ENGINE PERFORMANCE – Ford Cutaway E350 1996 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

4.9L

4.9L, Engine Performance Wiring Diagrams (1 of 4) for Ford Cutaway E350 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (1 of 4) for Ford Cutaway E350 1996:

• bus -
• ground
• intake air temp. fuel pump mon. a/c on input
• shift sol #1
• tfi module gnd
• trans ctrl sw
• (not used)
• Air conditioning system
• Aird sol.
• Anti-theft module (left side of vehicle, behind "b" pillar)
• Bus +
• C143
• C233
• C336
• C6 trans.
• Cat monitor sens
• Coil
• Coil wire
• Data link connector (dlc) (below left side of i/p)
• Distributor (left side of engine)
• Distributor shield
• E40d trans.
• Egr sol.
• Eng temp sens.
• Fuse 18 15a
• Fuse 5 15a
• Fuse 7 10a
• G106 (left side of engine compartment, near battery)
• G200 (behind left cowl)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Gen scan tool in
• Gnd
• Ground
• Hot in run
• Hot in start or run
• Idm
• Idm monitor
• Ign gnd
• Ignition coil (left front of engine)
• Ignition control module (icm) (left rear of engine compartment)
• Ignition control module (icm) shield
• Instrument cluster
• Interior fuse panel (behind left side of i/p)
• Malfunction indicator lamp (mil)
• Mass air flw rtn
• Mil lp ctrl
• Misfire sens gnd
• Nca
• O/d off
• Park/neutral position switch (left side of transmission)
• Pip
• Pnk
• Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
• Pwr
• Radio capacitor (left side of engine, attached to ignition coil)
• Shield gnd
• Shift sol #2
• Shorting bar (left rear of engine compartment)
• Spk angle pulse
• Spout
• Tc3
• Tcil
• Trans temp sens.
• Transmission control switch/ indicator lamp
• W/ anti- theft
• W/o anti- theft

4.9L, Engine Performance Wiring Diagrams (2 of 4) for Ford Cutaway E350 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (2 of 4) for Ford Cutaway E350 1996:

• Acc
• Coast clutch solenoid
• Diode (plug- in)
• E4od transmission
• Electronic pressure control (epc) solenoid
• Engine compartment fuse panel (left side of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine, on heater outlet elbow)
• Fuel pump relay
• Fuse c 30a
• Fuse g 60a
• Fuse h 30a
• Fuse u 30a
• G106 (left side of engine compartment, near battery)
• Hot at all times
• Hot in start or run
• Ignition switch
• Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
• Lock
• Misfire sensor (lower right front of engine)
• Off
• Pcm power relay
• Red
• Run
• Shift solenoid #1
• Shift solenoid #2
• Start
• Starter motor relay (left front corner of engine compartment)
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• W/ c6 trans.
• W/ e40d trans.

4.9L, Engine Performance Wiring Diagrams (3 of 4) for Ford Cutaway E350 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (3 of 4) for Ford Cutaway E350 1996:

• Airb solenoid (rear of left valve cover, on bracket)
• Aird solenoid (rear of left valve cover, on bracket)
• All cutaways
• All vans & wagons
• Brake on/off (boo) switch (on brake pedal bracket)
• C422
• Class 1 trailer adapter only
• Egr solenoid (rear of left valve cover, on bracket)
• Fuel injectors (in intake manifold)
• Fuel pump/ sender (below vehicle in fuel tank)
• Fuse i 15a
• G106 (left side of engine compartment, near battery)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Hot at all times
• Idle air control (iac) valve (left side of engine, above distributer)
• In-transit fuel pump/ sender (below vehicle, along left frame rail)
• Inertia fuel shutoff (ifs) (behind right cowl panel)
• Instrument cluster system (anti-slosh module/fuel gauge)
• Interior fuse panel (behind left side of i/p)
• Mass air flow (maf) sensor (center of engine compartment)
• Nca
• Rear fuel pump/ sender (mounted on left rear frame crossmember)
• Red
• Tan
• Trailer/camper adapter connector
• W/trailer adapter only

4.9L, Engine Performance Wiring Diagrams (4 of 4) for Ford Cutaway E350 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (4 of 4) for Ford Cutaway E350 1996:

