ENGINE PERFORMANCE – Ford Mustang 2006 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

4.0L

4.0L, Engine Performance Wiring Diagram (1 of 5) for Ford Mustang 2006

List of elements for 4.0L, Engine Performance Wiring Diagram (1 of 5) for Ford Mustang 2006:

• (at right "a" pillar) g203
• (left rear of engine compt)
• (left side of engine compt)
• (on right front of engine compt) g103
• (right front of engine compt)
• 57o
• Accel ped pos 1
• Accel ped pos 2
• Accel ped pos 3
• Accelerator pedal position sensor (below left side of dash)
• Acp v6
• Acp v8
• Aid bag mntr
• Anti- theft system
• Auxiliary relay box 1 (behind left side of dash)
• Brk ped pos sw
• Bussed electrical center (bec) (right front of engine compt)
• C175b
• Cruise control system
• Data link connector (dlc) (behind dash, left of steering column)
• Drv pmp fuel mntr
• Evap can vnt sol
• Evap canister purge valve (on left rear of engine compt)
• Evap canister vent control solenoid (on left rear of vehicle)
• Exterior lights system
• Fuel pmp drv mod
• Fuel tank press
• Fuel tank pressure transducer sensor (left rear of vehicle, on fuel tank)
• Fuse 10a
• Fuse 15a
• Fuse 5a
• G102 (on right front of engine compt)
• Ground
• Heated positive crankcase ventilation (pcv) valve (on top right side of engine)
• Hot at all times
• Hot in run or acc
• Hot in run or start
• Hs can +
• Hs can -
• Mod program sig
• Pcm key-off relay diode
• Pcm power diode
• Pcm power relay 1
• Pcm pwr rly out
• Pcv heater
• Power steering pressure switch (left side of engine compt)
• Powertrain control module (right front of engine compt)
• Pwr steering sw
• Red
• Red/pnk
• Ref vol
• Ref voltage
• Rx sig
• S100
• S113
• S114
• S115
• S116
• S212
• Sens 1
• Sens 2
• Sens 3
• Sens rtn
• Sens vref
• Sig rtn
• Sig trn
• Smart junction box (sjb) (at right kick panel)
• Spd ctrl sw rtn
• Spd ctrl sw sig
• Starter rly ctrl
• Starter rly feed
• Starting/ charging system
• Starting/charging system
• Tan/red
• To pcm power relay 2 (diagram 2 of 5)
• Tx sig
• Volt sply all time

4.0L, Engine Performance Wiring Diagram (2 of 5) for Ford Mustang 2006

List of elements for 4.0L, Engine Performance Wiring Diagram (2 of 5) for Ford Mustang 2006:

• (at left kick panel)
• (right side of radiator support) g100
• A/c clt rly ctrl
• A/c clutch
• Air conditioning system
• Auxiliary relay box 1 (behind left side of dash)
• Bat
• Brake pedal position switch (on brake pedal support)
• Bussed electrical center (bec) (right front of engine compt)
• C1035a b6 red
• C1035a c12
• C1035b f6 red
• C175e
• C5 red
• Cooling fans system
• Ect sen sig
• Evap can vnt vlv
• Fp ctrl
• Fp monitor
• Fp power
• Fp rtn
• From pcm power diode (diagram 1 of 5)
• Fuel pump driver module (underside of luggage compt)
• Fuel pump relay
• Fuel rail temp sig
• Fuel tank unit (left rear of vehicle, in fuel tank)
• Fuse 15a
• G400 (at left rear of luggage compt)
• Gen com
• Gnd
• Hi spd eng fan rly
• Hot at all times
• Ign coil 1/cop 1
• Ign coil 2/cop 7
• Ign coil 3/cop 3
• Ignition transformer capacitor (on left cylinder head)
• Inertia fuel shutoff (ifs) switch
• Instrument cluster system
• Lo spd eng fan rly
• Nca
• Pcm key-off relay
• Pcm power relay
• Powertrain control module (right front of engine compt)
• Red
• S104 (in engine control sensor harness, at top rear of engine)
• S112
• S120 (right front of engine compt)
• S407
• Shield
• Starting/ charging system
• Tan/red
• Transmission shift selector

4.0L, Engine Performance Wiring Diagram (3 of 5) for Ford Mustang 2006

List of elements for 4.0L, Engine Performance Wiring Diagram (3 of 5) for Ford Mustang 2006:

