm) (left side of engine compartment)
• K173
• K900
• Kdb 2 clock
• Kdb 2 data
• Kdb clock
• Kdb data
• Kdp 2 clock
• Kdp2 data
• Left temp
• Mix
• Mode door actuator
• Mode select
• Mtr ctrl
• Optional
• Panel
• Panel lamps
• Panel lamps driver
• Pass a blend dr
• Pass b blend dr
• Passen- ger
• Passenger blend door actuator
• Pci bus
• Pnl lp dr
• Power
• Powertrain control module (left side of engine compartment)
• Protected ign
• Radiator fan 1
• Radiator fan 2
• Radiator fan relay
• Radiator rly
• Rear automatic temperature control switch
• Rear blower
• Rear blower motor (at bottom of right "d" pillar)
• Rear blower motor power module
• Rear blower motor relay
• Rear defog on ind
• Rear defog sw
• Rear mode motor
• Rear temperature motor
• Rear wash sw
• Rear washer switch
• Rear window defog. sw.
• Rear wiper delay on indicator
• Rear wiper delay switch
• Rear wiper on indicator
• Rear wiper on switch
• Recirc mode
• Recirc switch
• Recirculate mode indicator
• Recirculate mode switch
• Recirculation door actuator
• Relay ctrl
• Right temp
• Rly out
• Rr blend dr a
• Rr blend dr b
• Rr mode dr a
• Rr mode dr b
• S101
• S102
• S116
• S201
• S202
• Sens gnd
• Sensor ground
• Sensor rtn
• Txv solenoid
• Wiper de-ice
• Wiper on indicator driver
• Wiper on switch
• Z134

Manual A/C Wiring Diagram for Dodge Grand Caravan EL 2002

List of elements for Manual A/C Wiring Diagram for Dodge Grand Caravan EL 2002:

113

• (2.4l: near breakout to torque converter clutch solenoid) (3.3l/3.8l: near breakout for ignition coil pack)
• (above starter) g103
• (in floor pan track wiring)
• (left "b" pillar) g300
• (left headlamp area) g102
• (near breakout for a/c clutch) s142 (3.3l/3.8l)
• (near breakout for knock sensor) (2.4l) s118
• (not used)
• 5 volts
• 87a
• A/c clutch rly
• A/c compr- essor clutch relay
• A/c compressor clutch (on left front of engine)
• A/c heater control
• A/c on
• A/c on indicator
• A/c press sens
• A/c pressure transducer (top front of engine, near throttle body)
• A/c switch
• Body control module (behind left side of dash)
• C13
• C18
• Coil
• Common
• Contact
• Data link connector (dlc) (below left side of dash)
• Defog on
• Defogger system
• Diagnostic junction port
• Driver
• Driver blend
• Driver blend door actuator (except zone 1)
• Engine controls system
• Evap temp sens
• Evaporator temperature sensor (on expansion valve)
• F blower
• F855
• Front blower motor (right side of dash, foreward of glove box)
• Front blower motor relay
• Front blower motor resistor block (on hvac assembly behind glove box)
• Front control module
• Front/ rear blower relay
• Fuse 15a
• Fuse 25a
• Fuse 40a
• G200 (right side of dash)
• Ground
• High
• Hot at all times
• Hot in run or start
• Hvac control
• Ign (run)
• Ignition output (run)
• Integrated power module (ipm) (left side of engine compartment)
• K173
• Left temp sensor
• Low
• Med
• Mode
• Mode door
• Mode door actuator
• Mode select
• Mode sense
• Off
• On/off sense
• Optional
• Panel lamps driver
• Panel switch bank) s202
• Pass blend
• Passen- ger
• Passenger blend door actuator
• Pci bus
• Power on
• Power on ind
• Power on/off sens
• Power switch
• Powertrain control module (left side of engine compartment)
• Radiator fan 1
• Radiator fan 2
• Radiator fan relay
• Radiator rly
• Rear a/c- heater unit
• Rear blend
• Rear blower front control switch
• Rear blower motor relay
• Rear blower rear control switch
• Rear defog
• Rear mode
• Rear mode motor
• Rear temp motor
• Rear temp rtn
• Rear temp sig
• Rear window defogger switch
• Recirc
• Recirc door
• Recirc mode switch
• Recirculate mode ind
• Recirculation door actuator
• Right temp sensor
• S101
• S102
• S106 (2.4l: 40 mm from breakout for torque converter clutch sol.) (3.3l/3.8l: near breakout for ground above starter)
• S116
• S205
• S207 (in a/c unit assembly)
• S311
• S332
• S333
• Sens gnd
• Sensor ground
• Switch sense
• Tvx sol feed
• Wiper de-icer