• Airb solenoid
• Boo switch input
• Catalyst monitor sensor (cms) (near lower right side of transmission)
• Cms sensor
• Coast clutch sol.
• Delta pressure feedback egr (dpfe) sensor (right side of engine)
• Dpfe sensor
• Epc solenoid
• Fuel injector #1
• Fuel injector #2
• Fuel injector #3
• Fuel injector #4
• Fuel injector #5
• Fuel injector #6
• Fuel pmp rly ctrl
• G106 (left side of engine compartment, near battery)
• Ground
• Heated oxygen sensor (ho2s) #11 (lower right side of engine)
• Heated oxygen sensor (ho2s) #21 (lower right side of engine)
• Hego #11
• Hego #21
• Hego sns mn #11
• Hego sns mn #21
• Iac valve
• Keep alive pwr in
• Knock sensor
• Knock sensor (ks) (left side of engine, near ignition coil)
• Mass air fl sens.
• Misfire sens.
• Nca
• Power input
• Powertrain control module (pcm) (left rear of engine, compartment, near brake master cylinder)
• Programmable speedometer/ odometer module (psom) (behind left side of i/p)
• Red
• Ref output volt
• Sens sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Tan
• Tcc solenoid
• Tcil ind. lp.
• Throttle position (tp) sensor (top left side of engine)
• Tp sensor
• Trans rng sensor
• Vapor man. valve
• Vapor management valve (center of engine compartment)
• Vehicle spd sens.
• Vss input
• Vss output
• W/ e40d trans.
• W/c6 trans.
• Wide open throt.
• Wide open throttle (wot) relay (lower left side of engine compartment, near starter motor relay)

5.8L

5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (1 of 2) for Ford Cutaway E350 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (1 of 2) for Ford Cutaway E350 1996:

• (not used)
• A/c on
• Air conditioning system
• Aird
• Boo
• Brake on/off (boo) switch (on brake pedal support)
• C162
• C163
• C175
• C233
• Canp
• Ccs
• Coil
• Coil wire
• Data (+)
• Data (-)
• Data link connector (left front corner of engine compt.)
• Data link connector (left front of engine compt.)
• Diode (plug-in) (in engine compartment fuse panel)
• Distributor
• Distributor shield
• Ect
• Egr sol
• Egr valve
• Engine compartment fuse panel (left side of engine compartment)
• Epc
• Fpm
• Fuse 1 15a
• Fuse 18 15a
• Fuse c 30a
• Fuse u 30a
• G106 (left side of engine compartment, near battery)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Gnd
• Ho2s
• Ho2s gnd
• Hot at all times
• Hot in start or run
• Iac
• Iat
• Idm
• Ign gnd
• Ign power
• Ignition coil (left rear of engine)
• Ignition control module (icm) (left rear of engine compartment)
• Ignition control module (icm) shield
• Inj 1,4,5,8 out
• Inj 2,3,6,7 out
• Instrument cluster
• Interior fuse panel (behind left side of i/p)
• Kapwr
• Malfunction indicator lamp (mil)
• Map
• Mil
• Nca
• Or
• Pcm power relay
• Pip
• Pnk
• Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
• Psom (+)
• Pwr
• Radio capacitor (attached to ignition coil)
• Red
• Shorting bar (left rear of engine compartment)
• Sig rtn
• Speed control servo/amplifier assembly (near brake master cylinder)
• Spout
• Ss1
• Ss2
• Sti
• Tan
• Tcc sol
• Tcil
• Tcs
• Tft
• Tr sensor
• Transmission range (tr) sensor (left side of transmission)
• Vehicle speed input
• Vref
• Vss (-)

5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (2 of 2) for Ford Cutaway E350 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (2 of 2) for Ford Cutaway E350 1996:

• (not used)
• Aird solenoid (rear of left valve cover, on bracket)
• All cutaways
• All vans and wagons
• Coast clutch solenoid
• Compartment, near battery)
• E40d transmission
• Egr solenoid (rear of left valve cover, on bracket)
• Egr valve (evp) position sensor (top right front of engine, on egr valve)
• Electronic pressure (epc) control solenoid
• Engine compartment fuse panel (left side of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine, near distributor, on heater tube)
• Evaporative emissions (evap) canister purge valve (right side of engine, connected to throttle body)
• Fuel injectors
• Fuel pump relay
• Fuel pump/ sender (below vehicle, in fuel tank)
• Fuse 15a
• Fuse h 30a
• G106 (left side of engine compartment, near battery)
• Heated oxygen sensor (ho2s) no.11 (middle lower right side of vehicle)
• Hot at all times
• Hot in run
• Idle air control (iac) valve (front of engine, near distributor)
• Ignition switch acc
• In-transit fuel pump/sender (below vehicle, along left frame rail)
• Inertia fuel shut off (ifs) switch (behind right cowl panel)
• Intake air temperature (iat) sensor (right side of engine, near fuel injector no.1)
• Interior fuse panel (behind left side of i/p)
• Lock
• Manifold absolute pressure (map) sensor (right side of engine compartment)
• Nca
• No.1
• No.2
• No.3
• No.4
• No.5
• No.6
• No.7
• No.8
• Od off
• Off
• Rear fuel pump sender (mounted on left rear frame crossmember)
• Red
• Run
• Shift solenoid no.1
• Shift solenoid no.2
• Start
• Tan
• Tc3
• Tcil
• Throttle position (tp) sensor (right front of engine)
• Torque converter clutch solenoid
• Trans- mission fluid temper- ature sensor
• Transmission control switch/ indicator lamp

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (1 of 4) for Ford Cutaway E350 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (1 of 4) for Ford Cutaway E350 1996:

• (not used)
• A/c on in sig
• Air conditioning system
• Anti-theft module (left side of vehicle, behind "b" pillar)
• Bus +
• Bus -
• C143
• C233
• C336
• Cat monitor sens
• Coil
• Coil wire
• Data link connector (dlc) (below left side of i/p)
• Distributor (center front of engine)
• Distributor shield
• Egr sol.
• Eng temp sens.
• Fuel pump mon.
• Fuse 18 15a
• Fuse 5 15a
• Fuse 7 10a
• G106 (left side of engine compartment, near battery)
• G200 (behind left cowl)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Gen scan tool in
• Gnd
• Ground
• Hot in run
• Hot in start or run
• Idm
• Idm monitor
• Ign gnd
• Ignition coil (left rear of engine)
• Ignition control module (icm) (left rear of engine compartment)
• Ignition control module (icm) shield
• Instrument cluster
• Intake air temp.
• Interior fuse panel (behind left side of i/p)
• Malfunction indicator lamp (mil)
• Mass air flw rtn
• Mil lp ctrl
• Misfire sens gnd
• Nca
• O/d off
• Pip
• Pnk
• Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
• Pwr
• Radio capacitor (left side of engine, attached to ignition coil)
• Shield gnd
• Shift sol #1
• Shift sol #2
• Shorting bar (left rear of engine compartment)
• Spk angle pulse
• Spout
• Tc3
• Tcil
• Tfi module gnd
• Trans ctrl sw
• Trans temp sens.
• Transmission control switch/ indicator lamp
• Vss ground
• W/ anti- theft
• W/o anti- theft
• Wire coil

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (2 of 4) for Ford Cutaway E350 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (2 of 4) for Ford Cutaway E350 1996:

• Acc
• Coast clutch solenoid
• Diode (plug- in)
• E4od transmission
• Electronic pressure control (epc) solenoid
• Engine compartment fuse panel (left side of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine, near distributor, on heater tube)
• Fuel pump relay
• Fuse c 30a
• Fuse g 60a
• Fuse h 30a
• Fuse u 30a
• G106 (left side of engine compartment, near battery)
• Hot at all times
• Hot in start or run
• Ignition switch
• Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
• Lock
• Misfire sensor (lower right front of engine)
• Off
• Pcm power relay
• Red
• Run
• Shift solenoid #1
• Shift solenoid #2
• Start
• Starter motor relay (left front corner of engine compartment)
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (3 of 4) for Ford Cutaway E350 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (3 of 4) for Ford Cutaway E350 1996:

• All cutaways
• All vans & wagons
• C422
• Egr solenoid (rear of left valve cover, on bracket)
• Fuel injectors (in intake manifold)
• Fuel pump/ sender (below vehicle, vehicle, in fuel tank)
• G106 (left side of engine compartment, near battery)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Idle air control (iac) valve (front of engine, near distributor)
• In-transit fuel pump/ sender (below vehicle, along left frame rail)
• Inertia fuel shutoff (ifs) (behind right cowl panel)
• Instrument cluster (anti-slosh module)
• Mass air flow (maf) sensor (center of engine compartment)
• Nca
• No.1
• No.2
• No.3
• No.4
• No.5
• No.6
• No.7
• No.8
• Rear fuel pump/ sender (mounted on left rear frame crossmember)
• Red
• Tan
• Tan/ red
• Tan/red
• Trailer/camper adapter connector
• W/class 1 trailer adapter only
• W/trailer adapter only

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (4 of 4) for Ford Cutaway E350 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (4 of 4) for Ford Cutaway E350 1996:

• Boo switch input
• Brake on/off (boo) switch (on brake pedal bracket)
• C143
• Catalyst monitor sensor (cms) (lower middle side of vehicle)
• Cms sensor
• Coast clutch sol.
• Delta pressure feedback egr (dpfe) sensor (right side of engine)
• Dpfe sensor
• Epc solenoid
• Fuel inj. no.1
• Fuel inj. no.2
• Fuel inj. no.3
• Fuel inj. no.4
• Fuel inj. no.5
• Fuel inj. no.6
• Fuel inj. no.7
• Fuel inj. no.8
• Fuel pmp rly ctrl
• Fuse i 15a
• G106 (left side of engine compartment, near battery)
• Ground
• Heated oxygen sensor (ho2s) no.11 (beneath center of vehicle)
• Heated oxygen sensor (ho2s) no.21 (lower left side of transmission)
• Hego mn no.11
• Hego mn no.21
• Hego no.11
• Hego no.21
• Hot at all times
• Iac valve
• Interior fuse panel (behind left side of i/p)
• Keep alive pwr in
• Mass air fl sens.
• Misfire sens.
• Nca
• Power distribution system
• Power input
• Powertrain control module (pcm) (left rear of engine, compartment, near brake master cylinder)
• Programmable speedometer/ odometer module (psom) (behind left side of i/p)
• Red
• Ref output volt
• Sens sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Tan
• Tan/red
• Tcc solenoid
• Tcil ind. lp.
• Throttle position (tp) sensor (right front of engine)
• Tp sensor
• Trans rng sensor
• Vapor man. valve
• Vapor management valve (center of engine compartment)
• Vehicle spd sens.
• Vss input
• Vss output

7.3L

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams (1 of 3) for Ford Cutaway E350 1996

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams (1 of 3) for Ford Cutaway E350 1996:

• "wait to start" indicator
• (left rear of engine compartment, near brake master cylinder)
• Auxiliary powertrain control connector (behind left side of i/p)
• Brake press sw
• Brake pressure switch (bottom of master cylinder)
• Brake warning in
• Bus (+)
• Bus (-)
• C143
• C233
• C247
• C248
• Check eng light
• Check engine light
• Cruise control system
• Data link connector (dlc) (partial) (behind left side of i/p)
• Diesel warning lamps display
• Diode (plug-in) (in engine compartment fuse panel)
• Ebp
• Engine compartment fuse panel (left side of engine compartment)
• Engine oil temperature (eot) sensor (center left side of engine)
• Eot
• Fuse link e (20 ga.- gray)
• Fuse link f (16 ga.- gray)
• Fuse 15a
• Fuse u 30a
• G106 (left side of engine compartment, near battery)
• G106 (left side of engine compartment, near battery)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Generic scan tool
• Gnd
• Hot at all times
• Hot in run or start
• Iat
• Idle valid sw
• Idle validation switch (behind left side of i/p)
• Idm relay
• Injection pressure regulator (ipr) (top front of engine)
• Instrument cluster
• Instrument cluster system
• Intake air temper- ature (iat) sensor (center of engine compartment)
• Interior fuse panel (behind left side of i/p)
• Map
• Pcm power relay
• Powertrain control module (pcm)
• Red
• Red
• Speed ctrl gnd
• Ss1
• Ss2
• Tcc
• Tcs
• Tft
• Vss gnd

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams (2 of 3) for Ford Cutaway E350 1996

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams (2 of 3) for Ford Cutaway E350 1996:

• (left rear of engine compartment, near brake master cylinder)
• A/c on in
• Accelerator pedal (ap) position sensor (behind left side of i/p, above accelerator pedal)
• Accl pdl pos sens
• Air conditioning system
• Baro
• Barometric pressure (baro) sensor (behind left side of i/p)
• Boo
• C143
• Cam pos sens
• Camshaft position (cmp) sensor (front center of engine)
• Ccs
• Cid sig
• Cmp rtn
• Cruise control system
• Elec feedback
• Epc
• Epr
• Exhaust back pressure (ebp) sensor (top center of engine)
• Exhaust pressure regulator (epr) (top left side of engine)
• Fuel delivery sig
• Fuse 15a
• G106 (left side of engine compartment, near battery)
• G112 (left side of engine)
• Glow plug ctrl
• Gnd
• Hot in run
• Icp
• Idm enable out
• Injection control pressure (icp) sensor (center left side of engine)
• Interior fuse panel (behind left side of i/p)
• Ipr
• Kapwr in
• Manifold absolute pressure (map) sensor (right side of engine compt)
• Nca
• Power in
• Powertrain control module (pcm)
• Programmable speedometer/ odometer module (behind left side of i/p)
• Red
• Sig rtn
• Speed ctrl gnd
• Tcil
• Tcs
• Tr sensor
• Transmission control switch/indicator lamp
• Vref
• Vss
• Vss out
• Wait to start out

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams (3 of 3) for Ford Cutaway E350 1996

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams (3 of 3) for Ford Cutaway E350 1996:

• transmission range (tr) sensor (left side of transmission)
• (left rear of engine compartment)
• Brake on/off (boo) switch (on brake pedal support bracket)
• C299
• Cid sig in
• Coast clutch solenoid
• E40d transmission
• Elec feedback
• Electronic pressure control (epc) solenoid
• Engine compart- ment fuse panel (left side of engine compartment)
• Fuel delivery sig
• Fuel inj feed left
• Fuel inj feed right
• Fuel injector no.1
• Fuel injector no.2
• Fuel injector no.3
• Fuel injector no.4
• Fuel injector no.5
• Fuel injector no.6
• Fuel injector no.7
• Fuel injector no.8
• Fuel injectors/glow plugs (no. 6, no.8) (near rear of left side of valve cover)
• Fuel injectors/glow plugs (no.1, no.3) (near front of right side of valve cover)
• Fuel injectors/glow plugs (no.2, no.4) (near front of left side of valve cover)
• Fuel injectors/glow plugs (no.5, no.7) (near rear of right side of valve cover)
• Fuel line heater (top left side of engine)
• Fuse 15a
• Fuse u 30a
• Glow plug relay (top right side of engine)
• Gnd
• Hot at all times
• Hot in run or start
• Inj shield gnd
• Injector driver module (idm)
• Interior fuse panel (behind left side of i/p)
• Nca
• No.1
• No.2
• No.3
• No.4
• No.5
• No.6
• No.7
• No.8
• Power input
• Red
• Shift solenoid no.1
• Shift solenoid no.2
• Sig rtn
• Tan
• Tan b
• Tan/red
• Tan/red d
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature sensor

7.5L

7.5L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford Cutaway E350 1996

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford Cutaway E350 1996:

• (not used)
• A/c on in sig
• Air conditioning system
• Aird solenoid
• All cutaways
• All vans/ wagons
• Anti slosh module
• Anti-theft module (left side of vehicle, behind "b" pillar)
• Bus +
• Bus -
• C143
• C232
• C233
• C336
• Cat monitor sens
• Coil
• Coil wire
• Data link connector (dlc) (below left side of i/p)
• Distributor (center front of engine)
• Distributor shield
• Egr sol.
• Eng temp sens.
• Fuel pump mon.
• Fuse 18 15a
• Fuse 5 15a
• Fuse 7 10a
• G106 (left side of engine compartment, near battery)
• G200 (behind left cowl)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Gen scan tool in
• Gnd
• Ground
• Hot in run
• Hot in start or run
• Idm
• Idm monitor
• Ign gnd
• Ignition coil (left rear of engine)
• Ignition control module (icm) (left rear of engine compartment)
• Ignition control module (icm) shield
• Instrument cluster
• Intake air temp.
• Interior fuse panel (behind left side of i/p)
• Malfunction indicator lamp (mil) (check engine light)
• Mass air flw rtn
• Mil lp ctrl
• Misfire sens gnd
• Nca
• O/d off
• Pip
• Pnk
• Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
• Pwr
• Radio capacitor (left side of engine, attached to ignition coil)
• Shield gnd
• Shift sol no.1
• Shift sol no.2
• Shorting bar (left rear of engine compartment)
• Solid state
• Spk angle pulse
• Spout
• Tc3
• Tcil
• Tfi module gnd
• To fuel gauge
• Trans ctrl sw
• Trans temp sens.
• Transmission control switch/ indicator lamp
• Vss ground
• W/ anti- theft
• W/o anti- theft
• Wire coil