• (in engine control sensor harness, 0n top of engine)
• (left front of engine compt) a/c pressure transducer sensor
• (on left rear side of transmission) output shaft speed (oss) sensor
• (on right front of engine compt) g102
• (on throttle body assembly)
• (on top front of engine)
• (to rear of engine) ignition coil
• (top left side of transmission) intermediate shaft speed (iss) sensor
• (top left side of transmission) turbine shaft speed (tss) sensor
• Anti-lock brakes system
• Bussed electrical center (bec) (right front of engine compt)
• C1035a
• C1035b
• Crankshaft position sensor (on center front of engine, below right side of water pump)
• Electronic throttle control (etc) motor (on top of engine)
• Engine coolant temperature (ect) sensor
• Fuel rail pressure transducer sensor (on fuel rail, on top of engine)
• Knock sensor (on top of engine)
• Nca
• Pressure sn
• Red
• Red/pnk
• S103
• Sig rtn
• Spark plugs
• Tan/red
• Temp sn
• Throttle position sensor (tps)
• Vref

4.0L, Engine Performance Wiring Diagram (4 of 5) for Ford Mustang 2006

List of elements for 4.0L, Engine Performance Wiring Diagram (4 of 5) for Ford Mustang 2006:

• (m/t: in engine control sensor harness, on top of transmission)
• (on left side of transmission) digital transmission range (dtr) sensor
• A/t
• Automatic transmission
• C175t
• Deacti- vator switch (on clutch pedal support)
• Dtr sens tr1
• Dtr sens tr2
• Dtr sens tr3a
• Dtr sens tr4
• G400 (at left rear of luggage compt)
• Ho2s 12 ctrl
• Ho2s 12 sig
• Ho2s 22 ctrl
• Ho2s 22 sig
• Iss sens sig
• Oss sens sig
• Pca sol a ctrl
• Pcb sol b ctrl
• Pcc sol c ctrl
• Powertrain control module (right front of engine compt)
• Red
• Red/pnk
• Reverse lmp sw
• Reversing lamps switch (m/t) (left side of trans- mission)
• S106
• S408
• Shift sol a ctrl
• Shift sol b ctrl
• Shift sol c ctrl
• Shift sol d ctrl
• Sig rtn
• Spd ctrl deact sw
• Tcc sol ctrl
• Tft sens sig
• Trans od cancel
• Tss sens sig

4.0L, Engine Performance Wiring Diagram (5 of 5) for Ford Mustang 2006

List of elements for 4.0L, Engine Performance Wiring Diagram (5 of 5) for Ford Mustang 2006:

• 357
• (in engine control sensor harness, at rear of engine) s107
• (in engine control sensor harness, near breakout to egr system module)
• (on right front of engine compt) g102
• A/t
• Brk ped pos sw
• C175e
• Camshaft position sensor (on left side of engine)
• Ckp pos sens +
• Ckp pos sens -
• Cmp pos sens
• Dpfe
• Dpfe sens sig
• Egr sys mod in
• Egr system module (top center of engine)
• Etc mntr +/-
• Etc motor +/_
• Evr ctrl
• Evr-
• Fuel inj 1 ctrl
• Fuel inj 2 ctrl
• Fuel inj 3 ctrl
• Fuel inj 4 ctrl
• Fuel inj 5 ctrl
• Fuel inj 6 ctrl
• Fuel injectors (1, 2, 3: right side of engine) (4, 5, 6: left side of engine)
• Fuel rail press
• Gnd
• Heated oxygen sensor (ho2s) 11 (in exhaust manifold, above flange on inboard side)
• Heated oxygen sensor (ho2s) 12 (in right rear exhaust, rear of catalytic converter)
• Heated oxygen sensor (ho2s) 21 (in exhaust manifold, above flange on inboard side)
• Heated oxygen sensor (ho2s) 22 (lower left rear of engine, in exhaust manifold)
• Ho2s 11 ctrl
• Ho2s 11 sig
• Ho2s 21 ctrl
• Ho2s 21 sig
• Intake air temp
• Knock sens 1 +
• Knock sens 1 -
• M/t
• Maf sig
• Maf sig trn
• Map
• Mass air flow (maf) sensor (on right side of engine compt, on air cleaner assembly)
• Powertrain control module (right front of engine compt)
• Red
• Red/pnk
• Ref volt
• S101
• S102
• Sig rtn
• Tan
• Tps ref volt
• Tps sig 1
• Tps sig 2
• Vpwr
• Vsupp

4.6L

4.6L, Engine Performance Wiring Diagram (1 of 6) for Ford Mustang 2006

List of elements for 4.6L, Engine Performance Wiring Diagram (1 of 6) for Ford Mustang 2006:

• (left rear of engine compt)
• (left side of engine compt)
• (on right front of engine compt) g103
• 57o
• Ac v8
• Accel ped pos 1
• Accel ped pos 2
• Accel ped pos 3
• Accelerator pedal position sensor (below left side of dash)
• Acp v6
• Aid bag mntr
• Air conditioning system
• Anti- theft system
• Anti-lock brakes system
• Auxiliary relay box 1 (behind left side of dash)
• Brk ped pos sw
• Bussed electrical center (bec) (right front of engine compt)
• C175b
• Cruise control system
• Data link connector (dlc) (behind dash, left of steering column)
• Drv pmp fuel mntr
• Evap can vnt vlv
• Evap canister purge valve (on left rear of engine compt)
• Evap canister vent control solenoid (on left rear of vehicle)
• Exterior lights system
• Fuel pmp drv mod
• Fuel tank press
• Fuel tank pressure transducer sensor (left rear of vehicle, on fuel tank)
• Fuse 10a
• Fuse 15a
• Fuse 5a
• G102 (on right front of engine compt)
• G203 (at right "a" pillar)
• Ground
• Heated positive crankcase ventilation (pcv) valve
• Hot at all times
• Hot in run or acc
• Hot in run or start
• Hs can +
• Hs can -
• Mod program sig
• Pcm key-off relay diode
• Pcm power diode
• Pcm power relay 1
• Pcm pwr rly out
• Powertrain control module (right front of engine compt)
• Red
• Red/pnk
• Ref vol
• Ref voltage
• Rx sig
• S113
• S114
• S115
• S212
• Sens 1
• Sens 2
• Sens 3
• Sens rtn
• Sens vref
• Sig rtn
• Sig trn
• Smart junction box (sjb) (at right kick panel)
• Spd ctrl sw rtn
• Spd ctrl sw sig
• Starter rly ctrl
• Starter rly feed
• Starting/ charging system
• Starting/charging system
• Tan/red
• To pcm power relay 2 (diagram 2 of 5)
• Tx sig
• Volt sply all time

4.6L, Engine Performance Wiring Diagram (2 of 6) for Ford Mustang 2006

List of elements for 4.6L, Engine Performance Wiring Diagram (2 of 6) for Ford Mustang 2006:

• (at left kick panel)
• (right side of radiator support) g100
• A/c clt rly ctrl
• A/c clutch
• Air conditioning system
• Auxiliary relay box 1 (behind left side of dash)
• Bat
• Brake pedal position switch (on brake pedal support)
• Bussed electrical center (bec) (right front of engine compt)
• C1035a b6 red
• C1035a c12
• C1035b
• C1035b f6 red
• C175e
• C5 red
• Coil on plug 1 ctrl
• Coil on plug 2 ctrl
• Coil on plug 3 ctrl
• Coil on plug 4 ctrl
• Coil on plug 5 ctrl
• Coil on plug 6 ctrl
• Coil on plug 7 ctrl
• Coil on plug 8 ctrl
• Cooling fans system
• Evap can pur vlv
• Fp ctrl
• Fp monitor
• Fp power
• Fp rtn
• From pcm power diode (diagram 1 of 5)
• Fuel pump driver module (underside of luggage compt)
• Fuel pump relay
• Fuel rail temp sig
• Fuel tank unit (left rear of vehicle, in fuel tank)
• Fuse 15a
• G400 (left rear of luggage compt)
• Gen com
• Gnd
• Hi spd eng fan rly
• Hot at all times
• Inertia fuel shutoff (ifs) switch
• Instrument cluster system
• Lo spd eng fan rly
• Nca
• Pcm key-off relay
• Pcm power relay
• Powertrain control module (right front of engine compt)
• Red
• S112
• S120 (right front of engine compt)
• S407
• Shield
• Starting/ charging system
• Transmission shift selector

4.6L, Engine Performance Wiring Diagram (3 of 6) for Ford Mustang 2006

List of elements for 4.6L, Engine Performance Wiring Diagram (3 of 6) for Ford Mustang 2006:

• (on left rear side of transmission) output shaft speed (oss) sensor
• (on right front of engine compt) g102
• (on throttle body assembly)
• (top left side of transmission) intermediate shaft speed (iss) sensor
• (top left side of transmission) turbine shaft speed (tss) sensor
• Anti-lock brakes system
• Bussed electrical center (bec) (right front of eng compt)
• C1035a
• C1035b
• Crankshaft position sensor (on center front of engine, below right side of water pump)
• Electronic throttle control (etc) motor (on throttle body)
• Fuel rail pressure transducer sensor (on top left side of engine)
• Nca
• Pressure sn
• Red
• Red/pnk
• Sig rtn
• Temp sn
• Throttle position sensor (tps)
• Vref

