AIR CONDITIONING – Mercury Villager GS 1998 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

A/C Wiring Diagram, Auto A/C (1 of 2) for Mercury Villager GS 1998

List of elements for A/C Wiring Diagram, Auto A/C (1 of 2) for Mercury Villager GS 1998:

• (behind left side of dash) g202
• (engine room harness,near breakout to front blower motor)
• (main harness, near breakout behind right side of dash, on fresh/ recirculation door actuator)
• (main harness, near breakout to front blower motor resistor assembly)
• (main harness, near breakout to in-line conn. behind instrument cluster)
• A/c cont fuse 7.5a
• A/c lo pressure
• Acc
• All times
• Ambient air temp sens in
• Blower motor
• C2027
• C2028
• C2029
• C212
• E/m switch
• Eatc module
• Electron fuse 10a
• Electronic automatic temperature (eatc) control module (center of dash)
• Engine compartment fuse/relay panel
• F/r door (fresh)
• F/r door (recirc)
• F/r door actuator
• Floor/panel
• Fresh/recirculation door actuator (behind right side of dash, on a/c-heater plenum)
• Front blend door actuator (behind right center of dash, on a/c-heater plenum)
• Front blower fuse 20a
• Front blower motor
• Front blower motor relay
• Front blower motor/ speed controler (center of dash)
• Frt blend door (cool)
• Frt blend door (warm)
• Frt blend door actuator
• Frt blo motor relay
• Frt blwr fuse 65a
• G201 (behind right side of dash)
• Ground
• Ha01
• Ha02
• Ha04
• Ha06
• Ha09
• Ha11
• Ha12
• Ha13
• Ha14
• Ha15
• Ha16
• Ha17
• Ha18
• Ha20
• Ha21
• Ha22
• Ha23
• Ha24
• Ha28
• Hae2
• Hc02
• Hc03
• Hc04
• Hc05
• Hc06
• Hc08
• Hc09
• Hc10
• Hc11
• Hc12
• Hc13
• Hc14
• Hc15
• Hc16
• Hc17
• Hc18
• Hc19
• Hc20
• Hc21
• Hce2
• Hce5
• Hce7
• Headlights system
• Hj02
• Hj03
• Hj05
• Hj06
• Hj07
• Hj10
• Hj12
• Hot at
• Hot at all times
• Hot in run
• I/p fuse/ relay panel
• I/p fuse/relay panel
• Ignition switch
• Ih01
• Ih02
• Ih91
• Illumination
• In car temp sensor
• Instrument cluster system
• Interior lights system
• J/c 1 (left side of dash)
• Mode actuator
• Mode actuator (behind left center of dash)
• Nca
• Off
• Pnk
• Position switches
• Power
• Power input
• Rear blend dr act
• Rear blower motor
• Rear climate control panel
• Rear vent door act
• Rear water vlv sol
• Rr blend door actuator
• Rr blower motor relay
• Rr blw motor sw
• Rr cc panel
• Rr cc power
• Rr cc switch (frt)
• Rr climate ctrl panel
• Run
• S2010
• S203
• S231 (main harness, near breakout to in-line connector, behind instrument cluster)
• S236 (main harness, near breakout to front blower motor)
• S249 (main harness, near breakout to in-line connector, behind instrument cluster)
• S315
• S316
• Sensor power
• Start
• Sunload sensor

A/C Wiring Diagram, Auto A/C (2 of 2) for Mercury Villager GS 1998

List of elements for A/C Wiring Diagram, Auto A/C (2 of 2) for Mercury Villager GS 1998:

• (engine control harness, in breakout to powertrain control module (pcm))
• (engine control harness, near breakout to a/c compressor clutch coil)
• (engine control harness, near breakout to in-line connector, right rear of engine)
• (engine room harness, near breakout for cooling fan motor)
• (engine room harness, near breakout for in-line connector, near battery)
• (engine room harness, near engine compartment fuse/relay panel)
• (front center
• (main harn, near breakout to elec. automatic temperature module)
• (main harn, near breakout to in-line connector, behind center of dash)
• (main harness, near breakout to electronic automatic temperature control)
• (main harness, near breakout to in-line connector, behind center of dash)
• (main harness, near breakout to in-line connector, behind instrument cluster)
• (main harness, near breakout to in-line connector, behind instrument cluster) s237
• (main harness, near breakout to inertia fuel cutoff switch)
• (main harness, near breakout to rear blower motor resistor assembly)
• (main harness, near breakout to rear blower motor switch relay)
• (sub harn (eatc), near breakout to in-line connector, behind center of dash, near eatc module)
• A/c compressor clutch coil
• A/c high pressure switch (right front of engine)
• A/c low pressure switch (right side of engine compartment, on a/c accumulator)
• A/c relay
• Ambient air temperature sensor 1 (center rear of engine)
• Ambient air temperature sensor 2
• Aw16
• Aw17
• Compartment)
• Cooling fan hi1 relay
• Cooling fan hi2 relay
• Cooling fan lo relay
• Cooling fan motor
• Engine compartment fuse/relay panel
• Engine compartment fuse/relay panel j/c no.1
• Engine compartment relay box
• Fa06
• Fa12
• G102 (left rear of engine compartment, on side of strut tower)
• G134 (top of engine)
• G201 (behind right side of dash)
• G202 (behind left side of dash)
• G415 (center rear of vehicle, above rear axle)
• Ha41
• Ha45
• Hot at all times
• Hot in start or run
• Hx01
• I/p fuse/ relay panel
• In-car temperature sensor (behind ashtray assembly, in dash)
• Interior lights system
• Nca
• Of engine
• Off
• Pnk
• Powertrain control module (pcm) (behind glove box)
• Rad fan fuse 65a
• Rear
• Rear blend door actuator (left side of rear passenger area, on rear a/c-heater plenum)
• Rear blower fuse 15a
• Rear blower motor
• Rear blower motor relay
• Rear blower motor resistor assembly (left side of rear passenger area, on rear a/c-heater plenum)
• Rear blower motor switch (front)
• Rear blower motor switch (rear)
• Rear blower motor switch relay
• Rear engine coolant valve solenoid (top center rear of engine)
• Rear vent door actuator (left side of rear passenger area, on rear a/c-heater plenum)
• Red
• Relays fuse 10a
• S102 (engine room harness, near breakout to engine oil pressure switch)
• S116
• S135
• S158
• S159
• S2015
• S210
• S210 (engine control harness, near breakout to a/c compressor clutch coil)
• S212
• S219
• S253
• S288
• S289
• S290
• S304
• S311
• S313
• S314
• S318
• Sunload sensor (right side of cargo area, above wheelwell)

A/C Wiring Diagram, Manual A/C for Mercury Villager GS 1998

List of elements for A/C Wiring Diagram, Manual A/C for Mercury Villager GS 1998:

• (behind right side of dash)
• (engine control harn, right rear of engine)
• (engine control harness, in breakout to powertrain control module (pcm)
• (engine control harness, near breakout to a/c compressor clutch coil)
• (engine room harness, near breakout for cooling fan motor)
• (engine room harness, near breakout for in-line connector, near battery)
• (engine room harness, near engine compartment fuse/relay panel)
• (left rear of engine compartment, on side of strut tower) g102
• (left side of dash)
• (main harness, near breakout to in-line conn., behind instrument cluster)
• (main harness, near breakout to in-line connector, behind center of dash)
• (main harness, near breakout to in-line connector, behind instrument cluster)
• (main harness, near breakout to in-line connector, behind instrument cluster)
• (main harness, near breakout to j/c no.2, behind top left side of dash, right of instrument cluster)
• A/c compressor clutch coil
• A/c cont fuse 7.5a
• A/c high pressure switch (right front of engine)
• A/c high/low press sw
• A/c low pressure switch (right side of engine compartment, on a/c accumulator)
• A/c relay
• Acc
• All times
• Aw16
• Aw17
• Bi-level/floor input
• C201
• C203
• C209
• Cooling fan hi1 relay
• Cooling fan hi2 relay
• Cooling fan lo relay
• Cooling fan motor
• Defrost input
• Electron fuse 10a
• Engine compart- ment fuse/ relay panel
• Engine compartment fuse/relay panel
• Engine compartment relay box
• Fa06
• Fa12
• Flr or flr/def input
• Flr/def or def input
• Fresh/recirc dr act
• Fresh/recirculation door actuator (behind right side of dash, on plenum)
• Front blend door actuator (behind right side of dash, on plenum)
• Front blower fuse 20a
• Front blower motor
• Front blower motor relay
• Front blower motor resistor assembly (behind right side of dash, in plenum)
• Front blower motor switch
• Front climate control panel
• Frt blend dr act
• Frt blend dr mtr act
• Frt blwr fuse 65a
• Frt blwr mtr rly ctrl
• G134 (top of engine)
• G201
• G201 (behind right side of dash)
• G202 (behind left side of dash)
• Ground
• Ha01
• Ha02
• Ha04
• Ha05
• Ha06
• Ha09
• Ha11
• Ha12
• Ha13
• Ha14
• Ha15
• Ha16
• Ha17
• Ha18
• Ha20
• Ha21
• Ha22
• Ha23
• Ha24
• Ha28
• Ha41
• Ha45
• Hae2
• Hb21
• He01
• Headlights system
• Hot at
• Hot at all times
• Hot in run
• Hot in start or run
• Hx01
• I/p fuse/ relay panel
• I/p fuse/relay panel
• Ignition
• Ignition switch
• Ih01
• Ih91
• Illumination
• Interior lights system
• J/c 1
• Mode act motor
• Mode act sig rtn
• Mode actuator
• Mode actuator (behind center of dash)
• Nca
• Off
• Pnk
• Position switches
• Power
• Powertrain control module (pcm) (behind glove box)
• Rad fan fuse 65a
• Rear blower motor switch (front)
• Rear blw mtr sw
• Relays fuse 10a
• Run
• S102 (engine room harness, near breakout to engine oil pressure switch)
• S116
• S135
• S158
• S159
• S203
• S210
• S219
• S231
• S236 (main harness, near breakout to front blower motor)
• S248
• S249
• S250
• S287
• S301 (main harness, near breakout to rear vent door actuator)
• Start

Rear A/C Wiring Diagram, Manual A/C for Mercury Villager GS 1998

List of elements for Rear A/C Wiring Diagram, Manual A/C for Mercury Villager GS 1998:

• (center rear of vehicle, above rear axle) g415
• (engine cntrl harn, near a/c comp clutch coil breakout)
• (main harn, behind left side of dash)
• (main harn, near blwr mtr res ass'y breakout)
• (main harn, near rear vent door actuator breakout)
• A/c cont fuse 15a
• Actuator breakout)
• C209
• Front climate control panel
• G201 (behind right side of dash)
• G202 (behind left side of dash)
• Ground
• Hb21
• He01
• Hj01
• Hj02
• Hj03
• Hj05
• Hj06
• Hj07
• Hj08
• Hj09
• Hj10
• Hj12
• Hje1
• Hot at all times
• Hot in run
• I/p fuse relay panel
• Ignition
• Ih02
• Illumination lamp
• Interior lights system
• Nca
• Nca ground
• Off
• Pnk
• Rear
• Rear blend door actuator (left side of rear passenger area, on rear plenum)
• Rear blend dr act
• Rear blower fuse 15a
• Rear blower motor
• Rear blower motor resistor assembly (left side of rear passenger area)
• Rear blower motor switch (front)
• Rear blower motor switch (rear)
• Rear blw nca
• Rear climate control panel
• Rear engine coolant valve solenoid (top center rear of engine)
• Rear vent door act
• Rear vent door actuator (left side of rear passenger area)
• Rear water vlv sol
• Rr blw motor sw
• S210
• S250
• S301
• S311
• S313
• S314
• S318
• S3o1