7.5L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford Cutaway E350 1996

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford Cutaway E350 1996:

• Acc
• Coast clutch solenoid
• Coil
• Diode (plug- in)
• E4od transmission
• Electronic pressure control (epc) solenoid
• Engine compartment fuse panel (left side of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine, near distributor)
• Fuel pump relay
• Fuse c 30a
• Fuse g 60a
• Fuse h 30a
• Fuse u 30a
• G106 (left side of engine compartment, near battery)
• Hot at all times
• Hot in start or run
• Ignition switch
• Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
• Lock
• Misfire sensor (lower right front of engine)
• Off
• Pcm power relay
• Red
• Run
• Shift solenoid no.1
• Shift solenoid no.2
• Start
• Starter motor relay (left front corner of engine compartment)
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)

7.5L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford Cutaway E350 1996

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford Cutaway E350 1996:

• Aird solenoid (rear of left valve cover, on bracket)
• All cutaways
• All vans & wagons
• C422
• Egr solenoid (rear of left valve cover, on bracket)
• Fuel injectors (in intake manifold)
• Fuel pump/ sender (below vehicle, in fuel tank)
• G106 (left side of engine compartment, near battery)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Idle air control (iac) valve (top rear of engine, near engine oil pressure switch)
• In-transit fuel pump/ sender (below vehicle, along left frame rail)
• Inertia fuel shutoff (ifs) (behind right cowl panel)
• Mass air flow (maf) sensor (center of engine compartment)
• Nca
• No.1
• No.2
• No.3
• No.4
• No.5
• No.6
• No.7
• No.8
• Rear fuel pump/ sender (mounted on left rear frame crossmember)
• Red
• Tan
• Tan/ red
• Tan/red
• Trailer/camper adapter connector
• W/class 1 trailer adapter only
• W/trailer adapter only

7.5L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford Cutaway E350 1996

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford Cutaway E350 1996:

• Airb solenoid
• Airb solenoid (rear of left valve cover, on bracket)
• Boo switch input
• Brake on/off (boo) switch (on brake pedal bracket)
• C143
• Catalyst monitor sensor (cms) (lower middle side of vehicle)
• Cms sensor
• Coast clutch sol.
• Delta pressure feedback egr (dpfe) sensor (top of engine near throttle body)
• Dpfe sensor
• Epc solenoid
• Fuel inj. no.1
• Fuel inj. no.2
• Fuel inj. no.3
• Fuel inj. no.4
• Fuel inj. no.5
• Fuel inj. no.6
• Fuel inj. no.7
• Fuel inj. no.8
• Fuel pmp rly ctrl
• Fuse i 15a
• G106 (left side of engine compartment, near battery)
• Ground
• Heated exhaust gas oxygen sensor (hego) no.11 (middle lower right side of vehicle)
• Heated exhaust gas oxygen sensor (hego) no.21 (lower left side of transmission)
• Hego mn no.11
• Hego mn no.21
• Hego no.11
• Hego no.21
• Hot at all times
• Iac valve
• Interior fuse panel (behind left side of i/p)
• Keep alive pwr in
• Mass air fl sens.
• Misfire sens.
• Nca
• Power distribution system
• Power input
• Powertrain control module (pcm) (left rear of engine, compartment, near brake master cylinder)
• Programmable speedometer/ odometer module (psom) (behind left side of i/p)
• Red
• Ref output volt
• Sens sig rtn
• Solid state
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Tan
• Tan/red
• Tcc solenoid
• Tcil ind. lp.
• Throttle position (tp) sensor (top left side of engine)
• Tp sensor
• Trans rng sensor
• Vapor man. valve
• Vapor management valve (center of engine compartment)
• Vehicle spd sens.
• Vss input
• Vss output