4.6L, Engine Performance Wiring Diagram (4 of 6) for Ford Mustang 2006

List of elements for 4.6L, Engine Performance Wiring Diagram (4 of 6) for Ford Mustang 2006:

• (on left side of transmission) digital transmission range (dtr) sensor
• A/t
• Automatic transmission
• C175t
• Deacti- vator switch (on clutch pedal support)
• Dtr sens tr2
• Dtr sens tr3a
• Dtr sens tr4
• G400 (left rear of luggage compt)
• Ho2s 12 ctrl
• Ho2s 12 sig
• Ho2s 22 ctrl
• Ho2s 22 sig
• Iss sens sig
• Oss sens sig
• Pca sol a crtl
• Pcb sol b crtl
• Pcc sol c ctrl
• Powertrain control module (right front of eng compt)
• Red
• Red/pnk
• Reverse lmp sw
• Reversing lamps switch (m/t) (left side of trans- mission)
• S102
• S408
• Shift sol a ctrl
• Shift sol b ctrl
• Shift sol c ctrl
• Shift sol d ctrl
• Sig rtn
• Spd ctrl deact sw
• Tcc sol ctrl
• Tft sens sig
• Trans od cancel
• Tss sens sig

4.6L, Engine Performance Wiring Diagram (5 of 6) for Ford Mustang 2006

List of elements for 4.6L, Engine Performance Wiring Diagram (5 of 6) for Ford Mustang 2006:

• (at right rear of engine compt) inlet manifold runner control (imrc) module
• (front of left cylinder head) variable valve timing solenoid 2
• (front of right cylinder head) variable valve timing solenoid 1
• (in engine control sensor harness, left front of engine) s104
• (on left front of engine) camshaft position sensor 2
• (on right front of engine compt) g102
• (rear of right cylinder head) knock sensor
• (rear right side of oil pan) engine oil temperature (eot) sensor
• (right rear of engine) cylinder head temperature sensor
• Coil on plugs
• Ignition transformer capacitor 1 (on right front of engine)
• Ignition transformer capacitor 2 (on left front of engine)
• Nca
• Red
• Red/pnk
• S119 (in engine control sensor harness, at top right side of engine)

4.6L, Engine Performance Wiring Diagram (6 of 6) for Ford Mustang 2006

List of elements for 4.6L, Engine Performance Wiring Diagram (6 of 6) for Ford Mustang 2006:

• 357
• (in engine control sensor harness, at rear of engine)
• (in engine control sensor harness, at top right side of engine) s107
• (on right front of engine compt) g102
• A/t
• Brk ped pos sw
• C175e
• Camshaft position sensor 1 (on right front of engine)
• Ckp pos sens +
• Ckp pos sens -
• Cmp pos sens 1
• Cmp pos sens 2
• Cyl head temp sens
• Eot sig
• Etc motor +/-
• Etc motor +/_
• Fuel inj 1 ctrl
• Fuel inj 2 ctrl
• Fuel inj 3 ctrl
• Fuel inj 4 ctrl
• Fuel inj 5 ctrl
• Fuel inj 6 ctrl
• Fuel inj 7 ctrl
• Fuel inj 8 ctrl
• Fuel injectors (1, 2, 3: right side of engine) (4, 5, 6: left side of engine)
• Fuel rail press
• Heated oxygen sensor (ho2s) 11 (in exhaust manifold, above flange on inboard side)
• Heated oxygen sensor (ho2s) 12 (in right rear exhaust, rear of catalytic converter)
• Heated oxygen sensor (ho2s) 21 (in exhaust manifold, above flange on inboard side)
• Heated oxygen sensor (ho2s) 22 (lower left rear of engine, in exhaust manifold)
• Ho2s 11 ctrl
• Ho2s 11 sig
• Ho2s 21 ctrl
• Ho2s 21 sig
• Imtv ctrl
• Imtv mntr
• Intake air temp
• Knock sens 1 +
• Knock sens 1 -
• Knock sens 2 +
• Knock sens 2 -
• M/t
• Maf sig
• Maf sig rtn
• Mass air flow (maf) sensor (on air cleaner assembly)
• Powertrain control module (right front of engine compt)
• Red
• Red/pnk
• Ref volt
• S101 (in engine control sensor harness, at top right side of engine)
• S106
• S109 (in engine control sensor harness, at top rear of engine)
• Sig rtn
• Tan
• Tan/red
• Tps ref volt
• Tps sig 1
• Tps sig 2
• Var vlv timing 1
• Var vlv timing 2