ENGINE PERFORMANCE – Ford Aerostar 1995 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

3.0L

3.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995:

• (not used)
• 3-4/4-3 shift solenoid
• A4ld automatic transmission
• Accs
• Air conditioning
• Air conditioning system
• Boo
• Brake on/off switch (behind steering column)
• C256
• Canp
• Coil output
• Cse gnd
• Data (+)
• Data (-)
• Data link connector (right rear corner of engine compartment)
• Distributor
• Ect
• Engine compartment relay box
• Fpm
• Fuse 15a
• Fuse panel
• G100 (front left fender apron, left of battery)
• G206 (behind center of i/p, below right side of radio)
• H2os
• Hot at all times
• Hot in start or run
• Iac
• Iat
• Idm
• Ign gnd
• Ign pwr
• Ignition coil
• Ignition control module (icm) (center of right fender apron, near air cleaner)
• Inj 1
• Inj 2
• Inj 3
• Inj 4
• Inj 5
• Inj 6
• Instrument cluster
• Kapwr
• Maf
• Maf rtn
• Nca
• Pcm power relay
• Pcm power relay diode
• Pip
• Pnk
• Pnp
• Power distribution system
• Powertrain control module (pcm) (top left side of safety wall, left side of brake master cylinder)
• Psom (+)
• Psom (-)
• Pwr gnd
• Radio noise capacitor (top left rear of engine, near ignition coil)
• Red
• Sig rtn
• Spout
• Spout check connector (left rear of engine compartment, tape to engine control sensor harness, near master cylinder)
• Ss 3/4
• Starting/ charging system
• Sti
• Sti connector (right rear corner of engine compartment)
• Sto/mil
• System
• Tan
• Tcc
• Torque converter clutch solenoid
• Vpwr
• Vref
• Wac

3.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995:

• (behind center of i/p, below left side of battery)
• C251
• Canister purge solenoid (top left side of engine, below intake manifold)
• Cruise control system
• Engine compartment relay box
• Engine coolant temperature (ect) sensor (top center front of engine, above water pump pulley)
• Fuel injectors
• Fuel pump relay
• Fuel pump/ fuel gauge sender (below rear of vehicle, top of fuel tank)
• Fuse 18 15a
• Fuse 5 15a
• Fuse panel
• G117 (right rear of engine, near oil pressure switch)
• G206
• Heated oxygen sensor (ho2s) (lower left rear of engine, on exhaust manifold)
• Hot at all times
• Hot in run
• Hot in run or start
• Idle air control valve (top left front of engine, left side of air air intake assembly)
• Inertia fuel shut-off switch (opens on impact) (behind center of right cowl panel)
• Instrument cluster
• Intake air temperature (iat) sensor (top left side of engine, behind idle air control valve)
• Malfunction indicator
• Mass air flow sensor (right rear of engine compartment, on air intake assembly)
• Nca
• Psom module
• Red
• Tan
• Throttle position (tp) sensor (top center front of engine, on throttle body)

4.0L

4.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995

List of elements for 4.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995:

• (not used)
• 3-4/4-3 shift solenoid
• A4ld automatic transmission
• Accs
• Air conditioning system
• Boo
• Brake on/off switch (behind steering column)
• C198
• C199
• Canp
• Ckp (+)
• Ckp (-)
• Coil 1
• Coil 2
• Coil 3
• Cpp m/t-pnp a/t
• Crankshaft position sensor (lower right front of engine compartment)
• Cse gnd
• Data (+)
• Data (-)
• Data link connector (left rear of engine compartment on safety wall)
• Diode
• Ect
• Engine compartment relay box
• Fpm
• Fuse 1 15a
• Fuse panel
• G100 (front left fender apron, left of battery)
• G206 (behind center of i/p, below right side of radio)
• Ground
• Ho2s
• Ho2s gnd
• Hot at all times
• Hot start or run
• Iac
• Iat
• Idm
• Ign gnd
• Ign pwr
• Ignition coil (right side of valve cover)
• Ignition control module (center of right fender apron near air cleaner)
• Inj bank 1
• Inj bank 2
• Instrument cluster
• Kapwr
• Maf
• Maf rtn
• Nca
• Oct adj
• Octane adjust plug (top left rear of engine compt)
• Pcm power relay
• Pip
• Pnk
• Powertrain control module (left side of brake master cylinder)
• Psom (+)
• Psom (-)
• Pwr gnd
• Radio noise capacitor (near ignition coil)
• Red
• Shield
• Sig rtn
• Spark plugs
• Speed output
• Spout
• Spout check connector (near master cylinder)
• Ss3/4
• Starting charging system
• Sti
• Sti connector (left rear of engine compt on safety wall)
• Sto/mil
• Tan
• Tcc
• Torque converter clutch solenoid
• Vpwr
• Vref
• Wac

4.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995

List of elements for 4.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995:

• Canister purge solenoid (left side of engine near throttle body)
• Engine compartment relay box
• Engine coolant temperature sensor (top left front of engine)
• Fuel injectors
• Fuel pump relay
• Fuel pump/ fuel gauge sender (top of fuel tank)
• Fuse 5 15a
• Fuse panel
• G206 (behind center of i/p, below left side of radio)
• Heated oxygen sensor (lower right rear of engine, on exhaust manifold)
• Hot in run
• Idle air control valve (left side of air intake assembly)
• Inertia fuel shut-off switch (behind center of right cowl panel)
• Instrument cluster
• Intake air temperature sensor (top left side of engine)
• Malfunction indicator lamp
• Mass air flow sensor (right rear of engine compt, on air intake assembly)
• Nca
• Red
• Tan
• Throttle position sensor (attached to throttle body)