7.5L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford Cutaway E350 1996

List of elements for 7.5L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford Cutaway E350 1996:

• (not used)
• A/c on
• Acd
• Air conditioning system
• Airb
• Aird
• Boo
• Brake on/off (boo) switch (on brake pedal support)
• C162
• C163
• C233
• Ccs
• Coil
• Coil wire
• Data
• Data (+)
• Data (-)
• Data link connector (dlc) (left front corner of engine compartment)
• Data link connector (dlc) (left front of engine compt)
• Diode (plug-in) (engine compartment fuse panel)
• Distributor
• Distributor shield
• Ect
• Egr
• Egr valve
• Engine compartment fuse panel (left side of engine compartment)
• Epc
• Evap
• Fp enable
• Fpm
• Fuse 1 15a
• Fuse 18 15a
• Fuse c 30a
• Fuse u 30a
• G106 (left side of engine compartment, near battery)
• G202 (attached to instrument panel assembly, behind instrument cluster)
• Gnd
• Ho2s
• Ho2s gnd
• Hot at all times
• Hot in start or run
• Iac
• Iat
• Idm
• Ign gnd
• Ignition
• Ignition coil (left rear of engine)
• Ignition control module (icm) shield
• Ignition control module (left rear of engine compartment)
• Inj 1,4,5,8 out
• Inj 2,3,6,7 out
• Instrument cluster
• Interior fuse panel (behind left side of i/p)
• Kapwr
• Malfunction indicator lamp (mil)
• Map
• Mil
• Nca
• Pcm power relay
• Pip
• Pnk
• Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
• Psom (+)
• Pwr
• Radio capacitor (attached to ignition coil)
• Red
• Sensor sig rtn
• Shorting bar (left rear of engine compartment)
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Spout
• Ss1
• Ss2
• Tan
• Tcc
• Tcil
• Tcs
• Tft
• Tr sensor
• Transmission control switch/ indicator lamp
• Transmission range (tr) sensor (left side of transmission)
• Vehicle speed input
• Vref
• Vss (-)

7.5L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford Cutaway E350 1996

List of elements for 7.5L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford Cutaway E350 1996:

• (not used)
• Acc
• Airb solenoid (rear of left valve cover on bracket) (super duty only)
• Aird solenoid (rear of left valve cover, on bracket)
• All cutaways
• All vans & wagons
• Coast clutch solenoid
• E40d transmission
• Egr solenoid (rear of left valve cover, on bracket)
• Egr valve position (evp) sensor (top of egr valve, near throttle body)
• Electronic pressure control (epc) solenoid
• Engine compartment fuse panel (left side of engine compartment)
• Engine coolant temperature (ect) sensor (top front of engine, near distributor)
• Evaporative emissions (evap) canister purge valve (left rear of engine, connected to throttle body)
• Fuel injectors
• Fuel pump relay
• Fuel pump/ sender (below vehicle in fuel tank)
• Fuse h 30a
• G106 (left side of engine compartment, near battery)
• Heated oxygen sensor (ho2s) n0.11 (super duty) (beneath center of vehicle) (except super duty) (middle lower right side of vehicle)
• Hot at all times
• Idle air control (iac) valve (top rear of engine, near engine oil pressure switch)
• Ignition switch
• In-transit fuel pump/sender (below vehicle, along left frame rail)
• Inertia fuel shutoff (ifs) switch (behind right cowl panel)
• Intake air temperature (iat) sensor (top of engine, near fuel injector no.6)
• Lock
• Manifold absolute pressure (map sensor (right side of engine compartment)
• Nca
• No.1
• No.2
• No.3
• No.4
• No.5
• No.6
• No.7
• No.8
• Off
• Rear fuel pump/sender (mounted on left rear frame crossmember)
• Red
• Run
• Shift solenoid no.1
• Shift solenoid no.2
• Start
• Tan
• Throttle position (tp) sensor) (top left of engine)
• Torque converter clutch (tcc) solenoid
• Trans- mission fluid temper- ature sensor